015
p/n PL015 Rev.A 070212 cps
SERVICE PARTS LIST
PL015
Built-In Heat 'N Hold Warmer
HW-106D
HW/SMP-6D
CONTENTS
Description page
Parts List ………………………………………………….. 2
HW-106D ………….………………………………………. 3
HW/SMP-6D ……………………………………………….. 4
PART # DESCRIPTION
ACCESSORIES FOR HW-106D
20822 ADAPTER TOP 1 x 4QT INSET
20175 ADAPTER TOP 1 x 7QT INSET
22592 WELLSLOK EXTENSION KIT (to 1½")
ACCESSORIES FOR HW/SMP-6D
20176 ADAPTER TOP 2 x 7QT STD 12x20
20434 ADAPTER TOP 2 x 4QT & 2 x 2½QT
21615 ADAPTER TOP 3 x 4QT INSET
21617 ADAPTER TOP 1 x 7QT & 1 x 4QT
21621 ADAPTER TOP 1 x 7QT & 1 x 11QT
21624 ADAPTER TOP 4 x 2½QT INSET
ACCESSORIES FOR HW-WARMERS
20385 DRAIN VALVE EXTENSION KIT
20587 ROUND INSET & LID 7QT
20773 ROUND INSET & LID 2½QT
20774 ROUND INSET & LID 4QT
20908 ROUND INSET & LID 11QT
21057 ROUND INSET w/ HINGED LID 11QT
21709 DRAIN SCREEN
2
PART # DESCRIPTION
MECHANICAL
50291 CLAMP THERMOSTAT BULB
51023 CONTROL PANEL HW-SMP
51038 RETAINER, TRADEMARK (pk 10)
51779 SLEEVING, GLASS 9" (pk 10)
53848 CASTING, TRADEMARK
55992 POT ASSY HW-10
56196 INSULATION 1"x9" 4RL 300SQFT
57946 RING, SAFETY THERMO .040D
60516 CLAMP ELEM HW/SMP
64802
TOP & PAN ASSY HW/SMP
ELECTRICAL
53068 TERMINAL BLOCK 2P
54136 FITTING FLEX CONDUIT 1/2 x90º
55687 LIGHT SIGNAL RED #8 RING
55693 ELEMENT HEATING 120V HW-106
55966 LIGHT SIGNAL GREEN #8 RING
55967 ELEMENT HEATING 240V HW-106
55972 KNOB THERMO HW-106
55984 THERMO HW-106 6' CAP TUBE
60457 ELEMENT HEATING 240V HW/SMP
60509 THERMO CTRL HW-SMP
62896 CONNECTOR WIRE 12-14ga (pk 5)
62898 CONNECTOR WIRE 10-14ga
65149 WIRE 14ga N-MGT 2000' RL
PART # DESCRIPTION
HARDWARE, etc.
18-84 NUT 8-32 Ni
18-302 NUT 8-32 SS
50177 WASHER FIBER ½"
51040 BUSHING HEYCO
7
/
8
"
51053 NUT 8-32 KEPS (pk 100)
51718 SCREW 8-32 x
3
/
16
PH HD Ni (PK 10)
53935 SCREW #6 x ¼ SMS (pk 100)
53977 SCREW 8-32 x
3
/
8
PHBD (pk 100)
54284 POP RIVET
3
/
32
D x
1
/
8
55135 SCREW 6-32 x ¼ RD (pk 25)
55137 NUT TNZ 8-32
55736 NUT 8-32 KEPS GREEN (PK 10)
65193 SCREW 8-32 x ½ PH FL (pk 50)
PL015 Parts List for Built-In Heat 'N Hold Warmer HW-106D HW/SMP-6D
3
PL015 Parts List for Built-In Heat 'N Hold Warmer HW-106D HW/SMP-6D
HW-106D COMPONENTS HW-106D
50177
53068
51040
55736
55984
55966 (green)
55687 (red)
55972
OFF
WELLS
21ºC
24
35
46
54
66
74
82
96
70ºF
75
93
115
130
150
1
6
5
180
205
21709
55992
50177
57946
50291
55693 (120V)
55967 (240V)
part of
55984
8706-109 (CONDUIT
FITTING ONLY)
4
PL015 Parts List for Built-In Heat 'N Hold Warmer HW-106D HW/SMP-6D
HSW/SMP-6D COMPONENTS
64802
21709
make from 56196
(150' roll)
make from
56050
(150' roll)
50177
51040
55736
60509
55972
OFF
WELLS
21ºC
2
4
35
46
54
66
74
82
96
70ºF
75
93
115
130
150
1
6
5
180
205
8706-109 (CONDUIT
FITTING ONLY)
50291
57946
60457 208/240V
51023
55687
60516
60516
THIS PAGE BLANK
5
PL015 Parts List for Built-In Heat 'N Hold Warmer HW-106D HW/SMP-6D
/
