Sony STR-DK5 E User manual

1

SERVICE MANUAL

E Model

Russia Model

STR-DK5

FM STEREO/FM-AM RECEIVER

Amplifier section

Power Output

1)

Models of area code SP, MY

(6 ohms 1 kHz, THD 0.7 %)

FRONT

2)

: 80 W/ch

CENTER

2)

: 80 W

SURR

2)

: 80 W/ch

(6 ohms 1 kHz, THD 10 %)

FRONT

2)

: 110 W/ch

CENTER

2)

: 110 W

SURR

2)

: 110 W/ch

Models of area code VTM, RU, TH

(6 ohms 1 kHz, THD 0.7 %)

FRONT

2)

: 70 W/ch

CENTER

2)

: 70 W

SURR

2)

: 70 W/ch

(6 ohms 1 kHz, THD 10 %)

FRONT

2)

: 95 W/ch

CENTER

2)

: 95 W

SURR

2)

: 95 W/ch

1) Measured under the following conditions:

Area code Power requirements

SP, MY, RU 230 V AC, 50 Hz

VTM, TH 220 V AC, 50 Hz

2) Depending on the sound field settings and the

source, there may be no sound output.

SPECIFICATIONS

Inputs (Analog)

MULTI CH IN, Sensitivity: 500 mV

SA-CD/CD, DVD, Impedance: 50 k ohms

VIDEO 1, 2

Inputs (Digital)

DVD (Coaxial) Sensitivity: –

Impedance: 75 ohms

SA-CD/CD (Optical) Sensitivity: –

Impedance: –

Outputs (Analog)

SUB WOOFER Voltage: 2 V

Impedance: 1 k ohm

Reproduction frequency range:

20 – 20,000 Hz

FM tuner section

Tuning range 87.5 – 108.0 MHz

Antenna FM wire antenna

Antenna terminals 75 ohms, unbalanced

Intermediate frequency 10.7 MHz

AM tuner section

Tuning range

With 9-kHz tuning scale: 531 – 1,602 kHz

Antenna Loop antenna

Intermediate frequency 450 kHz

Ver. 1.1 2006. 03

9-887-005-02

2006C04-1

Sony Corporation

Home Audio Division

Published by Sony Techno Create Corporation

Manufactured under license from Dolby Laboratories.

“Dolby”, “Pro Logic” and the double-D symbol are

trademarks of Dolby Laboratories.

“DTS”, “DTS Digital Surround” are registered

trademarks of Digital Theater Systems, Inc.

– Continued on next page –

2

MODEL IDENTIFICATION

— BACK PANEL —

MODEL PART No.

SP, MY 2-655-484-0s

RU 2-655-484-4s

VTM 2-655-484-6 s

TH 2-655-484-7s

•Abbreviation

SP : Singapore model

MY : Malaysia model

RU : Russia model

TH : Thai model

VTM : Vietnam model

Part No.

STR-DK5

General

Power requirements

Area code Power requirements

SP, MY 230 – 240 V AC, 50/60 Hz

VTM, TH 220 – 230 V AC, 50/60 Hz

RU 230 V AC, 50/60 Hz

Power consumption 165 W

Power consumption (during standby mode)

0.2 W

Dimensions (w/h/d) (Approx.)

430 × 145 × 296 mm

including projecting parts

and controls

Mass (Approx.) 7.0 kg

Supplied accessories

FM wire antenna (1)

AM loop antenna (1)

Remote commander RM-AAU002 (1)

R6 (size-AA) batteries (2)

Design and specifications are subject to change

without notice.

•Abbreviation

SP : Singapore model

MY : Malaysia model

RU : Russia model

TH : Thai model

VTM : Vietnam model

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE

WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN

THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.

REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE

PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR

IN SUPPLEMENTS PUBLISHED BY SONY.

Ver. 1.1

3

TABLE OF CONTENTS

1. GENERAL

Receiver ...................................................................................4

Remote Button Description ..................................................... 5

2. DISASSEMBLY

2-1. Case ....................................................................................... 6

2-2. Front Panel Section ...............................................................7

2-3. Back Panel Section................................................................ 7

2-4. Digital Board ......................................................................... 8

2-5. Main Board ........................................................................... 8

2-6. Standby Board ....................................................................... 9

3. TEST MODE .............................................................. 10

4. DIAGRAMS

4-1. Block Diagram — Tuner/Audio Section — ...................... 11

4-2. Block Diagram — Digital Section — ............................... 12

4-3. Block Diagram — Karaoke Section —............................. 13

4-4. Block Diagram — Display Section —.............................. 14

4-5. Block Diagram — Power Section — ................................ 15

4-6. Circuit Boards Location .................................................... 16

4-7. Printed Wiring Board — Main Section — ........................ 17

4-8. Schematic Diagram — Main Section (1/2) — .................. 18

4-9. Schematic Diagram — Main Section (2/2) — .................. 19

4-10. Printed Wiring Board — Digital Section (1/2) — ............ 20

4-11. Printed Wiring Board — Digital Section (2/2) — ............ 21

4-12. Schematic Diagram — Digital Section (1/3) — ............... 22

4-13. Schematic Diagram — Digital Section (2/3) — ............... 23

4-14. Schematic Diagram — Digital Section (3/3) — ............... 24

4-15. Printed Wiring Boards — Mic Section — ........................ 25

4-16. Schematic Diagram — Mic Section —............................. 26

4-17. Printed Wiring Boards — Display Section— ................... 27

4-18. Schematic Diagram — Display Section—........................ 28

4-19. Printed Wiring Board — Karaoke Section — ................... 29

4-20. Schematic Diagram — Karaoke Section —...................... 30

4-21. Printed Wiring Board — Power Section — ...................... 31

4-22. Schematic Diagram — Power Section — ......................... 32

5. EXPLODED VIEWS

5-1. Case Section ........................................................................ 40

5-2. Front Panel Section ............................................................. 41

5-3. Back Panel Section.............................................................. 42

5-4. Chassis Section ................................................................... 43

6. ELECTRICAL PARTS LIST ....................................44

STR-DK5

4

STR-DK5

SECTION 1

GENERAL

This section is extracted

from instruction manual.

42

GB

Receiver

A.F.D. qg (21, 22, 23)

D.B.F.B. (button/indicator) 8

(28)

DISPLAY 5 (19, 39)

Display 6 (20)

ECHO wh (24)

INPUT MODE q; (27)

INPUT SELECTOR qa (17, 18,

19, 24, 27)

IR (receptor) ql (33, 39)

KARAOKE ON/OFF (button/

indicator) wj (24)

KEY CONTROL

#/2 4 (26)

MASTER VOLUME 9 (12, 16,

17, 25, 38)

MEMORY/ENTER qj (12, 18)

MIC 1 (jack) wf (24)

MIC 2 (jack) wd (24)

MIC 1 Tone knobs

LOW, MID, HIGH 2 (24)

MIC 2 Tone knobs

LOW, MID, HIGH 3 (24)

MIC 1 VOL wg (24)

MIC 2 VOL ws (24)

MOVIE qf (22, 28, 38)

MUSIC qd (23, 28, 38)

Music Tone knobs

LOW, MID, HIGH 7 (25)

MUSIC VOLUME qs (24, 25)

SCORE (button/indicator) wa

(26)

TUNING –/+ qk (17, 18)

VOCAL SELECT (button/

indicator) w; (26)

2CH qh (21, 23, 28)

?/1 (power) 1 (12, 13, 28)

List of button locations and reference pages

How to use this page

Use this page to find the location of buttons that are

mentioned in the text.

Ill

us

t

ra

ti

on num

b

er

r

DISPLAY 5 (19, 39)

RR

Name of button/part Reference page

ALPHABETICAL ORDER

A - L

M - Z

NUMBERS AND SYMBOLS

6

423

1

w;wa

qaqs q;

wdwfwh

5

89

w

s

w

g

w

j

ql

7

qdqfqgqhqj

qk

5

STR-DK5

33

GB

Operations Using the Remote RM-AAU002

You can use the remote RM-AAU002 to operate

the components in your system.

Inserting batteries into the

remote

Insert R6 (size-AA) batteries with the + and –

properly oriented in the battery compartment.

When using the remote, point it at the remote

sensor on the receiver.

Tip

Under normal conditions, the batteries should last for

about 6 months. When the remote no longer operates

the receiver, replace all batteries with new ones.

Notes

•Do not leave the remote in an extremely hot or humid

place.

•Do not use a new battery with an old one.

•Do not expose the remote sensor to direct sunlight or

lighting apparatuses. Doing so may cause a

malfunction.

•If you don’t use the remote for an extended period of

time, remove the batteries to avoid possible damage

from battery leakage and corrosion.

*The MASTER VOL +, numeric button 5 and H

buttons have a tactile dot. Use the tactile dot as a

reference when operating the receiver and other

audio/video components.

**Input buttons

Operations Using the Remote RM-AAU002

Before you use your

remote

Remote button

description

123

46

78

0/10

ENTER

9

SYSTEM STANDBY

TV/VIDEO

SLEEP

TEST

TONE

AV

?/1

VIDEO 1 VIDEO 2 DVD SA-CD/CD

2CH A.F.D.

RETURN/EXIT

TV CH –

PRESET –

TV CH +

PRESET +

TUNING –

TV

TUNING +

REPLAY ADVANCE

c STEP C

DISPLAY

MOVIE MUSIC

MEMORY SHIFT

D.SKIPCLEAR ANGLE

AV

MENU

TOP MENU/

GUIDE MUTING

TV VOL

MASTER VOL

FM MODE

MPX

AUDIO

D.TUNING

ANT

JUMP

SUBTITLE

DUAL MONO

TUNER

MAIN MENU

TV

?/1

>10

-

F

Gg

f

ENTER

.

HmM

Xx

<

>

5

1

3**

4**

**ej

ek

el

**eh

8

9

q;

qa

qs

qf

qd

qj

qh

qk

w;

wa*

ws

wd

wf

wh

wj

e;

wg

wk

wl

ea

*es

ef

**eg

ql

qg*

5

6

7

ed

AV ?/1

(on/standby)

switch

TV ?/1, ?/1

(on/standby)

switch

2

continued

6

STR-DK5

Note : This set can be disassemble according to the following sequence.

SECTION 2

DISASSEMBLY

2-1. CASE

Note : Follow the disassembly procedure in the numerical order given.

2-1. CASE

(Page 6)

2-2. FRONT PANEL SECTION

(Page 7)

2-3. BACK PANEL SECTION

(Page 7)

SET

2-6. STANDBY BOARD

(Page 9)

2-4. DIGITAL BOARD

(Page 8)

2-5. MAIN BOARD

(Page 8)

1

two

screws

(case 3 TP2)

2

two

screws

(case 3 TP2)

3

two

screws

(+BVTP 3

×

8)

4

cas

e

Ver. 1.1

7

STR-DK5

2-2. FRONT PANEL SECTION

2-3. BACK PANEL SECTION

1

CNP200 (10P)

2

flexible flat cable (23 core)

(CNS505)

3

five

screws

(+BVTP 3

×

8)

4

front panel section

1

CNP904 (2P)

2

CNP551 (9P)

3

flexible flat cable (7 core)

(CNS503)

4

flexible flat cable (11 core)

(CNS508)

0

two

screws

(+BVTP 3

×

8)

5

four

screws

(+BVTP 3

×

8)

6

three

screws

(+BVTP 3

×

8)

7

two

screws

(+BVTP 3

×

8

)

8

screw

(+BVTP 3

×

8)

9

screw

(+BVTP 3

×

8)

qa

back panel section

Ver. 1.1

8

STR-DK5

2-4. DIGITAL BOARD

2-5. MAIN BOARD

1

CNP505 (8P)

2

CNP503 (4P)

3

CNP504 (5P)

CNP501

CNP502

4

screw

(+BVTP 3

×

8)

5

screw

(+BVTP 3

×

8)

6

bracket (digital

)

7

DIGITAL board

2

CNP801 (5P)

1

CNP916 (5P)

3

CNP901 (3P)

4

CNP902 (5P)

8

MAIN boar

d

5

two

screws

(+BV3 (3-CR))

6

two

screws

(+BV3 (3-CR))

7

screw

(+BV3 (3-CR))

9

STR-DK5

2-6. STANDBY BOARD

1

CNP916 (5P)

2

CNP801 (5P)

3

CNP904 (2P)

4

CNP903 (3P)

5

three

screws

(+BVTP 3

×

8)

6

STANDBY board

10

STR-DK5

SECTION 3

TEST MODE

FACTORY PRESET MODE

* All preset contents are reset to the default setting.

* Procedure:

While depressing the [2CH] and the [MOVIE] buttons

simultaneously, press the

?/1 button to turn on the main power.

The message “FACTORY” appears for a moment and the present

contents are reset to the default values.

SPEAKER SIZE SELECTION MODE

* Either the normal speaker or micro satellite speaker can be

selected.

* Procedure:

While depressing the [DISPLAY] and the [TUNING ---] buttons

simultaneously, press the ?/1 button to turn on the main power.

Either the message “NORM. SP.” or “MICRO SP.” appears for a

moment and select the desired speaker size.

VACUUM FLUORESCENT DISPLAY TEST MODE

* All fluorescent segments are tested.

When this test is activated, all segments light on at the same

time, then each segment lights on one after another.

* Procedure:

While depressing the [DISPLAY] and the [A.F.D.] buttons

simultaneously, press the ?/1 button to turn on the main power.

1. ALL segments light on.

[KARAOKE ON/OFF], [VOCAL SELECT], [SCORE] and [D.B.F.B.]

LED light on.

2. Turn the [INPUT SELECTOR] control, confirm display.

[KARAOKE ON/OFF] and [SCORE] LED light on.

3. Turn the [INPUT SELECTOR] control, confirm display.

[VOCAL SELECT] and [D.B.F.B.] LED light on.

4. Turn the [INPUT SELECTOR] control, all segments and all LEDs

light off.

SOUND FIELD CLEAR MODE

* The preset sound field is cleared when this mode is activated.

Use this mode before returning the product to clients upon

completion of repair.

* Procedure:

While depressing the [2CH] button, press the ?/1 button to turn

on the main power.

The message “SF. CLR.” appears for a moment and

initialization is performed.

SOFTWARE VERSION DISPLAY MODE

* The software version is displayed.

* Procedure:

While depressing the [DISPLAY] and the [TUNING +] buttons

simultaneously, press the ?/1 button to turn on the main power.

The model name, destination and the software version are

displayed for a moment.

KEY CHECK MODE

* Button check

* Procedure:

While depressing the [DISPLAY] and the [2CH] buttons

simultaneously, press the ?/1 button to turn on the main power.

Either the message “REST 15” appears.

Every pressing of any button other than the ?/1 counts down

the buttons. The buttons which are already counted once are not

counted again. When all buttons are pressed “REST 00” appears.

COMMAND MODE SELECTION MODE

* The command mode (AV1 or AV2) of the remote commander

can be selected.

* Procedure:

While depressing the [TUNING ---] button, press the

?/1 button

to turn on the main power.

Either the message “C.MODE.AV 1” or “C.MODE.AV 2”

appears for a moment and select the desired mode.

L

SW

CR

SL S SR

SBL SB SBR

LFE

SP A

SP B SLEEP OPT COAX MULTI CH IN 96/24

DIGITALEX PRO LOGIC II x DTS-ES NEO:6 MPEG-2 AAC RDS

D.RANGE EQ STEREO MONO

D

dB

kHz

mft.

MHz

MEMORY

DIRECT

L

SW

R

S

SB

LFE

SP A

SP B SLEEP OPT COAX MULTI CH IN 96/24

DIGITALEX PRO LOGIC II x DTS-ES NEO:6 MPEG-2 AAC RDS

D.RANGE EQ STEREO MONO

D

dB

kHz

mft.

MHz

MEMORY

DIRECT

C

SL SR

SBL SBR

SP A

SP B SLEEP OPT COAX MULTI CH IN 96/24

DIGITALEX PRO LOGIC II x DTS-ES NEO:6 MPEG-2 AAC RDS

D.RANGE EQ STEREO MONO

D

kHz

mft.

MHz

MEMORY

DIRECT

STR-DK5

11 11

STR-DK5

4-1. BLOCK DIAGRAM — TUNER/AUDIO SECTION —

(Page 13)

(Page 12)

(Page 15)

SECTION 4

DIAGRAMS

(Page 12)

C-CH

SR-CH

R-CH

SL-CH

L-CH

R-IN

L-IN

SW

SEL

C

SEL

SL

SEL

R-CH

DIR

FUNCTION SELECT

IC400

AVCCDVDD

+7V

+3.3V

+7V

SEL

SW

MCU

I/F

SW OUT

C OUT

SL OUT

L OUT

• Signal path

: TUNER (FM/AM)

: VIDEO (AUDIO)

: CD (ANALOG)

• R-ch is omitted due to

same as L-ch.

76

75

78

74

73

AUDIO INAUDIO IN

LRLR

VIDEO 1

DVD

AM

TN1

FM/AM TUNER UNIT

SYSTEM

CONTROL

IC1101 (1/5)

SA-CD/CD

LRLR

J401 J402

R-CH

SLATCH

17

TUNER DATA

16

T.SERIAL CLK

VOL DATA

VOL CLK

STEREO

TUNED

MUTE

DO

L-CH

R-CH

STEREO

TUNED

MUTING

CE

DO

DATA

CLOCK

TU+10V

32

31

VIDEO 2

FM 75Ω

COAXIAL

ANTENNA

-1 -2 -3 -4-1 -2 -3 -4

VDD3.3V

53

RDS DATA

52

RDS CLK

RDS INT

43

RDS SIG

RUSSIA MODEL

FM SIG OUT

10

AUDIO IN AUDIO IN

26 27

24

25

14

49

48

40

41

SB-CH

33

21 20 19 16

7

6

9

8

3

2

5

4

32

+3.3V REG

Q471

13

L

SEL

DIGITAL

SECTION

B

KARAOKE

SECTION

D

DIGITAL

SECTION

A

POWER

SECTION

C

Ver. 1.1

STR-DK5

1212

STR-DK5

4-2. BLOCK DIAGRAM — DIGITAL SECTION —

(Page 13)

(Page 11)

• Signal path

: TUNER (FM/AM)

: VIDEO (AUDIO)

: CD (DIGITAL)

• R-ch is omitted due to

same as L-ch.

SDI1

SD01

DOUT

15

18

SDI2

30

GP8

AUDIO

24

XMCK

20

69

LRCKI1

15

BCKI1

17

KFSI0

CKOUT

13 22

BCKI2

BCK

14 29

LRCKI2

LRCK

15 28

CS

WE

DATAO

23

SD02

24

SD03

25

SCKOUT

14

LRCKO

19

BCKO

20

X1502

13.9MHz

X1301

12.288MHz

MCLK1

9

MCLK2

12

CSO

44

WEO

45

68

108,107,105 -102,99,

98,80 - 77,75 - 72

24 - 27,42 - 44,

1 - 5,18 - 21

29 - 32,35 - 38,

16-13,10 - 7

112,110,109,97 - 92,

85-82,66 - 64

6

17

OE

OEO

43

41

2 11336 35 33 3432

299

37

6 74 18 19 205

EXLOCK

GP12

56

BST

ERROR

21

22

SYSCLK

16

BCK

14

LRCK

13

95 96 97 98

38 37 36 35 47 17

INPUT

DATA

DEMODULATOR

Pa,Pb DETECTION LOCK

DETECTION

MICROPROCESSOR

I/F

C bit DETECTION

34 59

16

DVD

IN

(COAXIAL)

1

SA-CD/CD

IN

(OPTICAL)

OUT

OPTICAL

RECEIVER

IC1352

IC1303

DIGITAL AUDIO

I/F RECEIVER

IC1301

J1301

23

WAVE

SHAPER

+1.8V

VDDI

+3.3V

VDDE

5

+3.3V

VDD

L-IN

DIGITAL

DECIM.

FILTER

ADC

IC1401

DSP

IC1501

SDRAM

IC1502

SWITCH

IC1503

8

GP12

ERROR

1

DATAO

HACN

XRST

HDIN

PM

392

BST_SEL

HDOUT

GP9

HACN

HCS

XRST

HDIN

PM

HDOUT

HCLK

6

CLK

CE

DI

DO

XSTATE

CLK

CE

DI

DO

CKSEL1

93100

48

XMODE

94

CKSEL1

XMODE

XSTATE

5

3

XOUT

DIN2

DIN0

XIN

D1301

D0-15A0-15

SYSTEM

CONTROL

IC1101 (2/5)

TUNER/

AUDIO

SECTION

B

KARAOKE

SECTION

E

TUNER/

AUDIO

SECTION

A

∆Σ

MOD.

HCLK

BST

HCS

3633

1215

PCM1602 MDO

PCM1602 MDI

PCM1602 MC

PCM1602 ML

PCM1602 RST

MDO

ML

35

13

MC

34

14

MDI

37

10

RST

GP9

DATA3

L OUT

R-CH

VOUT5

VOUT6

VOUT1

VOUT2

VOUT3

VOUT4

47

2

9

10

1

AMP

IC1403

45

46

38

SCKI

40

BCK

LRCK

41

LRCKO

6CH DAC

IC1452

DAC

DATA1

SL OUT

R-CH

5

13

14

7

AMP

IC1405

DAC

DATA2

C OUT

312

1

SW OUT

511

7

AMP

IC1404

DAC

1

2

1

L IN

R-IN

5

R IN

STR-DK5

13 13

STR-DK5

4-3. BLOCK DIAGRAM — KARAOKE SECTION —

(Page 12)

(Page 11)

• Signal path

: TUNER (FM/AM)

• R-ch is omitted due to same as L-ch.

5 1

TONE CONTROL

IC2000

MIC AMP

IC2004

MIC 1 AMP

IC2001

RV2000

MIC 1 VOL

RV2003

HIGH

J2000

MIC 1

KARAOKE

RV2002

MID

RV2001

LOW

5 7

MIX AMP

IC2350 (1/2)

5 7

AF AMP

IC2102

5 7

AF AMP

IC2101

L OUT

5 7

BUFFER AMP

IC2351

3 1

MIX AMP

IC2350 (2/2)

+9V

+K5V +15V

RY2000

INVERTER

IC2301

SYSTEM CONTROL

IC1101 (3/5)

64

63

KARAOKE CONTROL

IC2300

7

MIC AMP

IC2003

IC2120

ECHO

CONTROL

ECHO

RV2109

KARAOKE

16

18

20

14 12 5

75 13

2 10

TONE

(MIC 1 TONE)

TONE CONTROL

IC2100

RV2103

HIGH

RV2102

MID

RV2101

LOW

16

18

20

14 12

TONE

(MUSIC TONE)

KARAOKE

5 1

MIC 2 AMP

IC2002

RV2050

MIC 2 VOL

RV2053

HIGH

J2050

MIC 2

RV2052

MID

RV2051

LOW

1

5

3

1

7 9 3

TONE

(MIC 2 TONE)

93

77

75

74

SEL

R-CH

WR

STB

CLK

REQ

DATA

LOUT

MIC IN

L IN

R IN

ROUT

SRAM

K-OK R/W

K-OK STB

K-OK CLK

K-OK REQ

K-OK DATA

INTERFACE

SRAM

36

1

88

34

4

90

33

3 6 8

10

89

K-OK RY

87

35

34

32

33

RELAY

DRIVER

Q2000

+4V REG

Q2350

CN2506

D-LIGHT

SYNC OUTPUT

+9V

D+4V

L+R

-1

-2

3

L

4

R-CH

MIC

OUTPUT

J400

R

DIGITAL

SECTION

E

L OUT

TUNER/

AUDIO

SECTION

D

PHASE

SHIFTER

LOGIC

EQ

3 1

IC2303 IC2302

3 1

+5V

REG

+9V

REG

STR-DK5

1414

STR-DK5

4-4. BLOCK DIAGRAM — DISPLAY SECTION —

83

FL DISPLAY/LED DRIVER

IC100

14

I

29

82

29

30

5

6

47

46

54

SW NETWORK

S121-124

RV102

MASTER

VOLUME

56

51

49

28

27

77

+3.3V

(STBY)

X1

X0

SDA

SCL

POWER_KEY

FLASH1

FLASH2

MD2

MD0

RSTX

SDA

SCL

EEPROM

IC1131

X1101

24MHz

SIRCS

F1

F2

59

FL DATA

7

DIN

57

FL LAT

9

STB

SW1

SW2

SW3

SW4

60

FL CLK

8

1

CLK

2

3

4

1G

I

12G

P1

I

P16

VOL_ENC(A)

VOL_ENC(B)

INPUT ENC(A)

INPUT ENC(B)

MUSIC ENC (A)

MUSIC ENC (B)

A/D2

SW NETWORK

S101-106

SW NETWORK

S111-115

A/D0

A/D1

1

3

63

64

RV100

INPUT

SELECTOR

RV103

MUSIC VOLUME

KARAOKE

1

3

85

86

1

3

1

REMOTE

CONTROL

SIGNAL

RECEIVER

IC102

OUT

SIRCS

SYSTEM

CONTROL

IC1101 (4/5)

BUFFER

IC101

CNS504

S100

FLASH2

MD2

MD0

RESET

1

2

SDA

SCL

FLASH1

9

8

7

6

5

FLASH

PROGRAMMING

12

I

/

I

D101-104

38

39

40

FL101

VACUUM

FLUORESCENT

DISPLAY

IC1111

RESET

42

I

31

9

4

2

8

6

3

STR-DK5

15 15

STR-DK5

4-5. BLOCK DIAGRAM — POWER SECTION —

(Page 11)

8

12

11

DRIVE

POWER AMP

Q501-504

CURRENT

DETECT

Q505,506

RY501

RY601

PRE DRIVER

IC501

IN 2

+VOUT2

-VOUT2

R

L

FRONT

L

SURROUND

AUDIO

OUT

SUB

WOOFER

CENTER

R

R-CH

L-CH

R-CH

SL-CH

C-CH

R-CH

SR-CH R-CH

TUNER/

AUDIO

SECTION

C

RY901

D802

F1

F2

-20V

+3.3V

(STBY)

+1.8V

+5V

-7V

+7V

TU+10V

-20V

RECT

D910-913

D914 D915

(SUB)

D1001

D1110

D1107

D1111

OVERLOAD

DETECT

D502,Q507

8

61

12

11

DRIVE

POWER AMP

Q701-704

CURRENT

DETECT

Q705,706

-20V REG

Q801

B-SWITCH

Q851,852

RELAY

DRIVER

Q901

AC IN

DETECT

Q911

PRE DRIVER

IC701

IN 2

+VOUT2

-VOUT2

OVERLOAD

DETECT

D702,Q707

8

12

11

DRIVE

POWER AMP

Q601-604

CURRENT

DETECT

Q605,606

PRE DRIVER

IC601

IN 2

+VOUT2

-VOUT2

OVERLOAD

DETECT

D602,Q607

RELAY

DRIVER

Q508

RELAY

DRIVER

Q608

RY701

RY702

RELAY

DRIVER

Q560

69

PROTECTOR

D882,883

Q881-883

58

48

70

+5.6V

(STBY)

OVERLOAD

DETECT AMP

72

IC850

–40V

-B

+3.3V/+1.8V

REG

4

5

+3.3V

2

IC1901

+A5V

+5V

REG

13

VDD3.3V

+3.3V

REG

13

IC1001

+3.3V

REG

13

IC1904

+9V

REG

13

IC1902

IC1071

-16V

+16V

+7V

REG

31

IC821

-7V

REG

23

IC822

+5V

REG

13

IC1031

+B

R-CH

R-CH R-CH

RECT

D811

RECT

D920-923

RECT

D804-807

T901

POWER

TRANSFORMER

TM602

TM600 (1/2)

TM600 (2/2)

J403

(MAIN)

FRONT RY

SURR RY

C/SW RY

SURR RY

FRONT RY

C/SW RY

FRONT RY

PROTECTOR

POWER RY

71

SURROUND RY

STOP

C/SW RELAY

SYSTEM

CONTROL

IC1101 (5/5)

PRE

DRIVE

PRE

DRIVE

SB-CH

-40V +BV

PRE

DRIVE

R810

R812

R910

T902

POWER

TRANSFORMER

AC IN

~

F901

SPEAKERS

IMPEDANCE

USE 6-16Ω

RELAY

DRIVER

Q708

RUSSIA

MODEL

• Signal path

: TUNER (FM/AM)

• R-ch is omitted due to

same as L-ch.

Ver. 1.1

STR-DK5

1616

STR-DK5

THIS NOTE IS COMMON FOR PRINTED WIRING

BOARDS AND SCHEMATIC DIAGRAMS.

(In addition to this, the necessary note is

printed in each block.)

for schematic diagram:

• All capacitors are in µF unless otherwise noted. (p: pF)

50 WV or less are not indicated except for electrolytics

and tantalums.

• All resistors are in Ω and

1

/

4

W or less unless otherwise

specified.

•

f

: internal component.

• 2 : nonflammable resistor.

• 5 : fusible resistor.

• C : panel designation.

• A : B+ Line.

• B : B– Line.

•Voltage and waveforms are dc with respect to ground

under no-signal (detuned) conditions.

no mark : FM

∗

: Impossible to measure

•Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-

tion tolerances.

•Waveforms are taken with a oscilloscope.

Voltage variations may be noted due to normal produc-

tion tolerances.

• Circled numbers refer to waveforms.

• Signal path.

F : TUNER (FM/AM)

L : VIDEO (AUDIO)

J : CD (ANALOG)

c : CD (DIGITAL)

• Abbreviation

RU: Russia model

for printed wiring boards:

• X : parts extracted from the component side.

•

f

: internal component.

• : Pattern from the side which enables seeing.

Caution:

Pattern face side: Parts on the pattern face side seen from the

(Side B) pattern face are indicated.

Parts face side: Parts on the parts face side seen from the

(Side A) parts face are indicated.

• Waveforms

— DIGITAL Board —

C

B

These are omitted.

E

Q

B

These are omitted.

C

Q

E

BCE

Note: The components identified by mark 0 or dotted line

with mark 0 are critical for safety.

Replace only with part number specified.

4-6. CIRCUIT BOARDS LOCATION

MIC TONE board

STANDBY board

KARAOKE board

DIGITAL boar

d

MAIN board

MIC AMP board

DISPLAY board

VOLUME board

1

IC1301 qd (CKOUT)

2.2 Vp-p

2.4 Vp-p

1V/DIV, 50nsec/DIV

3

IC1301 wa (XOUT)

1V/DIV, 50nsec/DIV

4

IC1501 9 (MCLK1)

0.8 Vp-p

1V/DIV, 50nsec/DIV

2

IC1301 qf (BCK)

3.3 Vp-p

1V/DIV, 0.2

µ

s/DIV

13.9 MHz

12.288 MHz

3.07 MHz

12.288 MHz

5

IC1501 qs (MCLK2)

1.1 Vp-p

1.2 Vp-p

1V/DIV, 50nsec/DIV

7

IC1101 id (X1)

1V/DIV, 50nsec/DIV

6

IC1501 qf (SCKOUT)

2.9 Vp-p

1V/DIV, 50nsec/DIV

24 MHz

12.288 MHz

13.9 MHz

Ver. 1.1

• Abbreviation

RU: Russia model

STR-DK5

17 17

STR-DK5

(Page 21)

(Page 31)

(Page 29)

1

A

B

C

D

E

F

G

234567891011 12 13 14

-1

L

-2

R

-3

L

-4

R

-1

L

-2

R

-3

L

RL

-4

R

RL

IC400

JW819

JW780

JW781

JW771

JW783

JW784

JW458

JW463

JW496

JW457

JW461

JW462

JW518

JW519

JW520

JW540

JW467

JWH03

JWH04

JWH11

JW

H16

JW760

JW763

JW602

JW601

JW495

JW419

JW440

JW436

JW309

JW498

JW560

JW506

JW502

JW474

Q703

B C E

B C E B C E B C E B C E B C E

B C E

B C E B C E B C E

Q704

Q503 Q504 Q603

Q604

Q553

Q554

Q653

Q654

JWH01

JWH02

JW568

JW559

R881

JW570

JW821

JW445

JW817

JW818

JW820

D852

JWH08

JWH05

JW438

JW620

JW816

JW569

JW615

JW582

JW581

JW578

JW755

JW610

JW611

JW612

JW613

JWH09

JWH10

JW505

JW439

JW412

JW319

JW455

JW453

JW454

JW317

JW503

JW706

JW628

JW630

JW736

JW707

JW527

JWH12

JW469

JW468

JWH13

JW703

JW572

JWH19

JW701

JW637

JW636

JW490

JW491

JW452

JW492

JW470

JW471

JW735

JW507

JW504

JWH18

JW550

JW650

JW529

JW739

JW318

JW422

JW441

JW526

JW757

JW720

JW722

JW528

JW536

JW535

JW537

JW813

TP1

BLK

TP2

JW713

L701

R523

L501

L651

R412

R415

L601

L551

R723

R411

R573

10

1

15

14

2

1

15

14 2

1

15

14

2

1

14

85

R623

R673

TP300

JW480

JWB02

JW423

JW430

JW451

JW409

JW803

JW804

JW350

JW800

GRY

RED

GRY

RED

JW801

JW805

JW806

JW807

JW808

JW809

JW810

JW435

R413

R414

JW475

JW750

JW501

JW473

JW614

JW534

JW525

JW716

JW717

JW558

R844

R840

JW815

D591

JW524

JW704

JW456

JW459

CN551

JW322

JW460

JW476

JW477

JW478

JW479

C445

C443

C444

C442

C441

C481

C483

C882

Q852

D703

D585

RU MODEL

IC821

123

321

Q502

C821

C816

R517

TM600

R703

Q657

D882

R516

R404

R659

CNP901

R401

D603

R616

R853

R625

R856

R590

R581

C403

R416

C563

Q560

R560

R666

C807

R453

C702

R802

D702

R783

C713

R561

R563

R469

Q708

C881

R752

C400

D883

D590

R565

R668

D503

D580

D821

C564

R580

C580

RR12

RR11

CC12

RU MODEL

CC11

R589

C591

R585

C585

R711

R700

R620

Q557

C557

R452

C603

C801

R910

D807

C803

ORG

BLK

RED

R653

R403

D806

D805

C802

C662

D804

R524

C666

R852

D552

R815

R402

R451

C561

R816

R663

R882

R562

R568

C815

R558

R471

R555

R556

D811

R621

Q851

C664

Q705

D881

C715

R667

C663

D501

R569

C446

R559

R715

R512

R708

C471

C653

AUDIO IN

SA-CD/CD

AUDIO IN

DVD

AUDIO IN

VIDEO 2

AUDIO IN

VIDEO 1

AUDIO OUT

SUB WOOFER

SURROUND

SPEAKERS

IMPEDANCE

USE 6-16Ω

TM602

FRONTCENTER

C706

R503

R661

Q602

R660

R664

D652

C604

Q555

C716

IC701

Q552

R564

R655

D651

R707

R567

C482

C423

C811

C665

C813

R859

R658

Q707

C507

C822

J402 J401 J403

Q655

C700

R525

C432

R554

R612

R624

Q702

C431

C711

R454

C421

C703

R704

R665

R718

Q652

C514

R508

Q471

R600

R706

C611

R705

Q501

C612

R672

R780

R518

R472

R610

RY701

R611

D601

R613

R854

R618

R586

C613

CNP902

R406

Q656

C616

R858

Q606

C558

Q505

R609

R572

C516

R710

C614

D851

R605

R669

R566

Q607

R606

R615

R617

Q882

C452

R884

C513

R885

R607

Q601

Q508

R604

R511

C824

C608

C434

R571

R510

D502

C433

R509

R804

C402

Q651

R505

R709

D551

R506

R522

R619

CNP501

CN503

C661

R513

R519

C484

R670

R500

Q507

R622

R614

R407

Q801

B C E

R722

R608

C601

R473

R570

R725

R652

R557

C422

R855

C503

C823

C708

C436

R857

CN504

1

10

5

C515

R671

CNP502

CNP916

Q706

C508

C814

C425

Q605

Q551

R724

C512

R719

R713

R720

R520

Q883

R507

C701

Q881

C651

R883

R851

R662

C404

C704

IC850

D801

JW753

C658

C812

C562

C606

R721

R521

RY601

C566

R714

C806

R657

R514

C426

Q608

R656

C707

R701

C435

R702

C565

Q556

Q701

D701

R806

C472

C501

D602

RY501

R717

R803

D841

C511

IC822

IC601

R712

R716

C500

C712

C607

C600

C554

C714

C424

C552

R515

R502

C502

R552

R501

R553

C656

R504

C504

C506

C553

R551

R602

C556

R601

C657

C654

IC501

C652

R603

C851

C615

R654

C602

Q506

C551

R651

RY702

D752

D802

C842

RU MODEL

C808

T901

POWER

TRANSFORMER

(MAIN)

DIGITAL

BOARD

CNP505

H

CN504

RED

GRY

T901

POWER

TRANSFORMER

(MAIN)

CNP902

BLU

GRY

RED

YEL

GRN

E

I

STANDBY

BOARD

CNP906

G

CN503

RED

1

5

4

6

10

GRY

RED

GRY

C

DIGITAL

BOARD

CNP504

DIGITAL

BOARD

CNP503

D

DIGITAL

BOARD

CNS501

A

KARAOKE

BOARD

CNP551

F

DIGITAL

BOARD

CNS502

B

91

1-868-725-

11

(11)

BLK

JWB01

JWB03

(Page 31)

(Page 21)

4-7. PRINTED WIRING BOARD — MAIN SECTION — • Refer to page 16 for Circuit Boards Location. : Uses unleaded solder.

Ver. 1.1

Ref. No. Location

• Semiconductor Location

D501 F-6

D502 E-5

D503 D-9

D551 F-10

D552 E-9

D580 D-10

D585 E-8

D590 E-10

D601 F-9

D602 F-9

D603 C-8

D651 F-12

D652 E-10

D701 F-2

D702 F-2

D703 C-8

D752 B-7

D801 D-12

D802 E-12

D804 C-13

D805 C-13

D806 C-13

D807 C-13

D811 C-12

D821 C-6

D841 E-12

D851 D-8

D881 E-11

D882 E-10

D883 E-10

Ref. No. Location

IC400 C-3

IC501 D-5

IC601 D-7

IC701 E-3

IC821 C-6

IC822 C-6

IC850 D-8

Q471 D-3

Q501 F-5

Q502 G-6

Q503 G-6

Q504 G-7

Q505 F-7

Q506 F-6

Q507 F-6

Q508 D-9

Q551 F-9

Q552 G-9

Q553 G-9

Q554 G-10

Q555 F-10

Q556 F-10

Q557 E-9

Q560 B-7

Q601 F-7

Q602 G-8

Q603 G-7

Q604 G-8

Q605 F-9

Ref. No. Location Ref. No. Location

Q606 F-8

Q607 F-8

Q608 D-9

Q651 F-11

Q652 G-11

Q653 G-11

Q654 G-11

Q655 F-12

Q656 F-12

Q657 E-10

Q701 F-2

Q702 G-3

Q703 G-3

Q704 G-4

Q705 F-4

Ref. No. Location

Q706 F-3

Q707 F-2

Q708 C-8

Q801 E-12

Q851 E-9

Q852 D-8

Q881 E-10

Q882 E-11

Q883 E-11

Ref. No. Location

STR-DK5

1818

STR-DK5

4-8. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) —

(Page 19)

R472

R803

R471

R806

R416

R473

C806

C807

C808

D821

C803

R804

D804

D807

D806

D805

C431

C432

C433

C434

C435

C436

C423

C425

C446

C426

D801

R407

R406

CNP501

CNP502

IC822

D752

R469

R783

C801

C802

C400

C472

C482

C484

C821

C822

C441

C442

C444

C443

C445

R411

R412

R413

R414

R415

R802

C823

C824

C811

C812

C813

C814

C452

C402

C481

C483

IC400

CNP916

RY702

R780

C471

J402

IC821

CN504

CNP901

CNP902

CN503

D802

TP2

TP1

J401

C421 C422 C424

J403

Q471

Q801

D811

R401

R451

R402

R452

R403

R453

R404

R454

C403

C404

Q560

CN551

R910

(Page 32)

(Page 23)

(Page 32)

(Page 19)

(Page 30)

(Page 24)

(Page 23)

STR-DK5

19 19

STR-DK5

4-9. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 33 for IC Block Diagrams.

IC B/D

R701

C502

C552

R501

R551

C602

R601

C652

R651

C702

R508

R509

R514

R517

R518

R519

R520

Q501

Q503

Q504

C514

C515

D501

D502

Q507

Q551

Q552

R558

R559

Q554

Q553

R570

C563

R564

R569

R568

Q557C565

D552

R567

C564

D551

R571

C566

Q601

Q602

R609

Q604

C613

Q603

R614

R619

R618

Q607

D602

C615

C614

R617

D601

R620

Q657

R669

R668

D652

C664

R667

C665

D651

R671

C666

R664

R670

Q653

C663

Q654

R658

R659

Q652

Q651

Q701

Q702

R709

Q703

Q704

C713

R713

R720

R714 D701

C714

R717

D702

C715

Q707

R718

R719

R524

R624

R724

D503

D603

D703

R851

R853

R854

R855

R857

R856

C815C816

Q883

C881

C882

R882

R883

R884

R885

C706

R516

R566

R616

R666

R716

IC850

C712

C711

C662

C661

C612

C611

C562

C561

C512

C511

C554

C504

C704

R816

D881

D882

D883

R562

R662

C654

C604

R515

R565

R615

R665

R715

D852

R503R553

R603R653

R703

C851

Q882

R525

R725

R625

C503

C603

C703

R700

R600

R500

C707

R881

R523

R573

R623

R673

R723

L501

L551

L601

L651

L701

Q506

Q555

Q556

Q606

Q655

Q656

Q705

Q706

Q881

C500

R502

R552

C501

C551

C506

C507

R554

C556

R504

C600

C607

R604

C606

C656

R654

R602

R652

C601

C651

C700

R702C701

R704

R815

R852

C508

C558

C608

C658

C708

R705 R706

R707

R655

R656

R657

R607

R606R605

R555

R556

R557

Q502

R507

R506

R505

R608

R708

R512

C513R511

Q505

R513

R521

C516

R572

R563

R561

R611

R612

R613

R622C616

R621

R672

R663

R661

R711

R712

R722C716

R721

Q605

R522

RY701

RY601

RY501

R844

IC501

IC601

IC701

JW753

Q851

TM600

TM602

R510

R560

R610

R660

R710

Q852

D851

R752

C657

C557

C653

C553

R858 R859

Q508

Q608

Q708

R580 C580 D580

R581

R590 C591

R589

D590

R585 C585 D585

R586

R840

C842

D841

RR11

RR12

CC12

CC11

(Page 18)

Ver. 1.1

STR-DK5

2020

STR-DK5

4-10. PRINTED WIRING BOARD — DIGITAL SECTION (1/2) — • Refer to page 16 for Circuit Boards Location. : Uses unleaded solder.

1

A

B

C

D

E

F

G

H

I

J

2345678910111213

IC1403

IC1404 IC1405

IC1101

R1149

IC1301

IC1452

IC1303

R1352

R1357

R1359

R1358

R1356

C1315

IC1401

R1436

R1486

R1426

R1476

R1466

IC1502

R1470

R1435

R1461

JR1502

R1475

R1460

R1556

D1302

R1402

R1144

C1566

R1474

R1401

R1471

C1408

C1405

FB1405

C1487

FB1452

C1494

C1309

C1361

C1357

C1360

R1407

R1504

FB1306

C1301

C1302

R1301

R1304

R1446

C1303

C1304

R1303

R1305

R1360

JR1511

R1306

R1307

R1308

R1309

R1310

D1301

FB1305

X1301

JR1020

R1502

R1505

FB1503

R1425

R1152

R1153

R1154

R1155

R1151

R1445

R1044

R1523

R1506

IC1503

R1142

R1143

R1113

R1484

R1520

C1432

C1441

R1503

R1553

R1197

R1472

R1554

X1502

R1521

R1522

R1519

R1518

R1517

R1552

R1464

R1525

C1107

R1526

R1551

R1550

R1549

R1548

R1547

R1546

R1528

R1570

R1571

R1572

R1573

R1574

R1527

R1311

R1536

R1543

R1542

R1540

R1539

R1538

R1537

R1544

R1535

R1534

R1533

R1532

R1511

R1312

R1313

R1315R1316

R1318

R1510

R1134

R1135

R1136

R1137

R1509

R1140

R1508

IC1131

R1085

R1123

R1105

R1186

R1076

R1095

R1555

R1541

R1121

R1150

R1501

R1138

R1086

R1041

R1042

R1120

C1002

C1401

R1524

R1115

R1111

R1112

IC1111

R1127

R1128

R1190

R1119

R1107

R1108

R1058

R1059

R1109

R1106

R1175

R1053

X1101

C1122

C1123

C1124

R1083

R1362

C1253

C1251

C1310

C1605

R1161

R1545

C1511

C1522

R1162

R1129

R1635

R1636

R1122

R1052

R1124

R1179

R1180

R1035

R1199

R1198

R1515

FB1308

C1516

R1531

R1132

R1160

C1521

C1913

RU MODEL

EXCEPT

RU MODEL

C1063

FB1502

D1001

R1094

R1403

C1422

IC1501

R1075

R1070

R1081

R1147

R1079

R1080

C1145

C1146

C1147

C1148

R1181

R1182

R1183

R1184

R1185

R1188

1-868-724-

11

(11)

Ref. No. Location

• Semiconductor

Location

(Component Side)

D1001 C-5

D1301 E-10

D1302 E-12

IC1101 G-4

IC1111 F-4

IC1131 I-5

IC1301 D-11

IC1303 F-12

IC1401 H-11

IC1403 I-9

IC1404 I-7

IC1405 I-6

IC1452 H-10

IC1501 F-8

IC1502 D-8

IC1503 G-7

Ver. 1.1

Page is loading ...

Sony STR-DK5 E User manual

This manual is also suitable for

Sony STR-DK5 E User manual

Related papers

Other documents