IEI Technology AFOLUX M Series User manual

AFL M Series LCD Monitor

Page i

IEI Technology Corp.

User Manual

MODEL:

AFOLUX M Series

7"~19" Multimedia Touch Monitor with Built-in Speakers,

VGA, Component, Composite, S-Video and DVI-D Input

IP 64 Protection

Rev. 1.12 – 10 March, 2011

AFL M Series LCD Monitor

Page ii

Revision

Date Version

Changes

10 March, 2011 1.12 Updated Section 37.2 37-inch to 12.1-inch Driver

Installation and Configuration

29 September, 2009 1.11 Added screw torque warning

05 December, 2007 1.10 Added AFL-10M model information

Added USB touch screen feature to 7” to 12.1” models

Added USB touch screen models for 15” to 19” models

Added smartOSD function and smartOSD appendix

Added 7” to 12.1” model driver installation procedures

Added screen calibration procedures

30 June, 2007 1.00 Initial release

AFL M Series LCD Monitor

Page iii

Copyright

COPYRIGHT NOTICE

The information in this document is subject to change without prior notice in order to

improve reliability, design and function and does not represent a commitment on the part

of the manufacturer.

In no event will the manufacturer be liable for direct, indirect, special, incidental, or

consequential damages arising out of the use or inability to use the product or

documentation, even if advised of the possibility of such damages.

This document contains proprietary information protected by copyright. All rights are

reserved. No part of this manual may be reproduced by any mechanical, electronic, or

other means in any form without prior written permission of the manufacturer.

TRADEMARKS

IBM PC is a registered trademark of International Business Machines Corporation. INTEL

is a registered trademark of INTEL Corporation. Other product names mentioned herein

are used for identification purposes only and may be trademarks and/or registered

trademarks of their respective owners.

AFL M Series LCD Monitor

Page iv

Manual Conventions

WARNING!

Warnings appear where overlooked details may cause damage to the equipment or result

in personal injury. Warnings should be taken seriously. Warnings are easy to recognize.

The word “warning” is written as “WARNING,” both capitalized and bold and is followed by

text. The text is the warning message. A warning message is shown below:

WARNING:

This is an example of a warning message. Failure to adhere to warning

messages may result in permanent damage to the AFL series monitor

or personal injury to the user. Please take warning messages seriously.

CAUTION!

Cautionary messages should also be heeded to help reduce the chance of losing data or

damaging the AFL series monitor. Cautions are easy to recognize. The word “caution” is

written as “CAUTION,” both capitalized and bold and is followed. The italicized text is the

cautionary message. A caution message is shown below:

AFL M Series LCD Monitor

Page v

CAUTION:

This is an example of a caution message. Failure to adhere to cautions

messages may result in permanent damage to the AFL series monitor.

Please take caution messages seriously.

NOTE:

These messages inform the reader of essential but non-critical information. These

messages should be read carefully as any directions or instructions contained therein can

help avoid making mistakes. Notes are easy to recognize. The word “note” is written as

“NOTE,” both capitalized and bold and is followed by text. The text is the cautionary

message. A note message is shown below:

NOTE:

This is an example of a note message. Notes should always be read.

Notes contain critical information about the AFL series monitor. Please

take note messages seriously.

AFL M Series LCD Monitor

Page vi

Packing List

NOTE:

If any of the components listed in the checklist below are missing,

please do not proceed with the installation. Contact the IEI reseller or

vendor you purchased the AFL M series from or contact an IEI sales

representative directly. To contact an IEI sales representative, please

send an email to 0[email protected].

The items listed below should all be included in the AFL M series package.

z 1 x AFL M Series industrial LCD monitor

z 1 x Power adapter

z 1 x Power cord

z 1 x DVI cable

z 1 x VGA cable

z 1 x Component cable

z 1 x Audio cable

z 1 x User manual and driver CD

z 1 x Remote control

z 1 x Screw set

z 1 x Wire strain bands

z 1 x Touch Panel RS-232 Cable / Touch Pen / Driver CD-ROM (T-R

models only)

z 1 x Touch Panel USB Cable (for AFL-07M/T-R, AFL-08MH/T-R,

AFL-10M/T-R, and AFL-12M/T-R)

Images of the above items are shown in Chapter 383H383H5.3.3.

AFL M Series LCD Monitor

Page vii

Table of Contents

1H1H1 INTRODUCTION.......................................................................................................... 384H384H1

2H2H1.1 AFL M SERIES LCD MONITOR OVERVIEW ................................................................ 385H385H3

3H3H1.1.1 Added Features .................................................................................................. 386H386H3

4H4H1.1.2 Standard Features.............................................................................................. 387H387H3

5H5H1.1.3 IEI smartOSD..................................................................................................... 388H388H4

6H6H1.1.4 Model Variations................................................................................................ 389H389H4

7H7H1.2 EXTERNAL OVERVIEW................................................................................................ 390H390H5

8H8H1.2.1 Front View.......................................................................................................... 391H391H5

9H9H1.2.2 Rear View........................................................................................................... 392H392H6

10H10H1.3 SERIES SPECIFICATIONS.............................................................................................. 393H393H7

11H11H1.4 CERTIFICATIONS......................................................................................................... 394H394H8

12H12H2 MECHANICAL OVERVIEW...................................................................................... 395H395H9

13H13H2.1 INTRODUCTION......................................................................................................... 396H396H10

14H14H2.2 FRONT VIEW ............................................................................................................ 397H397H10

15H15H2.3 BOTTOM PANEL........................................................................................................ 398H398H12

16H16H2.3.1 AFL-07M/08MH/10M/12M Connectors.......................................................... 399H399H12

17H17H2.3.2 AFL-15M/17M/19M Connectors...................................................................... 400H400H12

18H18H2.4 PHYSICAL DIMENSIONS............................................................................................ 401H401H13

19H19H2.4.1 General Physical Dimensions.......................................................................... 402H402H13

20H20H2.4.2 AFL-07M Physical Dimensions....................................................................... 403H403H15

21H21H2.4.3 AFL-08MH Physical Dimensions.................................................................... 404H404H16

22H22H2.4.4 AFL-10M Physical Dimensions....................................................................... 405H405H17

23H23H2.4.5 AFL-12M Physical Dimensions....................................................................... 406H406H18

24H24H2.4.6 AFL-15M Physical Dimensions....................................................................... 407H407H19

25H25H2.4.7 AFL-17M Physical Dimensions....................................................................... 408H408H20

26H26H2.4.8 AFL-19M Physical Dimensions....................................................................... 409H409H21

27H27H2.5 MOUNTING KITS ...................................................................................................... 410H410H22

28H28H2.6 MOUNTING OPTIONS................................................................................................ 411H411H22

29H29H2.6.1 Panel Mounting................................................................................................ 412H412H22

30H30H2.6.2 Rack and Cabinet Mounting ............................................................................ 413H413H23

AFL M Series LCD Monitor

Page viii

31H31H2.6.3 Wall Mounting.................................................................................................. 414H414H23

32H32H2.6.4 Monitor Arm or Stand Mounting...................................................................... 415H415H24

33H33H3 LCD AND TOUCH PANEL SPECIFICATIONS ..................................................... 416H416H25

34H34H3.1 LCD SPECIFICATIONS............................................................................................... 417H417H26

35H35H3.1.1 LCD Overview ................................................................................................. 418H418H26

36H36H3.1.2 AFL-07M LCD Specifications.......................................................................... 419H419H26

37H37H3.1.3 AFL-08MH LCD Specifications....................................................................... 420H420H27

38H38H3.1.4 AFL-10M LCD Specifications.......................................................................... 421H421H28

39H39H3.1.5 AFL-12M LCD Specifications.......................................................................... 422H422H29

40H40H3.1.6 AFL-15M LCD Specifications.......................................................................... 423H423H30

41H41H3.1.7 AFL-17M LCD Specifications.......................................................................... 424H424H31

42H42H3.1.8 AFL-19M LCD Specifications.......................................................................... 425H425H32

43H43H3.2 OPTIONAL TOUCH PANELS ....................................................................................... 426H426H33

44H44H3.2.1 Touch Panel Models......................................................................................... 427H427H33

45H45H3.2.2 Touch Panel Dimensions.................................................................................. 428H428H34

46H46H3.2.3 Touch Panel Specifications.............................................................................. 429H429H35

47H47H3.2.4 Touch Panel RS-232 Controller Specifications................................................ 430H430H36

48H48H3.2.5 Touch Panel USB Controller Specifications.................................................... 431H431H37

49H49H3.3 POWER ADAPTERS.................................................................................................... 432H432H38

50H50H4 AD BOARD................................................................................................................... 433H433H39

51H51H4.1 AV-9962 AD BOARD OVERVIEW.............................................................................. 434H434H40

52H52H4.1.1 AV-9962 AD Board Connectors ....................................................................... 435H435H41

53H53H4.1.2 AV-9962 AD Board Layout............................................................................... 436H436H42

54H54H4.1.3 AV-9962 Peripheral Interface Connectors....................................................... 437H437H42

55H55H4.1.4 AV-9962 Rear Panel Connectors ..................................................................... 438H438H43

56H56H4.1.5 AV-9962 On-board Jumpers............................................................................. 439H439H43

57H57H4.2 AV-9962 INTERNAL PERIPHERAL CONNECTORS ....................................................... 440H440H44

58H58H4.2.1 Audio Output Connector.................................................................................. 441H441H44

59H59H4.2.2 Auto-Dimming Connector................................................................................ 442H442H45

60H60H4.2.3 Debug Port Connector..................................................................................... 443H443H46

61H61H4.2.4 OSD and LED Connector ................................................................................ 444H444H47

62H62H4.2.5 LED Indicator and Remote Sensor Connector ................................................ 445H445H48

63H63H4.2.6 Backlight Inverter Interface Connector........................................................... 446H446H49

AFL M Series LCD Monitor

Page ix

64H64H4.2.7 IR Sensor Connector........................................................................................ 447H447H50

65H65H4.2.8 LVDS Signal Output Connector (AFL-08MH/10M/12M only)........................ 448H448H51

66H66H4.2.9 Power Output Connector................................................................................. 449H449H52

67H67H4.2.10 Remote Control Connector ............................................................................ 450H450H53

68H68H4.2.11 TTL Signal Output Connector (AFL-07M Model Only)................................. 451H451H54

69H69H4.2.12 Touch Panel Connector.................................................................................. 452H452H55

70H70H4.3 AV-9962 ON-BOARD JUMPERS ................................................................................. 453H453H57

71H71H4.3.1 LCD Panel Voltage Select Jumper................................................................... 454H454H58

72H72H4.3.2 Touch Screen Select Jumper............................................................................. 455H455H58

73H73H4.4 AV-9962 EXTERNAL (REAR PANEL) CONNECTORS................................................... 456H456H59

74H74H4.4.1 Audio Jack........................................................................................................ 457H457H59

75H75H4.4.2 Component Video Connector ........................................................................... 458H458H60

76H76H4.4.3 Composite Video Connector............................................................................. 459H459H61

77H77H4.4.4 DC 12V Connector........................................................................................... 460H460H61

78H78H4.4.5 RS-232 Touch Panel Connector....................................................................... 461H461H62

79H79H4.4.6 S-Video Connector ........................................................................................... 462H462H62

80H80H4.4.7 USB Touch Panel Connector ........................................................................... 463H463H63

81H81H4.4.8 VGA Connector................................................................................................ 464H464H64

82H82H4.5 AV-6962 AD BOARD OVERVIEW.............................................................................. 465H465H65

83H83H4.5.1 AV-6962 AD Board Connectors ....................................................................... 466H466H66

84H84H4.5.2 AV-6962 AD Board Layout............................................................................... 467H467H67

85H85H4.5.3 AV-6962 Peripheral Interface Connectors....................................................... 468H468H68

86H86H4.5.4 AV-6962 Rear Panel Connectors ..................................................................... 469H469H68

87H87H4.5.5 AV-6962 On-board Jumpers............................................................................. 470H470H69

88H88H4.6 AV-6962 INTERNAL PERIPHERAL CONNECTORS ....................................................... 471H471H70

89H89H4.6.1 Audio Output Connector.................................................................................. 472H472H70

90H90H4.6.2 Auto-Dimming Connector................................................................................ 473H473H71

91H91H4.6.3 Debug Port Connector..................................................................................... 474H474H71

92H92H4.6.4 Backlight Inverter Interface Connector........................................................... 475H475H72

93H93H4.6.5 IR Sensor Connector........................................................................................ 476H476H73

94H94H4.6.6 LVDS Signal Output Connector....................................................................... 477H477H74

95H95H4.6.7 OSD and LED Connector ................................................................................ 478H478H75

96H96H4.6.8 Power Input Connector.................................................................................... 479H479H76

97H97H4.6.9 Power Output Connector................................................................................. 480H480H77

98H98H4.6.10 Remote Control Connector ............................................................................ 481H481H78

AFL M Series LCD Monitor

Page x

99H99H4.6.11 RS-232 Serial Port Connector........................................................................ 482H482H79

100H100H4.6.12 USB Connector .............................................................................................. 483H483H80

101H101H4.7 AV-6962 ON-BOARD JUMPERS ................................................................................. 484H484H81

102H102H4.7.1 LCD Panel Voltage Select Jumper................................................................... 485H485H82

103H103H4.8 AV-6962 EXTERNAL (REAR PANEL) CONNECTORS................................................... 486H486H83

104H104H4.8.1 Audio Jack........................................................................................................ 487H487H83

105H105H4.8.2 Component Video Connector ........................................................................... 488H488H84

106H106H4.8.3 Composite Video Connector............................................................................. 489H489H85

107H107H4.8.4 Digital Input Connector................................................................................... 490H490H86

108H108H4.8.5 DC 12V Connector........................................................................................... 491H491H87

109H109H4.8.6 RS-232 Touch Panel Connector....................................................................... 492H492H87

110H110H4.8.7 S-Video Connector ........................................................................................... 493H493H88

111H111H4.8.8 USB Touch Panel Connector ........................................................................... 494H494H89

112H112H4.8.9 VGA Connector................................................................................................ 495H495H89

113H113H5 INSTALLATION ......................................................................................................... 496H496H91

114H114H5.1 I ............................................................................................................................... 497H497H91

115H115H5.2 NSTALLATION PRECAUTIONS .................................................................................... 498H498H92

116H116H5.3 UNPACKING.............................................................................................................. 499H499H93

117H117H5.3.1 Packaging ........................................................................................................ 500H500H93

118H118H5.3.2 Unpacking Procedure ...................................................................................... 501H501H93

119H119H5.3.3 Packing List ..................................................................................................... 502H502H94

120H120H5.4 PRE-INSTALLATION PREPARATION ............................................................................ 503H503H96

121H121H5.4.1 Tools................................................................................................................. 504H504H96

122H122H5.5 CONNECTORS ........................................................................................................... 505H505H96

123H123H5.5.1 VGA Connector................................................................................................ 506H506H96

124H124H5.5.2 12V Power Connector...................................................................................... 507H507H97

125H125H5.5.3 DVI-D Connector (AFL-15M/17M/19M Models Only)................................... 508H508H97

126H126H5.5.4 Optional RS-232 Touch Panel Connector........................................................ 509H509H98

127H127H5.5.5 Optional USB Touch Panel Connector............................................................ 510H510H99

128H128H5.6 MOUNTING THE AFL SERIES INDUSTRIAL MONITOR................................................ 511H511H99

129H129H5.6.1 Mounting Kits................................................................................................. 512H512H100

130H130H5.6.2 Panel Mounting.............................................................................................. 513H513H100

131H131H5.6.2.1 Standard Panel Mounting........................................................................ 514H514H100

132H132H5.6.3 Wall Mounting................................................................................................ 515H515H103

AFL M Series LCD Monitor

Page xi

133H133H5.6.4 AFL-07M/08MH/10M/12M Wall Mounting................................................... 516H516H104

134H134H5.6.4.1 AFL-15M/17M/19M Wall Mounting...................................................... 517H517H106

135H135H5.6.5 Monitor Stand Installation............................................................................. 518H518H108

136H136H5.6.6 Arm Mounting ................................................................................................ 519H519H109

137H137H6 ON-SCREEN-DISPLAY (OSD) CONTROLS ......................................................520H520H112

138H138H6.1 USER MODE OSD STRUCTURE................................................................................521H521H113

139H139H6.1.1 OSD Buttons....................................................................................................522H522H113

140H140H6.1.2 OSD Menu Structure.......................................................................................523H523H114

141H141H6.2 USING THE OSD......................................................................................................524H524H116

142H142H6.2.1 Image Menu ....................................................................................................525H525H116

143H143H6.2.2 Display Menu..................................................................................................526H526H117

144H144H6.2.3 PiP Menu.........................................................................................................527H527H118

145H145H6.2.4 Color Menu.....................................................................................................528H528H119

146H146H6.2.5 System Menu .................................................................................................. 529H529H120

147H147H6.2.5.1 OSD Configuration................................................................................. 530H530H121

148H148H6.2.5.2 Auto-Brightness (Auto-Dimming) Configuration................................... 531H531H122

149H149H6.3 REMOTE CONTOL................................................................................................... 532H532H123

150H150H7 SOFTWARE DRIVERS............................................................................................ 533H533H124

151H151H7.1 INTRODUCTION....................................................................................................... 534H534H125

152H152H7.2 7-INCH TO 12.1-INCH DRIVER INSTALLATION AND CONFIGURATION....................... 535H535H125

153H153H7.2.1 RS-232 or USB Touch Screen......................................................................... 536H536H125

154H154H7.2.2 7-inch to 12.1-inch Touch Panel Driver Installation..................................... 537H537H126

155H155H7.2.3 Change the Touch Screen Interface................................................................ 538H538H129

156H156H7.2.4 7-inch to 12.1-inch Touch Panel Driver Configuration................................. 539H539H130

157H157H7.3 15-INCH TO 19-INCH DRIVER INSTALLATION AND CONFIGURATION........................ 540H540H131

158H158H7.3.1 RS-232 or USB Touch Screen......................................................................... 541H541H131

159H159H7.3.2 15-inch to 19-inch Touch Panel Driver Installation...................................... 542H542H131

160H160H7.3.3 15-inch to 19-inch Touch Panel Driver Configuration.................................. 543H543H138

161H161H7.4 CALIBRATING THE TOUCH SCREEN......................................................................... 544H544H138

162H162H8 GASKET REPLACEMENT..................................................................................... 545H545H142

163H163H8.1 GASKET REPLACEMENT ......................................................................................... 546H546H143

164H164HA SAFETY PRECAUTIONS....................................................................................... 547H547H145

AFL M Series LCD Monitor

Page xii

165H165HA.1 SAFETY PRECAUTIONS .......................................................................................... 548H548H146

166H166HA.1.1 General Safety Precautions........................................................................... 549H549H146

167H167HA.1.2 Anti-static Precautions.................................................................................. 550H550H147

168H168HA.2 MAINTENANCE AND CLEANING PRECAUTIONS...................................................... 551H551H147

169H169HA.2.1 Maintenance and Cleaning............................................................................ 552H552H147

170H170HA.2.2 Cleaning Tools............................................................................................... 553H553H148

171H171HB CERTIFICATIONS .................................................................................................. 554H554H149

172H172HB.1 ROHS COMPLIANT ................................................................................................ 555H555H150

173H173HB.2 IP 64 COMPLIANT FRONT PANEL ........................................................................... 556H556H150

174H174HC AUTO-DIMMING..................................................................................................... 557H557H151

175H175HC.1 AUTO-DIMMING CONFIGURATIONS........................................................................ 558H558H152

176H176HC.1.1 Default Settings............................................................................................. 559H559H152

177H177HC.1.2 OSD Control.................................................................................................. 560H560H153

178H178HD SMARTOSD.............................................................................................................. 561H561H154

179H179HD.1 IEI SMARTOSD QUICK INSTALLATION GUIDE ....................................................... 562H562H155

180H180HD.2 PRE-INSTALLATION NOTICE................................................................................... 563H563H155

181H181HD.3 SOFTWARE ILLUSTRATION ..................................................................................... 564H564H155

182H182HD.3.1 EDID Page.................................................................................................... 565H565H157

183H183HD.3.2 Image Page ................................................................................................... 566H566H158

184H184HD.3.3 Display Page (for analog signal).................................................................. 567H567H159

185H185HD.3.4 Color Page.................................................................................................... 568H568H160

186H186HD.3.5 PIP Page (For MDM/AFLUX series)........................................................... 569H569H161

187H187HD.3.6 System Page .................................................................................................. 570H570H162

188H188HD.3.7 User Page...................................................................................................... 571H571H163

189H189HD.3.8 About Page.................................................................................................... 572H572H164

190H190HD.4 INSTALL SOFTWARE............................................................................................... 573H573H164

191H191HD.5 SMARTOSD FAQ................................................................................................... 574H574H170

192H192HE HAZARDOUS MATERIALS DISCLOSURE ....................................................... 575H575H173

193H193HE.1 HAZARDOUS MATERIAL DISCLOSURE TABLE FOR IPB PRODUCTS CERTIFIED AS

ROHS COMPLIANT UNDER 2002/95/EC WITHOUT MERCURY ..................................... 576H576H174

AFL M Series LCD Monitor

Page xiii

List of Figures

194H194HFigure 1-1: AFL-12M Front View..................................................................................577H577H6

195H195HFigure 1-2: AFL-15M Front View..................................................................................578H578H6

196H196HFigure 1-3: AFL-12M Rear View ...................................................................................579H579H7

197H197HFigure 2-1: AFL-12M Front View................................................................................580H580H10

198H198HFigure 2-2: AFL-15M Front View................................................................................581H581H11

199H199HFigure 2-3: AFL-12M Bottom Panel View..................................................................582H582H13

200H200HFigure 2-4: AFL-15M Bottom Panel View..................................................................583H583H13

201H201HFigure 2-5: AFL-07M Physical Dimensions (millimeters)........................................584H584H15

202H202HFigure 2-6: AFL-08MH Physical Dimensions (millimeters) .....................................585H585H16

203H203HFigure 2-7: AFL-10M Physical Dimensions (millimeters)........................................586H586H17

204H204HFigure 2-8: AFL-12M Physical Dimensions (millimeters)........................................587H587H18

205H205HFigure 2-9: AFL-15M Physical Dimensions (millimeters)........................................588H588H19

206H206HFigure 2-10: AFL-17M Physical Dimensions (millimeters)......................................589H589H20

207H207HFigure 2-11: AFL-19M Physical Dimensions (millimeters)......................................590H590H21

208H208HFigure 2-12: Typical Wall Mounting...........................................................................591H591H24

209H209HFigure 4-1: AV-9962 AD Board Overview..................................................................592H592H40

210H210HFigure 4-2: AV-9962 Connector and Jumper Locations..........................................593H593H42

211H211HFigure 4-3: Audio Output Connector Location.........................................................594H594H45

212H212HFigure 4-4: Auto-dimming Connector Location .......................................................595H595H46

213H213HFigure 4-5: Debug Port Connector Location ............................................................596H596H47

214H214HFigure 4-6: OSD and LED Connector Location ........................................................597H597H48

215H215HFigure 4-7: LED and Remote Sensor Connector Location......................................598H598H49

216H216HFigure 4-8: Backlight Inverter Connector Location.................................................599H599H50

217H217HFigure 4-9: IR Sensor Connector Location...............................................................600H600H51

218H218HFigure 4-10: LVDS Signal Output Connector Location ...........................................601H601H52

219H219HFigure 4-11: Power Output Connector Locations....................................................602H602H53

220H220HFigure 4-12: Remote Control Connector Location...................................................603H603H54

221H221HFigure 4-13: TTL Signal Output Connector Location ..............................................604H604H55

222H222HFigure 4-14: Touch Panel Connector Location ........................................................605H605H56

223H223HFigure 4-15: Jumpers..................................................................................................606H606H57

224H224HFigure 4-16: AV-9962 Jumper Locations ..................................................................607H607H57

AFL M Series LCD Monitor

Page xiv

225H225HFigure 4-17: AV-9962 External (Rear Panel) Connectors........................................608H608H59

226H226HFigure 4-18: Component Video Connector Pinout Locations ................................609H609H60

227H227HFigure 4-19: S-Video Connector Pinout Locations..................................................610H610H63

228H228HFigure 4-20: USB Touch Panel Connector................................................................611H611H64

229H229HFigure 4-21: VGA Connector Pinout Locations........................................................612H612H64

230H230HFigure 4-22: AV-6962 AD Board Overview................................................................613H613H65

231H231HFigure 4-23: AV-6962 Connector and Jumper Locations........................................614H614H67

232H232HFigure 4-24: Audio Output Connector Location.......................................................615H615H70

233H233HFigure 4-25: Auto-dimming Connector Location.....................................................616H616H71

234H234HFigure 4-26: Debug Port Connector Location ..........................................................617H617H72

235H235HFigure 4-27: Backlight Inverter Connector Location...............................................618H618H73

236H236HFigure 4-28: IR Sensor Connector Location.............................................................619H619H74

237H237HFigure 4-29: LVDS Signal Output Connector Location ...........................................620H620H75

238H238HFigure 4-30: OSD and LED Connector Location......................................................621H621H76

239H239HFigure 4-31: Power Output Connector Locations....................................................622H622H77

240H240HFigure 4-32: Power Input Connector Locations.......................................................623H623H78

241H241HFigure 4-33: Remote Control Connector Location...................................................624H624H79

242H242HFigure 4-34: RS-232 Serial Port Connector Location ..............................................625H625H80

243H243HFigure 4-35: USB Connector Location......................................................................626H626H81

244H244HFigure 4-36: Jumpers..................................................................................................627H627H81

245H245HFigure 4-37: Jumper Locations..................................................................................628H628H82

246H246HFigure 4-38: AV-6962 External (Bottom Panel) Connectors....................................629H629H83

247H247HFigure 4-39: Component Video Connector Pinout Locations ................................630H630H84

248H248HFigure 4-40: DVI-D Connector Pinout Locations......................................................631H631H86

249H249HFigure 4-41: S-Video Connector Pinout Locations..................................................632H632H88

250H250HFigure 4-42: USB Touch Panel Connector................................................................633H633H89

251H251HFigure 4-43: VGA Connector Pinout Locations........................................................634H634H90

252H252HFigure 5-1: VGA Connector........................................................................................635H635H97

253H253HFigure 5-2: 12V Power Connector..............................................................................636H636H97

254H254HFigure 5-3: DVI Connector..........................................................................................637H637H98

255H255HFigure 5-4: Optional RS-232 Touch Panel Connector .............................................638H638H98

256H256HFigure 5-5: USB Touch Panel Connector..................................................................639H639H99

257H257HFigure 5-6: AFL-07M Panel Opening ...................................................................... 640H640H101

258H258HFigure 5-7: AFL-08MH Panel Opening.................................................................... 641H641H101

259H259HFigure 5-8: AFL-12M Panel Opening ...................................................................... 642H642H101

AFL M Series LCD Monitor

Page xv

260H260HFigure 5-9: Insert the Monitor ................................................................................. 643H643H102

261H261HFigure 5-10: Tighten the Panel Mounting Clamp Screws (AFL-12M).................. 644H644H103

262H262HFigure 5-11: Wall-mounting Bracket....................................................................... 645H645H104

263H263HFigure 5-12: Chassis Support Screws.................................................................... 646H646H105

264H264HFigure 5-13: Secure the Monitor............................................................................. 647H647H106

265H265HFigure 5-14: Wall-mounting Bracket....................................................................... 648H648H107

266H266HFigure 5-15: Chassis Support Screws.................................................................... 649H649H108

267H267HFigure 5-16: Monitor Stand Mounting .................................................................... 650H650H109

268H268HFigure 5-17: AFL-07M/AFL-08MH Arm Mounting Retention Screw Holes.......... 651H651H110

269H269HFigure 5-18: AFL-10M/12M Arm Mounting Retention Screw Holes..................... 652H652H110

270H270HFigure 5-19: AFL-15M/17M/19M Arm Mounting Retention Screw Holes............. 653H653H111

271H271HFigure 6-1: OSD Control Buttons............................................................................ 654H654H113

272H272HFigure 6-2: Image Menu........................................................................................... 655H655H116

273H273HFigure 6-3: Display Menu......................................................................................... 656H656H117

274H274HFigure 6-4: PiP Menu................................................................................................ 657H657H118

275H275HFigure 6-5: Color Menu............................................................................................ 658H658H119

276H276HFigure 6-6: System Menu......................................................................................... 659H659H120

277H277HFigure 6-7: OSD Configuration ............................................................................... 660H660H121

278H278HFigure 6-8: Auto Brightness Configuration........................................................... 661H661H122

279H279HFigure 6-9: Remote Control..................................................................................... 662H662H123

280H280HFigure 7-1: Setup Icon.............................................................................................. 663H663H127

281H281HFigure 7-2: Welcome Screen................................................................................... 664H664H127

282H282HFigure 7-3: License Agreement............................................................................... 665H665H128

283H283HFigure 7-4: Initiate Install......................................................................................... 666H666H128

284H284HFigure 7-5: Installation Starts.................................................................................. 667H667H128

285H285HFigure 7-6: Finish Installation................................................................................. 668H668H129

286H286HFigure 7-7: Control Panel ........................................................................................ 669H669H130

287H287HFigure 7-8: Remove Touch Screen Driver ............................................................. 670H670H130

288H288HFigure 7-9: Driver CD Pop Up Screen..................................................................... 671H671H132

289H289HFigure 7-10: Install Shield Wizard Preparation...................................................... 672H672H133

290H290HFigure 7-11: Welcome Screen................................................................................. 673H673H133

291H291HFigure 7-12: Install PS/2 Interface Driver............................................................... 674H674H134

292H292HFigure 7-13: Install PS/2 Interface Driver............................................................... 675H675H135

293H293HFigure 7-14: Touch Monitor/USB Touch Controller Confirmation ...................... 676H676H135

294H294HFigure 7-15: Controller Installation Directory........................................................ 677H677H136

AFL M Series LCD Monitor

Page xvi

295H295HFigure 7-16: Program Icon Directory...................................................................... 678H678H137

296H296HFigure 7-17: Installing.............................................................................................. 679H679H137

297H297HFigure 7-18: Installation Complete ......................................................................... 680H680H138

298H298HFigure 7-19: PenMount Monitor Icon...................................................................... 681H681H139

299H299HFigure 7-20: PenMount Monitor Popup Menu ....................................................... 682H682H139

300H300HFigure 7-21: Configuration Screen......................................................................... 683H683H140

301H301HFigure 7-22: Calibration Initiation Screen.............................................................. 684H684H141

302H302HFigure 7-23: Calibration Screen.............................................................................. 685H685H141

303H303HFigure 8-1: Gasket Replacement ............................................................................ 686H686H143

AFL M Series LCD Monitor

Page xvii

List of Tables

304H304HTable 1-1: AFL Series Model Variants ..........................................................................................687H687H5

305H305HTable 1-2: AFL M Series Specifications........................................................................................688H688H8

306H306HTable 2-1: General Physical Dimensions ...................................................................................689H689H14

307H307HTable 2-2: AFL Series Mounting Kits..........................................................................................690H690H22

308H308HTable 2-3: Panel Mounting Clamps.............................................................................................691H691H23

309H309HTable 2-4: Rack Mounting Holes.................................................................................................692H692H23

310H310HTable 3-1: AFL-07M LCD Specifications.....................................................................................693H693H27

311H311HTable 3-2: AFL-08MH LCD Specifications..................................................................................694H694H28

312H312HTable 3-3: AFL-10M LCD Specifications.....................................................................................695H695H28

313H313HTable 3-4: AFL-12M LCD Specifications.....................................................................................696H696H29

314H314HTable 3-5: AFL-15M LCD Specifications.....................................................................................697H697H30

315H315HTable 3-6: AFL-17M LCD Specifications.....................................................................................698H698H31

316H316HTable 3-7: AFL-19M LCD Specifications.....................................................................................699H699H32

317H317HTable 3-8: Touch Panel Models...................................................................................................700H700H33

318H318HTable 3-9: Touch Panel Dimensions (mm).................................................................................701H701H34

319H319HTable 3-10: Touch Panel Specifications.....................................................................................702H702H35

320H320HTable 3-11: Touch Panel RS-232 Controller Specifications .....................................................703H703H36

321H321HTable 3-12: Touch Panel USB Controller Specifications..........................................................704H704H37

322H322HTable 3-13: Power Adapter Specifications.................................................................................705H705H38

323H323HTable 4-1: AV-9962 Peripheral Interface Connectors................................................................706H706H43

324H324HTable 4-2: AV-9962 Rear Panel Connectors...............................................................................707H707H43

325H325HTable 4-3: AV-9962 On-board Jumpers ......................................................................................708H708H44

326H326HTable 4-4: Audio Output Connector Pinouts .............................................................................709H709H44

327H327HTable 4-5: Auto-dimming Connector Pinouts............................................................................710H710H45

328H328HTable 4-6: Debug Port Connector Pinouts.................................................................................711H711H46

329H329HTable 4-7: OSD and LED Connector Pinouts.............................................................................712H712H48

330H330HTable 4-8: LED and Remote Sensor Connector Pinouts ..........................................................713H713H48

331H331HTable 4-9: Backlight Inverter Connector Pinouts......................................................................714H714H49

332H332HTable 4-10: IR Sensor Connector Pinouts..................................................................................715H715H50

333H333HTable 4-11: LVDS Signal Output Connector Pinouts................................................................716H716H52

334H334HTable 4-12: Power Output Connector Pinouts (CN15)..............................................................717H717H52

AFL M Series LCD Monitor

Page xviii

335H335HTable 4-13: Remote Control Connector Pinouts .......................................................................718H718H53

336H336HTable 4-14: TTL Signal Output Connector Pinouts...................................................................719H719H55

337H337HTable 4-15: Touch Panel Connector Pinouts.............................................................................720H720H56

338H338HTable 4-16: LCD Panel Voltage Select Jumper Settings...........................................................721H721H58

339H339HTable 4-17: LCD Panel Power Input Jumper Settings...............................................................722H722H58

340H340HTable 4-18: Audio Jack Pinouts ..................................................................................................723H723H60

341H341HTable 4-19: Component Video Connector Pinouts....................................................................724H724H60

342H342HTable 4-20: Composite Signal Input BNC Connector (J7) Pinouts..........................................725H725H61

343H343HTable 4-21: Composite Signal Input Connector (J6) Pinouts...................................................726H726H61

344H344HTable 4-22: DC 12V Connector Pinouts......................................................................................727H727H62

345H345HTable 4-23: RS-232 Touch Panel Connector Pinouts................................................................728H728H62

346H346HTable 4-24: S-Video Connector Pinouts.....................................................................................729H729H63

347H347HTable 4-25: USB Touch Panel Connector Pinouts ....................................................................730H730H63

348H348HTable 4-26: VGA Connector Pinouts...........................................................................................731H731H64

349H349HTable 4-27: AV-6962 Peripheral Interface Connectors..............................................................732H732H68

350H350HTable 4-28: AV-6962 Rear Panel Connectors.............................................................................733H733H69

351H351HTable 4-29: AV-6962 On-board Jumpers....................................................................................734H734H69

352H352HTable 4-30: Audio Output Connector Pinouts ...........................................................................735H735H70

353H353HTable 4-31: Auto-dimming Connector Pinouts..........................................................................736H736H71

354H354HTable 4-32: Debug Port Connector Pinouts...............................................................................737H737H72

355H355HTable 4-33: Backlight Inverter Connector Pinouts....................................................................738H738H73

356H356HTable 4-34: IR Sensor Connector Pinouts..................................................................................739H739H73

357H357HTable 4-35: LVDS Signal Output Connector Pinouts................................................................740H740H75

358H358HTable 4-36: OSD and LED Connector Pinouts...........................................................................741H741H76

359H359HTable 4-37: Power Output Connector Pinouts (CN15)..............................................................742H742H77

360H360HTable 4-38: Power Input Connector Pinouts (CN15).................................................................743H743H77

361H361HTable 4-39: Remote Control Connector Pinouts .......................................................................744H744H78

362H362HTable 4-40: RS-232 Serial Port Connector Pinouts...................................................................745H745H79

363H363HTable 4-41: USB Connector Pinouts...........................................................................................746H746H80

364H364HTable 4-42: LCD Panel Voltage Select Jumper Settings...........................................................747H747H82

365H365HTable 4-43: Audio Jack Pinouts ..................................................................................................748H748H84

366H366HTable 4-44: Component Video Connector Pinouts....................................................................749H749H84

367H367HTable 4-45: Composite Signal Input BNC Connector (J10) Pinouts........................................750H750H85

368H368HTable 4-46: Composite Signal Input Connector (J9) Pinouts...................................................751H751H85

369H369HTable 4-47: DVI-D Connector Pinouts.........................................................................................752H752H86

AFL M Series LCD Monitor

Page xix

370H370HTable 4-48: DC 12V Connector Pinouts......................................................................................753H753H87

371H371HTable 4-49: RS-232 Touch Panel Connector Pinouts................................................................754H754H88

372H372HTable 4-50: S-Video Connector Pinouts.....................................................................................755H755H88

373H373HTable 4-51: USB Touch Panel Connector Pinouts ....................................................................756H756H89

374H374HTable 4-52: VGA Connector Pinouts...........................................................................................757H757H90

375H375HTable 5-1: External Peripheral Interface Connectors................................................................758H758H96

376H376HTable 5-2: Optional RS-232 Touch Panel Connector Pinouts..................................................759H759H98

377H377HTable 5-3: USB Touch Panel Connector Pinouts ......................................................................760H760H99

378H378HTable 5-4: Mounting Kits........................................................................................................... 761H761H100

379H379HTable 5-5: AFL Series VESA Standard..................................................................................... 762H762H103

380H380HTable 6-1: OSD Menus............................................................................................................... 763H763H115

AFL M Series LCD Monitor

Page xx

THIS PAGE IS INTENTIONALLY LEFT BLANK

Page is loading ...

IEI Technology AFOLUX M Series User manual

IEI Technology AFOLUX M Series User manual

Related papers

Other documents