Lanier Worldwide, Inc.
2300 Parklake Dr., N. E.
Atlanta, GA 30345-2979
Emergency Telephone: (800) 526-4371
MATERIAL SAFETY DATA SHEET
Section 1: Chemical Product and Company Information
Identity:
Toner for 1210, 1240, 1260, 1205
MSDS No.
FX-071
Product ID: 491-0282 Issued:
02/06/2004
Synonyms
& Common
Names:
Uses:
Chemical
Formula:
Toner for Lanier 1210, 1240, 1260, 1205
Fax
Lanier 1210, 1240, 1260, 1205 Fax
Mixture
Supersedes:
Date:
Prepared by:
Approved by:
European Contact:
08/12/2002
02/06/2004
Lanier Worldwide, Inc. EH&S Department
(770) 496-9500
Larry Choskey, Manager, EH&S
Lanier Worldwide, Inc., Manager, Safety &
Environment, Walter Fricke,
Im Taubental D-41468 Neuss, Germany
+49-2131-387-177
Section 2: Composition / Information on Ingredients
PERCENT CAS No. EXPOSURE LIMITS SOURCE
Polyester resin > 85 Confidential Not listed n/a
Carbon black 1 – 5 1333-86-4 3.5 mg/m
3
, 3.5 mg/m
3
6 mg/m
3
OSHA TWA, ACGIH TLV
MAK
Polyolefin wax 1 – 5 Confidential Not listed N/a
Organic pigment 1 – 5 Confidential Not listed N/a
Quaternary ammonium salt 1 – 5 Confidential Not listed N/a
*PEL as the product: 15mg/m
3
(total dust), 5mg/m
3
(respirable dust)
*TLV as the product: 10mg/m
3
(total dust), 5mg/m
3
(respirable dust)
Section 3: Hazards Identification
HMIS Rating:
FLAMMABILITY = 1 HEALTH = 1
REACTIVITY = 0 SPECIAL = none
Health Hazards (Acute, Chronic, Immediate and Potential): Minimum irritation to respiratory tract may occur as with exposure to any non-
toxic dust. May cause gasping if inhaled. Inhalation should be avoided. May cause temporary eye discomfort.
Health Hazards of Long Term exposure (Chronic): A manufacturer sponsored chronic inhalation study in rats using a special test toner
revealed there were no lung changes at all in the lowest exposure level (1mg/m
3
), the most relevant level to potential human exposures. A very
slight degree of fibrosis was noted in 25% of the animals at the middle exposure level (4mg/m
3
), while a slight degree of fibrosis was observed
at the highest exposure level (16mg/m
3
) in all animals. These findings are attributed to “Lung Overloading”, a generic response to excessive
amount of any dust retained in the lungs for a prolonged interval. The special test toner was ten times more respirable than commercially
available toner to comply with EPA testing protocol and would not function properly in Xerographic equipment.
Carbon Black is listed on the IARC Monograph and the Massachusetts Substance List. The IARC has evaluated the evidence for the
carcinogenicity of Carbon Black as inadequate to determine a carcinogenic risk for humans.
This product contains no known hazardous materials as defined by the OSHA Hazard Communication Standard 29 CFR 1910.1200.
Section 4: First Aid Measures
Inhalation:
Remove to fresh air if effects occur. Get medical
attention if needed.
Eye Contact:
In case of contact, immediately flush eyes with
water for 5 minutes. Get medical attention if
needed.
Skin Contact: Wash with soap and water. Ingestion:
Dilute stomach contents with several glasses
of water. Get medical attention.
Section 5: Fire Fighting Measures
Suitable extinguishing media: CO
2
, dry chemical, foam or water.
Extinguishing media which may not be used for safety reasons: none
Explosion limits: n/a
This material will burn in case of fire. The decomposition products are CO, CO
2
, and No
x
. Avoid inhalation of smoke.
Special protective equipment for fire fighters: none
LEL: n/a UEL: n/a
MATERIAL SAFETY DATA SHEET
Page 2 of FX-071
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions.
On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the usual precautionary measures
for dealing with chemicals.
Section 6: Accidental Release Measures
Spill / leak Procedures: If spilled, sweep up using an approved toner vacuum with a 0.5 micron filter or smaller, such as the Atrix AAA Toner
Vacuum or 3M Toner Vacuum. Use of a vacuum cleaner not rated for toner particles, could result in a fire or personal injury. Remove residue
with soap and cold water.
Miscellaneous: Keep product out of sewers and watercourses.
Personal protection: Avoid inhalation of dust.
Section 7: Handling and Storage
Special Handling: Cleanse skin after contact before breaks or meals, and end of workday.
Special Storage: Avoid direct sunlight. Keep out of reach of children. Store in a cool, dry place.
Section 8: Exposure Control and Personal Protection Information:
Ventilation: Local exhaust
Respiratory Protection: Nuisance dust respirator. Hand Protection: none required under normal use.
Eye Protection: Safety goggles. Skin Protection: Gloves.
Section 9: Physical and Chemical Properties
CHARACTERISTICS:
Appearance: Black Melting point: 120 - 130ºC
Form: Powder Vapor pressure: n/a
Odor: Faint odor Vapor density: n/a
Solubility in Water: Negligible Evaporation rate: n/a
Specific gravity: 1.2 Ignition temp. 450ºC
Section 10: Stability and Reactivity
Conditions to avoid: Electronic discharge or throwing into fire Materials to avoid: Oxidizing materials Stability: Stable
Hazardous decomposition products: CO and CO2 and other decomposition products when burned.
Section 11: Toxicological Information:
Acute oral toxicity (rat) LD
50
: Over 5.0 g/kg Acute Inhalation: LC
50
(4H) is in excess of 0.74 g/m
3
(rat)
Mutagenicity: Ames Test result: Negative Dermal: LD50 Over 2.0 g/kg (rat)
Skin sensitizer: None indicated (Guinea-pig) Eye Irritation: Not an irritant (rabbit)
Section 12: Environmental / Ecological Information
Mobility: No data is available on the adverse effects of this material on the environment.
Persistence/Degradability: No data is available on the adverse effects of this material on the environment.
Bioaccumulation: No data is available on the adverse effects of this material on the environment.
Ecotoxicity: Behavior in Sewage works: No data is available on the adverse effects of this material on the environment.
Aquatic Toxicity: No data is available on the adverse effects of this material on the environment.
Ecological Data (EC) Csb Value (EC): No data is available on the adverse effects of this material on the environment.
AOX-Remark (EC): No data is available on the adverse effects of this material on the environment.
BsB5 Value (EC): No data is available on the adverse effects of this material on the environment.
Significant Components (EC): Not applicable
Section 13: Disposal Consideration
Used Toner should be disposed of under conditions that meet all federal, state and local environmental regulations. Disposal regulations vary
from locality to locality; therefore consult your local Lanier office or the EPA to determine the proper method for disposal.
Section 14: Transportation Information
Special Precautions: None
International Transport Information: UN Classification number: None DOT Identification number: None
MATERIAL SAFETY DATA SHEET
Page 3 of FX-071
Information on this data sheet represents our current data and best opinion as to the proper use in handling of this product under normal conditions.
On the basis of the data available to us, this product is not a dangerous substance. One should, however, observe the usual precautionary measures
for dealing with chemicals.
Domestic Transportation : n/a Land RID(EC): None ADR(EC): None Inland Waterways ADNR (Rhine R.): None Sea: IMDG: None Air: ICAO-TI:
None IATA-DGR: None
Section 15: Regulatory Information
OSHA Hazard Communication Standard, 29 CFR 1910.1200: Not regulated
TSCA: All chemical substances in this product comply with all applicable rules or orders under TSCA
RCRA, 40 CFR 261: Not regulated
NTP Annual Report on Carcinogens: Not listed as a NTP carcinogen
IARC: See Section 11
California Proposition 65: Neither toner, nor any of its components, are listed as chemicals known to the state of California to cause cancer.
Controlled Products Regulations (Canada): This product has been classified in accordance with the hazard criteria of the CPR.
Other State Regulations: Carbon Black is listed in the New Jersey Right To Know List, Pennsylvania Hazardous Substance List and
Massachusetts Substance List.
U.S. / Canada Label Standards: LOW HAZARD FOR RECOMMENDED HANDLING. Minimize dust generation and accumulation. Use with
adequate ventilation.
EU Information
Label Information according to Directives 67/548 EEC & 88/379 EEC:
Symbol & Indication: Not required Risk Phase: Not required Safety Advice Phase: Not required
EEC Directive (76/548 EEC, 79/831, 92/32 EEC): All chemical substances in this product comply with all applicable rules or order under EEC
Directive.
Section 16: Miscellaneous Information
Notice: Judgments as to the suitability of information contained herein for purchaser’s purposes are the purchaser’s
responsibility. Therefore, although reasonable care has been taken in the preparation of such information, Lanier Worldwide,
Inc. extends no warranties, makes no representations, and assumes no responsibility as to the accuracy or suitability of such
information for application to purchaser’s intended purposes or for consequences of its use. All materials may present
unknown hazards and should be used with caution. Although certain hazards are described within, we do not guarantee that
these are the only hazards, which exist.
References: IARC (1996) IARC Monographs on the Evaluation of the Carcinogenic Risks of Chemical to Humans, Vol. 65,
Printing Processes and Printing Inks, Carbon Black and Some Nitro Compounds, Lyon, pp. 149-261.
H. Muhle, B. Bellmann, O. Creutzenberg, C. Dasenbrock, H. Ernst, R. Kilpper, J.C. MacKenzie, P. Morrow, U. Mohr, S. Takenaka,
and R. Mermelstein (1991).
Pulmonary Response to Toner upon Chronic Inhalation Exposure in Rats, Fundamental and Applied Toxicology 17, pp 280-299.
Abbreviations:
(1) OSHA PEL ; Permissible Exposure Limit under Occupational Safety and Health Administration. (USA)
(2) ACGIH TLV; Threshold Limit Value under American Conference of Governmental Industrial Hygienists. (USA)
(3) DFG-MAK; Maximale Arbeitsplatzkonzentrationen under Deutsche Forschungsgemeinschaft.
(4) TWA; Time Weighted Average.
(5) IARC; International Agency for Research on Cancer.
(6) NTP; National Toxicology Program. (USA)
(7) NIOSH; National Institute for Occupational Safety and Health. (USA)
(8) DOT; Department of Transportation. (USA)
-
1
-
2
-
3
Lanier 491-0282 User manual
- Category
- Toners & Laser Cartridges
- Type
- User manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
Panasonic FP7750 Important information
-
Sharp MX-M753 Product information
-
Sharp AR-C160 Product information
-
Sharp MX-2300N Product information
-
-
Sharp DX-C310 Product information
-
-
-
Sharp AR-BC260 Product information
-
Sharp MX-M1100 Product information