NCR RealPOS 70XRT 7403 Site Preparation Manual

NCRRealPOS70XRT(7403)POS

Workstation

Release1.2

SitePreparationGuide



B005‐0000‐1873

IssueC

TheproductdescribedinthisbookisalicensedproductofNCRCorporation.

NCRisaregisteredtrademarkofNCRCorporation.

NCRRealPOSiseitheraregisteredtrademarkoratrademarkofNCRCorporationintheUnitedStatesand/orothercountries.

UniWinDriver,TSHARCandHampshirearetradenamesofHampshireCompany,Inc.Copyright1995‐2008Hampshire

Company,Inc.

ItisthepolicyofNCR

Corporation(NCR)toimproveproductsasnewtechnology,components,software,andfirmware

becomeavailable.NCR,therefore,reservestherighttochangespecificationswithoutpriornotice.

Allfeatures,functions,andoperationsdescribedhereinmaynotbemarketedbyNCRinallpartsoftheworld.Insome

instances,photographsareof

equipmentprototypes.Therefore,beforeusingthisdocument,consultwithyourNCR

representativeorNCRofficeforinformationthatisapplicableandcurrent.

Tomaintainthequalityofourpublications,weneedyourcommentsontheaccuracy,clarity,organization,andvalueofthis

book.

Addresscorrespondenceto:

Manager,InformationSolutions

NCRCorporation



DiscoveryCentre

3FultonRoad

DD24SW

InternetAddress:

http://www.info.ncr.com/eFeedback.cfm



Copyright©2009

ByNCRCorporation

Duluth,GAU.S.A.

AllRightsReserved

i

Preface

Thisisacontractualdocument.Itcontainsimportantwarningsandconfersimportant

legalrightsandobligations.Youareadvisedtoreaditcarefully.

Itistheresponsibilityofthecustomertoensurethatallinstallation preparationsare

completeandincompliancewithNCRspecificationsandrequirementsandall

applicablenational,state,

orlocalcodes,regulations,andlaws.

Safety Requirements

TheNCR7403TerminalmustbeconnectedtoanACoutletthatisneartheterminal

andiseasilyaccessiblebytheoperator.

Warning: Thisunitcontainshazardousvoltagesandshouldonlybeservicedby

qualifiedservicepersonnel.

Theon/offswitchisalogicswitchonly.TheAClinevoltageprimaries

areliveatall

timeswhenthepowercordisconnected.Therefore,disconnecttheACpowercord

beforeopeningtheunittoinstallfeaturesorservicethis terminal.

Peripheral Usage

The7403shouldbeusedonlywithperipheraldevicesthatarerecommendedbyNCR

Corporationandarecertifiedbytheappropriatesafetyagencyforthecountryof

installation(UL,CSA,TUV,VDE).

Safety and Regulatory Information

TheNCRRealPOS70XRTconformstoallapplicablelegalrequirements.Toviewthe

compliancestatementsseetheNCRRealPOSTerminalsSafetyandRegulatoryStatements

(B005‐0000‐1589).

ii

About this Book

ThisbookprovidessitepreparationinformationforNCR7403Terminalcomponents.

PeripheralcomponentandACwiringsitepreparationinformationisNOTprovided

inthisbook.TheassociatedreferencedocumentsarelistedintheRelatedSite

PreparationDatasection.

Thisbookcontainstheinformationnecessaryforthepreparationofasiteconforming

to

theNCRspecifications.Itisveryimportantthatthesitecomplieswiththerequirements

specifiedinthedocumentbecause,oncetheequipmenthasbeeninstalled,deficiencies

insitepreparationortheproblemscausedbythesedeficienciesaremuchmoredifficult

todetectandcorrect.Further,failuretocomplywith

theserequirementsortotake

properstepstoprotectequipmentagainstrisksidentifiedinthisdocumentmaycause

seriousdamagetotheequipmentandtothecustomer

ʹsbusiness.

Inadditiontotheneedtocomplywiththerequirementsspecified,electricalwiring,

andmechanicalsystemsmustalsocomplywithallrelevantcodes,laws,and

regulations.

Itisimportantthatthesitebepreparedbyacustomerorhisagentwhoisfully

conversantwiththespecialrequirementsof

electronicequipment.Theresponsibility

ofensuringthatthesiteispreparedincompliancewiththisdocumentremainswith

thecustomer.

Forinformationandguidancepurposesonly,alistisprovided,ingeneralterms,of

thosemattersforwhichthecustomerisresponsible.Thislistisnotintendedtobe

comprehensive,

andinnowaymodifies,alters,orlimitstheresponsibilityofthe

customerforallaspectsofadequatesitepreparation.

NCRstaffwillbeavailabletoanswerquestionsrelatingtothecontentsofthis

documentexceptwhere:

• acustomerhasbeennotifiedthatafullorpartialconsultancyserviceis

available

and/orthatNCRwillbewillingtoundertakeapreliminaryorfinalsitesurvey

and

• thecustomershallhaveenteredintoaformalcontractwithNCRforprovisionof

thesame.

Nocomment,suggestion,oradviceofferedornotofferedaboutpreparationofthe

sitenoranyinspection

ofthesitewhetherbeforeorafterpreparationistobetakenas

approvalofthelocationofthesiteandequipmen toritspreparationandNCRwillnot

beliableinrespectofanycomment,suggestion,oradvicegivenbyitsstafforin

respecttoanyfailuretogive

advice.

Finally,onlythecustomercanknowthefullextentofdamagewhichmaybecaused

tohisbusinessbyreasonoffailureoftheequipmentwhichistobeinstalled.Forthis

reasonitisthecustomer

ʹsresponsibilitytoascertaintheextentofanypossible

damagetohisexistingorplannedbusiness,andtoeffectfullinsuranceinrespectofit.

iii

Table of Contents

Introduction 1

ModelNumbers 2

CustomerResponsibilities 2

ThirdPartyPeripheralCertification 4

LANCommunications 4

Dimensions 5

7403Terminal(15”)w/Base...................................................................................... 5

7403Terminal(17”)w/Base...................................................................................... 6

7403Terminal(15”,ModularConfiguration)........................................................ 7

7403Terminal(17”,ModularConfiguration)........................................................ 8

IntegratedVFDCustomerDisplay(7403‐K451) ................................................... 8

Integrated12.1”5942CustomerDisplay ............................................................... 9

Integrated15”5942CustomerDisplay ................................................................ 10

Integrated15”5965CustomerDisplay ................................................................ 11

Integrated15”5966CustomerDisplay ................................................................ 12

Integrated6.5”5982CustomerDisplay ............................................................... 13

Integrated5975CustomerDisplay ....................................................................... 14

WallMount(7403‐K320)......................................................................................... 16

WallMount(7403‐K321)......................................................................................... 18

Printers...................................................................................................................... 19

7167ThermalReceiptandImpactSlipPrinter ............................................. 19

7168ThermalReceiptandImpactSlipPrinter ............................................. 19

7198ThermalReceiptPrinter .......................................................................... 20

RemoteDisplays...................................................................................................... 21

596415‐InchTouchLCD.................................................................................. 21

594212.1‐InchLCDMonitor ........................................................................... 21

594215‐InchLCDMonitor .............................................................................. 22

596515‐InchLCDMonitor .............................................................................. 22

596615‐InchLCDMonitor .............................................................................. 23

5975RemoteCustomerDisplays ........................................................................... 24

iv

TallPoleMount................................................................................................. 25

BasePlateMountingHoleDimensions ......................................................... 26

CashDrawers........................................................................................................... 27

NCR2181CashDrawer ................................................................................... 27

NCR2186CompactCashDrawer .................................................................. 27

NCR2189............................................................................................................ 28

ComponentWeights 29

ServiceClearanceRequirements 29

ElectricalRequirements 30

7403ElectricalRequirements ................................................................................. 30

PeripheralPowerRequirements ........................................................................... 30

StoreACWiringRequirements............................................................................. 30

EnvironmentalRequirements 31

BarometricPressure ................................................................................................ 31

Temperature............................................................................................................. 31

Humidity .................................................................................................................. 31

AirflowRequirements 32

ExternalCableRouting 34

ExternalPeripheralSystemCables 35

PrinterCables........................................................................................................... 35

PoweredUSB..................................................................................................... 35

PoweredUSB(PowerOnly) ............................................................................ 35

RS‐232(9‐Pinto9‐Pin)...................................................................................... 35

DisplayCables ......................................................................................................... 36

5975RemoteCustomerDisplay(PoweredRS‐232) ..................................... 36

5975RemoteCustomerDisplay(RS‐232w/PowerConnector).................. 36

PoweredUSB(12V) ......................................................................................... 36

VGA(5942,5964,5965,5975)........................................................................... 37

VGAExtensionCable....................................................................................... 37

VGACable(IntegratedCustomerDisplay) .................................................. 37

USB+Power(5942,5964,5965,5975).............................................................. 38

v

PoweredRS‐232(5975)..................................................................................... 38

Power(594212”) ............................................................................................... 38

Ethernet,10/100/1000BaseT.................................................................................... 39

DualCashDrawer,Y‐Cable................................................................................... 39

PowerCables............................................................................................................ 39

Revision Record

Issue Date Remarks

A Nov2008 Firstissue

B July2009 Release1.1

C Dec2009 Release1.2

NCR RealPOS 70XRT Site Preparation

Introduction

Thisdocumentprovidestheinformationnecessarytopreparea sitetoNCR

specificationspriortoinstallinganNCRRealPOS70

XRT(alsoreferredtoasNCR

7403).Thesitemustbeproperlypreparedbeforetheterminalisinstalled,becausesite

preparationdeficienciesmaybedifficulttodetectandcorrectafterinstallation.

TheNCR7403consistsofseparatepiecesthatmaybecombinedinavarietyof

configurations.TheSystemConfigurationDiagram

sectionidentifiestheindividual

components.Certaincombinationsaremutuallyexclusive.Youmustdeterminethe

equipmentthatwillactuallybeinstalledbeforeproceedingwiththesitepreparation.

26026



2 NCR RealPOS 70XRT Site Preparation

Model Numbers

Major Model Description

7403‐1000 IntelCeleronprocessor,1GBDDR2,NoHardDisk

7403‐1001 IntelCeleronprocessor,512MBDDR2,HardDisk

7403‐1200 IntelDualCoreT1600processor,1GBDDR2,NoHardDisk

7403‐1300 IntelCore2DuoT7500processor,2GBDDR2,NoHardDisk

7403‐F011 LCDTouchDisplay,15”,Capacitive(Usedwith7403Baseonly)

7403‐F015 LCDTouchDisplay,15”,Capacitive(7403Baseorremotemount)

7403‐F017 LCDTouchDisplay,17”,Capacitive(7403Baseorremotemount)

7403‐F025 LCDTouchDisplay,15”,Resistive(7403Baseorremotemount)

NCR RealPOS 70XRT Site Preparation 3

Customer Responsibilities

Beforethesystemcanbeinstalled,thecustomermustperformorprovidethe

following:

• WhenrequiredbyNCR,providetheNCRCustomerServicesrepresentativewith

appropriatedrawingsthatindicate:

• Equipmentlocation

• Sitewiring(powerandcommunications,pathsandlengths)

• Locationofotherequipmentthatmaygenerateelectrical

noise,

electromagneticinterference,orheat

• Makebuildingalterationsnecessarytomeetwiringandothersiterequirements

• Provideandinstallallcommunicationscables,walljacks,specialconnectors,and

associatedhardware

• Provideandinstallnecessarypowerdistributionboxes,conduits,grounds,

lightningprotectiondevices,andassociatedhardware

• Ensureall

applicablecodes,regulations,andlaws(including,butnotlimitedto,

electrical,building,safety,andhealth)aremet

• Provideandinstallauxiliarypowerorotherequipmentasrequired

• Providestorageorserviceareasasrequired

• Meetallsystem/unitenvironmentalrequirements

• Provideandinstallfloorcoveringsandenvironmentsystems

thatlimitorcontrol

staticelectricitybuild‐upanddischarge

Ingeneral,keeptheNCRequipmentareafreefromdust,smoke,lint,andother

particles.Restrictsmoking,eating,anddrinkingaroundtheequipment.Avoid

locatingtheequipmentnearothermachinesthatgenerateink,carbon,andpaperdust

particles.

4 NCR RealPOS 70XRT Site Preparation

Third Party Peripheral Certification

ThirdpartyperipheralsmustbecertifiedwiththePOSterminalorapotentialESD

issuecanoccur.Thirdpartyperipheralsincludeanyelectricallypowered devices

connectedtothePOSterminalthatisnotanNCRbrandedproduct oracertified

solutionadvocatedbyNCR.Examplesofthirdpartyproductsincludeprinters,



externalCD‐ROMdrives,cashdrawers,cigaretteboxes,pinpaddevices,etc.

Peripheralstendtobelesssensitivetoelectrostaticdamagewhendirectlygrounded

throughtheirpowercords.Iftheperipheralispoweredbytheterminalandhasno

dedicatedground,thenalloftheESDenergyiscoupledinto

theportconnection.

Somedevicesmayrequiretheuseofanin‐linegalvanicisolator/surgeprotectorin

ordertopreventproblems.

TheNCRTPP/SCERprocessisdesignedtoevaluatethirdpartyperipheralsand

determinewhetheradditionalprotectivedevicesareneeded.

TheNCRWorkstationandPeripheralsACWiringGuide(BST0‐2115‐53)

contains

additionalinformationonthissubject.



LAN Communications

TheNCR7403TerminalsupportsEthernet10/100/1000baseTLocalAreaNetwork

(LAN)communicationprotocol.ForEthernetcommunicationswiringspecifications,

refertotheNCREthernetCommunicationWiringGuide(BST0‐2118‐82).

NCR RealPOS 70XRT Site Preparation 5

Dimensions

7403 Terminal (15”) w/Base

26404

368 mm

(14.5 in.)

394 mm

(15.5 in.)

240 mm

(9.4 in.)

375 mm

(14.75 in.)

394 mm

(15.5 in.)

381 mm

(15.0 in.)

318 mm

(12.25 in.)

193 mm

(7.6 in.)



6 NCR RealPOS 70XRT Site Preparation

7403 Terminal (17”) w/Base

27697

400 mm

(15.8 in.)

427 mm

(16.8 in.)

240 mm

(9.4 in.)

404 mm

(15.9 in.)

318 mm

(12.25 in.)

193 mm

(7.6 in.)

396 mm

(15.6 in.)

427 mm

(16.5 in.)



NCR RealPOS 70XRT Site Preparation 7

7403 Terminal (15”, Modular Configuration)

26410

328 mm

(12.9 in.)

368 mm

(14.5 in.)

394 mm

(15.5 in.)

70 mm

(2.8 in.)

203 mm

(8.0 in.)

282 mm

(11.1 in.)

240 mm

(9.4 in.)



8 NCR RealPOS 70XRT Site Preparation

7403 Terminal (17”, Modular Configuration)

27698

376 mm

(14.8 in.)

77 mm

(3.3 in.)

203 mm

(8.0 in.)

282 mm

(11.1 in.)

240 mm

(9.4 in.)

400 mm

(15.8 in.)

427 mm

(16.8 in.)



Integrated VFD Customer Display (7403-K451)

26405

318 mm

(12.25 in.)



NCR RealPOS 70XRT Site Preparation 9

Integrated 12.1” 5942 Customer Display

26262

127 mm

(5.0 in.)

305 mm

(12.0 in.)

337 mm

(13.25 in.)

114 mm

(4.5 in.)



10 NCR RealPOS 70XRT Site Preparation

Integrated 15” 5942 Customer Display

26263

140 mm

(5.5 in.)

350 mm

(13.9 in.)

375 mm

(14.75 in.)

107 mm

(4.2 in.)



NCR RealPOS 70XRT Site Preparation 11

Integrated 15” 5965 Customer Display

26267

140 mm

(5.5 in.)

368 mm

(14.5 in.)

394 mm

(15.5 in.)

107 mm

(4.2 in.)



12 NCR RealPOS 70XRT Site Preparation

Integrated 15” 5966 Customer Display

26268

152 mm

(6.0 in.)

394 mm

(15.5 in.)

394 mm

(15.5 in.)

107 mm

(4.2 in.)



Page is loading ...

NCR RealPOS 70XRT 7403 Site Preparation Manual

NCR RealPOS 70XRT 7403 Site Preparation Manual

Related papers

Other documents