B&B Electronics ZZ24D-NB-SR Datasheet

www

elec

com

Zlinx

™

Wireless Modbus I/O - ﬂexible enough to ﬁt your applications.

Theseplug-n-playunitscombinetraditionalModbusRTUremoteanalog

anddiscreteI/Owithbuilt-inwirelessconnectivity.WirelessRTUservesas

ModbusslaveRTUinradio-basedSCADAsystems,orasapeer-to-peer

communication platform.

Two Ranges Available - Short, Long range.

Active Repeaters -Withbuilt-inrepeaterfunctionalityon900MHz-LR

models, you can ensure vital signals get through.

Modular - Just snap on your I/O and you are ready to communicate.

Wide Temperature - Meets most indoor or outdoor applications.

Rugged circuitry - prevents signal degradation.

128 / 256 Bit AES Encryption - Secures data.

Selectable RF Transmit Power-Allowsyoutooptimizethetransmitter

power for your application.

Selectable Over-the-air Data Rate-AllowsyoutodecreasetheOTA

DataRate(on-LRand-LR-AUversions),effectivelyincreasingtheradio

transmitter’s range.

Exception Reporting - In Modbus mode, allows the reporting of possible

problems with connected devices.

Fail Safe - Allows you to set I/O to a safe state in the event of a

communications failure.

Calibration - Calculates correction factors to make I/O values better

match your sensor.

Communications Failure Alarm-AllowstherstDOtobeconguredas

a COM failure alarm indicator.

Invert Output -YoucaninvertthelogicofallDO’sinpeer-to-peermode.

Monitor-UsetheZlinx™ManagerSoftwaretomonitoryourI/O.

• Modular,CustomizableWire

Replacement

• Flexiblecongurationformultiple

types of analog/digital I/Os

• SoftwareSelectableRFTransmitPower

• SoftwareSelectableOver-the-airData

Rate

• ModbusASCII/RTUCompatible

• 900MHzand2.4GHzVersions

• WideOperatingTemperature

• ActiveRepeaterFunctionality

• 10to40VDC&24VACInputPower

• AESEncryption

ORDERING INFORMATION

MODEL NUMBER DESCRIPTION

ZZ8D-XX-LR Base Modules *

ZZ8D-NA-LR 868MHz,2AI,2A0,2DI,2D0Sourcing,LongRange

ZZ8D-NB-LR 868MHz,4DI,4D0Sourcing,LongRange

ZZ8D-NC-LR 868MHz,2AI,2A0,2DI,2D0Sinking,LongRange

ZZ8D-ND-LR 868MHz,4DI,4D0Sinking,LongRange

ZZ9D-XX-LR Base Modules *

ZZ9D-NA-LR 900MHz,2AI,2AO,2DI,2DOSourcing,LongRange

ZZ9D-NA-LR-AU 900MHz,2AI,2AO,2DI,2DOSourcing,LongRange

ZZ9D-NB-LR 900MHz,4DI,4DOSourcing,LongRange

ZZ9D-NB-LR-AU 900MHz,4DI,4DOSourcing,LongRange

ZZ9D-NC-LR 900MHz,2AI,2AO,2DI,2DOSinking,LongRange

ZZ9D-NC-LR-AU 900MHz,2AI,2AO,2DI,2DOSinking,LongRange

ZZ9D-ND-LR 900MHz,4DI,4DOSinking,LongRange

ZZ9D-ND-LR-AU 900MHz,4DI,4DOSinking,LongRange

ZZ24D-XX-SR Base Modules*

ZZ24D-NA-SR 2.4GHz,2AI,2AO,2DI,2DOSourcing,ShortRange

ZZ24D-NB-SR 2.4GHz,4DI,4DOSourcing,ShortRange

ZZ24D-NC-SR 2.4GHz,2AI,2AO,2DI,2DOSinking,ShortRange

ZZ24D-ND-SR 2.4GHz,4DI,4DOSinking,ShortRange

ACCESSORIES

ZZ-PROG1-USB ZlinxUSBProgrammingModule,Cable,SoftwareCD

ZZ24D-ANT1 2.4GHzSpareAntenna

ZZ9D-ANT1 900MHzSpareAntenna

ZZ-DIN1 ReplacementDINClipandSpring

ZZ-TB1 ReplacementTerminalBlockKit

PRODUCT FEATURES

Peer-to-Peer and Modbus I/O

Zlinx Standard Wireless I/O

MODEL NUMBER DESCRIPTION

Expansion Modules

ZZ-8DI-DC 8DigitalInputs,10-48VDC

ZZ-8DO-T 8DigitalOutputsSourcing

ZZ-8DO-T1 8DigitalOutputsSinking

ZZ-8DO-R 8 Relay Outputs

ZZ-4AI 4 Analog Inputs

ZZ-4AO

4 Passive Source Analog Inputs,

RequiresIsolatedExternalPowerSupply

ZZ-4AO-2 4 Analog Output Sourcing

ZZ-4RTD1 4RTDInput

ZZ-4DI4DO-DCT 4DigitalInputs,10-48VDC,4DigitalOutputsSourcing

ZZ-4DI4DO-DCT1 4DigitalInputs,10-48VDC,4DigitalOutputsSinking

ZZ-2AI2AO 2 Analog Inputs, 2 Analog Outputs

World-wide.

Check with your local distributor for availability and options.

*Checkwirelessregulations/standardsinyourgeographicarea.

Zlinx Standard Wireless I/O_3713ds

International Ofﬁce: 707 Dayton Road PO Box 1040 Ottawa, IL 61350 USA 815-433-5100 Fax 433-5104

European Ofﬁce: Westlink Commercial Park Oranmore Co. Galway Ireland +353 91 792444 Fax +353 91 792445

orders@bb-elec.com

support@bb-elec.com

Peer-to-Peer and Modbus I/O

Zlinx Standard Wireless I/O

SPECIFICATIONS

BASE MODULE RADIO PROPERTIES

Model No. Frequency Software Selectable RF Power Options

Factory RF Power

Setting

AES Encryption Over-the-air Data Rate

ZZ24D-Nx-SR 2.4GHz 10mW, 16mW, 25mW, 40mW, 63mW 63mW 128 Bit 250 Kbps

ZZ9D-Nx-LR 900MHz* 1mW,10mW, 100mW, 500mW, 1000mW 1000mW 256 Bit 9.6 or 115.2 Kbps

ZZ9D-Nx-LR-AU 900MHz* 1mW, 10mW, 100mW, 500mW, 1000mW 1000mW 128 Bit 9.6 or 115.2 Kbps

ZZ8D-Nx-LR 868MHz** 1mW, 23mW, 100mW, 159mW, 316mW 316mW 128 Bit 24 Kbps

Note:ZZ9D-Nx-LRandZZ9D-Nx-LR-AUhavesoftwareselectableOTAdatarates.

Range w/Supplied Antenna (indoor / outdoor) maximum Range w/High Gain Antenna (Outdoor) maximum

ZZ24D-Nx-SR 300Feet(91Meters)/1Mile(1.6Kilometers) N/A

ZZ9D-Nx-LR 3000Feet(914Meters)/14Miles(23Kilometers) 40Miles(64Kilometers)

ZZ9D-Nx-LR-AU 3000Feet(914Meters)/14Miles(23Kilometers) 40Miles(64Kilometers)

ZZ8D-Nx-LR 1800Feet(549Meters)/25Miles(40Kilometers) 25Miles(40Kilometers)

*Note:900MHzunitsarenotsoldinEurope

**Note:868MHzunitsarenotsoldinNorthAmerica

LATENCY

Base Module Modbus Peer-to-Peer

Digital Analog Digital Analog

ZZ24D-xx-SR 8mS 15mS 20mS 25mS

ZZ9D-xx-LR 9mS 104mS 55mS 52mS

LatencytimesweremeasuredinacleanRFenvironmentwithdeviceslessthan3feet(1m)apart.

Add 45mS per analog expansion module and 25mS per digital expansion module.

ZZ8D-Nx-LRradioshavea10%maximumdutycycle.

I/O POINTS

Model No. Digital Inputs Digital Outputs Analog Inputs Analog Outputs

ZZxD-NA-xx(Base) 2(Pull-upResistors) 2(Sourcing) 2(mA,V) 2(V,mA,Sinking)

ZZxD-NB-xx(Base) 4(Pull-upResistors) 4(Sourcing) --- ---

ZZxD-NC-xx(Base) 2(Pull-upResistors) 2(Sinking) 2(mA,V) 2(V,mA,Sinking)

ZZxD-ND-xx(Base) 4(Pull-upResistors) 4(Sinking) --- ---

ZZ-8DI-DC 8(Pull-upResistors) --- --- ---

ZZ-8DO-T --- 8(Sourcing) --- ---

ZZ-8DO-T1 --- 8(Sinking) --- ---

ZZ-4DI4DO-DCT 4(Pull-upResistors) 4(Sourcing) --- ---

ZZ-4DI4DO-DCT1 4(Pull-upResistors) 4(Sinking) --- ---

ZZ-4AI --- --- 4(mA,V) ---

ZZ-4AO --- --- --- 4(V,mA,Sinking)

ZZ-4A0-2 --- --- --- 4(V,mA,Sourcing)

ZZ-2AI2AO --- --- 2(mA,V) 2(V,mA,Sinking)

ZZ-8DO-R --- 8(Relay) --- ---

ZZ-4RTD1 --- --- 4(RTD) ---

SOFTWARE PROGRAMMING KITS – REQUIRED TO PROGRAM YOUR SYSTEM

Model Number Description

ZZ-PROG1-USB ProgrammingModule(USBInterface),USBcableandSoftwareCD

Note:TheSoftwareCDisonlyavailablewiththeprogrammingkit.SoftwareandFirmwarecanalsobedownloadedatwww.bb-elec.com

www

elec

com

Peer-to-Peer and Modbus I/O

Zlinx Standard Wireless I/O

ANALOG INPUTS AND OUTPUTS

Ranges:

0to10VDCor0to20mA

ZZ-4AO-2 is an active current source. All

others are passive

Resolution: 12 Bit

Input Accuracy: 0.2%fullscalereadingtypical

Output Accuracy: 0.27%fullscalereadingtypical

AI Load Resistance:

100MegaOhmswhenconguredforvoltage

input250Ohmswhenconguredfor

current input

AO Max Output Current: 1mAwhenconguredforvoltageoutput.

AO Max Load

450Ohmswhenconguredforcurrentoutput

@12V

RTD INPUTS

NumberofRTD: 4

WireConguration: 2, 3, and 4 wire

Type:

PT100,PT1000(Optimizedfor

temperaturecoefcientof385C),

Cu10(Optimizedfortemperature

coefcientof427C)

Input Connection:

3.5mm removable terminal block

(4peroutput)

TemperatureRange:

PT100=(-)200to(+)650C

PT1000=(-)200to(+)100C

Cu10=(-)100to(+)260C

Resolution: 0.1Ccrossat(-)40to(+)80C

Accuracy@25C: (+/-)0.5Ctypical

Accuracy(-)40to(+)80C (+/-)2.0Cmaximum

ENVIRONMENTAL

Operating Temperature

ZZ-8DO-R -40to55°C(-40to131°F)

All Others -40to80°C(-40to176°F)

MAXIMUM AMBIENT AIR TEMPERATURE

ZZ-8DO-R 55°C(131°F)

All Others 80°C(176°F)

StorageTemperature -40to85°C(-40to185°F)

OperatingHumidity 0to95%Non-condensing

Enclosure Plastic IP30

Mounting 35mmDINRail

Expansion

1 Base Module supports up to 6 Expansion

Modules

Dimensions

1.2 x 3.7 x 5.0 in

(2.9x9.3x12.7cm)

SPECIFICATIONS

DIGITAL INPUTS

VoltageRange: 0to48VDC

LowVoltage(0): 0.8Vmaximum

HighVoltage(1): 4.0Vminimum

PullUpCurrent: 38 micro-amps

FrequencyInput:

2DIinputspermodule

Software selectable as

frequencycounters,

0to5KHzrange.

DIGITAL OUTPUTS

VoltageRange:

10to40VDC(Sourcing)

0to48VDC(Sinking)

40 mA per output

RELAY OUTPUTS

Number of Relays: 8

Type: C -normally open & normally closed

Output Connection:

3.5mm removable terminal block

(2peroutput)

Common Connection: 3.5mm removable terminal block

Ratings:

250VAC@8A,30VDC@5A(maximumperbankof4

asgroupedonthelabel)

RADIO PROPERTIES (2.4 GHZ - SR MODELS)

Frequency: 2.4GHz

Output Power: 100 mW

Receiver Sensitivity: -102 dbm

Antenna:

Theincludedantennaisa4.25inchomni-directional

withRPSMAconnector.(p/nZZ24D-ANT1)

RADIO PROPERTIES (900 MHX - LR MODELS)

Frequency: 900MHz

Output Power: 1W

Receiver Sensitivity: 100dbm@115.2K,110dbm@9.6K

Antenna:

Theincludedantennaisa6.5inchomni-directional

withRPSMAconnector.(p/nZZ9D-ANT1)

RADIO PROPERTIES (868 MHZ LR MODELS)

Frequency: 868MHz

Output Power: 315 mW

Receiver Sensitivity: -112 dbm

Antenna:

Theincludedantennaisa6.5inchomni-directional

withRPSMAconnector.(p/nZZ9D-ANT1)

LED INDICATORS

Receive Signal Strength:

Tri-color–Off=NoSignal

Red=WeakSignal

Yellow=MediumSignal

Green=StrongSignal

RFData:

Green–BlinkswithTDorRD

Off=NoData

LocalBusData:

Green–BlinkswithTDorRD

Off=NoData

Power:

Red–On=Powerapplied

Off=NoPower

continued...

Zlinx Standard Wireless I/O_3713ds

International Ofﬁce: 707 Dayton Road PO Box 1040 Ottawa, IL 61350 USA 815-433-5100 Fax 433-5104

European Ofﬁce: Westlink Commercial Park Oranmore Co. Galway Ireland +353 91 792444 Fax +353 91 792445

orders@bb-elec.com

support@bb-elec.com

SPECIFICATIONS

SOFTWARE

Supported OS

AsoftwareCDisprovidedwithprogrammingkits

andcontainsZlinxManagersoftware,UsersManual

andQuickStartGuide.

AGENCY APPROVALS

FCC Part 15 Class A

DownloadDoCatwww.bb-elec.com

UL/cUL

FileNumbersE245458(Class1,Div2)&E222870

(UL508)

Models that are Class 1/Division 2 listed:

ZZ24D-Nx-SR(2.4GHz,Shortrange)

ZZ9D-Nx-LR(900MHz,Longrange)

ZZ-2AI2AO

ZZ-4AI

ZZ-4AO

ZZ-4AO-2

ZZ-4DI4DO-DCT

ZZ-4DI4DO-DCT1

ZZ-4RTD1

ZZ-8DI-DC

ZZ-8DO-R

ZZ-8DO-T

ZZ-8DO-T1

ZZ-PROG1-USB

Class 1, Division 2 exceptions:

ZZ-8DO-RisnotUL508listed.

ZZxxD-Nx-MR,ZZxxD-Nx-xR-AUandZZ8D-Nx-xR

modelsarenotClass1,Division2Listedbutare

UL508listed.

MTBF (HOURS)

ZZ24D-NA-SR 85547 ZZ24D-NB-SR 137106

ZZ24D-NC-SR 86247 ZZ24D-ND-SR 138362

ZZ24D-NA-MR 88006 ZZ24D-NB-MR 142946

ZZ24D-NC-MR 88746 ZZ24D-ND-MR 144909

ZZ9D-NA-MR 88006 ZZ9D-NB-MR 144746

ZZ9D-NC-MR 88746 ZZ9D-ND-MR 144909

ZZ9D-NA-LR 88195 ZZ9D-NB-LR 143446

ZZ9D-NC-LR 88938 ZZ9D-ND-LR 145422

ZZ8D-NA-LR 88195 ZZ8D-NB-LR 143446

ZZ8D-NC-LR 88938 ZZ8D-ND-LR 145422

ZZ-4AI 136050 ZZ-4AO 113996

ZZ-2AI2AO 119183 ZZ-8DI-T 317530

ZZ-8DO-T 313100 ZZ-8DO-T1 317530

ZZ-4DI4DO-DCT 197045 ZZ-4DI4DO-DCT1 200795

ZZ-8DO-R 40670 ZZ-4RTD1 243007

ZZ-4AO-2 113996

ZLINX RADIO MODEM & I/O COMPATIBILITY

Radio Modem Zlinx Base I/O Module

ZP24D-250RM-SR ZZ24D-Nx-SR

ZP9D-115RM-LR ZZ9D-Nx-LR/ZZ9D-Nx-LR-AU

ZP8D-24RM-LR ZZ8D-Nx-LR

POWER (BASE MODULES)

Source

Anexternalpowersupplyisrequired

(notincluded)

Voltage

10-40VDC,24VAC

Class2,(2.7AMaximum)

Power Connection RemovableTerminalBlock,3.81mmspacing

WIRING TERMINALS

WireType

Conductors

Wire Range

TighteningTorque

FieldWiringTempRating

Power Consumption

SR Models

900MHzLRModels

868MHzLRModels

Copper Wire Only

OneConductorPerTerminal

28 to 16 AWG

1.7lb–in

105°CMinimum(Sizedfor60°Campacity).

10.0 W

9.5 W

12.0 W

POWER (EXPANSION MODULES)

Source

Class2PowerDerivedfrombasemodules

Voltageandcurrentlistedonproductlabel.

Power Consumption

ZZ-4AI

ZZ-4AO

ZZ-2AI2AO

ZZ-8DI-DC

ZZ-8DO-T

ZZ-8DO-T1

ZZ-4DI4DO-DCT

ZZ-4DI4DO-DCT1

ZZ-8DO-R

ZZ-4RTD1

ZZ-4AO-2

1.0 W

1.1 W

1.2 W

0.4 W

15.8 W

1.1 W

8.1 W

1.0 W

3.2 W

0.4 W

6.0 W

OUTPUTS

ZZ-8DO-R

RelayOutput,250VAC

2 A General Purpose/Point

8AGeneralPurposeTotal

All Others

LowVoltage,LimitedEnergy

Communications Protocol

Wire Type

Conductors Copper Wire Only

WireSize OneConductorPerTerminal28to16AWG

TighteningTorque 0.2Nm(Newton-Meters)

REPLACEMENT PARTS

ZZ-DIN1

ReplacementDINclipandspringforallZZ

products, also comes with spare screws for

enclosure

ZZ-TB1

Replacement terminal block kit for ZZ

products. Kit includes

(1)TwopositionTB(3.81mm)

(1)FourpositionTB(3.5mm)

(1)EightpositionTB(3.5mm)

(1)CoverforlocalBus

ZZ24D-ANT1 2.4GHZbandantenna

ZZ9D-ANT1 900MHzSpareAntenna

Peer-to-Peer and Modbus I/O

Zlinx Standard Wireless I/O

continued...

B&B Electronics ZZ24D-NB-SR, ZZ9D-NB-LR Datasheet

Related papers

Other documents