Sea Ray 2006 250 AMBERJACK Supplement Owner's manual

Owner’s Manual Part Number: MRP 1803649

This owner’s manual is arranged into two parts. Following is a description of each.

General Information

This section contains general information you need to know to safely operate

and maintain your boat.

Specific Information

This section contains information that is specific to your boat such as dimensions,

general arrangement, specific safety information, special features and the electrical

system.

If any of these sections are missing from this book contact your dealer.

Your dealer can find out when it will be available and order it for you.

Sea Ray

Owner’s

Manual

250 Amberjack

®

250 A

MBERJACK

®

Sea Ray

®

• Owner’s Manual Supplement 250 Amberjack

®

• MRP #1803649

Printed in the U.S.A., September 1999 Revised February 2002, May 2004, July 2005 ©Sea Ray Boats, Inc.

Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914.

For information call 1-800-SRBOATS. or fax 1-314-213-7878

Internet address: http://www.searay.com

Note: Not all accessories shown in pictures or described herein are standard equipment or even available as options.

Options and features are subject to change without notice.

O

WNER

’

S

M

ANUAL

S

PECIFIC

I

NFORMATION

2

250 Amberjack

®

3

250 Amberjack

®

If this is your first craft, or you are changing to a type of

craft you are not familiar with, for your own comforts

and safety, please ensure that you obtain handling and

operating experience before “assuming command” of

the craft. Your dealer or yacht club will be pleased to

advise you of local sea schools, or competent instructors.

PLEASE KEEP THIS OWNER'S MANUAL PACKET IN

A SECURE PLACE, AND HAND IT OVER TO THE NEW

OWNER WHEN YOU SELL THE CRAFT.

This owner's manual supplement has been written to

provide additional specific information about your boat

and should be read carefully. Keep this booklet with the

owner's manual in the owner's manual packet.

The owner's manual packet has been compiled to help

you to operate your craft with safety and pleasure. It

contains details of the craft, the equipment supplied or

fitted, its systems and information on its operation and

maintenance. Please read the information in it carefully,

and familiarize yourself with the craft before using it.

Information in this publication is based upon the latest product specifications available at printing. Sea Ray

®

Boats,

Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,

materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea

Ray

®

is not obligated to make similar changes or modifications to models sold prior to the date of such changes.

The following are registered trademarks of the Brunswick Corporation: Sea Ray

®

, The SR Wave Logo.

I NTRODUCTION & TABLE OF CONTENTS

Fuel System ............................................................ 14

Bilge Blower Installation ......................................... 15

Bilge Pumping Installation ....................................... 15

Manual Bilge Pump ................................................. 16

Steering System .................................................... 17

Fire Extinguishing System ..................................... 18

Fire Extinguisher Discharge Port .......................... 18

Engine Cooling System ......................................... 19

Anchoring Arrangement ........................................ 19

Location Of Through-Hull Fittings ......................... 20

Dash Layout ........................................................... 21

Canvas ................................................................... 22

Cabin & Cockpit Switch Location .......................... 23

Wiring Harness Installation .............................. 24-25

Wiring Schematics .............................................27-34

International Homologations ................................... 31

Life Saving Equipment (PFD) .................................... 4

Troubleshooting ........................................................ 4

Repair and Parts Facilities ........................................ 4

Docking / Lifting / Trailering ..................................... 4

Bow & Stern Eye / Cleat Location ............................. 5

General Arrrangements & Dimensions .......................

6

Interior Seating Plan ................................................. 6

Accommodation Plan ................................................ 7

Deck Occupancy Plan ................................................ 8

Accessory Locations .................................................. 9

Head System .......................................................... 10

Bilge Layout ............................................................ 11

Fresh Water Line Routing ....................................... 12

Drain Line Routing .................................................. 12

Electrical Installations ............................................. 13

Battery Cable Routing ............................................. 13

Battery Switch (Opt) ............................................... 13

(This book contains 36 pages.)

4

250 Amberjack

®

DOCKING/LIFTING/TRAILERING

CLEATS: Cleats must not be used for lifting

the boat, they are intended for mooring

use only.

BOW AND STERN EYES: The bow eye should be used

to haul the boat onto a trailer. The stern eyes should be

used as tie down points for trailering the boat. The

bow and stern eyes may be used for short term lifting

of the boat such as for service. Long term lifting with

the bow and stern eyes may cause stress on the

fiberglass and gel coat.

For long term storage use flat, wide belt-type slings

and spreaders long enough to keep pressure from

gunwales. Do not place slings where they may lift on

underwater fittings.

REFER TO THE ENGINE OWNER'S MANUAL IN THE

OWNER'S PACKET FOR INSTRUCTIONS AND

WARRANTY INFORMATION.

TROUBLESHOOTING

LIST OF REFERENCE MANUALS AND DRAWINGS

PERFORMANCE: Refer to the owner's manual.

ENGINE: Refer to the owner's manual and/or the engine

manual.

ELECTRICAL: Refer to electrical section of the owner's

manual and electrical schematics in this owner's manual

supplement. Only a qualified marine electrical technician

may service the boat's electrical system.

REPAIR AND PARTS FACILITIES

To find a Sea Ray

®

dealer in your area, call: Sea Ray

®

Customer Service: 1-800-SRBOATS

FAX: 1-314-213-7878

To find repair and parts facilities for equipment installed

on your boat, refer to the original equipment manuals

(OEM's) found in the owner's manual packet.

S UPPLEMENTAL GENERAL INFORMATION

LIFE SAVING EQUIPMENT

(PERSONAL FLOTATION DEVICE (PFD) )

STORAGE: The 250 AJ offers storage under the helm

seat, the back to back lounger seat, floor storage, and

cockpit side storage (port and stbd).

OPERATION: Wear PFD according to manufacturer

recommendations. See pamphlet Federal Requirements

And Safety Tips For Recreational Boats in the owner’s

packet or get one from your dealer.

MAINTENANCE: Rinse with fresh water and let dry

thoroughly. Do not store in a damp compartment. Avoid

the possibility of mildew.

5

250 Amberjack

®

STERN EYES (FIG. 5.2)

B

OW EYE (FIG. 5.1)

BOW CLEATS

BOW EYE

WINCH LINE

STERN

EYE

STERN EYE

CLEAT LOCATIONS

(FIG. 5.3)

6

250 Amberjack

®

(FIG. 6.2)

G ENERAL ARRANGEMENTS & DIMENSIONS

HEIGHT DIMENSIONS

PROFILE

(FIG. 6.1)

26’ 3” (8.00 m) Bow to Swim Platform

KEEL

WATERLINE

6’ 2”

(1.88 m)

8’ 0”

(2.44 m)

INTERIOR SEATING PLAN

250 AJ SEATING PLAN

(Port Adjustable Back-to-Back Lounger Seat & Storage Base, Aft Jump Seats (Forms Lounger Seat),

Starboard Helm Seat w/Flip-Up Thigh Rise Bolster & Storage Base

(FIG. 6.3)

8’ 6”

(2.59 m)

250 AJ SPECIFICATIONS

Overall Length ............................... 24’ 0” (7.32 m)

w/std. Swim Platform .................... 26’ 3” (8.00 m)

Beam .................................................... 8’ 6” (2.59 m)

Draft (stern drive down) ................ 3’ 3” (1.0 m)

Draft (stern drive up) ....................... 2’ 0” (0.6 m)

Dry Weight (lbs.) ................ 5,200 lbs (2,358 kg)

Fuel Capacity (gal) ................. 70 gal (265 liters)

Usable Fuel ...................... 66.5 gal (251.70 liters)

Water Capacity ............................ 11 gal (38 liters)

Dead Rise .................................................................. 1 9 °

Waterline To Top

Of Windshield ...................................... 6’2” (1.88 m)

Keel To Top Of

Windshield ........................................... 8’ 0” (2.44 m)

24’ 0” (7.32 m) Overall Length

7

250 Amberjack

®

ACCOMMODATION PLANS

MAIN DECK (FLOOR PLAN)

(FIG. 7.1)

PORT

STBD

FWD

ANCHOR STORAGE

W/HATCH

FUEL

FILL

COCKPIT

WASTE

PUMPOUT

PLATE

CABIN

DOOR

WATER

TANK

FILL

PLATE

CONTROL

STATION

HEAD &

VANITY

GALLEY

CONVERTIBLE

DINETTE

SLEEPER SOFA

PORTSIDE

ADJUSTABLE

BACK-TO-BACK

LOUNGER SEAT

AFT JUMP SEATS (FORMS

LOUNGER SEAT)

TRANSOM

DOOR

MID DECK (FLOOR PLAN)

(

FIG. 7.2)

STBD HELM SEAT

W/FLIP-UP THIGH

RISE/STORAGE

BASE

DECK

HATCH

COCKPIT

8

250 Amberjack

®

DECK OCCUPANCY PLAN

(FIG. 8.1)

ANCHOR

STORAGE

W/HATCH

CLEAT CLEAT

DECK

HATCH

PERSONAL INJURY HAZARD

When underway, keep passen-

gers clear of areas not designed

for riding. Especially hazardous

areas include seat backs, bow,

gunwale, transom platform and

fore and aft decks.

! WARNING

SLIPPING HAZARD - Wet decks

are slippery. Wear proper

footwear and use extreme

caution on wet surfaces.

! WARNING

CLEAT CLEAT

CLEAT

TO AVOID RISK OF SERIOUS INJURY

OR DEATH SHUT OFF ENGINE WHEN

NEAR SWIMMERS OR PRIOR TO US-

ING SWIM PLATFORM AND BOARD-

ING LADDER.

! DANGER

WORKING DECK

(DECK AREA INTENDED FOR OCCUPATION

DURING ANCHORING, MOORING AND

EMERGENCY OPERATION ONLY)

ACCOMODATION DECK

(DECK AREA INTENDED FOR OCCUPATION

DURING NORMAL OPERATION)

DO NOT WALK ON THIS AREA

Anchor should be independently

secured to prevent accidental re-

lease.

! WARNING

COCKPIT

AREA

! WARNING

DO NOT STAND OR WALK ON

THIS AREA. SERIOUS IN-

JURY COULD RESULT.

9

250 Amberjack

®

SINGLE-

BURNER

BUTANE STOVE

HANGING

LOCKER

/TABLE

STORAGE

LOCKABLE

SLIDING

CABIN DOOR

SINK

SWIM

LADDER

(UNDER LID)

DINING

TABLE

BEVERAGE

HOLDERS

(4 TOTAL)

FWD

AFT

PORT

STBD

ENGINE SHIFT

& THROTTLE

CONTROL

12V

RECEPTACLE

SPEAKER

(ON SIDE PANEL)

DASH PANEL

ACCESSORY LOCATIONS

C/O

MONITOR

(FIG. 9.1)

BATTERY SELECTOR

SWITCH

BILGE PUMP

FUSE

STEREO

MEMORY FUSE

(FIG. 9.3)

FUSE BLOCK

ELECTRONIC

INTERFACE MODULE

DECK

CONTROL

STATION

GROUND BUSS

EXTINGUISHER

MODULE

(DIESEL OPT)

ELECTRONICS BEHIND DASH

(FIG. 9.2)

FRESH

WATER

SPICKETT

LIGHT

PORTABLE

HEAD

COCKPIT SIDE

STORAGE

ACCESS TO

ENGINE

UNDER AFT

JUMP SEAT

FENDER

STORAGE

ADDITIONAL

FLOOR

STORAGE

CARRY ON COOLER W/

DEDICATED STORAGE

SKI TOW

EYE

COCKPIT SIDE

STORAGE

12V GFI

RECEPTACLE

FIRE

EXTINGUISHER

DISCHARGE

PORT

FUEL SENDING

UNIT

CONVERTIBLE

DINETTE

SLEEPER SOFA

(DEDICATED

DINING TABLE

STORAGE BELOW)

SPEAKER

(ON SIDE PANEL)

SPEAKER

(ON FWD PANEL)

10

250 Amberjack

®

SUPPLEMENTAL GENERAL INFORMATION

HEAD SYSTEM

The standard head system on your Sea Ray

®

utilizes

the following items: Portable Head, Vent Filter and Waste

Deck Plate for pumpout station access. The illustration

below shows this sytem and its layout. The owner’s

manual packet in your boat contains information

pertaining to your head system that should be carefully

read.

WASTE WATER LINE ROUTING

(STANDARD) (FIG. 10.1)

ROUTE FROM HEAD

TO THRU-HULL

PUMP OUT HOSE

ROUTE TO DECK PLATE

HEAD UNIT

Do not place facial tissue, paper towels or sani-

tary napkins in head.

! CAUTION

VENT HOSE ROUTE

FROM HEAD

TO THRU-HULL

ROUTE FROM

VACUUM GENERATOR

TO HEAD UNIT

HEAD UNIT

VACUUM

GENERATOR

WASTE WATER LINE ROUTING

(DIRECT OVERBOARD INTERNATIONAL OPT)

(FIG. 10.2)

11

250 Amberjack

®

B ILGE LAYOUT

(FIG. 11.1)

TRANSDUCER

BILGE

BLOWER

FLOAT SWITCH

FUEL TANK

BILGE

PUMP

POWER TRIM

PUMP

WATER PUMP

TRIM TAB

PUMP

BATTERY TRAYS

WATER TANK

FIRE

EXTINGUISHER

VACUUM

GENERATOR

(INTERNATIONAL

OPTION)

OVERBOARD DISCHARGE

SEACOCK (CE OPT)

12

250 Amberjack

®

ROUTE TO

GALLEY SINK

ROUTE TO

FRESHWATER

WASHDOWN

(OPT)

FRESH WATER LINE ROUTING

(FIG. 12.1)

GALLEY SINK

DRAIN

WATER

PUMP

DRINK HOLDER

DRAIN

DRAIN LINE ROUTING

(FIG. 12.2)

WATER

TANK

WATER FILL

HOSE ROUTE

TO DECK FILL

BILGE PUMP

HOSE

BILGE PUMP

COCKPIT

DRAIN

STEP DRAIN

WATER VENT

HOSE ROUTE TO

DECK FILL VENT

ROUTE TO VACUUM

FLUSH HEAD

(INT. OPTION)

13

250 Amberjack

®

GUEST

M

A

D

E

I

N

U

.

S

.

A

ON

OFF

F

U

L

Y

E

N

G

A

G

E

D

A

T

D

E

T

E

N

T

S

T

O

P

E

N

G

I

N

E

B

E

F

O

R

E

S

W

I

T

C

H

I

N

G

O

F

ELECTRICAL INSTALLATION

This owner’s manual supplement contains electrical

schematics for your boat. These electrical schematics

where generated by technicians at the engineering

division for technical reference and service technicians.

Sea Ray

®

does not recommend that you attempt to work

on the boats electrical system yourself, instead we

recommend that you take your boat to your authorized

Sea Ray

®

dealer for service. Sea Ray

®

reserves the

right to change or update the electrical system on any

model at any time without notice to the consumer and

is NOT obligated to make any updates to units built

prior to changes.

BATTERY

SWITCH

PORT (OPTION)

BATTERY

ENGINE

STARTER

TERMINAL

STBD

BATTERY

ENGINE

NEGATIVE

TERMINAL

BATTERY CABLE ROUTING

(FIG. 13.1)

POSITIVE

NEGATIVE

BATTERY SWITCH

Your boat is equipped with a

battery on/off switch. It’s located

in the transom compartment. (See

figure 9.3 for exact location). The

battery switch controls the delivery

of DC loads, as well as allowing

the engine alternator to charge the

batteries.

(FIG. 13.2)

14

250 Amberjack

®

HULL

FUEL FEED LINE

ROUTE TO ENGINE

FUEL VENT

FUEL FILL

FUEL TANK

FUEL LINE ROUTING (DIESEL OPT)

(FIG. 14.2)

HULL

FUEL FEED LINE

ROUTE TO ENGINE

FUEL VENT

FUEL FILL

FUEL TANK

MANUAL SHUTOFF

VALVE

FUEL FILTER

FUEL RETURN

ROUTE TO ENGINE

FUEL FEED

ROUTE TO ENGINE

FUEL LINE ROUTING (GAS STANDARD)

(FIG. 14.1)

FUEL SYSTEM

The Owner’s Manual contains important

fueling information. Take time to read all

the fuel related information in the owner’s

packet.

The 250 Amberjack

®

standard gasoline fuel system

An optional diesel fuel system is available and consists

of a 70 gallon (265 liters) fuel tank, Racor

®

fuel filter,

fuel tank vent, manual shut-off valve, engine fuel supply

and return line and fuel fill (see fig. 14.2).

consists of a 70 gallon (265 liters) fuel tank, fuel tank

vent, an engine fuel supply line and fuel fill (see fig.

14.1).

15

250 Amberjack

®

DECK

BILGE BLOWER

HOSES

BILGE BLOWER INSTALLATION

(FIG. 15.1)

PORT

STBD

FWD

BILGE

PUMP

BILGE PUMP INSTALLATION

(FIG. 15.2)

BILGE

BLOWER

FLOAT

SWITCH

PORT

STBD

FWD

STARBOARD

ENGINE MOUNT

PORT ENGINE

MOUNT

16

250 Amberjack

®

MANUAL BILGE PUMP

INSTALLATION (CE OPT)

(FIG. 16.1)

MANUAL

BILGE PUMP

DECK

STRAINER

CORRIGATED

REINFORCED

HOSE

ROUTE TO

PUMP

INTAKE

ROUTE FROM

PUMP DISCHARGE

TO THRU-HULL

PORT

STBD

FWD

17

250 Amberjack

®

POWER STEERING LINE ROUTING

(FIG. 17.1)

SHIFT CABLE

THROTTLE CABLE

THROTTLE/SHIFT

CONTROL BOX

STEERING

AT HELM

STEERING SYSTEM

This boat is equipped with power steering.

REFER TO THE OWNER’S MANUAL GENERAL IN-

FORMATION AND ENGINE OWNER'S MANUAL IN THE

OWNER'S PACKET FOR INSTRUCTIONS AND

WARRANTY INFORMATION.

STEERING

CABLE

18

250 Amberjack

®

FIRE EXTINGUISHING SYSTEM

The 250 AJ is offered with the

optional automatic fire extin-

guishing system. Your boat also

needs to be equipped with ap-

proved portable fire extinguish-

ers. It is your responsibility to

equip and maintain fire extin-

guishers.

Following are United States Coast Guard (USCG) re-

quirements and American Boat & Yacht Council (ABYC)

recommendations for boats not equipped with the au-

tomatic fire extinguishing system option for open boats

over 26 feet (4.9 meters) but less than 40 feet (7.9

meters).

AUTOMATIC FIRE EXTINGUISHER SYSTEM

(WITH DIESEL ENGINES) (FIG. 18.3)

BATTERY

IGNITION

SWITCH

DISCHARGE

ALARM BUZZER

STARTER

IGNITION

GROUND

ENGINE SHUTDOWN

OVERRIDE SWITCH

UPON SYSTEM DISCHARGE,

SHUTDOWN:

• ENGINE

• FORCED VENTILATION

• ELECTRICAL SYSTEMS

CHARGE & DISCHARGE

INDICATOR LIGHTS

CHARGE DISCHARGE

NORM

OVERRIDE

AUTOMATIC FIRE EXTINGUISHER SYSTEM

(WITH GASOLINE ENGINES) (FIG. 18.2)

CHARGE & DISCHARGE

INDICATOR LIGHT

BATTERY

IGNITION

SWITCH

STARTER

IGNITION

GROUND

(FIG. 18.1)

• In case of fire DO NOT open compartment.

• Shut down engine.

• Continuously discharge entire contents of

portable fire extinguisher through port

immediately.

! WARNING

(FIG. 18.4)

FIRE EXTINGUISHER DISCHARGE

PORT / ACCESS PLATE

This access plate is located

under the port aft jump seat.

In the event of a fire, the

access plate can be re-

moved to allow the opera-

tor to discharge a fire ex-

tinguisher into the compart-

ment without opening the

engine compartment.

UPON SYSTEM DISCHARGE,

SHUTDOWN:

• ENGINE

• FORCED VENTILATION

• ELECTRICAL SYSTEMS

Location: Outside engine compartment, steering postion

and galley, or passenger cockpit.

Note: To be ABYC compliant Sea-Ray Boats, Inc. follows

ABYC construction standards and recommendations.

BoatStandard

No Fixed

System

Qty.

W/Approved

Fixed System

Qty.

Type

USCG 250 AJ 1 0 B1

ABYC 250 AJ 2 0 B1

19

250 Amberjack

®

ANCHORING A RRANGEMENT

The 250 AJ is equipped with an anchor storage

compartment. Stow the anchor in the storage

compartment when not in use. Note: Before using the

anchor be sure the anchor line is secured to the boat –

to the bow eye or bow cleat.

ANCHOR ARRANGEMENT

(STANDARD & OPTIONAL) (FIG. 19.1)

ANCHOR

STORAGE

WITH HATCH

ENGINE COOLING SYSTEM

The engine cooling system is an integral part of the

propulsion system.

REFER TO THE ENGINE OWNER’S MANUAL FOR

INSTRUCTIONS AND WARRANTY INFORMATION.

CLEAT

Page is loading ...

Sea Ray 2006 250 AMBERJACK Supplement Owner's manual

Sea Ray 2006 250 AMBERJACK Supplement Owner's manual

Related papers

Other documents