Kettler 8852-800 User manual

Brand: Kettler

Model: 8852-800

Category: Bicycles

Type: User manual

AssemblyInstructions

Kiddi‐o

Air‐tireSwift

Model#8852‐800

AdjustableWrench–x1

FlatheadScrewdriver–x1

ToolsNeeded

KETTLER® Int’lInc.

1355LondonBridgeRoadVirginiaBeach,VA23453‐USA

T‐866‐804‐0440/[email protected]/www.kettlerusa.com

PictureSimilar



Readtheseinstructionscarefullybeforeassemblingtheproductorusingitforthefirsttime.They

containimportantinformationforyoursafetyandforthecorrectuseandmaintenanceofthis

product.Keeptheinstructionsinasafeplaceforinformationorfororderingspare parts.



WARNING–*TOAVOIDSERIOUSINJURY*Adultsupervisionrequired.Neveruse

nearsteps,slopes,driveways,hills,roadways,alleys,orswimmingpoolareas.Always

wearshoes.Neverusenearmotorvehicles.Neverallowmorethanonerider.Theuseof

protectivegearandsafetyhelmetishighlyrecommended.Ridersshouldalwaysweara

properlyfittedhelmetthatcomplieswithConsumerProductSafetyCommission(CPSC)

Standard16CFR1203.Adultassemblyrequired.



Caution!AdultAssemblyRequired.Thispackagecontainssmallparts.Keepawayfrom

childrenuntilassembled.



Thisproducthasbeendesignedinaccordancewiththe lateststandardsofsafetyandsubjectedto

constantqualitymonitoring.Thedatagainedfromthisqualityprocessisthenincorporatedinthe

developmentofourproducts.Forthisreason,wereservetherighttomakechangesindesignand

technologyinordertoofferourcus

omersproductsofthehigheststandardofqualityatalltimes.



Foryoursafety

■ Thistricycleshouldbeusedforitsintendedpurposeonly,i.e.one(1)childonly.Itshould

notbeusedinanyotherway,asthismaybedangerous.Themanufacturercannotbeheld

liablefordamageorinjurycausedbyincorrectuse.

■Thisproductisatoyandisnotsuitableforuseintrafficoronpublicroads.

■ Alwayskeepawatchfuleyeonyourchildinordertoavoidrisksbythoughtlessandhasty

move‐

ments.

■Pleasecareforthefactthatthetricycleisonlyusedonsafeground.

■ Thisproductissuitableforchildrenbetween1‐5yearsandlessthan100lbs.Excessive

weightmaycauseahazardousorunstablecondition.

■Thetricycleisanunlightedplayimplement.Itsuseinthedarkisdangerous.

■Thistricycleisdesignedonlyforprivateuse(nocommercialorpublicuse).

■Incaseofasuddenand/orstrongturnofthehandlebarthetricyclecouldbecausedtotip.

Dangerofinjuries!

■Thetricyclemustnotbeconnectedwithothervehicles,sportsorsimilardevicesandnotbe

driven/pulledbythem.Neversubjectyourchildonthetricycletospeeds

exceedingwalking

pace!

■Damagedcomponentsmayendangerthesafetyofyourchildorshortenthelifespanofthepro‐

duct.Inspectitatregularintervalstoensurethatnoneofthecomponentsaredamagedand

thatnoneoftheboltsorotherjointshaveworkedloose.

■ Replacewornordamagedpartsimmediatelyandensurethattheproductisnotusedagainuntil





thishasbeendone.Ifanypartsrequirereplacement,useonlyoriginalsparesmanufactured

byKETTLER®.

UseoftheToy

■ Ensurethatthetricycleisnotuseduntilithasbeenproperlyassembledandcheckedbyan

adultperson.

■Incaseoftricycleswithoutafree‐wheelconsiderthefactthatthepedalswillrotateevenwhen

thetricycleispushed.

■ Donottransportanyobjectsonthetricycle.

■Alwaysadju

sttheuseofthetricycletotheconditionsencountered.

■Tricyclesdonotpossessacontinuouslyeffectivebrakesystem.Therefore,safeguardthetricycle

againstrollingawaywhenparkingit.Neverparkthetricycleunattendedwithachildonit!

■Neverdrawthetricyclebehindyouaslongasachildisseatedonit.

■Instructyourchildhowtousethetricyclecorrectlyanddrawattentiontopossiblesourcesof

danger.

■Althoughdangeroussituationsareunlikelytooccurifthetricycleisusedcorrectly,childrenatplay

should,ifpossible,besupervised.

■Pleasebearinmindthatthereisalwaysadangerofchildreninjuringthemselveswhileusing

swings,climbingframes,toyvehiclesorsimilarequipment.

■Whenchildrenareatplay,situationsmayarisewhichcannotbepredictedbythemanufacturer

andforwhichhecannotbeheldresponsible.

■Beforeuse,alwaysche

ckallscrewsandplug‐inconnectionsaswellasrespectivesafetydevices

fitcorrectly.

■Neverusecorrosiveorabrasivesubstancestocleanthetricycle.Neverusesubstanceswhichmay

causepollutionoftheenvironment.

■Formodelswithpushbars:Alwaysensurethatthepushbarfitscorrectlyintheadaptor,and

locks.Donothanganyweightsonthebar!Thetricyclemaytipover,andyourchildmaybehurt.

Thepushbarisintendedforadultuseonly,donotpassresponsibilityforchildrenontoother

children.Forfreeplaytimetakethepushbaroffforsafetyreasons.

■Formodelswithpneumatictir

es:Duetothenatureofmaterialsusedinpneumatictires,itisnot

recommendedfortheproducttobeleftinanyoneplacefortoolongwheresolventsorother

chemicals,i.e.oil,maylie.Thismayresultinachemicalreaction,whichcouldcausethetiresto

markthesurfacesuchasavinylflooring.Ifindoubtputsomethingunderneaththewheelsto

coverthefloor.Ensurethatairpressureinthetiresiscorrect;ifairpressureistoolowthis

increaseswear,andmakesridingthetricyclemoredifficult!

■Lubricatethebearingsleevesofthewheelsandthehandlebarswithafewdropsofoileverytwo

orthreemonths.



Assemblyofthetoyvehicle

■ Pleaseensurethatthetricyclewillonlybeusedforplayingwhenassemblyhasbeencarriedout

correctly,andchecked,byanadult.

■ Thetricyclemustbeassembledcarefullybyanadultperson.Studytheassemblyinstructions

carefullybeforebeginningwork.Assemblethetricycleintheexactsequenceshownbythe

lettersinthediagrams.Thisisessentialforthesafefunctionanduseofthetricycle.

■ Pleasenotethatthereisalwaysadangerofinjurywhenworkingwithtoolsordoingmanual

work.Thereforepleasebecarefulwhenassemblingthisproduct.

■ Ensurethatyourworkingareaisfreeofpossiblesource

sofdanger,forexampledon’tleaveany

toolslyingaround.Alwaysdisposepackagingmaterialinsuchawaythatitmaynotcauseany

danger.Thereisalwaysariskofsuffocationifchildrenplaywithplasticbags!

■Boltallthepartstogetherlooselyatfirst,andcheckthattheyha

vebeenassembledcorrectly.

Tightenthelocknutsbyhanduntilresistanceisfelt,thenusewrenchtofinallytightennuts

completelyagainstresistance(lockingdevice).Thencheckthatallscrewconnectionshavebeen

tightenedfirmly.Attention:oncelocknutshavebeenunscrewedtheynolongerfunction

correctly(thelockingdeviceisdestroyed),andmustbereplaced.

■ Whenassemblingplasticgrips:Thegripscanbepushedontothehandlebarsmoreeasilyifthey

arefirstsoakedinwarmwater.

■Pleasekeeporiginalpackagingofthisarticle,sothatitmaybeusedfortransport

atalaterdate,

ifnecessary.

■Fortechnicalreasons,wereservetherighttocarryoutpreliminaryassemblywork(e.g.addition

oftubingplugs).



Listofsparepartspage21‐22

Whenorderingspareparts,alwaysstatethefullarticlenumber,spare‐partnumber,thequantity

required.

Exampleorder:Model#8852‐ϴ00/ spare‐partƉŽƐŝƚŝŽŶno1

Pleasekeeporiginalpackagingofthisarticle,sothatitmaybeusedfortransportatalaterdate,if

necessary.Goodsmayonlybereturnedafterpriorarrangementandin(internal)packaging,which

issafefortransportation,intheoriginalboxifpossible.

Itisimportanttoprovideadetaileddefectdescription/damagereport!Important:sparepart

pricesdonotincludefasteningmaterial;iffasteningmaterial(bolts,nuts,washersetc.)isrequired,

thisshouldbeclearlystatedonth

eorderbyaddingthewords„withfasteningmaterial“.

WasteDisposal

KETTLERproductsarerecyclable.Attheendofitsusefullifepleasedisposeofthisarticlecorrectly

andsafely(localrefusesites).



KETTLERInternationalInc.∙1355LondonBridgeRoad∙VA23453USA



www.kettlerusa.

com



THEREARENOWARRANTIES,EXPRESSEDORIMPLIED,MADEBYEITHERTHEDISTRIBUTORORTHE

MANUFACTURERONKETTLER®PRODUCTS,EXCEPTTHEMANUFACTURER’SLIMITEDWARRANTY

AGAINSTDEFECTSINMATERIALSETOUTBELOW:

ThisKETTLER®LimitedWarrantyappliestoproductssoldthroughtheKETTLER®AuthorizedDealer

Networktotheoriginalretailpurchaserandaut

henticatedbyproofofpurchasefromare

tailer

locatedintheUnitedStates.Anyshipmentsmadeunderthiswarrantywillbeshippedtothe

UnitedStatesonly.AnyshipmentoutsideoftheUnitedStateswillbeatthesolecostofthe

customer.ThisKETTLER®LimitedWarrantyisamanufacturer’swarrantyandisnotchangedor

modifiedbyadd

itionalwarrantiesextendedbyindividualretailersatthepointofsale.

Manufacturerwarrantsthisproducttobefreefromdefectsinmaterialatthetimeofthe

product’stenderofdeliveryforaperiodofϯyearforresidentialuse.This LimitedWarrantyisnot

transferableanddoesnotcovernormalwearandtear(including,butnotlimite

dto,damageand

weartotires,powershocks,drivebeltsandothernon‐durableparts).Theliabilityofthe

manufacturerunderthisLimitedWarrantyshallnotincludeanyliabilityfordirect,indirect,or

consequentialdamagesresultingfromthedefe

ct.ThisLimitedWarrantyisvoidiftheproductis

damagedbyaccident,unreasonableuse,improperservice,failuretofollowinstructionsprovided,

modificationfromitsoriginalstate,orothercausesdeterminednotarisingoutofdefectsin

material.



Thiswarrantygivesyouspecificlegalrights.Shouldthisproductbecomedefectiveduetomaterial

withinthewarrantyperiod,contactKETTLER®Parts&ServiceDept.byphoneat866.804.0440,fax

at757.563.9273,ore‐mailat[email protected].

THISLIMITEDWARRANTYISEXPRESSLYINLIEUOFANYOTHERWARRANTIES,EXPRESSEDOR

IMPLIED,INCLUDINGANYIMPLIEDWARRANTYOFMERCHANTABILITYORFITNESSFORA

PARTICULARPURPOSE,

ANDOFANYOTHEROBLIGATIONSORLIABILITYONTHEPARTOFTHE

MANUFACTURER.KETTLER®NEITHERASSUMESNORAUTHORIZESANYOTHERPERSONTO

ASSUMEFORITANYOTHERLIABILITYINCONNECTIONWITHSUCHPRODUCTS.



Page is loading ...

2 2a

Detaching for repairs

Démontage pour réparation

Desmontaje en casa de la reparación

2,5 bar/36 PSI

Re inflate

• The rubber tire needs to be seated cor-

rectly on the rim.

• Squeeze tire to rim as illustrated to achie-

ve correct seating of the tire on the rim

whilst inflating.

• It is advisable to inflate the tire with the

aid of a compressor usually found at your

local garage. Tire needs to be inflated

quickly.

Hinchado de los neumáticos

• El neumático deshinchado debe estar cor-

rectamente montado sobre la llanta.

• Durante el hinchado, adapte el neumático

a los bordes de la llanta ejerciendo una

presión uniforme sobre el mismo (ver ilu-

stración).

• Hinche el neumático con un compresor,

como el que p. ej. puede encontrar en una

gasolinera. Un neumático debe ser hincha-

do con rapidez y de forma uniforme.

Gonflage

• Le pneu en caoutchouc droit être posi-

tionné correctement sur la jante.

• Appuyer le pneu sur la jante comme

illustré afin d’obtenir le bon positionne-

ment durant le gonflage.

• Il est conseillé de gonfler le pneu a l’ai-

de d’un compresseur généralement

disponible dans votre garage local. Un

pneu nécessite un gonflage rapide.

USA

Spare Parts Drawing for Model 8852-500

Spare Parts Drawing for Model #8852-800

Pos.ηescriptioŶYty.

1 FrontFrame 1

2 RearFrame 1

3 Fork 1

FrontWheel 1

5 Rear

Wheel 2

6 WheelCoverw/ValveHoleforFrontWheel 1

7 WheelCoverw/outValve

HoleforFrontWheel(notshown) 1

8 Handlebar 1

9 Seat 1

10 Fender 1