Cateye CC-VL520 Owner's manual

CC-VL820 / 520 ENG 1

Before using the computer, please thoroughly read this

manual and keep it for future reference.

Warning / Caution

• Donotconcentrateonthecomputerwhileriding.Ridesafely!

• Installthemagnet,sensor,andbracketsecurely.Checktheseperiodi-

cally.

• Ifachildswallowsabattery,consultadoctorimmediately.

• Donotleavethecomputerindirectsunlightforalongperiodoftime.

• Donotdisassemblethecomputer.

• Donotdropthecomputertoavoidmalfunctionordamage.

• Whencleaningthecomputer,bracketandsensor,donotusethinners,

benzene,oralcohol.

• Disposeofusedbatteriesaccordingtolocalregulations.

• LCDscreenmaybedistortedwhenviewedthroughpolarizedsunglass

lenses.

CATEYE

VELO 9 / VELO 7

CYCLOCOMPUTER

CC-VL820 / CC-VL520

Maintenance

• Tocleanthecomputeroraccessories,usedilutedneutraldetergent

onasoftcloth,andwipeitoffwithadrycloth.

• Ifthegapsbetweenthebuttonsandtheunitgetcloggedwithmudor

sand,washthemawaywithwater.

Replacing the battery

Whenthedisplaybecomesdim,replacethe

battery.Installanewlithiumbattery(CR2032)

withthe(+)sidefacingupward.

*Afterreplacingthebattery,besuretosetthe

unitagainaccordingtotheprocedurespeci-

edin“Preparingthecomputer”(page3).

Troubleshooting

No display.

Isbatteryinthecomputerrundown?

Replacewithnewbatteriesaccordingtotheprocedurespecied

inthesection“Replacingthebattery”.

Incorrect data appear.

Followtheproceduredescribed“Preparingthecomputer”(page3).

Current speed does not appear.(First,short-circuitthecontactofthe

computerafewtimeswithapieceofmetal.Ifcurrentspeedappears,

thecomputerisworkingneandthecauseshouldbeattributedtothe

bracketorthesensor.)

Isthewirebroken?

Eveniftheoutsideofthewirelooksnormal,therecouldbe

damage.Replacethebracketsensorkitwithanewone.

Istheclearancebetweenthesensorandthemagnettoolarge?

Arethemagnet’scenterandthesensor’smarkinglinealigned?

Re-adjustthepositionsofthemagnetandthesensor.

(Theclearanceshouldbelessthan5mm.)

Isthereanythingstickingonthecontactofthecomputerorthe

bracket?

Cleanthecontactwithacloth.

COIN

CR2032

Open

Speciﬁcation

Battery/Batterylife

Lithiumbattery(CR2032)x1/Approx.3year

*Thefactory-loadedbatterylifemightbeshorterthantheabove-mentionedspecication.

Controller 4bit,1-chipmicrocomputer(Crystalcontrolledoscillator)

Display Liquidcrystaldisplay

Sensor Nocontactmagneticsensor

Tiresizetobe

selected

26”,700c,27”,16”,18”,20”,22”and24”,ortirecircumferenceof

100cm-299cm(initialvalue:26inch)

Working

temperature

32°F-104°F(0°C-40°C)(Thisproductwillnotdisplayappropri-

atelywhenexceedingtheWorkingTemperaturerange.Slowresponse

orblackLCDatlowerorhighertemperaturemayhappenrespectively.)

Dimensions/weight

2-3/16”x1-15/32”x5/32”(55.5x37.5x18.5mm)/1.06oz(30g)

*Thespecicationsanddesignaresubjecttochangewithoutnotice.

Limited warranty

2-Year: Computer only

(Accessories/Bracket sensor and Battery Consumption excluded)

CatEyecyclecomputersarewarrantedtobefreeofdefectsfrommaterialsandworkmanship

foraperiodoftwoyearsfromoriginalpurchase.Iftheproductfailstoworkduringnormal

use,CatEyewillrepairorreplacethedefectatnocharge.ServicemustbeperformedbyCat-

Eyeoranauthorizedretailer.Toreturntheproduct,packitcarefullyandenclosethewarranty

certicate(proofofpurchase)withinstructionforrepair.Pleasewriteortypeyournameand

addressclearlyonthewarrantycerticate.Insurance,handlingandtransportationchargesto

CatEyeshallbebornebypersondesiringservice.

ForUKandREPUBLICOFIRELANDconsumers,pleasereturntotheplaceofpurchase.This

doesnotaffectyourstatutoryrights.

2-8-25,Kuwazu,HigashiSumiyoshi-ku,Osaka546-0041Japan

Attn:CATEYECustomerServiceSection

Phone :(06)6719-6863 Fax :(06)6719-6033

E-mail :[email protected] URL :http://www.cateye.com

[For US Customers]

CATEYE AMERICA, INC.

2825WildernessPlaceSuite1200,BoulderCO80301-5494USA

Phone :303.443.4595 TollFree :800.5CATEYE

Fax :303.473.0006 E-mail :[email protected]

Partskit Bracket

sensorkit

Wheel

magnet

Lithium

battery

Spare accessories

Standard accessories

1603390

1603391

1603491

1665150

CR2032

1699691N

Optional accessories

Heavydutybracket

sensorkit

In use

CC-VL820 / 520 ENG 2

How to install the unit on your bicycle

5 mm

WhenattachingtheFlexTight™brackettothestem

Attach the bracket to the stem or handlebar

Install the sensor and magnet 3

Route the wire

TheFlexTight™bracketcanbeattachedtoeitherthestemorthehandlebar,dependingonhowthebrackettsintothe

bracketband.

Remove/Install

the computer

Sensor

Nylonties

(x7)

Magnet

Nylonties

NylontiesHandlebar

Click

Whilesupportingitbyhand,

Pushitoutasiflifting

thefrontup

Stem

Bracket Wire

Double-sidedtape

Bracket

Double-sidedtape

Pull

securely

Magnet

Spoke

Magnet

SENSOR ZONE

Sensor

Magnet

Sensor

Nylonties

SENSOR

ZONE

Tothe

SENSOR ZONE

WhenattachingtheFlexTight™brackettothehandlebar

Install the sensor and magnet

Themagnetpassesthroughthe

sensorzone.

Theclearancebetweenthesen-

sorandmagnetis5mmorless.

Caution:

Adjust the wire length so that it may not be pulled when the

handle is operated.

*Themagnetmaybein-

stalledanywhereonthe

spokeiftheaboveinstal-

lationconditionsaresatis-

ed.

Pullsecurely

NO!

Cut

CC-VL820 / 520 ENG 3

Operation test

Afterinstalled,checkthatthecomputerdisplaysthespeedbyturning

thefrontwheel.Whenitisnotdisplayed,checktheinstallationcondi-

tions and again(page2).

Preparing the computer

Performtheclearalldataoperationasshownbelow,whenyouusethe

unitforthersttimeorrestoretheunittotheconditioncheckedatthe

factory.

1 Clear all data (initialization)

PresstheACbuttononthebackofthecomputer.

2 Select the speed unit

Select“km/h”or“mph”.

MODE

km/h ↔ mph

SET

setting

3 Set the tire size

Setthetiresizebyeitheroneofthefollowingmethods.

Simplesetting(selectfromthetiresize)

PressingtheMODEbuttonchanges26” → 700c

→ 27” → 205[] → 16” → 18” → 20” → 22” →

24” → 26”inorder.Selectthetiresize(inch)of

yourbicycle,andthenpresstheSETbutton.

*Generally,thetiresizeisindicatedontheside

ofthetire.

MODE

Switchingsize

SET

thesetting

MODE

Pressandholdtothe

MODEbuttonwith

“205[]”displayedto

changetothewheel

sizeentryscreen.

Detailedsetting(enterthenumericvalueofthetirecircumference)

*Enteringthetirecircumferenceensuresmoreaccuratemeasure-

ments.

1

With205[]displayedonthescreen,pressand

holdtheMODEbutton.

2

PressingtheMODEbuttonincreasesthenu-

mericvalueflashing,whereaspressingand

holdingtheMODEbuttonmovesthedigit.En-

teranyvalueofthecircumferenceincm,and

thenpresstheSETbutton.

*Use“Tirecircumferencereferencetable”asa

guide.

MODE

Increase

thevalue

MODE

Movedigits

(Press&

hold) SET

setting

Tire circumference

Youcanndthetirecircumference(L)ofyourtiresizeinthechartbe-

low,oractuallymeasurethetirecircumference(L)ofyourbicycle.

• How to measure the tire circumference (L)

Forthemostaccuratemeasurement,doawheelroll

out.Withthetiresunderproperpressure,placethe

valvestematthebottom.Markthespotontheoor

andwiththerider’sweightonthebike,rollexactlyone

wheelrevolutioninastraightline(untilthevalvecomesaroundagainto

thebottom).Markwherethevalvestemisandmeasurethedistance.

• Tire circumference reference table

*Generally,thetiresizeorETRTOisindicatedonthesideofthetire.

L cm

ETRTO Tire size L (cm)

47-203 12x1.75 94

54-203 12x1.95 94

40-254 14x1.50 102

47-254 14x1.75 110

40-305 16x1.50 119

47-305 16x1.75 120

54-305 16x2.00 125

28-349 16x1-1/8 129

37-349 16x1-3/8 130

32-369 17x1-1/4(369) 134

40-355 18x1.50 134

47-355 18x1.75 135

32-406 20x1.25 145

35-406 20x1.35 146

40-406 20x1.50 149

47-406 20x1.75 152

50-406 20x1.95 157

28-451 20x1-1/8 155

37-451 20x1-3/8 1625

37-501 22x1-3/8 177

40-501 22x1-1/2 179

47-507 24x1.75 189

50-507 24x2.00 193

54-507 24x2.125 197

25-520 24x1(520) 175

24x3/4Tubuler 179

28-540 24x1-1/8 180

32-540 24x1-1/4 191

25-559 26x1(559) 191

32-559 26x1.25 195

37-559 26x1.40 201

40-559 26x1.50 201

47-559 26x1.75 202

50-559 26x1.95 205

54-559 26x2.10 207

ETRTO Tire size L (cm)

57-559 26x2.125 207

58-559 26x2.35 208

75-559 26x3.00 217

28-590 26x1-1/8 197

37-590 26x1-3/8 207

37-584 26x1-1/2 210

650CTubuler

26x7/8 192

20-571 650x20C 194

23-571 650x23C 194

25-571 650x25C

26x1(571) 195

40-590 650x38A 213

40-584 650x38B 211

25-630 27x1(630) 215

28-630 27x1-1/8 216

32-630 27x1-1/4 216

37-630 27x1-3/8 217

18-622 700x18C 207

19-622 700x19C 208

20-622 700x20C 209

23-622 700x23C 210

25-622 700x25C 211

28-622 700x28C 214

30-622 700x30C 215

32-622 700x32C 216

700CTubuler 213

35-622 700x35C 217

38-622 700x38C 218

40-622 700x40C 220

42-622 700x42C 222

44-622 700x44C 224

45-622 700x45C 224

47-622 700x47C 227

54-622 29x2.1 229

60-622 29x2.3 233

MODE AC

SET

Batterycasecover

Contact

4 Set the Clock

1

PressingtheMODEbuttonswitches“24h”and

“12h”.Selecteitheroneofthedisplayformats,

andthenpresstheSETbutton.

2

PressingtheMODEbuttonincreasesthenu-

mericvalueflashing,whereaspressingand

holdingtheMODEbuttonswitches“Hour”to

“Minute”.

MODE

12h ↔ 24h,orin-

creasesthevalue

MODE

Switchthe

screenormove

digits

5 Press the SET button to complete setting

PresstheSETbuttonwiththecurrentclockdisplayed.Then,theunit

settingiscompleted,andtheunitchangestotheMeasuringscreen.

SET

(Finish)

Displayformat

Hour Minute

CC-VL820 / 520 ENG 4

Power-saving function

Ifthecomputerhasnotreceivedasignalfor10minutes,power-saving

screenwillactivateandonlytheclockwillbedisplayed.Whenthecom-

puterreceivesasensorsignal,themeasuringscreenreappears.

MODE

Calorie Consumption(VL820)*2

Thiscomputermeasuresthecalorieconsumptionbyintegratingthevalue

calculatedfromthespeedineverysecond.Checkitasareferencevalue.

Speed 10km/h[mph] 20km/h[mph] 30km/h[mph]

Kcalperhour 67.3kcal

[155.2kcal]

244.5kcal

[768.2kcal]

641.6kcal

[2297.2kcal]

How to calculate the Carbon offset(VL820)*3

TheCarbonoffsetarecalculatedasfollows.

Tripdistance(km)x0.15=Carbonoffset(kg)

*Thisfactorof0.15isdeterminedbyapplyingtheaveragevalueofthe

overallgasoline-poweredpassengercarsin2008totheequationofthe

“Carbonoffsetfrom1kmdriveofagasoline-poweredcar”described

onthewebsiteoftheMinistryofLand,InfrastructureandTransportand

Tourism.

Operating the computer [Measuring screen]

Switching computer function

PressingtheMODEbuttonswitchesthemeasurementdataatthebottom

intheordershowninthefollowinggure.

*1: WhenTMexceedsabout27hours,orDSTexceeds999.99km,

.Ewillappear.

Resetthedata.

*2,*3: TobedisplayedonlywithVL820.

Current speed

0.0(4.0)–199.9km/h

[0.0(3.0)–124.9mph]

Pace arrow

Indicatesifthecurrentspeedisfasteror

slowerthantheaveragespeed.

(Faster, Slower)

Speed unit

Measuring screen

VELO 7 VELO 9 Power-saving screen

10minutes

How to change tire size

DisplaytheTotalDistance(ODO)andpress

theSETbuttontochangethetiresize.

Thesettingmethodisthesameasfor“Pre-

paringthecomputer-3”(page3).

How to set clock

Intheclockmode,pressSETbuttononthe

back,andthedisplayentersclocksetting

mode.

Thesettingmethodisthesameasfor“Pre-

paringthecomputer-4”(page3).

TMElapsedTime

0:00.00–9:59.59

DSTTripDistance

0.00–999.99km[mile]

AVAverageSpeed

(*1)

0.0–199.9km

[0.0–124.9mph]

MXMaximumSpeed

0.0–199.9km/h

[0.0–124.9mph]

CAL

CalorieConsump-

tion

(*2)

0–99999kcal

CO2Carbonoffset

(*3)

0.00–999.99kg

ODOTotalDistance

0–99999km[mile]

Clock

0:00–23:59

[1:00–12:59]

MODE

(Press&hold)

SET

Starting/Stopping measurement

Measurementsstartautomaticallywhenthebicycleisinmotion.

Duringmeasurement,km/hormphashes.

START STOP

Resetting data

PressingandholdingMODEonthemeasuringscreen

returnsthemeasurementdatato0.

*Thetotaldistance(ODO)isnotreset.

Startmeasurement Stopmeasurement

Cateye CC-VL520, CC-VL820, Velo 9 Owner's manual

Related papers

Other documents