KIA Sportage 2008 User manual

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

1/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

SPORTAGE(KM)>2008>G2.0DOHC>Restraint

Restraint>GeneralInformation>GeneralSafetyInformationand Caution

Precautions

GeneralPrecautions

Pleasereadthefollowingprecautionscarefullybeforeperformingtheairbagsystemservice.Observetheinstructions

describedinthismanual,ortheairbagscouldaccidentallydeployandcausedamageorinjuries.

• Exceptwhenperformingelectricalinspections,alwaysturntheignitionswitchOFFanddisconnectthenegative

cablefromthebattery,andwaitatleastthreeminutesbeforebeginningwork.

ThecontentsinthememoryisnoterasedeveniftheignitionswitchisturnedOFForthebatterycablesare

disconnectedfromthebattery.

• Usethereplacementpartswhicharemanufacturedtothesamestandardsastheoriginalpartsandquality.

DonotinstallusedSRSpartsfromanothervehicle.

UseonlynewpartswhenmakingSRSrepairs.

• CarefullyinspectanySRSpartbeforeyouinstallit.

Donotinstallanypartthatshowssignsofbeingdroppedorimproperlyhandled,suchasdents,cracksor

deformation.

• BeforeremovinganyoftheSRSparts(includingthedisconnectionoftheconnectors),alwaysdisconnecttheSRS

connector.

AirbagHan dlingandStorage

Donotdisassembletheairbags;ithasnoserviceableparts.Onceanairbaghasbeendeployed,itcannotberepairedor

reused.

Fortemporarystorageoftheairbagduringservice,pleaseobservethefollowingprecautions.

• Storetheremovedairbagwiththepadsurfaceup.

• Keepfreefromanyoil,grease,detergent,orwatertopreventdamagetotheairbagassembly.

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

2/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

• Storetheremovedairbagonsecure,flatsurfaceawayfromanyhighheatsource(exceeding85°C/185°F).

• Neverperformelectricalinspectionstotheairbags,suchasmeasuringresistance.

• Donotpositionyourselfinfrontoftheairbagassemblyduringremoval,inspection,orreplacement.

• Refertothescrappingproceduresfordisposalofthedamagedairbag.

• BecarefulnottobumporimpacttheSRSunitorthesideimpactsensorswhenevertheignitionswitchisON,wait

atleastthreeminutesaftertheignitionswitchisturnedOFFbeforebeginwork.

• Duringinstallationorreplacement,becarefulnottobump(byimpactwrench,hammer,etc.)theareaaroundthe

SRSunitandthesideimpactsensor.Theairbagscouldaccidentallydeployandcausedamageorinjury.

• Afteracollisioninwhichtheairbagsweredeployed,replacethefrontairbagsandtheSRSunit.Afteracollisionin

whichthesideairbagwasdeployed,replacethesideairbag,thefrontimpactsensorandsideimpactsensoronthe

sidewherethesideairbagdeployedandtheSRSunit.Afteracollisioninwhichtheairbagsorthesideairbagsdid

notdeploy,inspectforanydamageoranydeformationontheSRSunitandthesideimpactsensors.Ifthereisany

damage,replacetheSRSunit,thefrontimpactsensorand/orthesideimpactsensors.

• DonotdisassembletheSRSunit,thefrontimpactsensororthesideimpactsensors

• TurntheignitionswitchOFF,disconnectthebatterynegativecableandwaitatleastthreeminutesbeforebeginning

installationorreplacementoftheSRSunit.

• BesuretheSRSunit,thefrontimpactsensorandsideimpactsensorsareinstalledsecurelywiththemounting

bolts.

• DonotspillwateroroilontheSRSunit,orthefrontimpactsensororthesideimpactsensorsandkeepthemaway

fromdust.

• StoretheSRSunit,thefrontimpactsensorandthesideimpactsensorsinacool(lessthan104°F/40°C)anddry

(lessthan80%relativehumidity,nomoisture)area.

WiringPrecautions

SRSwiringcanbeidentifiedbyspecialyellowoutercovering(excepttheSRScircuitsunderthefrontseats).

Observetheinstructionsdescribedinthissection.

• Neverattempttomodify,splice,orrepairSRSwiring.

IfthereisanopenordamageinSRSwiring,replacetheharness.

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

3/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

• Besuretoinstalltheharnesswiressothattheyarenotpinched,orinterferewithotherparts.

• MakesureallSRSgroundlocationsareclean,andgroundsaresecurelyfastenedforoptimummetaltometal

contact.Poorgroundingcancauseintermittentproblemsthataredifficulttodiagnose.

PrecautionsforElectricalInspectio ns

• Whenusingelectricaltestequipment,inserttheprobeofthetesterintothewiresideoftheconnector.

Donotinserttheprobeofthetesterintotheterminalsideoftheconnector,anddonottamperwiththeconnector.

• Useaushapedprobe.Donotinserttheprobeforcibly.

• Usespecificedserviceconnectorsfortroubleshooting.

Usingimpropertoolscouldcauseanerrorininspectionduetopoormetalcontact.

SpringloadedLockConnector

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

4/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

AirbagConnector(I)

Connec ting

1. Toreconnect,holdthepawlsideconnectorhalf,andpressonthebackofthesleevesideconnectorhalfinthe

directionshown.Asthetwoconnectprhalvesarepressedtogether,thesleeve(A)ispushedbackbythepawl(C).

Donottouchthesleeve.

2. Whentheconnectorhalvesarecompletelyconnected,thepawlisreleased,andthespringloadedsleevelocksthe

connector.

AirbagConnector(II)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

5/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

Connec ting

Holdbothconnectorhalvesandpressfirmlyuntiltheprojection(C)ofthesleevesideconnectorclickstolock.

WA RNINGLAMPACTIVATION

1. Activefaultorhistoricalfaultcounterisgreaterorequalto10

2. Normalorhistoricalfaultcounterislessthan10

3. LossofbatterysupplytotheSRSCM:warninglampturnedoncontinuously.

4. Lossofinternaloperatingvoltage:warninglampturnedoncontinuously.

5. LossofSRSCMoperation:warninglampturnedoncontinuously.

6. SRSCMnotconnected:warninglampturnedoncontinuouslythroughtheshortingbar.

7. ResetbytheWatchdogTriggerfailure:warninglampflashedorturnedoncontinuously.

TELLTALELAMPACTIVATION

DE SCRIPTION

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

6/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

TheTelltaleLampindicatesthePassengerAirbag(PAB)enabledisablestatusbasedonoccupantstatusofpassenger

seat.Ifthepassengerseatisoccupiedwithchild(orchildseat),thePassengerAirbagisdisabledandtheTelltale

LampisturnedONtoinformthedriverthatthePABisdisabled.

AssoonasoperatingvoltageisappliedtotheSRSCMignitioninput,theSRSCMactivatestelltalelampproveout.

OCSwillsendanindeterminatestatustotheSRSCMasadefaultsettingforpassengerairbagdeploymentduringthe

proveoutperiod.AftercrashifOCSgetsresetandsendstheindeterminatestatus,thetelltalelampwillbeONaslong

astheoccupantstatusisintheindeterminatestatus.Occupantstatusinformationandtelltaleststusareasbelow

table.

OccupantStatus TelltaleStatusIndicator PassengerAirbag

Empty(buckled) ON Disable

Empty*unbuckled) OFF Disable

Small ON Disable

Large OFF Available

Indeterminate ON Disable

Afterignitionon,telltalelampwillturnonfor4secondsandturnofffor3secondsduringtheinitializationphaseandbe

turnedoffafterwarduntilreceivefirstvalidsuppressionmessagefromOCSsystem.

Restraint>GeneralInformation>GeneralInformation

Description

Thesupplementalrestraintsystem(SRS)isdesignedtosupplementtheseatbelttohelpreducetheriskorseverityof

injurytothedriverandpassengerbyactivatinganddeployingthedriver,passenger,sideairbagandbeltpretensioner

incertainfrontalorsidecollisions.

TheSRS(Airbag)consistsof:adriversideairbagmodulelocatedinthecenterofthesteeringwheel,whichcontains

thefoldedcushionandaninflatorunit;apassengersideairbagmodulelocatedinthepassengersidecrashpad

containsthefoldedcushionassembledwithinflatorunit;sideairbagmoduleslocatedinthedriverandpassengerseat

containthefoldedcushionandaninflatorunit;curtainairbagmoduleslocatedinsideoftheheadlinerwhichcontains

foldedcushionsandinflatorunits.ThePassengerOccupantclassificationSystem(OCS)utilizesbladderplaced

betweenthepassengerseatcushionandsuspensiontomeasuretheoccupant’sloadingforceonthevehicleseat.Seat

TrackPositionSensor(STPS)locatedindriverandpassengerseatinterfaceswithSRSCMandwillhelpindetermining

whethertosuppresseitherstageofamultistageairbagsystem.SRSCMislocatedunderthecenterconsole.The

impactsensingfunctionoftheSRSCMiscarriedoutbyelectronicaccelerometerthatcontinuouslymeasurethe

vehicle'saccelerationanddeliversacorrespondingsignalthroughamplifyingandfilteringcircuitrytothe

microprocessor.

SRSCM(SRS ControlModule)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

7/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

SRSCMwilldetectfrontimpactwithfrontimpactsensor,andsideimpactwithsideimpactsensor,anddetermine

airbagmoduledeployment.

1. DC/DCconverter:DC/DCconverterinpowersupplyunitincludesup/downtransformerconverter,andprovideignition

voltagefor2frontairbagignitioncircuitsandtheinternaloperationvoltageoftheSRSCM.Iftheinternaloperation

voltageisbelowcriticalvaluesetting,itwillperformresetting.

2. Safetysensor:Safetysensorislocatedinairbagignitioncircuit.Safetysensorwilloperateairbagcircuitatany

deploymentconditionandreleaseairbagcircuitsafelyatnormaldrivingcondition.Safetysensorisadoublecontact

electromechanicalswitchthatwillclosedetectingdecelerationabovecertaincriteria.

3. Backuppowersupply:SRSCMhasseparatebackuppowersupply,thatwillsupplydeploymentenergyinstantlyin

lowvoltageconditionoruponpowerfailurebyfrontcrash.

4. Selfdiagnosis:SRSCMwillconstantlymonitorcurrentSRSoperationstatusanddetectsystemfailurewhilevehicle

powersupplyison,systemfailuremaybecheckedwithtroublecodesusingscantool.(HiScan)

5. Airbagwarninglampon:Upondetectingerror,themodulewilltransmitsignaltoSRSCMindicatorlamplocatedat

cluster.MILlampwillindicatedriverSRSerror.Uponignitionkeyon,SRSlampwillturnonforaboutsixseconds.

6. Troublecoderegistration:Uponerroroccurrenceinsystem,SRSCMwillstoreDTCcorrespondingtotheerror.DTC

canbeclearedonlybyHiScan.However,ifaninternalfaultcodeisloggedorifacrashisrecordedthefaultclearing

shouldnothappen.

7. Selfdiagnosticconnector:DatastoredinSRSCMmemorywillbeoutputtoHiScanorotherexternaloutputdevices

throughconnectorlocatedbelowdriversidecrashpad.

8. Onceairbagisdeployed,SRSCMshouldnotbeusedagainbutreplaced.

9. SRSCMwilldeterminewhetherpassengerputonseatbeltbythesignalfrombuiltinswitchinseatbeltbuckle,and

deployfrontseatairbagateachsetcrashspeed.

10. SideairbagdeploymentwillbedeterminedbySRSCMthatwilldetectsatellitesensorimpactsignaluponside

crash,irrespectivetoseatbeltcondition.

Restraint>GeneralInformation>SpecialServiceTools

SPECIALSERVICETOOLS

Tool(NumberandName) Illustration Use

Deploymenttool

0957A34100A

Airbagdeploymenttool

Deploymentadapter

0957A38510

Usewithdeploymenttool.(DAB,PAB)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

8/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

Deploymentadapter

0957A38100

Usewithdeploymenttool.(SAB)

Deploymentadapter

0957A38500

Usewithdeploymenttool.(CAB,BPT)

Dummy

0957A38200

Simulatortochecktheresistanceof

eachwiringharness

Dummyadapter

0957A38300

Usewithdummy(SAB)

Dummyadapter

0957A2G000

Usewithdummy

(DAB,PAB,CAB,BPT)

DAB:DriverAirbag

PAB:PassengerAirbag

SAB:SideAirbag

CAB:CurtainAirbag

BPT:BeltPretensioner

Restraint>GeneralInformation>ComponentsandComponentsL ocation

airbagsystem

components

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

9/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

COMPONENTSLOCATION

DRIVER AIRBAG(DAB)/PA SSENGERAIRBAG(PAB)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

10/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

SIDEAIRBAG(SAB)

FRONTIMPACTSEN SOR(FIS)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

11/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

SEAT BELTPRETE NSIONER(BPT)/SIDEIMPACTSENSOR(SIS)

SRSCM

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

12/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

Restraint>GeneralInformation>Specifications

SPECIFICATION

ITEM SPECIFICATION

DriverAirbag(DAB) Resistance(Ω) 1.5~5.7Ω

PassengerAirbag(PAB) Resistance(Ω) 1.5~5.7Ω

SideAirbag(SAB) Resistance(Ω) 1.5~5.7Ω

CurtainAirbag(CAB) Resistance(Ω) 1.5~5.7Ω

SeatBeltPretensioner(BPT) Resistance(Ω) 1.5~5.7Ω

TIGHTENINGTORQUES

ITEM kgf.m N.m lb. ft

DriverAirbag(DAB) 0.8~1.1 7.8~10.8 5.8~8.0

PassengerAirbag(PAB) 1.9~2.7 18.6~26.5 13.7~19.5

SideAirbag(SAB) 0.6~1 5.9~9.8 4.3~7.2

CurtainAirbag(CAB) 0.7~0.9 6.9~8.8 5.1~6.5

SeatBeltLowerAnchorbolt(BPT) 4.0~5.5 39~54 29~40

SRSCMMountingBolt 0.7~0.9 6.9~8.8 5.1~6.5

FrontImpactSensor(FIS)MountingBolt 0.9~1.1 8.8~10.8 6.5~8.0

SideImpactSensor(SIS)MountingBolt 0.9~1.1 8.8~10.8 6.5~8.0

Restraint>SupplementalRestraintSystemControlModule(SRSCM)>Schematic

Diagrams

SYSTEMBLOCKDIAGRAM

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

13/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

CIRCUITDIAGRAM(1)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

14/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

CIRCUITDIAGRAM(2)

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

15/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

SRSCMCONNECTORTERMINAL

PIN Function PIN Function

1 ShortingBar 26 WarningLamp

2 ShortingBar 27 BatteryGround

3 BatterySupply(Vbat) 28 KLineDiagnostic

4 SeatBeltPretensioner[FrontDriver]Low 29 SeatBeltPretensioner[FrontPassenger]Low

5 SeatBeltPretensioner[FrontDriver]High 30 SeatBeltPretensioner[FrontPassenger]High

6 (2ndStage)PassengerAirbagHigh 31 BuckleSwitch[FrontPassenger]High

7 (2ndStage)PassengerAirbagLow 32 BuckleSwitch[FrontPassenger]Low

8 (2ndStage)DriverAirbagLow 33 BuckleSwitch[Driver]Low

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

16/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

9 (2ndStage)DriverAirbagHigh 34 BuckleSwitch[Driver]High

10 CurtainAirbag[Passenger]High 35 SeatTrackPositionSensor[Passenger]High

11 CurtainAirbag[Passenger]Low 36 SeatTrackPositionSensor[Passenger]Low

12 CurtainAirbag[Driver]Low 37 SeatTrackPositionSensor[Driver]Low

13 CurtainAirbag[Driver]High 38 SeatTrackPositionSensor[Driver]High

14 SideAirbag[FrontPassenger]High 39 SideImpactSensor[Passenger]High

15 SideAirbag[FrontPassenger]Low 40 SideImpactSensor[Passenger]Low

16 SideAirbag[FrontDriver]Low 41 SideImpactSensor[Driver]Low

17 SideAirbag[FrontDriver]High 42 SideImpactSensor[Driver]High

18  43

OccupantClassification(OC)SensorCAN

Low

19  44

OccupantClassification(OC)SensorCAN

High

20  45 FrontImpactSensor[Passenger]High

21  46 FrontImpactSensor[Passenger]Low

22 (1stStage)PassengerAirbagHigh 47 FrontImpactSensor[Driver]Low

23 (1stStage)PassengerAirbagLow 48 FrontImpactSensor[Driver]High

24 (1stStage)DriverAirbagLow 49 CrashOutput

25 (1stStage)DriverAirbagHigh 50 TelltaleWarningLamp

Restraint>SupplementalRestraintSystemControlModule(SRSCM)>Troubleshooting

HiScancheck

1. Turntheignitionswitchoff.

2. ConnecttheHiScanProconnectortothedatalinkconnectorlocatedunderthecrashpad.

3. ConnecttheHiScanPropowercable.

4. TurntheignitionswitchonandpowerontheHiScanPro.

5. ReadDTCs.

6. Findandrepairthetrouble,andcleartheDTCsusingHiScanPro.

7. DisconnecttheHiScanPro.

DIAGNOSTICTROUBLESHOOTINGFLOW

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

17/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

DIAGNOSTICTROUBLECODES(DTC)

CODE FAULTDESCRIPTION

B1101 BatteryVoltagetooHigh

B1102 BatteryVoltagetooLow

B1326 FrontImpactSensor[Driver]ShorttoGround

B1327 FrontImpactSensor[Driver]ShorttoBattery

B1328 FrontImpactSensor[Driver]Defect

B1329 FrontImpactSensor[Driver]CommunicationError

B1330 FrontImpactSensor[Driver]WrongID

B1331 FrontImpactSensor[Passenger]ShorttoGround

B1332 FrontImpactSensor[Passenger]ShorttoBattery

B1333 FrontImpactSensor[Passenger]Defect

B1334 FrontImpactSensor[Passenger]CommunicationError

B1335 FrontImpactSensor[Passenger]WrongID

B1346 (1stStage)DriverAirbagResistanceTooHigh

B1347 (1stStage)DriverAirbagResistanceTooLow

B1348 (1stStage)DriverAirbagCircuitShorttoGround

B1349 (1stStage)DriverAirbagCircuitShorttoBattery

B1352 (1stStage)PassengerAirbagResistanceTooHigh

B1353 (1stStage)PassengerAirbagResistanceTooLow

B1354 (1stStage)PassengerAirbagCircuitShorttoGround

B1355 (1stStage)PassengerAirbagCircuitShorttoBattery

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

18/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

B1361 SeatBeltPretensioner[FrontDriver]ResistanceTooHigh

B1362 SeatBeltPretensioner[FrontDriver]ResistanceTooLow

B1363 SeatBeltPretensioner[FrontDriver]CircuitShorttoGround

B1364 SeatBeltPretensioner[FrontDriver]CircuitShorttoBattery

B1367 SeatBeltPretensioner[FrontPassenger]ResistanceTooHigh

B1368 SeatBeltPretensioner[FrontPassenger]ResistanceTooLow

B1369 SeatBeltPretensioner[FrontPassenger]CircuitShorttoGround

B1370 SeatBeltPretensioner[FrontPassenger]CircuitShorttoBattery

B1378 SideAirbag[FrontDriver]ResistanceTooHigh

B1379 SideAirbag[FrontDriver]ResistanceTooLow

B1380 SideAirbag[FrontDriver]CircuitShorttoGround

B1381 SideAirbag[FrontDriver]CircuitShorttoBattery

B1382 SideAirbag[FrontPassenger]ResistanceTooHigh

B1383 SideAirbag[FrontPassenger]ResistanceTooLow

B1384 SideAirbag[FrontPassenger]CircuitShorttoGround

B1385 SideAirbag[FrontPassenger]CircuitShorttoBattery

B1396 SeatTrackPositionSensor[Driver]OpenorShorttoGround

B1397 SeatTrackPositionSensor[Driver]ShortorShorttoBattery

B1398 SeatTrackPositionSensor[Passenger]OpenorShorttoGround

B1399 SeatTrackPositionSensor[Passenger]ShortorShorttoBattery

B1400 SideImpactSensor[FrontDriver]Defect

B1401 SideImpactSensor[FrontDriver]ShorttoGround

B1402 SideImpactSensor[FrontDriver]ShorttoBattery

B1403 SideImpactSensor[FrontPassenger]Defect

B1404 SideImpactSensor[FrontPassenger]ShorttoGround

B1405 SideImpactSensor[FrontPassenger]ShorttoBattery

B1409 SideImpactSensor[FrontDriver]CommunicationError

B1410 SideImpactSensor[FrontPassenger]CommunicationError

B1414 SideImpactSensor[FrontDriver]WrongID

B1415 SideImpactSensor[FrontPassenger]WrongID

B1473 SideCurtainAirbag[Driver]ResistanceTooHigh

B1474 SideCurtainAirbag[Driver]ResistanceTooLow

B1475 SideCurtainAirbag[Driver]CircuitShorttoGround

B1476 SideCurtainAirbag[Driver]CircuitShorttoBattery

B1477 SideCurtainAirbag[Passenger]ResistanceTooHigh

B1478 SideCurtainAirbag[Passenger]ResistanceTooLow

B1479 SideCurtainAirbag[Passenger]CircuitShorttoGround

B1480 SideCurtainAirbag[Passenger]CircuitShorttoBattery

B1481 (2ndStage)DriverAirbagResistanceTooHigh

B1482 (2ndStage)DriverAirbagResistanceTooLow

B1483 (2ndStage)DriverAirbagCircuitShorttoGround

B1484 (2ndStage)DriverAirbagCircuitShorttoBattery

B1485 (2ndStage)PassengerAirbagResistanceTooHigh

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

19/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

B1486 (2ndStage)PassengerAirbagResistanceTooLow

B1487 (2ndStage)PassengerAirbagCircuitShorttoGround

B1488 (2ndStage)PassengerAirbagCircuitShorttoBattery

B1489 PassengerOccupantClassification(OC)ECUfailure

B1490 PassengerOccupantClassification(OC)Sensor(Bladder)failure

B1493 PassengerOccupantClassification(OC)CommunicationError

B1494 PassengerOccupantClassification(OC)WrongID

B1495 BeltTensionSensorfailure

B1521 SeatBeltBuckleSwitch[Driver]ShortorShorttoBattery

B1522 SeatBeltBuckleSwitch[Driver]OpenorShorttoGround

B1523 SeatBeltBuckleSwitch[FrontPassenger]ShortorShorttoBattery

B1524 SeatBeltBuckleSwitch[FrontPassenger]OpenorShorttoGround

B1620 AirbagcontrolunitInternalFault(Replaceairbagcontrolunit)

B1650 CrashRecoredin1stStageonly(FrontalReplaceairbagcontrolunit)

B1651 CrashRecordedDriverSide(Replaceairbagcontrolunit)

B1652 CrashRecordedPassengerSide(Replaceairbagcontrolunit)

B1657 CrashRecordedBeltPretensionerOnly

B1658 BeltPretensioner6timesDeployment(Replaceairbagcontrolunit)

B1670 CrashRecordedinFullStage(FrontalReplaceairbagcontrolunit)

B2500 WarningLampFault

B2502 TelltaleLampFault

Restraint>SupplementalRestraintSystemControlModule(SRSCM)>SRSControl

Module(SRSCM)>DescriptionandOperation

DESCRIPTION

TheprimarypurposeoftheadvancedSRSCM(SupplementalRestraintsSystemControlModule)istodiscriminate

betweenaneventthatwarrantsrestraintsystemdeploymentandaneventthatdoesnot.TheadvancedSRSCMmust

decideifandwhentodeploytherestraintsystempretensionersandairbags.Afterdeterminingthatpretensionersand/or

airbagdeploymentisrequired,theadvancedSRSCMmustsupplysufficientpowertothepretensionersandairbag

igniterstoinitiatedeployment.TheadvancedSRSCMdeterminesthatanimpactmayrequiredeploymentofthe

pretensionersandairbagsfromdataobtainedfrombuckleswitches,seattrackpositionsensors,occupantclassification

system,frontimpactsensorsandsideimpactsensorsinconjunctionwithasafingfunction.

TheadvancedSRSCMwillnotbereadytodetectacrashortoactivatetherestraintsystemdevicesuntilthesignalsin

theadvancedSRSCMcircuitrystabilize.ItispossiblethattheadvancedSRSCMcouldactivatethesafetyrestraint

devicesinapproximately2secondsbutisguaranteedtofullyfunctionafterproveoutiscompleted.Theadvanced

SRSCMmustperformadiagnosticroutineandlightasystemreadinessindicatoratkeyon.Thesystemmustperform

acontinuousdiagnosticroutineandprovidefaultannunciationthroughawarninglampindicatorintheeventoffault

detection.Aserialdiagnosticcommunicationinterfacewillbeusedtofacilitateservicingoftheadvancedrestraint

controlsystem.

Restraint>SupplementalRestraintSystemControlModule(SRSCM)>SRSControl

Module(SRSCM)>Repairprocedures

REMOVAL

1. Disconnectthenegative()cablefrombatteryandwaitforatleastthreeminutes.

7/6/12 https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

20/227https://www.kiatechinfo.com/viewer/toc_print.asp?vehicletype=Passenger&mfrcode=KM&area=KM…

2. Removeignitionkeyfromthevehicle.

3. DisconnecttheDAB,PAB,SAB,CABandBPTconnectors.

4. Removethecenterconsole(RefertoBDgroupintheServiceManual).

5. DisconnecttheSRSCMharnessconnector(A)fromtheSRSCM(B).

6. RemovetheSRSCMmountingboltsfromtheSRSCMthenremovetheSRSCM.

INSTALLATION

1. Disconnectthenegative()cablefrombatteryandwaitforatleastthreeminutes.

2. Removeignitionkeyfromthevehicle.

3. InstalltheSRSCMwiththeSRSCMmountingbolts.

TighteningTorque(SRSCMMountingBolt)

:6.9~8.8N·m(5.1~6.5lb·ft)

4. ConnecttheSRSCMharnessconnector.

5. Installthecenterconsole.

6. ConnecttheDAB,PAB,SAB,CABandBPTconnectors.

7. AfterinstallingtheSRSCM,confirmpropersystemoperation:

A. TurntheignitionswitchON;theSRSindicatorlightshouldbeturnedonforaboutsixsecondsandthengooff.

Restraint>SupplementalRestraintSystemControlModule(SRSCM)>FrontImpact

Sensor(FIS)>DescriptionandOperation

DESCRIPTION

ThereleasesystemforthefrontairbagconsistsofaSRSCMinstalledinthemiddleofthevehicleandtwofrontimpact

sensors(FIS)whicharelocatedinfrontofthevehicle.OnlytheSRSCMiscapableofreleasingtheairbagsortheseat

beltpretensionersysteminthevehicle.InthedialogbetweentheSRSCMandthefrontimpactsensoritistheSRSCM

whichtakesthereleasedecision.

KIA Sportage 2008 User manual

Related papers

Other documents