Therapure TPP540 Owner's manual

Brand: Therapure

Model: TPP540

Category: Air purifiers

Type: Owner's manual

This manual is also suitable for

8291 SI

byby

TPP540

uv germicidal air purifier

TPP540

uv germicidal air purifier

owner

’

s guide

TPP540-030813

SAFETY INSTRUCTIONS 2

IMPORTANT WARNINGS 3

UV Lamp Notice 3

Mercury Notice 3

UV Lamp Disposal Notice 3

UV Lamp Breakage 3

PRODUCT BENEFITS 4

MAIN PARTS 5

OPERATING THE THERAPURE

540 AIR PURIFIER 6

Air Puriﬁer Speciﬁcations 6

Getting Ready 7

Controls/Settings 8

CLEANING & MAINTENANCE 9

Cleaning the Permanent Filter 9

Resetting the Clean Filter Indicator 9

Maintenance UV Lamp 10

Cleaning External Surfaces 10

Replacing the UV Lamp 11

TROUBLE-SHOOTING 12

ONE-YEAR LIMITED WARRANTY 13

TABLE OF CONTENTS

Thank you for purchasing the Therapure

540 air puriﬁer. With UV germicidal

protection to reduce germs and

permanent HEPA-type ﬁltration to

purify the air, the Therapure

540 air

puriﬁer will greatly improve the quality

of the air in your home, ofﬁce or other

environments. We want you to be fully

satisﬁed with your Therapure

540.

That’s why your Therapure

540 comes

with a one-year limited warranty.

Once you’ve experienced the purity of

Therapure

540 air, visit us at our website

to ﬁnd out more ways to improve the

quality of your air and your life with our

premium products and upgrades.

Please be sure to read the following

instructions carefully to ensure optimal

performance and safety.

www.envionproducts.com

Therapure

by Envion, LLC

P.O. Box 9159

Van Nuys, CA 91409-8291

800.875.8577

TPP540

SAFETY INSTRUCTIONS IMPORTANT WARNINGS

READ AND SAVE THESE INSTRUCTIONS

WARNING: RISK OF ELECTRICAL SHOCK

Safety precautions should always be used when operating this or any electrical appliance.

Decrease the risk of electrocution, electric shock, injury or ﬁre by reading and following all the

warnings below.

Use only as described in this Therapure

540 manual. To reduce the risk of electric shock, do

not attempt to service the product in any way other than in the manner described in the

“Cleaning & Maintenance” section of this manual.

READ ALL INSTRUCTIONS BEFORE OPERATING THE AIR PURIFIER.

» This product operates at 120V AC, 60Hz only.

» Do not run cord under carpeting. Do not cover cord with throw rugs, runners, or similar

coverings. Arrange cord away from trafﬁc area and where it will not be tripped over.

» Do not operate the product in any greasy environment, such as in the kitchen. This product is

not intended to ﬁlter oil or grease from the air.

» Do not use the Therapure

540 air puriﬁer in bathrooms or other humid environments. Do not

use near ﬁreplaces or in areas where ﬂammable or combustible vapors or products may exist.

» Always unplug the power cord from the electrical outlet when the puriﬁer is not in use, before

cleaning, inserting or removing parts or before moving to another location.

» Never run the air puriﬁer unless it is fully assembled.

» This appliance has a polarized plug (one blade is wider than the other). To reduce the risk of

electric shock, this plug is intended to ﬁt in a polarized outlet only one way. If the plug does not

ﬁt fully in the outlet, reverse the plug. If it still does not ﬁt, contact a qualiﬁed electrician. Do not

attempt to defeat this safety feature.

» Always turn off all controls before unplugging the Therapure

540 air puriﬁer from the outlet.

» Attempting to service the Therapure

540 air puriﬁer in any way that is not described in this

owner’s manual will cause the warranty to be voided and could cause serious personal injury to

the user and/or result in considerable damage to the unit.

» Do not place the cord near a heated surface.

» Do not operate this product with a damaged cord or plug. Discard the product or return to an

authorized service facility for examination and/or repair.

» Never use the power cord to pick up, carry, drag, pull, or lift the Therapure

540 air puriﬁer. Do

not pull the cord against or around sharp corners and edges. This could result in injury to the

user or damage to the cord.

» Always remove the plug from its power outlet by holding onto the plug itself and pulling gently.

» Never pull on the cord itself to unplug it from its power outlet.

» Use care when operating the Therapure

540 air puriﬁer by keeping all foreign objects,

ﬁngers, body parts, hair, loose clothing and jewelry away from openings.

» Never touch the Therapure

540 air puriﬁer or its plug when your hands are wet.

» The Therapure

540 air puriﬁer is an electrical appliance. Adult supervision is required when

operating the Therapure

540 in the presence of children.

» To reduce the risk of fire or electric shock, do not use this air puriﬁer with any solid-state speed

control devices.

UV Lamp Notice

UV Light is harmful to bare skin and eyes and can cause temporary or permanent loss of vision.

Never look directly at the UV lamp while it is illuminated; doing so could cause loss of vision!

Only view illumination through the window at the front of the unit. To prevent exposure to

ultraviolet light, disconnect the power to the unit before servicing any part of the Therapure

5 40

air puriﬁer.

UV Lamp Disposal

If the UV lamp breaks, turn off the unit. Do not operate the unit with a broken lamp. Do not use a

vacuum to clean up breakage. Sweep debris into a plastic bag and dispose of properly. Contact your

local waste management authority for instructions regarding recycling and the proper disposal of

old lamp(s). To order a replacement lamp, call 1.800.875.8577 or go to www.envionproducts.com.

Mercury Notice

Because the Therapure

540 contains a light bulb and light bulbs contain mercury, Envion is required

to provide the following warning:

WARNING: This product contains mercury, a chemical known to the State of California to cause

birth defects or other reproductive harm.

Do not place your used lamp(s) in the trash. Disposal of any item containing mercury must be in

accordance with any hazardous waste disposal or recycling laws and regulations of your state.

TPP540

540

PRODUCT BENEFITS

» Triple action puriﬁcation:

1. Permanent HEPA-type Filter takes particles

out of the air, purifying it.

2. UV lamp reduces germs, such as

viruses and bacteria.

3. Photo catalyst ﬁlter helps remove VOCs

(volatile organic compounds) from the air,

including toxic fumes, such as paint

and new carpet fumes.

» Effectively removes smoke, pollen, dust,

animal dander, dust mites, mold and bacteria.

» 3 speed fan setting–lets you select the

desired cleaning level.

» 24-hour timer for automatic power off.

» Night mode to dim the control panel light

when you sleep

» Clean ﬁlter indicator.

MAIN PARTS

1. Locking Latch

2. Air Inlet Grill

3. Permanent HEPA-type Filter: the permanent ﬁlter removes small visible

and non-visible particles down to 0.1 microns in size.

4. UV Lamp Cover

5. Control Panel: Time, On/Off, Speed, UV/VOC and Night Mode

6. UV Indicator Light Bar: Lights up when UV feature is turned ON

7. Air Outlet Grill

8. UV Lamp

Locking

Latch

Air Inlet

Grill

UV Lamp

Cover

Permanent

HEPA-type

Filter

Control Panel

UV Indicator

Light Bar

Air Outlet Grill

UV Lamp

TPP540

540

OPERATING THE THERAPURE

540

Before using the Therapure

540 air puriﬁer, please read the following important information.

Electrical Ratings:

• 120V Setting: 120Vac, 60 Hz

• Power consumption: 55 watts (0.45 ampere) at high fan speed,

• 3 watt UV light bulb

• Net weight: 9.5 lbs

• Dimension (L x W x H): 8.7” x 7.3” x 25.2”

Replacement Parts:

Lamp – TPP2400

Filter – TPP440F

Locate a level surface on which to place the

Therapure

540 air puriﬁer near a 120V outlet

(follow warnings in the “SAFETY INSTRUCTIONS”

and “IMPORTANT WARNINGS” sections of this

manual). Position your Therapure

540 at least one

foot (12 inches) from the wall. Plug in the unit.

OPERATING THE THERAPURE

540

Before using the Therapure

540 air puriﬁer, please read the following important information.

Safety

1. Do not place near fans.

2. Keep both sides of the unit at least 1 foot away from a wall.

3 Do not place the unit near curtains.

4. Placing the unit close to the source of air pollution is an effective way to improve

indoor air quality.

Note:

DO NOT run the Therapure

540 with a broken ﬁlter. Replace the ﬁlter if the ﬁlter has

a tear or a hole in it.

If the ﬁlter is damaged or needs replacement, please visit the Therapure

website at

www.envionproducts.com to order for a replacement ﬁlter. Or call 1.800.875.8577.

1. 2.

3. 4.

540

CLEANING & MAINTENANCE

Keep the Therapure

540 functioning properly by cleaning the permanent HEPA-type Filter every

four weeks of use. More frequent cleaning will be necessary if the unit is located in an area with a

high level of airborne contaminants (excessive amounts of smoke, pet dander, etc.).

Exposing the Therapure

540 to candle/oil/ﬁreplace soot and smoke is not recommended and will

require more frequent cleaning.

NOTE: Always make sure the Therapure

540 is turned off and unplugged before cleaning.

» Vacuuming will restore performance of the permanent HEPA-type Filter. However,

the ﬁlter may appear stained. This is normal and does not affect performance in any way.

» Do not use water or any household cleaners or detergents to clean the permanent

HEPA-type Filter.

» The inlet grill may be cleaned (after unit is turned off and unplugged) with a vacuum

or a slightly damp cloth.

Cleaning the permanent HEPA-type Filter

1. Release the inlet grill by pressing on the locking latch (see diagram of Main Parts).

2. Remove the inlet grill from the unit as shown below.

3. Grasp the left and right frames of the permanent HEPA-type Filter through the indentations on

the sides of the ﬁlter enclosure and remove the ﬁlter.

4. To clean the permanent HEPA-type Filter, use the brush or crevice attachment with a vacuum

cleaner. Run the attachment along the inlet and outlet side of the ﬁlter, cleaning between the

crevices as much as possible. Do not use water or any household cleaners or detergents to

clean the permanent HEPA-type Filter.

5. Once the permanent HEPA-type Filter has been cleaned and checked for any possible damage,

replace the ﬁlter back in the reverse direction described here. Plug in the unit and hold down

Time + Power On button for 3 seconds. The clean ﬁlter light will go off and your cleaning

maintenance is done.

4.3.

OPERATING THE THERAPURE

540

CONTROLS/SETTINGS:

Power Control – To operate the Therapure

540 air puriﬁer, press the ON/OFF button to turn on

the air puriﬁer. Press the button again to turn the unit off.

Timer Control – The Therapure

540 air puriﬁer can be programmed to turn off after a preset

amount of time. Press the “TIME” button to program the timer. Each press will add one hour up to

a total of 24 hours. Keeping the button pressed will automatically increase to 24 hours, 1 hour at a

time, after that it will turn back to off.

Fan Speed Control – The Therapure

540 has three different speeds of cleaning, LOW, MED and

HI. Press “SPEED” button to cycle the settings and select the fan speed you desire. The speed state

will be shown on the LED display.

Clean Filter Indicator Light – The Therapure

540 Clean Filter Indicator Light will turn on each time

the ﬁlter needs to be cleaned. To reset the ﬁlter indicator, press the TIME and the ON/OFF buttons

together for 3 seconds. The CLEAN FILTER light will ﬂash 3 times and then turn off completely,

indicating the unit has been reset.

Night Mode – If the UV light bar

is too bright, press the “Night

Mode” button to turn off the UV

light bar feature, and the lighted

display. The ON/OFF indicator,

however, will remain lit. The night

mode only turns off UV light bar

not the actual UV feature.

UV Control – Press the UV/VOC

control button “UV/VOC” to turn

on the UV lamp to kill harmful

airborne germs and reduce

harmful VOC (volatile organic

compounds). Press it again to

turn off the UV and VOC.

540

CLEANING & MAINTENANCE

Cleaning External Surfaces

1. Turn off and unplug unit.

2. Use a washcloth slightly dampened with

a little water and dishwashing soap

to wipe the outer case surfaces.

3. Do not allow water to slip into the internal parts

as this could damage your unit and result in

electrical shock and injury to you.

4. Allow the unit to thoroughly dry before use.

UV Lamp

The lifetime of the UV lamp is up to 12 months of

continuous, effective operation. After this time, the

bulb may remain illuminated, but its effectiveness

is greatly reduced. For maximum germicidal

protection, please replace the UV bulb annually.

If the lamp stops functioning or needs

replacement, please visit our web site at

www.envionproducts.com to order a

replacement lamp. Or call 1.800.875.8577.

Caution:

•

Do not touch the glass part of the lamp. Oil

from ﬁngertips will decrease the effectiveness

of the lamp.

•

Never operate the unit without a ﬁlter or with

a damaged ﬁlter. UV lamp cover must be

installed at all times. The UV light from the UV

lamp will result in severe damage to eyes and

could cause blindness.

UV Lamp Notice Warning:

UV Light is harmful to bare skin and eyes and can

cause temporary or permanent loss of vision.

Never look directly at the UV lamp while it is

illuminated-doing so could cause loss of vision!

Before replacing the UV lamp, make sure the Therapure

540 air puriﬁer is turned

off and unplugged. Let the lamp cool down for 5 minutes before replacing it.

Replacing the UV Lamp:

1. Release the inlet grill by pressing on the locking latch.

2. Grasp the left and right frames of the permanent HEPA-type Filter through the

indentations on the sides of the ﬁlter enclosure and remove ﬁlter.

3. Remove the two bolts used to ﬁx the UV lamp cover and remove the cover out from

the unit then unscrew the old UV lamp from the lamp base of the unit.

4. Install the new UV lamp into the lamp base of the unit.

5. Install the UV lamp cover with the two bolts on the unit.

6. Install the inlet grill on the unit.

CLEANING & MAINTENANCE

540

1110

ONE-YEAR LIMITED WARRANTY

ONE YEAR LIMITED WARRANTY

Your Therapure

540 air puriﬁer is warranted to be free from defects in materials and workmanship

for one year from the original purchase date. Should the product have a defect in materials or

workmanship, we will repair or replace it without charge to you (a shipping and processing fee

will apply). To obtain service under warranty, simply call our customer service center toll-free

at 800.875.8577.

This warranty does not cover damage caused by accident, misuse or any use other than as intended

and described in this product manual, or damage resulting from failure to maintain and clean this

product as speciﬁed in this product manual. This warranty applies only to the original purchaser of

the Therapure

540 air puriﬁer.

ALL EXPRESS AND IMPLIED WARRANTIES FOR THIS PRODUCT, INCLUDING IMPLIED

WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARE

LIMITED IN DURATION TO THE WARRANTY PERIOD, AND NO WARRANTIES, WHETHER

EXPRESS OR IMPLIED, WILL APPLY AFTER THIS PERIOD.

Some states do not allow limitations on the duration of implied warranties, so the above limitation

may not apply to you. While this warranty gives you speciﬁc legal rights, you may also have other

rights which may vary from state to state.

Contact Info for Warranty Service:

Therapure

by Envion LLC

P.O. Box 9159

Van Nuys, CA

| 91409-8291

1.800.875.8577

www.envionproducts.com

TROUBLESHOOTING

PROBLEM REASON SOLUTION

Unit will not operate.

Reduced airﬂow or

poor ﬁltering.

Power button has not been

turned on.

Unit is unplugged.

The inlet grill has not been

installed & locked into place.

The inlet or outlet grill may

be blocked.

Permanent ﬁlter may

be clogged.

Press the Power button

Check to ensure unit

is plugged in.

Check to make sure ﬁlter and

inlet grill is properly installed

& locked into place.

Check to ensure nothing is

blocking air inlet & air outlet.

Check & clean ﬁlter,

if necessary.

The energy efﬁciency of this ENERGY STAR qualiﬁed model is measured based on a ratio between

the model’s CADR for dust and the electrical energy it consumes, or CADR/Watt.

TPP540

uv germicidal air purifier

540

1312

Therapure TPP540 Owner's manual

Brand: Therapure

Model: TPP540

Category: Air purifiers

Type: Owner's manual

This manual is also suitable for

8291 SI

Download PDF

report

Therapure TPP540 Owner's manual

This manual is also suitable for

Therapure TPP540 Owner's manual

Related papers

Other documents