de Jong Duke NIO User manual

user manual

Contents

1 Safety 6

1.1 Safety use 6

1.2 Installaon 7

1.3 Maintenance 7

1.4 Extendeddownme 8

2 Descriponofthemachine 10

2.1 General 10

2.2 Themachineexteriorandinterior 10

2.3 Displayandselecons 10

2.4 Type plate 10

3 UsingtheNio 12

3.1 Switchon 12

3.2 Switcho 12

3.3 Preparing a drink 12

3.4 Numberselecon 14

3.5 Filling the ingredients 14

3.6 Manualgroundcoeeinsert 15

3.7 Connectthefreshmilk 15

3.8 Servicemenu 17

4 Informaon 18

4.1 Readingoutthecounters 18

5 Maintenanceandcleaning 20

5.1 Dailymaintenance 20

5.2 Weeklymaintenance 25

5.3 Monthlymaintenance 34

5.4 Yearlymaintenance(onlyforoponalfreshmilksystem) 35

6 Messages 36

7 Technicalspecicaons 38

8 Normsandstandards 39

6

1 Safety

1.1 Safety use

• Beforeusingyourcoeemachine,pleasereadthesafety

instruconsandalloftheinformaoninthismanualrstand

keepitforfuturereference.

• Becareful!Thismachineserveshotdrinks.Don’treach

beneaththedispensingnozzlesandhotwaterspoutaer

seleconandduringdispensing.

• Ifafaultoccurs,disconnectthemachinefromtheelectricity

supplyandfromthewatersupply.

• Thisappliancecanbeusedbychildrenaged8yearsand

aboveandpersonswithreducedphysical,sensoryormental

capabiliesorlackofexperienceandknowledgeiftheyhave

beengivensupervisionorinstruconconcerninguseofthe

applianceinasafewayandtheyunderstandthehazards

involved.Childrenshallnotplaywiththeappliance.Cleaning

andusermaintenanceshallnotbedonebychildrenwithout

supervision.

• Themachinemayonlybeinlocaonswhereitcanbe

overseenbytrainedpersonnel.

!

Safety 7

1.2 Installation

• Installaon,transportaonandadjustmentofthemachine

shouldonlybecarriedoutbyproperlytrainedservice

personnel.Theirinstruconsfortransportaon,unpacking

andinstallaonofthemachine,areavailableinthetechnical

manual.

• Checktheappliancefortransportdamage.Donotconnecta

damagedmachine.

• Themachineisnotsuitableforoutdooruse.

• Donotinstallthemachineinanareawhereawaterjetor

similardevicecouldbeused.

• Placethemachineonalevelsurfaceinahygienicdryroom,

withatemperaturebetween5°Cand35°C.(40°F-95°F)

• Donotuseanextensioncord.

• Onlyhose-setsaccordingtoIEC61770maybeusedforthe

connecontothewatersupply.

1.3 Maintenance

• Regularcleaningaccordingthismanualisneededtoensure

hygienicoperaon.

8

• Theapplianceshallnotbecleanedbyawaterjet.

• Donotusewaterinornearthemachineunlessthe

instruconsexplicitlygivedirecontodoso.

• Donotuseaggressivecleaningproductsorabrasivestoclean

(partsof)themachine.

• Ifthepowercordisdamaged,itmustbereplacedbythe

manufacturer,itsserviceagentorsimilarqualiedpersonsin

ordertoavoidasafetyissue.

1.4 Extended down time

• Ifthemachinewillnotbeusedforalongerperiodofme(for

exampleduringtheholidays)itisrecommendedtoswitcho

thewatersupplyandtheelectricity.Themainon/oswitchis

locatedattherearsideofthemachine.

• Inareaswherethetemperaturecandropbelowfreezing,the

boilersmustbeemped.Contacttechnicalsupportofthe

supplier.

• Whenfreezinghasoccurred,pleasecontactthetechnical

supportofyoursupplier.

Safety 9

10

2 Description of the machine

2.1 General

Thisisafullyautomacsinglecupmachineforcoee,cafécrème,espresso,

cappuccino,macchiatoandhotwater.Alwaysplaceacupbeforeselecngadrink

fromthetouchscreen.Youcanadjustforweakerorstrongertasteintheselecon

menu.Yoursuppliercanmakefurtheradjustmentstothestrengthandsizesofthe

drinks.

2.2 The machine exterior and interior

See the foldoutinthebackofthisguide.Theexteriorandinteriornumbersand

leerscorrespondwiththenumbersorleersbetweenthebrackets( ) in the text.

2.3 Display and selections

Themachinecanbeoperatedusingthetouchscreenpanel(6)onthedoor.By

pushingoneoftheseleconbuonsonthescreen,aproductchoicecanbemade.

Beforeyoudispenseabeverage,acupmustbeplacedunderoneoftheoutlets.

2.4 Type plate

Seefoldoutforlocaonofthetypeplate(F).

Thetypeplateshows:

• Manufacturer.

• Serialnumber.

• Type/modelspecicaon.

• Dateofproducon.

• Waterconnecon.

12

3 Using the Nio

3.1 Switch on

1 Checkifthewatersupplyisturned

on.

2 Presstheon/oswitch(14)atthe

rearsideofthemachine.Thecoee

machineswitchesonandheatsup.

3.2 Switch off

Theon/oswitch(14)islocatedatthe

rearsideofthemachine.

1 Press‘O’toswitchothemachine.

2 Ifthemachinewillnotbeused

foralongerperiodofme,itis

recommendedtoturnothewater

supply.

3 Seealsochapter1.4‘Extended

downme’.

3.3 Preparing a drink

1 Placecupunderoutlet.

2 Adjusttheheightofthecoee

outlet(9)tothesizeofyourcup.

Themaximumheightofacupis

135mm/5.3in.Fig.2.

3 Selectabeveragebypushingoneof

thebuonsonthetouchscreen.

4 Ifapulldownarrowisshownin

2

1

UsingtheNio 13

theboomofthemenu,more

seleconsareavailableusingthis

buon.

5 Ifyouwanttochangeyour

selecon,pressthe‘Cancel’buon

onthescreentoreturntothemain

menu.

6 Ifavailable,youmaysetthe

strengthofyourbeverageusingthe

buonsintheseleconmenu,then

pressthe‘Start’buon.

7 Aerthecupislled,themachine

willsignal‘beep’andthescreenwill

indicate‘Ready,takeyourcup’.

8 Youcanstoptheprocessanyme

bypressingthe‘Stop’buononthe

screen.

3

14

3.4 Number selection

Eachselecteddrinkhasitsowncode.

Usingthiscodeyoucandirectlyselect

adrinkwiththe‘Numberselecon’

funcon.Thiscodeisdisplayedinthe

menuwhenpreparingthedrink.

1 Inthemainmenuselectthebuon

‘Numberselecon’.

2 Enterthebeveragecode.

3 Press‘Start’.

3.5 Filling the ingredients

Ingredientcanisterscanbelled

withoutopeningthedooroftheNio.

Whenlling,thecanisters(2)can

remaininthemachine.Justopenthe

lid(1)ofthecanisterandstartlling.

• Donotllcanistersfurtherthan

necessaryforoneortwodays.This

willkeeptheingredientsfresh.

• Eachcanisterisintendedfora

specicingredient.Theingredient

isshownonatextlabelonthe

canister.Useingredientswhichare

recommendedbythesupplierofthe

machine.

• Toremovethecanisterseechapter

5.3.

Opon

5

4

UsingtheNio 15

3.6 Manual ground coffee insert

Theoponalmanualgroundcoee

inletisusedfordecaeinatedand

specialcoeetypes.

1 Touchthe‘Manualcoeeinsert’

buononthescreen.

2 Openthemanualgroundcoee

inlet(4).

3 Insertthedesiredamountofcoee.

4 Closethemanualgroundcoee

inlet.

5 Press‘Start’.

3.7 Connect the fresh milk

1 Slidetheadjustableoutlet(9)tothe

topposion.

2 Removethewastebucket(11).

3 Slidetheadjustableoutlettothe

boomposion.

4 Removethemilkfrotherassembly

(10)bypushingthelockpinonthe

righthandsideoftheadjustable

outletandcatchthemilkfrother.

Fig.7.

5 Removethecoverfromthepump

unit(15)andconnectthemilkhose

tothepumpconnecons,withthe

text‘UP’visiblefromthetopside.

6 Connecttheinletpiecetothe

Opon Opon

7

6

16

shortestpartofthemilkhoseand

routeitthroughtheholeintothe

refrigerator(16).

7 Routethelongestpartofthemilk

hosethroughtheholeintheright

sideofthemachine.Fig.8.

8 Disassemblethemilkfrotherfrom

theholderandroutethehose

throughtheholeintheholder.

Connectthehosewiththemilk

frother.Fig.9.

Reassemblethefrotherinthe

holder.

9 Mountthemilkfrotherassembly

bymovingitupwardinthelocking

mechanismoftheadjustableoutlet

(9).Fig.10.

10 Slidetheadjustableoutletdownto

theboomposion.

11 Gentlypullthehoseandroute

themilkhoseintotheslotatthe

boomoftherighthandpartof

theoutletbracket.Fig.11.

12 Intherefrigerator,openthemilk

containerandplacethemilktubein

themilkcontainer.

OnlyuseUHTmilk!

10

9

8

Opon

UsingtheNio 17

13 Closetherefrigerator(16).

14 Replacethecoveronthepumpunit

(15).

15 Slidetheoutlettothetopposion

andreplacethewastebucket(11).

3.8 Service menu

Theservicemenucanbeenteredby

eitheropeningthedoororbypressing

thelogoattheboomofthescreen

(6)forabout5seconds.Fig.12.

Keepinmindthatthelogoinyour

situaonmaybedierent.

Fromtheservicemenu,thedaily

cleaningcanbestarted(seechapter

5.1)andproductcounterscanberead

(seechapter4.1).

12

11

Press5seconds

Opon

18

4 Information

4.1 Reading out the counters

1 Entertheservicemenubypressingandholdingthelogoattheboomofthe

screenforabout5seconds.

2 Fromtheservicemenu,select‘Beveragecounters’.

3 Thedisplaynowshowsthe‘Freecounter’,‘Paidcounter’and‘Totalcounter’

4 Select‘Exit’and‘Pressheretoquitservice’toreturntothemainmenu.

1413

Informaon 19

20

5 Maintenance and cleaning

5.1 Daily maintenance

Performingdailymaintenancewillensurethequalityofyourbeveragesanda

properoperaonofthemachine.

Dailymaintenancecanbeperformedwithoutopeningthedoorofthemachine.

Toperformthedailymaintenancethefollowingitemsareneeded:

• \_/asdeliveredwiththehygienekit.

• Asodampcloth.

• Ajug,minimum0.6l/20oz.

• Milkfrothercleaningliquid;DeJongDukepartnumber4INF011.

Step 1. Rell

Checkiftherearesllenoughingredientsinthecanisters(2).

Ifnecessary,llupthecanisters.

Ingredientcanisterscanberelledwithoutopeningthedoorofthemachine.

Donotllcanistersmorethannecessaryforoneortwodays.Thiswillkeepthe

ingredients fresh.

Opon

Page is loading ...

de Jong Duke NIO User manual

Related papers

Other documents