LIFAN LF-168F Owner's manual

LIFAN
Brand
LIFAN
Model
LF-168F
Type
Owner's manual

This manual is also suitable for

!
!
!
!
!
!
!
!
!
!
Operating!Instructions!and!
Owner’s!Manual!
LF160F,!LF168F,!LF168F<2,!LF170!
!
!
PLEASE!READ!THIS!MANUAL!CAREFULLY!BEFORE!OPERATING!YOUR!NEW!
LIFAN!POWER!USA!ENGINE!
(Q)!Indicates!this!Engine!has!a!Keyway!Horizontal!Output!Shaft!
(P)!or!(T)!or!(W)!Indicates!this!Engine!has!a!Threaded!Horizontal!Output!Shaft!
(13111)!Indicates!this!Engine!has!a!Tapered!Horizontal!Output!Shaft!
(R)!Indicates!this!Engine!has!a!2:1!Clutch!Reducer!
(H)!Indicates!this!Engine!has!a!6:1!Gear!Reducer!
(<CA)!Indicates!this!unit!is!CARB!Certified!for!California!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
.!
!"#$%#&'#$(&)*#&
+,"",-./0&./%)'12).,/%3&
!
1. Unit!Shipped!with!“NO!OIL”!in!Engine!or!where!applicable!pumps!and/or!
accessories.!!Check!and!fill!with!proper!oil!as!outlined!in!the!Owner’s!Manual!for!
the!respective!product.!
!
!
2. For!repair!under!Warranty!or!questions!concerning!Warranty,!DO!NOT!return!
this!product!to!the!Store!where!purchased.!!Follow!the!procedures!as!outlined!in!
the!“WARRANTY!POLICY”!and!“WARRANTY!REGISTRATION”!in!the!Owner’s!
Manual.!!!For!any!questions!visit!www.lifanpowerusa.com!or!call!1<866<471<
7464.!
!
!
3. Read!the!“Owner’s!Manual”!prior!to!operating!any!equipment!and!familiarize!
yourself!with!the!proper!and!safe!operation!of!the!equipment.!!If!you!have!any!
questions!visit!www.lifanpowerusa.com!or!call!1<866<471<7464.!
!
!
!
)456&,789:;6&<=8>=?&56&@A:&B49&+A??A758C&<AD9?6E!
!
!
!
!
"+FGH+&
"+FGI+&
"+FGI+JK&
"+FLH&
(Q)!Indicates!this!Engine!has!a!Keyway!Horizontal!Output!Shaft!
(P)!or!)T)!or!(W)!Indicates!this!Engine!has!a!Threaded!Horizontal!Output!Shaft!
(13111)!Indicates!this!Engine!has!a!Tapered!Horizontal!Output!Shaft!
(R)!Indicates!this!Engine!has!a!2:1!Clutch!Reducer!
(H)!Indicates!this!Engine!has!a!6:1!Gear!Reducer!
(<CA)!Indicates!this!unit!is!CARB!Certified!for!California!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
J!
)=M?9&A@&2A8B98B6&
! ! !
Preface! ! 4!
Product!Specifications! 5!
Safety!Instructions! ! 6!
Controls!and!Features! 10! !
PRE<OPERATING!INSTRUCTIONS! 12! !
!Assembly!12! !
!Engine!Setup! 13!
Operation!of!Engine! 16! !
Storing!the!Unit! 19! !
Maintenance! 20! !
Troubleshooting! 24! !
Engine!Safety! 25! !
Limited!Warranty!Policy! 26! !
!
!
!
&
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
C!
!:9@=N9&
Thank! you! for! choosing! LIFAN! Power! USA! for! your! Engine! needs.! ! LIFAN! Power! USA!
prides!itself!on!providing!quality!engines!at!affordable!pricing.!
!
All! LIFAN! Power! USA! products! are! manufactured! utilizing! the! latest! technology.! ! Built!
with! quality! components,! your! new! LIFAN! Power! USA! engine! will! give! you! years! of!
dependable!service.!
!
This!Owner’s!Manual!will!provide!you!with!all!of!your!needed!information!for!your!new!
LIFAN! Power! USA! engine,! including! Safe! Operation! and! Maintenance! of! your! unit.!!
Please!read!this!Owner’s!Manual!completely!and!carefully!prior!to!operation.!!Keep!this!
Owner’s!Manual!for!assistance!in!the!future,!such!as!proper!maintenance!schedules!and!
tips!to!prolong!the!life!and!effective!use!of!your!unit.!!If!you!require!assistance,!please!
visit!our!website!(www.lifanpowerusa.com)!or!call!toll!free!866<471<7464.!!!
!
This!Owner’s! Manual!contains! information!with!respect!to!the!newest!products!at!the!
time! of! publication.! ! Due! to! revision! and! modifications,! the! information! noted! in! the!
Owner’s!Manual!might!vary!from!the!actual!status.!!This!Owner’s!Manual!is!subject!to!
change!without!notice.!!The!copyright!of!this!Owner’s!Manual!belongs!to!EquipSource,!
LLC.!!Any!group!or!individual!is!forbidden!to!reprint!or!copy!any!of!this!Owner’s!Manual!
without!the!written!consent!of!EquipSource,!LLC.!
! !
+,'&$""&-$''$/)O&$/(&%#'P.2#&'#"$)#(&.%%1#%QR1#%).,/%&(,&/,)&'#)1'/&
O,1'&1/.)&),&)*#&%),'#&,'&(#$"#'&-*#'#&)*#&.)#<&-$%&!1'2*$%#(S&&+,'&
%#'P.2#&P.%.)&".+$/&!,-#'&1%$;%&-#T%.)#&U---S".+$/!,-#'1%$S2,<V&,'&2$""&
FJIGGJWLFJLWGWS&&-#&-.""&T#&*$!!O&),&*$/("#&O,1'&-$''$/)O&.%%1#&,'&(.'#2)&
O,1&),&)*#&/#$'#%)&X$1)*,'.Y#(&%#'P.2#&2#/)#'SZ&
&
&
&
&
&
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
0!
&
Model
LF160F
LF168F LF168F,2 LF170
Manufacturer !"#$% !"#$% !"#$% !"#$%
Engine9Type &'()*+,-./01.(2345-.675238-* &'()*+,-./01.(2345-.675238-* &'()*+,-./01.(2345-.675238-* &'()*+,-./01.(2345-.675238-*
Maximum9Horsepower9(MHP) &90: ;<;90: =<;90: >90:
Displacement ??@AA
?=BAA ?C=AA D?DAA
Bore9X9Stroke =EFF.G.&DFF
[email protected].&;FF [email protected].;&FF >EFF.G.;;FF
Compression9Ratio @<;H?
@<;H? @<;H? @<;H?
Engine9Speed B=EE.*IF
B=EE.*IF B=EE.*IF B=EE.*IF
Starting9System99(D9Models9Only)1
J-A+25.KJ-A+25LM5-A)*2AN J-A+25.KJ-A+25LM5-A)*2AN J-A+25.KJ-A+25LM5-A)*2AN J-A+25.KJ-A+25LM5-A)*2AN
Fuel9Tank9Capacity E<==.OP55+3Q E<C;.OP55+3Q E<C;.OP55+3Q E<C;.OP55+3Q
Fuel9Type @>./A)P3-.OPQ+523- @>./A)P3-.OPQ+523- @>./A)P3-.OPQ+523- @>./A)P3-.OPQ+523-
9Engine9Oil9Type9&9Amount ($M.?ERBER.DE+S ($M.?ERBER.DE+S ($M.?ERBER.DE+S ($M.?ERBER.DE+S
Low9Oil9Shutoff9Protection T-Q
T-Q T-Q T-Q
CARB9Certified K'6$N.9+8-5Q./357 K'6$N.9+8-5Q./357 K'6$N.9+8-5Q./357 K'6$N.9+8-5Q./357
Keyway9(Q9Models)9Diameter E<>;.23 E<>;.23 E<>;.23 (I-A2P5./*8-*./357
Threaded9(P9Models)9Diameter (I-A2P5./*8-*./357 (I-A2P5./*8-*./357 (I-A2P5./*8-*./357 (I-A2P5./*8-*./357
Threaded9(T9Models)9Diameter (I-A2P5./*8-*./357 (I-A2P5./*8-*./357 ;[email protected]?@U?<D;.VW*-P8N (I-A2P5./*8-*./357
Threaded9(W9Models)9Diameter
(I-A2P5./*8-*./357 (I-A2P5./*8-*./357 DE.FF (I-A2P5./*8-*./357
Tapered9(131119Models)9Diameter
(I-A2P5./*8-*./357 (I-A2P5./*8-*./357 O-3-*P)+*.M3423- O-3-*P)+*.M3423-
2:19Clutch9Reduction9(R9Model)9Diameter
(I-A2P5./*8-*./357 (I-A2P5./*8-*./357 DEFF (I-A2P5./*8-*./357
6:19Gear9Reduction9(H9Model)9Diameter
E<>;.23 (I-A2P5./*8-*./357 E<>;.23 (I-A2P5./*8-*./357
Length ?=.23 ?=.23 ?=.23 ?=.23
Width ?;.23 ?;.23 ?;.23 ?;.23
Height ?&.23 ?=.23 ?=.23 ?=.23
Dry9Weight BD<;.5XQ [email protected] [email protected] [email protected]
[2F-3Q2+3Q.42\-3.P*-.]+*.^_^.9+8-5Q.+357<../)W-*.M3423-.+I)2+3Q.R255.APZQ-.82F-3Q2+3Q.)+.\P*7<
!#?=@#'DV.Y.=<;90:.;L@^.0+*2S+3)P5.VW*-P8-8./Z)IZ).(WP]).
!#?>>#:.Y.C90:.0+*2S+3)P5.VW*-P8-8./Z)IZ).(WP]).
!#?=@#'D_.Y.=<;90:..0+*2S+3)P5.`-7RP7./Z)IZ).(WP])
#+*.$882)2+3P5.!"#$%.:*+8ZA)."3]+*FP)2+3a.
(AP3.)W-._J.6+8-.)+.)W-.!-])a./*.12Q2).
RRR<52]P3I+R-*ZQP<A+F
@==.>&?'>&=&
1P3.bZ*-3a.$J.>DC;=
DDE;."38ZQ)*2P5.:P*,.J+P8
?.Y./357.^[^.9+8-5Q.WP\-.J-A+25.c.M5-A)*2A.()P*)
Legend
Horizontal9Keyway9Output9Shaft9Dimensions
PRO9SERIES9ENGINES
PRODUCT9SPECIFICATIONS
Horizontal9Output9Shaft9Options
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
@!
%=@9B[&.86B:>NB5A86!
!
&
!
!
!
$(+!K(3+!47F*5K!+*72!5L64!I71378!H7+*F388KE!<*H(I*!F7I6867+!)65L!5L*!G+(G*+!(G*+756(1=!
H7+*=!712!I7615*171H*!(F!K(3+!"#$%&!'()*+!,-%!M*1*+75(+E!
!
NL*!47F*5K!712!78*+5!4KIO(8!P!!!!!!!!!!!!!!!!Q!64!34*2!)65L!7!46M178!)(+2!P!"#$%&'()*"'+,-()."-'%'+Q=!7!G6H5(+678!712R(+!
47F*5K!I*447M*!5(!78*+5!K(3!5(!L7S7+24E!!"#$%&')6126H75*4!7!L7S7+2!5L75=!6F!1(5!7T(62*2=!H(382!+*4385!61!I61(+!(+!I(2*+75*!
61U3+KE!*"'+,-!6126H75*4!7!L7S7+2!5L75=!6F!1(5!7T(62*2=!H(382!+*4385!61!2*75L!(+!4*+6(34!61U3+KE!."-'%'+)6126H75*4!7!
L7S7+2!5L75=!6F!1(5!7T(62*2=!H(382!+*4385!61!2*75L!(+!4*+6(34!61U3+KE!
&
*=\=:D&%[]MA?6&=8D&<9=858C6&
! !
!
!
!
!
!
!
!
!
."-'%'+/)
:31161M!*1M61*!*I654!H7+O(1!I(1(V62*W!71!(2(+8*44=!H(8(+8*44=!G(64(1!M74E!
<+*75L61M!H7+O(1!I(1(V62*!H71!H734*!1734*7!(+!2*75LX!
ONLY%operate%engine%outdoors.%
Exhaust%gas%must%be%prevented%from%entering%confined%areas.%
Direct%exhaust%gas%away%from%windows,%doors,%ventilation%and%other%openings.%
Do%not%operate%engine%inside%or%under%any%buildings.%
Operating%this%engine%inside%the%compartment%of%a%recreational%vehicle%will%likely%result%in%death!!
."-'%'+/!
NL*!*1M61*!*VL7345!!H(157614!HL*I6H784!91()1!5(!5L*!4575*!(F!Y786F(+167!5(!H734*!O6+5L!2*F*H54=!+*G+(23H56T*!L7+I=!
712!H71H*+E!
!
Z(!1(5!34*!5L64!*1M61*!)65L61!5L*!M*1*+75(+!H(IG7+5I*15!(F!7!+*H+*756(178!T*L6H8*X!
NL64!*1M61*!2(*4!1(5!I**5!,E-E!Y(745![37+2!:*M38756(1!JJY$:BDAJ!712!4L(382!1(5!O*!34*2!(1!I7+61*!7GG86H756(14E!
,4*!(F!5L64!*1M61*!(1!I7+61*!7GG86H756(14!H(382!+*4385!61!61U3+K!(+!2*75LE!
NL64!64!5L*!47F*5K!78*+5!4KIO(8E!#5!64!34*2!5(!78*+5!K(3!5(!G(5*15678!G*+4(178!61U3+K!
L7S7+24E!\O*K!788!47F*5K!I*447M*4!5L75!F(88()!5L64!4KIO(8!5(!7T(62!G(446O8*!61U3+K!
(+!2*75LE!
!
!!! !!!!!!!!!!!!!!!!!!!!!!!!! !!!!!!!!!!!!!!!!!!!!!!! !
!!!!!]VG8(46(1!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!$6+*!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!!]8*H5+6H78!
-L(H9!!!!!!!!!!!!!
!!!!! !!!!!!!!!!!!!!!!!!!!!! !!!!!!!!!!!!!!!!!!!!!! !
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
>!
%=@9B[&.86B:>NB5A86&(continued)!
!
."-'%'+/!
!
:7G62!+*H(68!(F!457+5*+!H(+2!P96H9O7H9Q!I7K!G388!L712!712!7+I!F(+)7+2!
5()7+2!*1M61*!75!7!+7G62!+75*E!
<+(9*1!O(1*4=!O+364*4=!4G+7614=!712!F+7H53+*4!I7K!+*4385E!
• ^L*1!457+561M!*1M61*=!G388!H(+2!48()8K!31568!5*146(1!64!F*85=!712!5L*1!G388!+7G628K!5(!7T(62!
96H9O7H9E!
• &*T*+!457+5!(+!45(G!*1M61*!)65L!*8*H5+6H78!2*T6H*4!G83MM*2!61!712!53+1*2!(1E!Z(61M!4(!64!
L7S7+2(34!712!)688!27I7M*!M*1*+75(+E!
."-'%'+/!
!
$3*8!712!654!T7G(+4!7+*!*V5+*I*8K!F87II7O8*!712!*VG8(46T*E!
!
$6+*!(+!*VG8(46(1!H71!H734*!4*T*+*!O3+14!(+!2*75LE!
!
^_]&!%ZZ#&[!\:!Z:%#&#&[!$,]"!
• N3+1!*1M61*!(FF!712!8*5!65!H((8!F(+!75!8*745!5L+**!I6135*4!O*F(+*!+*I(T61M!F3*8!H7GE!"((4*1!H7G!48()8K!61!(+2*+!5(!
+*86*T*!G+*443+*!61!5L*!F3*8!5719E!
• $688!(+!2+761!F3*8!5719!(352((+4E!Z(!1(5!*VH*446T*8K!61L78*!F3*8!T7G(+4E!
• `**G!7)7K!F+(I!(G*1!F87I*4!(+!4G7+94!712!(5L*+!4(3+H*4!(F!6M1656(1E!
• Z(!&\N!4I(9*!)L68*!F68861M!F3*8!5719E!
• Z(!&\N!(T*+F688!5719E!%88()!4G7H*!F(+!F3*8!*VG7146(1E!
^_]&!N:%&-'\:N#&[!\:!:]'%#:#&[!]a,#'b]&N!
• N+714G(+5!*1M61*!)65L!5L*!F3*8!T78T*!61!5L*!(FF!G(4656(1E!
• :*G76+!*1M61*!)65L!5L*!F3*8!5719!*IG5K!(+!5L*!F3*8!T78T*!61!5L*!(FF!G(4656(1E!
• Z64H(11*H5!4G7+9!G83M!)6+*!O*F(+*!5+714G(+5!(+!4*+T6H*E!
^_]&!-N\:#&[!$,]"!\:!]a,#'b]&N!Y\&N%#&#&[!$,]"!
• -5(+*!7)7K!F+(I!F3+17H*4=!45(T*4=!)75*+!L*75*+4=!H8(5L*4!2+K*+4!(+!(5L*+!7GG8671H*4!5L75!L7T*!G68(5!86ML5!(+!(5L*+!
6M1656(1!4(3+H*!O*H734*!5L*K!H71!6M165*!F3*8!T7G(+4E!
^_]&!-N%:N#&[!]a,#'b]&N!
• ]143+*!4G7+9!G83M=!I3FF8*+=!76+!H8*71*+=!712!F3*8!H7G!7+*!61!G87H*E!
• Z(!&\N!H+719!*1M61*!)65L!4G7+9!G83M!+*I(T*2E!
• #F!F3*84!4G6884=!)765!31568!65!*T7G(+75*4!O*F(+*!457+561M!*1M61*E!
^_]&!\']:%N#&[!]a,#'b]&N!
• Z(!1(5!HL(9*!H7+O3+*5(+!5(!45(G!*1M61*E!
• Z(!1(5!56G!*1M61*!(+!*c36GI*15!75!71!71M8*=!)L6HL!H734*4!F3*8!5(!4G688E!
• NL64!*1M61*!64!1(5!F(+!34*!61!I7+61*!7GG86H756(14E!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
A!
%=@9B[&.86B:>NB5A86&(continued)!
!
!"#$%&'/!
]VH*446T*8K!L6ML!(G*+7561M!4G**24!P*1M61*!+*T(8356(14Q!61H+*74*!5L*!+649!(F!61U3+K!712!27I7M*!5(!5L*!*1M61*E!
]VH*446T*8K!8()!4G**24!6IG(4*!7!L*7TK!8(72!712!)688!27I7M*!*1M61*E!
• Z(!&\N!72U345!*1M61*!4G**2!M(T*+1(+E!!
• b(26FK61M!*1M61*!61!71K!)7K!I7K!O*!271M*+(34!712!)688!T(62!)7++715KE!
!
!
!
!
!
."-'%'+/!
!
.0123)345143)16)7844145)93:;37<9873):<=)3>?33@)ABCDE)FGBD!HI)
J37K37)L8746):<=)M??87I)
)
,>0<869)03<9N5<6636)?<4)154193)?M:L8691L236()6978?98736)M7)@<:<53)O832)9<4P)?<86145)<)
O173I!
!
• Z(!&\N!5(3HL!L(5!43+F7H*4!712!2(!7T(62!*VL7345!M744*4E!
• %88()!*1M61*!5(!H((8!O*F(+*!5(3HL61ME!
• `**G!75!8*745!@!F5E!PDAJHIQ!H8*7+71H*!(1!788!462*4!(F!*1M61*!61H83261M!(T*+L*72!H8*7+E!
• :*F8*H56T*!*VL7345!L*75!I7K!27I7M*!F3*8!5719!H73461M!F6+*E!
• Y(2*!(F!$*2*+78!:*M38756(1PY$:Q!N658*!J@!'7+94=!$(+*454=!712!'3O86H!'+(G*+5K!+*c36+*!*c36GI*15!G()*+*2!OK!71!615*+178!H(IO3456(1!
*1M61*!5(!L7T*!7!4G7+9!7++*45*+=!I7615761*2!61!)(+961M!(+2*+=!H(IG8K61M!5(!,-Z%!$(+*45!4*+T6H*!457127+2!0D//BDH!(+!875*+!+*T646(1E!
#1!5L*!4575*!(F!Y786F(+167!7!4G7+9!7++*45*+!64!+*c36+*2!312*+!4*H56(1!CCC.!(F!5L*!Y786F(+167!'3O86H!+*4(3+H*4!H(2*E!
."-'%'+/!
!
,1615*156(178!4G7+961M!H71!+*4385!61!F6+*!(+!*8*H5+6H78!
4L(H9E!
!
^_]&!N]-N#&[!$\:!]&[#&]!-'%:`!
• Z(!&\N!HL*H9!F(+!4G7+9!)65L!5L*!4G7+9!G83M!+*I(T*2E!
• ,4*!7GG+(T*2!4G7+9!G83M!5*45*+E!
^_]&!:]'%#:#&[!\:!%Zd,-N#&[!]&[#&]!
• Z64H(11*H5!5L*!4G7+9!G83M!)6+*!F+(I!5L*!4G7+9!G83M!712!G87H*!5L*!)6+*!)L*+*!65!H711(5!H(157H5!4G7+9!G83ME!!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
?!
%=@9B[&.86B:>NB5A86&(continued)!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!"#$%&'/!
#IG+(G*+!34*!712!H7+*!(F!5L64!*1M61*!)688!H734*!27I7M*!712!4L(+5*1!654!86F*4G71E!$7683+*!5(!F(88()!5L*4*!7H56(14!)688!T(62!788!
)7++7156*4E!
• ,4*!*1M61*!(18K!F(+!7GG+(G+675*!712!2*46M175*2!G3+G(4*4E!
• NL*!2*78*+!(+!H345(I*+!L*8G861*!PDBA@@BC>DB>C@CQ!H71!6145+3H5!K(3!(1!615*12*2!34*4E!
• ]1M61*!I345!O*!G87H*2!(1!7!8*T*8!43+F7H*E!
• Z(!&\N!*VG(4*!]1M61*!5(!*V5+*I*!H(12656(14E!]VH*446T*!2345=!I(6453+*=!712!H(++(46T*!T7G(+4!)688!27I7M*!3165E!
• Y((861M!48(54!I345!O*!9*G5!H8*7+!(F!2*O+64E!
• Z(!1(5!H(11*H5!6IG+(G*+8K!(G*+7561M!2*T6H*4!5(!*1M61*E!
• -L35!(FF!*1M61*!712!579*!5(!7!c3786F6*2!4*+T6H*!H*15*+!6F!5L*!*1M61*!F7684!5(!(G*+75*!G+(G*+8KE!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
D/!
2A8B:A?6&=8D&+9=B>:96!
Read!this!Owner’s!Manual!Completely!and!Carefully!before!Operating!Engine.!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
&
&
&
&
&
&
&
&
&
&
E832)$<4P)!<;)
E832)$<4P)
-3?M12)J9<79145)
Q<4@23)
E832)!M?P)
FR<2K3H)
)
$07M9923)
S3K37)
!0MP3)
S3K37)
!<7L8739M7)
TMU2)*7<14)
"17)!23<437)
,23:349)!MK37)
,>0<869)
R<2K3)
!MK37)
!7<4P?<63)&12)
*1;691?P)N)&12)E122)
QM23)!<;)
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
DD!
2A8B:A?6&=8D&+9=B>:96&(continued)!
!
!
"9C98D&
1. +>9?&)=8^&2=_&–!Vented!Fuel!Cap!Must!be!Properly!Installed!at!all!times!during!
Operation.!
2. +>9?&)=8^&–!Contains!Gasoline!for!Operation.!
3. +>9?&2AN^&UP=?`9V&–!Turn!to!“OFF”!to!Terminate!Fuel!Delivery!to!Engine!
4. '9NA5?&%B=:B58C&*=8D?9&–!Pull!Handle!to!Rotate!Engine!for!Starting.!
5. )4:ABB?9&"9`9:&–!Push!toward!“Rabbit”!for!“FAST”!operation;!Push!toward!
“Turtle”!for!“SLOW”!operation.!
6. 24A^9&"9`9:&–!!
Before!starting!cold!engine,!push!the!Choke!Lever!to!the!“LEFT”!to!activate!
choke.!!After!allowing!engine!to!operate!for!a!few!seconds,!push!Choke!Lever!to!
the!“RIGHT”!designated!by!the!gas!pump!symbol.!
7. 2=:M>:9BA:&TA7?&(:=58!–!Refer!to!Fuel!System!Maintenance!in!the!Maintenance!
Section!of!this!Owner’s!Manual.!
8. 2:=8^N=69&,5?&(5_6B5N^Q,5?&+5??&*A?9&2=_&–!Check/Fill!Engine!Oil.!
9. P=?`9&2A`9:&–!Cover!for!Overhead!Valves!designed!to!be!removed!periodically!
for!valve!adjustments.!
10. $5:&2?9=89:&#?9]98B&2=69!–!Check!Maintenance!Schedule!for!Service!Intervals.!
11. #a4=>6B&–!Avoid!contact;!Only!Ventilate!in!open,!outdoor!areas.!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
D.!
!:9J,_9:=B58C&.86B:>NB5A86E&$669]M?[&
!
Your!LIFAN!Power!USA!engine!is!packaged!without!fuel!and!oil.!!!
!
For!further!assistance,!please!visit!our!website!(www.lifanpowerusa.com)!or!call!1<866<
471<7464!between!the!hours!of!9am<5pm!Monday<Friday.!
!
T,b&2,/)#/)E!
• Engine!
• Owner’s!Manual!and!Warranty!Card!
&
1/!$2c./0&)*#&#/0./#E&
1. Set!the!Carton!on!a!Flat,!Rigid!Surface.!
2. Open!Top!of!Box.!
3. Remove!All!Contents!from!Carton!EXCEPT!Engine.!
4. Open!Box!Completely!by!Cutting!Each!Corner!from!Top!to!Bottom.!
5. Carefully!Lift!Engine!Out!of!the!Box!and!Plastic!and!Set!in!Flat,!Rigid!Surface.!
!
&
&
&
&
&
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
DJ!
!:9J,_9:=B58C&.86B:>NB5A86E&#8C589&%9B>_&
2$1).,/:!!Any!attempt!to!start!the!engine!before!it!has!been!properly!serviced!may!
result!in!engine!failure!and!void!warranty.!
!
$((&#/0./#&,."E!!Refer!to!the!diagrams!below.!
1. Ensure!engine!is!on!level!surface.!
2. Clean!area!around!Oil!Hole!Dipstick/Plug!&!Unscrew!Oil!Hole!Dipstick/Plug.!
3. Fill!with!appropriate!type!and!amount.!!Refer!to!Chart!below!for!recommended!
oil!type!based!on!Environmental!temperature.!
NOTE:!Refer!to!“Product!Specifications”!section!for!universal!recommended!oil!
type!and!oil!amount.!
4. Replace!Oil!Hole!Dipstick/Plug!and!tighten!securely.!
!
!
&
&
&
&
&
&
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
DC!
!:9J,_9:=B58C&.86B:>NB5A86E&#8C589&%9B>_&
(continued)!
!
$((&+1#"E&Refer!to!Controls!and!Features!section!for!diagrams.!
1. Clean!area!around!fuel!cap,!then!remove!fuel!cap.!
2. Pour!fresh,!clean!regular!automotive!grade!unleaded!fuel!with!a!minimum!
octane!rating!of!85!into!fuel!tank.!!Do!NOT!mix!fuel!with!oil.!!Fuel!must!have!
ethanol!blend!of!15%!or!less.!!Pay!close!attention!to!the!storage!requirements!of!
these!fuels.!!Do!NOT!overfill!fuel!tank.!!!
3. Install!the!fuel!cap.!!Rotate!the!fuel!cap!clockwise!until!it!is!in!its!locked!position.!!
Wipe!away!any!spilled!fuel.!
&
2$1).,/E&&Alcohol<blended!fuels!(gasohol,!ethanol,!or!methanol)!will!attract!moisture,!
which!leads!to!separation!and!formation!of!acids!during!storage.!!Acidic!gas!can!damage!
the!fuel!system!of!an!engine!while!in!storage.!!To!avoid!engine!problems,!the!fuel!
system!should!be!treated!with!a!fuel!stabilizer!or!drained!if!the!generator!will!not!be!
started!for!thirty!(30)!days.!!If!using!a!fuel!stabilizer,!follow!the!manufacture’s!
recommended!instructions!for!use.!!Always!use!stabilizer!with!a!full!tank!of!gasoline.!!
Always!drain!old!fuel!and!use!fresh!fuel!before!next!use.!!If!you!do!not!use!a!fuel!
stabilizer,!the!fuel!system!must!be!drained!and!cleaned.!!Drain!the!fuel!tank!and!start!
the!engine,!allowing!it!to!run!until!all!fuel!lines!and!carburetor!are!drained!of!fuel.!!
Before!restarting!the!carburetor.!Float!bowl!must!be!removed!and!cleaned!of!any!
debris.!!
!
/#P#'!use!chemical!solvents!or!cleaners!in!the!fuel!tank!for!damage!may!occur.!
!
."-'%'+/!
!
$3*8!712!654!T7G(+4!7+*!*V5+*I*8K!F87II7O8*!712!*VG8(46T*E!
!
!
$6+*!(+!*VG8(46(1!H71!H734*!4*T*+*!O3+14!(+!2*75LE!
!
!
^_]&!%ZZ#&[!$,]"!
• N3+1!*1M61*!(FF!712!8*5!65!H((8!F(+!7!I616I3I!(F!5L+**!I6135*4!O*F(+*!+*I(T61M!F3*8!H7GE!N3+1!712!+*I(T*!H7G!48()8K!61!
(+2*+!5(!+*86*T*!+*462378!5719!G+*443+*E!
• %8)7K4!F688!5L*!F3*8!5719!)65L!5L*!3165!(352((+4E!
• Z\!&\N!(T*+F688!5719E!%88()!+((I!F(+!F3*8!*VG7146(1E!
• `**G!F3*8!7)7K!F+(I!4G7+94=!(G*1!F87I*4=!L*75=!G68(5!86ML54=!712!(5L*+!6M1656(1!4(3+H*4E!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
D0!
!:9J,_9:=B58C&.86B:>NB5A86E&#8C589&%9B>_&
(continued)!
&
2*#2c&$.'&2"#$/#'&#"#<#/)E!!!
Refer!to!“Air!Cleaner!Maintenance”!in!the!Maintenance!section!of!this!Owner’s!Manual!
to!ensure!Air!Cleaner!Element!is!in!operable!condition.!
!
&
&
&
&
!
!
!
&
&
&
&
&
&
&
&
&
&
&
&
&
&
&
&
&
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
D@!
,_9:=B5A8&A@&#8C589!
*,-&),&1%#&O,1'&#/0./#&
&
#/0./#&",2$).,/E&
!
."-'%'+/)
)
-844145)345143)51K36)MOO)?<7LM4):M4M>1@3)5<6I)%9)16)M@M72366()?M2M72366()<4@)01502=)
9M>1?I)
T73<90145)?<7LM4):M4M>1@3)5<6)?<4)23<@6)9M)O<149145()4<863<)M7):<=)736829)14)@3<90I)
• \18K!(G*+75*!*1M61*!(352((+4E)
• '+*T*15!*VL7345!M74!F+(I!*15*+61M=!5L+(3ML!)612()4!2((+4!(+!T*1568756(1!61579*4=!71K!H(1F61*2!7+*74E)
• Z\!&\N!(G*+75*!*1M61*!61462*!71K!*1H8(4*2!(+!+((F*2!7+*74E!NL64!61H832*4!5L*!M*1*+75(+!H(IG7+5I*15!(F!71K!
+*H+*756(178!T*L6H8*!P:;QE)
!
&
%)$')./0&)*#&#/0./#E!!Refer!to!the!Controls!and!Features!section.!
!
1. Make!sure!the!engine!is!in!a!level!position.!
2. Open!the!fuel!cock!by!turning!the!fuel!cock!to!the!“ON”!position.!!
3. For!cold!engine!starts!only:!!Push!the!Choke!Lever!to!the!“CHOKE”!position.!!
!
!1""&%)$')&U'#2,."V&,/"O&<,(#"%E&
4. Grasp!starter!handle!and!pull!slowly!until!resistance!is!felt.!!Then!pull!the!cord!
rapidly!with!a!full!arm!stroke.!!Allow!the!rope!to!return!slowly.!!Do!NOT!allow!the!
rope!to!snap!back!against!housing.!
5. Once!the!engine!runs!for!3<5!seconds,!push!the!Choke!Lever!to!the!“RUN”!
position,!designated!by!the!gas!pump!icon.!
!
!
!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
D>!
,_9:=B5A8&A@&#8C589!
*,-&),&1%#&O,1'&#/0./#&
UNA8B58>9DV&
&
#"#2)'.2Q!1""&U'#2,."V&%)$')&<,(#"%E&
5. Using!provided!key,!turn!the!key!switch!to!the!“ON”!position.!!Rotate!the!key!one!
more!position!to!the!“START”!position!in!order!to!engage!the!starting!motor.!!
Hold!key!switch!in!the!“START”!position!until!engine!starts!for!NO!MORE!than!10!
engine!rotations.!!If!the!engine!does!NOT!start!repeat!procedures!beginning!with!
Step!One!(1).!
6. Once!the!engine!runs!for!3<5!seconds,!push!the!Choke!Lever!to!the!“RUN”!
position,!designated!by!the!gas!pump!icon.!
!
/,)#&U=??&]AD9?6VE&&If!engine!does!not!start!within!three!pulls,!check!the!crankcase!oil!
level.!!The!engines!“Low!Oil!Alarm!System”!may!be!activated!and!preventing!the!engine!
from!starting.!
&
&
",-&,."&$"$'<&%O%)#<E!
This!model!is!equipped!with!a!Low!Oil!Alert!System!designed!to!avoid!engine!damage!
from!insufficient!oil!in!the!crankcase.!!The!Low!Oil!Alarm!System!will!stop!the!engine!
automatically!before!the!oil!level!in!the!crankcase!drops!below!safe!operating!levels.!!!
&
&
&
&
&
&
&
&
&
&
&
&
&
&
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
DA!
,_9:=B5A8&A@&#8C589!
*,-&),&1%#&O,1'&#/0./#&
UNA8B58>9DV&
%),!!./0&)*#&#/0./#E&&Refer!to!Controls!and!Features!section!for!diagram.!
&
#<#'0#/2O&%*1)(,-/&
1. Turn!the!Fuel!Valve!to!“OFF”!position!
!
/,'<$"&%*1)(,-/!
1. In!order!to!stabilize!internal!equipment!temperatures,!allow!the!engine!to!run!
for!3<5!minutes!under!no!load.!
2. If!the!engine!will!not!be!in!use!for!more!than!7!days,!turn!the!fuel!valve!to!the!
“OFF”!position!and!allow!the!unit!to!run!until!the!fuel!in!the!carburetor!is!used!
and!the!engine!shuts!itself!off.!
3. Turn!the!ignition!switch!to!the!“OFF”!position.!
4. Allow!unit!to!cool!to!ambient!temperature!before!storage!or!transportation.!
5. Always!transport!the!unit!with!the!fuel!valve!in!the!“OFF”!position.!!Failure!to!do!
so!will!result!in!damage!to!the!engine.!
!
)
#J"+,)%')Q%+Q)"S$%$#*,)-,+%&'JV!
#1!+*M6(14!)65L!L6ML!7856532*=!5L*!457127+2!H7+O3+*5(+!G+(23H*4!(T*+8K!2*14*!
H(IO61756(14!(F!F3*8!712!76+=!)L6HL!+*4385!61!2*H+*74*2!*1M61*!G*+F(+I71H*!712!
61H+*74*2!F3*8!H(143IG56(1E!!N(!I7615761!L6ML!*1M61*!G*+F(+I71H*!75!L6ML!7856532*4=!
6145788!7!L6ML!7856532*!H7+O3+*5(+!I761!4G+7K!1(SS8*!712!+*B72U345!5L*!72U34561M!
4H+*)!F(+!628*!4G**2E!!$(+!347M*!61!+*M6(14!)65L!71!7856532*!(F!(T*+!C=0.>F5!PDJA/IQ=!
H(157H5!K(3+!2*78*+!5(!+*G87H*!5L*!457127+2!H7+O3+*5(+!712!I79*!1**2*2!
72U345I*154!61!72T71H*E!!]T*1!)65L!7!G+(G*+!L6ML!7856532*!H7+O3+*5(+!4G+7K!1(SS8*!
6145788*2!61!5L*!*1M61*=!5L*!G()*+!(35G35!(F!5L*!*1M61*!)688!2+(G!7O(35!JE0e!)65L!
*T*+K!D///F5!PJ/0IQ!61H+*74*!61!7856532*E!!#F!5L*!457127+2!H7+O3+*5(+!U*54!7+*!1(5!
+*G87H*2!712!72U345*2!F(+!347M*!61!L6ML!7856532*=!5L*!61H+*74*2!7856532*!*FF*H5!)688!O*!
*T*1!I(+*!4*T*+*E!
'&$,V))#6<53)MO)903)U<937);8:;)14)7351M46)U190)2MU37)<29198@3)90<4)903)0150)
<29198@3)?<7L8739M7)6;7<=)4MWW23)16)<;;21?<L23():<=)736829)14)@3?73<63)MO)
345143);37OM7:<4?3I))$03)345143):<=)L3?M:3)MK3703<93@)<4@)MK37X23<4)
?M:L14<91M4)MO)O832)<4@)<17);7M@8?3@():<=)?<863)63K373)@<:<53)9M)903)345143I)
&
&
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
!
D?!
%BA:58C&B49&185B&
!
%),'$0#E&Refer!to!Controls!and!Features!section!or!diagram!and!definitions.!
!
T9@A:9&?A8C&B9:]&6BA:=C9&A@&[A>:&_A79:&9d>5_]98B&_:AD>NBe&B[_5N=??[&fH&D=[6&A:&]A:9e&
_9:@A:]&B49&@A??A758CE&
1. Set!the!fuel!cock!(valve)!to!the!“OFF”!position.!
2. Let!the!unit!continue!to!run!until!it!stops!itself,!burning!all!of!the!fuel!in!the!fuel!
system.!
3. Turn!the!ignition!switch!to!the!“OFF”!position.!
4. Drain!the!engine!oil!in!accordance!with!the!“Oil!Change!Procedures”!in!this!
Owner’s!Manual’s!Maintenance!section.!!Do!NOT!re<fill!with!oil!until!ready!to!use!
again.!
5. Remove!the!Spark!Plug!in!accordance!with!the!“Spark!Plug!Maintenance”!in!the!
Owner’s!Manual’s!Maintenance!section.!!Spray!a!lubricant,!such!as!WD40®,!into!
the!Spark!Plug!hole!to!lubricate!the!top!of!the!piston!and!walls!of!the!cylinder.!!
Replace!the!Spark!Plug.!
6. Pull!starter!rope!until!resistance!is!felt.!!This!will!place!the!valves!in!the!closed!
position.!
7. Add!the!recommended!amount!of!fuel!stabilizer,!in!accordance!with!the!amount!
recommended!by!the!manufacturer!of!the!fuel!stabilizer,!to!the!unused!gasoline!
left!in!the!fuel!tank.!
8. Place!the!unit!in!a!clean,!dry,!and!secure!location.!
9. Cover!with!canvas/vinyl!tarpaulin.!!Do!NOT!operate!unit!with!cover!installed.!
!
!
!
!
!
!
!
!
!
!
!
!
!
!
"#$%&!'()*+!,-%!
../0!#12345+678!'7+9!:(72!
;71!<3+*1=!%:!>.?0@!
A@@BC>DB>C@C!
)))E86F71G()*+347EH(I!
./!
<=58B98=8N9&
&
<$./)#/$/2#&%2*#(1"#&
!',2#(1'#&
).<#&
Engine!Oil!Check!
Each!Use!
Replace!Engine!Oil!
After!Each!40!Hours!of!Use!(For!Initial!Break!
in!–!After!First!(1st)!10!Hours!of!Use!
Air!Cleaner!Filter!Check!
Each!Use!
Air!Cleaner!Filter!
Replacement!
When!Needed!or!After!Every!100!Hours!of!
Use!
Air!Cleaner!Wash!
When!Needed!
Spark!Plug!
!!
Valve!Clearance!
Check!&!Re<adjust!annually!or!after!300!
Hours!of!Use!
Fuel!Tank!
Replace!Every!3!Years!Based!on!Condition!
&&&&&/,)#E&&Refer!to!Following!Procedures!for!Proper!Method!to!Perform!Maintenance!
&
,."&2*$/0#&!',2#(1'#%E&!Refer!to!Controls!and!Feature!section!for!diagram.!
!9:5AD5N&<=58B98=8N9&A@&[A>:&98C589&A5?&64A>?D&M9&_9:@A:]9D&=@B9:&9=N4&WH&4A>:6&A@&
>69&A@&[A>&!A79:&#d>5_]98B&!:AD>NBS&&249N^&[A>:&98C589&A5?&?9`9?&_:5A:&BA&9=N4&>69S&
1. Start!your!engine!and!let!it!warm!up!to!get!the!oil!warm!and!thinner.!!Turn!the!
engine!On/OFF!switch!to!the!“OFF”!position.!!Turn!Fuel!Valve!to!the!“OFF”!
position.!!!
2. Remove!the!oil!cap/dipstick!by!turning!counter!clockwise.!!Remove!the!oil!drain!
plug!located!below!the!oil!cap/dipstick!utilizing!the!appropriate!tools.!
1%#&2$1).,/E&)*#&,."&<$O&T#&*,)S&
3. Drain!the!engine!oil!into!an!approved!receptacle!and!discard!in!accordance!with!
all!Federal!and!State!Regulations.!!Never!dump!the!used!engine!oil!on!the!ground!
or!into!drains,!only!discard!in!an!approved!manner.!!Check!with!your!local!
authorities!to!determine!the!regulations!in!your!area.!!!
-$'/./03&$P,.(&%!"$%*./0&,+&*,)&,."g&.)&2$/&T1'/&O,1&$/(&2$1%#&
%#P#'#&./h1'OS&
4. After!oil!is!completely!drained,!replace!oil!drain!plug!and!tighten!with!
appropriate!tools.!!Replace!oil!with!the!proper!oil!for!your!product.!Refer!to!the!
Pre<Operating!Instruction:!Generator!Setup!section!for!exact!fill!requirements.!!!
&
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27

LIFAN LF-168F Owner's manual

LIFAN
Brand
LIFAN
Model
LF-168F
Type
Owner's manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents