MARAZZI AJ6R Operating instructions

AJ6R
MARAZZI
Brand
MARAZZI
Model
AJ6R
Type
Operating instructions
(pattern layout brochure)
the fine art of porcelain
Made In The USA
PLEASE NOTE:
These layout suggestions are provided as a service by Marazzi USA. The calculations are believed to be
accurate and correct; however, final responsibility for pattern calculation and usage rests with the user.
• Whenusingasinglesizeoftile,useonlyonecaliberonajob.Thesizesmayvaryfromtiletotile
andapropergroutjointwidthmustbeselected.
•Whenchoosingapatternwithmultiplesizes,calibersshouldbesynchronizedwithintilesizes.
Multiple caliber sizes mayneedtobeusedtoinsureaproperwidthgroutjoint.
• Ifseriesisindicatedasamodularproduct,calibersarenotanissue.
• Ifoffsetpatternisrequiredfortileswithsideslongerthan16",useanoffsetnotgreaterthan33%.
• Alwayslayoutatleastfourinterlockingsamplesofthepatternchosenandobtainacceptanceby
customerbeforeinstallation.
• Shadedareasindicatepatternrepeat.
GroutRecommendationsperANSIA108.02
4.3.8Groutjointsize:Toaccommodatetherangeinfacialdimensionsofthetilesuppliedforaspecific
project,theactualgroutjointmay,ofnecessity,varyfromthegroutjointsizespecified.Theactual
groutjointsizeshallbeatleastthreetimestheactualvariationoffacialdimensionsofthetilesupplied.
Example:fortilehavingatotalvariationof1/6inchinfacialdimensions,aminimumof3/16inchgroutjoint
shallbeused.Nominalcenterlineofalljointsshallbestraightwithdueallowancesforhand-moldedor
rustictiles.Innocircumstanceshallthejointbelessthan1/16inch.
Size Percent
6"x6"/6"x6"/12"x12"/
13"x13"/16"x16"/18"x18"/
20"x20"
100%
(one tile)
Size Percent
6"x6"/6"x6"/12"x12"/
13"x13"/16"x16"/18"x18"/
20"x20"
100%
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/4"x24"/6"x24"/
12"x24"/12"x48"/24"x48"/
6"x36"/9"x36"/18"x36"
100%
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/4"x24"/6"x24"/
12"x24"/12"x48"/24"x48"/
6"x36"/9"x36"/18"x36"
100%
Size Percent
6"x6"/6"x6"/12"x12"/
13"x13"/16"x16"/18"x18"/
20"x20"
100%
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/4"x24"/6"x24"/
12"x24"/12"x48"/24"x48"/
6"x36"/9"x36"/18"x36"
100%
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/4"x24"/6"x24"/
12"x24"/12"x48"/24"x48"/
6"x36"/9"x36"/18"x36"
100%
(two tiles)
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/12"x24"/24"x48"/
18"x36"
100%
Size Percent
3"x6"/6"x12"/6"x13"/
10"x20"/12"x24"/24"x48"/
18"x36"
100%
Size Percent
6"x12"/6"x13"/12"x24" 33.33%
12"x12"/13"x13"/24"x24" 66.67%
(one tile)
Size Percent
6"x12"/6"x13"/12"x24" 33.33%
12"x12"/13"x13"/24"x24" 66.67%
Size Percent
6"x6"/6"x6"/12"x12" 33.33%
6"x12"/6"x13"/12"x24" 66.67%
Size Percent
12"x12" 11.11%
24"x48" 88.89%
Size Percent
6"x6"/6"x6"/12"x12" 33.33%
6"x12"/6"x13"/12"x24" 66.67%
Size Percent
6"x6"/6"x6"/12"x12" 20.00%
6"x12"/6"x13"/12"x24" 80.00%
(two tiles)
Size Percent
6"x6"/6"x6" 50.00%
6"x12"/6"x13" 50.00%
Size Percent
6"x6"/6"x6"/12"x12" 11.11%
6"x12"/6"x13"/12"x24" 88.89%
Size Percent
6"x12"/6"x13"/12"x24" 50.00%
12"x12"/13"x13"/24"x24" 50.00%
Size Percent
6"x6"/6"x6"/12"x12" 25.00%
6"x12"/6"x13"/12"x24" 75.00%
Size Percent
6"x12"/6"x13"/12"x24" 42.86%
12"x12"/13"x13"/24"x24" 57.14%
Size Percent
6"x6"/6"x6"/12"x12" 75.00%
12"x12"/13"x13"/24"x24" 25.00%
Size Percent
4"x24" 25.00%
12"x24" 75.00%
Size Percent
4"x24"/6"x36" 40.00%
6"x24"/9"x36" 60.00%
Size Percent
4"x24" 25.00%
12"x24" 75.00%
Size Percent
12"x48" 33.33%
24"x48" 66.67%
Size Percent
6"x6"/6"x6" 25.00%
12"x12"/13"x13" 75.00%
Size Percent
12"x12" 20.00%
24"x24" 80.00%
(two tiles)
Size Percent
6"x36" 40.00%
9"x36" 60.00%
Size Percent
6"x24"/12"x48" 33.33%
12"x24"/24"x48" 66.67%
Size Percent
6"x12"/6"x13"/12"x24" 33.33%
12"x12"/13"x13"/24"x24" 66.67%
Size Percent
12"x12" 11.11%
24"x48" 88.89%
Size Percent
3"x6" 33.33%
13"x13" 66.67%
Size Percent
12"x24" 30.77%
18"x36" 69.23%
Size Percent
12"x24" 30.77%
18"x36" 69.23%
Size Percent
6"x6"/6"x6"/12"x12" 20.00%
12"x12"/13"x13"/24"x24" 80.00%
Size Percent
12"x12" 50.00%
12"x24" 50.00%
(two tiles)
Size Percent
12"x12"/13"x13" 15.79%
16"x16"/18"x18" 84.21%
Size Percent
13"x13" 36.00%
16"x16" 64.00%
Size Percent
12"x12"/13"x13" 30.76%
18"x18"/20"x20" 69.24%
(three tiles
+
)
Size Percent
6"x6"/6"x6" 20.00%
6"x12"/6"x13" 40.00%
12"x12"/13"x13" 40.00%
Size Percent
6"x6"/6"x6"/12"x12" 14.29%
6"x12"/6"x13"/12"x24" 28.57%
12"x12"/13"x13"/24"x24" 57.14%
Size Percent
6"x6"/6"x6"/12"x12" 14.29%
6"x12"/6"x13"/12"x24" 28.57%
12"x12"/13"x13"/24"x24" 57.14%
Size Percent
6"x6"/6"x6" 33.34%
6"x12"/6"x13" 33.33%
12"x12"/13"x13" 33.33%
Size Percent
6"x6"/6"x6"/12"x12" 25.00%
6"x12"/6"x13"/12"x24" 25.00%
12"x12"/13"x13"/24"x24" 50.00%
Size Percent
6"x6"/6"x6"/12"x12" 9.09%
6"x12"/6"x13"/12"x24" 54.55%
12"x12"/13"x13"/24"x24" 36.36%
Size Percent
6"x6"/6"x6"/12"x12" 14.29%
6"x12"/6"x13"/12"x24" 28.57%
12"x12"/13"x13"/24"x24" 57.14%
+
Largest tile in pattern needs to be two calibers larger than other tiles
Size Percent
6"x6"/6"x6"/12"x12" 11.11%
6"x12"/6"x13"/12"x24" 44.44%
12"x12"/13"x13"/24"x24" 44.45%
Size Percent
6"x6"/6"x6"/12"x12" 25.00%
6"x12"/6"x13"/12"x24" 50.00%
12"x12"/13"x13"/24"x24" 25.00%
Size Percent
12"x24" 14.29%
24"x24" 28.57%
24"x48" 57.14%
(three tiles
+
)
Size Percent
6"x6"/6"x6"/12"x12" 25.00%
6"x12"/6"x13"/12"x24" 50.00%
12"x12"/13"x13"/24"x24" 25.00%
Size Percent
6"x6"/6"x6"/12"x12" 33.33%
6"x12"/6"x13"/12"x24" 33.33%
12"x12"/13"x13"/24"x24" 33.34%
Size Percent
6"x12"/6"x13" 28.57%
12"x12"/13"x13" 28.57%
18"x18"/20"x20" 42.86%
+
Largest tile in pattern needs to be two calibers larger than other tiles
Size Percent
6"x6"/6"x6"/12"x12" 16.67%
6"x12"/6"x13"/12"x24" 27.78%
12"x12"/13"x13"/24"x24" 55.55%
Size Percent
6"x13" 16.67%
13"x13" 33.33%
20"x20" 50.00%
Size Percent
6"x6" 15.25%
12"x12" 30.51%
16"x16" 54.24%
Size Percent
4"x24" 14.28%
6"x24" 42.86%
12"x24" 42.86%
Size Percent
4"x24" 18.18%
6"x24" 27.27%
12"x24" 54.55%
(three tiles
+
)
+
Largest tile in pattern needs to be two calibers larger than other tiles
Size Percent
3"x6" 44.44%
6"x6" 11.11 %
13"x13" 44.45%
Size Percent
6"x6" 15.25%
12"x12" 30.51%
16"x16" 54.24%
Size Percent
3"x6" 16.67%
6"x6" 16.67%
13"x13" 66.66%
Size Percent
6"x6" 7.14%
12"x12" 28.57%
18"x18" 64.29%
Size Percent
12"x12" 6.67%
12"x24" 13.33%
24"x24" 26.67%
24"x48" 53.33%
Size Percent
6"x6" 5.80%
13"x13" 23.52%
10"x20" 17.65%
20"x20" 53.03%
Size Percent
6"x6" 14.28%
6"x13" 14.28%
13"x13" 28.58%
20"x20" 42.86%
(four tiles
+
)
Size Percent
6"x6" 13.33%
13"x13" 26.67%
20"x20" 60.00%
American Marazzi Tile, Inc.
Headquarters & Manufacturing Plant
359 Clay Road East
Sunnyvale, Texas 75182
T 972.226.0110
F 972.226.5629
www.marazzitile.com
[email protected]
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10

MARAZZI AJ6R Operating instructions

AJ6R
MARAZZI
Brand
MARAZZI
Model
AJ6R
Type
Operating instructions
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents