Concept OPO-5590 Operating instructions

Page is loading ...

EN

25

OPK4460, OPK4490, OPO5590

CONTENTS

Technical Parameters..............................1

Important notices.................................2

Product Description ...............................3

DescriptionoftheControlPanel....................4

Operating Instructions ............................4

Cleaning and Maintenance ........................5

Unit installation ..................................6

Troubleshooting ..................................7

Service ...........................................8

Environmental Protection .........................8

Technical parameters

OPK 4460 OPK 4490 OPO 5590

Voltage 230 V ~ 50 Hz

Power input 202 W 204 W

Version Chimney Island

ASSEMBLY On the wall On the ceiling

Width 600 mm 900 mm 900 mm

Depth 500 mm 600 mm

Height 650 – 900 mm 700 – 1000 mm 800 - 1000 mm

Diameter 150 mm 150 mm

Numberoffans 1

Numberoffanpowerlevels 4

Capacity Max. 900 m

3

/h

Numberoffatlters 2 3 3

Mode Airing or re-circulation

Odour sensor / automatic mode Yes/Yes

Lighting 2 x 1 W LED 4 x 1 W LED

Weight 14 kg 16 kg 15 kg

Noise level, airing/re-circulation < 49/51 dB(A)

Themanufacturerreservestherighttomaketechnicalmodicationsanddesignchangeswithoutpriornotice.

ThankyouforpurchasingaConceptproduct.Wehopeyouwillbesatisedwithourproductthroughoutitsservicelife.

PleasestudytheentireOperatingManualcarefullybeforeyoustartusingtheproduct.Keepthemanualinasafeplace

forfuturereference.Makesureotherpeopleusingtheproductarefamiliarwiththeseinstructions.

ACKNOWLEDGMENT

26

EN

OPK4460, OPK4490, OPO5590

IMPORTANT NOTICES:

Delivery

• Check the package and unit immediately after delivery for any damage that may have occurred during

shipping.

• Iftheunitisdamaged,donotoperateit.Contactthesupplierassoonaspossible.

• Removeallthecoveringandmarketingmaterialsfromtheunitbeforethefirstuse.

• Disposeofthepackagingmaterialproperly.

Installation

• Theunitisdesignedtobemountedonthewall(OPK4460andOPK4490),orontheceiling(OPO5590).

• Followtheinstructionsfortheapplianceconnectionandinstallation.

• Theunithastobedisconnectedfromthepowersocketduringinstallation.

• Beforeconnectingtheappliance,ensurethatyourlocalconnectionisearthedandcompliantwithallapplicable

regulations.

• Makesurethemainsvoltageandcurrentprotectioncorrespondtothevaluesontheratingplate.Useearthed

wall outlets only.

• Afterinstallationoftheunititsplugorcircuitbreakershallbefreelyaccessible.

• Onlyanauthorisedtechnicianmayinstallandconnectyourappliance.

• Improperconnectionand/orincompetentinstallationmayresultininjuryordeath.

• Themanufacturertakesnoresponsibilityforanydamageincurredduetoimproperinstallationoruse.

Normal operation

• Usetheunitonlyasdescribedinthisoperatingmanual.

• Usetheunitonlyinthehouseholdsolelyforthepurposeofabsorbingvapourcreatedduringcooking,orre-

circulationandabsorptionofodourscreatedduringcooking.

• Installtheunitatleast650mmabovetheelectriccooker(orhotplate),and700mmatminimumabovegas

cooker (or gas hotplate).

• Neveroperatetheappliancewithwethands.

• Incaseofanyfailureandbeforemaintenanceandcleaningturnofftheproductanddisconnecttheplugfrom

themainsoutlet,orswitchoffthecircuitbreaker.

• Neverpullthecordtodisconnecttheplugfromthewalloutlet;holdthepluginstead.

• Checktheapplianceandpowercordfordamageregularly.Neverswitchonadamagedappliance.

• Donotimmersethepowercord,plug,orapplianceinwateroranyotherliquid.

• MakesurethatallcontrolsareintheOFFpositionwhentheapplianceisnotinuse.

• Donothandleopenfireundertheunit(e.g.flaming)!Incaseyouremovecookingvesselfromgascooker,put

downtheflametominimum,orturnitoff!

 Makesurethediameteroftheburnerofgascookerorgashotplatecorrespondswiththecookingkitchenware

used.Whenusingsmallerthanrecommendedvesselstheflamecouldtouchthesides,andtheplastichandles

couldbescorched–riskoffire!

• Whenyoudeep-fryorfryfood,keepitundercontinuouscontrol.Whenoilisoverheated,thereisariskoffire!

• Keeptheintervalsforreplacementandcleaningofthefilters(every2monthsatminimum).Iftheseinstructions

arenotfollowed,thereisariskoffireduetofatsedimentsinthefilters!

• Fortheventilationductsalltheapplicablestandardsandregulationsshallbeobserved.

• Thediameterofductpipelinefortheairingmodeshouldbeapproximatelythesameasthediameterofoutput

pipeoftheabsorber.

EN

27

OPK4460, OPK4490, OPO5590

PRODUCT DESCRIPTION

OPK 4460, OPK 4490

A Upper chimney cover

B Lower chimney cover

C Body of the unit

D Wall holder

E Wall holder of the upper chimney cover

F Upper cover

OPO 5590

A Body of the unit and lower chimney cover

B Upper chimney cover

C Ceiling holder with fan

Accessories

1. Backﬂow valve

1

• Theairshallnotbeventilatedthroughachimneyusedforcombustiongases,orinashaftusedfortheairingof

rooms where combustion chambers are installed.

• Duringtheoperationinairingmodeasufficientorificefortheinputairshallbemade,itssizeapproximatelythe

sameorbiggerthanthatoftheholeforventilatedair.

• Duringsimultaneousoperationoftheunitinairingmodeandthecookerstheunderpressureintheroomshall

not exceed 4 Pa (0.04 mbar).

• Usemanufacturer-recommendedaccessoriesonly

Children in the household

• The appliance is not intended for and should not be accessible to children or persons with reduced

capabilities.

• Theapplianceisnotintendedforusebypersonswithreducedphysical,sensoryormentalcapabilitiesorlackof

knowledge,unlessunderthesupervisionofanacquaintedpersonresponsiblefortheirsafety.

• Takeextracarewhenusingtheunitnearchildren.

• Donotusetheapplianceasatoy.

28

EN

OPK4460, OPK4490, OPO5590

OPERATING INSTRUCTIONS

WARNING!

• Thetouchcontrolisactivatedbyputtingafingerontherequiredsymbolonthecontrolpanel.Thereforekeep

the control panel clean and dry.

• Ateachpressingofasymbolabeepcanbeheard.Theresponsetimeforpressingasymbolis1second,forwhich

timeitisnecessarytoholdafingeronthesymbol.

• Thesensorsdonotrespondtomattdarkcolours(donotuseblackgloves).

• Makesuretheunitisnotaccidentallyswitchedon,e.g.duringcleaning!

Before the first use

Priortothestartofuseofanewunit,wipeitwithawetandthenadrycloth.

Airing mode

Inthismodethevapoursareventilatedthroughtheoutputpipeintotheshaftandoutoftheroom.Incasethere

arecarbonfiltersinstalledintheunit,removethem(seeCleaningandmaintenancechapter).

1.Selecttherequiredfanpowerlevelbypressing„+“and„-“symbols(1–4).

2.Aftertheuseswitchtheunitoffbysettingthefanpowerlevelto„0“.

Re-circulation mode

Ifyouhavenopossibilitytoventilatetheairoutoftheroom,re-circulationmodecanbeselected.Inthismodethe

vapoursarefilteredthroughmetalandcarbonfilters.Activecarboninthesefiltersabsorbssmells,andtheclean

airflowsbacktotheroomthroughholesintheupperchimneycover.Forthismodeitisnecessarytobuyand

assemblecorrespondingcarbonfilters(seeCleaningandmaintenancechapter).

1.Selecttherequiredfanpowerlevelbypressing„+“and„-“symbols(1–4).

2.Afteruseswitchtheunitoffbysettingthefanpowerlevelto„0“.

Switching the lighting on and off

SwitchthelightonbypressingtheLsymbol.SwitchthelightoffbyrepeatedpressingoftheLsymbol.

Delayed OFF function

1.Selecttherequiredfanpowerlevel(1–4).

2.Bypressingthe„T“symbolactivatethedelayedofffunction.Adotsymbolwillblinkonthedisplay.

3.Settherequireddelayedofftimebyrepeatedpressingof„-“and„+“symbolsintherange10–90minutes.Tens

ofminuteswillbedisplayed,i.e.1=10minutes,2=20minutesetc.Confirmbypressingthe„T“symbol(fan

power level will be displayed, and dot symbol will blink).

DESCRIPTION OF THE CONTROL PANEL

1. Fan power level setting symbols

2. Display of the set power level, or time of delayed

switch oﬀ

3. Symbol of setting the delayed OFF timer

4. Symbol of lighting ON/OFF

1 2 3 4

EN

29

OPK4460, OPK4490, OPO5590

Note: If you don‘t confirm the delayed off settings within 20 seconds, the settings will be erased, and the

delayedofffunctionwillbedeactivated.

4.Theunitwillswitchoffautomaticallyafterthepresettimerunsout.

Note: Incaseyoupressthe„T“symbolduringthecountdown,orswitchoffthefanmanuallybeforethetime

runsout,thedelayedofffunctionwillbedeactivated.

Automatic fan power regulation

Theunitisequippedwithaso-calledodoursensorthatdetectsanincreasedvolumeofodoursintheair.

Thisfunctionenablesautomaticregulationoffanpowerdependingonthevolumeofodoursintheair.

Afterconnectingtoelectricpowerthefanshallnotbeswitchedonforabout5minutes,sothatthesensorcanbe

calibrated.

Thefunctionisactivatedbyalongpressingofthe„–“symbol.An„A“willbedisplayed.

Todeactivatethefunction,long-pressthe„–“symbol.

Filter replacement signal function

Thisfunctionisonlyindicative,itremindsyouwhenthefiltersshouldbecleanedorreplacedunderstandarduse.

Thefunctioncountshoursofoperation,i.e.theunitdoesnotdetectwhetheryouhavealreadyperformedthe

replacementornot;itjustremindsyouthatacheck-up,cleaningorreplacementshouldbecarriedout.

„F“–signaltocleanthefatfilterswillbedisplayedafter100hoursofoperation.

„C“–signaltoreplacethecarbonfilterswillbedisplayedafter220hoursofoperation.

Youmayresetthecounterbypressingthe„T“symbolfor10seconds,thedisplaywillgooff.

CLEANING AND MAINTENANCE

• Beforeanymaintenanceandcleaningdisconnectthepowercordfromthemainsorswitchoffthecircuitbreaker

ofthemainsoutletoftheunit.

• Donotimmersethepowercord,plug,orapplianceinwateroranyotherliquid.

• SetallcontrolsintheOFFposition.

• Cleantheoutersurfaceoftheunitwithawetcloth,oruseaneutraldetergent.

• Donotusecoarsesponges,abrasivecleanersorcausticagentssuchasovencleanerorstainremover.

• Donotuseautoclaveforcleaningtheunit!

CLEANING AND REPLACING THE FILTERS

a)Metallicfatfilters

 Undernormalusethemetallicfatfiltersshouldbecleanedevery2months.

Incaseofmorefrequentfryingordeepfryingmaketheintervalshorter.

 Donotusetheunitwithoutproperlymountedmetallicfatfilters!

1.Removethemetallicfilters(Fig.1).Incasetherearecarbonfiltersmounted,

remove them.

2.Putthemetallicfiltersinwarmwaterwithadetergent.Cleanthemwitha

softbrush,rinsewithcleanwaterandletdry.

3.Remountcompletelydryfiltersfollowingthereversesteps.

Fig. 1

30

EN

OPK4460, OPK4490, OPO5590

UNIT INSTALLATION

• Only authorised personnel can install the power connection!

• Onlythecustomerisresponsibleforinstallationinsitu.Defectscausedbyincorrectinstallationarenotcovered

by the warranty.

• Removeallthecoveringandmarketingmaterialsfromtheunitbeforethefirstuse.

• Werecommendyoutoletaspecialisedcompanyperformtheinstallation.

• Themanufacturerbearsnoresponsibilityfordamagecausedtopeople,animalsorobjectsasaresultofincorrect

installation.

Follow the installation instructions:

a) Chimney type (models OPK 4460, OPK 4490)

1.Marktheminimumrequiredassemblyheightonthewallbehindthehotplate(650mmforelectric,and700mm

forgashotplates,Fig.3).

2.Markthepositionofcentreofthehotplatebyaverticalline.

3.Drillholes,fixwallholder(D)attherequiredheightusingthesuppliedwallplugs(G)andscrews(H)(960mm

forelectricand1010mmforgashotplates,Fig.3).

4.Hangthebodyoftheunitontheholder(K).Settheexactverticalpositionbyscrews(J)and(I),Fig.4.

5.Fortheairingmodemountthebackflowvalveontheoutputhole,andconnecttheoutputholeofthefanwith

holetheinthewallusingflexiblepipe.Ifneedbeusetheadapter(150/120mm).

Note: Flexible pipe and diameter adapter are not supplied.

6.Mountboththechimneycoversonthebody(KandN),shifttheupperchimneycover(N)totherequiredheight,

and mark its upper edge on the wall (Fig. 4 and 5. Remove both the chimney covers.

7.Measureandmarka16mmdistanceunderthemarkedmaximumheightoftheupperchimneycover.Drillholesat

thisheight,andxthewallholderoftheupperchimneycover(E).Ifnecessaryusetheuppercover(F),Fig.5.

8. Mount and screw the lower and upper chimney covers.

9. Plug the supply cable in the wall outlet.

b)Carbonfilters(mustbepurchased)

Thesefiltersareusedonlyinthere-circulationmode.

Thefilterscontainactivecarbonthatabsorbstheventilatedodours.Afterawhiletheactivecarbonissaturated,

andlosesitsabsorptionability.Thesefilterscan‘tbewashedorotherwisecleaned.

Undernormalusethecarbonfiltersshouldbereplacedevery2months.Incaseofmorefrequentfryingordeep

fryingmaketheintervalshorter.

1.Removethemetallicfilters(Fig.1),andremovecarbonfiltersfromthem.

2.Mountnewcarbonfilterstothemetallicones(Fig.2),andputthesetback.

Fig. 2

EN

31

OPK4460, OPK4490, OPO5590

b) Island type (model OPO 5590)

1.Markthecentreofthehotplateontheceilingabove.

2.Drillholes,fixtheceilingholderusingsuppliedwallplugsandscrews(Fig.7).

3.Fortheairingmodemountbackflowvalveontheoutputhole,andconnecttheoutputholeofthefanwiththe

holeinthewallusingflexiblepipe.Ifneedbeusetheadapter(150/120mm).

Note: Flexible pipe and diameter adapter are not supplied.

4.Mounttheupperchimneycoverontheceilingholder(Fig.8),andfixitusingthescrews(B).

5.Mountthelowerchimneycoverontheceilingholder(Fig.9and10),shiftupandfixtothebodyusingscrews

(C).Keeptheminimumrequiredheightabovethehotplate(650mmforelectric,and700mmforgashotplates,

Fig. 6).

6. Open the switch box and connect the control cable. Connect all other possible connectors.

7.Plugthesupplycableinthewalloutletandshiftthelowerchimneycoverdown.

Fig. 3 Fig. 4 Fig. 5

Fig. 7 Fig. 8 Fig. 9 Fig. 10

32

EN

OPK4460, OPK4490, OPO5590

SUPPORTED ACCESSORIES

Metalfilter1pc Ord.No.61990001 Price:Seepricelist

Carbonfilter1pc Ord.No.61990002 Price:Seepricelist

150/120 mm diameter adapter Ord. No. 61990013 Price: See price list

Removal

Beforeremovaldisconnectthepowercablefromwalloutlet,followthereversestepstoremoveindividualparts

oftheunit.

TROUBLESHOOTING

Problem Cause, solution

The control does not work, or

does not work properly.

Therewasavoltageuctuationorblackoutinthenetwork.Disconnectthepower

sourcefor10seconds,thenconnectagain.Thecontrolelectronicswillbereset.

Lowsuctionperformance Check and clean he metallic ﬁlters, or replace the carbon ﬁlters.

"A" symbol is displayed. AutomaticfanpowerregulationfunctionisON.

"C" symbol is displayed. Signalforcheck-uporreplacementofcarbonlter(re-circulation).

"F" symbol is displayed. Signalofcheck-upofcleaningfatFilter(airingmode)

ENVIRONMENTAL PROTECTION

• Packagingmaterialsandobsoleteappliancesshouldberecycled.

• Thetransportboxmaybedisposedofassortedwaste.

• Polyethylenebagsshallbehandedoverforrecycling.

Appliance recycling at the end of its service life:

A symbol on the product or its packaging indicates that this product should not go into household waste.

Itmustbetakentothecollectionpointofanelectricandelectronicequipmentrecyclingfacility.Bymaking

surethisproductisdisposedofproperly,youwillhelppreventthenegativeeectsontheenvironment

andhumanhealththatwouldotherwiseresultfrominappropriatedisposalofthisproduct.Youcanlearnmoreabout

recyclingthisproductfromyourlocalauthorities,ahouseholdwastedisposalserviceorintheshopwhereyoubought

this product.

SERVICE

Anyextensivemaintenanceorrepairthatrequiresaccesstotheinnerpartsoftheproductmustbeperformedbyanexpert

service centre.

Page is loading ...

Concept OPO-5590 Operating instructions

Concept OPO-5590 Operating instructions

in other languages

Related papers

Other documents