CAUTION
BEFORE
rolling this portable volleyball system onto any floor, check with the flooring
manufacturer to ensure the finished floor will not be damaged due to the weight of this unit.
Each portable can weigh as much as 1,300 pounds.
NET HEIGHT SETTINGS
READ THESE ASSEMBLY AND OPERATING INSTRUCTIONS IN THEIR ENTIRETY, BEFORE
ATTEMPTING TO UNPACK, OR OPERATE THESE PORTABLES, TO AVOID POSSIBLE INJURIES,
OR DAMAGE TO THE EQUIPMENT.
INNER VOLLEYBALL UPRIGHTS ARE UNIVERSALLY ADJUSTABLE
www.porterathletic.com
Copyright
2020 by Porter Athletic.
All rights reserved.
888-277-7778
2/27/2020
INST1935
Page 1 of 5
1935 - POWR-COURT VOLLEYBALL SYSTEM
INST1935
#12 SCREW
SET SCREWS
Attach clamps to winch
Tighten 2 set screws
42"
Tie-Off Sleeve
42"
Winch
SET SCREW
(HDWE09015000)
Portable will
raise off the
front feet
2. Slide the tie-off sleeve (SLVE00038001) onto the pole from the bottom.
Secure the tie-off sleeve as shown 42" from the floor.
3. Attach the winch (WINH00113) 42" from the floor using the instructions provided in the winch box
4. Place assembled poles in the bases. Rotate until the winch
and tie-off sleeves are oriented in line with the pulley. Secure
the poles to the bases with set screws.
1. Unpack and confirm all parts are included. The base will ship fully assembled. The poles and pads will
need to be assembled.
www.porterathletic.com
Copyright
2020 by Porter Athletic.
All rights reserved.
888-277-7778
2/27/2020
INST1935
Page 2 of 5
1935 - POWR-COURT VOLLEYBALL SYSTEM
INST1935
Top Pad
Front Pad
Middle Pad
Back Pad
Top Pad
Pole Pad
5. Set the Top Pad onto the base as shown. This will set
the height of the Front Pad.
Using the peel and stick Velcro, attach the Front Pad
starting in the middle, then moving to the two sides.
6. Attach the Middle Pad and Back Pad using the peel
and stick Velcro. Start with the middle, then attach the
two sides.
7. Attach the Top Pad with peel and stick Velcro. Finish pad installation by
attaching the Pole Pad.
Confirm all pads are securely fastened.
These faces must be at the same height
www.porterathletic.com
Copyright
2020 by Porter Athletic.
All rights reserved.
888-277-7778
2/27/2020
INST1935
Page 3 of 5
1935 - POWR-COURT VOLLEYBALL SYSTEM
INST1935
FLAT SURFACES FOR
HEIGHT LABELS
@ CENTER COURT
@ COURT LINE
(2.43m)
(2.45m)
8' 0-3/8"
7' 11-5/8"
BOY'S/MEN'S NET HEIGHTS
HEIGHT
LABELS
LINE UP BOTTOM OF
LABEL WITH TOP OF
OUTSIDE UPRIGHT
1'-0"
2'-0"
CRANK HANDLE
RAISES PORTABLE
FOR TRANSPORT
8. To move the portable from the play position to the transport position, use the crank assembly to
raise it off the floor.
9. With the portables in place on the court, attach the net using the instructions provided in the net box.
10. Adjust net to the desired height with the pressure-locking T-handle.
www.porterathletic.com
Copyright
2020 by Porter Athletic.
All rights reserved.
888-277-7778
2/27/2020
INST1935
Page 4 of 5
1935 - POWR-COURT VOLLEYBALL SYSTEM
INST1935
x
Inspect this equipment for wear, loose fittings, damage and proper stability before each use. Replace defective or worn
parts immediately. If in doubt, do not use this equipment until repaired. Check pressure-lock assembly for wear and to
ensure it is functioning properly.
x
Lubricate threaded studs on pressure-lock assembly and tension winch periodically (at least twice a year) to minimize
wear and to ensure proper operation.
GENERAL MAINTENANCE
x
Serious injuries, including permanent paralysis, can occur in volleyball. Such can be caused by falls on the head, neck
and other parts of the body, or by running into unpadded volleyball standards.
Approved upright padding is mandatory
. Keep
the pole pad pushed back to cover the crank handle.
x
While it cannot be eliminated, the risk of injuries can be greatly reduced by following proper safety guidelines and providing
proper maintenance and safety inspections.
x
A high degree of injury potential and severe liability problems exist when players or spectators are allowed to
hang, sit or stand on the portables. UNDER NO CIRCUMSTANCES SHOULD ANYONE STAND ON THE PORTABLES.
ONLY STAND ON THE REFEREE STAND.
x
THE OPERATION AND TRANSPORT OF THESE PORTABLES MUST BE DONE BY AUTHORIZED ADULTS ONLY.
x
IMPORTANT – UPON FINAL SET UP OF THIS UNIT, SHOW THE INDIVIDUALS WHO WILL OPERATE THIS UNIT HOW
TO PROPERLY OPERATE AND MOVE THIS UNIT AND READ THE WARNING LABELS TO THEM EXPLAINING THE
NECESSITY TO FOLLOW SAFE OPERATING PROCEDURES. THESE INSTRUCTIONS MUST BE GIVEN TO AN
OFFICIAL IN CHARGE OF THE FACILITY FOR FUTURE REFERENCE.
WARNING
x
Uprights are equipped with a spring counterbalance mechanism. Release the Pressure-Lock Assembly
ONLY WHEN
UPRIGHT IS IN THE VERTICAL PLAY POSITION
.
x
Do not over tighten the volleyball net, as damage to uprights may result and void all written or implied warranties.
x
Cable tension must be released before adjusting net height. Failure to do so may cause damage to the equipment, or
cause personal injury.
x
Never attempt to release the Pressure-Lock Assembly if the net is under tension.
x
When raising or low
ering the portables, stand to one side and keep all individuals clear. Keep hands and feet away from all pinch
or crush points. Do not raise the unit more than a few inches off the ground for transport. Use extreme caution when moving.
x
Never remove any ballast plates from the portables.
CAUTION
STORAGE
x
Under no circumstances should volleyball standards be stored in the transport position.
x
PREVENT THE USE OF THE PORTABLES BY UNAUTHORIZED INDIVIDUALS WHILE IN STORAGE.
WARNING
: Cancer and Reproductive Harm –
For more information go to www.p65warnings.ca.gov
!
F
www.porterathletic.com
Copyright
2020 by Porter Athletic.
All rights reserved.
888-277-7778
2/27/2020
INST1935
Page 5 of 5
1935 - POWR-COURT VOLLEYBALL SYSTEM
INST1935
/
