Southbend P48C-CCCC Datasheet

Brand: Southbend

Model: P48C-CCCC

Category: Cookers

Type: Datasheet

This manual is also suitable for

Job Item#

www.yatesgd.com www.yatesgraphicdesign.com

STANDARD CONSTRUCTION SPECIFICATIONS

48" Sectional Range

Full-Width Charbroiler

Model P48A-CCCC with optional 24" ue riser

 P48N-CCCC (Modular Mount)

 P48C-CCCC (Cabinet Base)

 P48D-CCCC (Standard-Oven Base)

 P48A-CCCC (Convection-Oven Base)

Standard Features

• 48"-widesectionalrangewithfull-widthcharbroileravailable

withastandard-ovenbase,convection-ovenbase,cabinet

base,orasamodularunit(formountingoncountertop,

refrigeratedorfreezerbase)

• Eight16,000BTUNAT(14,000BTULP)burnerswithfour

high/lowcontrolknobs

• Removablecastirongrateswithadjustablefront-to-back

slopethatipoverforeither1/8"or1/4"gridwidth

• 600°Fevensurfacetemperatureonhighsetting

• Castironradiantsor“lavarocks”(eldconvertible)

• 9-1/4"deepfrontrail

• Removabledriptray

• Stainlesssteelfront,sides,rearandexteriorbottom

• Fullyinsulatedliningandburnerbox

• 1-1/4"frontgasmanifoldand1"reargasconnection

• 5"highstainlesssteelueriser

• Freebattery-designassistance

• Warranty:twoyearsonspeciedoperationalpartsandone

yearonlaborfromdateofpurchase

Standard Features of Oven-Base Models

• 45,000BTUNAT(42,000BTULP)ovenwithstandingpilot

• Cool-to-the-touchhandle

• Porcelainenamelinterior

• Ovenracks(2forstandardoven,3forconvectionoven)

• “Insta-On”thermostatrangingfrom175°Fto550°F

• Standard-oveninteriorislargeenough(26"by26-1/2")for

sheetpanstoteitherway

• Convection-ovenmodelshave1/2hp,two-speedblower

Standard Features of Cabinet-Base Model

• Two24"-widestainlesssteelcabinetsinbasewithremovable

doorsthatopenfromthecenter.

Exterior Finish:Front,sides,rearandexteriorbottom

constructedof#3polished430and304stainlesssteel.

Range: 48"-widefront-manifoldsectionalrangewith128,000

BTUNAT(112,000BTULP)full-widthcharbroilerwith

removablecastirongratesandoperatingsurfacetemperature

ofupto600°F(315°C).

Front Rail: 9-1/4"deepfrontrail.

Flue Riser: 5"highstainlesssteelueriser.

Battery: Unitcanbeinanypositioninabattery.Iftheunitis

attheendofthebattery,theendsidewillbesolid(ratherthan

haveacoverplateovertheendofthefrontmanifold).

Legs:6"stainlesssteeladjustablelegsstandard.

Model 48D:45,000BTUNAT(42,000BTULP)ovenwith

standingpilotandthermostatrangeof175°Fto550°F(79°C

to288°C).Porcelainenamelinterior,measuring14”highx

26”widex26.5”deep.Tworackswithve-positionsiderails.

Rightsidecabinet.

Model 48A:45,000BTUNAT(42,000BTULP)convection

ovenwithstandingpilotandthermostatrangeof175°Fto

550°F(79°Cto288°C).Porcelainenamelinterior,measuring

14”highx26”widex24”deep.Threerackswithve-position

siderails.Two-speed,1/2hpblowermotor.Rightsidecabinet.

Model 48C:Two24"-widestainlesssteelcabinetsinbase

withremovabledoorsthatopenfromthecenter.

PrintedinUSA

FormP48-CCCCRev3(September/2009)

1100 Old Honeycutt Road, Fuquay-Varina, NC 27526

(919) 762-1000 www.southbendnc.com

Models:

FRONT VIEW

43"

(1092)

24"

(610)

60"

(1524)

41"

(1041)

72"

(1829)

8-1/2" (216)

SIDE VIEW of MODULAR MODEL

SIDE VIEW

33-3/4"

(859)

Motor for

Convection

Oven Models

15-3/4"

(400)

36"

(914)

37-1/2"

(953)

9-1/4"

(235)

37-1/2" (953)

34" (864)

40" (1016)

43-1/2" (1105)

5" (127)

Front Gas

Manifold

Optional extra-deep flue riser (cooking area is

same as for models with standard flue riser).

5" Flue Riser

24" Flue Riser

36" Flue Riser

48" (1219)

6" (152)

20"

(508)

Rear Gas

Connection

18"

(457)

TOP VIEW

REAR VIEW

Oven models also have 16" cabinet,

cabinet models have two 24" cabinets.

2-1/2" (64)

Electrical

Connection

for Oven

Models

 P48N-CCCC  P48C-CCCC  P48D-CCCC  P48A-CCCC

INTENDED FOR COMMERCIAL USE ONLY.

NOT FOR HOUSEHOLD USE.

OPTIONS and ACCESSORIES

MISCELLANEOUS

UTILITY INFORMATION

GAS:Eachunithasa

1-1/4"frontmanifold

thatcouplestothe

adjacentsectional

unit(s),anda1"rear

gasconnectionwitha

maleNPTconnector.

Minimumgassupply

pressureis7"W.C.

fornaturalgasand

11"W.C.forpropane.

All sectional units

requirearegulatedgassupply(apressureregulatormustbeordered

separately).Ifusingaexible-hosegasconnection,theinside

diameterofthehosemustnotbesmallerthantheconnectoron

theunitandmustcomplywithANSIZ21.69,providinganadequate

meansofrestrainttopreventunduestrainonthegasconnection.

ELECTRICITY: Allovenmodelswithoptionalelectronicignition

require50Hzor60Hzsingle-phasepower.120Vmodelshavea

7-footpowercordwithgroundplug(3.8Afor"A"models).208/240V

modelshaveaterminalblockforconnectiontoasingle-phase

208/240Vsource(1.6Afor"A"models).

• Ifcastersareusedwithaexible-hosegasconnection,a

restrainingdeviceshouldbeusedtopreventunduestrain

onthehose.

• Minimumclearancefromnoncombustibleconstructionis

zero(excepttheremustbe2"clearancebehindtheblower

motorofconvection-ovenmodels).Installationnextto

combustibleconstructionisnotrecommended.

• Installationunderaventedhoodisrecommended.

• Checklocalcodesforreandsanitaryregulations.

NOTICE:

Southbendhasapolicyofcontinuousproductresearchand

improvement.Wereservetherighttochangespecicationsand

productdesignwithoutnotice.Suchrevisionsdonotentitlethebuyer

tocorrespondingchanges,improvements,additionsorreplacements

forpreviouslypurchasedequipment.

 Externalpressureregulator

 Frontrailoptions:

Cutoutsinfrontrailforsaucepans

7-1/4"deepfrontrail(tomatchold

stylesectional)

Squarebellybarmountedon7-1/4"

deepfrontrail

 Casters(fronttwocasterslock)

 Cablerestraintkit(torestrict

movementwhenoncasters)

 24"or36"highueriser

 Open-framebasewithcastersfor

battery

 Extra-deeprear-extendingueriser

 Stainless steel oven interior

 Salamanderorcheesemelter

mountedon36"highueriser

 Removableshelfinsidecabinet

 Overlappingcharbroiler

 Platedshgrids

 Electronicovenpilotignition

 120V,NEMA4waterresistant

controls

FormP48-CCCCRev3(September/2009)

Dimensionsshownininchesand(millimeters)

SHIPPING CRATE DIMENSIONS & WEIGHT

MODEl WIDTH HEIGHT DEPTH VOluME WEIGHT

P48N-CCCC

55"

(1397)

23"

(584)

55"

(1397)

40.3cuft

(1.14cum)

276lbs

(125.2kg)

P48C-CCCC

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

462lbs

(209.6kg)

P48D-CCCC

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

568lbs

(257.6kg)

P48A-CCCC

55"

(1397)

45"

(1143)

55"

(1397)

78.8cuft

(2.23cum)

621lbs

(281.7kg)

MODEl

GAS (BTU/HOuR) ElECTRICITy (AMPS)

NATuRAl PROPANE 120V 208/240V

P48N-CCCC 128,000 112,000 - -

P48C-CCCC 128,000 112,000 - -

P48D-CCCC 173,000 154,000 0* 0*

P48A-CCCC 173,000 154,000 3.8* 1.6*

*StandingOvenPilotModels

Southbend P48C-CCCC Datasheet

Brand: Southbend

Model: P48C-CCCC

Category: Cookers

Type: Datasheet

This manual is also suitable for

Download PDF

report

Southbend P48C-CCCC Datasheet

This manual is also suitable for

Southbend P48C-CCCC Datasheet

Related papers

Other documents