Southbend P48A-GGGG Datasheet

Brand: Southbend

Model: P48A-GGGG

Category: Cookers

Type: Datasheet

Job Item#

www.yatesgd.com www.yatesgraphicdesign.com

STANDARD CONSTRUCTION SPECIFICATIONS

48" Sectional Range

Full-Width Griddle

Model P48A-TTTT with optional 24" ue riser

 P48N-GGGG (Modular Mount)

 P48C-GGGG (Cabinet Base)

 P48D-GGGG (Standard-Oven Base)

 P48A-GGGG (Convection-Oven Base)

 P48N-TTTT (Modular Mount with Thermostatic Griddle)

 P48C-TTTT (Cabinet Base with Thermostatic Griddle)

 P48D-TTTT (Standard-Oven Base with Thermostatic Griddle)

 P48A-TTTT (Convection-Oven Base with Thermostatic Griddle)

Standard Features

• 48"-widesectionalrangewithfull-widthgriddleavailablewitha

standard-oven base, convection-oven base, cabinet base, or as

 amodularunit(formountingoncountertop,refrigeratedor

freezerbase)

• Six20,000BTUNAT(18,000BTULP)burnerswiththree

control knobs

• Electronicpilotignition-Piezo

• 1"thickgriddleplatewithsideandrearsplashers

• 9-1/4"deepfrontrail

• Removablestainlesssteelgreasedrawer

• Stainlesssteelfront,sides,rearandexteriorbottom

• Fullyinsulatedliningandburnerbox

• 1-1/4"frontgasmanifoldand1"reargasconnection

• 5"highstainlesssteelueriser

• Freebattery-designassistance

• Warranty:twoyearsonspeciedoperationalpartsandoneyearon

laborfromdateofpurchase

Standard Features of Thermostatic Griddle Models

• “Insta-On”thermostaticcontrolofgriddlesurfacetemperatureinthe

range180°Fto400°F

Standard Features of Oven-Base Models

• 45,000BTUNAT(42,000BTULP)ovenwithstandingpilot

• Cool-to-the-touchhandle

• Porcelainenamelinterior

• Ovenracks(2forstandardoven,3forconvectionoven)

• “Insta-On”thermostatrangingfrom175°Fto550°F

• Standard-oveninteriorislargeenough(26"by26-1/2")forsheetpans

toteitherway

• Convection-ovenmodelshave1/2hp,two-speedblower

Standard Features of Cabinet-Base Models

• Two24"-widestainlesssteelcabinetsinbasewithremovabledoors

thatopenfromthecenter.

Exterior Finish:Front,sides,rearandexteriorbottom

constructedof#3polished430and304stainlesssteel.

Range: 48"-widefront-manifoldsectionalrangeincludes

full-width120,000BTUNAT(108,000BTULP)griddlewith

1"thickstainlesssteelsurface,sideandrearsplashersand

greasedrawer.

Front Rail: 9-1/4"deepfrontrail.

Flue Riser: 5"highstainlesssteelueriser

Battery: Unitcanbeinanypositioninabattery.Iftheunitis

attheendofthebattery,theendsidewillbesolid(ratherthan

haveacoverplateovertheendofthefrontmanifold).

Legs:6"stainlesssteeladjustablelegsstandard.

Model 48D:45,000BTUNAT(42,000BTULP)ovenwith

standingpilotandthermostatrangeof175°Fto550°F(79°C

to288°C).Porcelainenamelinterior,measuring14”highx

26”widex26.5”deep.Tworackswithve-positionsiderails.

Rightsidecabinet.

Model 48A:45,000BTUNAT(42,000BTULP)convection

ovenwithstandingpilotandthermostatrangeof175°Fto

550°F(79°Cto288°C).Porcelainenamelinterior,measuring

14”highx26”widex24”deep.Threerackswithve-position

siderails.Two-speed,1/2hpblowermotor.Rightsidecabinet.

Model 48C:Two24"-widestainlesssteelcabinetsinbase

withremovabledoorsthatopenfromthecenter.

PrintedinUSA

FormP48-GGGGRev3(September/2009)

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

(919) 762-1000 www.southbendnc.com

Models:

FRONT VIEW

43"

(1092)

24"

(610)

60"

(1524)

41"

(1041)

72"

(1829)

8-1/2" (216)

SIDE VIEW of MODULAR MODEL

SIDE VIEW

33-3/4"

(859)

Motor for

Convection

Oven Models

15-3/4"

(400)

36"

(914)

37-1/2"

(953)

9-1/4"

(235)

37-1/2" (953)

34" (864)

40" (1016)

43-1/2" (1105)

5" (127)

Front Gas

Manifold

20-1/2"

(521)

11-3/4"

(298)

Optional extra-deep flue riser (cooking area is

same as for models with standard flue riser).

Optional Shelf

5" Flue Riser

24" Flue Riser

36" Flue Riser

48" (1219)

6" (152)

20"

(508)

Rear Gas

Connection

18"

(457)

TOP VIEW

REAR VIEW

Oven models also have 16" cabinet,

cabinet models have two 24" cabinets.

2-1/2" (64)

Electrical

Connection

for Oven

Models

 P48N-GGGG  P48C-GGGG  P48D-GGGG  P48A-GGGG  P48N-TTTT  P48C-TTTT  P48D-TTTT  P48A-TTTT

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

OPTIONS and ACCESSORIES

MISCELLANEOUS

UTILITY INFORMATION

GAS:Eachunithasa

1-1/4"frontmanifoldthat

couplestotheadjacent

sectional unit(s), and a

1"reargasconnection

with a male NPT

connector.Minimumgas

supplypressureis7"

W.C.fornaturalgasand

11"W.C.forpropane.All

sectional units require a

regulatedgassupply(a

pressureregulatormustbeorderedseparately).Ifusingaexible-

hosegasconnection,theinsidediameterofthehosemustnotbe

smallerthantheconnectorontheunitandmustcomplywithANSI

Z21.69,providinganadequatemeansofrestrainttopreventundue

strainonthegasconnection.

ELECTRICITY: Allovenmodelswithoptionalelectronicignition

require50Hzor60Hzsingle-phasepower.120Vmodelshavea

7-footpowercordwithgroundplug(3.8Afor"A"models).208/240V

modelshaveaterminalblockforconnectiontoasingle-phase

208/240Vsource(1.6Afor"A"models).

• Ifcastersareusedwithaexible-hosegasconnection,a

restrainingdeviceshouldbeusedtopreventunduestrain

onthehose.

• Minimumclearancefromnoncombustibleconstructionis

zero(excepttheremustbe2"clearancebehindtheblower

motorofconvection-ovenmodels).Minimumclearance

fromcombustibleconstructionis10"(254mm)onsides

and6"(152mm)onrear.

• Installationunderaventedhoodisrecommended.

• Checklocalcodesforreandsanitaryregulations.

NOTICE:

Southbendhasapolicyofcontinuousproductresearchand

improvement.Wereservetherighttochangespecicationsand

productdesignwithoutnotice.Suchrevisionsdonotentitlethebuyer

tocorrespondingchanges,improvements,additionsorreplacements

forpreviouslypurchasedequipment.

 Externalpressureregulator

 Frontrailoptions:

Cutoutsinfrontrailforsaucepans

7-1/4"deepfrontrail(tomatchold

stylesectional)

Squarebellybarmountedon

7-1/4"deepfrontrail

 Casters(fronttwocasterslock)

 Cable restraint kit (to restrict

movement when on casters)

 24"or36"highueriser

 Shelvesonueriser(oneon24"ue

riser,oneortwoon36"ueriser)

 Trayortubularshelves

 Open-framebasewithcastersfor

battery

 Extra-deeprear-extendingueriser

 Stainless steel oven interior

 Salamander or cheesemelter

mountedon36"highueriser

 Removableshelfinsidecabinet

 Overlappinggriddle

 Groovedgriddlesurface

 Chromegriddlesurface

 Electricovenpilotignition

 120V,NEMA4waterresistant

controls

FormP48-GGGGRev3(September/2009)

Dimensions shown in inches and (millimeters)

Shipping Crate DimenSionS & Weight

moDel WiDth height Depth Volume Weight

P48N-GGGG

P48N-TTTT

55"

(1397)

23"

(584)

55"

(1397)

40.3cuft

(1.14cum)

500lbs

(226.8kg)

P48C-GGGG

P48C-TTTT

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

660lbs

(299.4kg)

P48D-GGGG

P48D-TTTT

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

800lbs

(362.9kg)

P48A-GGGG

P48A-TTTT

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

840lbs

(371.0kg)

moDel

gaS (Btu/hour) eleCtriCity (ampS)

natural propane 120V 208/240V

P48N-GGGG

P48N-TTTT

120,000 108,000 - -

P48C-GGGG

P48C-TTTT

120,000 108,000 - -

P48D-GGGG

P48D-TTTT

165,000 150,000 0* 0*

P48A-GGGG

P48A-TTTT

165,000 150,000 3.8* 1.6*

*StandingOvenPilotModels

Southbend P48A-GGGG Datasheet

Brand: Southbend

Model: P48A-GGGG

Category: Cookers

Type: Datasheet

Download PDF

report

Southbend P48A-GGGG Datasheet

Southbend P48A-GGGG Datasheet

Related papers

Other documents