E-Z-GO 2014 TERRAIN 1000 72V CE Owner's manual

Brand: E-Z-GO

Model: 2014 TERRAIN 1000 72V CE

Category: Utility Vehicle

Type: Owner's manual

This manual is also suitable for

OWNER’S GUIDE

639050

TERRAIN 1000 72V

TERRAIN 1000 72V CE

ISSUED JUNE 2014

WELCOME

Thank you for purchasing this vehicle. Before driving the vehicle, we ask you to spend some time reading this Owner’s

Guide. This guide contains the information that will assist you in maintaining this highly reliable vehicle. Some illustrations

may show items that are optional for your vehicle. This guide covers the operation of several vehicles; therefore, some

illustrations may not represent your vehicle. Physical differences in controls will be illustrated.

Most of the service procedures in this guide can be accomplished using common, automotive hand tools. Contact your ser-

vice representative on servicing the vehicle in accordance with the Periodic Service Schedule.

Repair or replacement parts are available through your E-Z-GO retailer or Genuine E-Z-GO Service Parts Department.

The following information is needed when contacting E-Z-GO concerning service or parts for your vehicle:

Vehicle Model: _______________________________________________________

VIN or Serial Number: _________________________________________________

Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability or increase the speed

beyond the factory specifications. Such modifications can cause serious personal injury or death. E-Z-GO Division of Textron Inc. prohib-

its and disclaims responsibility for any such modifications or any other alteration which would adversely affect the safety of the vehicle.

E-Z-GO Division of Textron Inc. reserves the right to incorporate engineering and design changes to products in this manual, without obli-

gation to include these changes on units sold previously.

The information contained in this manual may be revised periodically by E-Z-GO, and therefore is subject to change without notice.

E-Z-GO DISCLAIMS LIABILITY FOR ERRORS IN THIS MANUAL, and SPECIFICALLY DISCLAIMS LIABILITY FOR INCIDENTAL AND CONSE-

QUENTIAL DAMAGES resulting from the use of the information and materials in this Manual.

These are the original instructions as defined by 2006/42/EC.

E-Z-GO Division of Textron Inc.

1451 Marvin Griffin Road.

Augusta, Georgia, USA 30906-3852

North America:

Technical Assistance & Warranty PHONE: 1-800-774-3946 FAX: 1-800-448-8124

Service Parts PHONE: 1-888-GET-EZGO (1-888-438-3946) FAX: 1-800-752-6175

International:

PHONE: 001-706-798-4311 FAX: 001-706-771-4609

OWNER’S GUIDE

72 VOLT ELECTRIC POWERED VEHICLE

TERRAIN 1000 72V

TERRAIN 1000 72V CE

STARTING MODEL YEAR 2014

CALIFORNIA Proposition 65 Warning

WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known

to the State of California to cause cancer and brith defects or other reproductive harm. In addition, certain fluids

contained in vehicles and certain products of component wear contain or emit chemicals known to the State of

California to cause cancer and birth defects or other reproductive harm.

FORWARD

ii Owner’s Guide

This vehicle has been designed and manufactured in the United States of America (USA).

The Standards and Specifications listed in the following text originate in the USA unless oth-

erwise indicated.

The use of non-Original Equipment Manufacturer (OEM) approved parts may void the

warranty.

Failure to properly maintain batteries may void the warranty. Refer to the battery manaul for

instructions on the proper maintenance and care of the batteries.

BATTERY PROLONGED STORAGE

Batteries self-discharge over time. The rate of self-discharge varies depending on the ambi-

ent temperature, the age and condition of the batteries.

Fully charged batteries will not freeze in winter temperatures unless the temperature falls

below -75°F (- 60°C).

For winter storage, the batteries must be clean, fully charged and disconnected from any

source of electrical drain.

The battery charger may be left connected to the vehicle to maintain a full charge on the bat-

teries, provided the charger is plugged into an active electrical source. If power to the elec-

trical source is disconnected or interrupted, the battery charger will continue to check the

charge on the battery pack. This will draw power from the battery pack and eventually drain

the batteries if power is not restored in a timely manner.

As with all electric vehicles, the batteries must be checked and recharged as required or at a

minimum of 30 day intervals.

Check and maintain the proper fluid level in all battery cells during the storage period.

Proper fluid level is required for maximum battery performance.

BATTERY DISPOSAL

Lead-acid batteries are recyclable. Return whole scrap batteries to distributor, manufacturer

or lead smelter for recycling. For neutralized spills, place residue in acid-resistant contain-

ers with absorbent material, sand or earth and dispose of in accordance with local, state and

federal regulations for acid and lead compounds. Contact local and/or state environmental

officials regarding disposal information.

FORWARD

ii Owner’s Guide

This vehicle has been designed and manufactured in the United States of America (USA).

The Standards and Specifications listed in the following text originate in the USA unless oth-

erwise indicated.

The use of non-Original Equipment Manufacturer (OEM) approved parts may void the

warranty.

Failure to properly maintain batteries may void the warranty. Refer to the battery manaul for

instructions on the proper maintenance and care of the batteries.

BATTERY PROLONGED STORAGE

Batteries self-discharge over time. The rate of self-discharge varies depending on the ambi-

ent temperature, the age and condition of the batteries.

Fully charged batteries will not freeze in winter temperatures unless the temperature falls

below -75°F (- 60°C).

For winter storage, the batteries must be clean, fully charged and disconnected from any

source of electrical drain.

The battery charger may be left connected to the vehicle to maintain a full charge on the bat-

teries, provided the charger is plugged into an active electrical source. If power to the elec-

trical source is disconnected or interrupted, the battery charger will continue to check the

charge on the battery pack. This will draw power from the battery pack and eventually drain

the batteries if power is not restored in a timely manner.

As with all electric vehicles, the batteries must be checked and recharged as required or at a

minimum of 30 day intervals.

Check and maintain the proper fluid level in all battery cells during the storage period.

Proper fluid level is required for maximum battery performance.

BATTERY DISPOSAL

Lead-acid batteries are recyclable. Return whole scrap batteries to distributor, manufacturer

or lead smelter for recycling. For neutralized spills, place residue in acid-resistant contain-

ers with absorbent material, sand or earth and dispose of in accordance with local, state and

federal regulations for acid and lead compounds. Contact local and/or state environmental

officials regarding disposal information.

TABLE OF CONTENTS

iii

Owner’s Guide

SAFETY

GENERAL ......................................................................................................................... 1

NOTICES, CAUTIONS, WARNINGS, AND DANGERS ................................................... 1

GENERAL OPERATION................................................................................................... 3

MAINTENANCE ................................................................................................................ 4

LABELS AND PICTOGRAMS........................................................................................... 5

LABELS AND PICTOGRAMS........................................................................................... 6

GENERAL SPECIFICATIONS

VEHICLE DIMENSIONS ................................................................................................. 10

TURNING DIAMETER AND INCLINE INFORMATION .................................................. 11

INTRODUCTION

FEATURES ..................................................................................................................... 13

General Information ........................................................................................... 13

Steering Wheel ................................................................................................... 13

Brake Pedal........................................................................................................ 13

Park Brake ......................................................................................................... 13

Horn ................................................................................................................... 13

Turn Signal (If Equipped) ................................................................................... 13

Accelerator Pedal............................................................................................... 13

Key / Light Switch............................................................................................... 13

State of Charge Meter........................................................................................ 13

Direction Selector............................................................................................... 14

Fuse Block ......................................................................................................... 14

Charger Receptacle (If Equipped)...................................................................... 14

AC Outlet............................................................................................................ 14

Hour Meter (If Equipped).................................................................................... 15

Run - Tow/Maintenance/Storage Switch ............................................................ 15

Seat and Seat Lock............................................................................................ 15

Hip Restraints..................................................................................................... 15

Cup Holder ......................................................................................................... 15

Glove Box Compartments with Optional Doors.................................................. 15

Ash Tray (If Equipped) ....................................................................................... 15

Load Bed............................................................................................................ 15

Manual Bed Lift Handle...................................................................................... 16

Electric Bed Lift Switch....................................................................................... 16

TABLE OF CONTENTS

Owner’s Guide

12 Volt Outlet ...................................................................................................... 16

Weather Enclosure (If Equipped)........................................................................ 16

OPERATING PROCEDURES

BEFORE INITIAL USE..................................................................................................... 19

Recommended Tire Pressures ...........................................................................20

CHARGER ....................................................................................................................... 20

On Board Charger ...............................................................................................20

OPERATING THE VEHICLE ........................................................................................... 21

Brake / Park Brake Pedal Operation ..................................................................22

Accelerator Pedal Operation ...............................................................................22

Key / Light Switch Operation ...............................................................................22

Direction Selector Operation ...............................................................................22

Run - Tow/Maintenance Switch Operation .........................................................23

Load Bed .............................................................................................................24

Manual Lift Operation ..........................................................................................24

Electric Lift Operation ..........................................................................................24

Performance .......................................................................................................25

Speed Control .....................................................................................................25

Pedal-Up Braking ................................................................................................25

Terrain .................................................................................................................25

Walk-Away Feature .............................................................................................26

Anti-Roll Back Feature ........................................................................................26

Anti-Stall Feature ................................................................................................26

High Pedal Disable Feature ................................................................................26

Diagnostic Mode Feature ....................................................................................26

STARTING AND DRIVING .............................................................................................. 26

Starting Vehicle On A Hill ....................................................................................27

Coasting ..............................................................................................................27

LABELS AND PICTOGRAMS.......................................................................................... 27

SUN TOP AND WINDSHIELD (IF EQUIPPED)............................................................... 28

MAINTENANCE

SERIAL NUMBER LOCATION ........................................................................................ 31

VEHICLE CLEANING AND CARE................................................................................... 32

COMMON SENSE OPERATION..................................................................................... 32

ENVIRONMENTAL CONCERNS .................................................................................... 33

TABLE OF CONTENTS

Owner’s Guide

Battery Disposal ................................................................................................. 33

LIFTING THE VEHICLE.................................................................................................. 33

WHEELS AND TIRES..................................................................................................... 34

Tire Repair ......................................................................................................... 34

Wheel Installation ............................................................................................... 35

LIGHT BULB REPLACEMENT ....................................................................................... 35

Headlight ........................................................................................................... 36

Taillight ............................................................................................................... 36

FUSE REPLACEMENT................................................................................................... 36

TRANSPORTING VEHICLE ........................................................................................... 37

Towing ................................................................................................................ 37

Hauling ............................................................................................................... 37

SERVICE AND MAINTENANCE..................................................................................... 37

ROUTINE MAINTENANCE............................................................................................. 38

TIRE INSPECTION ......................................................................................................... 39

BRAKES ......................................................................................................................... 39

Periodic Brake Test ............................................................................................ 39

SYSTEM TEST ............................................................................................................... 39

REAR AXLE .................................................................................................................... 40

Checking the Lubricant Level ............................................................................. 40

LUBRICATION ................................................................................................................ 40

CAPACITIES AND REPLACEMENT PARTS ................................................................. 40

HARDWARE ................................................................................................................... 41

BATTERY CHARGING AND MAINTENANCE ............................................................... 41

Safety ................................................................................................................. 41

Battery Disposal ................................................................................................. 42

Battery ................................................................................................................ 42

Battery Maintenance .......................................................................................... 42

At Each Charging Cycle ..................................................................................... 43

Monthly ............................................................................................................... 43

Electrolyte Level and Water ............................................................................... 43

Battery Cleaning ................................................................................................. 45

Battery Replacement .......................................................................................... 46

Prolonged Storage ............................................................................................. 46

Battery Charging ................................................................................................ 47

AC Voltage ......................................................................................................... 48

TABLE OF CONTENTS

Owner’s Guide

Troubleshooting ..................................................................................................48

Hydrometer .........................................................................................................48

PERIODIC SERVICE SCHEDULE

PERIODIC SERVICE SCHEDULE .................................................................................. 51

APPENDIX A

DELTA-Q USER’S GUIDE................................................................................................ A

APPENDIX B

DECLARATION OF CONFORMITY ................................................................................. E

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Owner’s Guide

SAFETY

GENERAL

For any questions on material contained in this manual, contact an authorized representative for clarification.

Read all labels located on the vehicle. Always replace any damaged or missing labels.

On steep hills it is possible for vehicles to coast at greater speeds. To prevent loss of vehicle control and possible serious

injury, speeds should be limited to no more than the maximum speed on level ground. See GENERAL SPECIFICA-

TIONS. Limit speed by applying the service brake.

Catastrophic damage to the drivetrain components due to excessive speed may result from driving the vehicle above

specified speed. Damage caused by excessive speed may cause a loss of vehicle control, is costly, is considered abuse

and will not be covered under warranty.

Use extra caution when towing the vehicle(s). Do not tow a single vehicle at speeds in excess of 12 mph (19 kph). Do not

tow more than three vehicles at a time. Do not exceed 5 mph (8 kph) while towing multiple vehicles. Towing the vehicle at

above the recommended speed may result in personal injury and/or damage to the vehicle and other property.

If the vehicle is to be used in a commercial environment, signs similar to the ones illustrated should be used to warn of

situations that could result in an unsafe condition.

NOTICES, CAUTIONS, WARNINGS, AND DANGERS

Throughout this guide NOTICE, CAUTION, WARNING, and DANGER will be used. Please observe these NOTICES,

CAUTIONS, WARNINGS, and DANGERS; be aware that servicing a vehicle requires mechanical skill and a regard for

conditions that could be hazardous. Improper service or repair may damage the vehicle or render it unsafe.

Address practices not related to personal injury.

Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.

Indicates a hazardous situation which, if not avoided, could result in death or serious injury.

Indicates a hazardous situation which, if not avoided, will result in death or serious injury.

2Owner’s Guide

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

This manual has been designed to assist in maintaining the vehicle in accordance with procedures developed by the

manufacturer. Adherence to these procedures and troubleshooting tips will ensure the best possible service from the

product. To reduce the chance of personal injury or property damage, the following must be carefully observed:

Certain replacement parts can be used independently and/or in combination with other accessories to modify

an E-Z-GO-manufactured vehicle to permit the vehicle to operate at or in excess of 20 mph. When an E-Z-GO-

manufactured vehicle is modified in any way by the Distributor, Dealer or customer to operate at or in excess

of 20 mph, UNDER FEDERAL LAW the modified product will be a Low Speed Vehicle (LSV) subject to the

strictures and requirements of Federal Motor Vehicle Safety Standard 571.500. In these instances, pursuant to

Federal law the Distributor or Dealer MUST equip the product with headlights, rear lights, turn signals, seat

belts, top, horn and all other modifications for LSV’s mandated in FMVSS 571.500, and affix a Vehicle Identifi-

cation Number to the product in accordance with the requirements of FMVSS 571.565. Pursuant to FMVSS

571.500, and in accordance with the State laws applicable in the places of sale and use of the product, the

Distributor, Dealer or customer modifying the vehicle also will be the Final Vehicle Manufacturer for the LSV,

and required to title or register the vehicle as mandated by State law.

E-Z-GO will NOT approve Distributor, Dealer or customer modifications converting E-Z-GO products into LSVs.

The Company recommends that all E-Z-GO products sold as personal transportation vehicles BE OPERATED ONLY BY

PERSONS WITH VALID DRIVERS LICENSES, AND IN ACCORDANCE WITH APPLICABLE STATE REQUIREMENTS.

This restriction is important to the SAFE USE AND OPERATION of the product.

Information on FMVSS 571.500 can be obtained at Title 49 of the Code of Federal Regulations, section 571.500, or

through the Internet at the web site for the U.S. Department of Transportation - at Dockets and Regulation, then to Title

49 of the Code of Federal Regulations (Transportation).

All vehicles can be used for a variety of tasks beyond the original intended use of the vehicle; therefore, it is impossible to

anticipate and warn against every possible combination of circumstances that may occur. No warning can replace good

common sense and prudent driving practices.

Good common sense and prudent driving practices do more to prevent accidents and injury than all of the warnings and

instructions combined. E-Z-GO strongly suggests that all users and maintenance personnel read this entire manual pay-

ing particular attention to the CAUTIONS, WARNINGS and DANGERS contained therein.

If you have any questions regarding this vehicle, contact your E-Z-GO/CUSHMAN dealer or write to the address on the

back cover of this publication, Attention: Customer Care Department.

E-Z-GO reserves the right to make design changes without obligation to make these changes on units previously sold.

The information contained in this manual is subject to change without notice.

E-Z-GO IS NOT LIABLE FOR ERRORS IN THIS MANUAL. E-Z-GO IS NOT LIABLE FOR INCIDENTAL OR CONSE-

QUENTIAL DAMAGES THAT RESULT FROM THE USE OF THE MATERIAL IN THIS MANUAL.

This vehicle conforms to the current applicable standard(s) for safety and performance requirements.

These vehicles are designed and manufactured for off-road use. They DO NOT conform to Federal Motor Vehicle Safety

Standards of the United States of America (USA) and are not equipped for operation on public streets. Some communi-

ties may permit these vehicles to be operated on their streets on a limited basis and in accordance with local ordinances.

Refer to GENERAL SPECIFICATIONS for vehicle seating capacity.

Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease

its stability, or increase the speed or extend the stopping distance beyond the factory specifica-

tion. Such modifications can result in serious personal injury or death.

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Owner’s Guide

Never modify the vehicle in any way that will alter the weight distribution of the vehicle, decrease its stability, or increase

the speed or extend the stopping distance beyond the factory specification. E-Z-GO prohibits and disclaims responsibility

for all such modifications which would adversely affect the safety of the vehicle.

Vehicles that are capable of higher speeds must limit their speed to no more than the speed of other vehicles when used

in a golf course environment. Additionally, speed should be further moderated by the environmental conditions, terrain

and common sense.

Operation of the vehicle is limited to persons above the height of 59 inches (150 cm).

GENERAL OPERATION

Read the following warnings before attempting to operate the vehicle.

To prevent personal injury or death, observe the following:

When vehicle is to be left unattended, turn key to OFF position AND REMOVE KEY.

Drive vehicle only as fast as terrain and safety considerations allow. Consider the terrain

and traffic conditions. Consider environmental factors which affect the terrain and the abil-

ity to control the vehicle.

Avoid driving fast downhill. Sudden stops or change of direction may result in a loss of

control. Use brake to control speed when traveling down an incline.

Use extra care and reduced speed when driving in poor conditions or on poor surfaces.

Stay in designated areas where provided and avoid steep slopes.

Keep feet, legs, hands, and arms inside vehicle at all times.

Avoid extremely rough terrain.

Check area behind the vehicle before operating in reverse.

Make sure the direction selector is in correct position before depressing the

accelerator pedal.

Slow down before and during turns.

Always bring vehicle to a complete stop before shifting the direction selector.

See GENERAL SPECIFICATIONS for vehicle load and seating capacity.

Read the following text and warnings before attempting to service vehicle.

In any product, components may eventually fail to perform properly as the result of normal use, age, wear, or abuse.

It is impossible to anticipate all possible component failures or the manner in which each component may fail.

A vehicle requiring repair is no longer functioning as designed and therefore could be potentially hazardous. Therefore,

use extreme care when working on any vehicle. When diagnosing, removing, or replacing any components that are not

operating correctly, take time to consider the safety of yourself and others around you.

Some components are heavy, spring-loaded, highly corrosive, explosive, may produce high amperage, or reach high

temperatures. Exposure to battery acid and hydrogen gas could result in serious bodily injury. Be careful to protect

hands, face, feet, and body from injury.

Always use the appropriate tools listed in the tool list and wear approved safety equipment.

4Owner’s Guide

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Before working on the vehicle, remove all jewelry.

Be sure no loose clothing or hair can contact moving parts.

Use care not to touch hot objects.

Wear eye protection when working on or around the vehicle. In particular, use care when working

around batteries, using solvents or compressed air.

ALWAYS:

• Use the vehicle in a responsible manner and maintain the vehicle in safe operating condition.

• Read and observe all warnings and operation instruction labels affixed to the vehicle.

• Follow all safety rules established in the area where the vehicle is being operated.

• Leave the vehicle and seek shelter when there is a risk of lightning.

• Reduce speed to compensate for poor terrain or conditions.

• Apply service brake to control speed on steep grades.

• Maintain adequate distance between vehicles.

• Reduce speed in wet areas.

• Use extreme caution when approaching sharp or blind turns.

• Use extreme caution when driving over loose terrain.

• Use extreme caution in areas where pedestrians are present.

MAINTENANCE

ALWAYS:

• Replace damaged or missing warning, caution or information labels.

• Maintain the vehicle in accordance with the manufacturer’s periodic service schedule.

• Ensure that repairs are performed by trained and qualified personnel.

• Follow the manufacturer’s maintenance procedures.

• Insulate any tools used within the battery area in order to prevent sparks or battery explosion.

• Use specified replacement parts, NEVER use replacement parts of lesser quality.

• Use recommended tools.

• Determine that tools and procedures not specifically recommended by the manufacturer will not compromise the

safety of personnel nor jeopardize the safe operation of the vehicle.

• Support the vehicle using wheel chocks and jack stands. NEVER get under a vehicle that is supported by a jack. Lift

the vehicle in accordance with the manufacturer’s instructions.

• Maintain the vehicle in an area away from exposed flame or persons who are smoking.

• Be aware that a vehicle that is not performing as designed is a potential hazard and must not be operated.

• Test drive the vehicle after any repairs or maintenance in a safe area that is free of both vehicular and pedestrian

traffic.

• Keep complete records of the maintenance history of the vehicle.

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Owner’s Guide

LABELS AND PICTOGRAMS

28203-G01

634229

< 14° 25%

MIN 150

R F

634229

35493G01

28203G01

28203-G01

35493-G01

On Battery Under Seat

AUTHORIZED REPRESENTATIVE IN EC IS:

RANSOMES JACOBSEN LTD.

WEST ROAD, IPSWICH,

SUFFOLK, IP3 9TT, UK 614068

614068

READ MANUAL

OPERATE ACCORDING

TO LOCAL LAWS AND

REGULATIONS

WARNING

USE CAUTION IN BAD

WEATHER

DO NOT DISPOSE OF

BATTERIES IN LANDFILL

NEGATIVE GROUND

BATTERY

DO NOT CONNECT

POSITIVE BATTERY

TERMINAL TO GROUND

SHORTING BATTERY

TERMINALS MAY

CAUSE EXPLOSION

WARNING

DO NOT DRIVE ON

HIGHWAY

DO NOT OPERATE IF

USING DRUGS OR

ALCHOHOL

LEAVE VEHICLE WHEN

LIGHTNING IS IN AREA

WARNING

MAXIMUM CROSS HILL

OR RAMP ANGLE

WARNING

READ MANUAL FOR MAX

LOAD BED CAPACITY AND

INCLINE ANGLE

MINIMUM HEIGHT TO

OPERATE VEHICLE

OPERATE FROM

DRIVER SIDE ONLY

KEEP ARMS AND LEGS

WITHIN VEHICLE

GASOLINE

VEHICLES

FORWARD OPERATION:

- TURN KEY TO ‘ON’

- MOVE DIRECTION

SELECTOR TO ‘F’

- PRESS ACCELERATOR

PEDAL GENTLY

REVERSE OPERATION:

- TURN KEY TO ‘ON’

- MOVE DIRECTION

SELECTOR TO ‘R’

- PRESS ACCELERATOR

PEDAL GENTLY

PARK VEHICLE:

- MOVE DIRECTION

SELECTOR TO ‘F’

- TURN KEY TO ‘OFF’

- APPLY PARK

BRAKE

ELECTRIC

VEHICLES

FORWARD OPERATION:

- TURN KEY TO ‘F’

- PRESS ACCELERATOR

PEDAL GENTLY

REVERSE OPERATION:

- TURN KEY TO ‘R’

- PRESS ACCELERATOR

PEDAL GENTLY

PARK VEHICLE:

- TURN KEY TO ‘OFF’

6Owner’s Guide

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

LABELS AND PICTOGRAMS

MAX

600 lbs.

272 kg

MAX

5 in.

12 cm MAX

14o / 25%

35980G03

634221

WARNING

Keep entire body

inside car.

27653G01

WARNING

Windshi e l ds d o not

provide protection

from golf balls or

other flying objects.

EGWHL14

71419G01

71415G01

71417G01

74099G01

634221

75696G01

WARNING

LETHAL

VOLTAGE

WARNING

EXPLOSIVE

WARNING

CORROSIVE

READ MANUAL

WARNING

DANGER OF

EXPLOSION

DO NOT FILL GAS

IN LOAD BED

SECURE LOAD AS

FAR FORWARD AS

POSSIBLE

MAX LOAD BED

CAPACITY

LOAD WITH HIGH

CENTER OF

GRAVITY COULD

RESULT IN TIP

OVER

LOAD CENTER

OF GRAVITY

MAX HEIGHT

MAX CROSS

HILL/RAMP

ANGLE

DO NOT RIDE

IN LOAD BED

KEEP HANDS & FINGERS

AWAY FROM DUMP BED

DO NOT STAND BEHIND

DUMP BED

75696G01

HOT

MOTOR

Owner’s Guide

Notes:

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

SAFETY

8Owner’s Guide

SAFETY

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Notes:

GENERAL SPECIFICATIONS

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Owner’s Guide

GENERAL SPECIFICATIONS

MODEL: TERRAIN 1000 72V

TYPE: ELECTRIC 72V POWERED TRUCK

MODEL YEAR: 2014

Part No:. 638709

zzSolid State continuously variable AC speed controller

Full torque, reduced speed reverse

zSeatwrap mounted direction selector switch (Forward-Neutral-Reverse)

Inductive throttle sensor

Anti-roll back, walkaway braking and alarm (only with key in on position)

Diagnostic indicator

zAnti-stall motor protection

Factory programmable to application

zRegenerative ’Pedal Down’ and/or ‘Pedal Up’ braking

Battery Charger: 900 Watt, 72 VDC, 120/230 VAC 50/60 Hz. Underwriters Laboratories (U.L.) Listed, (C.S.A. Certified)

Motor: 72 Volt AC Induction, solid copper windings. Non vented 22.4 hp (16.7 kW) Peak

Drive Train: Direct motor shaft connected to transaxle pinion shaft

Electrical System: 72 Volt DC, nine, 8 volt deep cycle storage batteries (78 minutes @ 75 Amps, 170 amp-hour @ 20 hr. discharge rate)

Transaxle: Differential with helical gears

Brakes:

Dual rear wheel mechanical self-adjusting drum brakes. Automatic single point park brake release with self-compensating system

Cargo Bed: Roto-molded cross-linked polyethelene. Lifts for access to powertrain. Removable hinged multi-position tailgate requires no latch mechanism

Performance

Overall Length 111 in (281 cm) Seating Capacity 2 Person

Overall Width 49.8 in (126 cm) Dry Weight 873 lb (396 kg) (Without Batteries)

Overall Height (No Canopy)

52.0 in (132 cm) (Top of steering wheel)

Curb Weight 1440 lb (653 kg)

Overall Height (With Canopy) 77.0 in (196 cm) Bed Load Capacity 500 lb (227 kg)

Wheel Base

78.0 in (198 cm) Vehicle Load Capacity 900 lb (408 kg)

Front Wheel Track 38.0 in (97 cm) Outside Clearance Circle 24.0 ft (7.3 m)

Rear Wheel Track 38.8 in (99 cm)

Intersecting Aisle Clearance

N/A

Ground Clearance (at Differential) 7.0 in (18 cm) Speed (Level Ground) 16 mph ± 0.5 mph (26 kph ± 0.8 kph)

Cargo Box Width (inside) 44.0 in (112 cm) Towing Capacity 930 lb (4137 N) Max Drawbar

Cargo Box Length (inside) 36.0 in (91 cm) Steering & Suspension

Cargo Box Depth (inside) 10.5 in (27 cm) Steering Self-compensating rack and pinion

Cargo Box Capacity 9.6 cu ft (0.27 m3) Front Suspension

Leaf springs with hydraulic shock absorbers

Cargo Box material Roto-molded polyethylene

Rear Suspension

Leaf springs with hydraulic shock absorbers

Vehicle Power Service Brake Rear wheel mechanical self-adjusting drum

Power Source 72 Volts DC Parking Brake Self-compensating, single point engagement

Motor Type

AC Induction

Front Tires 22 x 9 - 10 (4 Ply Rated)

Horsepower (kW) 22.4 hp (16.7 kW) Peak Rear Tires 22 x 9 - 10 (4 Ply Rated)

Electrical System

72 Volt

Body & Chassis

Batteries (Qty, Type) Nine, 8 Volt Deep Cycle Frame Welded steel. DuraShield™ powder coat

Key or Pedal Start Pedal Start Front Body & Finish

Injection Molded TPO

Battery Charger 900 Watt, 72VDC Standard Color Hunter Green

Speed Controller

350 Amp AC

Noise & Vibration

Drive Train Motor Shaft Direct Drive Noise Sound pressure; continued A-weighted ≤ 70 db(A)

Transaxle Differential with helical gears Vibration, WBV Highest RMS value of weighted acceleration is less than 2.5 m/s

Gear Selection

Seatwrap Mounted Forward-Neutral-Reverse

Vibration, HAV Highest RMS value of weighted acceleration is less than 2.5 m/s

Rear Axle Ratio 17:1 The uncertainty of measurement is 0.12 m/s

Measurement methods were applied per the ISO 2631 and ISO 5349

Some items shown may be optional equipment standards under conditions of typical vehicle surfaces.

PRODUCT OVERVIEW

CONFIGURATION HIGHLIGHTS

PRODUCT SPECIFICATION

Dimensions

10 Owner’s Guide

GENERAL SPECIFICATIONS

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

VEHICLE DIMENSIONS

36.0 in (91.0 cm)

49.8 in

(126.0 cm)

10.5 in

(27.0 cm)

75.3 in (191.3 cm)

111.0 in (281.0 cm)

(Rear)

38.8 in (98.6 cm)

(Front)

37.0 in (94.0 cm)

52.0 in

(132.0 cm)

GENERAL SPECIFICATIONS

Read all of SAFETY and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.

Owner’s Guide

TURNING DIAMETER AND INCLINE INFORMATION

TURNING CLEARANCE DIA.

Approx. 24.0 ft (7.3 m)

RECOMMENDED MAX RAMP GRADE

25% or 14o MAX

RECOMMENDED MAX SIDE TILT

25% or 14o MAX

Page is loading ...

E-Z-GO 2014 TERRAIN 1000 72V CE Owner's manual

Brand: E-Z-GO

Model: 2014 TERRAIN 1000 72V CE

Category: Utility Vehicle

Type: Owner's manual

This manual is also suitable for

Download PDF

report

E-Z-GO 2014 TERRAIN 1000 72V CE Owner's manual

This manual is also suitable for

E-Z-GO 2014 TERRAIN 1000 72V CE Owner's manual

Related papers

Other documents