Wonder Light Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V User guide

Brand: Wonder Light

Model: Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V

Type: User guide





WonderLightUVInstallationGuideRev050414



WonderLightUVSterilizerInstallationGuide

ThankyouforpurchasingaCleanWaterSystem!Withproperinstallationandalittleroutinemaintenance

yourUVsterilizerwilllastformanyyears.





Questions?

Callustoll‐free:1‐888‐600‐5426or1‐831‐462‐8500

Emailus:[email protected]

Seemoreinformationonourwebsite:www.cleanwaterstore.com/resources

Clean Water Made

Eas





WonderLightUVInstallationGuideRev050414

Pre‐Installation

1. NotethatforUVtobeeffectivethewatershouldbelow:

a. Lessthan7grainspergallonofhardness,orlessthan120PPM)

b. Freeofcolorandcrystalclear.

c. Ironshouldbelessthan0.3mg/L.

d. Manganeseshouldbelessthan0.05mg/L

e. pHrangeshouldbe6.5to9.5

2. Ifyouaregoingtobeturningoffthewatertothehouseandyouhaveanelectricwaterheater,

shutoffthepowertothewaterheaterbeforebeginninginstallationincasewaterheateris

accidentallydrained.

3. PickasuitablelocationforyourUVSterilizer.Itisbesttomountonawall,whereyoucanbe

suretoremoveoneendoftheUVwithenoughspacetocompletelyremoveandinstalltheUV

lamp(bulb).Choosealocationwhereitwon’tbeexposedtofreezingtemperatures.A

minimumof10PSIisrequired.Maximumpressureis100PSI.

4. Getallofyourplumbingpartstogetherbeforebeginninginstallation.Installationtypicallytakes

1to4hours.Reviewyourpackinglistandmakesureyouhavereceivedallthepartsbefore

beginninginstallation.

BestPracticesforPiping&DrainInstallation

1. Seetypicalinstallationonpage2,Figure1

2. InstallUVwithstainlesssteelflexiblelines,oruseapipeunionsoUVcanbeeasilyremoved

laterifneeded.

3. Ifyouwillbeusingcopperpiping,donotsweatthecopperpipedirectlyontheUV.

4. IfyouaregoingtobeusingPVCpipe,donotconnectPVCfittingsdirecttoUVsterilizer,asthe

UVrayscandegradethePVCpipe.UseastainlesssteellinetoisolatethePVCfromtheUV

sterilizeristhebestpractice.

5. Installaseriesof3ballvalvestocreateaby‐passaroundtheUVasshowninFigure1ifdesired.

6. Installa5micronpre‐filterpriortoUVsterilizer(optional)toremoveveryfineparticlesthat

mightblockthetransmissionofUVraysintothewater.



WonderLightUVSterilizerInstallationGuide

Page3WonderLightUVInstallationGuidewww.cleanwaterstore.comRev040814



Fig1



Installation:



1. InstallUVsterilizerinpiping.

2. Add½to1cupofbleachtopre‐filtertoUV,orshockwelloradddirectlytopipingifpossible.

3. FlushpipinginhomeafterUVwithchlorinatedwatertosanitizepipesinthehome.

4. Forbadlycontaminatedpipingorpipingwithsedimentorscale,thisproceduremayneedtobe

repeatedtokillallbacteriaafterUVuponstart‐up.

5. TurnonUVlampandnoteGREENlightonballast.ThismeanstheUVlamp(‘lamp’iswhatthe

UVlightbulbisoftenreferredto)isoperatingnormal,andwaterflowingthroughUVis

sterilized.



WonderLightUVSterilizerInstallationGuide

Page4WonderLightUVInstallationGuidewww.cleanwaterstore.comRev040814



6. IfballastREDlightislit,thismeansthelampisnotoperating.

7. NOTE:IFLAMPISBURNEDOUT,ALARMWILLSOUNDANDREDLIGHTWILLBELITONTHE

BALLAST.



Maintenance:

ChangeUVlampandcleanquartzsleevewithadampclothonceevery12months.

WhenchangingUVlamp,werecommendthehouseholdpipingissanitizedwithchlorineorhydrogen

peroxide.



Wonder Light Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V User guide

Brand: Wonder Light

Model: Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V

Type: User guide

Download PDF

report

Wonder Light Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V User guide

Wonder Light Ultraviolet Sterilizer Stainless Steel PC-6: 6 GPM 110V User guide

Other documents