Blue Ox BRK3050 Installation guide

Brand: Blue Ox

Model: BRK3050

Category: Wall & ceiling mounts accessories

Type: Installation guide

BRK3050

Brake Lock III

Installation Instructions

405-0451 Rev B Page 1 of 2 5/31/16

1. Pull back the carpet on the driver side of

the vehicle. Locate an area on the rewall

behind the brake pedal and mount the

mounting plate to the rewall with the

supplied #10 screws.

Using a 1/4” drill bit, drill a hole centered

in the threaded opening of the mounting

plate thru the rewall.

2. Loop the cable back thru it itself as shown

(left inset). Feed the cable thru the rewall

and install the Brake Lock assembly into

the mounting plate. Reinstall the carpet

around the Brake Lock assembly. Zip tie

the cable to the brake pedal to keep in

position (right inset).

Note: DO NOT try to pull the cable thru

the assembly internal damage can occur.

3. Feed the cable thru the engine compartment

in the most direct route with the least amount

of obstructions and out the front fascia.

Avoid any moving parts or parts that

could be damaged when the cable tightens

during a breakaway situation.

Feed the cable thru the fuse leaving

approximately 3” of slack. Secure the cable

to the fuse with the two (2) cable clamps and

trim the excess wire.

4. Using the supplied zip ties, secure the

fuse to the fascia so that it is not hanging

down.

Install one end of the coiled cable to the

fuse carabiner. Then attach the other end

to a secure location on the back of the

coach with the other supplied carabiner.

BRK3050

Brake Lock III

Installation Instructions

405-0451 Rev B Page 2 of 2 5/31/16

CUSTOMER SERVICE COMMITMENT

Blue Ox® is committed to providing you with exceptional customer care throughout your lifetime with our

products. Our team is here to assist you with any questions you may have regarding the performance of your

product. Simply call (402) 385-3051 and you can speak with our customer care team.

Additionally, please visit our website to see which rallies our Destination America team will be attending. For a

nominal fee, our service technician will service your towing system to ensure it’s in proper working condition.

Also, as a commitment to our customers, should you visit our factory, you can stay at our full service Blue Ox®

campground at no charge along with enjoying a factory tour.

Again, thank you for being our customer and for the condence you have shown in the performance of our

products. It is because of customers like you we enjoy the success we have today.

One Mill Road, Industrial Park

Pender, Nebraska 68047

Phone: (402) 385-3051

Fax: (402) 385-3360

www.blueox.com

Item No. Part No. Description Qty.

1.................................62-4006 .............................Brake Lock III Assembly ..................................................1

2.................................62-4015 .............................Carabiner Fuse ................................................................1

3.................................201-0708 ...........................#10 x 1-1/2” Self Drilling Screw .......................................4

4.................................225-0052 ...........................3/32” Wire Rope Clamp ................................................... 2

5.................................225-0064 ...........................Carabiner .........................................................................1

6.................................226-0055 ...........................9’ Blue Vinyl Coiled Cable ...............................................1

7.................................290-0275 ...........................8” Nylon Zip Tie ...............................................................3

8.................................299-0633 ...........................Firewall Mounting Plate ...................................................1

Tools Required

Drill

Tape Measure

1/4” Drill Bit

5/16” Nut Driver

Important:

Use only genuine factory replacement parts, do NOT substitute homemade or non-typical parts. Replacement parts may be ordered through your

nearest Blue Ox® Dealer or Distributor. Failing to follow and/or altering these installation instructions in either installation or required equipment will void

the manufacturer’s warranty. Towing behind a non-motorized vehicle will void the warranty.