Univex G-Peeler is a user-friendly, efficient, and safe peeling solution for various vegetables, including potatoes. Its notable features include a 20 lb. capacity, a 3-minute average peeling time, and a user-friendly timer knob for precise operation. The G-Peeler ensures food safety by preventing operation by individuals under 18 years of age and features a safety mechanism to avoid injuries while the machine is running. Proper cleaning and maintenance procedures are outlined in the manual to ensure optimal performance and longevity of the peeler.
Univex G-Peeler is a user-friendly, efficient, and safe peeling solution for various vegetables, including potatoes. Its notable features include a 20 lb. capacity, a 3-minute average peeling time, and a user-friendly timer knob for precise operation. The G-Peeler ensures food safety by preventing operation by individuals under 18 years of age and features a safety mechanism to avoid injuries while the machine is running. Proper cleaning and maintenance procedures are outlined in the manual to ensure optimal performance and longevity of the peeler.
INSTRUCTION
MANUAL
«
tø
2'
A
G PEELER
F
Persons under age 18 are not permitted to operate or
have accessibility to operate this equipment per
U.S. Dept. of Labor Employment Standards
Administration Fact Sheet No. ESA91-3.
unuvex
GP/0904
ED12
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
G PEELER
TO INSURE BOTH SAFE AND
TROUBLE-FREE PERFORMANCE WE STRESS
THAT ALL PERSONNEL THAT WILL BE
INVOLVED WITH YOUR NEW UNIVEX G PEELER
MUST READ AND UNDERSTAND THESE
INSTRUCTIONS BEFORE, ATTEMPTING TO
OPERATE THIS UNIT.
WE APPRECIATE YOUR COOPERATION AND
YOUR BUSINESS. SHOULD THERE BE A
QUESTION OR IF WE CAN BE OF FURTHER
ASSISTANCE, PLEASE CALL US,
1-603-893-6191.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Page 1
G PEELER
TABLE OF CONTENTS
DESCRIPTION
PAGE
Table of Contents
Overall View of Peeler
2
Installation
3
Operating Instructions
3
Cleaning
3
Maintenance
4
Housing Assembly
5
7
Disk Drive Assembly
8
Motor Drive Assembly
9
Wiring Diagram 115V, 60HZ, 1PH
10
Wiring Diagram 220-230v, 50160HZ, 1PH
il
Wiring Diagram 115V, 60HZ, 1PH Canadian Specification Only
12
Wiring Diagram 220-240 V, 50HZ, 1PH British Specification Only
13
Warranty
Back Cover
OPERATOR SAFETY
IT IS A VIOLATION OF UNITED STATES DEPARTMENT
OF LABOR
REGULATIONS TO PERMIT OPERATION OF THE G-PEELER
BY ANY
PERSON UNDER THE AGE OF 18 YEARS.
READ AND MAKE SURE THAT YOU UNDERSTAND
INSTRUCTIONS AND
SAFETY WARNINGS BEFORE ATTEMPTING TO OPERATE
THE PEELER.
NEVER PUT FINGERS OR HANDS IN PEELER WHILE
THE PEELER IS
OPERATING OR SERIOUS INJURY COULD RESULT.
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
G PEELER
JNSTALLATION
After peeler has been removed from carton, remove cover, shipping spacer, water inlet hose and any
literature packed in the peeler. Place peeler on sink drain board or any suitable location. Be
sure that
drain outlet [Fig. 1(6)1 is located so that water and peelings will discharge into sink.
Pull up into position water inlet tube (Fig. 1 [2]). Turn tube in holder positioning it towards the center
of the peeler.
Install cover. Slip small end of flexible hose (Fig 1 [3]) over water inlet tube. Attach large end into cold
water faucet; close and latch discharge door [Fig. 1 [7])
CAUTION: Before making electrical connections, check the specifications on the nameplate to make
sure that they agree with those on your electric service. Plug electric cord (Fig.
1
[4]) into AC outlet.
OPERATING INSTRUCTIONS
After machine has been properly installed, adjust cold water faucet for a small flow of water to flush
away peelings.
To start peeler: Turn timer knob (Fig. 1 [5]) beyond desired time, then turn back to three minute mark.
This is the average time required to peel a 20 lb. load.
Insert potatoes or other vegetables through opening in cover (Fig. 1 [1]).
Timer (fig 1 [5]) will automatically stop unit. Inspect vegetables. If you are satisfied with peeling,
unlatch discharge door. Have receptacle ready to receive vegetables - or discharge directly into sink.
To eject the vegetables, start machine (by turning timer), hold door partly open. Rotation of peeling disc
will eject load. Timer may be turned off and on without damage.
Peeling time will vary with the sìze, shape and condition of potatoes or vegetables. The three minute
average peeling time may have to be increased or decreased accordingly. The estimated capacity of 20
lbs. is based on US Grade i potatoes. Unusually large or long potatoes may require a slight reduction in
load to obtain satisfactory results.
CAUTION: DO NOT OVERLOAD. THERE SHOULD BE AT ALL TIMES ROOM IN THE
PEELER FOR COMPLETE TUMBLING OF VEGETABLES FOR PROPER
PEELING.
Noise emissions below 70 db(A).
CLEANING
WARNING: DISCONNECT ELECTRIC POWER BEFORE CLEANING.
Proper cleaning is essential for insuring the long life of your UNIVEX peeler.
As soon as peeling is complete and before peeled particles dry and stick, remove cover (Fig. 2 [2]) and
peeling disc (Fig. 3 [3]), wash thoroughly with cold water only.
Wash inside of peeler and flush out thoroughly with flexible hose. Allow discharge door to remain
unlatched, thus prolonging the life of the door seal.
Page 3
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
G PEELER
MAINTENANCE
WARNING: DISCONNECT THE ELECTRICAL POWER PRIOR TO PERFORMING ANY
MAINTENANCE
Maintenance is simple and has been kept to a minimum through modem engineering design.
To expose driving mechanism for service, lay unit on side and remove bottom cover (Fig. 2 [1 1]).
To replace belt, (Fig. 4 [3]) release tension spring (Fig. 4 [8]) to loosen belt. Hold motor in slack
position and roll belt off the large pulley. (Fig. 4 [5]) Reverse procedure to install new belt. Do not use
any metallic tools to force belt over pulleys. To do so will greatly shorten belt life.
Page 4
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Page 5
G PEELER
HOUSING ASSEMBLY
FIGURE 2
ILLUS. NO.
PART NO.
DESCRIPTION
QTY.
1
1120304
HOUSING
1
2
1120029
COVER
1
3
1120038
TUBE, WATER INLET
1
4
1200008
SCREW, PPHD 8-32 X 3/8
11
5
1120019
HOSE, WATER INLET
1
6
1120060
CORD, ELECTRICAL, 115V, With Plug
1
1120060.1
CORD, ELECTRICAL, 220/230 V, Without Plug
1
7
1120048
STRAIN RELIEF, CORD
1
8
1120064
LABEL, TIMER
1
9
1120062
TIMER, 5 MIN., 1 POL, 115V
1
1120063
TIMER, 5 MIN., 2 POL, 220/230V
1
10
7100028
KNOB, TIMER
1
11
1120061
COVER, BOTTOM
1
12
2300125
FEET, RUBBER
3
13
1120036
HOSE, DRAIN
1
14
4400155
SCREW, HEX HD 1/4.20 X 1/2
2
15
1120040
PIN, DISCHARGE DOOR
1
16
1120028
HANDLE, DISCHARGE DOOR
17
4400154
SET SCREW, HEX 10-32 X 1/4
1
18
1120039
BAR, LATCH
1
19
1120041
STOP, DOOR
2
20
1120042
PIN, HINGE
1
21
1120027
DOOR, DISCHARGE
1
22
1120022
SEAL, DISCHARGE DOOR
2FT
23
1120026
HOUSING, DISCHARGE
1
24
1120023
GASKET, HOUSING CHUTE
1
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
G PEELER
HOUSING ASSEMBLY
FIGURE 2 (cont)
ILLUS. NO.
PART NO.
DESCRIPTION
QTY
25
RESERVED
26
RESERVED
27
4400270
LABEL, WARNING (Not Shown)
28
RESERVED
29 4400079
SCREW M4-0.7 X 6MM LO (Not Shown)
2
34
1200465
SCREW, SS RD BD SLOTTED 1/4-20 X 5/8
3
FOR CANADIAN SPECIFICATIONS ONLY
6
1120060-2
CORD 115V, CSA ONLY
30
4400238
CIRCUIT BREAKER
31
4400227 LABEL, RESET
32
4400226
LABEL, CSA (not shown)
FOR BRITISH SPECIFICATIONS ONLY
6
8800209
CORD 220-230, BRITISH ONLY
7
7100107
STRAIN RELIEF, CORD
30
7100097
CIRCUIT BREAKER
31
4400227
LABEL, RESET
32
4400423
LABEL, CE (NOT SHOWN)
33
4400335
LABEL, GROUND (NOT SHOWN)
Page 6
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
G PEELER
DISK DRIVE ASSEMBLY
FIGURE 3
Page 8
ILLUS. NO.
PART NO.
DESCRIPTION
QTY.
1
1120310
HOUSING, BEARING
2
1120307
DISC, DRIVE PEELING ASSY
1
3
1120002
DISC, DRIVE PEELING
1
4
4400230
KEYSQ3/16X1 1/2
1
5
6509012
SEAL, OIL
1
6
1030035
BEARING, BALL 5204ZZ
1
7
1200117
RETAINING RING, INT.
3
8
1030019
BEARING, BALL 6204LL
1
9
1120311
GASKET, BEARING HOUSING
1
10
1120318
RING, REINFORCEMENT
1
ii
1200077
LOCKWASHER 5/16
4
12
1200206
SCREW, HEX HD SS 5/16.18 X 5/8
4
13
1120305
HOUSING, DIVIDER (PART OF ITEM 10F FIG. 2)
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
Page 9
G PEELER
MOTOR DRIVE ASSEMBLY
FIGURE 4
1
1200412
SET SCREW 1/4-20 X 1/4
2
2
1120302
PULLEY, DRIVE
1
3
1120303
BELT, POLY-V
1
4
1200119
RETAINING RING, EXT.
2
5
1120302
PULLEY, DRIVEN
6
1200036
SET SCREW 5/16-24 X 3/8
2
7
1120047
TAB. BELT TENSION
1
8
1120017
SPRING, BELT TENSION
1
9
2200021
TAB, TENSION SPRING, 115V
1
10
1120316
BOLT, MPTOR MOUNT
11
4400083
NUTJAM3/8-24
1
12
6090012
MOTOR 1/3HP, 100-120V/200-240V, 50/60HZ, 1PH
13
1120225
ROD, MOTOR PIVOT
1
14
1200060
NUT, HEX HD 10-32
2
PDF compression, OCR, web optimization using a watermarked evaluation copy of CVISION PDFCompressor
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
Univex G-Peeler is a user-friendly, efficient, and safe peeling solution for various vegetables, including potatoes. Its notable features include a 20 lb. capacity, a 3-minute average peeling time, and a user-friendly timer knob for precise operation. The G-Peeler ensures food safety by preventing operation by individuals under 18 years of age and features a safety mechanism to avoid injuries while the machine is running. Proper cleaning and maintenance procedures are outlined in the manual to ensure optimal performance and longevity of the peeler.
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
Powerhouse PH6500Ri Quick start guide
-
Hobart 6430 Peeler Owner's manual
-
Coopers 8118 Operating instructions
-
Champion DH-1000 User manual
-
-
Pro Fitness GF738339-DI Assembly & User Manual
-
Jackson / Dalton Dishwasher D226 User manual
-
Frymaster FPPH255 User manual
-
Frymaster H50 User manual
-
TurboChef C3/C User manual
