Sea Ray 2008 220 SUNDECK is a boat ideal for water sports, fishing and day trips. The boat can hold up to 10 people or 1600 pounds. It has a 6.2 L liter, 320 horsepower engine. The boat is 22 feet long with an 8'6" beam. The fuel capacity is 52 gallons and the water capacity is 15 gallons. The boat has a variety of features including: a swim platform, a bimini top, a stereo system, and a depth finder. The boat also has a variety of storage compartments for gear and supplies. With its spacious layout and powerful engine, the Sea Ray 2008 220 SUNDECK is perfect for a day on the water.
Sea Ray 2008 220 SUNDECK is a boat ideal for water sports, fishing and day trips. The boat can hold up to 10 people or 1600 pounds. It has a 6.2 L liter, 320 horsepower engine. The boat is 22 feet long with an 8'6" beam. The fuel capacity is 52 gallons and the water capacity is 15 gallons. The boat has a variety of features including: a swim platform, a bimini top, a stereo system, and a depth finder. The boat also has a variety of storage compartments for gear and supplies. With its spacious layout and powerful engine, the Sea Ray 2008 220 SUNDECK is perfect for a day on the water.
Specific
Information
Manual
220 Sundeck
Manual Part Number: MRP 1902268
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
220 Sundeck i
Manual Part Number: MRP 1902268
220 SUNDECK SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances .................4
5. Function and Location of Through-Hull Cutouts ......5
6. Helm, Gauge & Switch Layout ................................6
7. Deck Layout .............................................................7
8. Cleats .......................................................................8
9. Navigation and Anchor Lights ..................................8
10. Lighting ..................................................................8
11. Bilge Layout ...........................................................8
12. Fire Extinguishing System ..................................... 9
13. Fuel System ...........................................................9
A. Gasoline Fuel System .......................................9
B. Diesel Fuel System (Optional) ..........................9
14. Water System ........................................................9
15. Canvas ................................................................... 9
16. Water Sports Tower ................................................ 9
17. Transom Trailer Trim Switch ................................. 10
18. Entertainment System .........................................10
19. Electrical Schematics...........................................10
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
220 Sundeck
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
220 Sundeck i
Manual Part Number: MRP 1902268
220 SUNDECK SPECIFIC INFORMATION MANUAL
TABLE OF CONTENTS
1. Load Capacity ..........................................................1
2. Passenger Locations ...............................................1
3. Safety Label Locations ............................................2
4. Basic Boat Dimensions and Clearances .................4
5. Function and Location of Through-Hull Cutouts ......5
6. Helm, Gauge & Switch Layout ................................6
7. Deck Layout .............................................................7
8. Cleats .......................................................................8
9. Navigation and Anchor Lights ..................................8
10. Lighting ..................................................................8
11. Bilge Layout ...........................................................8
12. Fire Extinguishing System ..................................... 9
13. Fuel System ...........................................................9
A. Gasoline Fuel System .......................................9
B. Diesel Fuel System (Optional) ..........................9
14. Water System ........................................................9
15. Canvas ................................................................... 9
16. Water Sports Tower ................................................ 9
17. Transom Trailer Trim Switch ................................. 10
18. Entertainment System .........................................10
19. Electrical Schematics...........................................10
Information in this publication is based upon the latest product specifications available at printing. Sea Ray
®
Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications,
materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea
Ray
®
is not obligated to make similar changes or modifications to models sold prior to the date of such changes.
Owner’s Manual
220 Sundeck
Printed in the U.S.A. April 2007
©3EA2AY"OATS)NCs!"RUNSWICK#OMPANY
Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914
For information call 1-800-SRBOATS or fax 1-314-213-7878
(International 1-314-216-3333)
Internet Address: http://www.searay.com
Note: Not all accessories shown in pictures or described herein are
standard equipment or even available as options.
Options and features are subject to change without notice.
The following are registered trademarks of the Brunswick Corporation: Sea Ray
®
& The SR Wave Logo
1
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or
water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near
boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while
engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting
something in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring,
mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and
hold on to rails or boat structure.
! WARNING
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
10 PERSONS OR 1600 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 220 SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
TELLICO, TN
Certified
NMMA
(FIG. 1.2)
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
10
Ray
220 SD
Boats
820
kg
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGN ATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
P
ASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPAT ION DURING NORMAL
OPERAT ION)
220 Sundeckii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
1
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
1. LOAD CAPACITY
Refer to the General Information Manual for a
detailed explanation of Load Capacity.
Never carry more weight or passengers than indicated
on the certification plate, regardless of weather or
water conditions.
The boat can capsize, swamp or sink.
! DANGER
Rotating propellers can injure or kill you.
Shut off engine when persons are in water near
boat, or on swim platform or ladder.
! DANGER
Rear facing transom seats MUST NOT be used while
engine is running or boat is moving.
! WARNING
2. PASSENGER LOCATIONS
Refer to the General Information Manual for a
detailed explanation of Passenger Locations.
Boat motion can be erratic.
You can fall overboard or be injured by hitting
something in or on the boat.
All persons must be in cockpit area or cabin and be
prepared for sudden boat movement.
Use front or bow deck area only during anchoring,
mooring or emergencies.
! WARNING
Wet decks are slippery.
You can be seriously injured if you slip and fall.
Wear slip resistant footwear secured to your feet and
hold on to rails or boat structure.
! WARNING
BUILDER’S PLATE (DOMESTIC)
MAXIMUM CAPACITIES
10 PERSONS OR 1600 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 220 SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
TELLICO, TN
Certified
NMMA
(FIG. 1.2)
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
10
Ray
220 SD
Boats
820
kg
BUILDER’S PLATE (INTERNATIONAL)
BOAT MANUFACTURER
MFR’S MODEL
DESIGN ATION
MAXIMUM NUMBER
OF PASSENGERS
MAXIMUM LOAD
CAPACITY
(FIG. 1.1)
P
ASSENGER LOCATIONS
(FIG. 1.3)
ACCOMMODATION DECK
(DECK AREA INTENDED FOR
OCCUPAT ION DURING NORMAL
OPERAT ION)
220 Sundeckii
Manual Part Number: MRP 1902268
THIS PAGE INTENTIONALLY LEFT BLANK
3
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
SAFETY LABEL LOCATIONS (CONTINUED)
SAFETY LABEL LOCATIONS
(FIG. 3.1)
PLASTIC-Includes, but is
not limited to: plastic
bags, styrofoam cups
and lids, six pack
holders, stirrers, straws,
milk jugs, egg cartons,
synthetic fishing nets,
ropes, lines, and bio or
photo degradeable
plastics.
GARBAGE-Means
paper, rags, glass, metal,
crockery, (generated in
living spaces aboard the
vessel that we
normally call trash), and
all kinds of food,
maintenance and cargo-
associated waste.
“Garbage” does not
include fresh fish or fish
parts, dishwasher and
gray water.
INSIDE 3 MILES
3 TO 12 MILES
(and in U.S. Lakes, Rivers,
bays and Sounds)
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE EXCEPT DISHWATER/
GRAYWATER/FRESH FISH PARTS
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE NOT GROUND TO
LESS THAN ONE SQUARE INCH
12 TO 25 MILES
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
OUTSIDE 25 MILES
PLASTICS
It is illegal to dump plastic trash anywhereinto the ocean or navigable waters
of the United States. Violation of these requirements may result in civil penalty
up to $25,000 and fine of $50,000 and imprisonment up to five years.
Regional, state and local restrictions on garbage, discharge amy also apply.
S O
ave
DUNNAGE- Material
used to block and brace
cargo, and is considered
a cargo associated
waste.
DISHWATER-Means the
liquid residue from the
manual or automatic
washing of dishes and
cooking utensils which,
have been pre-cleaned to
the extent that any food
particles adhering to them
would not normally
interfere with the
operation of automatic
dishwashers.
GRAYWATER-Means
drainage from a
dishwasher, shower,
laundry, bath, and
washbasin, and does not
include drainage from
toilets, urinals, hospitals
and cargo spaces.
S
easur
2
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(FIG. 2.1)
MRP 852525 SR-111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 852533 SR-119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOXIVE
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD, INSPECT SYSTEM REGULARY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
MRP 551689 SR-66
MRP 111287 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP 811000 SR-102
DANGER
!
TRANSOM DOOR MUST BE
CLOSED AND SECURE WHEN
ENGINE IS RUNNING
DO NOT STAND OR WALK ON
TH IS AREA S ERIOUS INJURY
COULD RESULT.
MRP # 113562 SR-216
DANGER
!
!
MRP 852632 SR-151
WARNING
!
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
AVOID SERIOUS INJURY OR DEATH FROM CARBON MONOXIDE
EXHAUST FUMES FROM ENGINES CONTAIN CARBON MONOXIDE GAS
AND MAY COLLECT IN ENCLOSED AREAS
KEEP COCKPIT CABIN AND CABIN AREAS WELL VENTILATED. DO NOT
USE CANVAS, SIDE CURTAINS AND FORWARD VISOR WITHOUT
PROPER VENTILATION.
CO SIDKNESS SYMPTIONS INCLUDE HEADACHE, NAUSEA, AND DIZZINESS.
DO NOT MISTAKE FOR SEASICKNESS.
MRP 1369743 SR-246
DANGER
!
VENDOR SUPPLIED
CAUTION
AVOID INJURY.
SECURE GLASS DOOR WHILE
UNDERWAY.
!
!
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
INSIDE ENGINE BOX
BELOW CUSHION
IF SWITCH IS TURNED OFF WHILE
ENGINE IS RUNNING ALTERNATOR
WILL BE DAMAGED.
MRP # 921767 SR-167
CAUTION
!
STAINLESS STEEL SLIDING SWIM LADDERS
SUGGESTED CARE & MAINTENANCE
MRP 1573112 SR-505
AFTER EACH USE:
Fully extend ladder and thoroughly rinse all ladder and slide surfaces
with fresh water. Pay special attention to flushing any debris and salt
water from the slide areas.
MONTHLY:
Examine the ladder slide grooves and remove any foreign particles
lodged within the grooves.
Wash entire ladder, uning ONLY a clean, soft cloth, and mild soap solution.
Rinse thoroughly with fresh water. To prevent damage NEVER USE
ABRASIVES or ABRASIVE CLEANERS!
Allow ladder to dry after washing. Apply a light coating of spray lubricant or
clear silicone grease to the slide areas ONLY. Work ladder back and forth
to assure distribution of lubricant and ease of operation.
CAUTION - TO PREVENT THE POSSIBILITY OF PERSONAL INJURY,
ENSURE THAT ANY LUBRICANT IS CLEANED FROM LADDER RUNGS
AND STILES PRIOR TO USE.
Inspect the ladder for damage and check the security of all fasteners.
Repair damage and/or tighten any hardware that may have become
loose prior to use.
UNDER SWIM LADDER COVER
12VDC-15A MAX
MRP # 324756 SR-47
UNDER ENGINE HATCH, ABOVE ENGINE
BELOW SHIFT/THROTTLE
INSIDE STORAGE COMPARTMENT
ON TRANSOM DOOR
MAXIMUM CAPACITIES
10 PERSONS OR 1600 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 220SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
Tellico, TN
Certified
NMMA
THIS TAG REPLACES DOMESTIC CERTIFICATION TAG (RIGHT)
WHEN BOAT IS ORDERED WITH INTERNATIONAL (CE) OPTION.
MRP 722041 SR-87
! DANGER
! WARNING
CARBON MONOXIDE CAN BE FATAL In all gasoline powered boats, engine exhaust systems
produce colorless, odorless carbon monoxide gas (’CO’) Direct prolonged exposure can result in
CO poisoning which may be harmful or fatal. to prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through utilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO ‘CO’ CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
Operation at slow speeds or dead in water. Utilization of canvas tops, side curtains or back curtains.
Any blockage of hull exhaust outlets.
Operation with a high bow angle attitude. Operation of engines and/or generator in confined spaces or at dockside.
Contributing climatic conditions, such as headwind.
AVOID RISK OF INJURY OR DEATH. SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”. Visibility can be limited
by high boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
WARNING
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
10
Ray
220 SD
Boats
820
kg
3
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
SAFETY LABEL LOCATIONS (CONTINUED)
SAFETY LABEL LOCATIONS
(FIG. 3.1)
PLASTIC-Includes, but is
not limited to: plastic
bags, styrofoam cups
and lids, six pack
holders, stirrers, straws,
milk jugs, egg cartons,
synthetic fishing nets,
ropes, lines, and bio or
photo degradeable
plastics.
GARBAGE-Means
paper, rags, glass, metal,
crockery, (generated in
living spaces aboard the
vessel that we
normally call trash), and
all kinds of food,
maintenance and cargo-
associated waste.
“Garbage” does not
include fresh fish or fish
parts, dishwasher and
gray water.
INSIDE 3 MILES
3 TO 12 MILES
(and in U.S. Lakes, Rivers,
bays and Sounds)
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE EXCEPT DISHWATER/
GRAYWATER/FRESH FISH PARTS
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
ANY GARBAGE NOT GROUND TO
LESS THAN ONE SQUARE INCH
12 TO 25 MILES
PLASTICS
DUNNAGE, LINING AND PACKING
MATERIALS THAT FLOAT
OUTSIDE 25 MILES
PLASTICS
It is illegal to dump plastic trash anywhereinto the ocean or navigable waters
of the United States. Violation of these requirements may result in civil penalty
up to $25,000 and fine of $50,000 and imprisonment up to five years.
Regional, state and local restrictions on garbage, discharge amy also apply.
S O
ave
DUNNAGE- Material
used to block and brace
cargo, and is considered
a cargo associated
waste.
DISHWATER-Means the
liquid residue from the
manual or automatic
washing of dishes and
cooking utensils which,
have been pre-cleaned to
the extent that any food
particles adhering to them
would not normally
interfere with the
operation of automatic
dishwashers.
GRAYWATER-Means
drainage from a
dishwasher, shower,
laundry, bath, and
washbasin, and does not
include drainage from
toilets, urinals, hospitals
and cargo spaces.
S
easur
2
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
3. SAFETY LABEL LOCATIONS
SAFETY LABEL LOCATIONS
(FIG. 2.1)
MRP 852525 SR-111
WARNING
!
USE CAUTION WITH SKIER IN TOW
AS TOW ROPE MAY BACKLASH INTO
COCKPIT WHEN RELEASED
MRP 852533 SR-119A
DANGER
!
NO SMOKING
GASOLINE VAPORS ARE EXPLOXIVE
LEAKING FUEL IS A FIRE AND EXPLOSION
HAZARD, INSPECT SYSTEM REGULARY.
EXAMINE FUEL TANKS FOR LEAKS OR
CORROSION AT LEAST ANNUALLY.
STAY CLEAR OF MOVING PARTS
WHILE ENGINE IS RUNNING.
MRP 852624 SR-149
DANGER
MRP 551689 SR-66
MRP 111287 SR-214
DANGER
!
TO AVOID RISK OF SERIOUS INJURY OR DEATH
SHUT OFF ENGINE WHEN NEAR SWIMMERS
OR PRIOR TO USING SWIM PLATFORM AND
BOARDING LADDER.
MRP 811000 SR-102
DANGER
!
TRANSOM DOOR MUST BE
CLOSED AND SECURE WHEN
ENGINE IS RUNNING
DO NOT STAND OR WALK ON
TH IS AREA S ERIOUS INJURY
COULD RESULT.
MRP # 113562 SR-216
DANGER
!
!
MRP 852632 SR-151
WARNING
!
NOTICE
GASOLINE RECOMMENDATION
Minimum octane rating of 87 AKI.
Refer to the engine owner’s manual for
additional information.
AVOID SERIOUS INJURY OR DEATH FROM CARBON MONOXIDE
EXHAUST FUMES FROM ENGINES CONTAIN CARBON MONOXIDE GAS
AND MAY COLLECT IN ENCLOSED AREAS
KEEP COCKPIT CABIN AND CABIN AREAS WELL VENTILATED. DO NOT
USE CANVAS, SIDE CURTAINS AND FORWARD VISOR WITHOUT
PROPER VENTILATION.
CO SIDKNESS SYMPTIONS INCLUDE HEADACHE, NAUSEA, AND DIZZINESS.
DO NOT MISTAKE FOR SEASICKNESS.
MRP 1369743 SR-246
DANGER
!
VENDOR SUPPLIED
CAUTION
AVOID INJURY.
SECURE GLASS DOOR WHILE
UNDERWAY.
!
!
SEE OWNER’S MANUAL FOR ADDITIONAL INFORMATION
INSIDE ENGINE BOX
BELOW CUSHION
IF SWITCH IS TURNED OFF WHILE
ENGINE IS RUNNING ALTERNATOR
WILL BE DAMAGED.
MRP # 921767 SR-167
CAUTION
!
STAINLESS STEEL SLIDING SWIM LADDERS
SUGGESTED CARE & MAINTENANCE
MRP 1573112 SR-505
AFTER EACH USE:
Fully extend ladder and thoroughly rinse all ladder and slide surfaces
with fresh water. Pay special attention to flushing any debris and salt
water from the slide areas.
MONTHLY:
Examine the ladder slide grooves and remove any foreign particles
lodged within the grooves.
Wash entire ladder, uning ONLY a clean, soft cloth, and mild soap solution.
Rinse thoroughly with fresh water. To prevent damage NEVER USE
ABRASIVES or ABRASIVE CLEANERS!
Allow ladder to dry after washing. Apply a light coating of spray lubricant or
clear silicone grease to the slide areas ONLY. Work ladder back and forth
to assure distribution of lubricant and ease of operation.
CAUTION - TO PREVENT THE POSSIBILITY OF PERSONAL INJURY,
ENSURE THAT ANY LUBRICANT IS CLEANED FROM LADDER RUNGS
AND STILES PRIOR TO USE.
Inspect the ladder for damage and check the security of all fasteners.
Repair damage and/or tighten any hardware that may have become
loose prior to use.
UNDER SWIM LADDER COVER
12VDC-15A MAX
MRP # 324756 SR-47
UNDER ENGINE HATCH, ABOVE ENGINE
BELOW SHIFT/THROTTLE
INSIDE STORAGE COMPARTMENT
ON TRANSOM DOOR
MAXIMUM CAPACITIES
10 PERSONS OR 1600 LBS.
1800 POUNDS, PERSONS, GEAR
LOAD AND CAPACITY • COMPARTMENT VENTILATION
STEERING, FUEL AND ELECTRICAL SYSTEMS
INTERNATIONAL LIGHTS • BASIC FLOATION
MANEUVERABILITY
THIS BOAT COMPLIES WITH U.S. COAST
GUARD SAFETY STANDARDS IN EFFECT ON
THE DATE OF CERTIFICATION
MODEL: 220SD
DESIGN COMPLIANCE WITH NMMA REQUIREMENTS BELOW IS
VERIFIED. MFR. RESPONSIBLE FOR PRODUCTION CONTROL
NATIONAL MARINE MANUFACTURERS ASSN.
MANUFACTURER: SEA RAY BOATS, INC.
Tellico, TN
Certified
NMMA
THIS TAG REPLACES DOMESTIC CERTIFICATION TAG (RIGHT)
WHEN BOAT IS ORDERED WITH INTERNATIONAL (CE) OPTION.
MRP 722041 SR-87
! DANGER
! WARNING
CARBON MONOXIDE CAN BE FATAL In all gasoline powered boats, engine exhaust systems
produce colorless, odorless carbon monoxide gas (’CO’) Direct prolonged exposure can result in
CO poisoning which may be harmful or fatal. to prevent excess exposure and reduce the possibility of
accumulations of CO in the boat, the operator should include adequate ventilation through utilization of cabin
hatches and walk-through windshields to increase air movement through the boat. The following conditions tend
to increase the accumulation of CO in and about the boat and require the operator’s particular attention:
INDICATIONS OF EXCESSIVE EXPOSURE TO ‘CO’ CONCENTRATIONS MAY INCLUDE NAUSEA, DIZZINESS, HEADACHE AND DROWSINESS.
Operation at slow speeds or dead in water. Utilization of canvas tops, side curtains or back curtains.
Any blockage of hull exhaust outlets.
Operation with a high bow angle attitude. Operation of engines and/or generator in confined spaces or at dockside.
Contributing climatic conditions, such as headwind.
AVOID RISK OF INJURY OR DEATH. SHUTOFF ENGINE NEAR SWIMMERS OR PRIOR TO USING SWIM PLATFORM, SUNPAD OR BOARDING LADDER.
USE CAUTION WITH SKIER IN TOW AS ROPE MAY BACKLASH INTO COCKPIT WHEN RELEASED
AVOID COLLISIONS - Maintain lookout as required by “Rules of the Road”. Visibility can be limited
by high boat trim angles, persons and gear. Such issues are considered under the control of the operator.
NOTICE: It is recommended that all occupants wear approved Personal Flotation Devices (PFD’s).
WARNING
MAXIMUM
0609
IMCI
F
I
N
T
E
R
N
A
T
I
O
N
A
L
C
E
R
T
I
I
C
A
T
I
O
N
Sea
10
Ray
220 SD
Boats
820
kg
5
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(F
IG.5.1)
CORSA™
EXHAUST
BILGE PUMP TRANSDUCER ENTERTAINMENT
CENTER SINK
DRAIN
STA RBOARD
DOCKING LIGHT
CORSA™
EXHAUST
HEAD PUMP-OUT
VENT, (OPTION)
PORT
DOCKING LIGHT
ROPE LOCKER
DRAIN
GARBOARD DRAIN
(FIG.5.3)
PORT THROUGH-HULL CUTOUTS
(F
IG.5.2)
4
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
Overall Length .............................. 23ft. 6in. 7.16 m
Beam (Width) ................................. 8ft. 6in. 2.59 m
Draft (Stern Drive Down) ............... 36in.* 91.4 cm
Draft (Stern Drive Up) .................... 20in.* 51 cm
Dry Weight ..................................... 4,200 lbs. 1,905 kg.
Fuel Capacity ................................. 50 gal. 189.3 liters
Dead Rise ...................................... 21°
220 SUNDECK SPECIFICATIONS
BOAT DIMENSIONS AND CLEARANCES
20”
(91.4 cm)
(FIG.4.1)
23’ 6” (7.16m)
2’ 5”
(.73m)
FULL LOAD WATER LINE
8’ 6” (2.59M)
6’ 1” (1.85m)
NOTE: DIMENSIONS CAN VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS.
5
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
5. FUNCTION AND LOCATION OF THROUGH-HULL CUTOUTS
STARBOARD THROUGH-HULL CUTOUTS
(F
IG.5.1)
CORSA™
EXHAUST
BILGE PUMP TRANSDUCER ENTERTAINMENT
CENTER SINK
DRAIN
STA RBOARD
DOCKING LIGHT
CORSA™
EXHAUST
HEAD PUMP-OUT
VENT, (OPTION)
PORT
DOCKING LIGHT
ROPE LOCKER
DRAIN
GARBOARD DRAIN
(FIG.5.3)
PORT THROUGH-HULL CUTOUTS
(F
IG.5.2)
4
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
4. BASIC BOAT DIMENSIONS AND CLEARANCES
Overall Length .............................. 23ft. 6in. 7.16 m
Beam (Width) ................................. 8ft. 6in. 2.59 m
Draft (Stern Drive Down) ............... 36in.* 91.4 cm
Draft (Stern Drive Up) .................... 20in.* 51 cm
Dry Weight ..................................... 4,200 lbs. 1,905 kg.
Fuel Capacity ................................. 50 gal. 189.3 liters
Dead Rise ...................................... 21°
220 SUNDECK SPECIFICATIONS
BOAT DIMENSIONS AND CLEARANCES
20”
(91.4 cm)
(FIG.4.1)
23’ 6” (7.16m)
2’ 5”
(.73m)
FULL LOAD WATER LINE
8’ 6” (2.59M)
6’ 1” (1.85m)
NOTE: DIMENSIONS CAN VARY DEPENDING ON LOAD
AND RUNNING CONDITIONS.
7
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(FIG. 7.1)
PORT BOW CLEAT
PORT NAVIGAT ION
LIGHT
STBD NAVIGAT ION
LIGHT
HORN
BOW SWIM PLATFORM W/LADDER AND
ANCHOR STORAGE
CONCEALED
FOLDING SWIM
LADDER
STERN SWIM
PLATFORM
SKI TOW
BILGE BLOWER
VENTILATION
ACCESS PLATE TO FUEL
TANK SENDING UNIT
COMPANION SEAT WITH
FLIP UP THIGH RISE
BOLSTER
PORT LOUNGER & AFT
BENCH SE AT
BATTERY SWITCH
(OPTION-BELOW CUSHION)
FUEL FILL
PLATE
STERN
NAVIGAT ION
LIGHT
FRESH WATER
FILL PLATE
AFT PULL-OUT
SHOWER
BOW PULL-OUT
SHOWER
COCKPIT TABLE
ICE CHEST
BOW SEAT ING
WITH STORAGE
BELOW
OPENING WALK-THROUGH
WINDSHIELD
HEAD COMPARTMENT
(PORTABLE HEAD-STANDARD)
PUMPOUT HEAD-OPTION)
WET BAR WITH SINK &
STORAGE BELOW
HELM SEAT WITH FLIP UP
THIGH RISE BOLSTER
12 VOLT RECEPTACLE
(FWD INSIDE SIDEWALL
STORAGE)
ENGINE BOX
(UNDER CUSHION)
FIRE EXTINGUISHER
DISCHARGE PLATE
ACCESS PANEL TO FRESH
WATER
PUMP & FILTER
TRANSOM DOOR
BOW WALK-THROUGH
DOOR
CONTROL STATION
COMPASS (OPTION)
COCKPIT TABLE
SKI STORAGE HATCH
PORT AMIDSHIP
CLEAT
AFT PORT
CLEAT
AFT STA RBOARD
CLEAT
STA RBOARD
AMIDSHIP
CLEAT
6
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
GAUGE PANEL
FUEL
GAUGE
SPEEDOMETER
SYSTEM
TAC HOMETER
OIL
PRESSURE
WATER
TEMPERATURE
STERN DRIVE
TRIM GAUGE
ACCY
THRU-HULL
EXHAUST
WATER
PUMP
LIGHTS
ANCHOR COCKPITNAV
LIGHT ON - UNIT CHARGED
LIGHT OFF - UNIT DISCHARGED
IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER AND ELECTRICAL SYSTEM
AUTOMATIC EXTINGUISHING SYSTEM
CLARION STEREO REMOTE
S TARBOARD SWITCH PANELPORT SWITCH PANEL
HELM LAYOUT
(FIG. 6.1)
WARNING
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH
!
BEFORE STARTING ENGINE, CHECK ENGINE COMPARTMENT BILGE FOR
GASOLINE OR VAPORS. OPERATE BLOWER FOR FOUR MINUTES,
AND VERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL
IS OPERATING BELOW CRUISING SPEED.
HORN WIPER BILGE
PUMP
BILGE
BLOWER
7
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
7. DECK LAYOUT
GENERAL LAYOUT
(FIG. 7.1)
PORT BOW CLEAT
PORT NAVIGAT ION
LIGHT
STBD NAVIGAT ION
LIGHT
HORN
BOW SWIM PLATFORM W/LADDER AND
ANCHOR STORAGE
CONCEALED
FOLDING SWIM
LADDER
STERN SWIM
PLATFORM
SKI TOW
BILGE BLOWER
VENTILATION
ACCESS PLATE TO FUEL
TANK SENDING UNIT
COMPANION SEAT WITH
FLIP UP THIGH RISE
BOLSTER
PORT LOUNGER & AFT
BENCH SE AT
BATTERY SWITCH
(OPTION-BELOW CUSHION)
FUEL FILL
PLATE
STERN
NAVIGAT ION
LIGHT
FRESH WATER
FILL PLATE
AFT PULL-OUT
SHOWER
BOW PULL-OUT
SHOWER
COCKPIT TABLE
ICE CHEST
BOW SEAT ING
WITH STORAGE
BELOW
OPENING WALK-THROUGH
WINDSHIELD
HEAD COMPARTMENT
(PORTABLE HEAD-STANDARD)
PUMPOUT HEAD-OPTION)
WET BAR WITH SINK &
STORAGE BELOW
HELM SEAT WITH FLIP UP
THIGH RISE BOLSTER
12 VOLT RECEPTACLE
(FWD INSIDE SIDEWALL
STORAGE)
ENGINE BOX
(UNDER CUSHION)
FIRE EXTINGUISHER
DISCHARGE PLATE
ACCESS PANEL TO FRESH
WATER
PUMP & FILTER
TRANSOM DOOR
BOW WALK-THROUGH
DOOR
CONTROL STATION
COMPASS (OPTION)
COCKPIT TABLE
SKI STORAGE HATCH
PORT AMIDSHIP
CLEAT
AFT PORT
CLEAT
AFT STA RBOARD
CLEAT
STA RBOARD
AMIDSHIP
CLEAT
6
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
6. HELM, GAUGE & SWITCH LAYOUT
GAUGE PANEL
FUEL
GAUGE
SPEEDOMETER
SYSTEM
TAC HOMETER
OIL
PRESSURE
WATER
TEMPERATURE
STERN DRIVE
TRIM GAUGE
ACCY
THRU-HULL
EXHAUST
WATER
PUMP
LIGHTS
ANCHOR COCKPITNAV
LIGHT ON - UNIT CHARGED
LIGHT OFF - UNIT DISCHARGED
IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER AND ELECTRICAL SYSTEM
AUTOMATIC EXTINGUISHING SYSTEM
CLARION STEREO REMOTE
S TARBOARD SWITCH PANELPORT SWITCH PANEL
HELM LAYOUT
(FIG. 6.1)
WARNING
GASOLINE VAPORS CAN EXPLODE
RESULTING IN INJURY OR DEATH
!
BEFORE STARTING ENGINE, CHECK ENGINE COMPARTMENT BILGE FOR
GASOLINE OR VAPORS. OPERATE BLOWER FOR FOUR MINUTES,
AND VERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL
IS OPERATING BELOW CRUISING SPEED.
HORN WIPER BILGE
PUMP
BILGE
BLOWER
9
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
11. FIRE EXTINGUISHING SYSTEM
Your 220SD has an automatic fire extinguisher
system option. Refer to the General Information
Manual for a detailed explanation of the automatic
fire extinguisher system.
12. FUEL SYSTEM
The 220 Sundeck standard gasoline fuel system
consists of a 50 gallon (19.3 liter) fuel tank, fuel
tank vent, anti-siphon valve, engine fuel supply line
and fuel fill.
13. WATER SYSTEM
The fresh water system on the 220SD consists of
a 10 gal. (37.9 liter) tank, transom shower, and sink
faucet. Refer to the General Information Manual for
a detailed explanation of the water system.
14. CANVAS
The standard canvas set for the 220 Sundeck®
consists of a bimini top with boot and a cockpit
cover/tonneau cover.
The following canvas options are available.
Aft Curtain
Side Curtains
Canvas Storage Bag
Front Curtain
! DANGER
Exhaust fumes from engines contain deadly carbon
monoxide gas (CO). Boats enclosed with canvas or with
poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea
and dizziness. Do not mistake these symptoms for
sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for
more details.
Do not use the rear (aft) curtain while engine is
running or boat is moving.
15. WATER SPORTS TOWER,
(OPTIONAL)
If equipped, the water sports tower provides a
raised attach point (ski tow pylon) for the ski rope.
The high attach point enables the skier to perform
a wide variety of skills not capable with the lower
transom attach point.
The tower attach point is intended for use only when
towing a single skier. If you are towing multiple skiers
or water toys carrying more than one person use
only the transom attach point. The tower attach point
is NOT intented for towing inflatables.
DO NOT USE TOWER FOR PULLING INFLATABLES.
Use water sports tower for single skier/wakeboarder
only. Use ski tow or stern eyes on transom for all other
tow behind sports. Heavy loads could collapse tower
causing personal injury.
! WARNING
DO NOT USE WATER SPORTS TOWER FOR TOWING
ANOTHER BOAT OR BEING TOWED. TOWER COULD
COLLAPSE AND CAUSE INJURY. SEE OWNER'S
MANUAL FOR INSTRUCTIONS ON TOWING.
! WARNING
WATER SPORTS TOWER (OPTIONAL)
(FIG. 9.1)
8
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
8. CLEATS
Cleats must not be used for lifting the boat; they
are intended for docking or mooring use only.
10. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
CLEAT LOCATIONS
(FIG. 8.1)
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
9. BILGE LAYOUT
BILGE LAYOUT
(FIG. 8.2)
NAVIGATION AND
ANCHOR LIGHTS
(FIG. 8.3)
RED SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
GREEN SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
360
0
WHITE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
STBD NAVIGAT ION
LIGHT
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
PORT NAVIGAT ION
LIGHT
BLOWER
POWER TRIM PUMP
BATTERY, (OPTION)
BATTERY
BILGE PUMP
FUEL TANK
ELECTRIC FUEL VALVE
WATER PUMP AND FILTER
WATER TANK
AUTOMATIC FIRE
EXTINGUISHER, (OPTION)
A
B
C
E
F
G
D
H
I
J
H
G
F
E
B
A
C
D
I
J
9
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
11. FIRE EXTINGUISHING SYSTEM
Your 220SD has an automatic fire extinguisher
system option. Refer to the General Information
Manual for a detailed explanation of the automatic
fire extinguisher system.
12. FUEL SYSTEM
The 220 Sundeck standard gasoline fuel system
consists of a 50 gallon (19.3 liter) fuel tank, fuel
tank vent, anti-siphon valve, engine fuel supply line
and fuel fill.
13. WATER SYSTEM
The fresh water system on the 220SD consists of
a 10 gal. (37.9 liter) tank, transom shower, and sink
faucet. Refer to the General Information Manual for
a detailed explanation of the water system.
14. CANVAS
The standard canvas set for the 220 Sundeck®
consists of a bimini top with boot and a cockpit
cover/tonneau cover.
The following canvas options are available.
Aft Curtain
Side Curtains
Canvas Storage Bag
Front Curtain
! DANGER
Exhaust fumes from engines contain deadly carbon
monoxide gas (CO). Boats enclosed with canvas or with
poor ventilation are most likely to collect fumes.
CO sickness symptoms include headache, nausea
and dizziness. Do not mistake these symptoms for
sea sickness.
Ventilate boat. See Section 1.4, Carbon Monoxide, for
more details.
Do not use the rear (aft) curtain while engine is
running or boat is moving.
15. WATER SPORTS TOWER,
(OPTIONAL)
If equipped, the water sports tower provides a
raised attach point (ski tow pylon) for the ski rope.
The high attach point enables the skier to perform
a wide variety of skills not capable with the lower
transom attach point.
The tower attach point is intended for use only when
towing a single skier. If you are towing multiple skiers
or water toys carrying more than one person use
only the transom attach point. The tower attach point
is NOT intented for towing inflatables.
DO NOT USE TOWER FOR PULLING INFLATABLES.
Use water sports tower for single skier/wakeboarder
only. Use ski tow or stern eyes on transom for all other
tow behind sports. Heavy loads could collapse tower
causing personal injury.
! WARNING
DO NOT USE WATER SPORTS TOWER FOR TOWING
ANOTHER BOAT OR BEING TOWED. TOWER COULD
COLLAPSE AND CAUSE INJURY. SEE OWNER'S
MANUAL FOR INSTRUCTIONS ON TOWING.
! WARNING
WATER SPORTS TOWER (OPTIONAL)
(FIG. 9.1)
8
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
8. CLEATS
Cleats must not be used for lifting the boat; they
are intended for docking or mooring use only.
10. NAVIGATION AND ANCHOR LIGHTS
See General Information Manual for a detailed
explanation of the anchor lights.
CLEAT LOCATIONS
(FIG. 8.1)
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
CLEAT
9. BILGE LAYOUT
BILGE LAYOUT
(FIG. 8.2)
NAVIGATION AND
ANCHOR LIGHTS
(FIG. 8.3)
RED SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
GREEN SIDE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
360
0
WHITE
LIGHT
(VISIBLE 2-
NAUTICAL MILES)
STERN NAV. /
ANCHOR LIGHT
BULB REPLACEMENT
FUSE TYPE BULB
#12V10WPERKO
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
STBD NAVIGAT ION
LIGHT
BULB REPLACEMENT
BULB# GE2641L
12V R 10W
PORT NAVIGAT ION
LIGHT
BLOWER
POWER TRIM PUMP
BATTERY, (OPTION)
BATTERY
BILGE PUMP
FUEL TANK
ELECTRIC FUEL VALVE
WATER PUMP AND FILTER
WATER TANK
AUTOMATIC FIRE
EXTINGUISHER, (OPTION)
A
B
C
E
F
G
D
H
I
J
H
G
F
E
B
A
C
D
I
J
220 Sundeck 11
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
SECTION 5 • ELECTRICAL SYSTEM
DC WIRING DIAGRAM (1 OF 2)
DRAWING NO. 09-603
1. ELECTRICAL SCHEMATICS, 220 SUNDECK
(FIG. 11.1)
10
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
18. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
®
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
®
dealer for service. Sea Ray
®
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
STEREO SYSTEM (12 VOLT AM/FM RADIO & CD)
STEREO
REMOTE
AM/FM RADIO, SINGLE CD UNIT, (LOCATED IN THE PORT GLOVEBOX)
STEREO REMOTE (LOCATED ON THE DASH)
(FIG. 10.2)
(F
IG. 10.3)
Use transom-mounted power trim switch to tilt for trailering
only. Tilting drive unit into trailering zone while underway can
damage the drive unit or engine.
! CAUTION
TRANSOM TRAILER TRIM SWITCH (OPTIONAL)
(FIG. 10.1)
16. TRANSOM TRAILER TRIM SWITCH
(OPTIONAL)
A transom-mounted power trim switch is available
for the convenience of raising the drive unit to
the TRAILERING position while at the rear of the
boat.
17. ENTERTAINMENT SYSTEM
The entertainment system on the 220 Sundeck®
consists of a 12V AM/FM radio, single CD, satellite
ready unit located in the storage area behind the
helm,. The system includes four (4) waterproof
speakers, a digital remote control located on the
control station and an option digital remote located
on the transom.
An optional Premium Cockpit Sound System is
available. It includes a 6-disc CD changer, upgraded
speakers, subwoofer, amplifier and transom stereo
remote.
220 Sundeck 11
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
SECTION 5 • ELECTRICAL SYSTEM
DC WIRING DIAGRAM (1 OF 2)
DRAWING NO. 09-603
1. ELECTRICAL SCHEMATICS, 220 SUNDECK
(FIG. 11.1)
10
220 SUNDECK OWNERS MANUAL
220 Sundeck
Manual Part Number: MRP 1902268
18. ELECTRICAL SCHEMATICS
This owner's manual contains electrical schematics
and wiring harness illustrations for your boat. These
electrical schematics were generated by electrical
CAD designers at the engineering division for
technical reference and service technicians. Sea
Ray
®
does not recommend that you attempt to work
on the boat’s electrical system yourself. Instead,
we recommend that you take your boat to your
authorized Sea Ray
®
dealer for service. Sea Ray
®
reserves the right to change or update the electrical
system on any model at any time without notice to
the consumer and is NOT obligated to make any
updates to units built prior to changes.
STEREO SYSTEM (12 VOLT AM/FM RADIO & CD)
STEREO
REMOTE
AM/FM RADIO, SINGLE CD UNIT, (LOCATED IN THE PORT GLOVEBOX)
STEREO REMOTE (LOCATED ON THE DASH)
(FIG. 10.2)
(F
IG. 10.3)
Use transom-mounted power trim switch to tilt for trailering
only. Tilting drive unit into trailering zone while underway can
damage the drive unit or engine.
! CAUTION
TRANSOM TRAILER TRIM SWITCH (OPTIONAL)
(FIG. 10.1)
16. TRANSOM TRAILER TRIM SWITCH
(OPTIONAL)
A transom-mounted power trim switch is available
for the convenience of raising the drive unit to
the TRAILERING position while at the rear of the
boat.
17. ENTERTAINMENT SYSTEM
The entertainment system on the 220 Sundeck®
consists of a 12V AM/FM radio, single CD, satellite
ready unit located in the storage area behind the
helm,. The system includes four (4) waterproof
speakers, a digital remote control located on the
control station and an option digital remote located
on the transom.
An optional Premium Cockpit Sound System is
available. It includes a 6-disc CD changer, upgraded
speakers, subwoofer, amplifier and transom stereo
remote.
220 Sundeck 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
(FIG. 13.1)
SATELLITE STEREO DIAGRAM
DRAWING NO. 09-615
220 Sundeck12
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
DC WIRING DIAGRAM (2 OF 2)
DRAWING NO. 09-603
(FIG. 12.1)
220 Sundeck 13
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
(FIG. 13.1)
SATELLITE STEREO DIAGRAM
DRAWING NO. 09-615
220 Sundeck12
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
DC WIRING DIAGRAM (2 OF 2)
DRAWING NO. 09-603
(FIG. 12.1)
Index i
220 Sundeck
INDEX
Manual Part Number: MRP 1902268
A
Anchor Lights ...............................................................8
C
Canvas.........................................................................9
Clearances .................................................................. 4
Cleats .......................................................................... 8
D
Deck Layout .................................................................7
Dimensions .................................................................. 4
E
Electrical Schematics ................................................ 10
F
Fire Extinguishing System ........................................... 9
Fuel System .................................................................9
G
Gauge Layout .............................................................. 6
H
Helm Layout.................................................................6
N
Navigation Lights ......................................................... 8
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................2
Switch Layout ..............................................................6
T
Through-Hull Cutouts .................................................. 5
W
Water Sports Tower .....................................................9
Water System ..............................................................9
220 Sundeck14
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
SMARTCRAFT SYSTEM WIRING DIAGRAM
DRAWING NO. 09-710
(FIG. 14.1)
Index i
220 Sundeck
INDEX
Manual Part Number: MRP 1902268
A
Anchor Lights ...............................................................8
C
Canvas.........................................................................9
Clearances .................................................................. 4
Cleats .......................................................................... 8
D
Deck Layout .................................................................7
Dimensions .................................................................. 4
E
Electrical Schematics ................................................ 10
F
Fire Extinguishing System ........................................... 9
Fuel System .................................................................9
G
Gauge Layout .............................................................. 6
H
Helm Layout.................................................................6
N
Navigation Lights ......................................................... 8
P
Passenger Locations ...................................................1
S
Safety Label Locations ................................................2
Switch Layout ..............................................................6
T
Through-Hull Cutouts .................................................. 5
W
Water Sports Tower .....................................................9
Water System ..............................................................9
220 Sundeck14
Manual Part Number: MRP 1902268
Warning:
DO NOT attempt to
work on the electrical system
of this boat without professional
assistance.
ELECTRICAL SCHEMATICS, 220 SUNDECK (CONTINUED)
SMARTCRAFT SYSTEM WIRING DIAGRAM
DRAWING NO. 09-710
(FIG. 14.1)
Specific
Information
Manual
220 Sun Sport
Manual Part Number: MRP 1902268
Manual Part Number: MRP 1902268
THIS PAGE LEFT INTENTIONALLY BLANK
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
Sea Ray 2008 220 SUNDECK is a boat ideal for water sports, fishing and day trips. The boat can hold up to 10 people or 1600 pounds. It has a 6.2 L liter, 320 horsepower engine. The boat is 22 feet long with an 8'6" beam. The fuel capacity is 52 gallons and the water capacity is 15 gallons. The boat has a variety of features including: a swim platform, a bimini top, a stereo system, and a depth finder. The boat also has a variety of storage compartments for gear and supplies. With its spacious layout and powerful engine, the Sea Ray 2008 220 SUNDECK is perfect for a day on the water.
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Sea Ray 2014 SEA RAY 300SLX Owner's manual
-
-
-
-
-
-
-
-
-
