Harrie Leenders Signa Installation Instructions User Instructions

Brand: Harrie Leenders

Model: Signa

Category: Stoves

Type: Installation Instructions User Instructions

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

1

INSTRUCTIONSFORINSTALLATION,

USEANDMAINTENANCE

FUGA eL

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

3

Generalinstructionsandregulations

Maintenance………………………………………………………….. 5

Service………………………………………………………………… 5

Declaration……………………………………………………………. 5

Characteristicsreport………………………………………………... 5

DescriptionoftheFugaeL………………………………………...… 5

HETASsupplement

HealthandSafetyprecautions…………..…………………………. 6

Chimney……………………………………………………………….. 7

Hearth…………………………………………………………………. 8

Combustionairsupply……………………………………………….. 8

Connectiontochimney…………………………………………….... 8

Commissioningandhandover……………………………………… 8

Manual

WhatyoushouldknowabouttheFugaeL………………………… 9

Thethreebasicrulesforproperburning………………………….. 9

Warningnote…………………………………………………………. 10

Importantnotes………………………………………………………. 10

Useroperatinginstructions…………………………………………. 11

Thefineheatfromwood…………………………………………….. 12

Initialfireup,agoodstart…………………………………………… 12

Initialfireupinsteps…………………………………………………. 13

HowtousetheFugaeL…………………………………………..… 14

Thepoweroffire……………………………………………………… 15

Afewtips……………………………………………………………… 15

Maintenance

Ceramicfirebricks……………………………………………………. 16

Glass………………………………………………………………….. 16

Movingparts………………………………………………………….. 16

Collectingsootwhensweepingthechimney……………………… 17

Installationinstructions

FugaeLspecifications……………………………………..………… 18

Generalinstructionsandregulations………………………………. 19

Safetyrecommendations……………………………………………. 19

Materialsandtoolsrequired………………………………………… 19

Installationdiagrams………………………………………………… 20/21

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

4

1. Flue

2. Case

3. Ceramicglass

4. Aerationslide

5. Convectionfins

6. Doorhandle

7. Base

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

5

Generalinstructionsandregulations

Maintenance

Havetheapplianceservicedregularlybyaqualifiedtechnician.

Ensurethatthefluegasconnectionandthechimneyarecleanedregularly.

Checktoensurethatthechimneyisstillopenbeforelightingthestoveagainifithasnotbeen

usedforanextendedperiodoftime.

If,inspiteoftheprecautionstaken,thereshouldoccurachimneyfire(usually

accompaniedbyaroaringnoiseinthechimney),proceedasfollows:

Shutofftheairsupplyandclosethedoorofthestoveimmediately

Callthefirebrigade

Quicklyextinguishthefireinthestovewithsandtopreventsmokefromgettingintoyourhouse

Ventilatethehouse

Neverusewatertoextinguishthefire

Ensurethatafterafirethechimneyisfirstsweptandinspectedforanydamageandleaks.

Service

Itisnotallowedtomakeanymodificationstotheappliancewithoutpriorauthorizationofthe

manufacturer.

Onlyusereplacementpartsrecommendedbythemanufacturer.

Declaration

Theundersigned,representingthefollowing:

HarrieLeendersHaardkachels,Industrieweg25,5688DP,Oirschot,Nederland

herewithdeclarethattheproductFugaeLisinconformitywiththeprovisionsofthefollowingEC

Directiveswheninstalledinaccordancewiththeinstallationinstructionscontainedintheproduct

documentation:EN13240:2001/A2:2004(E)"Roomheatersfiredbysolidfuel"

Product:Roomheatersfiredbysolidfuelsascoveredunderthescopeofthisstandardintended

use:Spaceheatinginresidentialbuildings.

CharacteristicsReport

Firesafety 2005PMC/12

Emissionofcombustionproducts 2005PMC/12

Releaseofdangeroussubstance 2005PMC/12

Surfacetemperature 2005PMC/12

Mechanicalresistance(tocarryachimney/flue) 2005PMC/12

Thermaloutput/energyefficiency 2005PMC/12

DescriptionoftheroomheaterFugaeL:

Woodstovemadeofsheetmetal.Thestoveisdesignedtobeinstalledonthewall.Itisprovided

withaselfclosingwindowdoor,fixedsecondaryairsupplyandcontrollableairwashair

supply.Thecombustionchamberisinsulatedwithrefractoryceramicelements.Thefluegas

connectionislocatedatthetopoftheappliance.

Notifiedbody: SGSEnvironmentalServices,Postbus5252,6802EGArnhem

Reportnumber: 2005PMC/12

Manufacturer: HarrieLeendersHaardkachels

Name:BartLeenders

Position:GeneralManager

Date:15072005

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

6

READTHEINSTRUCTIONBOOKLETANDTHESESUPPLEMENTARY

INSTRUCTIONSCAREFULLYBEFOREINSTALLATION

Theseinstructionstogetherwiththoseintheinstructionbookletcoverthebasicprinciples

toensurethesatisfactoryinstallationofthestove,althoughdetailmayneedslight

modificationtosuitparticularlocalsiteconditions.

InallcasestheinstallationmustcomplywithcurrentBuildingRegulations,LocalAuthority

Byelawsandotherspecificationsorregulationsastheyaffecttheinstallationofthestove.

ItshouldbenotedthattheBuildingRegulationsrequirementsmaybemetbyadoptingthe

relevantrecommendationsgiveninBritishStandardsBS8303,BSEN152871:2007asan

alternativemeanstoachieveanequivalentlevelofperformancetothatobtainedfollowing

theguidancegiveninApprovedDocumentJ.

PleasenotethatitisalegalrequirementunderEnglandandWalesBuildingRegulations

thattheinstallationofthestoveiseithercarriedoutunderLocalAuthorityBuilding

ControlapprovalorisinstalledbyaCompetentPersonregisteredwithaGovernment

approvedCompetentPersonsScheme.HETASLtdoperatesuchaSchemeandalistingof

theirRegisteredCompetentPersonscanbefoundontheirwebsiteatwww.hetas.co.uk.

COAlarms:

Buildingregulationsrequirethatwheneveraneworreplacementfixedsolidfuelorwood/

biomassapplianceisinstalledinadwellingacarbonmonoxidealarmmustbefittedinthe

sameroomastheappliance.Furtherguidanceontheinstallationofthecarbonmonoxide

alarmisavailableinBSEN50292:2002andfromthealarmmanufacturer’sinstructions.

Provisionofanalarmmustnotbeconsideredasubstituteforeitherinstallingthe

appliancecorrectlyorensuringregularservicingandmaintenanceoftheapplianceand

chimneysystem.

HEALTHANDSAFETYPRECAUTIONS

SpecialcaremustbetakenwheninstallingthestovesuchthattherequirementsoftheHealthandSafetyat

WorkActaremet.

Handling

Adequatefacilitiesmustbeavailableforloading,unloadingandsitehandling.

FireCement

Sometypesoffirecementarecausticandshouldnotbeallowedtocomeintocontactwiththeskin.In

caseofcontactwashimmediatelywithplentyofwater.

Asbestos

Thisstovecontainsnoasbestos.Ifthereisapossibilityofdisturbinganyasbestosinthecourseofinstalla

tionthenpleaseseekspecialistguidanceanduseappropriateprotectiveequipment.

MetalParts

Wheninstallingorservicingthisstovecareshouldbetakentoavoidthepossibilityofpersonalinjury.

STOVEPERFORMANCE

Pleaserefertothetableinthemaininstructionmanualfordetailsofthestoves’performances

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

7

PREPARATORYWORKANDSAFETYCHECKS

IMPORTANTWARNING

Thisstovemustnotbeinstalledintoachimneythatservesanyotherheatingappliance.

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscancausethestovetoemit

fumesintotheroom.

Chimney

Inorderforthestovetoperformsatisfactorilythechimneyheightmustbesufficienttoensureanadequate

draughtofapproximately15Pasoastocleartheproductsofcombustionandpreventsmokeproblemsinto

theroom.

NOTE:Achimneyheightofnotlessthan4.5metresmeasuredverticallyfromtheoutletofthestovetothe

topofthechimneyshouldbesatisfactory.AlternativelythecalculationproceduregiveninEN133841may

beusedasthebasisfordecidingwhetheraparticularchimneydesignwillprovidesufficientdraught.

Theoutletfromthechimneyshouldbeabovetheroofofthebuildinginaccordancewiththeprovisionsof

BuildingRegulationsApprovedDocumentJ.

Ifinstallationisintoanexistingchimneythenitmustbesoundandhavenocracksorotherfaultswhich

mightallowfumesintothehouse.Olderproperties,especially,mayhavechimneyfaultsorthecrosssec

tionmaybetoolargei.e.morethan230mmx230mm.Remedialactionshouldbetaken,ifrequired,seek

ingexpertadvice,ifnecessary.Ifitisfoundnecessarytolinethechimneythenafluelinersuitableforsolid

fuelmustbeusedinaccordancewithBuildingRegulationsApprovedDocumentJ.

Anyexistingchimneymustbeclearofobstructionandhavebeensweptcleanimmediatelybeforeinstalla

tionofthestove.Ifthestoveisfittedinplaceofanopenfirethenthechimneyshouldbesweptonemonth

afterinstallationtoclearanysootfallswhichmayhaveoccurredduetothedifferenceincombustionbe

tweenthestoveandtheopenfire.

Ifthereisnoexistingchimneythenanynewsystemmustbetothedesignationdescribedaboveandinac

cordancewithBuildingRegulationsApprovedDocumentJ.

Asinglewallmetalfluepipeissuitableforconnectingthestovetothechimneybutisnotsuitableforuseas

thecompletechimney.Thechimneyandconnectingfluepipemusthaveaminimumdiameterof150mm

anditsdimensionshouldbenotlessthanthesizeoftheoutletsocketofthestove.

Anybendinthechimneyorconnectingfluepipeshouldnotexceed45°.90°bendsshouldnotbeused.

Combustiblematerialshouldnotbelocatedwheretheheatdissipatingthroughthewallsoffireplacesor

fluescouldigniteit.Thereforewheninstallingthestoveinthepresenceofcombustiblematerialsdueac

countmustbetakenoftheguidanceontheseparationofcombustiblematerialgiveninBuildingRegula

tionsApprovedDocumentJandalsointhesestoveinstructions.

Ifitisfoundthatthereisexcessivedraughtinthechimneythenadraughtstabilisershouldbefitted.Fitting

ofadraughtstabiliserwillaffecttherequirementforthepermanentairsupplyintotheroominwhichthe

stoveisfittedinaccordancewithApprovedDocumentJ(seealsocombustionairsupply).

Adequateprovisione.g.easilyaccessiblesootdoorordoorsmustbeprovidedforsweepingthechimney

andconnectingfluepipewhereitisnotintendedforthechimneytobesweptthroughtheappliance.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

8

Hearth

Thehearthshouldbeabletoaccommodatetheweightofthestoveanditschimneyifthechimneyisnot

independentlysupported.Theweightofthestoveisindicatedinthebrochure.

Thestoveshouldpreferablybeinstalledonanoncombustiblehearthofasizeandconstructionthatisin

accordancewiththeprovisionsofthecurrentBuildingRegulationsApprovedDocumentJ.

Theclearancedistancestocombustiblematerialbeneath,surroundingoruponthehearthandwallsadja

centtothehearthshouldcomplywiththeguidanceontheseparationofcombustiblematerialgivenin

BuildingRegulationsApprovedDocumentJandalsointhesestoveinstructions.

Ifthestoveistobeinstalledonacombustiblefloorsurface,itmustbecoveredwithanoncombustiblema

terialatleast12mmthick,inaccordancewithBuildingRegulationsApprovedDocumentJ,toadistanceof

30cminfrontofthestoveand15cmtoeachsidemeasuringfromthedoorofthecombustionchamber.

Combustionairsupply

Inorderforthestovetoperformefficientlyandsafelytheremustbeanadequateairsupplyintotheroomin

whichthestoveisinstalledtoprovidecombustionair.Theprovisionofairsupplytothestovemustbein

accordancewithcurrentBuildingRegulationsApprovedDocumentJ.Anopeningwindowisnotappropriate

forthispurpose.

Connectiontochimney

Stovesmayhaveachoiceofeitherarearortopfluegasconnectorthatallowsconnectiontoeitherama

sonrychimneyoraprefabricatedfactorymadeinsulatedmetalchimneyinaccordancewiththeirinstruc

tions.Insomecasesitmaybenecessarytofitanadaptortoincreasethediameterofthefluetothemini

mumrequired150mmsectionofthechimneyorliner.

Commissioningandhandover

Ensureallpartsarefittedinaccordancewiththeinstructions.

Oncompletionoftheinstallationallowasuitableperiodoftimeforanyfirecementandmortartodryout,

beforelightingthestove.Oncethestoveisunderfirecheckallsealsforsoundnessandcheckthattheflue

isfunctioningcorrectlyandthatallproductsofcombustionareventedsafelytoatmosphereviathechimney

terminal.

Oncompletionoftheinstallationandcommissioningensurethattheoperatinginstructionsforthestoveare

leftwiththecustomer.Ensuretoadvisethecustomeronthecorrectuseoftheapplianceandwarnthemto

useonlytherecommendedfuelforthestove.

Advisetheuserwhattodoshouldsmokeorfumesbeemittedfromthestove.Thecustomershouldbe

warnedtouseafireguardtoBS8423:2002(ReplacesBS6539)inthepresenceofchildren,agedand/or

infirmpersons.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

9

Manual

We congratulate you on the purchase of your stove. This manual will inform you about

the best way of using the stove and the artof keeping a perfect fire. Before using the

stove,carefullyreadthetextaboutbreakinginthestove.

TheseheatinginstructionsapplytotheFugaeL.Theyaremerelyintendedasaguideline

asyourstovewillbehavedifferentlyaccordingtotheplacewhereitisinstalled,simply

becausetheconditionsaredifferent.Theflue,theweather,thequalityofthewoodused

andtheclimateconditionsinthehousedetermineyourstove'sburningbehaviour.Intime

youwilldevelopyourowndirectionsforuse,basedontheseheatinginstructions.

WhatyoushouldknowabouttheFugaeL

TheFugaeLisaradiantstovewithconvectionwhich,whenthestoveisburningproperly,

ensuresafineheatdistribution.

Theburningchamberislinedinsidewithhighgradeceramicfirebrickelements(prisolith).

Theaerationslideisopenedbypullingitoutwards(kindlingposition).

Youopenthedoorontherightsideofthestove.

Thethreebasicrulesforproperburningare:

1Usedryandcleanwood.

Thestoveissuitableforburningsocalled'stackablefuels':woodandbriquettes.We

assumeyouwillbeusingdryfuelsonly.So,thisalsoholdsforthekindlingpaperand

cardboard.Wetfuelcostsmoreenergy,leavesmoistureontheglassandsoilstheflue.

2Donottempertheburningprocessexcessively.

Allowthestovesufficienttimetowarmup(staywithitatthisstage)anddonottemper

thefiretooquickly.Bearthisruleinmind:youmustnottemperastoveuntilithas

warmedupproperly.

3Alwaysmakesurethereisenoughfreshair.

Inhousestoday,cracksandgapshaveoftenbeensealed.Openingasmallgrateor

cantileverwindowwillensuresufficientfreshair,providednofreshairsupplysystemis

used.

Themainthingwhenmakingthefireisthatboththeflueandthestovereachtheproper

temperature.

Eachtimeyouwanttoopenthestovewhenburning,theaircontrolslidemustbeopen

(completelypulledout)toensureproperairsupply.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

10

READTHEINSTRUCTIONBOOKANDTHESEINSTRUCTIONSCAREFULLY

BEFOREUSINGTHESTOVE

WARNINGNOTE

Properlyinstalled,operatedandmaintainedthisstovewillnotemitfumesintothedwelling.Occasionalfumes

fromde‑ashingandre‑fuellingmayoccur.However,persistentfumeemissionispotentiallydangerousand

mustnotbetolerated.Iffumeemissiondoespersist,thenthefollowingimmediateactionshouldbetaken:‑

(a) Opendoorsandwindowstoventilatetheroomandthenleavethepremises.

(b) Letthefiregoout.

(c) Checkforflueorchimneyblockageandcleanifrequired

(d) Donotattempttorelightthefireuntilthecauseofthefumeemissionhasbeenidentifiedandcorrected.

Ifnecessaryseekexpertadvice.

Themostcommoncauseoffumeemissionisfluewayorchimneyblockage.Foryourownsafetythese

mustbekeptcleanatalltimes.

IMPORTANTNOTES

General

Beforelightingthestovecheckwiththeinstallerthattheinstallationworkandcommissioningchecksde

scribedabovehavebeencarriedoutcorrectlyandthatthechimneyhasbeensweptclean,issoundand

freefromanyobstructions.Aspartofthestoves’commissioningandhandovertheinstallershouldhave

shownyouhowtooperatethestovecorrectly.

COAlarm

YourinstallershouldhavefittedaCOalarminthesameroomastheappliance.Ifthealarmsoundsunex

pectedly,followtheinstructionsgivenunder“WarningNote”above.

Useoffireguard

Whenusingthestoveinsituationswherechildren,agedand/orinfirmpersonsarepresentafireguardmust

beusedtopreventaccidentalcontactwiththestove.Thefireguardshouldbemanufacturedinaccordance

withBS8423:2002(ReplacesBS6539).

Chimneycleaning

Thechimneyshouldbesweptatleasttwiceayear.Itisimportantthattheflueconnectionandchimneyare

sweptpriortolightingupafteraprolongedshutdownperiod.

Ifthestoveisfittedinplaceofanopenfirethenthechimneywillrequiresweepingafteramonthofcontinuous

operation.Thisisaprecautiontoensurethatany“softer”depositsleftfromtheopenfireusagehavenotbeen

loosenedbythehigherfluetemperaturesgeneratedbytheclosedstove.

Insituationswhereitisnotpossibletosweepthroughthestovetheinstallerwillhaveprovidedalternative

means,suchasasootdoor.Aftersweepingthechimneythestoveflueoutletandthefluepipeconnecting

thestovetothechimneymustbecleanedwithafluebrush.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

11

PeriodsofProlongedNonUse

Ifthestoveistobeleftunusedforaprolongedperiodoftimethenitshouldbegivenathoroughcleanto

removeashandunburnedfuelresidues.Toenableagoodflowofairthroughtheappliancetoreducecon

densationandsubsequentdamage,leavetheaircontrolsfullyopen.

Extractorfan

Theremustnotbeanextractorfanfittedinthesameroomasthestoveasthiscancausethestovetoemit

smokeandfumesintotheroom.

Aerosolsprays

Donotuseanaerosolsprayonornearthestovewhenitisalight.

Useofoperatingtools

Alwaysusetheoperatingtoolsprovidedwhenhandlingpartslikelytobehotwhenthestoveisinuse.

ChimneyFires

Ifthechimneyisthoroughlyandregularlyswept,chimneyfiresshouldnotoccur.However,ifachimneyfire

doesoccurturnoffthestoveimmediatelyandisolatethemainselectricitysupply(ifapplicable),andtightly

closethedoorsofthestove.Thisshouldcausethechimneyfiretogoout.Ifthechimneyfiredoesnotgo

outwhentheaboveactionistakenthenthefirebrigadeshouldbecalledimmediately.Donotrelightthe

stoveuntilthechimneyandfluewayshavebeencleanedandexaminedbyaprofessional.

Permanentairvent

Thestoverequiresapermanentandadequateairsupplyinorderforittooperatesafelyandefficiently.

InaccordancewithcurrentBuildingRegulationstheinstallermayhavefittedapermanentairsupplyvent

intotheroominwhichthestoveisinstalledtoprovidecombustionair.Thisairventshouldnotunderany

circumstancesbeshutofforsealed.

USEROPERATINGINSTRUCTIONS

Recommendedfuels

Stovesmaybedesignedtoburndryseasonedwoodlogsand/orsolidmineralfuelasindicatedinthemain

stovemanuals.

HETASLtdApproval

HETASapprovalmaybelimitedtospecificfueltypesasdetailedinthemaininstructionmanuals.Approval

doesnotcovertheuseofotherfuelseitheraloneormixedwiththerecommendedfuel,nordoesitcover

instructionsfortheuseofotherfuels.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

12

Initialfireup,agoodstart

Youhavepurchasedabrandnewstove,'zeroonthemeter',hasnotseenaflameyet.

Thismeansyouaregoingtotakecareoftheinitial'miles'.Theceramicfirebrickswillstart

evaporatingmoistureandyourwoodburningstovewillstartsetting.Forthisreason,the

firstfewtimes,donotmakeyourfiretoohotbecauseotherwisethebrickscouldcrack.

Youneednotworryaboutanyshrinkagecracks.

Theinitialfireuprequiressomeadditionaltimeandattention,aswellastheapproachwe

haveoutlinedbelowforyouinsteps.Beforestarting,pleasenotethefollowingimportant

points:

Whenstartingthefireinthestove,opentheaerationslide.(Thisisthekindling

position.)

Youcanproperlycontrolthefirewiththeaerationslide.Thefurthertheslideis

opened,themorevigorouslyyourfirewillburn.

Makesurethereissufficientventilation.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

13

Initialfireupinsteps

1.Opentheairslidecompletelybypullingittowardsthefrontofthe

stove.Thisisthekindlingposition.

2.Lightalargeballofdrypaperagainstthebackplateoftheburning

chamberandallowthisfiretogooutagain.

4.Allowthefiretoburnupandthestovetocooloffforanhoursothat

themoistureinthefirebrickcanevaporate.Someliquidmightcome

freefromtheceramicfirebrick.Thereforeplaceanoldtowel

underneaththestovebeforefiringup

5.Afteranhour,youwillstartbringingtheentirestovetotheproper

temperatureusingfirstsomethinkindlingwood.

Usethekindlingpositionoftheairslideuntilthefireburns

properly.

6.Thenusethickerlogs,±5x5cmthickand20cmlong.Atthesame

time,leavetheaerationslideopen.Closeitalittlebitwhenthefireis

burningproperly.

3.Fillthestovewithahandfulofdryandthinkindlingwoodandlightit.

Whenitburnsproperly,closetheairslideabitbypushingit

inwards.

Stirupthefireoffandonbysettingthedoorajarforjustamoment

eachtime.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

14

HowtousetheFugaeL

1.Fullyopentheaircontrolslidebymovingittowardsthefrontofthe

stove.Thisisthekindlingposition.

3.Whenthestovehasbeenburningproperlyforawhile,addafew

moresolidlogs.(Firstopentheaerationslide.)

Stacklightly.Theamount(notmorethan3logs)dependsontheheat

required.

4.Aquietlyburningfireisobtainedbyclosingtheairslideevenmore

bypushingitinwards.ThiswillreducethedraughtintheFugaeL.For

aglowingmassofcharcoal,youmayclosetheairslideevenfurther.

Theheatwillthenlastlonger.Whenyouwanttoletthefirediedown,

youmustopentheairslidemore.

2.Place3fairlythicklogsonthebottomofthestove.Stacksomekin

dlingwoodontopofthem.Stacklightly.

Lightthekindlingwoodupinthestovewithafirelighterorsomepaper.

Allowsometimeforthestovetoheatupinordertoensureaproper

draughtandagoodfireunderthemoresolidlogstobeadded.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

15

Thepoweroffire

Asamatteroffactjustafewthingswithstandarealhotfire.Yourfireplacecanalsobe

damagedbyoverheating.

Justtopreventthis,takeaccountofnotburningmorethan3,5kilogramsofwoodatthe

sametime.3,5Kilogramsisapproximatelyequalto3,5largelogs;oakwith15%

moisture.Theconstructionandthematerialsusedfromthefireplacearechosento

controlandresistafireinaconsideredway.Soheatwithconsideration.

Afewtips

Makethefirealwaysonabedofash.Thisisaninsulatinglayerforthefireandan

excellentbedforthefuel.

IftheFugaeLisoverloadedwithtoomuchwoodandthemaximumamountofoxygenis

supplied(whichhappenswhentheairslideisfullyopen),thefiremay'runwild'.Ifthis

shouldoccur,closeairslidebypushingitinwards.Neverinsuchcaseleavethefireplace

unattended.

Youalsocontrolthetemperaturebytheamountandkindoffuelusedforeachload.

Removeexcessashesusingashoveloranashcleaner.Neverremoveashesusinga

vacuumcleanerbecausefiremaystillcontinuetosmoulderfordays.Makesureyou

leavealayerofashes(±3cm)forthenextfiretobemade.

Whentheweatherisfoggy,preheatthefluepriortolightingyourfire..

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

16

Maintenance

Glass

Theglasscansteamupwhenburningwetfuelortoolittleoxygenis

supplied.Also,theglassmaysteamupifthefiredoesnotstartfiercely

enough.Thishappens,forinstance,whenyoustartwithsmalllogs

insteadofthinkindlingwood.Moisturewillthenremaininthefireplace

fortoolong,andwillsettleonthecoldestpart:theglass.

Lightmoisture:

Usepapertowelandthenremovethelightmoistureusingadampcloth.

Counterpressurealittleattheoutsidesothattheglasspaneldoesnot

move.

Thickerdeposits:

Thesecanbetreatedwithspecialfireplaceglasscleaner(thiscanalso

bedonewithapieceofmoistpapertowelandwhiteash).Allowa

momentforthistohaveitseffect.Alwaysmakesurethattheseagents

donotcomeintocontactwiththepaintedsurfacesinordertoprevent

stainsfrombeingformed.

Movingparts

Movingandsqueakingpartscanbelubricatedusinggraphitegrease.

Askyoursupplierforadvice.

Maintenance

Dustthestoveusinganonfibrouscloth.

UsetheHarrieLeendersPolishertotouchupsmallspotsandgivethestoveitsshine

back.Askyousupplierforadvice.

Inox:Removestainswithasoftcloth.UseHarrieLeendersInoxCleaner.Note:Inox

cleanercandamagethepaintofthestove.Becareful.

Maintenanceceramicfirebricks

Youneednotworryaboutanycracksintheceramicfirebrickelements

aslongastheflamedoesnotcomeintodirectcontactwiththemetal

behindthem.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

17

Collectingsootwhensweepingthechimney

Therefractoryboardbaffleandsteelbafflemustberemovedsothat

thesootbeingremovedduringchimneysweepingwilllandatthe

bottomofthestove.

1.Slightlylifttheceramicbaffleandpullittowardsyou.Youcanthen

takeitouteasily.Thenliftthesteelbaffletoremoveit.

2.Placeanewspaperonthebottomofthestovetocollectthe

accumulatedsoot.Closethedoorandtheaircontrolslide.

Aftersweepingthechimney,removetheaccumulatedsootfromthe

stoveandputtherefractorybaffleandthesteelbafflebackintheir

respectivepositions.

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

18

Installationinstructions

· AlllocalregulationsincludingthosereferringtonationalandEuropeanstandards

mustbeobservedwheninstallingtheappliance.

· Ensurethereissufficientventilation/airsupplyintheroomfromwhichyourstove

getsthecombustionair.Thisistheroomwherethestoveisinstalledifyoudonot

useawallorstovebaseairsupplysystem.

· Thestoveisnotsuitableforasharedfluesystem.

· Ensureadequateaccessforcleaningtheappliance,thefluegasconnectionandthe

chimney.

· Wheninstallingthestove,takeintoaccounttheminimumdistancesfromthewallso

astoavoidanyfirerisk.Theminimumdistances(sizesincm)areshowninthe

figurebelow.

SpecificationsFugaeL

Nominalpowerofthestoveis8kW.

Fluegasmassflow=8.6g/s

Applianceweight=130kg

Minimumchimneydraught=8.0Pa

Fluegastemperaturedirectlyoverthestove=317°C

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

19

Generalinstructionsandregulations

TheinstallationoftheFugaeLwithdecorativecasingmustbecarriedoutbyaskilled

personemployedbyadealerrecognizedbyHarrieLeendersHaardkachels.

Thecasingpartsaresusceptibletoscratching.Handlethemgently.

Afterthestovehasbeenproperlyinstalled,burnsomekindlingwoodtocheckthe

draught.

PleaseNote,theFugaeLhasbeentestedbythemanufacturersona3mstraightflue.

Safetyrecommendations

Glasstendstobreakeasily,andbrokenglassisquitesharp.Thereforetakeadequate

safetyprecautions.

Forgeneralsafety,werefertoguidelinesorregulationsissuedbyarelevantofficialbody

Materialsandtoolsrequired

Crossheadscrewdriver

Flatheadscrewdriver

Boxspannerset

Hexagonalwrenchset

Materialsincluded

4S6plugs

4stuccoscrews

SetofmasonrybitsKnife

PlumblineSlidingpieces

4selftappingscrews03.5x9.5(+2spares)

SpiritlevelHandtruck

Singlewalledpipeandaccessories(connector)

HarrieLeendersFugaeLInstructionsforInstallation,UseandMaintenance

20

4.Replacethedoor

Carefullyhangthedoorbackonit’shinges.

Becarefulnottocauseanydamage.

2.Installingwallplateforstovewithrearoutlet

Determinethecentreofthewallplateat114cmabove

thefloor.

Fixthewallplatewithconnectionringusingplugsand

chipboardscrews.

Fillupgap,ifany,betweenwallandwallplateif

necessaryinordertoensurethewallplateisplumb.

Markoffthecentreofthestoveonthefloor(standard

distancefromwallis37cm).

3.Positioningthestove

Pushthestoveinthemarkedpositionusingthe

slidingpieces.Becarefulnottodamagethefloor.

Removetheslidingpieces.

Removethepackaging.

1.Movingthestove

Removethedoorandputitinasafeplace

Placestyrofoamorapackingcushionbetween

thestoveandthehandtruckforprotection.

Movethestovewithitsfrontrestingagainstthe

handtruck.

Removetheplasticwrappingafterpositioningthe

stove.

Page is loading ...

Harrie Leenders Signa Installation Instructions User Instructions

Brand: Harrie Leenders

Model: Signa

Category: Stoves

Type: Installation Instructions User Instructions

Download PDF

report

Harrie Leenders Signa Installation Instructions User Instructions

Harrie Leenders Signa Installation Instructions User Instructions

Related papers

Other documents