Haier DWL3025DWW User manual

- 1 -



Service Manual

Model No: DWLSeries

Issue

Rev.

- 2 -



*.1035"/54"'&5:/05*$&

5IFJOGPSNBUJPOJOUIJTTFSWJDFHVJEFJTJOUFOEFEGPSVTFCZJOEJWJEVBMTQPTTFTTJOHBEFRVBUFCBDLHSPVOETPG

FMFDUSJDBMFMFDUSPOJDBOENFDIBOJDBMFYQFSJFODF"OZBUUFNQUUPSFQBJSBNBKPSBQQMJBODFN

BZSFTVMUJOQFSTPOBM

JOKVSZBOEQSPQFSUZEBNBHF5IFNBOVGBDUVSFSPSTFMMFSDBOOPUCFSFTQPOTJCMFGPSUIFJOUFSQSFUBUJPOPGUIJTJO

GPSNBUJPOOPSDBOJUBTTVNFBOZMJBCJMJUZJODPOOFDUJPOXJ

UIJUTVTF



8"3/*/(

5PBWPJEQFSTPOBMJOKVSZEJTDPOOFDUQPXFSCFGPSFTFSWJDJOHUIJTQSPEVDU*G

FMFDUSJDBMQPXFSJTSFRVJSFEGPSEJBHOP

TJTPSUFTUQVSQPTFTEJTDPOOFDUUIFQPXFSJNNFEJBUFMZBG

UFSQFSGPSNJOHUIFOFDFTTBSZDIFDLT



3&$0//&$5"--(306/%*/(%&7*$&4

*GHSPVOEJOHXJSFTTDSFXT

TUSBQTDMJQTOVUTPSXBTIFSTVTFEUPDPNQMFUFBQBUIUPHSPVOEBSFSFNPWFEGPSTFSWJDF

UIFZNVTU

CFSFUVSOFEUPUIFJSPSJHJOBMQPTJUJPOBOEQSPQFSMZGBTUFOFE



)BJFS"NFSJDB

5FDIOJDBM4FSWJDF(VJEF

$PQZSJHIU

©



"MMSJHIUTSFTFSWFE5IJTTFSWJDFHVJEF

may

OPUCFSFQSPEVDFEJOXIPMFPS

 JOQBSUJOBOZGPSNXJUIPVUXSJUUFOQFSNJTTJPOGSPNUIF)BJFS"NFSJDB



- 3 -

Table of Contents

ACTIVE

VENT……………………………………………………………………………………………………

…………………………...21

CIRCULATION PUMP AND

MOTOR………………………………………………………………………………………………

….15

COMPONENT LOCATOR

VIEWS………………………………………………………………………………………………….

…..10

COMPONENTS………………………………………………………………………………………

…………………………….….……..13

CONTROL

FEATURES………………………………………………………………………………………………

…..……………………6

CONTROL

BOARD………………………………………………………………………………………………

……………………..……20

TEST

MODE…………………………………………………………………………………………………

…………………..…………….16

DETERGENT/RINSE

MODULE……………………………………………………………………………………………….

.………..21

DOOR INTERLOCK

SWITCH………………………………………………………………………………………………..

……………21

DOOR

PANEL………………………………………………………………………………………………..

……………..…………………19

DRAIN

SYSTEM……………………………………………………….………………………………………

………………….………….17

FILL

FUNNEL……………………………………………………….………………………………………

………………….…………..….14

HEATING

ELEMENT………………………………………….……………………………………………………

…………………...….16

LOWER SPRAY WASH ARM, FINE FILTER, AND INLET

COVER…………………………………………………………..14

MAIN

Service Manual

Model No: DWL Series

Issue

Rev.

- 4 -

CONDUIT……………………………………………………….………………………….…………

…………………………..….14

MEMBRANE

KEYPAD………………………………………………………………………………..………………

……..….…………19

MIDDLE SPRAY

ARM………………………………………………………………………………..…………………

…..….………….13

NOMENCLATURE………………………………………………………………………………..…

…………………..….…………………4

SCHEMATIC………………………………………………….………………………………………

….…………………..…….………….25

STRIP

CIRCUITS………………………………………………….………………………………………….

…………….…..…………….24

THERMISTOR………………………………………………….………………………………………

….…………….…..……………….15

TOP SPRAY

ARM……………………….………………………………………….…………….…………………

………...…………….14

TROUBLESHOOTING…………….………………………………………….…………….…………

………………...……….….…….22

TURBIDITY

SENSOR………………………………………………….………………………………………….…

………….….……….17

USING THE DISHWASHER WITH THE UPPER RACK

REMOVED…………………………………………………………13

WASH

CYCLES………………………………………………………………………………………………

…………………………………15

WATER VALVE AND FLOOD

SWITCH…………………………………….……………………………………..…….…………...1

7

WATER VALVE

TEST………………………………………….…………………………………………………………

…..….……….…18

- 5 -

.

.PEFM/VNCFS



 



4FSJBM/VNCFS



5IFNPEFMOVNCFSBOETFSJBMOVNCFSBSFMPDBUFEJOTJEFUIFEPPSKBN5IFfiSTUUXPDIBSBDUFSTPGUIF

TFSJBMOVNCFSJEFOUJGZ 

FA0540E0700

FA 1 1 1 0 0 01

(1)

Modle Code

(2) Line Code

(3) Year Code

(4) Month Code

(5) Date Code

(6) Manufacturing Serial Number

Column 1.

Model number, DWL3025DWW/DBBB/SBSS:FA0540E0800/0900/0A00

Column 2. Line code: FA=Dishwasher line

Column 3 Year of Manufacture

Column4 Month of Manufacture

Column5 Date of Manufacture

Column 6

Manufacturing Serial Number

DW L 3025 DBWW

Door type

L=Long door

Dishwasher

Design

Code

Exterior Colour

DBWW=White

DBBB=Black

SBSS

=

Stainles

Service Manual

Model No: DWL Series

Issue

Rev.

- 6 -

DATE OF MANUFACTURE CODE TABLE (For column 3,4 & 5):

Month of Manufacture Year of Manufacture

1 – Jan 1–2001 D 2013,

2 – Feb 2–2002 E 2014,

3 – Mar 3–2003 F 2015,

4 – Apr 4–2004 G 2016…. …..

5 – May 5–2005

6 – June 6 –2006

7 – July 7 –2007

8 – Aug 8 –2008

9 – Sept 9 –2009

A – Oct A –2010

B – Nov B –2011

C – Dec C –2012



   

Date of Manufacuure



1-1 A-10 D-13

2-2 B-11 E-14

3-3… C-12 F-15…



Service Manual

Model No: DWL Series

Issue

Rev.

- 7 -



$POUSPM4FUUJOHT

4UBUVT*OEJDBUPS-JHIUT

*OEJDBUPSTWBSZCZNPEFMT

The status dislay tells you what is happening while the dishwasher is in operation and may flash,

indicating a malfunction. The lights will come

0/

indicating the sequence of the dishwasher operation.

            

4&/4*/(

%JTQMBZFEXIJMFUIFUVSCJEJUZTFOTPSJTNFBTVSJOHUIFBNPVOUPGTPJMBOEUFNQFSBUVSFPG

XBUFS5IFEJTIXBTIFSXJMMBEKVTUUIFTFMFDUFEDZDMFUPBDIJFWFPQUJNBMQFSGPSNBODF

4"/*5*;&% 

%JTQMBZFEXIFODZDMFIBTNFUTBOJUJ[BUJPODPOEJUJPOT

$-&"/

%JTQMBZFEXIFOBXBTIDZDMFJTDPNQMFUFBOEFOIBODFNFOUTBSFDPNQMFUF



1

2

3

4

5

Service Manual

Model No: DWL Series

Issue

Rev.

3

4

2

5

1

2

4

3

1

5

2

4

3

- 8 -



     









$ZDMFT

"6508"4)

("-NJO

6TFGPSBMMTPJMUZQFTBOEEJTIMPBET5IJTDZDMFIBTBEEJUJPOBMDIFDLTGPSTPJMJOUIFXBUFSUP

HJWFBEEFEXBTIBDUJPOUJNF5IFXBTIBDUJPOXJMMQBVTFTFWFSBMUJNFTUISPVHIPVUUIFDZDMF

GPSVQUPTFDPOETUPDIFDLUIFTPJMMFWFMJOUIFXBTIXBUFS



10541"/4

HBMNJO   

  

5IJTDZDMFJTNFBOUGPSIFBWJMZTPJMFEEJTIFTPSDPPLXBSFXJUIESJFEPOPSCBLFEPOTPJMT5IJT            

DZDMFNBZOPUSFNPWFCVSOFEPOGPPET&WFSZEBZEJTIFTBSFTBGFUPCFVTFEJOUIJTDZDMF



/03."-8"4)      

HBMNJO 

5IJTDZDMFJTGPSNFEJVNIFBWJMZTPJMFEEJTIFTBOEHMBTTXBSF



41&&%$:$-&      

HBMNJO 

5IJTDZDMFJTGPSFWFSZEBZEJTIFTBOEHMBTTXBSF 



$)*/"$3:45"--*()58"4)   

HBMNJO

5IJTDZDMFJTTQFDJGJDBMMZEFTJHOFEUPSFEVDFUIFSJTLPGNFMUJOHQMBTUJDJUFNTBOE

JNQSPWFQMBTUJDESZJOH

'PSSFNPWJOHSFEUPNBUPCBTFETUBJOT)BJFSSFDPNNFOET

UIFVTFPG$BTDBEF1MBTUJD 



3*/4&)PME  



HBMNJO

'PSSJOTJOHQBSUJBMMPBETUIBUXJMMCFXBTIFEMBUFS%POPUVTFEFUFSHFOUXJUIUIJTDZDMF



/05&

5IJTEJTIXBTIFSJTFRVJQQFEXJUIBO4FOTPSUIFSFGPSFDZDMFMFOHUIBOEUJNFNBZWBSZEFQFOEJOH

POTPJMDPOEJUJPOT



Service Manual

Model No: DWL Series

Issue

Rev.

- 9 -



0QUJPOT

5IFMJHIUBCPWFUIFTFMFDUFEQBEXJMMCF

0/

UPJOEJDBUFXIJDIPQUJPOIBTCFFOTFMFDUFE



%&-":)06340/%8-NPEFMT

:PVDBOEFMBZUIFTUBSUPGBXBTIDZDMFGPSVQUPIPVSTPO%8-4FSJFTPS 

IPVSTPO(-%4FSJFT

1SFTTUIF

%&-":)0634

QBEUPDIPPTFUIFOVNCFSPGIPVSTBOEUIFODIPTFUIFDZDMF 

ZPVXBOUUPEFMBZDZDMFPO%8-TFSJFTPSBGUFSDIPTJOHUIFDZDMFQSFTT

45"353&4&5

QBEPO%8-TFSJFT



%8-5IFNBDIJOFXJMMDPVOUEPXOBOETUBSUBVUPNBUJDBMMZBUUIFDPSSFDUUJNF 

%8-"GUFSDMPTJOHUIFEPPSUIFNBDIJOFXJMMDPVOUEPXOBOEBVUPNBUJDBMMZTUBSU

BUUIFDPSSFDUUJNF 

/05&

5PDBODFMUIF



%&-":

NPEFMTQSFTTUIF

4UBSU3FTFU

QBE

$BODFM%SBJO

QBEPO



%8-

.PEFMT



)&"5&%%3: 

8IFOTFMFDUFEUIFDZDMFXJMMSVOMPOHFSXJUIIFBUJOHFMFNFOUTPOUPJNQSPWFESZ

QFSGPSNBODF4IVUTPGGUIFESZJOHIFBUPQUJPO%JTIFTXJMMBJSESZOBUVSBMMZUPTBWF

FOFSHZ 

/05&

$BOOPUCFTFMFDUFEXJUI

3JOTF)PME

DZDMF 



$"/$&-%3"*/0/%8-.0%&-4



5PVDIUIF$"/$&-%3"*/QBEUPDBODFMUIFDZDMF5IFXBUFSJTQVNQFEPVUJGOFFE

5IJTUBLFTBQQSPYJNBUFMZNJOVUFT



$)*-%-0$, 

:PVDBOMPDLUIFDPOUSPMTUPQSFWFOUBOZTFMFDUJPOTGSPNCFJOHNBEF0SZPVDBOMPDL

UIFDPOUSPMTBGUFSZPVIBWFTUBSUFEBDZDMF 

=$IJMESFODBOOPUBDDJEFOUBMMZTUBSUEJTIXBTIFSCZUPVDIJOHQBETXJUIUIJTPQUJPOTFMFDUFE 

5P

VOMPDL



UIFEJTIXBTIFSDPOUSPMTQSFTTBOEIPMEUIF

4BOJUJ[FE3JOTF

QBEBOE

)FBUFE

%SZ

QBE%8-POMZOFFE

)FBUFE%SZ

QBE



GPSTFDPOET

5P

MPDL

UIFEJTIXBTIFSQSFTTBOEIPMEUIF

4BOJUJ[FE3JOTF

QBEBOE

)FBUFE%SZ

QBE

%8-POMZOFFE

)FBUFE%SZ

QBE



GPSTFDPOET

Service Manual

Model No:

DWL

Series

Issue

Rev.

- 10 -

4

4UBSU

%8-4FSJFT

$MPTF



UIFEJTIXBTIFSEPPSBOE

TFMFDUFE

UIFDZDMFBOEPQUJPOT8BUFSGJMMCFHJOTJNNFEJBUFMZBOE

BQQSPYJNBUFMZTFDPOETMBUFSUIFXBTIBDUJPOCFHJOT

      %8-4FSJFT

0QFOUIFEJTIXBTIFSEPPS"GUFSTFMFDUJOHUIFDZDMFBOEPQUJPOTUPVDIUIF

45"353&4&5

QBE$MPTFUIFEPPS

BOEUIFO8BUFSGJMMCFHJOBGUFSBQQSPYJNBUFMZTFDPOET8BTIBDUJPOCFHJOBQQSPYJNBUFMZTFDPOETMBUFS  

5IFEJTIXBTIFSXJMMBMXBZTEJTQMBZZPVSMBTUTFMFDUJPOBOEFOIBODFNFOUT*GZPVEPO’UXBOUUPDIBOHFUIF

TFUUJOHTTJNQMZUPVDIUIF

45"353&4&5

QBEUPSFBEZUIFEJTIXBTIFSBOEDMPTFUIFEPPSUPCFHJOUIFDZDMF



     



 



$MFBO

5IF

$MFBO

MJHIUJTJMMVNJOBUFEXIFOUIFTFMFDUFEDZDMFBOEFOIBODFNFOUTOPUJODMVEFE

3JOTF)PME



$ZDMFBSF

DPNQMFUF



5

Service Manual

Model No:

DWL Series

Issue

Rev.

- 11 -



*OTJEFDBCJOFUWJFX



1. Upper Spray

2. Top Rack Track

3. Water Inlet Opening (in tub wall)

4. Lower Spray Arm

5. Bottom Rack

6. Vent System

7. Split Folding Utility Shelf (4)



8. Adjustable Top Rack

9. Middle Spray Arm

10. Removable Silverware Basket

11. Overfill Protection Float

12. Heating Element

13. Detergent and Rinse Aid Dispenser



Service Manual

Model No: DWL Series

Issue

Rev.

- 12 -



%PPS7JFX1BOFMSFNPWFE



-FGUTJEF7JFX



Service Manual

Model No: DWL Series

Issue

Rev.

- 13 -



#PUUPN7JFX



Service Manual

Model No: DWL Series

Issue

Rev.

- 14 -

Using the Dishwasher with the Upper

Rack Removed

Middle Spray Arm



1. Unsnap and remove the end cap on each side

of the rails.

2. Pull the rack straight out and off the rails.

3. Replace the end caps.

4. Push the rails all the way back into

the dishwasher.



1. Check holes in spray arm for bits of

china, seeds, and other foreign matter.

2. Check spray arms for rotation.

Removal and Replacement



1. Pull upper rack all the way out.

2. Remove plastic bottom of middle spray

arm. This will allow the middle spray arm

and bearing to be removed.

1RWH

Install middle spray arm with spray jets

facing the upper rack. Place bearing between

spray arm screw and bottom of the middle arm.

5. Slide the shower nozzle attachment over

the spout.

6. The dishwasher is now ready for use.



Note: Always use the shower nozzle when the

upper rack is removed.

Note: If the upper rack experiences poor cleaning

problems, ensure the middle spray arm is turning

freely. If not, disassemble the middle spray arm and

clean the bearing surface, then reassemble.

Unsa

Service Manual

Model No: DWL Series

Issue

Rev.

- 15 -

Lower Spray Arm, Fine Filter, and Inlet

Cover



Check the holes in spray arm for bits of china,

seeds, and other foreign matter. Also check the

spray wash arms for rotation. If soil is present,

clean fine filter screen.

The lower spray wash arm can be removed by

gently lifting and rotating it counterclockwise.

The nut hub can be removed by rotating it

counterclockwise.

&DXWLRQ

Use care to avoid breaking the clip on

the hub when removing the main conduit from

hub.

1RWH

When installing the fine filter, make sure

the drain port of the filter is engaged with the

drain for the fine filter.

Top Spray Arm



Check the holes in spray wash arm for bits of

china, seeds, and other foreign matter. Also

check the spray wash arms for rotation.

To remove the top spray wash arm, remove the

upper rack (See

Middle Spray Arm),

then remove

the screw and top spray wash arm.

Main

Conduit



The main conduit supplies water to the middle

and upper spray wash arms.

Removal and Replacement

1. Pull upper rack all the way out.

2. Push the tab on the outer slide cap in

and remove the slide cap.

3. Remove the upper rack.

)LQH)LOWHU



'UDLQ3RUW



'UDLQ)RU



)LQH)LOWHU



/RZHU



6SUD\$UP



0RXWQJ6FUH

Z



0DLQ&RQGXLW



1XW+XE



LQH)LOWU

$VVHEO\



RY,QOHW

4. Release the bottom conduit tab.

5. Release 2 center conduit tabs and remove

the main conduit.

Fill Funnel



The top section of the fill funnel separates from

the main body. The fill funnel body is held in place

by a nut (located on the inside of the dishwasher).

Rotate the nut counterclockwise to remove the

main body. There is an O-ring seal between the

fi l l funnel and dishwasher tub. Make certain the

O-ring is fully seated when reinstalling.

&RDUVH)LOWHU



)ORDW'RPH



+XE



Main

Conduit

Tab



 



Nut

O-Ring

Service Manual

Model No: DWL Series

Issue

Rev.

- 16 -



8BTI$ZDMFT                      

  



8"4)

5*.&

 

8"4)

5&.1&3"563&

)&"5&%

%3:

5*.& 

$:$-& 

."90'

13&8"4)

$:$-&4 

8"4)

$:$-&

."9

3*/4&

$:$-&4

.*/

."9



/PSNBM

8BTI 

     



  

 



 



4QFFE8BTI



    







 



$IJOB$SZTUBM



     



 



 



1PUT1BOT



     







 



 



"OUJ#BUJSJDBM



    









 



 





3JOTF)PME



         

5JNFJTJONJOVUFT 

5FNQFSBUVSFJTJOEFHSFFT'BISFOIFJU 



$ZDMFUJNFTJODMVEFXBUFSGJMMBOEESBJO 

)FBUFSPOJONBJOXBTIBOEGJOBMVSJOTF 



Circulation Pump and Motor

           

5

he dishwasher must be removed from its

installation to gain access to the circulation pump

and motor. The circulation pump can be activated

using Test Mode

. Refer to schematic or strip circuit

for motor resistance value.

Before removing the circulation pump, remove the

water from the sump with a syringe.

It is important to remember the motor does not start

immediately when the dishwasher cycle has

started. If the motor hums, but will not start, make

certain the pump impeller is free from obstruction

and the motor shaft can turn freely.

The terminals on the induction motor are labeled



L1 and /5IFNPUPSJTUIFSNBMMZQSPUFDUFEJOUFSOBMMZ



through the L1 side. The wiring connector is blue to

match the wire leading to the motor. It is designed

to fit only one way on the terminals. Make certain

the connector is fully seated when installing.



$JSDVMBUJPO1VNQBOE.PUPS4USJQ$JSDVJU 

Service Manual

Model No: DWL Series

Issue

Rev.

- 17 -



Heating Element

The heating element can be activated using TEST

Mode.



The dual-wattage heating element produces 850

watts during wash, to help heat the water, and an

effective wattage due to cycling of 541 watts during

the dry cycle.



Water inlet temperature must be at least 120 F for

proper drying. Lower water inlet temperature will

prevent proper convection air movement and

increase drying time substantially.



If the problem is that the dishes are not drying

correctly, don’t overlook the rinse agent. A rinse

agent will improve the water sheeting action and

drying performance.



It is normal for the stainless steel tub and inner door

panel to retain water droplets even though the dishes

are dry.



       )FBUJOHFMFNFOU4USJQ$JSDVJU

5IFIFBUJOHFMFNFOUOVUTBSFMPDBUFEPOUIFVOEFSTJEFPG

UIFXBTIFSOFBSUIFEPPS"NQMFGPSDFJTSFRVJSFEUP

SFNPWFUIFOVUT3FNPWJOHUIFEJTIXBTIFSGSPN

JOTUBMMBUJPONBZCFSFRVJSF

E

 



Test Mode



*OTUBOECZNPEFQVTI)*5&.1)&"5&%%3:BOE

)*5&.18"4)UIFNBDIJOFXJMMFOUFSJOUPUIFQSPDFTTPG

5FTU.PEF"GUFSFOUFSJOHUIFTFMGJOTQFDUJPONPEFBMM

MJHIUTXJMMCF

0/

BOEUIFEJTQMBZXJMMTIPXUIFOPQFSBUF

UIFVOJUBDDPSEJOHUPUIFGPMMPXJOHPSEFS

 5PVDIUIF10541"/4UIFJOMFUXBUFSWBMWFXJMM

XPSLGPSTFDPOET

 5PVDIUIF/03."-UIFXBTIQVNQXJMMXPSLGPS

NJOVUFTBOETUPQGPSNJOVUFTUIFOSFQFBU

 5PVDIUIF$)*/"QBE  UIFEFUFSHFOUEJTQFOTFSXJMM

XPSLGPSNJOVUFBOETUPQGPSNJOVUFTUIFO

SFQFBU

 5PVDIUIF4QFFEQBEUIFIFBUJOHFMFNFOUBOEXBTI

QVNQXJMMXPSLTJNVMUBOFPVTMZGPSNJOVUFBOETUPQ

GPSNJOVUFUIFOSFQFBU

 5PVDIUIF3*/4&)0-%QBEUIFIFBUJOHFMFNFOUXJMM

XPSLGPSNJOVUFTBOETUPQGPSNJOVUFTUIFO

SFQFBU

 5PVDIUIF4"/*5*;&3*/4&QBEUIFESBJOQVNQXJMM

XPSLGPSNJOVUFTBOETUPQGPSNJOVUFUIFO

SFQFBU

 5PVDIUIF)*5&.1QBEUIFXBYNPUPSXJMMXPSLGPS

NJOVUFBOETUPQGPSNJOVUFUIFOSFQFBU  



Turbidity Sensor



5IFUVSCJEJUZTFOTPSJTMPDBUFEJOUIFGSPOUPGTVNQ



Service Manual

Model No: DWL Series

Issue

Rev.

- 18 -



5IFUVSCJEJUZTFOTPSNFBTVSFTUIFBNPVOUPGTVTQFOEFE

QBSUJDMFTJOUIFXBTIXBUFSJOUIFTVNQ5IFDPOUSPMTFOET

UIFUVSCJEJUZTFOTPSBQVMTFXJEUINPEVMBUFEWPMUTJHOBM

GPSDBMJCSBUJPOBOEVTBHFEVSJOHPQFSBUJPO 



/PUF

*GTIPSUDJSDVJUPSPQFODJSDVJUIBQQFOTUPUIFTFOTPS

UIFEJTIXBTIFSXJMMPQFSBUFUIFTIPSUFTUDZDMFUJNFBOE

NBZDBVTFUIFCBEXBTIQFSGPSNBODF



#ZNFBTJOHUIFUVSCJEJUZMFWFMUIFDPOUSPMNPEVMFDBO

DPOTFSWFFOFSHZPOMJHIUMZTPJMFEMPBETCZTLJQQJOH

VOOFDFTTBSZDZDMFT



5VSCJEJUZ4FOTPS$JSDVJU



Thermistor



5IFSNJTUPSJTMPDBUFEPOUIFSJHIUEPXOTJEFPGUIFTVNQ



5IFUVSCJEJUZ

’

TSFTJTUBODFIBTBOFHBUJWFUFNQFSBUVSF

DPFGGJDJFOU"TUIFUFNQFSBUVSFJODSFBTFUIFSFTJTUBOF

HPFT

E



5IFUIFSNJTUPS’TSFTJTUBODFIBTOFHBUJWFUFNQFSBUVSF 



DPFGGJDJFOU"TUIFUFNQFSBUVSFJODSFBTFUIFSFTJTUBODF

HPFTEPXO"UƈUIFSFTJTUBODFJTBQQSPYJNBUFMZL

ē"UƈUIFSFTJTUBODFJTBQQSPYJNBUFMZLē

Drain System



5IFESBJOTZTUFNDPTJTUTPGUIFGPMMPXJOHDPNQPOFOUT

 "VYJMJBSZESBJOQVNQ

 TVNQ

 $IFDLWBMWFJOMJOFXJUIUVCF

 %SBJOIPVTFJODMVEFTUXPESBJOIPTFPOFXJUI

POFXBZDIFDLWBMWF

5IFJOMFUDPWFSQSFWFOUTMBSHFQBSUJDMFTGSPNFOUFSJOHUIF

TVNQ8BUFSFOUFSJOHUIFESBJOQVNQJTOPUGJMUFSFECZUIF

GJOFGJMUFSQMBTUJDPSCZUIFTVNQGJMUFSNFUBMQMBTUJD

5IFESBJOQVNQJTNPVOUFEPOUIFTVNQBOEDPOUBJOTB

POFXBZDIFDLWBMWF5IFESBJOQVNQJTDPOUSPMMFECZUIF

DPOUSPMCPBSEBOEDBOCFBDUJWBUFEVTJOH

5FTUJOH.PEF

"VYJMJBSZESBJOQVNQTUJQ$JSDVJU



5IFESBJOQVNQVUJMJ[FTB7"$NPUPS5IFNPUPS

TIPVMESFBEBQQSPYJNBUFMZē



+5V

1

2

3

Thermistor

Service Manual

Model No: DWL Series

Issue

Rev.

- 19 -

Water Valve and Flood Switch



5IFXBUFSWBMWFJTB7"$TPMFOPJEWBMWFUIBUJT

TXJUDIFEPOPGGCZUIFDPOUSPMCPBSE5IFGMPPETXJUDIBDUT

BTBTBGFUZTXJUDI0/-:BOEEPFTOPUDPOUSPMOPSNBM

PQFSBUJPOPGUIFXBUFSWBMWF5IFGMPPETXJUDIPQFOTUIF- 

TJEFPGUIFXBUFSWBMWFDJSDVJU 



5IFTXJUDIJTOPSNBMMZPQFO5IFXFJHIUPGUIFGMPPE

TXJUDIGMPBUIPMETUIFTXJUDIDMPTFE5IFGMPPETXJUDIXJMM

OPUTUPQUIFGMPXPGXBUFSJGUIFWBMWFTUJDLTPQFOGSPNB

NFDIBOJDBMGBJMVSF 

5IFXBUFSWBMWFDBOCFSFQMBDFEXJUIUIFEJTIXBTIFS

JOTUBMMFE 

8"3/*/(

%JTDPOOFDUQPXFSUPEJTIXBTIFSCFGPSF

TFSWJDJOHXBUFSWBMWFBOEGMPPETXJUDI



5IFWBMWFJTTFDVSFEUPUIFDMJQCZ1IJMJQTIFBETDSFX

/PUF

5PQSFWFOUMFBLTBGUFSJOTUBMMBUJPOFOTVSFUIBUIPTF

UPWBMWFDPOOFDUJPOJTHPPEBOEUIBUDMBNQJTJOQMBDF 



Water Valve Test



 "UUFQUUPBDUJWBUFXBUFSWBMWFVTJOH

5FTU.PEF

1VNQ

PVUXBUFSBTOFDFTTBSZVTJOH

5FTU.PEF

*GBO

JOUFSNJUUFOUGBJMVSFJTTVTQFDUFEBDUJWBUFXBUFSWBMWF

UJNFTVTJOH

5FTU.PEF

8BUFSWBMWFTIPVMETUBZPOGPS

UPTFDPOETQFSBDUJWBUJPOBOETIPVMEOPUUVSO

POBOEPGGEVSJOHUIFUPTFDPOEBDUJWBUJPOUJNF

 *GUIFXBUFSWBMWFJTOPUPQFSBUJOHQSPQFSMZPSXBUFS

MFWFMJTMPXDIFDLUIFGPMMPX

 8BUFSWBMWFGMPPETXJUDIGMPPETXJUDIGMPBUBOE

TUFN5IFGMPPETXJUDITIPVMEPQFOXIFOUIF

XBUFSMFWFMJTBQQSPYJBUFSMZJOBCPWFUIF

CBTFCPUUPNPGUIFGMPBUEPNF

 3FTJTUBODFUISPVHIUIFXBUFSWBMWFTPMFOPJEDPJM

ēUPē



Water Valve

Flood Switch

Clamp

Service Manual

Model No: DWL Series

Issue

Rev.

- 20 -



%PPS1BOF

M                                                                      

