Haier HI8LMK User manual

Brand: Haier

Model: HI8LMK

Category: Ice cube makers

Type: User manual



Model#HI6LMK

IssueDate:April2013

120V,60Hz 

MadeinChina

HaierAmerica

NewYork,NY10018

www.HaierAmerica.com



P/N0060517641RevA

IceMaker

UserManual

HI6LMK



TABLE OF CONTENTS

SAFETYINFORMATION

ImportantSafetyInstrucons

SETUP&CARE

SuppliesRequiredforInstallaon

ToolsRequiredforInstallaon

PartsIncluded

InstallaonInstrucons

WaterSupplyConnecon

IceMakerOperaon

Tips&Care

NormalOperangSounds

TROUBLESHOOTING&WARRANTY

IceMakerFillAdjustment

CustomerService

Troubleshoo

ng

LimitedWarranty



3



4

5‐8

9

10



11

12

13

PRODUCT REGISTRATION

ThankyouforpurchasingourHaier

product.Thiseasy‐to‐usemanualwill

guideyouingengthebestuseofyour

product.

Remembertorecordthemodelandserial

numbers.Theyarelocatedonalabelon

theicemaker.

Stapleyourreceipttoyourmanual.Youwillneed

ittoobtainwarrantyservice.



ModelNumber



DateofPurchase



P/N0060517641RevA

PAGE15●NOTES



PAGE14●NOTES



P/N0060517641RevA

IMPORTANT SAFETY INSTRUCTIONS



TOAVOIDELECTRICALSHOCK,WHICHCANCAUSEDEATHORSEVERE

PERSONALINJURY,DISCONNECTTHEPOWERSUPPLYBEFORE

CONNECTINGAWATERSUPPLYLINETOTHEREFRIGERATOR.

!

WARNING



!

WARNING

DONOTPLACEFINGERSORHANDONTHEAUTOMATICICEMAKING

MECHANISMWHILETHEREFRIGERATORISPLUGGEDIN.

THISWILLHELPPROTECTYOUFROMPOSSIBLEINJURYASWELLAS

PREVENTINTERFERENCEWITHMOVINGPARTSOFTHEEJECTOR

MECHANISMANDTHEHEATINGELEMENTTHATRELEASESTHECUBES.

TOAVOIDPROPERTYDAMAGE:

 Coppertubingisrecommendedforthewatersupplyline.Wa ter

supplytubingshouldbe1/4".Plascisnotrecommendedsinceit

greatlyincreasesthepotenalforwaterleaks.

 Donotinstallwatersupplytubinginareaswherethetemperature

fallsbelowfreezing.

 Connecttheicemakertoadrinkablewatersourcethatisnot

connectedtoawater soening system.Chemicalsfromthesoener

maydamagetheicemaker,causingittomalfuncon.

SAVE THESE INSTRUCTIONS

HOUSEHOLD USE ONLY

PAGE3●SAFETYINFORMATION

PROFESSIONALINSTALLATIONISRECOMMENDED.



SUPPLIES REQUIRED FOR INSTALLATION

Thefollowingitemsarerequiredtoinstalltheicemaker.

 ¼‐inchcoppersupplylinewithshutoﬀvalve.

 ¼‐inchbrasscompressionnutandferrule(sleeve).

NOTE:Thecoppertubingandshut‐oﬀvalveshouldbeavailableatyourlocal

hardwareorplumbingsupplystore.Coilenoughtubingin

thebackof

theunittoallowmovementoftherefrigeratorforcleaning

and

service.

¼‐inchCompression

Nut

¼‐inchFerrule

¼‐inchCopper

SupplyLine

TOOLS REQUIRED FOR INSTALLATION

 1/4‐inchsocketwrenchornutdriver

 Phillips&Flatheadscrewdriver

 Adjustablewrench

 Pliers

PARTS INCLUDED

PAGE4●SETUP&CARE

IceBucket

Installaon

Checklist

UserManual

IceMaker

WaterSupply

Clamp

HexHeadScrews

Qty:2

MounngScrew

Washer



P/N0060517641RevA

In‐HomeService‐Whatiscoveredandforhowlong?

Thiswarrantycoversalldefectsinworkmanshipormaterialsoftheautomacicemakerfora

periodof:

12monthslabor

12monthsparts

Thewarrantycommencesonthedatetheitemwaspurchasedandtheoriginalpurchasereceipt

mustbepresentedtotheauthorizedservicecenterbeforewarrantyrepairs

arerendered.

Whatiscovered?

1.Themechanicalandelectricalparts,whichserveasafunconal,purposeofthiskitfora

periodof12mont hs.

Whatwillbedone?

1.Wewillrepairorreplace,atourdiscreonanymechanicalorelectricalpartwhichprovestobe

defecveinnormalusageduringthewarrantyperiodsospeciﬁed.

2.Therewillbenochargetothepurchaserforpartsandlaboronanycovereditemsduringthe

ini

al12monthperiod.

3.Contactyournearestauthorizedservicecenter.Forthenameofthenearestservicecenter

pleasecall1‐877‐337‐3639

THISWARRANTYCOVERSWITHINTHECONTINENTALUNITEDSTATES,PUERTO

RICOANDCANADA.ITDOESNOTCOVERTHEFOLLOWING:

− Damagesfromimproperinstallaon.

− Damagesinshipping.

− Defectsotherthanmanufacturing.

− Damagefrommisuse,abuse,accident,alteraon,lackofpropercareandmaintenanceor

incorrectcurrentorvoltage.

− Damagefromotherthanhouseholduse.

− Damagefromservicebyotherthananauthorizeddealer

orservicecenter.

− Transportaonandshipping.

− Improperinstallaon.Ifyouhaveaninstallaonproblem,contactyourdealerorinstaller.You

areresponsibleforprovidingadequateelectrical,plumbingandotherconnecngfacilies,

includingthewaterlinetotheicemakerandthewaterline

installaon.

− Replacementofhousefusesorresengofcircuitbreakers.

− Failureoftheproductifitisusedforotherthanitsintendedpurposeorusedcommercially.

− Damagetoproductcausedbyaccident,ﬁre,ﬂoodsorActsofGod.



WARRANTORISNOTRESPONSIBLEFORCONSEQUENTIALDAMAGES.THISLIMITED

WARRANTYISGIVENINLIEUOFALLOTHERWARRANTIES,EXPRESSEDOR,INCLUDING

THEWARRANTIESOFMERCHANTABILITYANDFITNESSFORAPARTICULARPURPOSE.

Theremedyprovidedinthiswarrantyisexclusiveandisgrantedinlieuofallotherremedies.This

warrantydoesnotcoverincidentalorconsequenaldamages,sotheabovelimitaonsmaynot

applytoyou.SomeStatesdonotallowlimitaonsonhowlonganimpliedwarrantylasts,

sothe

abovelimitaonsmaynotapplytoyou.Thiswarrantygivesyouspeciﬁclegalrights,andyoumay

haveotherrights,whichvary,fromstatetostate.

HaierAmerica

NewYork,NY10018

LIMITED WARRANTY

PAGE13●TROUBLESHOOTING&WARRANTY



PAGE12●TROUBLESHOOTING&WARRANTY

TROUBLESHOOTING

PROBLEM CAUSE/SOLUTION

Noiceproduced

Ensurethatrefrigeratorispluggedintopower

source

Wirecontrolarmisfullyraised.SeePage9.

Checkthaticemakerispluggedintoelectricalsocket

inrearoffreezercompartment.SeePages5‐6.

Watersupplyisturnedoﬀordisconnected.

Disconnectrefrigeratorfrompowersource,

remove

rearaccesscover,thenchecktoseethatwatervalve

ispluggedintowiringharnessinrearboom

compartment.

Checkwaterconneconsonwatervalve.SeePage8.

Low/slow

iceproducon

Adjustfreezertemperaturetocolderseng.See

RefrigeratorUserManualforinstrucons.

Check

forleaksorkinksinwatertubingonrearof

refrigerator.

Increasewaterﬁllamount.SeePage11.

Smallicecubes Increasewaterﬁllamount.SeePage11.

Waterleakinfreezer

Checkthatﬁlltubeisalignedintoﬁllcuponrearof

icemaker.SeePage7.

Decrease

waterﬁllamount.SeePage11.

Checkforleaksinwatertubingonrearof

refrigerator.

Disconnectrefrigeratorfrompowersupply,remove

rearcompartmentcover,thencheckwater

conneconsonwatervalve.

Waterleakunder

refrigerator



P/N0060517641RevA

INSTALLATION INSTRUCTIONS

4.Removeelectricalsocketcoverbygraspingbothsidesofcoverandpulling

lesidetowardsfrontofrefrigerator.

(Donotdiscardelectricalplugcover)

1

2

1.Moverefrigeratorawayfromwallandunplug.

2.Removefreezershelfbyliingupandslidingitoutoffreezercompartment.

PAGE5●SETUP&CARE

3.Removeplascplugaboveelectricalsocketbygraspingﬁrmlyandpulling

endofplugdown.

FreezerShelf



PAGE6●SETUP&CARE

INSTALLATION INSTRUCTIONS CONT.

6.Inserticemakerelectricalplugintosocketusingnotchesinsocketandplug

tohelpwithalignment,thenpressﬁrmly.

7.Re‐installelectricalplugcoverbypushingcoverdownonplug,inserngtab

intoslotonrearcoverandthensnappingfrontprongsintosquareholes.

5.Posionicemakerharnessinicemakerhookasshownbelow:

IceMaker

Harness

Hook

AlignmentNotch

Tab

Slot

FrontProng

SquareHole



P/N0060517641RevA

PAGE11●TROUBLESHOOTING&WARRRANTY

CUSTOMER SERVICE

IMPORTANT

DONOTRETURNTHISPRODUCTTOTHESTORE

Ifyouhaveaproblemwiththisproduct,pleasecontactthe

HaierCustomerSasfaconCenterat1‐877‐337‐3639

DATEDPROOFOFPURCHASE,MODELNUMBERANDSERIAL

NUMBERREQUIREDFORWARRANTYSERVICE

CUSTOMER

SERVICE

SERVICIO

AL CLIENTE

Hotline

1-877-337-3639

1.Useﬂatheadscrewdrivertopryfrontcoveroficemaker.Donotdiscard

frontcover.

2.UseaPhillipsscrewdrivertoturnﬁlladjustmentscrewclockwiseto

DECREASEwaterﬁllamount.Turnscrewcounter‐clockwisetoINCREASE

waterﬁllamount.

FillAdjustment

Screw

ICE MAKER FILL ADJUSTMENT

Ifyouricemakerismakingsmallicecubesorisn’tproducingasasfactory

amountofice,itispossibletoimprovethisbyadjusngtheamountofwater

usedtoﬁlltheicecubetrayintheicemaker.

3.Replacefrontcoveroficemaker.

NOTE:

Increasingthewaterﬁllamountcouldcausewatertooverﬂowoutof

theicemaker.Makehalf‐turnadjustmentsunlicecubesizeorice

produconamountissasfactory.Besuretocloselymonitorthefreezer

compartmentforwateroverﬂowaeradjusngthe

ﬁlladjustment

screw.

IceMakerBoom

THESEINSTRUCTIONSSHOULDONLYBEUSEDIFTHEHOMEHASUNUSUALLY

LOWWATERPRESSURETHATRESULTSINLOWICEPRODUCTIONORSMALL

ICECUBESIZE.CHANGESTOHOMEPLUMBINGCOULDAFFECTICEMAKERFILL

AMOUNTANDRESULTINOVERFLOWEDWATERINTHEFREEZER

COMPARTMENT.



PAGE10●SETUP&CARE

NOTE:Ittakesapproximately24hoursfortheicemakertoproduceice.

Newplumbingmaycauseicediscoloraonandpoorﬂavor.

Discardicemadeintheﬁrst24hours.

ICE MAKER OPERATION

Tostoptheicemaker,lithewirearmunlitclicksandlocksintheOFF

(raised)posion.TheicemakerturnsOFFautomacallywhentheice

containerisfull.Ifyourmodelhasanadjustablefreezershelf,placetheshelf

sothatwhentheicecontainer

isfull,theicewillhitthewirecontrolarm.

 Waterqualitydeterminesicequality.Donotconnecttheicemakertowater

thatissoened.Chemicalsfromamalfunconingsoenercandamagethe

icemaker.

 Icestoredtoolongmaydevelopanoddﬂavor.Emptythecontainerand

makesurethewirearmisintheON(lowered)posion.Theicemakerwill

thenproduceice.

 KeepthewirearminOFFposionunltherefrigeratorisconnectedtothe

watersupplyorwheneverthewatersupplyisturnedOFF.

CAUTION:

 Donotwashtheicebucketinyourdishwasher.

 Besuretostoptheicemakerwhencleaningthefreezeroronvacaon.

 IftheicemakerhastobeturnedOFFforalongperiodofme,turnthe

watersupplyvalvetotheclosedposion.

 Donotstoreanythingontopoforintheicemakerortheicebucket.

TIPS & CARE

NORMAL OPERATING SOUNDS

Thefollowingsoundsarenormalwhentheicemakerisoperang:

 Motorrunning(insidefreezercompartment)

 Icedroppingintoicebucket(insidefreezercompartment)

 Runningwater(insidefreezercompartment)

 Watervalveopeningorclosing(clickingfromrearofrefrigerator)



P/N0060517641RevA

PAGE7●SETUP&CARE

9.Hangicemakerfrommounngposts.

8.Posionﬁlltubeintoslotinrearoficemakerﬁllcup.

FillTube

FillCup

10.Usehexheadscrewandwashertosecuretabonboomoficemakerto

insideoffreezer.

INSTALLATION INSTRUCTIONS CONT.



INSTALLATIONINSTRUCTIONSCONT.

PAGE8●SETUP&CARE

15.Insertsupplylinefullyintowatervalveinlet.Slideferrule(sleeve)intovalve

inletandﬁnger‐ghtencompressionnutontovalvebeingcarefulnotto

cross‐thread.Tightenanotherhalf‐turnwithawrench.Donotover‐ghten.

DonotuseTeﬂontapeonthreads.

ValveInlet

WaterSupplyLine

14.Locatewatervalveonrearofrefrigerator.Valveprotrudesslightlythrough

rearcompartmentcover.

13.Re‐installfreezershelfonlowestrailasshownandplaceicebucketunder

theicemaker.RaisewirecontrolarmonicemakertoOFFposion.

WireControlArm

LowestRail



P/N0060517641RevA

PAGE9●SETUP&CARE

1.Turnoﬀwatersupplyatshut‐oﬀvalve.

2.Connectcopperwatersupplylinetohouseholdwatersystem.

3.TurnONwatersupplyandghtenanyconneconsthatleak.

4.Coilexcesswatersupplylinebehindrefrigerator,asshownbelowandarrangecoils

sotheydonotvibrateor

wearagainstothersurfaces.Usewatersupplyclampand

hexheadscrewtosecurewatersupplylinetorearofrefrigerator.

WaterSupply

Clamp

HexHead

Screw

6.Reconnectrefrigeratortopowersupply.

7.MoverefrigeratorbackintoplaceandlevelitusinginstruconsinUserManual.

8.TurnicemakerONbyloweringwirecontrolarm.

WireControlArm

WATER SUPPLY CONNECTION



Thiswatersupplyinstallaonisnotcoveredunderwarrantyby

therefrigeratororicemakermanufacturer(s).Followtheseinstrucons

carefullytominimizetheriskofexpensivewaterdamage.

!

WARNING

SuppliesRequiredforInstallaon:

Accesstoahouseholdcoldwaterlinewithwaterpressurebetween20psiand120psi.

Awatersupplylinemadeof1/4‐inchOutsideDiameter,coppertubing.Todetermine

thelengthofthecoppertubingneeded,youwillneedtomeasurethedistancefrom

theicemakerwatervalveatthebackoftherefrigeratortoyourcoldwaterline.Then

addapproximately7feetfortherefrigeratortobemovedoutforcleaningand

service.

Ashut‐oﬀvalvetoconnectthewatersupplylinetoyourhouseholdwatersystem.

NOTE:Donotuseaself‐piercingtypeshut‐oﬀvalve.

Acompressionnutandferrule(sleeve)forconnecngthewatersupplylinetotheice

makerinletvalve.Seepage4forpicture.

Haier HI8LMK User manual

Brand: Haier

Model: HI8LMK

Category: Ice cube makers

Type: User manual

Download PDF

report

Haier HI8LMK User manual

Haier HI8LMK User manual

Related papers

Other documents