Sea Ray 205 Sport Owner's manual

Sea Ray
Brand
Sea Ray
Model
205 Sport
Category
Air blowers/dryers
Type
Owner's manual

This manual is also suitable for

Specific
Information
Manual
205 Sport
Manual Part Number: MRP 1902268
INDEX
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
205 Sport i
Manual Part Number: MRP 1902268
205 SPORT SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances .................3
5. Function and Location of Through-Hull Cutouts ......4
6. Helm, Gauge & Switch Layout .................................5
7. Deck Layout .............................................................6
8. Cleats .......................................................................7
9. Navigation and Anchor Lights ..................................7
10. Bilge Layout ...........................................................7
11. Fuel System ...........................................................7
12. Entertainment System ...........................................8
13. Canvas ................................................................... 8
14. Water Sports Tower ................................................ 9
15. Swim Platform and Ladder .................................... 9
16. Electrical Schematic ..............................................9
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
205 Sport
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
205 Sport i
Manual Part Number: MRP 1902268
205 SPORT SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances .................3
5. Function and Location of Through-Hull Cutouts ......4
6. Helm, Gauge & Switch Layout .................................5
7. Deck Layout .............................................................6
8. Cleats .......................................................................7
9. Navigation and Anchor Lights ..................................7
10. Bilge Layout ...........................................................7
11. Fuel System ...........................................................7
12. Entertainment System ...........................................8
13. Canvas ................................................................... 8
14. Water Sports Tower ................................................ 9
15. Swim Platform and Ladder .................................... 9
16. Electrical Schematic ..............................................9
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
205 Sport
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
1
205 SPORT OWNERS MANUAL
205 Sport
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 205 Sport
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
(FIG. 1.2)
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGNATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
205 SP
7
545
kg.
C
Manual Part Number: MRP 1902268
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or
water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near
boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while
engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting
something in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring,
mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and
hold on to rails or boat structure.
! WARNING
PASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPATION DURING NORMAL
OPERATION)
205 Sportii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
1
205 SPORT OWNERS MANUAL
205 Sport
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 205 Sport
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
(FIG. 1.2)
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGNATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
205 SP
7
545
kg.
C
Manual Part Number: MRP 1902268
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or
water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near
boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while
engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting
something in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring,
mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and
hold on to rails or boat structure.
! WARNING
PASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPATION DURING NORMAL
OPERATION)
205 Sportii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
3
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
205 SPORT SPECIFICATIONS
BO AT DIMENSIONS AND CLEARANCES
B
O AT DIMENSIONS AND CLEARANCES
(CONT’D)(FIG. 3.2)
(F
IG. 3.1)
Length overall.......................................21ft./6.40m
Maximum beam.....................................8ft./2.44m
Bow to transom/keel
intersection...............................18ft. 6 in./5.65m
Draft (stern drive down)..........................33"/84cm
(stern drive up)...............................17"/43cm
Fuel capacity...............................37 gal./140 Liters
Dry Weight................................3,265 lbs/1,481 kg
Dead rise..........................................................20º
18’ 6 5/8”
21’ 0”
17”
FULL LOAD WATER LINE
33”
5' 1 1/8"
4' 3/8"
11 3/8”
8’
6’ 11 1/4”
NOTE: DIMENSIONS CAN
VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS
2
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(FIG. 2.1)
205 SP
7
545
kg.
C
THIS TAG REPLACES DOMESTIC
CERTIFICATION TAG (LEFT)
WHEN BOAT IS ORDERED WITH
INTERNATIONAL (CE) OPTION.
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
!
INSIDE ENGINE BOX ON AFT BULKHEAD
MRP 722041 SR-87
INDICATIONSOF EXCESSIVE EXPOSURE TO “CO” CONCENTRATIONS
MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
AVOID RIST OF INJURY OR DEATH, SHUTOFF ENGINE NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM SUNPAD OR BOARDING LADDER.
DANGER
!
WARNING
!
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”.
Visibility can be limited by high boat trim angles, persons and gear. Such issues
are considered under the control of the operator.
USE CAUTION WITH SKIER IN TOW AS TOW ROPE MAY BACKLASH
INTO COCKPIT WHEN RELEASED.
NOTICE: It is recommended that all occupants wear approved
Personal flotation Devices (PFD’s).
CARBON MONOXIDE CAN BE FATAL. In all gasoline powered boats, engine
exhaust systems produce colorless and odorless carbon monoxide gas “CO”
Direct prolonged exposure can result in CO poisoning which may be harmful or
FATAL. To prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate
ventilation through utilization of cabin hatches and walk-through windshields
to increase the accumulation of CO in and about the boat and require the
operator’s particular attention:
1. Operation at slow speeds or dead in water.
2. Operation with a high bow angle attitude.
3. Utilization of canvas tops, side curtains and back curtains.
4. Contributing climatic conditions, such as a head wind.
5. Operation of engines and/or generator in confined spaces or a dockside.
6. Any blockage of hull exhaust outlets.
MRP 1744762 SR-766
s).#!3%/&&)2%$/./4/0%.%.').%"/8/2
COMPARTMENT
WARNING
s3(54$/7.%.').%3'%.%2!4/2!.$",/7%23
s#/.4).5/53,9$)3#(!2'%%.4)2%#/.4%.43/&(!,/.
OR CO
2
PORTABLE FIRE EXTINGUISHER
THR OUG H P ORT IMM EDI ATE LY.
12VDC-15A MAX
MRP # 1744738 SR-747
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH.
BEFORE STARTING ENGINE:
CHECK ENGINE COMPARTMENT BILGE FOR GASLINE OR VAPORS.
OPERATE BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION,
RUN BLOWER WHEN VESSEL OPERATING BELOW CRUISING SPEED.
! WARNING
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
,/!$!.$#!0!#)49s#/-0!24-%.46%.4),!4)/.
STEERING, FUEL AND ELECTRICAL SYSTEMS
).4%2.!4)/.!,,)'(43s"!3)#&,/4!4)/.
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 205 Sport
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
MRP 1745157 SR-7119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOXIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
MRP 1745125 SR-7111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 1745519 SR-7214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP #1743499 SR-7125
FIRE PORT ACCESS UNDER
KEEP CLEAR
!
DANGER
Carbon monoxide (CO) can cause brain damage
or death.
Engine and generator exhaust contains odorless
and colorless carbon monoxide gas.
Carbon monoxide will be around the back of the
boat when engines or generators are running.
Move to fresh air, if you feel nausea, headache,
dizziness, or drowsiness.
NW-206-05
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
!
WARNING
Carbon monoxide (CO) can cause brain damage or death.
Engine and generator exhaust contains odorless and colorless carbon monoxide gas.
Signs of carbon monoxide poisoning include nausea, headache, dizziness, drowsiness,
and lack of consciousness.
Get fresh air if anyone shows signs of carbon monoxide poisoning.
See Owner's Manual for information regarding carbon monoxide poisoning.
NW-204-05
x
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD, INSPECT SYSTEM REGULARY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
MRP 852632 SR-151
WARNING
!
INSIDE ENGINE BOX ON AFT BULKHEAD
3
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
205 SPORT SPECIFICATIONS
BO AT DIMENSIONS AND CLEARANCES
B
O AT DIMENSIONS AND CLEARANCES
(CONT’D)(FIG. 3.2)
(F
IG. 3.1)
Length overall.......................................21ft./6.40m
Maximum beam.....................................8ft./2.44m
Bow to transom/keel
intersection...............................18ft. 6 in./5.65m
Draft (stern drive down)..........................33"/84cm
(stern drive up)...............................17"/43cm
Fuel capacity...............................37 gal./140 Liters
Dry Weight................................3,265 lbs/1,481 kg
Dead rise..........................................................20º
18’ 6 5/8”
21’ 0”
17”
FULL LOAD WATER LINE
33”
5' 1 1/8"
4' 3/8"
11 3/8”
8’
6’ 11 1/4”
NOTE: DIMENSIONS CAN
VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS
2
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(FIG. 2.1)
205 SP
7
545
kg.
C
THIS TAG REPLACES DOMESTIC
CERTIFICATION TAG (LEFT)
WHEN BOAT IS ORDERED WITH
INTERNATIONAL (CE) OPTION.
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
!
INSIDE ENGINE BOX ON AFT BULKHEAD
MRP 722041 SR-87
INDICATIONSOF EXCESSIVE EXPOSURE TO “CO” CONCENTRATIONS
MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
AVOID RIST OF INJURY OR DEATH, SHUTOFF ENGINE NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM SUNPAD OR BOARDING LADDER.
DANGER
!
WARNING
!
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”.
Visibility can be limited by high boat trim angles, persons and gear. Such issues
are considered under the control of the operator.
USE CAUTION WITH SKIER IN TOW AS TOW ROPE MAY BACKLASH
INTO COCKPIT WHEN RELEASED.
NOTICE: It is recommended that all occupants wear approved
Personal flotation Devices (PFD’s).
CARBON MONOXIDE CAN BE FATAL. In all gasoline powered boats, engine
exhaust systems produce colorless and odorless carbon monoxide gas “CO”
Direct prolonged exposure can result in CO poisoning which may be harmful or
FATAL. To prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate
ventilation through utilization of cabin hatches and walk-through windshields
to increase the accumulation of CO in and about the boat and require the
operator’s particular attention:
1. Operation at slow speeds or dead in water.
2. Operation with a high bow angle attitude.
3. Utilization of canvas tops, side curtains and back curtains.
4. Contributing climatic conditions, such as a head wind.
5. Operation of engines and/or generator in confined spaces or a dockside.
6. Any blockage of hull exhaust outlets.
MRP 1744762 SR-766
s).#!3%/&&)2%$/./4/0%.%.').%"/8/2
COMPARTMENT
WARNING
s3(54$/7.%.').%3'%.%2!4/2!.$",/7%23
s#/.4).5/53,9$)3#(!2'%%.4)2%#/.4%.43/&(!,/.
OR CO
2
PORTABLE FIRE EXTINGUISHER
THR OUG H P ORT IMM EDI ATE LY.
12VDC-15A MAX
MRP # 1744738 SR-747
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH.
BEFORE STARTING ENGINE:
CHECK ENGINE COMPARTMENT BILGE FOR GASLINE OR VAPORS.
OPERATE BLOWER FOR FOUR MINUTES, AND VERIFY BLOWER OPERATION,
RUN BLOWER WHEN VESSEL OPERATING BELOW CRUISING SPEED.
! WARNING
MAXIMUM CAPACITIES
8 PERSONS OR 1100 LBS.
1200 POUNDS, PERSONS, GEAR
,/!$!.$#!0!#)49s#/-0!24-%.46%.4),!4)/.
STEERING, FUEL AND ELECTRICAL SYSTEMS
).4%2.!4)/.!,,)'(43s"!3)#&,/4!4)/.
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 205 Sport
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
VONORE, TN
Certified
NMMA
MRP 1745157 SR-7119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOXIVE
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
MRP 1745125 SR-7111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 1745519 SR-7214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP #1743499 SR-7125
FIRE PORT ACCESS UNDER
KEEP CLEAR
!
DANGER
Carbon monoxide (CO) can cause brain damage
or death.
Engine and generator exhaust contains odorless
and colorless carbon monoxide gas.
Carbon monoxide will be around the back of the
boat when engines or generators are running.
Move to fresh air, if you feel nausea, headache,
dizziness, or drowsiness.
NW-206-05
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
CO
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD, INSPECT SYSTEM REGULARY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
MRP 852632 SR-151
WARNING
!
INSIDE ENGINE BOX ON AFT BULKHEAD
5
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
HELM
(FIG. 5.1)
BILGE
BLOWER
BILGE
PUMP
NAV
LIGHTS
ANCHOR
LIGHTS
HORN
WIPER
1
0
2
3
4
5
6
250
175
100
100
80
60
18
14
12
10
E
F
1/2
0
40
80
140
280
420
DEPTH
GAUGE
(OPTIONAL)
SPEEDOMETER
4-IN-1
GAUGE
OIL
PRESSURE
FUEL
WATER
TEMPERATURE
VOLT
METER
TACHOMETER
WITH HOURMETER
TRIM
GAUGE
IGNITION SWITCH BILGE BLOWER
SWITCH
BILGE PUMP
SWITCH
NAVIGATION
LIGHTS SWITCH
ANCHOR LIGHTS
SWITCH
WIPER
SWITCH
HORN
BUTTON
STEREO REMOTE
12 VOLT ACCESSORY
RECEPTACLE
COMPASS
(OPTIONAL)
4
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(FIG. 4.1)
PORT THROUGH-HULL CUTOUTS
(FIG. 4.2)
B
ILGE THROUGH-HULL CUTOUTS
(FIG. 4.3)
T
RANSOM THROUGH-HULL CUTOUTS
(FIG. 4.4)
BILGE PUMP
COOLER DRAIN
TRANSDUCER
GARBOARD DRAIN
5
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
HELM
(FIG. 5.1)
BILGE
BLOWER
BILGE
PUMP
NAV
LIGHTS
ANCHOR
LIGHTS
HORN
WIPER
1
0
2
3
4
5
6
250
175
100
100
80
60
18
14
12
10
E
F
1/2
0
40
80
140
280
420
DEPTH
GAUGE
(OPTIONAL)
SPEEDOMETER
4-IN-1
GAUGE
OIL
PRESSURE
FUEL
WATER
TEMPERATURE
VOLT
METER
TACHOMETER
WITH HOURMETER
TRIM
GAUGE
IGNITION SWITCH BILGE BLOWER
SWITCH
BILGE PUMP
SWITCH
NAVIGATION
LIGHTS SWITCH
ANCHOR LIGHTS
SWITCH
WIPER
SWITCH
HORN
BUTTON
STEREO REMOTE
12 VOLT ACCESSORY
RECEPTACLE
COMPASS
(OPTIONAL)
4
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(FIG. 4.1)
PORT THROUGH-HULL CUTOUTS
(FIG. 4.2)
B
ILGE THROUGH-HULL CUTOUTS
(FIG. 4.3)
T
RANSOM THROUGH-HULL CUTOUTS
(FIG. 4.4)
BILGE PUMP
COOLER DRAIN
TRANSDUCER
GARBOARD DRAIN
7
205 SPORT OWNERS MANUAL
205 Sport
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
Manual Part Number: MRP 1902268
8. CLEATS
Cleats must not be used for lifting the boat; they
are intended for docking or mooring use only.
CLEAT LOCATIONS
(FIG. 7.1)
9. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
NAVIGATION AND
ANCHOR LIGHTS
STERN NAVIGATION/
ANCHOR LIGHT
(REMOVABLE)
PORT/STBD
COMBO
NAVIGATION
LIGHT
(FIG.7.2)
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
PORT/STBD COMBO
NAV. LIGHT
10. BILGE LAYOUT
BILGE LAYOUT
(FIG. 7.3)
TRANSDUCER (OPT)
FLOAT SWITCH
BILGE PUMP
BATTERY
FUEL TANK
BLOWER
POWER TRIM PUMP
A
B
C
E
F
G
D
A
B
C
D
F
E
G
11. FUEL SYSTEM
The 205 Sport standard gasoline fuel system
consists of a 37 gallon (140 liter) fuel tank, fuel tank
vent, anti-siphon valve, engine fuel supply line and
fuel fill.
6
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(FIG. 6.1)
NAVIGATION LIGHT
BOW STORAGE (UNDER CUSHIONS)
WALK-THROUGH WINDSHIELD
SATELLITE STEREO ANTENNA
LOCKABLE GLOVE BOX (STEREO INSIDE)
INTEGRATED INSULATED COOLER
FUEL TANK ACCESS HATCH
AFT JUMP SEATS
POP-UP SKI TOW EYE
FUEL FILL DECK PLATE
SWIM PLATFORM
ANCHOR STORAGE LOCKER
HORN
COMPASS (OPTIONAL)
CONTROL STATION
12 VOLT RECEPTACLE
SKI/WAKEBOARD STORAGE
BUCKET SEAT
MOTOR BOX
NAV/ANCHOR LIGHT
STEREO REMOTE (OPTIONAL)
SWIM LADDER
TRANSOM BENCH SEAT (OPTIONAL)
SUN PAD
BACK-TO-BACK LOUNGER (OPTIONAL)
OPTIONAL SEATING PLANS
2 BUCKET SEATS; TRANSOM
BENCH SE AT; SUNPAD
BUCKET SEAT; BACK-TO-BACK
LOUNGER; 2 HI-LO JUMP
SEATS; MOTOR BOX
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
U
V
X
W
Y
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
U
V
W
X
Y
7
205 SPORT OWNERS MANUAL
205 Sport
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
Manual Part Number: MRP 1902268
8. CLEATS
Cleats must not be used for lifting the boat; they
are intended for docking or mooring use only.
CLEAT LOCATIONS
(FIG. 7.1)
9. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
NAVIGATION AND
ANCHOR LIGHTS
STERN NAVIGATION/
ANCHOR LIGHT
(REMOVABLE)
PORT/STBD
COMBO
NAVIGATION
LIGHT
(FIG.7.2)
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
PORT/STBD COMBO
NAV. LIGHT
10. BILGE LAYOUT
BILGE LAYOUT
(FIG. 7.3)
TRANSDUCER (OPT)
FLOAT SWITCH
BILGE PUMP
BATTERY
FUEL TANK
BLOWER
POWER TRIM PUMP
A
B
C
E
F
G
D
A
B
C
D
F
E
G
11. FUEL SYSTEM
The 205 Sport standard gasoline fuel system
consists of a 37 gallon (140 liter) fuel tank, fuel tank
vent, anti-siphon valve, engine fuel supply line and
fuel fill.
6
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(FIG. 6.1)
NAVIGATION LIGHT
BOW STORAGE (UNDER CUSHIONS)
WALK-THROUGH WINDSHIELD
SATELLITE STEREO ANTENNA
LOCKABLE GLOVE BOX (STEREO INSIDE)
INTEGRATED INSULATED COOLER
FUEL TANK ACCESS HATCH
AFT JUMP SEATS
POP-UP SKI TOW EYE
FUEL FILL DECK PLATE
SWIM PLATFORM
ANCHOR STORAGE LOCKER
HORN
COMPASS (OPTIONAL)
CONTROL STATION
12 VOLT RECEPTACLE
SKI/WAKEBOARD STORAGE
BUCKET SEAT
MOTOR BOX
NAV/ANCHOR LIGHT
STEREO REMOTE (OPTIONAL)
SWIM LADDER
TRANSOM BENCH SEAT (OPTIONAL)
SUN PAD
BACK-TO-BACK LOUNGER (OPTIONAL)
OPTIONAL SEATING PLANS
2 BUCKET SEATS; TRANSOM
BENCH SE AT; SUNPAD
BUCKET SEAT; BACK-TO-BACK
LOUNGER; 2 HI-LO JUMP
SEATS; MOTOR BOX
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
U
V
X
W
Y
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
P
Q
R
S
T
U
V
W
X
Y
9
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
16. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
¤
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
¤
dealer for service. Sea Ray
¤
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
14. WATER SPORTS TOWER
If equipped, the water sports tower provides a
raised attach point (ski tow pylon) for the ski rope.
The high attach point enables the skier to perform
a wide variety of skills not capable with the lower
transom attach point.
The tower attach point is intended for use only when
towing a single skier. If you are towing multiple skiers
or water toys carrying more than one person use
only the transom attach point. The tower attach point
is NOT intented for towing inflatables.
DO NOT USE TOWER FOR PULLING INFLATABLES.
Use water sports tower for single skier/wakeboarder
only. Use ski tow or stern eyes on transom for all other
tow behind sports. Heavy loads could collapse tower
causing personal injury.
! WARNING
DO NOT USE WATER SPORTS TOWER FOR TOWING
ANOTHER BOAT OR BEING TOWED. TOWER COULD
COLLAPSE AND CAUSE INJURY. SEE OWNER'S
MANUAL FOR INSTRUCTIONS ON TOWING.
! WARNING
WATER SPORT TOWER (OPTIONAL)
(FIG. 9.1)
15. SWIM PLATFORM AND LADDER
The swim ladder is located on the stbd side of the
swim platform. Unfold the ladder and drop into the
water to assist swimmers in boarding the vessel.
SWIM PL ATFORM LADDER
(FIG. 9.2)
LADDER (STOWED)
TO AVOID RISK OF SERIOUS INJURY OR DEATH SHUT
OFF ENGINE WHEN NEAR SWIMMERS OR PRIOR TO
USING SWIM PLATFORM AND BOARDING LADDER.
! DANGER
8
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
13. CANVAS
The following canvas pieces are available individually
as options:
s 3UNBRELLA¤"IMINI4OPW"OOT
s #OCKPITAND4ONNEAU#OVERSWSTORAGE"AG
s 4RAVEL3TORAGE#OVER
! DANGER
Exhaust fumes from engines contain deadly carbon
monoxide gas (CO). Boats enclosed with canvas or with
poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea
and dizziness. Do not mistake these symptoms for
sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for
more details.
Do not use the rear (aft) curtain while engine is
running or boat is moving.
12. ENTERTAINMENT SYSTEM
The entertainment center equipment options may
vary from boat to boat.
The entertainment system on the 205 Sport consists
of a 12V AM/FM radio, single CD unit and a remote
MP3 port located in the glove box on the port dash.
The system includes two (2) waterproof speakers.
The optional Premier Stereo upgrade also includes
an amplifier, two (2) additional speakers and a digital
remote control.
REFER TO OWNER’S MANUAL PACKET FOR
INSTRUCTIONS AND WARRANTY INFORMATION.
ENTERTAINMENT SYSTEM
(FIG.8.1)
STEREO REMOTE
(OPTIONAL)
AM/FM RADIO, SINGLE CD UNIT
POWER
SOURCE
VOL
VOL
MUTE
BAND
DISC
9
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
16. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
¤
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
¤
dealer for service. Sea Ray
¤
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
14. WATER SPORTS TOWER
If equipped, the water sports tower provides a
raised attach point (ski tow pylon) for the ski rope.
The high attach point enables the skier to perform
a wide variety of skills not capable with the lower
transom attach point.
The tower attach point is intended for use only when
towing a single skier. If you are towing multiple skiers
or water toys carrying more than one person use
only the transom attach point. The tower attach point
is NOT intented for towing inflatables.
DO NOT USE TOWER FOR PULLING INFLATABLES.
Use water sports tower for single skier/wakeboarder
only. Use ski tow or stern eyes on transom for all other
tow behind sports. Heavy loads could collapse tower
causing personal injury.
! WARNING
DO NOT USE WATER SPORTS TOWER FOR TOWING
ANOTHER BOAT OR BEING TOWED. TOWER COULD
COLLAPSE AND CAUSE INJURY. SEE OWNER'S
MANUAL FOR INSTRUCTIONS ON TOWING.
! WARNING
WATER SPORT TOWER (OPTIONAL)
(FIG. 9.1)
15. SWIM PLATFORM AND LADDER
The swim ladder is located on the stbd side of the
swim platform. Unfold the ladder and drop into the
water to assist swimmers in boarding the vessel.
SWIM PL ATFORM LADDER
(FIG. 9.2)
LADDER (STOWED)
TO AVOID RISK OF SERIOUS INJURY OR DEATH SHUT
OFF ENGINE WHEN NEAR SWIMMERS OR PRIOR TO
USING SWIM PLATFORM AND BOARDING LADDER.
! DANGER
8
205 SPORT OWNERS MANUAL
205 Sport
Manual Part Number: MRP 1902268
13. CANVAS
The following canvas pieces are available individually
as options:
s 3UNBRELLA¤"IMINI4OPW"OOT
s #OCKPITAND4ONNEAU#OVERSWSTORAGE"AG
s 4RAVEL3TORAGE#OVER
! DANGER
Exhaust fumes from engines contain deadly carbon
monoxide gas (CO). Boats enclosed with canvas or with
poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea
and dizziness. Do not mistake these symptoms for
sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for
more details.
Do not use the rear (aft) curtain while engine is
running or boat is moving.
12. ENTERTAINMENT SYSTEM
The entertainment center equipment options may
vary from boat to boat.
The entertainment system on the 205 Sport consists
of a 12V AM/FM radio, single CD unit and a remote
MP3 port located in the glove box on the port dash.
The system includes two (2) waterproof speakers.
The optional Premier Stereo upgrade also includes
an amplifier, two (2) additional speakers and a digital
remote control.
REFER TO OWNER’S MANUAL PACKET FOR
INSTRUCTIONS AND WARRANTY INFORMATION.
ENTERTAINMENT SYSTEM
(FIG.8.1)
STEREO REMOTE
(OPTIONAL)
AM/FM RADIO, SINGLE CD UNIT
POWER
SOURCE
VOL
VOL
MUTE
BAND
DISC
205 Sport10
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC Wi r i n g Di a g r a m (1 o f 2)
1. El E c t r i c a l Sc h E m a t i c S
(Fi g. 10.1)
205 Sport 11
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS (CONTINUED)
DC WIRING DIAGRAM (2 OF 2)
(FIG. 11.1)
205 Sport10
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
DC WIRING DIAGRAM (1 OF 2)
1. ELECTRICAL SCHEMATICS
(FIG. 10.1)
Index i
205 Sport
INDEX
Manual Part Number: MRP 1902268
A
Anchor Lights ...............................................................7
C
Canvas.........................................................................8
Clearances .................................................................. 3
Cleats .......................................................................... 7
D
Deck Layout .................................................................6
Dimensions .................................................................. 3
E
Electrical Schematics .................................................. 9
F
Fuel System .................................................................7
G
Gauge Layout .............................................................. 5
H
Helm Layout.................................................................5
L
Load Capacity ..............................................................1
N
Navigation Lights ......................................................... 7
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................2
Swim Platform .............................................................9
Switch Layout ..............................................................5
T
Through-Hull Cutouts .................................................. 4
W
Water Sports Tower ..................................................... 9
205 Sport12
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
THIS PAGE INTENTIONALLY LEFT BLANK
Index i
205 Sport
INDEX
Manual Part Number: MRP 1902268
A
Anchor Lights ...............................................................7
C
Canvas.........................................................................8
Clearances .................................................................. 3
Cleats .......................................................................... 7
D
Deck Layout .................................................................6
Dimensions .................................................................. 3
E
Electrical Schematics .................................................. 9
F
Fuel System .................................................................7
G
Gauge Layout .............................................................. 5
H
Helm Layout.................................................................5
L
Load Capacity ..............................................................1
N
Navigation Lights ......................................................... 7
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................2
Swim Platform .............................................................9
Switch Layout ..............................................................5
T
Through-Hull Cutouts .................................................. 4
W
Water Sports Tower ..................................................... 9
205 Sport12
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
THIS PAGE INTENTIONALLY LEFT BLANK
Specific
Information
Manual
210 Select
Manual Part Number: MRP 1902268
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18

Sea Ray 205 Sport Owner's manual

Sea Ray
Brand
Sea Ray
Model
205 Sport
Category
Air blowers/dryers
Type
Owner's manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents