Expert E200408 User manual

NU-E200408/1216

6 Rue Gustave Eiffel

91420 MORANGIS- France

http://www.expert-tool.com

E200408

NU-E200408_1216OK.indd 1 30/11/2016 14:24:39

Page is loading ...

1/ WARNING:

• TheBOOSTERshouldalwaysbeusedbyskilledpersonnel.

• Warningsandinstructionsofthevehiclemakermustbeappliedatalltimes.

• Wearprotectiongogglesandequipmentspeciedbyregulations.

• Wheneverleftunused,theBOOSTERmustbeincharge.

• Alwayswindandstorethecablesproperlytoavoidanyriskofcontactbetweentheclamps.

• Neverproduceshort-circuits.

• Neverusea12VoltBOOSTERona24Voltvehicle.

• After-salesinterventionsmustbeperformedonlybyEXPERTAfter-sales.

2/ SPECIFICATIONS :

E200408

Usagevoltage

12V

MaxPeakcurrent 1600A

Crankingcurrent 440A

TCFCcurrent* 420A

Batterycapacity 1X12Ah

Batterytype AGM

Batteryreference E200412

CableØ 25mm²

Cabletype Doubleinsulationcopper

Cablelength 60cm

Clips 650AStell/Bronze

Weight 6KG

Fusetype MEGA

Powerfuse 200A

Fusereference E200411

Voltageselection No

Safeties Fuse

Chargertype Automatic2A

INPUTcharger 120-240V50/60hz

OUTPUTcharger DC12V2A

EUchargerreference E200409

UKchargerreference E200410

EN

NU-E200408_1216OK.indd 5 30/11/2016 14:24:42

3/ PARTS LISTS

4/ CHARGING THE BOOSTER

Theboostermustalwaysbelefttochargewhenitisnotbeingused.

Beforechargingyourbooster,makesurethatthecablesarewoundseparatelyontheboosterunitidenticallytothephotoin

thepartslist.

AllEXPERTboostersmustbechargedinventilatedanddrypremises.

OnlyusetheEXPERTE200409orE200410forengland12V2AchargertochargeyourBOOSTER.

Connectthecharger’s«cigarlighter»socketinthebooster.

Connectthechargertothemains.

Theyellowlightontheleftindicatesthattheboosterischarging.

Thegreenlightinthemiddleindicatesthattheboosterischarged.

Theredlightontherightindicatesthatthechargerisnotcorrectlyconnectedtothebooster.

Whentheboosterischargedyoumustleaveitcharging.

TheE200409andE200410chargersareequippedwitha«FLOATING»modewhichkeepstheboosterchargedwithouttherisk

ofdamagingit.

5/ CHECKING THE CHARGE LEVEL

Tocheckyourbooster’schargelevel,youmustmakesurethatitisdisconnectedfromitscharger.

Pressthechargecheckbutton.

Forafullcharge,thevoltmetermustindicate13V.

Youmustonlyusetheboosteriftheneedleisinsidetheyelloworgreenzonesduringthevoltagetest.

Thechargecheckvoltmetermayalsobeusedtocheckthatthevehicle’salternatorischarging.

20secondsafterthevehiclestarts,thevoltmetermustindicate14Vto14.4Vat2000rpm.

6/ USING THE BOOSTER

Beforeusingthebooster,youmustcheckthat:

- Thevehicleiswedged,thetransmissionisinneutralandthatthevehicledoesnotpresentanyfaultsandisingood 

  mechanicalcondition.

- Theoperatorsaretrainedandknowhowtousethebooster.

- Thevehiclemanufacturer’sproceduresarefollowed.

-Checkthatthebooster’schargelevelissufcient.

Cigarlightersocket

Voltagecontrolbutton

Voltmeter

Cableandnegativeclip-

Cableandpositiveclip+

NU-E200408_1216OK.indd 6 30/11/2016 14:24:43

DISPOSAL OF THIS ARTICLE

DearCustomer,Ifyouatsomepointintendtodisposeofthisarticle,thenpleasekeepinmindthat

manyofitscomponentsconsistofvaluablematerials,whichcanberecycled.

Please do not discharge it in the garbage bin, but check with your local council for recycling

facilitiesinyourarea.

-Checkthattheboosterisplacedonastablesurface.

-Firstconnecttheredpositiveclip+tothevehicle’spositiveterminal+thenconnecttheblacknegativeclip-.

-Checkthattheboosteranditscables,oranyotherobjectorperson,arenotincontactornearamobilemechanisminsidethe

 engine.(Beltforexample).

-Startthevehicle.

Caution,makesureyoudonotactivatethestarterforlongerthan8seconds.

-Ifseveraltestsarenecessarytostartthevehicle,wait3minutesbetweentwotests.

-Checkthatthechargelevelissufcientbetweentwotests.

-Afterthevehiclestarts,disconnecttheblacknegativeclip-rstandstorethecableandtheclip,thendisconnectthered

 positiveclip+andstorethecableandtheclip.

7/ POWER FUSE

Theboosterisequippedwithapowerfuse.Itprotectstheboosteragainstaccidentalshortcircuitsonitsterminals

andagainstoverloads.

Tocheckthefuse,simplypressthechargecheckbutton.Ifthechargecheckvoltmeter’sneedledoesnotmove,thismeansthatthe

fuseisdefective.

Youmustremovetheboosterrear’scoverandthefuseinthetopleftwillbeaccessible.Youmustremovethetwo13mmnutstoremoveit.

Caution:OnlyuseanoriginalE200411referencefuse.

8/ GUARANTEE

YourEXPERTBOOSTERisguaranteed1yearfromitsinvoicedateagainstallmanufacturingaws.

ListofexclusionsofguaranteeforEXPERTBOOSTERS.

- Boosteropenorwhichhasbeendisassembled

- Short-circuit.

- Traceofelectricarconclamps.

- Reversedpolarity.

- Continuoususeformorethan10seconds.

- Boosterstoreddischarged.

- Cablesandclampsareexcludedfromtheguarantee.

- Boosterchargedwithachargerotherthantheonesuppliedwithit.

- Traceofshockorimpact.

- Fuses

Boosterbatteriesarewearparts excludedfromthe guarantee.Toincreasethe lifetimeof thebatteries, theymust bemaintained

chargedatalltimes.

Boosterchargersaredesignedtoremainconnectedtomainspermanently,andensuretheirchargeismaintained.

NU-E200408_1216OK.indd 7 30/11/2016 14:24:43

Page is loading ...

NOTA

NU-E200408_1216OK.indd 23 30/11/2016 14:24:48

6 Rue Gustave Eiffel

91420 MORANGIS- France

http://www.expert-tool.com

NU-E200408_1216OK.indd 24 30/11/2016 14:24:48

Expert E200408 User manual

Expert E200408 User manual

in other languages

Related papers

Other documents