Purpleline IMP003 is a 5 Amp DC-DC charger that converts direct current into the correct charging voltage for the onboard battery. It operates in a 4 step, 3 stage charging profile for lead-acid batteries and a CC/CV charging strategy for lithium batteries. The charger also includes safety features such as reverse polarity protection and over-current protection. With the IMP003, you can ensure that your batteries are safely and efficiently charged.
Purpleline IMP003 is a 5 Amp DC-DC charger that converts direct current into the correct charging voltage for the onboard battery. It operates in a 4 step, 3 stage charging profile for lead-acid batteries and a CC/CV charging strategy for lithium batteries. The charger also includes safety features such as reverse polarity protection and over-current protection. With the IMP003, you can ensure that your batteries are safely and efficiently charged.
5A DC-DC CHARGER
Tel: 03 9588 2959
Email: [email protected]
Web: www.purpleline.com.au
USER MANUAL
Part Number: IMP003
PRODUCT DESCRIPTION
1
The IMP003 Imperium 5A DC-DC charger converts
direct current into the correct charging voltage for
the onboard battery.
The Imperium 5A DC-DC charger will limit the
charging current to a maximum of 3.1A to avoid
overloading the cabling and it also ensures that no
current can flow from the on-board battery back to
the starter battery, as with all LiFePO4 batteries it is
better not to have a direct connection to any other
type of battery. Because the offered charging
voltage is often too low to fully charge LiFePO4
(14.6V) batteries, the DC-DC 5A charger transforms
this charging voltage to the correct voltage.
When the charger is setup for lead-acid batteries it
operates a 4 step, 3 stage voltage.
When the charger is setup for lead-acid batteries it
operates a 4 step, 3 stage charging profile. When
the charger is setup for lithium batteries it operates
a CC/CV charging strategy
01
Rechargeable battery Source, starter battery or alternator
SAFETY INSTRUCTIONS
2
2.1 Safety instructions statement
These safety instructions are divided into 3 categories,
as follows:
Danger, these instructions must be
followed to prevent injury or harm.
WARNING!
These instructions must be followed
to prevent damage.
CAREFUL!
Important advice and guidance.
PAY ATTENTION!
2.2 Safety regulations
Read this manual carefully before using the
Imperium DC-DC 5Ah Charger;
Keep this manual near the Imperium DC-DC 5Ah
Charger and make it available to the user of the
Imperium DC-DC 5Ah Charger;
As soon as the voltage of the source battery is
available the green Power LED of the charger will
turn on. During the charging process the red Charge
LED will be on. When the battery is fully charged the
Charge LED will turn off.
When the incoming voltage will go under 11.2 V or
12.0 V, the charging process stops to prevent the
source battery being discharged too deep
(depending on the settings).
Only technically qualified personnel should install
the Imperium DC-DC 5Ah Charger;
Use cables with the correct cross-section and
keep the cable connections as short as possible.
Use the supplied flat plugs and check whether
they clamp properly;
Do not place the Imperium DC-DC 5Ah Charger
in a high temperature environment or in direct
sun or with a heat source > 45 ° C;
Avoid damage to the Imperium DC-DC 5Ah
Charger housing;
Do not use a damaged Imperium DC-DC
5Ah Charger.
DESCRIPTION EN OPERATION
3
3.1 Operation
Advice: fit 5A fuses. These also function as reverse
polarity protection.
When mounting the Imperium DC-DC 5Ah
Charger, choose a place that is dry and clean;
The Imperium DC-DC 5Ah Charger can be
mounted in any position;
Use at least 1,5 mm² cables for connection and
to make the cables as short as possible to
prevent loss of current.
Connection diagram:
02
This Imperium 5A DC-DC Charger is compliant to
AS/NZS 61000.6.3 and has EMC accreditation.
SPECIFICATIONS
4
Electric appliances should not be disposed of with
normal household waste. According to the
European Directive 2012/19/EU on waste electrical
and electronic equipment (WEEE), these devices
must be collected separately in order to recycle
them in an environmentally friendly manner
possible.
Purple Line guarantees that the Imperium DC-DC
5A Charger is built according to all legally applicable
standards and regulations. During production and
before delivery all Imperium DCDC 5A Chargers
have been extensively tested and checked. Failure
to act in accordance with the instructions and
provisions of this manual may result in damage
and this may mean that the warranty will become
void. The warranty period is 2 years. The warranty
immediately expires if the silver label is removed
from the Imperium DC-DC 5Ah Charger, so DO NOT
remove this.
DECOMMISSIONING
5
WARRANTY
6
COMPLIANCE
7
Declaration according to Directive 2014/35 / EC, as
amended. This language version of the statement is
checked by the manufacturer (original statement).
We:
Name : Purple Line
Address : 13-15 Indian Drive
Keysborough VIC 3172 AUS
Country : Australia
declare for the product described below:
Generic name : LiFePO4 battery
Trade name : DC-DC 5A Charger
Model : IMP003
Function : 12V Battery for power supply in
caravans and other applications.
2014-35-EU DIRECTIVE 2014/35 / EU OF THE
EUROPEAN PARLIAMENT AND OF THE
COUNCIL of 26 February 2014 on the
harmonization of the laws of the Member
States concerning the making available
on the market of electrical equipment for
use within specified voltage limits.
014/30/EU DIRECTIVE 2014/30 / EU OF THE
EUROPEAN PARLIAMENT AND OF THE
COUNCIL of 26 February 2014 on the
harmonization of the laws of the Member
States concerning electromagnetic
compatibility.
011/65/EU DIRECTIVE 2011/65 / EU OF THE
EUROPEAN PARLIAMENT AND OF THE
COUNCIL of 8 June 2011 on the restriction
of the use of certain hazardous
substances in electrical and electronic
equipment.
that all relevant provisions of the Machinery Directive
are met; that the product also complies with the
provisions of the following European directives:
EG DECLARATION OF CONFORMITY
8
EG DECLARATION OF CONFORMITY OF
ELECTRICAL EQUIPMENT
and which the following natural or legal person
established in the Community is authorized to compile
the technical file:
Name and position : Purple Line Ltd Pty
Address : 13-15 Indian Drive
Keysborough VIC 3172 AUS
Country : Australia
Done at Kapelle 3-9-2018
EMC compliance.
The relevant standards are:
EN 61000-6-3:2007+A1:2011
EN 60950-1:2005+A1:2009+A2:2013
2
YEARS
WARRANTY
Full 2 years warranty from date of purchase against
all manufacturing defects.
WARRANTY PERIOD:
Under normal usage conditions, this warranty
covers:
1. Any defect in design or manufacture which results
in its failure to perform correctly as described.
2. We will either repair or replace the product at our
discretion provide that the fault is found to have
been caused by a design or manufacturing defect
and not misuse or tampering.
WHAT DOES THE WARRANTY COVER?
1. Cost of removing and reinstalling the product.
2. Travel and /or other expenses due to customer's
location.
3. Transport charges and damage in transit. It is
your responsibility to deliver and pick up your
product, including any costs associated with the
postage of repairing or replacing your product. If
you want to send the product back we recommend
that you insure against loss or damage.
4. Any loss directly or indirectly associated with the
product that fails to operate.
5. Damage caused by mould, misuse, incorrect
operation, adverse weather, accidents and daily
wear and tear.
6. The warranty is non-transferable and only applies to
the original purchaser.
7. This unit is not intended for commercial use.
8. This warranty does not apply to damage to units
from misuse or incorrect installation/connection.
Misuse includes wiring or connecting to improper
polarity power sources.
THE WARRANTY DOES NOT COVER
Purple Line Pty Ltd
13 Indian Drive
Keysborough
VIC 3172
AUSTRALIA
Web: www.purpleline.com.au
Tel: 03 9588 2959
Email: [email protected]
Photographs & diagrams for illustration purposes
only. Actual product may differ slightly. All weights
& dimensions are approximate. The manufacturer
reserves the right to change product specification
without prior notice. E & OE.
-
1
-
2
-
3
-
4
Purpleline IMP003 is a 5 Amp DC-DC charger that converts direct current into the correct charging voltage for the onboard battery. It operates in a 4 step, 3 stage charging profile for lead-acid batteries and a CC/CV charging strategy for lithium batteries. The charger also includes safety features such as reverse polarity protection and over-current protection. With the IMP003, you can ensure that your batteries are safely and efficiently charged.
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
Other documents
-
BlueBuilt BBIMP23 User guide
-
Molex 19286-1000 Operating instructions
-
Slitherine Warhammer 40,000: Sanctus Reach Horrors of Warp User manual
-
Munchkin Warhammer 40,000 Savagery and Sorcery Rules
-
Lego Bionicle - Manas 8539 Owner's manual
-
-
Motorola CG3500 User manual
-
Koch Media Sword of the Stars 2, DVD, PC User manual
-
Ravensburger Star Wars Labyrinth Owner's manual
-
Apple AppleWorks Series AppleWorks 6 Quick Start
