Bertazzoni PRO304INSX Installation, Use and Care Manual

Brand: Bertazzoni

Model: PRO304INSX

Category: Kitchen & houseware accessories

Type: Installation, Use and Care Manual

This manual is also suitable for

MAS304INSXT

IMPORTANTSAFETYINFORMATION

PLEASEREADANDFOLLOWTHESEIMPORTANT

INSTRUCTIONSFORTHESAFETYOFYOURHOME

ANDOFTHEPEOPLELIVINGINIT.

SavethisManualforlocalelectricalinspector’s

use.



Readandsavetheseinstructionsforfuture

reference.



Observeallgoverningcodes,ordinancesand

regulations.



‐Donotstoreorusegasolineorotherflammable

substancesinthevicinity ofthisoranyother

appliance.

‐Installationandservicemustbeperformedbya

qualifiedinstalleroraserviceagency.







WARNING!











WARNING

Readthisinstructionbookletbeforeinstalling

andusingtheappliance.



WARNING

Readthisinstructionbookletbeforeinstalling

andusingtheappliance.



Themanufacturerwillnotberesponsibleforany

damagetopropertyortopersonscausedby

incorrectinstallationorimproperuseofthe



appliance.



The manufacturer reserves the right to make

changes to its products when considered

necessary and useful, without affecting the

essentialsafetyandoperatingcharacteristics.



Thisappliancehasbeendesignedfornon‐

professional,domesticuseonly.



Donotusethisappliancetoheataroom.



Donotplaceanypot

orpanontheopenoven

door.Thedoorismadeofglassanditcanbreak

ifloadedwithaweight.



Before beginning installation, please read these

instructionscompletelyandcarefully.



Do not remove permanently affixed labels,

warnings, or plates from the product. This may

void the warranty.‐

Please observe all local and

nationalcodesandordinances.



Pleaseensuretherangeisproperlygrounded.



Theinstaller should leave these instructions with

the consumer who should retain for local

inspector'suseandforfuturereference.



Theplugshouldalwaysbeaccessible.



Installation must conform with local codes or

in

the absence of codes. Electrical installationmust

be in accordance with the National Electrical

Code, ANSI/NFPA70‐latest edition and/or local 

codes. Electrical installation must be in

accordancewith the currentCSAC22.1 Canadian

ElectricalCodesPart1and/orlocalcodes.



Warning!

Tip‐OverHazard

Achildoradultcantiptherangeandbekilled

Installanti‐tipdevicetorangeand/orstructureper

installationsinstructions

Engagetherangetotheanti‐tipdeviceinstalledto

thestructure

Re‐engageanti‐tipdeviceifrangeismoved

Failure to follow

these instructions can result in

deathorseriousburnstochildrenandadults.



Show specific manufacturer illustrations and

instructions for checking the installations of anti‐

tipdevice.



WARNING!

Iftheinformationinthismanualisnot

followedexactly,afireorexplosionmay

resultcausingpropertydamage,personal

injuryordeath.



BERTAZZONISpA

ViaPalazzina8

42016GuastallaRE

ITALY



WWW.BERTAZZONI.COM







5000980



REF. PRO304INSX Model [M70QPTU1XE.UP]

REF. PRO304INSAR Model [M70QPTU1SE.UP]

REF. PRO304INSNE Model [M70QPTU1NE.UP]

REF. PRO304INSRO Model [M70QPTU1RE.UP]

REF. PRO304INSVI Model [M70QPTU1LE.UP]

REF. PRO304INSBI Model [M70QPTUWXE.UP]

REF. PRO304INSGI Model [M70QPTU1IE.UP]

REF. MAS304INSXT Model [M70QPTA1XE.UP]





FromthedeskofthePresident



DearnewownerofaBertazzoniproduct,

Iwanttothankyouforchoosingoneofour

beautifulPROranges.Weknowthatyouhavemany

brandsandproductstochoosefromandweare

thrilledthatyouhavedecidedtotakeoneofour

productsintoyourhome.

Wetake

asmuchprideinmakingourrangesaswe

hopeyouwillinowningthem.Myfamilystarted

manufacturingcookingappliancesin1882.Eachof

ourproductsisablendofItaliandesignfinesseand

superiorappliancetechnolo gy.Whilewecannot

replaceyouruniquetalentatcookingdelicious

recipes

foryourself,yourfamilyandyourfriends,

wetryourbesttomakecookingeasier,more

effectiveandmorefun.

Ourappliancesaredesignedaccordingtothe

strictestsafetyandperformancestandardforthe

EuropeanandtheNorthAmericanmarket.We

followthemostadvancedmanufacturing

philosophy.Eachapplianceleavesthe

factoryafter

thoroughqualityinspectionandtesting.Our

distributorsandourservicepartnersarereadyto

answeranyquestionsyoumayhaveregardinghow

toinstall,useandcareforyourBertazzoniproduct.

Thismanualwillhelpyoulearntousetheproduct

inthesafestandmosteffectivemanner

andcare

foritsothatitmaygiveyouthehighestsatisfaction

foryearstocome.

Themanualalsoincludesdirectionsforthe

professionalinstallerthatwillinstalltheproductin

yourhome.Werecommendusingfactory‐trained

professionalsforthedelicatetaskofinstallingand

testingappliancesinyour

home.Pleasecall

CustomerServiceifyouneedhelplocatinga

factory‐trainedprofessionalinstallerinyourarea.

Pleasekeepthismanualforfutureuse.

Grazie!



TABLEOFCONTENTS

WARRANTYANDSERVICE........................................................................................................................................4

BEFOREINSTALLATION............................................................................................................................................6

INSTALLINGTHELEGS..............................................................................................................................................6

INSTALLINGTHEBACKGUARD..................................................................................................................................7

INSTALLATIONREQUIREMENTS...............................................................................................................................8

EXHAUSTHOODINSTALLATION...............................................................................................................................9

ELECTRICALCONNECTION......................................................................................................................................10

WIRINGDIAGRAM.................................................................................................................................................12

INSTALLATIONCHECKLIST......................................................................................................................................13

FINALPREPARATION.............................................................................................................................................13

USERMANUAL......................................................................................................................................................14

ROOMVENTILATION.............................................................................................................................................14

USINGTHEINDUCTIONCOOKTOPAREA................................................................................................................15

SURFACEHOTPLATES.............................................................................................................................................16

OVENCOOKING.....................................................................................................................................................18

OVENRACKS..........................................................................................................................................................19

USINGTHEOVEN...................................................................................................................................................20

BAKE............................................................................................................................... ......................................20

CONVECTION.........................................................................................................................................................21

CONVECTIONBAKE................................................................................................................................................21

TURBO............................................................................................................................... ................................... 21

WARMING.............................................................................................................................................................23

PROOFING.............................................................................................................................................................23

DEHYDRATE...........................................................................................................................................................24

BROIL/CONVECTIONBROIL............................................................................................................................... ...25

BROILINGANDROASTINGRECOMMENDATIONS...................................................................................................26

CAREANDMAINTENANCE.....................................................................................................................................27

SELF‐CLEANINGTHEOVEN.....................................................................................................................................27

MAINTAININGYOURRANGE..................................................................................................................................28

CLEANINGYOURRANGE........................................................................................................................................28

TROUBLESHOOTINGGUIDE....................................................................................................................................29

LOCATIONOFAPPLIANCETAGS.............................................................................................................................30

IMPORTANTAPPLIANCEINFORMATION................................................................................................................31



Please kindly register on our web site www.bertazzoni.com to validate your new product warranty and help us to

assistyoubetterincaseofanyinconvenience.

TWOYEARLIMITEDWARRANTY

The warranties provided by Bertazzoni Spa in this statement apply exclusively to Bertazzoni appliances and

accessories sold as new products to the original owner by a Bertazzoni authorized distributor, retailer, dealer or

service center and installed in the United States and Canada. The warranties provided in this statement are not

transferable

andhavevalidityfromthedateofinstallation.



COVERAGEINFORMATION

Bertazzoni SpA will repair or replace any component part which fails or proves defective due to materials and/or

workmanship within 2 years from the dateof installation and under conditions of normal residential use. Repair or

replacementwillbe

free of charge, including labor at standard rates and shipping expenses. Repair service must be

performedbyaBertazzoniAuthorizedServiceCenterduringnormalworkinghours.



COSMETICWARRANTY

Bertazzoniwillcoverpartsshowingcosmeticdefectsinmaterialandworkmanshipforaperiodofthirty(30)daysfrom

date of installation of theunit. This coverage will include scratches, stains, surface imperfections on stainless steel,

paint and porcelain, with the exclusion of slight differences in color due to

 materials and painting/enamelling

technologies.

Exclusionsarelaborcosts,Bstockitems,out‐of‐boxappliancesanddisplayunits.



HOWTOOBTAINSERVICE

ToobtainwarrantyservicepleasecontactBertazzoniCustomerServiceatthenumbersbelowandprovidemodel

number,serialnumberanddateofpurchase.



ENGLISH8669050010‐FRANCAIS8005617265



Saveproofoforiginalpurchaseoroforiginalinstallationtoestablishwarrantyperiod.Copyoftheproductserialtagis

affixedtothebackcoveroftheinstructionmanual.



WHATISNOTCOVERED

1 Theproductusedinanycommercialapplication

2 RepairserviceprovidedbyotherthanaBertazzoniauthorizedserviceagency.

3 Damageorrepairservicetocorrectserviceprovidedbyanunauthorizedagencyortheuseofunauthorized

parts.

4 Installationnotinaccordancewithlocal

electricalcodesorplumbingcodes.

5 Defectsordamageduetoimproperstorageoftheproduct.

6 Defectsordamageormissingpartsonproductssoldoutoftheoriginalfactorypackagingorfromdisplays.

7 Servicecallsorrepairstocorrecttheinstallationoftheproductand/orrelatedaccessories.

Servicecallstoconnect,convertorotherwiserepairtheelectricalwiringand/orgaslinetoproperlyusethe

product.

9 ServicecallstoprovideinstructionsontheuseofaBertazzoniproduct.

10 Repairserviceduetoproductusageinmannerotherthanwhatisnormalandcustomaryforhome

use.

11 Replacementofwearandtearparts

12 Replacementofglassesandlightbulbsiftheyareclaimedtohavefailedlaterthan30daysafterinstallation

andinnocaselaterthan4monthsafterdateofpurchase

13 Defectsanddamagesarisingfromaccident,alteration,misuse,abuse,improper

installation.

14 Defectsanddamagesarisingfromtransportationoftheproducttothehomeoftheowner.

15 DefectsanddamagearisingfromexternalforcesbeyondthecontrolofBertazzoniSpAsuchasfire,flood,

earthquakesandotheractsofGod.



In case the product will be installed in a remote area, where certified trained technicians are not reasonably

available, the customer will be responsible for the transportation costs for the delivery of the product to the

nearestauthorizedservicecenterorforthedisplacementcostsofacertifiedtrainedtechnician.



Bertazzonidoesnotassumeanyresponsibilityforincidentalorconsequentialdamages.

Somestatesdonotallowtheexclusionorlimitationofincidentalorconsequentialdamages,sotheabovelimitation

or exclusion may not apply to you. This warranty gives you specific legal rights and you may also have other rights

which

mayvaryfromstatetostateorprovincetoprovince.

PRODUCTSPECIFICATIONS

Dimensions(insertdrawingsfront,sideandback)



BEFOREINSTALLATION

This appliance shall only be installed by an

authorizedprofessional.

This appliance shall be installed in accordance

withthemanufacturer’sinstallationinstructions. 

This appliance must be installed in accordanc e

withthenorms&standardsofthecountrywhere

it will be installed. The installation of this

appliance must conform to local

 codes and

ordinances. In the absence of local codes,

InstallationsmustconformstoAmericanNational

Standards.

The appliance, when installed, must be

electrically grounded in accordance with local

codes or, in the absence oflocal codes, with the

NationalElectricalCode,ANSI/NFPA70.

All opening andholes in the wall

and floor, back

and under the appliance shall be sealed before

installationoftheappliance.

WARNING!

Donotuseaerosolspraysinthevicinityofthis

appliancewhileitisinoperation

ROOM VENTILATION: An exhaust fan may be

used with the appliance; in each case it shall be

installed

in conformity with the appropriate

national and local standards. Exhaust hood

operationmayaffectotherventedappliances; in

each case it shall be installed in conformity with

theappropriatenationalandlocalstandards.



INSTALLINGTHELEGS

Bertazzonirangesmustbeusedonlywiththe

legsproperlyinstalled.

Fourheight‐adjustablelegsareshippedwiththe

rangeinthepolystyrenecontainersituatedover

theappliance.

Before installing  the legs, position the appliance

nearits final locationasthe legs are notsuitable

formovingtheapplianceoverlong

distances.

After unpacking the range, raise it enough to

insert the legs in the a ppropriate receptacles

situated on the lower part of the appliance.

Lowerthe range gentlyto keep anyundue strain

fromlegsandmountinghardware.Ifpossibleuse

apalletorliftjackinsteadoftiltingthe

unit.

Adjust leg height tothe desired level bytwisting

the inside portion of the leg assembly until the

properheightis  reached.Check with a  levelthat

thecooktopisperfectlylevel.



INSTALLINGTHEBACKGUARD

The back guard must be installed prior to

operation of the appliance for appropriate

ventilationoftheovencompartment.

Remove n°2 screws fixing worktop as shown

below.



Place front part of the backguard and attach it

from bottom side with the two removed screw

(point2)asshownbelow.



Fix the front part of the backguard with the

screwssuppliedwiththebackguardkit.



Assemblebackpartwithfrontpartofthe

backguardandfixthemwithascrewssupplied

withthebackguardkit.

INSTALLINGTHEANTI‐TIPStability

DEVICE

Theanti‐tipbracketshipped withtherangemust

beproperly secured to therearwallas shown in

thepicturebelow.

Theheightofthebracketfromthefloormustbe

determined after the range legs have been

adjusted to the desired height and afterthe

rangehasbeenlevelled.



Measure the distance from the floor to the

bottom of the anti‐tip bracket receptacle on the

backoftheappliance.

Position the two anti‐tip brackets on the wall at

the desired height plus 1/8" (0.32 cm). The

bracketsmustbe placed at2”5/16(6,0cm)from

the side

of the range. The distance between the

twobracketis25”1/4(64,1cm).

Secure the bracketsto the wall with appropriate

hardware.

Slidetherangeagainstthewalluntilthebrackets

are fully inserted into their receptacles on the

backoftherange.



INSTALLATIONREQUIREMENTS

ELECTRICAL

A properly grounded and horizontally‐mounted

electrical receptacle Type NEMA 14‐50R should

beinstallednohigherthan3"(7.6cm)abovethe

floor,nolessthan2”(5cm)andnomorethan8”

(20,3 cm) from the left side (facing product);

refer to ELECTRICAL CONNECTION section pag.

12.



Checkalllocalcoderequirements.



INSTALLATIONADJACENTTOKITCHEN

CABINETS

WARNING

Toeliminatetheriskofburnsorfirebyreaching 

overheatedsurfaceunits,cabinetstoragespace

located above the surface units should be

avoided.Ifcabinetstorageistobeprovided,the

risk can be reduced by installing a range hood

that projects horizontally a minimum of 5

inchesbeyond

thebottomofthecabinets.



This range may be installed directly adjacent to

existingcountertophighcabinets(36"or91.5cm

fromthefloor).

For the best look, the worktop should be level

with the cabinet countertop.  This can  be

accomplished by raising the unit using the

adjustmentspindlesonthelegs.

ATTENTION: the range CANNOT

 be installed

directly adjacent to kitchen walls, tall cabinets,

tall appliances,  or other vertical surfaces above

36" (91.4 cm) high. The minimum side clearance

insuchcasesis6"(15.2cm).

Wallcabinets  withminimumsidecleara nce must

be installed 18" (45.7 cm) above the countertop

withcountertopheightbetween

35½”(90.2cm)

and37¼”(94.6cm).Themaximumdepthofwall

cabinetsabovetherangeshallbe13"(33.0cm)



EXHAUSTHOODINSTALLATION

ThisrangewillbestperformwhenusedwithPRO

lineBertazzoniexhausthoods.Thesehoodshave

been designed to work in conjunction with the

Bertazzoni range and have the same finish for a

perfectlook.

For maximum performance, the height of the 

bottomof the hood from the worktop should be



between 25 1/2" (65 cm) and 31 1/2" (80 cm).

This would typically result in the bottom of the

hoodbeing61 1/2" (156.2 cm) to67 1/2" (171.5

cm) above the floor.  These measurements

provide for safe and efficient operation of the

hood.

Before installation of the exhaust hood,

consult

local or regional building and installation codes

foradditionalspecificclearancerequirements.

Refer to the range hood installation instructions

provided by the manufacturer for additional

information.







A 30” (76,2 cm)

B 36” (91,5 cm)

C 13” (33,0 cm)

D 18” (45,7 cm)

E 35”1/2(90,2 cm) / 37” ¼ (94,6 cm)

F 6” (15,2 cm)

ELECTRICALCONNECTION

The appliance shall  be connected toa single

phase electric line rated at 120/208Vac or

120/240Vacand60Hzfrequency.



Electricpowerrating:

‐120/208Vac:11800Wattor53Amax.

‐120/240Vac:12900Wattor56Amax.



Ovenheatingelementspowerrating:

‐Ovenbakeelement=2100Watt

‐Oven

circularelement=3300Watt

‐Ovenbroilelement=3400Watt



Inductionheatingelements powerrating:

‐

210inductionelement=2300–3700Watt

‐

180 induction element = 1850 – 3000 Watt

(nr.2zones)

‐

145inductionelement=1400–2200Watt



Installasuitableelectricpowersupplyreceptacle

connection typeNEMA 14‐50R able to support a

load of atleast 50 A (per line) according to local

coderequirements.Forfourorthreewirespower

supplyconnectionsystemseediagrambelow.

FOUR-WIRE CONN.RECEPTACLE NEMA 14-50R

THREE-WIRE CONN.RECEPTACLE NEMA 14-50R



Check your local code for which of the options

belowshould be usedin grounding the

receptaclepowersupplyconnections.



OPTION 1 – FOUR Wires connection:

‐ Connect the L1 receptacle terminal to the

incoming BLACK electrica l  supply wire (L1‐hot 

wire)

‐ Connect the L2 receptacle terminal to the

incoming RED electrical supply  wire (L2‐hot

wire)

‐ Connect the NEUTRAL receptacle terminal to

the incoming NEUTRAL (WHITE) electrical

supplywire

‐ Connect the GROUND receptacle terminal to



the incoming GROUND (GREEN) electrical

supplywire

OPTION2‐THREE‐Wiresconnection:

‐ Connect the L1 receptacle terminal to the

incoming BLACK electrica l  supply wire (L1‐hot 

wire)

‐ Connect the L2 receptacle terminal to the

incoming RED electrical supply  wire (L2‐hot

wire)

‐ Connect the NEUTRAL with the GROUND

receptacle terminal to the incoming NEUTRAL

(WHITE)electrical

supplywire

DO NOT USE EXTENSION CORDS WITH THIS

APPLIANCEASITMAYRESULTINFIRE,ELECTRIC

SHOCKOROTHERtypeofPERSONALINJURY.



The appliance isequipped at the factory with an

electric supply cord set 4 wires type with ring

terminals (L1, L2,  N, Ground) suitable for range

use UL/CSA listed typ e SRDT/DRT 2x6AWG (L1,

L2)+2x8AWG (N, G) rated 300V, 50A with fused

plug type NEMA 14‐50P; cable length 1,5 m.; in



casethesupplycordsetmustbereplaced,itshall

bereplacedwithanidenticalsethavingthesame

technical specs and followingcarefully the

instructionsanddiagramsbelow:

1) Disconnect appliance from electrical power

supplyreceptacle

2) Slideouttheappliancefrominstallationplace

toaccesstobackenclosure

panel

3) Remove back enclosure panel by removing

the6screwsasshownbelow.



4) Loosestrainreliefbyunscrewingthetwo

strainrelief'sscrewsasindiagram.



5) Remove damaged supply cord set by taking

off the 4 electrical connection screws (block

L1,N,L2andGroundscrew,seediagram)

6) Insert the new supply cord set in the strain

relief and lock it with two strain relief's

screwsinsuitableposition.

7) Fix well thering

terminals G, L1, N, L2 of the

new supply cord set asshown in diagram

withits4screws

8) Re‐install the back enclosure panel with 6

screws

9) Slide the appliance back into its proper

location

10) Re‐connect the appliance to the electrical

power.

ELECTRICALGROUNDING

Thisapplianceisequippedwithafour‐prongplug

for your protection against shock hazard and

should be plugged directly into a properly

grounded receptacle. Do not cut or remove the

groundingprongfromthisplug.



WARNING!

ELECTRICALSHOCKHAZARD

Disconnectelectricalpowe ratthecircuit

breakerbox

orfuseboxbeforeinstallingthe

appliance.

Provideappropriategroundfortheappliance.

Usecopperconductorsonly. 

Failuretofollowtheseinstructionscouldresult

inseriousinjuryordeath



CAUTION

Labelallwirespriortodisconnectingwhen

servicingcontrols.Wiringerrorscancause

improperanddangerousoperation.

Verifyproperoperation

afterservicing



APPLIANCESERVING

Beforecarryinganyservicingoperation

disconnecttheappliancefromgasandelectric

supplyandextraappliancefromfinal

installationplaceinordertohaveaccesstothe

applianceforproperservicingintervention.



LOCATIONOFAPPLIANCEPLATES

Thedataratingplateshowsthe modeland serial

number of your range. It is  located under the

front edge of the range cooktop, and is visible

whentheovendoorisopen(seeillustration)



A=Ratingplate(s)locatedunderfrontedgeof

cooktop

B=Wiring/schematicdiagramplacedon

backsidepanelandoninstallationbooklet



WIRINGDIAGRAM



INSTALLATIONChecklist

1. Istherangemountedonitslegs?

2. Isthebackguardsecurelyconnected?

3. Hastheanti‐tipdevicebeenproperly

installed?

4. Doestheclea rancefromthesidecabinets

complywiththemanufacturersdirections?

5. Istheelectricityproperlygrounded?



FINALPREPARATION

Allstainlesssteelbodypartsshouldbewiped

withhot,soapywaterandwithaliquidstainless

steelcleanser.

Ifbuild‐upoccurs,donotusesteelwool,abrasive

cloths,cleaners,orpowders!Ifitisnecessaryto

scrapestainlesssteeltoremoveencrusted

materials,soakwithhot,wetclothsto

loosenthe

material,thenuseawoodornylonscraper.Do

notuseametalknife,spatula,oranyothermetal

tooltoscrapestainlesssteel!Scratchesare

almostimpossibletoremove.

Beforeusingtheovenforfoodpreparation,wash

thecavitythoroughlywithawarmsoapand

watersolution

toremovefilmresiduesandany

dustordebrisfrominstallation,thenrinseand

wipeddry.

USERMANUAL

IMPORTANT

Takecareofresetallworktop/oven/broiler

burnerscontrolsinOFFpositionafteruseofthe

appliance.

WARNING!

ProperInstallation.Besureyourapplianceis

properlyinstalledandgrounded byaqualified

technician.

Donotleavechildrenalone.Childrenshouldnot

beleftaloneorunattendedinarea

where

applianceisinuse.Theyshouldneverbe

allowedtositorstandonanypartofthe

appliance.

Wearproperapparel.Loose‐fittingorhanging

garmentsshouldneverbewornwhileusingthe

appliance.

Userservicing.Donotrepairorreplaceanypart

oftheapplianceunlessspecifically

recommended

inthemanual.Allotherservicing

shouldbereferredtoaqualifiedtechnician.

Useonlydrypotholders.Moistordamp

potholdersonhotsurfacesmayresultinburns

fromsteam.Donotletpotholdertouchhot

heatingelements.Donotuseatowelorother

bulkycloth.

Donotto

covertheholesinsidetheovenwith

aluminiumfoil.

Donottocovertheworktopwithaluminium

foil.

Donotstoreanyflammableobjectorobjects

underpressureinthestoragecompartment.

Keeptheareaofoperationoftherangefree

fromcombustiblematerials,gasolineandother

flammablevapoursandliquid.



Donotstoredangerousorflammablematerials

inthecabinetsabovetheappliance,sincethis

mayresultinapotentialfi rehazard.

Donotusetheapplianceforspaceheating.

Donotuseaerosolspraysinthevicinityofthe

appliancewhilecooking.

Donotsitorsteponthe

ovendoor.

Donotuseovencompartmentforstorage.

UseCareWhenOpeningDoor.Lethotairor

steamescapebeforeremovingorreplacingfood

Donotheatunopenedfoodcontainers.Build‐up

ofpressuremaycausecontainertoburstand

resultininjury.

Keepovenventductsunobstructed.

Alwaysplace

ovenracksindesiredlocation

whenoveniscool.Ifrackmustbemovedwhile

ovenishot,donotletpotholdercontacthot

heatingelementinoven.

Donottouchheatingelementsorinterior

surfacesofoven.

Donotcleanovendoorgasket.Thedoorgasket

isessentialfor

agoodseal.Careshouldbetaken

nottorub,damage,ormovethegasket.

Donotuseovencleaningproducts.No

commercialovencleanerorovenliner

protectivecoatingofanykindshouldbeusedin

oraroundanypartoftheoven.

Cleanonlypartslistedinmanual.

Before

startingtheself‐cleaningcycleofthe

oven,removebroilerpanandotherutensils.

Donotusewaterongreasefires.

Smotherfireorflamesorusedrychemicalor

foam‐typeextinguis her.



ROOMVENTILATION

The use of a cooking appliance generates heat

and humidity in the room where it is installed.

Proper ventilation in the room is needed. Make

surethekitchenisequippedwitharangehoodof

appropriatepower(400CFMminimum).Activate

the exhaust fan/range hood when possible.

Intensive and continuous use

 of the appliance 

may require additional ventilation, for example

byopeningawindow.



USINGTHEINDUCTIONCOOKTOP

AREA

COOKTOPAREACONTROLKNOB

Theseknobsprovidecontroloftheceramic

cooktoparea'scookingzones.

Thezoneitcontrolsisshownaboveeachknob.

Turntheknobtotherighttosetthezone's

operatingpower;thesettingsrangefroma

minimumof1toamaxim umof9.

Theworkingpower

isshownbyadisplayonthe

cooktoparea.

Heatingaccelerator

Each cooking  zone is equipped with a heating

accelerator.

This system allows the zone to be operated at

peak power for a time proportional to the

heatingpowerselected.

Tostarttheheatingaccelerator,turntheknobto

the left, select setting "A" and then release. The

letter "A"

 will  appear on the display on the

cooktoparea.

You now have 3 seconds to select the heating

setting of your choic e. Oncea setting between1

and 9 has been selected, "A" and the chosen

settingwillflashinalternationonthedisplay.'

Whiletheheating accelerator

isinoperation,the

heating level can be increased at any time. The

"full power" time will bemodified accordingly.If

the power is reduced by turning the knob

anticlockwise, option "A" is automatically

deactivated.

PowerFunction

The power function allows the user to operate

each heating zone continuously atthe maximum

power for a time of no more than 10 minutes.

Thisfunctioncanbeused,forexample,tobringa

largeamount ofwatertotheboilinahurry,orto

turnuptheheat

undermeat.

Turn the knob clockwise and set heating level 9,

then use the knob to set the "P" position and

releaseil."P"appearsonthecorrespondingzone

display.

After 10 minutes, the power is reduced

automatically, the knob returns to the 9 setting

andthe"P"

disappears.

However,thepowerfunctioncanbeturnedoffat

anytimebyreducingtheheatinglevel. .

When the power function is selected for one

heatingzone(e.g.theleftfrontzone),thepower

absorbed by the second zone (Ieft rear zone)

might be reduced to supply the maximum

available

energytothefirstzone. 

Consequently, the power function takes priority

overtheheatingaccelerator.

If a panis removed from thecookingzone while

thepowerfunctionison,thefunctionisswitched

off.

HoldingFunction

The holding function keeps the temperature of

the bottoms of pans at about

110°F/42°C or

160°F/70°C.Thisallowsfoodstobekepthotwith

optimal energy consump tion and to be heated

gently. The holding function can be kept in

operationforupto2hours.

The holding function is

and is indicated by

therelevantsymbolonthecookingzones.



COOKTOPAREA

ATTENTION:

Metalitemssuchascutleryorlidsmustneverbe

placed on the surface of the cooktop area since

theymaybecomehot.

Cookingzones

Theappliance is equippedwith 4 cooking zones 

having different diameter s and powers. Their

positions are clearly marked by rings, while the

heating power is

 only released in the area

shown on the ceramic cooktop area. The 4

cookingzonesareofinductiontypeandstartto

heat up a few seconds after they are switched

on.Thehea tlevelofeachzonecanberegulated 

from the minimum to the maximum setting

usingthe

knobsonthefrontpanel.

Underneath each cooking zone there is a  coil 

called an inductor, supplied with power by an 

electronic system, which generates a variable

magneticfield. When a panis placed insidethis

magnetic field, the highfrequency currents

concentrate directly on the bottom of the pan

andproduce

theheatneededtocookthefoods.

The4lights betweenthecookingzonescomeon

when the temperature of one or more cooking

zones exceeds 140°F/60° C.. The lights go out

when the temperature drops to below about

140°F/60°C.



SURFACEHOTPLATES

1.Mediuminductionelement

2.Mediuminductionelement

3.Biginductionelement

4.Smallinductionelement



Zone

num:

Zone

diam:

Powerabsorption

Normal

operation:

Withpower

function:

1 7” 1850W 3000W

2 7” 1850W 3000W

3 83/16” 2300W 3700W

4 53/4” 1400W 2200W



When the cooktop area is used for the first

time, it should be heated to its maximum

temperature for long enough to bum off any

oilyresiduesleftbythemanufacturingprocess,

which might contaminate foods with

unpleasantsmells.

TYPESOFPANS

Thistypeofappliancecanonlyoperatewithpans



ofspecialkinds.

Thebottomofthepanmustbeironorsteel/iron

togeneratethemagneticfieldnecessaryforthe

heatingprocess.

Vesselsmadefromthefollowingmaterialsare

notsuitable:

 glass;

 porcelain;

 pottery;

 steel,aluminiumorcopperwithout

magneticbottom;

Tocheckthata

panissuitable,simplypi acea

magnetclosetoitsbottom:

ifthemagnetisattracted,thepanissuitablefor

inductioncooking.Ifnomagnetistohand,puta

littlewaterinthepan,piaceitonacookingzone

and switch it on. If the symbol appears on

 the

display inste ad of the power, the pan is not

suitable.

Thepansusedforcookingmusthavecertain

minimumdiameterstoensuresatisfactory

operation.

Panslargerthanthecookingzonescanalsobe

used,butitisimportanttoensurethatthe

bottomofthepandoesnottouch

othercooking

zones,andthatitisalwayscentredoverthe

cookingzone.

Zonenumber Panminimumdiameter

1 45/16”

2 45/16”

3 51/2”

4 39/16”



Use only vessels specially designed for induction

cooking, with thick, completely flat bottom; if

these are not available, the pans used must not

havecrowned(concaveorconvex)bottom.



Panpresentdevice

Eachcookingzoneisequippedwitha"pan

present"device,whichensuresthatcooking

cannotstartunlessasuitablepanispresenton

thecookingzoneandproperlypositioned.

If the user attempts to switch on the cooking

zone with the pan not positioned properly or

withapanwhichis

notofsuitablematerial,afew

seconds after the zone is switched on the

symbol will appear to warn the user that an

errorhasbeenmade.

Residualheat

Each cooking zone is equipped with a device

which warns of residual heat. After any cooking

zoneisswitchedoff,aflashing‘H’mayappearon

the display. This warns that the cooking zone

concerned is stili very hot. Cooking can be

restartedwhilethe‘H’isflashing.

Childlockfunction

When not in use, the cooktop area can be

"locked out" to prevent children from

accidentallyswitchingiton.

With the cooking zones off, turn the knobs of

zones1and2totheleftsimultaneouslyuntil‘’L’’

appearonthepower

displayandthenreleasetheknobs.

To deactivate

it,repeatthesame procedure: the

cookingzonedisplayswillstopdisplayingthe‘’L’’,

indicatingthatthecookingzonelock‐outfunction

hasbeendeactivated.

Attention:

Take care not to spill sugar or sweet mixtures

ontothecooktopareaduringcooking,ortoplace

materialsorsubstanceswhichmightmelt(plastic

or aluminium foil) on it; if this should occur, to

avoiddamagetothesurface,turntheheatingoff

immediately andclean with  the scraper supplied



while the cooking zone is still warm. If the

ceramiccooktopareaisnotcleanedimmediately,

residues may form which cannot be removed

oncethecooktopareahascooled.

Important!

Keep a close eye on children because they are

unlikely to see the residual heat warning lights.

Thecookingzonesarestill veryhotforsometime

after use, even if they are switched off. Make

surethatchildrennevertouchthem.



WARNING:Undernocircumstanceuse

aluminiumfoilorplastic

containerstoholdthe

foodwhilecookingonaglass‐ceramiccooktop

area.

WARNING:Donotsoakremovableheating

elements–heatingelementsshouldneverbe

immersedinwater.

WARNING:Donottouchthecookingareaaslong

asthelightindicatingresidualheatontheglass‐

ceramiccooktoparea,

is“on”;thisindicatesthat

thetemperatureintherelativeareaisstillhigh.

WARNING:Neverplacepanwithbottomswhich

arenotperfectlyflatandsmoothonthecooktop

area.

WARNING:Ifyounoticeacrackintheceramic

cooktoparea,disconnecttheappliancefromthe

electricitysupplyandcontact

aservicecentre.

WARNING:Yourglass‐ceramiccooktopareais

thermalshockresistantandresistanttoboth

heatandcold.

If you drop a heavy pot on your cooktop area it

willnotbreak.

Onthecontra ry,ifahardobject,suchasthesalt

shakerorthespicebottle

strikestheedgeorthe

cornerofthecooktoparea,thecooktopareamay

break.

WARNING:neverusetheglass‐ceramiccooktop

areaassupportsurface.

WARNING:Donotcookonbrokencook‐top.

WARNING:Cleancook‐topwithcaution.Some

cleanerscanproducenoxiousfumesifapplieda

hotsurface.



Onlyusecleaningproductsmadespecificallyfor

ceramicglasscookingsurfaces.



SURFACECOOKING

IMPORTANT

Takecareofresetallworktop/oven/broiler

burnerscontrolsinOFFpositionafteruseofthe

appliance.

SYMBOLS

 



 Induction position (in this case

frontrightinductionelement).







OVENCOOKING

WARNING!

UseCareWhenOpeningDoor.Lethotairor

steamescapebeforeremovingorreplacing

food.

DoNotHeatUnopenedFoodContainers.Build‐

upofpressuremaycausecontainertoburstand

resultininjury.

KeepOvenVentDuctsunobstructed.

PlacementofOvenRacks.Alwaysplaceoven

racksindesired

locationwhileoveniscool.If

rackmustbemovedwhileovenishot,donotlet

potholdercontacthotheatingelementinoven.

DoNotCleanDoorGasket.Thedoorgasketis

essentialforagoodseal.Careshouldbetaken

nottorub,damage,ormovethegasket

DoNotUsecommercialovencleaneroroven

linerprotectivecoatingofanykindshouldbe

usedinoraroundanypartoftheoven.

CleanOnlyPartsListedinmanual.

BeforeSelf‐CleaningtheOven.Removebroiler

panandotherutensils.

IMPORTANT

Incaseofelectricpowerfailurereset

oven/broiler

controlsinoffpositionandnot

attempttouseoven/broilertillelectricpower

hasbeenrestored.

CAUTION

Donotstoreitemsofinteresttochildrenin

cabinetsabovearangeoronthebackguardofa

range–childrenclimbingontherangetoreach

itemscouldbeseriously

injured.



DONOTTOUCHHEATINGELEMENTSOR

INTERIORSURFACEOFOVEN

Heating elements may be hot even though are 

dark in colour. Interior surfaces of an oven

become hot enough to cause burns. During and

after use, do not touch, or let clothing or other

flammable materials come into contact

with the

heating elements or interior surfaces of oven

untilthey havehadsufficienttimetocool.Other

surfaces of the appliance  may become hot

enough to cause burns, for example, oven vent

openingsandsurfacesneartheseopenings,oven

doors,ovenglasswindow.



WARNING

TO REDUCETHE RISK

OF TIPPING OF THE

APPLIANCE, THE APPLIANCE MUST BE SECURED

WITHAPROPERLYINSTALLEDANTI‐TIPDEVICES.

TO CHECK IF THE DEVICES ARE INSTALLED

PROPERLY, REMOVETHE APPLIANCE FROM THE 

WALL AND VERIFY THAT THE ANTI‐TIP DEVICES

AREENGAGED.

IMPORTANT

Takecareofresetallworktop/oven/broiler

burnerscontrolsinOFF

positionafteruseofthe

appliance.

SYMBOLS

OVENFUNCTIONSSELECTOR



TEMPERATURE/CLEANSELECTOR



OVENRACKS

Bertazzoni ranges are equippedwith commercial

gradeshelvesandanenamelcookingtray.

Shelves are mounted on the appropriate guides

situated on the sides of the oven compartment.

Inserttheshelfbetweentopandbottomguidein

anyofthe5positionsavailable.



Tokeeptheovenascleanaspossible,cookmeat

onthetray.

When available, always follow recipe book

directions. Personal experience will help to

determine any variations in the values reported

in the table. In any case, it is recommended to

followtheinstructionsofthespecificrecipe

being

used.

ATTENTION!

Whenusingtheovenforthefirsttimeitshould

beoperatedfor15‐30minutesatatemperature

ofabout500 °F/260°Cwithou tcookinganything

insideinordertoeliminateanymoistureand

odoursfromtheinternalinsulation.



OVENFUNCTIONSELECTOR

The oven has 8 functions defined for the

following operations (from OFF position in

clockwisedirection):



BAKE(Broiler+Bottomheating

elements)tobeusedwithoventemperature

from100°F/38°Cto500°F/260°C



CONVECTIONBAKE(Broiler+Bottom

heatingelements+fan)tobeusedwithoven

temperaturefrom100°F/38°Cto500°F/260°C



TURBO(Circular+Bottomheating

elements+fan)tobeusedwithoven

temperaturefrom100°F/38°Cto500°F/260°C



BROILER(Broilerheatingelement) to

beusedwithtemperatureselectorat

500°F/260°Cforbroiling



CONVECTIONBROILER(Broiler

heatingelement+fan)tobeusedwith

temperatureselectorat500°F/260°Cfor

convectionbroiling



CONVECTION(Circularheating

element+fan)tobeusedwithoven

temperaturefrom100°F/38°Cto500°F/260°C



DEHYDRATE(Bottomheatingelement

+fan)tobeusedwithtemperatureselector

at100°F/38°C(correspondingtoaninternal

ovensetupfixedtemperatureof100°F/38°C)



PROOFING(Bottomheatingelement)

tobeusedwithtemperatureselectorsetat

150°F/65°C(correspondingtoaninternal

ovensetupfixedtemperatureof100°F/38°C)



WARMING‐Level1(Bottomheating

element)tobeusedwithtemperature

selectorsetat200°F/95°C(correspondingto

aninternalovensetupfixedtemperatureof

140°F/60°C)



WARMING‐Level2(Bottomheating

element)tobeusedwithtemperature

selectorsetat250°F/120°C(correspondingto

aninternalovensetupfixedtemperatureof

170°F/77°C)



WARMING‐Level3(Bottomheating

element)tobeusedwithtemperature

selectorsetat300°F/150°C(correspondingto

aninternalovensetupfixedtemperatureof

220°F/105°C)



CLEAN(Broiler+Bottomheating

elements)tobeusedwithtemperature 

selectorsetatCLEANforautomaticself‐

cleaningcycleatatemperatureofabout

840°F/450°C(seeproperchapter“SELF

CLEANINGTHEOVEN”pag.27fordetails ). 



USINGTHEOVEN

OVENLIGHT

The appliance is equipped with two oven lamps

that light up when the oven door is opened or

each time the oven is in operation. They are

turnedoffduringthecleaningcycle.

COOLINGFANS

The appliance is equipped with two cooling fan

motors that activate when the oven

 is in

operation for cooking orcleaning, except incase

of DEHYDRATE and PROOFING functions. In

stand‐bycondition(bothselectorinOFFposition)

the cooling fan motors operate if oven

temperatureexceedsapproximately430°F/220°C

and stop automatically when oven temperature

drops below approximately 285‐360°F/140‐

180°C.

FRONTINDICATORLIGHTS

This appliance is equipped with 3 indicatorlights

onthefrontpanel:

‐CLEAN/RED colour: on with doorlocked during

cleaningcycle

‐HEATING/BLUE colour: on when cooking or

cleaning temperature is reached, always on

during functions Dehydrate‐Proofing‐Warming

levels1‐2‐3

‐ PRE‐HEATING/BLUE colour: on during pre‐

heating

period; not active for functions

Dehydrate‐Proofing‐Warminglevels1‐2‐3.

The indicator  lights flash intermittently (in some

case together with the sound buzzer) when an

error is detected. For explanation of errors,

please refer to the chapter TROUBLESHOOTING

GUIDE.

SOUNDBUZZER

The appliance is equipped with a sound buzzer



that emits a triple “beep” each time the pre‐

heating time is finished (not used for functions

CLEAN and Dehydrate‐Proofing‐Warming levels

1‐2‐3”) and a single intermittent “beep” in some

casejointlywiththeindicatorlightwhenanerror

isdetected (refertochapterTROUBLESHOOTING

GUIDE).

OVENCONVECTIONFAN

The appliance is equipped with an oven fan

mounted inside a  circular heating element,

protectedbyafanshieldonthebackoftheoven

cavity; it operates each time that the oven

operates in the functions ROASTING, TURBO,

CONVECTION BROILER, CONVECTION BAKE and

DEHYDRATE.

BAKE

PREHEATINGTHEOVEN

Preheat the oven before baking. The oven does

not need to be preheated for large pieces of

meat or poultry. See your recipe for preheating

recommendation. Preheating time depends on

thetemperaturesettingandthenumberofracks

intheoven.



GETTINGTHEBESTRESULTS

Minimizeopening

thedoor.

Choosetherightsizebakeware.

Usethebakewarerecommendedintherecipe.

Storethebroilerpansoutsidetheoven:extra

panswithoutfoodaffectthebrowningand

cooking.

Browningcandependfromthetypeofpanused:

- Fortender,goldenbrowncrusts,uselight

non‐stick

anodizedorshinymetalpans.

- Forbrowncrispcrusts,usedarknon‐

stick/anodizedordark,dullmetalutensilsor

glassbakeware.Thesemayrequirelowering

thebaketemperature25°F/ ‐4°C.



BAKEWARETYPE

Metal bake ware (with or without a non‐stick

finish),heat‐proofglass,glassceramic,pottery,

or

other utensils are suitable for the oven. Suitable

cookie sheets have a small lip on one side only.

Heavysheetsorthosewithlipsonmorethanone

sidemayaffectthebakingtime.



BAKERACKPOSITIONS

Racklevelpositionsintheovenarenumberedas 

inthediagram

onpage19.



ONE RACK BAKING‐The Bake mode is best for

baking on one rack with rack level 3 and 4 used

for most baked items. When baking tall items,

racklevel  4 may be used.Piesarebestbakedon

racklevel4or5toensurethe

bottomofthecrust

is done without over‐browning the top. When

large pieces of meat or poultry are roasted such

as a prime rib ofbeef or a turkey, rack level 4is

thepreferredrack.



TWO RACK BAKING‐Rack levels3 and 5 may be

used when baking

 on two levels. Cookies and

biscuits can be cooked properly using  these two

racks.Casseroledishes may al so bebaked using

thesetwolevels.



Page is loading ...

Bertazzoni PRO304INSX Installation, Use and Care Manual

Brand: Bertazzoni

Model: PRO304INSX

Category: Kitchen & houseware accessories

Type: Installation, Use and Care Manual

This manual is also suitable for

MAS304INSXT

Download PDF

report

Bertazzoni PRO304INSX Installation, Use and Care Manual

This manual is also suitable for

Bertazzoni PRO304INSX Installation, Use and Care Manual

Related papers

Other documents