2. Sports & recreation
  3. Bicycles & accessories
  4. Bicycle accessories
  5. Cateye
  6. Velo 9 [CC-VL820]
Velo 9 [CC-VL820]

Cateye Velo 9 [CC-VL820], Velo 7 [CC-VL520] User manual

  • Hello! I am an AI chatbot trained to assist you with the Cateye Velo 9 [CC-VL820] User manual. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
  • What is the battery life of the Cateye Velo 9?
    What is the working temperature range of the Cateye Velo 9?
    How do I replace the battery in the Cateye Velo 9?
    What if the display becomes dim?
    How do I set the tire size on the Cateye Velo 9?
    How do I set the clock on the Cateye Velo 9?
    What should I do if the Cateye Velo 9 is not displaying speed?
VELO 9 / VELO 7 ENG 1
Before using the computer, please thoroughly read this
manual and keep it for future reference.
Warning / Caution
• Donotconcentrateonthecomputerwhileriding.
Ridesafely!
• Installthemagnet,sensor,andbracketsecurely.
Checktheseperiodically.
• Ifachildswallowsabattery,consultadoctorimmediately.
• Donotleavethecomputerindirectsunlightforalongperiodoftime.
• Donotdisassemblethecomputer.
• Donotdropthecomputertoavoidmalfunctionordamage.
• Whencleaningthecomputer,bracketandsensor,donotusethinners,
benzene,oralcohol.
• Riskofexplosionifbatteryisreplacedbyanincorrecttype.
Disposeofusedbatteriesaccordingtolocalregulations.
• LCDscreenmaybedistortedwhenviewedthroughpolarizedsunglass
lenses.
CATEYE
VELO 9 / VELO 7
CYCLOCOMPUTER
CC-VL820 / CC-VL520
Maintenance
• Tocleanthecomputeroraccessories,usedilutedneutraldetergent
onasoftcloth,andwipeitoffwithadrycloth.
• Ifthegapsbetweenthebuttonsandtheunitgetcloggedwithmudor
sand,washthemawaywithwater.
Replacing the battery
Whenthedisplaybecomesdim,replacethe
battery.Installanewlithiumbattery(CR2032)
withthe(+)sidefacingupward.
*Afterreplacingthebattery,besuretosetthe
unitagainaccordingtotheprocedurespeci-
edin“Preparingthecomputer”(page3).
Troubleshooting
No display.
Isbatteryinthecomputerrundown?
Replacewithnewbatteriesaccordingtotheprocedurespecied
inthesection“Replacingthebattery”.
Incorrect data appear.
Followtheproceduredescribed“Preparingthecomputer”(page3).
Current speed does not appear.
(First,short-circuitthecontactofthecomputerafewtimeswithapiece
ofmetal.Ifcurrentspeedappears,thecomputerisworkingneandthe
causeshouldbeattributedtothebracketorthesensor.)
Isthewirebroken?
Eveniftheoutsideofthewirelooksnormal,therecouldbe
damage.Replacethebracketsensorkitwithanewone.
Istheclearancebetweenthesensorandthemagnettoolarge?
Arethemagnet’scenterandthesensor’smarkinglinealigned?
Re-adjustthepositionsofthemagnetandthesensor.
(Theclearanceshouldbelessthan5mm.)
Isthereanythingstickingonthecontactofthecomputerorthe
bracket?
Cleanthecontactwithacloth.
COIN
CR2032
Close
Open
Specification
Battery/Batterylife
Lithiumbattery(CR2032)x1/Approx.3year
*Thefactory-loadedbatterylifemightbeshorterthantheabove-mentionedspecication.
Controller 4bit,1-chipmicrocomputer(Crystalcontrolledoscillator)
Display Liquidcrystaldisplay
Sensor Nocontactmagneticsensor
Tiresizetobe
selected
26”,700c,27”,16”,18”,20”,22”and24”,ortirecircumferenceof
100cm-299cm(initialvalue:26inch)
Working
temperature
32°F-104°F(0°C-40°C)(Thisproductwillnotdisplayappropri-
atelywhenexceedingtheWorkingTemperaturerange.Slowresponse
orblackLCDatlowerorhighertemperaturemayhappenrespectively.)
Dimensions/weight
2-3/16”x1-15/32”x5/32”(55.5x37.5x18.5mm)/1.06oz(30g)
*Thespecicationsanddesignaresubjecttochangewithoutnotice.
Limited warranty
2-Year: Computer only
(Accessories/Bracket sensor and Battery Consumption excluded)
CatEyecyclecomputersarewarrantedtobefreeofdefectsfrommaterialsandworkmanship
foraperiodoftwoyearsfromoriginalpurchase.Iftheproductfailstoworkduringnormal
use,CatEyewillrepairorreplacethedefectatnocharge.ServicemustbeperformedbyCat-
Eyeoranauthorizedretailer.Toreturntheproduct,packitcarefullyandenclosethewarranty
certicate(proofofpurchase)withinstructionforrepair.Pleasewriteortypeyournameand
addressclearlyonthewarrantycerticate.Insurance,handlingandtransportationchargesto
CatEyeshallbebornebypersondesiringservice.ForUKandREPUBLICOFIRELANDcon-
sumers,pleasereturntotheplaceofpurchase.Thisdoesnotaffectyourstatutoryrights.
PleaseregisteryourCatEyeproductonthewebsite.
http://www.cateye.com/en/support/regist/
2-8-25,Kuwazu,HigashiSumiyoshi-ku,Osaka546-0041Japan
Attn:CATEYECustomerServiceSection
Phone :(06)6719-6863 Fax :(06)6719-6033
E-mail :[email protected] URL :http://www.cateye.com
[For US Customers]
CATEYE AMERICA, INC.
2825WildernessPlaceSuite1200,BoulderCO80301-5494USA
Phone :303.443.4595 TollFree :800.5.CATEYE
Fax :303.473.0006 E-mail :[email protected]
Partskit
Bracket
sensorkit
Wheel
magnet
Lithium
battery
Spare accessories
Standard accessories
1603390
1603391
1603491
1665150
CR2032
1699691N
Optional accessories
Heavydutybracket
sensorkit
In use
U.S.Pat.No.6957926&DesignPatented
Copyright©2015CATEYECo.,Ltd.
CCVL82/52-150206
1
VELO 9 / VELO 7 ENG 2
How to install the unit on your bicycle
5 mm
WhenattachingtheFlexTight™brackettothestem
1
Attach the bracket to the stem or handlebar
2
Install the sensor and magnet
3
Route the wire
TheFlexTight™bracketcanbeattachedtoeitherthestemorthehandlebar,dependingonhowthebrackettsintothe
bracketband.
Remove/Install
the computer
Sensor
Nylonties
(x7)
Magnet
Nylonties
Nylonties
Nylonties
NylontiesHandlebar
Click
Whilesupportingitbyhand,
Pushitoutasiflifting
thefrontup
Stem
Bracket Wire
Double-sidedtape
Bracket
Bracket
Bracket
Bracket
Double-sidedtape
Double-sidedtape
Pull
securely
Magnet
Spoke
Magnet
Magnet
SENSOR ZONE
Sensor
Sensor
Magnet
Sensor
Sensor
Nylonties
Nylonties
SENSOR
ZONE
Tothe
SENSOR ZONE
WhenattachingtheFlexTight™brackettothehandlebar
Install the sensor and magnet
Themagnetpassesthroughthe
sensorzone.
Theclearancebetweenthesen-
sorandmagnetis5mm(3/16”)
orless.
Nylonties
Nylonties
Magnet
Magnet
Nylonties
Caution:
Adjust the wire length so that it may not be pulled when the
handle is operated.
*Themagnetmaybein-
stalledanywhereonthe
spokeiftheaboveinstal-
lationconditionsaresatis-
ed.
1
2
Pullsecurely
Pullsecurely
OK
NO!
Cut
Cut
Cut
(3/16”)
VELO 9 / VELO 7 ENG 3
Operation test
Afterinstalled,checkthatthecomputerdisplaysthespeedbyturning
thefrontwheel.Whenitisnotdisplayed,checktheinstallationcondi-
tions
and again(page2).
Preparing the computer
Performtheclearalldataoperationasshownbelow,whenyouusethe
unitforthersttimeorrestoretheunittotheconditioncheckedatthe
factory.
1
Clear all data (initialization)
PresstheACbuttononthebackofthecomputer.
2
Select the speed unit
Select“km/h”or“mph”.
MODE
km/h
↔
mph
SET
Registerthe
setting
3
Set the tire size
Setthetiresizebyeitheroneofthefollowingmethods.
Simplesetting(selectfromthetiresize)
PressingtheMODEbuttonchanges26”
→
700c
→
27”
→
205[]
→
16”
→
18”
→
20”
→
22”
→
24”
→
26”inorder.Selectthetiresize(inch)of
yourbicycle,andthenpresstheSETbutton.
*Generally,thetiresizeisindicatedontheside
ofthetire.
MODE
Switchingsize
SET
Register
thesetting
MODE
Pressandholdtothe
MODEbuttonwith
“205[]”displayedto
changetothewheel
sizeentryscreen.
Detailedsetting(enterthenumericvalueofthetirecircumference)
*Enteringthetirecircumferenceensuresmoreaccuratemeasure-
ments.
1
With205[]displayedonthescreen,pressand
holdtheMODEbutton.
2
PressingtheMODEbuttonincreasesthenu-
mericvalueflashing,whereaspressingand
holdingtheMODEbuttonmovesthedigit.En-
teranyvalueofthecircumferenceincm,and
thenpresstheSETbutton.
*Use“Tirecircumferencereferencetable”asa
guide.
MODE
Increase
thevalue
MODE
Movedigits
(Press&
hold)
SET
Registerthe
setting
AC
Tire circumference
Youcanndthetirecircumference(L)ofyourtiresizeinthechartbe-
low,oractuallymeasurethetirecircumference(L)ofyourbicycle.
• How to measure the tire circumference (L)
Forthemostaccuratemeasurement,doawheelroll
out.Withthetiresunderproperpressure,placethe
valvestematthebottom.Markthespotonthefloor
andwiththerider’sweightonthebike,rollexactlyone
wheelrevolutioninastraightline(untilthevalvecomesaroundagainto
thebottom).Markwherethevalvestemisandmeasurethedistance.
• Tire circumference reference table
*Generally,thetiresizeorETRTOisindicatedonthesideofthetire.
L cm
ETRTO Tire size L (cm)
40-254 14x1.50 102
47-254 14x1.75 110
40-305 16x1.50 119
47-305 16x1.75 120
54-305 16x2.00 125
28-349 16x1-1/8 129
37-349 16x1-3/8 130
32-369 17x1-1/4(369) 134
40-355 18x1.50 134
47-355 18x1.75 135
32-406 20x1.25 145
35-406 20x1.35 146
40-406 20x1.50 149
47-406 20x1.75 152
50-406 20x1.95 157
28-451 20x1-1/8 155
37-451 20x1-3/8 1625
37-501 22x1-3/8 177
40-501 22x1-1/2 179
47-507 24x1.75 189
50-507 24x2.00 193
54-507 24x2.125 197
25-520 24x1(520) 175
24x3/4Tubular 179
28-540 24x1-1/8 180
32-540 24x1-1/4 191
25-559 26x1(559) 191
32-559 26x1.25 195
37-559 26x1.40 201
40-559 26x1.50 201
47-559 26x1.75 202
50-559 26x1.95 205
54-559 26x2.10 207
57-559 26x2.125 207
58-559 26x2.35 208
75-559 26x3.00 217
28-590 26x1-1/8 197
ETRTO Tire size L (cm)
37-590 26x1-3/8 207
37-584 26x1-1/2 210
650CTubular
26x7/8
192
20-571 650x20C 194
23-571 650x23C 194
25-571
650x25C
26x1(571)
195
40-590 650x38A 213
40-584 650x38B 211
25-630 27x1(630) 215
28-630 27x1-1/8 216
32-630 27x1-1/4 216
37-630 27x1-3/8 217
40-584 27.5x1.50 208
50-584 27.5x1.95 209
54-584 27.5x2.1 215
57-584 27.5x2.25 218
18-622 700x18C 207
19-622 700x19C 208
20-622 700x20C 209
23-622 700x23C 210
25-622 700x25C 211
28-622 700x28C 214
30-622 700x30C 215
32-622 700x32C 216
700CTubular 213
35-622 700x35C 217
38-622 700x38C 218
40-622 700x40C 220
42-622 700x42C 222
44-622 700x44C 224
45-622 700x45C 224
47-622 700x47C 227
54-622 29x2.1 229
56-622 29x2.2 230
60-622 29x2.3 233
MODE
AC
SET
Batterycasecover
Contact
4
Set the Clock
PressingandholdingtheMODEbuttonswitchesthe
displayto“Displayformat”,“Hour”,and“Minute”in
order.
MODE
12h
↔
24h,or
increasesthe
value
MODE
Switchthe
screenormove
digits
5
Press the SET button to complete setting
PresstheSETbuttonwiththecurrentclockdisplayed.Then,theunit
settingiscompleted,andtheunitchangestotheMeasuringscreen.
SET
Registerthesetting
(Finish)
Displayformat
Hour Minute
Displayformat
VELO 9 / VELO 7 ENG 4
Calorie Consumption(VL820)*2
Thiscomputermeasuresthecalorieconsumptionbyintegratingthevalue
calculatedfromthespeedineverysecond.Checkitasareferencevalue.
Speed 10km/h[mph] 20km/h[mph] 30km/h[mph]
Kcalperhour
67.3kcal
[155.2kcal]
244.5kcal
[768.2kcal]
641.6kcal
[2297.2kcal]
How to calculate the Carbon offset(VL820)*3
TheCarbonoffsetarecalculatedasfollows.
Tripdistance(km)x0.15=Carbonoffset(kg)
*Thisfactorof0.15isdeterminedbyapplyingtheaveragevalueoftheover-
allgasoline-poweredpassengercarsin2008totheequationofthe“Carbon
offsetfrom1kmdriveofagasoline-poweredcar”describedontheweb-
siteoftheMinistryofLand,InfrastructureandTransportandTourism.
Operating the computer [Measuring screen]
Switching computer function
PressingtheMODEbuttonswitchesthemeasurementdataatthebottom
intheordershowninthefollowinggure.
*1: WhenTMexceedsabout27hours,orDSTexceeds999.99km,
.Ewillappear.
Resetthedata.
*2,*3: TobedisplayedonlywithVL820.
Current speed
0.0(4.0)–199.9km/h
[0.0(3.0)–124.9mph]
Pace arrow
Indicatesifthecurrentspeedisfasteror
slowerthantheaveragespeed.
(
Faster, Slower)
Speed unit
VELO 7 VELO 9
How to change tire size
DisplaytheTotalDistance(ODO)andpress
theSETbuttontochangethetiresize.
Thesettingmethodisthesameasfor“Pre-
paringthecomputer-3”(page3).
How to set clock
Intheclockmode,pressSETbuttononthe
back,andthedisplayentersclocksetting
mode.
Thesettingmethodisthesameasfor“Pre-
paringthecomputer-4”(page3).
TM
ElapsedTime
0:00.00–9:59.59
DST
TripDistance
0.00–999.99km[mile]
AV
AverageSpeed
(*1)
0.0–199.9km
[0.0–124.9mph]
MX
MaximumSpeed
0.0–199.9km/h
[0.0–124.9mph]
CAL
CalorieConsump-
tion
(*2)
0–99999kcal
CO2
Carbonoffset
(*3)
0.00–999.99kg
ODO
TotalDistance
0–99999km[mile]
Clock
0:00–23:59
[1:00–12:59]
SET
SET
Starting/Stopping measurement
Measurementsstartautomaticallywhenthebicycleisinmotion.
Duringmeasurement,km/hormphflashes.
START STOP
Resetting data
PressingandholdingMODEonthemeasuringscreen
returnsthemeasurementdatato0.
*Thetotaldistance(ODO)isnotreset.
Power-saving function
Ifthecomputerhasnotreceivedasignalfor10minutes,power-saving
screenwillactivateandonlytheclockwillbedisplayed.Whenthecom-
puterreceivesasensorsignal,themeasuringscreenreappears.
MODE
Startmeasurement Stopmeasurement
MODE
(Press&hold)
Measuring screen Power-saving screen
10minutes
or
How to change the total distance
DisplayDST,andthenpresstheSETbutton
toswitchtothetotaldistancemanualinput
screen.PresstheMODEbuttontoincrease
thevalue.PressandholdtheMODEbutton
tomovetothenextdigit.
PresstheSETbuttontoconrmthevalue.
*Onlywholenumberscanbeentered.(0–99999km[miles])
SET
/