Advent DODGE 2011 Owner's manual

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 1 of 15

128-9070

Document 128-9070 Created 2/29/12

System overview: The Dual Player Headrest Video utilizes a common power source for two

independent top-loading DVD players with 2-way audio-video sourcing. Each player has external

audio/video input, a wireless infrared 2-channel headphone and wireless remote. The left player has

audio playback capability through vehicle audio system via an OSD controlled FM transmitter.

TABLE OF CONTENTS PAGE#

Kit contents 2

Pre-installation precaution 3

Battery disconnect 3

Disassemble vehicle trim 3

Install power wiring 6

Mount control box and route cables 6

Install monitor assembly 7

Headrest cable connections 10

Reassemble trim 10

Complete installation 10

Functional verification 12

Troubleshooting 12

Wiring Diagram 15

If technical support is required, please contact Advent Technical Support at 1-800-323-4815.

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 2 of 15

128-9070

Document 128-90707 Created 2/29/12

Kit Contents:

Item # Qty. Component Description

1 2

Headrest Assembly

2 1 IN9000 Pre-Pack

1 Power Cord#9

1 Power Cord#8

1 Standard Hardware Bag

4 AAA Battery

1 Cable 3A Red

1 Cable 3B Black

4 Cable clamps w Foam

1 Control Box

3 1 IN9010 Pre-Pack

2 FF Headphone w/Logo

2 Remote Control

4 AAA Battery

1 SL Owner’s Manual

4 1 IN3056-59 Pre Pack

2 Cap LH Mercedes-Chrysler 14mm H103

2 Cap RH Mercedes-Chrysler 14mm H103

5

1

IN3065 Pre-Pack

4 Spacers 306091a2

Hardware Bag Contents:

Item # Qty. Component Description

1 3 Wire Tie Base

2 2 Blue T-Taps

3 2 Double Sided Tape

4 3 Red T-Taps

5 12 6” Wire Tie

6 2 11” Wire Tie

7 1 Foam Tape

Additional Items Required For Installation:

Item # Qty. Component Description

1

Recommended Tools:

Safety Tools

Seat/Floor Covers Blankets

Installation Tools

Wire Cutters

Pliers

NRT (Nylon Removal Tool)

Special Tools

None

Special Chemicals

None

Color Applicability/ Trim Level:

Vehicle Trim Color

Accessory

Color

077100

Black

077101

M. Graystone

077102

Tan

077103

Lt. Frost

00000

Black X

M. Graystone X

Tan X

Lt. Frost X

General Applicability:

LEGEND:

STOP:

Damage to the vehicle may occur. Do not

proceed until process has been complied with.

OPERATOR SAFETY:

Use caution to avoid risk of

injury.

CRITICAL PROCESS:

Proceed with caution to ensure

a quality installation. These points will be audited on a

completed vehicle installation.

TOOLS & EQUIPMENT: This calls out the specific

tools and equipment required for this process.

REVISION MARK:

This mark highlights a change in

installation with respect to previous issue.

INSTRUCTION/ INSTALLATION NOTES:

 After Safety mandated preparatory steps have been taken,

the installation sequence is the suggested method for

completing the accessory installation.

 When prying panels, use masking tape on all surfaces that a

tool may come in contact with to prevent marring.

 After a wire tie is fully fastened, cleanly cut excess wire tie

length with a pair of wire cutters.

 The wiring information is on an “as is” basis without any

representation or warranty. It is the installer’s responsibility

to verify any circuit before interfacing with it using a digital

multi-meter.

 Manufacturer’s service documents can be used for any

vehicle disassembly that may be depicted differently from

what the instruction states.

 Use Wiring Diagram on last page of document to clarify cable

or component names.

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 3 of 15

128-9070

A. Pre-Installation Precaution

1. Use Seat and Floor protectors to avoid damage

to surfaces.

BATTERY DICONNECT

Disconnecting the battery prior to any ground or harness

removal/ tapping to prevent possible vehicle damage is

recommended. The battery may be temporarily reconnected

and disconnected throughout the installation process to

perform various tasks. However prior to doing so all

connectors and harnesses must be reassembled and

reconnected. Once tasks are completed disconnect battery

until installation is complete and DVD system is ready to be

tested. After testing, the vehicles interior may be re-

assembled. If the vehicle is equipped with an Anti-theft radio,

the code must be written down prior to disconnecting the

battery cable. The code must be re-entered when the negative

battery cable is re-installed. Disconnecting the battery may

cause certain vehicle settings to be lost. Manufacturer’s

recommendations for the battery removal should be followed.

B. Disassemble Vehicle Trim

1. With a Nylon Removal tool (NRT) slide chrome

cap at the bottom of the gear shift knob in a

downward motion (Figure B1a-b)

2. Engage parking brake and put gear shifter in

neutral, remove metal keeper then remove shifter

knob. (Figure B2a-b)

3. Lift up on rear edge of console panel.

(Figure B3)

Figure

B1a

Figure

B1b

Figure

B2a

Figure

B2b

Figure

B3

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 4 of 15

128-9070

4. Unplug the shifter light connector at bottom of

cup holder. Disconnect power plug connector and

remove center console cover (Figure B4)

5. Remove driver side console panel by pulling out

at bottom with hand. Repeat on passenger side

(Figure B5a-b)

6. Using your hand pull outward at bottom of seat

back cover to release lower seat back clips. (left

and right) (Figure B6a-b)

Figure

B4a

Figure

B4b

Figure

B5a

Figure

B5b

Figure

B6a

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 5 of 15

128-9070

7. While pulling out on top corner of seat back and

pushing in approximatly 4 inches from top, slide

cover to the left to release upper clip. Repeat on

left side of seat (Figure B7)

8. Disconnect SRS connector. (Figure B8)

9. Insert Scribe into hole on right side of Headrest

post cap to release safty lock and push button on

left post cap to release Headrest. ( Figure B9)

10. Remove Cargo compartment cover.

(Figure B10)

11. Repeat on driver seat.

Figure

B6b

Figure

B7

Figure

B8

Figure

B9

Figure

B10

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 6 of 15

128-9070

C. Install Power Wiring

REMINDER: Disconnect the battery prior to any ground

or harness removal/ tapping to prevent possible vehicle

damage. Once all wiring installation is complete the

battery can be reconnected. If the vehicle is equipped

with an Anti-theft radio, the radio code must be written

down prior to disconnecting the battery cable. The code

must be re-entered when the negative battery cable is

re-installed. Disconnecting the battery may cause

certain vehicle settings to be lost. Manufacturer’s

recommendations for the battery removal should be

followed. Disconnecting the battery is recommended.

Temporarily battery connection may be required at

some points.

1. Using pliers attach a red T-Tap to the

Blue/Violet wire of the accessory power socket

harness and a red t-tap to the black wire of the

same harness.(Figure C1)

2. Make the following connections. (Figure C2)

DVD System Power

Harness

22 Pin Connector Pin #

Red Wire Blue/Violet Wire

Black Wire Black Wire

3. Secure the power harness fuse assembly to the

factory harness with wire ties. (Figure C3)

D. Mount Control Box and Route Cables

1. Make all six connections to the control box

using color coded connections including 3A-B

cables (red, white, blue, and black) antennae and

power harnesses. (Figure D1)

2. Wrap the control box in the supplied foam tape.

(Figure D2)

Figure

C1

Figure

C2

Figure

C3

Figure

D1

Figure

D2

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 7 of 15

128-9070

3. Place the control box inside the center console

cavity as shown. (Figure D3)

4. Continue to route cables along the side of

center console and under carpet. Then route cable

to split in carpet and route under the seat rail

protruding out under the seat. (Figure D4 a-c)

E. Install Monitor Assembly

1. Using a NRT (Nylon Removal Tool), push seat

cover and foam of driver’s seat away from

headrest sleeve creating a gap to route cables

#1A and #2A (red and white) (Figure E1)

Figure

D3

Figure

D4a

Figure

D4b

Figure

D4c

Figure

E1

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 8 of 15

128-9070

2. Continue to feed cables into seat. Attach

monitor/ bracket assembly by sliding bracket

around headrest sleeves from right to left.

(Figure E2a-b)

3. Install bracket spacers. (Figure E3a-b)

Figure

E2a

Figure

E2a

Figure

E2b

Figure

E3a

Figure

E3b

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 9 of 15

128-9070

4. Install bracket covers. (Figure E4)

5. Route cables toward bottom inboard side of

seat, exit at opening in seat frame. (Figure E5)

6. Continue to route cables to bottom side of seat

behind molding. Then transfer cables to lower seat

opening extending to underside of seat frame.

(Figure E6a-c)

7. Repeat steps 1-6 on driver seat.

Figure

E4

Figure

E5

Figure

E6a

Figure

E6b

Figure

E6c

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 10 of 15

128-9070

F. Headrest Cable Connections

1. Connect cables 1B and 2B to 3B then snap

security clamp around the connectors, add wire tie

for strain relief, and apply foam tape.

(Figure F1a-c)

2. Secure the cables to the factory harness under

the seat add enough slack to allow the seat move

freely. (Figure F2)

3. Repeat steps 1-2 on driver’s side using cables

1A, 2A, and 3A. (Figure F3)

G. Reassemble Trim

1. Trim all wire tie ends

2. Reassemble all trim removed in earlier sections.

3. Make sure all factory connections are

reconnected and secure.

H. Complete Installation

1. Make sure vehicles battery is connected to

manufacturer’s specifications.

2. Install (2) AAA batteries in each remote and

headphone set.

3. After testing with steps on following pages,

carefully re-assemble vehicle by reversing steps in

section B.

Figure

F1a

Figure

F1b

Figure

F1c

Figure

F2

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 11 of 15

128-9070

4. Check all previously disconnected factory

connectors and accessories to ensure they are all

connected and operational.

5. Store remotes, owner’s manual and

headphones in center console, glove box, or seat

back pockets.

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 12 of 15

128-9070

Functional Verification:

Check:

Accessory Function checks:

Turn vehicle ignition to ON, depress power

button on each headrest monitor.

Insert DVD into monitor, press enter.

Listen with wireless headphones (be sure

to set to channel “A” to listen to monitor “A”

and channel “B” to listen to monitor “B”).

Depress “eject” button.

Select Sound Around button on remote to

turn on the FM transmitter. Turn on vehicle

radio and set station to station selected on

FM transmitter.

Look For:

Monitor should power on, start up screen should

appear onscreen.

DVD should begin playing

Audio should be heard through vehicle

headphones.

Disc should eject.

Audio from monitor “A” should be heard through

vehicle speakers.

Video Entertainment System Troubleshooting Hints

Schematic Reference: Video System Schematics

•Many conditions that affect video system operation may be corrected without removing the DVD

Headrest Assembly or the DVD Control Box Assembly. Make sure to understand all features of

system operation before beginning the diagnosis of the system. Verify the condition and follow the

diagnostic procedures in order to isolate and correct the condition.

•Be sure the vehicle battery is fully charged before beginning video entertainment system diagnosis

Video or Audio Distortion

The manufacturing process for producing DVD’s does not have the same quality control processes in

place that compact disk manufacturing does. If there are video or audio quality problems with an

individual DVD, try playing that disk in another DVD player. If the quality is poor for both players,

return the disk to the place of purchase and request an exchange. If the quality problem is only seen

in one of the players, examine the disk for scratches, dirt, or smudges and attempt to clean the disk

with one of the disk cleaning systems that are commercially available.

Video or audio distortion during auxiliary playback can often be attributed to the DC to AC inverter

that is used to power the auxiliary device. The power inverters tend to introduce noisy signals into the

vehicle electrical system.

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 13 of 15

128-9070

DVD Player Inoperative (Power LED Not Illuminated)

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. The ignition is not turned on. Turn the ignition on.

2. DVD Jumper Harness not connected to vehicle. Verify Accessory Power and Ground.

3. DVD Jumper Harness not connected to Power Cord #9.Verify Accessory Power and Ground.

4. Cable 1A (Red Cable) not connected to Cable 3A (if not receiving power to Monitor A – Driver

Side) or Cable 1B (Black Cable) not connected to Cable 3B (if not receiving power to Monitor B –

Passenger Side). Make sure cables are connected.

5. Cable 3A (if not receiving power to Monitor A – Driver Side) not connected to Control Box or Cable

3B (if not receiving power to Monitor B – Passenger Side) not connected to Control Box. Make sure

cables are connected.

6. Power Cord #9 is not connected to Control Box.

7. Check for power at end of Power Cord #9 (white connector3-way) at Control Box. If power at

Control Box – Replace the Control Box.

8. Remove monitor that is not receiving power. Check power at Red Connector (Monitor A – Driver

Side) or power at Black Connector (Monitor B – Passenger Side). If power and ground verified at

connectors, replace the DVD Electronics (Monitor).

DVD Player Inoperative (Power LED Illuminated)

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. The DVD Player is not turned on. Press the Power Button to turn unit on.

2. Press the play button. If no disc in unit, NO DISC message appears on display.

3. Insert Disc. If unit does not accept disc, replace the DVD Electronics (Monitor).

DVD Display Inoperative (LEDs Illuminate but No Video)

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. Verify that the correct source is selected. Monitor A or Monitor B should appear in the upper right

hand corner of display.

2. Cable 2A (White Cable) not connected to Cable 3A (if no display on Monitor A – Driver Side) or

Cable 2B (Blue Cable) not connected to Cable 3B (if no display on Monitor B –Passenger Side).

Make sure cables are connected.

3. Cable 3A (if not receiving power to Monitor A – Driver Side) not connected to Control Box or Cable

3B (if not receiving power to Monitor B – Passenger Side) not connected to Control Box.

4. Remove monitor that is not receiving video. Verify that connectors are connected to the Monitor. If

no video displayed, replace the DVD Electronics (Monitor).

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 14 of 15

128-9070

Cannot Hear Audio Through Vehicle Speakers(FM Transmitter Inoperative)

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. FM Transmitter not turned on. Turn on FM Transmitter using the Remote Control. Press the DVD

Button (A) on the Remote Control to control Monitor A – Driver Side Headrest. Press the Sound

Around On/Off Button. “CH On” should appear on Monitor A display.

2. Radio and DVD Unit are not set to the same FM Frequency. Press the Sound Around Select button

to select a frequency (88.3 MHz, 88.7 MHz, 89.1 MHz, 89.5 MHz, 89.9 MHz, or90.3 MHz). The

frequency should appear on Monitor A display in upper right hand corner. Tune the Radio to the

frequency selected. If no DVD audio over speakers, verify audio by selecting another radio frequency.

Replace the DVD Control Box.

Video Entertainment System Wireless Headphone Inoperative

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. Volume control on the wireless headphone set is turned all the way down. Adjust the volume

control on the headphones.

2. Incorrect Channel Selected. To hear audio from Monitor A– Driver Side select Channel A. To hear

audio from Monitor B – Passenger Side select Channel B.

3. Dead batteries or batteries placed incorrectly in the wireless headphone set. Turn on power to the

headphone set. If the headset indicator does not turn on; place batteries in correctly or replace the

batteries in the headset as needed.

4. Make sure headphone is in line of sight and no obstructions of the Monitor being listened from.

5. Faulty headphone set. Test the operation of the system using a known good headphone set. If

operation is OK, replace the faulty headphone set.

6. Inoperative infrared transmitter in the (DVD) Monitor (s)--Replace the DVD Electronics.

Video Entertainment System Remote Control Inoperative

The buttons on the video remote control do not operate the videodisc player but the buttons on the

DVD Headrest Monitor Control Panel operate normally.

Important: The following information lists the most probable cause of the concern to the least

probable cause followed by the appropriate test for that condition.

1. Press DVD A button to control Monitor A or press DVD B button to control Monitor B.

2. Dead batteries or batteries placed incorrectly in the video remote control. Place batteries in

correctly or replace the dead batteries as needed.

3. Faulty remote control. Test the operation of the system using a known good remote control. If

operation is OK, replace the faulty remote control.

4. Inoperative infrared transmitter in the (DVD) Monitor (s)--Replace the DVD Electronics.

If problem persists contact INVSION AUTOMOTIVE Technical Assistance at 1-866-869-7888

DODGE / DURANGO / 2011-12 ADVENT DUAL PLAYER HEADREST VIDEO

Page 15 of 15

128-9070

Wiring Diagram

Advent DODGE 2011 Owner's manual

This manual is also suitable for

Advent DODGE 2011 Owner's manual

Related papers

Other documents