Yardistry YM11578 Installation guide

Brand: Yardistry

Model: YM11578

Type: Installation guide

This manual is also suitable for

YM11579

 1 support@yardistrystructures.com

YARDISTRY BAR

Installation and Operating Instructions – YM11578 & YM11579

Yardistry – North America

Toll Free Customer Support: 1.888.509.4382

info@yardistrystructures.com

www.yardistrystructures.com

Yardistry / Selwood Products – Europe

Customer Support: +44 1284 852569

parts@selwoodproducts.com

www.selwoodproducts.com

Revised 02/11/2013

1 support@yardistrystructures.com

78-1/2”

 2 support@yardistrystructures.com

Important Safety Notice!

Yardistrycomponentsareintendedforprivacy,decorativeandornamentaluseonly.

Product is NOT INTENDED for the following:

 •Asafetybarriertopreventunsupervisedaccesstopools,hottubs,spasorponds.

 •Asloadbearingsupportforabuilding,structure,heavyobjectsorswings.

 •Usedinstructuresthattrapwind,rainorsnowthatwouldcreateextraloadonthe

product.

Permanent structures may require a building permit. Asthepurchaserandorinstaller

ofthisproductyouareadvisedtoconsultlocalplanning,zoningandbuildinginspection

departmentsforguidanceonapplicablebuildingcodesand/orzoningrequirements.

Wood is NOT ame retardant and will burn.Grills,repitsandchimineasareare

hazardifplacedtooclosetoaYardistrystructure.Consultuser’smanualofthegrill,re

pitorchimneaforsafedistancesfromcombustiblematerials.

Wear gloves to avoid injuryfrompossiblesharpedgesofindividualelementsbefore

assembly.

During installation, follow all safety warnings provided with your tools and use

OHSA approved safety glasses.Somestructuresmayrequiretwoormorepeopleto

installsafely.

Check for underground utilities before digging or driving stakes into the ground!

General Information:WoodcomponentsaremanufacturedwithCedar(C.Lanceolata)

whichisprotectedwithfactoryappliedwater-basedstain.Knots,smallchecks(cracks)

andweatheringarenaturallyoccurringanddonotaffectthestrengthoftheproduct.

Annualapplicationofawater-basedwaterrepellentsealantorstainwillhelpreduce

weatheringandchecks.

www.yardistrystructures.com

Questions?

Calltollfreeorwriteusat:

1(888)509-4382

[email protected]

PatentsPending

General Information

 3 support@yardistrystructures.com

Limited Warranty

Yardistry warrants that this product is free from defect in materials and workmanship

for a period of one year from the original date of purchase. In addition, all lumber is

warranted for 5 years against rot and decay. This warranty applies to the original owner

and registrant and is non-transferable.

Regular maintenance is required to assure the integrity of your product and is a requirement of

the warranty. This warranty does not cover any inspection cost.

This Limited Warranty does not cover:

• Labor for replacement of any defective item(s);

• Incidental or consequential damages;

• Cosmetic defects which do not affect performance or integrity;

• Vandalism; improper use or installation; acts of nature;

• Actsofnatureincludingbutnotlimitedtowind,storms,hail,oods,excessivewater 

 exposure;

• Minor twisting, warping, checking, or any other natural occurring properties of wood that

do not affect performance or integrity.

Yardistryproductshavebeendesignedforsafetyandquality.Anymodicationsmadetothe

original product could damage the structural integrity of the product leading to failure and

possibleinjury.Yardistrycannotassumeanyresponsibilityformodiedproducts.Furthermore,

modicationvoidsanyandallwarranties.

This product is warranted for RESIDENTIAL USE ONLY. Yardistry disclaims all other

representations and warranties of any kind, express or implied.

This Warranty gives you specic legal rights. You may have other rights as well which vary from state to state or province to

province. This warranty excludes all consequential damages, however, some states do not allow the limitation or exclusion of

consequential damages, and therefore this limitation may not apply to you.

 4 support@yardistrystructures.com

Instructions for Proper Maintenance

YourYardistrystructureisdesignedandconstructedofqualitymaterials.Aswithall

outdoorproductsitwillweatherandwear.Tomaximizetheenjoyment,safetyandlife

ofyourstructureitisimportantthatyou,theowner,properlymaintainit.

Symbols:

Throughouttheseinstructionssymbolsareprovidedinthetop,right-handcornerofthepage.

If you dispose of your Yardistry structure: Pleasedisassembleanddisposeofyour

unitsothatitdoesnotcreateanyunreasonablehazardsatthetimeitisdiscarded.Be

suretofollowyourlocalwasteordinances.

HARDWARE:

• Checkmetalpartsforrust.Iffound,sandandrepaintusinganon-leadpaint

complyingwith16CFR1303.

• Inspectandtightenallhardwareaftercompletionofassembly;afterrstmonthof

use;andthenannually.Donotover-tightenastocausecrushingandsplinteringof

wood.

• Checkforsharpedgesorprotrudingscrewthreads,addwashersifrequired.

WOODPARTS:

• Unprotectedtheywillappearweatheredovertime.Periodicapplicationofan

exteriorwaterrepellentorstain(water-based)willhelpimproveappearanceand

life.

• Checkallwoodmembersfordeterioration,structuraldamageandsplintering.

Sanddownsplintersandreplacedeterioratedwoodmembers.Aswithallwood,

somecheckingandsmallcracksingrainisnormal

• TapeMeasure

• CarpentersLevel

• StandardorCordlessDrill

• #1,#2&#3PhillipsorRobertson

BitsorScrewdriver

• 7/16”WrenchorSocket

Assembly Guides

• 8’StepLadder

• SafetyGlasses

• AdultHelper

• Gloves

• HardHat

Tools Required:

• UseHelp,wherethisisshown,2or3people

arerequiredtosafelycompletethisstep.

Toavoidinjuryordamagetotheassembly

makesuretogetsomehelp.

• Useameasuringtapetoassureproper

location

• Pre-drillapilotholebeforefastening

screworlagtopreventsplittingofwood.

 5 support@yardistrystructures.com

6pc.

#8 x 2-1/4" Wood Screw - (Y06416-521)

9pc.

#8 x 2" Wood Screw - (Y06416-520)

2pc.

#12 x 3" Wood Screw - (Y06416-630)

Part Identification (Reduced Part Size) Part Identification (Reduced Part Size)

1-3/8" x 2-1/2"

1-1/2" x 5"

Nominal Size

1" x 4"

1" x 5"

2" x 5-1/2"

2" x 3"

2" x 2"

1-1/2" x 4"

Actual Size

5/8" x 3-3/8"

5/8" x 4-1/2"

1" x 3-1/2"

1-1/2" x 1-1/2"

Part Identification (Reduced Part Size)

Part Identification (Actual Size)

2 x 2 x 81-1/2"

1pc.

108

Bottom Inside 38.1 x 38.1 x 2070.1mm - (Y50113-108)

1 x 4 x 79-3/4"

1pc.

109

Front 15.9 x 85.7 x 2025.7mm - (Y50113-109)

2 x 5-1/2 x 16-3/32"

2pc.

110

Gusset 38.1 x 127 x 409.1mm - (Y50113-110)

2 x 5-1/2 x 16-3/32"

1pc.

111

Gusset Middle 38.1 x 127 x 409.1mm - (Y50113-111)

2 x 2 x 14"

3pc.

112

Joist Gusset 38.1 x 38.1 x 355.6mm - (Y50113-112)

2 x 3 x 14"

2pc.

113

Joist 34.9 x 63.5 x 355.6mm - (Y50113-113)

1 x 4 x 11"

2pc.

114

Side 15.9 x 85.7 x 279.4mm - (Y50113-114)

1 x 4 x 10-1/2"

2pc.

115

Side Short 15.9 x 85.7 x 266.7mm - (Y50113-115)

1 x 5 x 78-1/2"

3pc.

116

Top 15.9 x 114.3 x 1993.9mm - (Y50113-116)

1-1/2 x 4 x 81-1/2"

1pc.

117

Top Inside 25.4 x 88.9 x 2070.1mm - (Y50113-117)

43pc.

#8 x 1-1/2" Wood Screw - (Y06416-512)

20pc.

#8 x 2-1/2" Wood Screw - (Y06416-530)

 6 support@yardistrystructures.com

PRODUCTNUMBER:YM11578/YM11579

CARTONI.D.STAMP:_____________(Box1)

CARTONI.D.STAMP:_____________(Box2)

CARTONI.D.STAMP:_____________(Box3)

STOP STOPSTOP STOP

1-888-509-4382

support@yardistrystructures.com

C. Readtheassemblymanualcompletely,payingspecialattentiontoANSIwarnings;

notes;andsafety/maintenanceinformationonpages1-4.

 

•Followtheinstructionsinorder.



•Thisstructureisdesignedtobeassembledandinstalledideallybytwopeople,

DONOTattempttoinstallalone.

 •Considertheslopeofelevationwhereyouplantoinstallthestructure.Also,checkfor

gas,telephone,otherutilitiesorsprinklerlinelocationspriortoexcavatinganyholes.

D. 

Beforeyoudiscardyourcartonsllouttheformbelow.



•ThecartonI.D.stampislocatedontheendofeachcarton.

 •Pleaseretainthisinformationforfuturereference.Youwillneedthisinformationifyou

contacttheConsumerRelationsDepartment.

•Eachstepindicateswhichboltsand/orscrewsyouwillneedforassembly,aswellas

anyatwashers,lockwashers,t-nutsorlocknuts.

A.

Thisisthetimeforyoutoinventoryallyourhardware,woodandaccessories,

referencingthepartsidenticationsheets.Thiswillassistyouwithyourassembly.

Step 1: Inventory Parts - Read This Before Starting Assembly

B. Ifthereareanymissingordamagedpiecesoryouneedassistancewith

assemblypleasecontacttheconsumerrelationsdepartmentdirectly.Callus

beforegoingbacktothestore.

 7 support@yardistrystructures.com

Step 2: Assemble panels side-by-side

HardwareWood Parts

A:Assemblepanelsside-by-side.

B:Insertmaleintofemale.Slidedownuntilushwithadjacentpanel.

C:Securewith#8x2-1/4”Woodscrews.Usefactorydrilledholes.

#8x2-1/4”WoodScrew

Fig. 2.1

Fig. 2.2

Fig. 2.3

4 x Panels

6 x #8 x 2-1/4” Wood Screw

 8 support@yardistrystructures.com

Step 3: Attach Top Inside and Bottom to Panel Assembly

HardwareWood Parts

View from back

TopInside

#8x2-1/2”WoodScrew

4Places

1-1/2”BothEnds

BottomushtoPanel

1-1/2”BothEnds

#8x2”WoodScrew

4Places

2-1/8”

View from back

BottomInside

A: PlaceTopInsideontopofassembledpanelsandattachwith4#8x2”WoodScrews.Thereshouldbeanover-

hangof1-1/2”onbothends.MeasurementfromtopofTopInsidetothetopofpaneltopshouldbe2-1/8”

PanelTop

B: PlaceBottomInsideushtothebottomofassembledpanelsandattachwith4#8x2-1/2”WoodScrews.

Thereshouldbeanoverhangof1-1/2”onbothends.

Fig. 3.1

Fig. 3.2

Fig. 3.3

1 x Top Inside (25.4 x 88.9 x 2070.1mm)

1 x Bottom Inside (38.1 x 38.1 x 2070.1mm)

4 x #8 x 2-1/2” Wood Screw

4 x #8 x 2” Wood Screw

 9 support@yardistrystructures.com

Hardware

Step 4: Attach Panel Assembly to Room

78-1/2”

#12x3”WoodScrew

2Places

#8x2-1/2”WoodScrew

4Places

endsush

topost

3-5/8”

(075)

Engineered

PanelPost

A: Measure3-5/8”upfromground(Fig.4.2)andattachPanelAssemblytoRoomusing2#12x3”Woodscrews

intoBottominside,makingsurethattheendsareushtopost.Thensecureusing42-1/2”WoodScrewsintoTop

InsideasshowninFig.4.2.

Note: The distance between the posts is 78-1/2” as shown in Fig. 4.1

Fig. 4.1

Fig. 4.2

2 x #12 x 3” Wood Screw

4 x #8 x 2-1/2” Wood Screw

 10 support@yardistrystructures.com

Step 5: Attach Joists to Panel Assembly

Joist

2places

#8x2”WoodScrew

5places

Noteorientation

ofnotch

JoistGusset

3places

Hardware

Wood Parts

OutsideView

A: Attach3JoistGussettoTopInsideusing3#8x2”WoodScrews.Noteorientationofholes.Nextattach2Joist

toTopInsideusing2#8x2”WoodScrews.PleasenotetheorientationofthenotchasshowninFig.5.2.

Fig. 5.1

Fig. 5.2

3 x Joist Gusset (38.1 x 38.1 x 355.6mm)

2 x Joist (34.9 x 63.5 x 355.6mm)

5 x #8 x 2” Wood Screw

Noteorientation

ofholes

 11 support@yardistrystructures.com

Step 6: Attach 1st Top board to Assembly

Hardware

Wood Parts

#8x1-1/2”WoodScrew

10places

Topushonall

3sides

A: Attach1Topboardusing10#8x1-1/2”WoodScrews,besurethatitisushtoTopInsideandbothPosts.

Fig. 6.1

Fig. 6.2

1 x Top (15.9 x 114.3 x 1993.9mm) 10 x #8 x 1-1/2” Wood Screw

 12 support@yardistrystructures.com

Step 7: Attach Side (or Side Short) to Assembly

#8x1-1/2”WoodScrew

2perside

EndsFlush

5/8”

UseSide for rooms with 3”

Post anduse Side Short for

rooms with 3-1/2” Post

FlushtoTop

FlushtoPost

A: Attach2SideboardstoeachJoistGussetusing4#8x1-1/2”WoodScrews.BesurethatthetopsofSidesare

5/8”abovetheJoistGusset,aswellasbothendsareushandthatSideisushtoPostasshowninFig.7.1and

7.2

Note: The Joist should sit 5/8” from the top of Side or Side Short as shown in Fig. 7.2

Fig. 7.1

Fig. 7.2

HardwareWood Parts

2 x Side or Side Short ( 15.9 x 85.7 x 279.4mm) or (15.9 x 85.7 x 266.7mm) 4 x #8 x 1-1/2” Wood Screw

Noteholeorientation

 13 support@yardistrystructures.com

Step 8: Attach Front to Assembly

HardwareWood Parts

#8x1-1/2”WoodScrew

7places

Front

5/8”

FrontushtoSide

(orSideShort)

A: PlaceFrontushtobothSide(orSideShort)andattachusing7#8x1-1/2”WoodScrews.1screwintoeach

JoistGusset,and2willbeusedtoattachtoeachJoist.

Note: The Joist should sit 5/8” down from the top of Front as shown in Fig. 8.3

Joist

JoistGusset

Joist

JoistGusset

Fig. 8.1

Fig. 8.2

Fig. 8.3

1 x Front (15.9 x 85.7 x 2025.7mm) 7 x #8 x 1-1/2” Wood Screw

Front

 14 support@yardistrystructures.com

Attach Gussets to Assembly

Step 9: Attach Gussets to Assembly

HardwareWood Parts

#8x1-1/2”WoodScrew

2places

Gusset Gusset

#8x2-1/2”WoodScrew

12places

GussetMiddle

A: Attach2Gussetusing1#8x1-1/2”WoodScrewspersidethrougheitherSideorSideShort.Thenattach

GussetMiddleasshowninFig.9.2using4#8x2-1/2”WoodScrews.RepeatthisforbothGussetusing4#8x

2-1/2”WoodScrewsperGusset.

Fig. 9.1

Fig. 9.2

2 x Gusset (38.1 x 127 x 409.1 mm)

1 x Gusset Middle (38.1 x 127 x 409.1 mm)

2 x #8 x 1-1/2” Wood Screw

12 x #8 x 2-1/2” Wood Screw

 15 support@yardistrystructures.com

Attach 2 Top boards

to Assembly

20 Places

#8 x 1-1/2" Wood Screw

Top

flush to Front

evenly space

Step 10: Attach 2 Top boards to Assembly

HardwareWood Parts

Fig. 10.1

A: Evenlyspace2TopBoardstoassemblyasshowninFig.10.2.SecurethemtotheJoists(JoistGusset&Joist)

using20#8x1-1/2”WoodScrews.10perboard.BesurethatthesecondTopboardisushtoFront.

Fig. 10.2

2 x Top (15.9 x 114.3 x 1993.9mm) 20 x #8 x 1-1/2” Wood Screw

 16 support@yardistrystructures.com

 17 support@yardistrystructures.com

NOTES

 18 support@yardistrystructures.com

NOTES

 19 support@yardistrystructures.com

NOTES

 20 support@yardistrystructures.com

YARDISTRY

Consumer Registration Card

First Name Initial Last Name

Street Apt. No.

City State/Province ZIP/Postal Code

Country Telephone Number

E-Mail Address

Model Name Model Number (Box Labels)

Date Purchase Purchased From

How would you rate this product for quality?

Excellent

Very Good

Average

Below Average

Poor

How would you rate this product for ease of assembly?

Excellent

Very Good

Average

Below Average

Poor

How would you rate our instructions?

Excellent

Very Good

Average

Below Average

Poor

How would you rate the quality of packaging?

Excellent

Very Good

Average

Below Average

Poor

Would you recommend the purchase of our products to friends and family?

Yes

Comments:

MM / DD / YY

REVISION: 10/18/11

MAIL TO:

Yardistry c/o Solowave Design

375 Sligo Road W.

Mount Forest, Ontario, Canada

N0G 2L0

Attention: Customer Service

CUT ALONG LINE

Yardistry would like to say Thank You for your time and feed-

Yardistry YM11578 Installation guide

Brand: Yardistry

Model: YM11578

Type: Installation guide

This manual is also suitable for

YM11579

Download PDF

report

Yardistry YM11578 Installation guide

This manual is also suitable for

Yardistry YM11578 Installation guide

Related papers

Other documents