Coyote C1DBNG Owner's manual

Brand: Coyote

Model: C1DBNG

Category: Barbecues & grills

Type: Owner's manual

This manual is also suitable for



ForOutdoor UseOnly



IMPORTANT:ReadthelightinginstructiononPage13beforefirsttimeuse!

Toinstallerorpersonassembling:Leavethismanualwithburnerforfuturereference.

Toconsumer:Keepthismanualforfuturereference.

COYOTEOUTDOORLIVI NG,INC.

www.coyoteoutdoor.com

CoyoteStainlessSteelSideBurner

Use&CareManual

ForLiquidPropaneandNaturalGasModels

C1DB (LP/NG) C1SB (LP/NG)

Coyote Dual (Slide in) Side Burner Coyote Single (Slide in) Side Burner

Conforms to ANSI STD Z21.58-2015

Certified to CSA STD 1.6-2015

Outdoor Cooking Gas Appliance

4004477

PUT SERIES NO. LABEL HERE

Welcome&Congratulations

Congratulationsonyour purchaseofanewsideburner!Weareveryproudofourproductsandwe

arecompletelycommittedtoprovidingyouwith thebestservicepossible.Yoursatisfactionisour#1

priority.



Pleasereadthismanualcarefullytounderstandalltheinst ruction sabouthowtoinstall,operateand

maintainforoptimumperfo rmanceandlong ev ity. 

Weknowyou’ll enjoyyournew sideburnerand thankyoufor choosingourproduct.We hope you

considerusforfuturepurchases.



Pleasereadandsavetheinstru ctions

ThisManualprovidesspecificoperatinginstructionsforyourmodel.Useyoursideburneronlyas 

instructedinthismanual.Theseinstructionsarenotmeanttocovereverypossibleconditionand

situationthatmayoccur.Commonsenseandcautionmustbepracticedwheninstalling, operating

andmaintaininganyappliance.



TableofContents

SafetyInstru ctions...........................2

LocatingtheSideburner....................4

GasRequirements..............................6

LightingtheSideBurner...................12

OperationandFeatures.....................14

Care&Maintenance..........................15

TroubleshootingYourBurner............19

LimitedWarranty..............................21

PartsListings......................................22



SafetySymbols



• WARNING

IFYOUSMELLGAS:

1. Shutoffgastotheappliance.

2. Extinguishanyopenflame.

3. OpenLid.

4. Ifodorcontinues,keepawayfromthe

applianceandimmediatelycallyourgassupplier

oryourfiredepartment.



• WARNING

WARNING:

1. DO NOT store or use gasoline or other

flammable liquids or vapors in the vicinity of

thisoranyotherappliance.

2.AnLPcylindernotconnectedforuseshallnot

be stored in the vicinity of this or any other

appliance.

• WARNING

DANGER indicates an imminently

hazardoussituationwhich,ifnotavoided,

willresultindeathorseriousinjury.

• CAUTION

CAUTION indicates a potentially

hazardoussituationwhich,ifnotavoided,

mayresultinminorormoderatepersonal

injury,orpropertydamage.

• WARNING

FOROUTDOORUSEONLY:

NEVERoperatesideburnerinenclosedareas,as

thiscouldleadtogasaccumulatingfromaleak,

causing an explosion or a carbon monoxide

buildup which could result in injury or death.

DO NOT use your side burner in garages,

breezeways, sheds or any enclosed area. NOT

FORUSEBY

CHILDREN.Iftheseinstructions are

ignored, a hazardous fire or explosion could

result in physical injury, death or property

damage!

• WARNING

WARNING indicates a potentially

hazardoussituationwhich,ifnotavoided,

couldresultindeathorseriousinjury.



WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or

property damage. Read the installation, operating and maintenance instructions thoroughly before

installingorservicingthisequipment.

GeneralSafetyInstructions

1. For Household Outdoor Use Only –DONOTuseindoors or in any type of enclosed area suchasagarage,

shedorbreezeway.Keepclearoftreesandshrubs.Thesideburnersarenotintendedforinstallationinor

onrecreationalvehicles,portabletrailers,boatsoranyothermovinginstallation.Notforcommercialuse.

2. Theareasurroundingyournewsideburnershouldbekeptcleanandfreefromflammableliquidsandother

combustiblematerialssuchasmops,ragsorbrooms,aswellassolvents,cleaningfluids,andgasoline.

3. To reduce the risk of serious or fatal injury from breathing toxic fumes and from explosion and fire as a

resultofleakinggas,useonlyoutdoorsinanopenareawithgoodventilation.Donotobstructtheflowof

combustionandventilationair.

4. Never use the side burner in windy conditions. If located in a consistently windy area (oceanfront,

mountaintop,etc.)awindbreakwillberequired.Alwaysadheretothespecifiedclearanceslisted.

5. Donotleavethesideburnerunattendedwhilecooking.

6. Donotusenaturalgasinaunitdesignedforliquidpropanegasorviceversa.

7. Donotusefuelsuchascharcoalbriquettesonthesideburner.

8. Keepchildrenandpetsawayfromhotburner.DONOTallowchildrentouseorplaynearthesideburner.

9. Neverattempttorepairorreplaceanypartofthesideburneryourselfunlessspecificallyrecommendedin

thismanual.Allotherservicesshouldbeperformedbyaqualifiedservicetechnician.

10. Never lean over an open side burner. Do not place clothing or other flammable material on or near the

burner.Donotwearloose‐fittingclothesorlongsleeveswhileusingthesideburnerassomefabricscanbe

highlyflammable.

11. Have an ABC fire extinguisher accessible. Never attempt to extinguish a grease fire with water or other

liquids.

12. Neverusealuminumfoilontheburnergrids,thiscanalterairflowforpropercombustionandalsobuildup

heatinthecontrolareacausingtheknobsandignitertomelt.

13. When using the side burner, do not touch the burner grid or immediate surroundings as these areas

becomeextremelyhotandcancauseburns.

14. DONOTallowgreaseorotherhotmaterialdrippingfromtheburnerontovalve,hoseorregulator,turnoff

gassupplyimmediately. Afterthesideburnerhascooled,determinethecauseandcorrectit.Aftercleaning

thevalve,hoseandregulator,performaleaktestbeforecontinuinguse.

15. Donotheatanyunopened glassormetalcontaineroffoodonthesideburner.Pressuremaybuildupand

causethecontainertoburst,possiblyresultinginseriouspersonalinjuryordamagetothesideburner.

16. Keep any electrical supply cords away from water or heated surfaces. Electrical cords should be placed

awayfromwalkwaystoavoidtrippinghazard.

17. Keepgassupplylinesasshortaspossible.

18. Nevermovethesideburnerwhenhot.

19. DONOTusewhileundertheinfluenceofdrugsoralcohol.

20. DONOTstoreasparegascylinderunderornearyoursideburner.

Safety Instructions

21. Greaseisextremelyflammable.Lethotgreasecooldownbeforeattemptingtohandleordisposeofit.

22. Intheeventthataburnergoesout,turn burnerknobstothefullOFFposition.Donotattempttousethe

sideburneruntilthegashashadtimetodissipate.

23. Donotusesideburneruntilleakcheckhasbeenmade.

24. Turnoffthecylindervalvewhenyoursideburnerisnotinuse.

25. Ensurethecontrolknobsarein“OFF”positionwhennotinuse.



CALIFORNIAPROPOSITION65‐WARNING:Theburningofgascookingfuelsgeneratessomebyproductswhich

areonthelist of substances which areknown bytheStateof Californiatocausecancer or reproductive harm.

California law requires businesses to warn customers of potential exposure to such substances. To minimize

exposure to these substances, always operate this unit according to the Use and Care Manual, ensuring you

providegoodventilationwhencookingwithgas.



Check your local building codes for the proper method of installation. In the absence of local codes, this unit

shouldbeinstalledinaccordancewiththeNationalFuelGasCodeNo.Z223.1‐1998USAorCAN/CGA‐B149.1/.2

Natural Gas/Propane Code (Canada) latest edition or the National Electrical Code ANSI/NFPA No. 70 or the

CanadianElectricalCodeCSAC22.1,1990orlatestversion.



- Beforeinstalling the side burner inenclosures, copy all productinformation such asmodel number,serial

numberandtypeofsideburner(e.g.naturalgasorLP)andstoreinformationinasafeplace.

- Ifthesideburnerisinstalled

byaprofessionalinstallerortechnician, besurethatheshowsyouwhereyour

gassupplyshut‐offislocated.Allgaslinesmusthavea shut‐off thatisreadilyand easily accessible.Ifyou

smellgas,checkforgasleaksimmediately.Checkonlywithasoapandwatersolution.Nevercheckforgas

leakswithanopenflame.

Notice: Westronglyrecommend professionalinstallationandhookupofthegasside burner.Theseinstructions

will provide you with the measurements necessary for you or your builder to construct a masonry structure to

houseyouroutdoorgassideburner.

IMPORTANT:Gasfittings,regulator,andinstal ler suppliedshut‐offvalvesmustbeeasilyaccessible.

LOCATIONOFYOURSIDEBURNER:

Locate the side burner only in a well ventilated area. Never locate the side burner in a building, garage,

breezeway, shed or other such enclosed areas without an approved  ventilation system. During heavy use, the

sideburnerwillproducealotofsmoke.Ensurethereisadequateareaforittodissipate.



WindandyourSideburner:

Wind is a huge factor on a gas side burner’s performance. If the grill is located in a windy location (hillside,

oceanside, patio with constant breeze, etc) then a wind break will be required for proper combustion and

cookingtooccur.

o If your only option is to have the side burner in a windy location, build a back splash on your

islandatleast6”talltoassistinwinddiversion.

o If you have a cart model and are facing a wind problem, point the back with the direction of the

wind,sothatthegasstillflowsoutofthevalvesandintotheburners.

Clearance

- TO NON‐COMBUSTIBLE CONSTRUCTION:Aminimumof8.5" (217mm) clearancefromthebackof the side

burner is recommended. It is desirable to allow at least 2"(50.8mm) side clearance to non‐combustible

constructionabovethecookingsurfaceforcounterspace.Thesideburnercanbeplaceddirectlyadjacent

tonon‐combustibleconstructionbelowthecookingsurface.Thesideburnerexhaustscombustionproducts

andcookinggreasestotheback.Neverlocatethesideburnerwherethisexhaustwillbedifficulttoclean.



- CLEARANCE TO COMBUSTIBLE CONSTRUCTION: A Minimum of 24" (609.6mm) from the sides and a

minimumof24"(609.6mm)fromthebackmustbemaintainedfromthesideburneraboveandbelowthe

cookingsurfacetoadjacentverticalcombustibleconstruction.

Locating the Side Burner



Thetwotopillustrationsdemonstratehowtheslide‐intypeunitisdesignedtofitintoopen‐frontenclosures,and

supportedattheCountertop.



Do not install this unit under unprotected flammable surfaces. Do not install or use this appliance

insideabuilding,garage,oranyothercoveredarea.Itmustnotbeusedinoronrecreationalvehicles

orboats.



INSTALLER NOTE:This unit should be installed so thatit can be removed at a laterdateif factoryserviceis

required.Anyprotrusionintothesideburnerenclosuremaypreventtheunitfromslidingintoplace.



ENSURINGPROPERCOMBUSTIONAIRANDCOOLINGAIRFLOW



Yo u mustmaintainproperairflowforyourside burner to perform as it was designed. If airflow is blocked,

overheating andpoorcombustionwillresult.Makesurenottoblockthe 1"frontairinlet alongthebottomof

thefaceormorethan75%ofthesupportgridsurface

withpansorgriddles.



ForBuilt‐inInstallations

A side burner is designed for easy installation into masonry enclosures. For non‐c ombustible applications, the

sideburnerdropsintotheopening(asshownincut‐outdetail‐Fig.A)aboveorbelowdependingonspace,and

hangsfromitscountertoptrim.Adeckisnotrequiredtosupportitfromthebottom.

 Twoventilation holes, of atleast20 sq inches in size, mustbe present tohelp releaseany gas froma

leak.

 AsPropaneisheavierthanair,locateyourventsatthetankvalveheightorlower

 Thedeckledgesandcountershouldbeflatandlevelinreferencetothefloor.

 LPTANKSTORAGEAREAMUST BEISOLATEDFROMSIDEBURNERANDVENTED.



IMPORTANT: Before connecting side burner to gas source, make sure burner control knobs are in “OFF”

position. Verify the type of gas supply to be used, either natural or LP, and make sure the marking on the

applianceratinglabelagreeswiththatofthesupply.

AllpipesealantsmustbeanapprovedtypeandresistanttotheactionsofLPgas.Neverusepipesealantonflare

fittings.Theinstallationofthis appliance must conform withlocalcodes or, in theabsenceoflocalcodes, with 

eitherNationalFuelGasCode,ANSIZ223.1/NFPA54,NaturalGasandPropaneInstallationCode,CSAB149.1,or

Propane Storage and Handling Code, B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/ NFPA

1192M,andCSAZ240RVSeries,RecreationalVehicleCode,asapplicable.

WARNING:GasvalvesarepresetatthefactorytooperateonLPornaturalgas.Ifyouwishtoconvert,besure

tocontactyourdealerFIRST!

 WIDTH DEPTH HEIGHT

DoubleBurner

121/2”(318mm) 201/2”(521mm) 101/4”(260mm)

SingleBurner

101/2”(267mm) 14”(356mm) 101/4”(260mm)

Gas Requirements

WARNING: Never attach an unregulated gas line to the appliance. Connection to an

unregulated gas line can cause excessive heat or fire.

NOTE: Always have a qualified service technician perform difficult conversions

or modifications.



This propane gas side burner is designed to operate on propane gas ONLY, at a pressure regulated at

11”(279.4mm) water column (W.C.) when equipped with the correct propane orifices on the valves and a

propaneregulatoronthesupplylineregulatedattheresidentialmeter.TheLPgassideburnerisdesignedtobe

usedwithastandard20lbsgascylinderandmustbeconstructedandmarkedinaccordancewithspecifications

oftheUSDepartmentofTransportationforpropanegascylinders.

Always keep cylinder securely fastened in an upright position. Never connect an unregulated propane gas

cylindertothesideburner.

Donotsubjectpropanecylinderstoexcessiveheat.

CAUTION:NeverstoreaLPgascylinderinsideabuildingorinthevicinityofanygas‐burningappliance. 



Cylinder Specifications

- Any L.P. gas supply cylinder used with this appliance must be approximately 12 inches diameter and 18

inches high. The maximum fuel capacity is 80% and is approximately 20

poundsofpropane.

- The L.P. cylinder must have a shut‐off valve (see picture) terminating in a

Type1L.P.

AType 1compatiblecylinderwith aType1cylindervalvehasa  back‐check

valve which does not permit gas flow, until  a positive seal has been

obtained.

- Thecylindermustbearrangedfor vapor withdrawal. It mustalsoincludea

collar to protect the cylinder valve. A safety

relief device having direct

communicationwiththevaporspaceofcylindermustbeprovided.Thiswill

expel high pressure gas if the cylinder is overfilled or overheated which

couldresultinfireorexplosion.

- All L.P. gas cylinders used with this appliance shall be constructed and marked in accordance with

the

specifications for L.P. gas cylinders of the U. S. Department of Transportation (DOT) or the National

StandardofCanada,CAN/CSA‐B339,Cylinders,SpheresandTubesforTransportationofDangerousGoods;

andCommission,asapplicable;andshallbeprovidedwithalistedoverfillingpreventiondevice.

- ReadlabelsontheL.P.

GasSupplyCylinder.

- Newcylindersarealwaysshippedemptyforsafety.

- AllowonlyqualifiedL.P.gasdealerstofillorrepairyourL.P.gassupplycylinder.

- Informthegasdealerifitisaneworusedcylindertobefilled.

- Afterfilling,havethegasdealercheck

forleaksandtoseethatthereliefvalveremainsfreetofunction.



LP Gas Hook-up

HoseandRegulator

TheType1connectionsystemhasthefollowingfeatures:

- The system will not allow gas to flow until a positive connection has

beenmade.

NOTE: The cylinder control valve must be turned off before any

connectionismadeorremoved.

- The system has a thermal element that will shut off

 the flow of gas in

theeventofafire.

- Thesystemhasaflowlimitingdevicewhich,whenactivated,willlimittheflowofgasto10cubicfeetper

hour.

- NEVERusesideburnerwithoutleaktestingthisconnection.



LP(Propane)GasSupplyConnection

1. The tank valve should be in the “OFF” position. If not, turn the knob

clockwiseuntilitstops.

2. Makesureallburnervalvesareinthe“OFF”position.

3. Alwaysconnectthegassupplyregulatorasfollows:

Insert the regulator inlet into the tank valve and turn the coupling nut

clockwiseuntilthecouplertightensup(seepicture).Donotovertightenthe

coupler.Turn themaintankvalveonandturntheburnercontrolvalveson

the unit to the “HIGH” position for about  20 seconds to allow the air in  the system to purge before

attemptingtolighttheburners.



PRE‐OPERATIONLEAKTESTING

DANGER

1. Donotinsertanytoolintothevalveoutletorsafetyreliefvalve.Youmaydamagethevalveandcausea

leak.Leakingpropanemayresultinexplosion,fire,severepersonalinjury,ordeath.

2. Ifaleakisdetectedatanytimeoryoucannotstopagasleak,

immediatelyclosepipelinevalveandcallLP

gassupplieroryoufiredepartment!

3. Checkallgassupplyfittingsbeforeeachuseandeachtimethegassupplycylinderisconnectedtothe

regulator.Haveaqualifiedservicetechnicianleaktestthesideburneranytimeapartofthe

sideburner

systemisreplaced.

WARNING

Neverattempttoattachthissideburnertotheself‐containedLPgassystem.Donotusesideburneruntilleak

testing.

WARNING: Always take a leak test before lighting the side burner to prevent a possible fire or

explosion. Never store a spare propane cylinder in the vicinity of this side burner, or in the vicinity of

other

otential heat source.

BeforeTesting

DONOTsmokewhileleaktesting.Extinguishallopenflames.Neverleak testwithanopenflame.Mixasolution

ofequalpartsmilddetergentorliquidsoapandwater.

LeakTestingValves,HoseandRegulator

1.TurnallsideburnercontrolknobstoOFF.

2.BesurehoseistightlyconnectedtoLPtank.

3.CompletelyopenLPtankvalvebyturningcylindervalve

knobcounterclockwise(righttoleft).Ifyouheararushing

sound, turn gas off immediately. Thereis amajor leakat

the

 connection. Correct before proceeding by calling

franchiserforreplacementparts.

4.Brush soapy solution onto areas where bubbles are

showninLPtank(seepicture).

5.If“growing” bubbles appear,thereisa leak.CloseLP

tankvalveimmediatelyandretightenconnections.Ifleads

cannotbestoppeddonottry

torepair.Callfranchiserfor

replacement.

6.AlwayscloseLPtankvalveafterperformingleaktestbyturningcylindervalveknobclockwise.



NOTE:Whenleaktestingthisappliance,makesuretotestandtightenalllooseconnections,including

thesideburner.Aslightleakinthesystemcanresultinalowflame,orahazardouscondition.

gas tanks now come equipped with a leak detector mechanism internal to the tank; when gas is allowed to

escaperapidly,it shuts off thegassupply.Aleak may significantly reduce the gasflow makingthesideburner

difficulttolightorcausinglowflames.



LPGasSupplyCylinderDisconne ctio n

1. Turntheburnervalvesoff.

2. Turnthetankvalveoff.(Turnclockwisetostop).

3. Detachtheregulatorassemblyfromthetankvalvebyturningthequickcouplingnutcounterclockwise.



LPTankRemoval,TransportandStorage

- TurnOFFallcontrolknobsandLPtankvalve.Turncouplingnutcounterclockwisebyhandonly‐donotuse

tools to disconnect. Lift LP tank wire upward off of LP tank collar, then lift LP tank up and off of support

bracket.Installsafetycaponto LPtankvalve. Always

usecapandstrap supplied withvalve.Failuretouse

safetycapasdirectedmayresultinseriouspersonalinjuryand/orpropertydamage.

- AdisconnectedLPtankinstorageorbeingtransportedmusthave

a safety cap installed (as shown). Do not store an LP tank in

enclosedspacessuch

asacarport,garage,porch,coveredpatioor

other building. Neverleave a  LP tank inside a vehicle which may

becomeoverheatedbythesun.

- DonotstoreLPtankinanareawherechildrenplay.

LPTankFilling

- Useonlylicensedandexperienceddealers. 

- LPdealermustpurgedtankbeforefilling.

- DealershouldNEVERfillLPtankmorethan80%ofLPtankvolume.Volumeofpropaneintankwillvaryby

temperature.

- A frosty regulator indicates gas overfill. Immediately close LP tank valve and call local

 LP gas dealer for

assistance.

- Donotreleaseliquidpropane(LP)gasintotheatmosphere.Thisisahazardouspractice.

- Toremovegas from LP tank,contactanLPdealerorcall alocal fire department for assistance.Check the

telephonedirectoryunder“Gascompanies”fornearestcertifiedLP

dealers.

LPTankExchange

- ExchangeyourType1cylinderwithOPDsafetyfeature‐equippedONLY.

- Alwayskeepnew and exchanged LPtanksinuprightpositionduringuse,transitorstorage.Leaktestnew

andexchangedLPtanksBEFOREconnectingtoburner.

LargeCapacityPropaneTanksandHomes:

• LP (Liquid Propane) Coyote Grills can be installed  into propane fueled houses. Meaning that if your

entirehouseisplumbedforpropaneandyouhaveanexteriorconnectionforsuchuse,thenastandard

LPsideburnerfromCoyotewillmeetyourneeds,regardlessofthesize.Anyappliancecan

beinstalledif

installedproperly!ThatistheCoyoteway!

o Coyotedoesnotsupplyanygasfittingsorlines,otherthantheregulatorneededwithinthegrill

box

o All Coyote LP Side burnerscomewitha20lbtank regulator. This regulatorcannot be used or

modifiedto

workonanyothersetup.

 If you are running off of a large capacity tank (more than 20lbs), then an “in‐line” LP

regulator is needed, Coyote Customer Service must be contacted to assist with this

situation.

o As counties vary from state to state, it is upon the owner/installer

 to ensure that all county,

stateandfederalcodesarefollowedforanygasinstallation.



- 



Always check the rating plate to make sure the gas supply you are hooking up to is the gas type the grill is

manufacturedfor.

ThisnaturalgassideburnerisdesignedtooperateonnaturalgasONLY,atapressureregulatedat4”(101.6mm)

water column (W.C.) when equipped with the correct natural gas orifices on the valves and a natural gas

regulatoronthesupplylineregulatedattheresidentialmeter.

IMPORTANT:Neverconnectthegrilltoanunregulatedgassupply.

Naturalgasconnectionsmustbeperformedbyalicensedcontractororlocalgascompanyrepresentative.



Natural Gas Hook-up

NaturalGasRegulator

IMPORTANT:NEVERusesideburnerwithoutleaktestingthisconnection.



Naturalgasregulatormodel:GR120

Gaspressure:4”(101.6mm)

Maximumrateworkingpressure:1/2Psig

NaturalGasSupply and Connection

1. Makesureallburnervalvesareinthe“OFF”position

2. AllNGunitsneedtohavearegulatorandshut‐offvalveonthesupplyline.

3. AllPipethreadsneedtohaveproper,gasrated,outdoorratedthreadsealant.Flareendsdonotneedor

utilizepipesealant.

4. YourNGCoyotesideburnercomeswitha½”regulator,alongwitha18”blackhose.

a) Youneedtosealtheregulatortothehoseusingyourpipesealant.

b) Thenattachtheflareendtoyourmanifoldline,withnopipesealant.

c) Next,attachyournextconnectionhose(notincluded)totheothersideoftheNGregulator(itisalso

½”MIP)

i. Wesuggestusing½”stainlesssteelcorrugatedhosesforallNGGrills

ii. Makesurethatyoupurchaseahoseofadequatelengthandcapacityfortheintendedapplication.

d) Connecttheotherendofthishose,toyourshutoffvalve

i. Dependingonyourchoiceofhoseandshut‐off,thenipplegoingintotheshut‐offvalvemayvary.

e) Testallconnectionsforleakswithasoapandwatersolution.

5. Ifyouarealsousingagrillonthesamesupplyline,thenyouwillneedtoaddintheappropriateteeforyour

connections.

a) YoucanutilizeoneregulatortooperatetheGrillandSideBurnerboth,aslongasitisplacedbefore

thetee.

b) Youwillalsowanttoverifyyourgaspressureisgreatenoughtooperatebothpiecesofequipment

fromthesamesupplyline.

HighElevationInstallationandUse

Coyote Side burnersare designed tooperate most efficiently at 0‐2000feet above sealevel.From 2000‐4000 feet

abovesealevelyouwillnotnoticeanysubstantialdecreas einyourheat,althoughmoregasiscombu stingwithinthe

burnersduetolessoxygen.Above4000feet,youmayexperiencealittlelongercookingtimeonyourgrillth anyou

wouldexperienceatsealeve l.Butagain, thisisjustduetotheair/fuelmixturetaking placewithintheburners.Ifany

problemsorconcernsexistaboutyourlocationorelevation,pleasecontactCoyoteCustomerServiceforassistance.



GENERALRULES

Donotleavethesideburnerunattendedwhilecooking!

- Makesuretheburnerhasbeenleaktestedandisproperlylocated.

- Lighttheburnersusingtheinstructionsprovidedinthismanual.

- Adjustheatsettingstoyourdesiredcookingtemperature.

- Allowburnerstocooldown,wipeoffanysplattersorgrease.

- Donotputacoveronthe

sideburnerwhileitisstillhotasitcouldstartafire.



NOTE:Ifforsomereason,ignitersfailtolight,burnerscanbelitwithagaslighter.



NOTE:Tolightgasburnerwithagaslighter,makesurethesideburnerhasbeenleaktestedandburnersare

properly located. Remove the cooking grid from the burner you wish to light. Insert long‐necked gas lighter

placingneartoburnerports.Pressinthecontrolknobandrotate

leftto“HIGH”settingtoreleasegas.Turnon

the button on gas lighter, burner should light immediately. Place back the cooking grid and adjust burners to

desiredcookingtemperature.



WARNING

• DO NOT use the burner if gas odor is present.

• DO NOT stand with head, body, or arms over the burner when lighting.

• Inspect the hose before using the burner. If there is excessive abrasion or wear, or if the hose

is cut, it must be replaced prior to the outdoor cooking gas appliance being put into operation.

The replacement hose assembly shall be that specified by the manufacturer.

• Ensure the area around the burner is clear of flammable substances such as gasoline, yard

debris, wood, etc.

• Ensure there is no blockage of the airflow through the vent space located below the face of the

unit.

Lighting the Side Burner

DANGER

• Failure to open the lid while igniting the burners, or not waiting 5 minutes to allow the gas to

clear if the barbecue does not light, may result in an explosive flame-up which can cause

serious bodily injury or death.

Keep any electrical supply cords and the fuel supply hose away from any

heated surfaces.







UsingtheIgnitionSystem:

1. Openthelid.

2. Keepyourbody,armsandfaceasfarawayfromtheburnersandcookingsurfaceaspossible

3. Depressandrotatetheknobcounterclockwisetothe"High"position. 

a. Asyouarenearingthe"High"position,youwillnoticethevalvegettingtoughertoturn.Thisisthe

springinsidethevalvebuildingupenergytocreatethespark.Onceyouhearaclick,theigniterhas

firedthesparkandyoumustturnthevalvecompletelyoffto

generateanotherspark.

b. Donotturntheknobtoofast,asyouneedthegastotravelintoyourmanifold,thentoyourvalve

andfinallyintotheburnerwhereitwillmeetthesparkfromtheigniter(atthefrontoftheburner).

Alternatively,ifyouturnit

tooslow,youcancauseabuildupofgasinthesideburnerandcreatea

largeflashwhenitignites.

4. Iftheburnerdoesnotcatchonthefirstattempt,tryagainimmediatelybutbeveryawareofanygasbuilding

upinsidethesideburner.Ifthe

sideburnerdoeslightafterthreeconsecutiveattempts,turnthevalvestothe

"Off"positionandallowthesideburnertoclearofanybuiltupgasfor5minutes.

5. Ifatthispointthesideburnerwillstillnotignite,youcantrythemanuallightingprocessbelow

withalong

stemlighterandyoucanalsocontactCoyoteCustomerServiceforfurtherassistancetotroubleshootyour

sideburner.

6. Toturnthesideburner"Off,"yousimplyturneachknobclockwiseuntilitcannotturnanymore.Itisalso

normaltoexperienceapoppingnoisewhenthe

burnersareturnedoffabruptly.



ManuallyLightingtheBurners:



• Ifforsomereason,ignitersfailtolight, burnerscanbelitwithagaslighter.

o Tolightgassideburnerwithagaslighter,makesurethesideburnerhasbeenleaktestedand

burnerscanbeproperlylocated.Insertlong‐neckedgaslighter,placingitnear

theburnerports.

Pressinthefarrightcontrolknobandrotateleftto“HIGH”settingtoreleasegas.Turnonthe

buttonongaslighter,burnershouldlightimmediately.Adjustburnerstodesiredcooking

temperature.



Lighting Instructions



Wheninitiallybringingturningtheburnerson,burntheburnerstogetridofanyodorsordebrisbyoperatingat

“HIGH”setting

PreparingFoodfortheSideBurner



- Alwayscookfoodsadequately.Undercookedfoodscanretainbacteria,especiallyifthawedorexposedto

warmconditionspriortocooking.

- Alwaysuseseparateplatesandutensilsforthehandlingofrawfood.Neverplacerawfoodandcooked

foodonthesameplate,andneverplacecookedfoodonaplatethatwasusedforhandlingrawfood.

- Alwayscarefullywashallplatesandutensilsusedtohandlerawfoodbeforeusingthemtohandlecooked

food.

- Alwayswashallvegetables,seafoodandpoultrybeforecooking.

- Alwaysleaveuncookedfoodsintherefrigeratoruntilyouarereadytostartcooking.

- Alwaysmarinatemeatintherefrigerator.Disposeoftheexcessmarinade,andneverreuseit.



SideburneringTips:

- Ifyoupre‐cookmeatorpoultry,dosoimmediatelybeforesideburnering.

- Neverdefrostmeatatroomtemperatureoronacountertop.

- Refrigerateleftoverswithin2hoursoftakingfoodoffthesideburner.

- Neverletthetrayboildry.Thatcouldbehazardous,asgreasefromfattyfoodsthathave

collectedinthetraycouldigniteandpossiblycausebodilyinjuryorpropertydamage.

- Useameatthermometertobesurefoodhasreachedasafeinternaltemperature.

- Alwaystrimexcessfatfromyourfoodstoreducetheoccurrenceofflare‐upsduringcooking.

- Applyalightcoatingofcookingoiltothecookinggridsbeforesideburnering, topreventfoodsfrom

sticking.

- Cooksimilarportionsizestogether,sothattheyallcookevenly.

- Usetongstoturnfoodsontheburner.

- Neverpiercefoodswhiletheyarecookingontheburner,asthiswilldrythemout.

- Turnfoodsinfrequently.Somechefssaythatagoodsteakshouldneverbeturnedmorethanonce.

- Applysugar‐basedsaucessuchascommercialbarbecuesaucesonlyduringthelatterstagesofcooking,to

preventcharring.



Operations and Features

WARNING: Always observe safe food-handling and safe food-preparation practices when using

this burner, to prevent food-borne illnesses.



DRIPPAN

Thedrippanlocatedbelowtheburnershouldbecleanedperiodicallytopreventheavybuildupofdebris.

NOTE:Allowthedrippantocoolbeforeattemptingtoclean.

IMPORTANT: Do not leave the side burner outside during inclementweather unless it is covered(cover sold

separately).If thedrippanisnotcleanedafteruseandtheburnerisleftuncovered, thedrippanwillfillwithwater

causinggreaseandwatertospillintothecounter.Werecommendcleaningdrippanaftereveryuse.



COOKINGGRATES

Thecookinggratescanbe cleanedimmediately after cooking iscompletedandafter turning offthesideburner .

Wear a barbecue mitt and scrub the cooking grates with a damp cloth. If the burner is allowed to cool down,

cleaningthegrateswillbeeasierifremovedfromtheburnerandcleanedwithamilddetergent.



BURNERS

IMPORTANT:Gascontrolknobsshouldbeinthe“OFF”positionandfuellineshouldbedisconnected.Toreduce

the chance of FLASHBACK, the procedure below should be followed at least once a month or when your side

burnerhasnotbeenusedforanextendedperiodoftime.

1.Removeburnersfromsideburnerbodybycarefullyliftingeachburnerupandawayfromgasvalveorifice.Wire

brushentireoutersurfaceofburnertoremovefooddebrisanddirt.Cleananycloggedportswithastiffwiresuch

asanopenpaperclip.

2.Inspecttheburnerfordamage(cracksorholes)andifsuchdamageisfound,orderandinstallanewburner.

3. After installation, check to insure that gas valve orifices are correctly placed inside the proper position, also

checkpositionofsparkelectrode.



STAINLESSSTEELCARE&MAINTENANCE

Itis acommonmisconceptionthatstainlesssteelwillmaintainitsoriginalfactoryshinewithlittlehelpfromthe

consumer. Unfortunately,thisisnottrue. Stainless steel will not stain, discolor, corrode or rust as fastas other

typesofsteel,butitisnotfullystainorweatherproof.Ifitisnotproperlymaintained,allgradesofstainlesssteel

can face surface discoloration, corrosion and eventually rust. Any stainless steel that is exposed to the

environment will require attention and care throughout its life to ensure that it keeps its shine and structural

integrity.



CleaningtheStainlessSteelandPolishing

1. Tocleanthestainlesssteelyouwillwanttowashoffalldirtanddebrisfromthesteelwithwarmwater.If

youhavetoughspotstoclean,thenadegreasersuchasFormula409canbeused.

Care & Maintenance

CAUTION: All cleaning and maintenance should be done only when side burner is cool & with

the fuel supply turned off at the cylinder. If your side burner is set up for use with Natural Gas, turn

off

as su

at the s

stem manual shut off valve.

2. Next,youwillwanttorinseanddrythesteelthoroughlywithacleantowel.Donotallowthesteeltoair

dryasthestandingwatercancause surfacediscoloration.

3. Thelast thingyouwanttodoistoprotect totheunitwitha goodpolish.Thereareseveralpolisheson

themarketthat work great(BarkeepersFriendPolish and Stainless Steel Magic areafew)andwillhelp

keepyour side burnerprotectedfrom the elementsfora longer periodof time. Mostof these polishes

aretoxic,soyouwouldonlywanttousetheseontheexteriorofthesideburner(notyourcookinggrates

orflavorizers).

a. Youwillwanttoapplythepolishtoacleanpapertowelandwipewiththedirectionofthegrainin

thestainlesssteel.

b. Thereshouldbenoexcessliquidonthesurfacebutitisacceptableforittobealittleoily,asthat

willdissipate.

4. Ifyouhaveasituationwhereyoursideburnerhasdevelopedsurfacediscolorationorsurfacerust,then

you need tocleanthe unit as stated above and use a good polish (Barkeepers Friend Polish, or Instant

RustOut)toremovethespots.

a. Each of these polishingagents take about 30 seconds to work and then you simply wipe off the

product (if needed use a soft Scotch‐Brite pad to remove any tough spots.) If you used

BarkeepersFriend,thenyoudonotneedtodoanythingfurther.IfyouusedInstantRustOut(or

anothercleaningagent),you wouldwant towipeit downwith freshwater and dryitoffagain

withacleantowelandthencoatthesteelwithalayer ofWD‐40or anotherStainless Polishing

solution,whichwillactasasurfaceprotectantforthesteel.

i. IMPORTANT: Be sure not to have your side burner on when using any flammable

product,suchasWD‐40.Theseproductsareextremely flammableintheiraerosolform.



EnvironmentalFactorsthatcanaffectyourSideburner

MotherNatureisawonderfulthingbutunfortunatelyshecanbetoughonoutdoorappliances.Thereareseveral

usualcausesforsurfacediscolorationandcorrosiononyourstainlesssteeloutdoorequipment:

1) Mortar(whichcontainslime)fromtheislandassemblyprocess,hasrestedontheunitforapro‐longedperiod

oftimeandtheunitwasnotcleanedquickly

2) Poolchemicalsweresplashedontothesideburner(chlorineandacidwillcauseveryquickproblems)andthe

unitwasnotcleanedoffquickly

3) Hardwaterfromsprinklers(chlorineinthewater)wasallowedtositontheunit

4) Saltfromtheoceanair/waterwasallowedtorestuponthesideburnerforaprolongedperiodoftimebefore

beingcleaned(beachownersmustbediligentinmaintainingtheiroutdoorstainlessequipment)

5) Dust,orrust,fromothermetalsfounditwaysontothesideburnerandwasleftonforanextendedperiodof

time.

6) Organicmatters(suchascertaintypesoffood)mighthavegottenontothesurfaceofthesideburnerandit

wasthencovered.Withhighhumidityandlowoxygen,corrosionwillstarttotakeplace.

7) Sprays and cleaning solutionscontaining alkaline, lime, acid, salt might have been left on the side burner

surfaceun‐dried.

8) Nostainlesssteelpolishwaseverusedafteroneoftheabovementionedactstookplace.



WaystoAvoidRustonyou rSideburner:

1) AlwayspurchaseaCoyoteSideburnercoverforyourunit.Thiswillensurethatyourcoveriscorrectfitand

breathable,whileprovidingtheprotectionneededtokeepallothercontaminantsoffofthesurface.

2) Wheninstallingtheunit,makesuretokeeptheunitcoveredwhenanymasonryworkisbeingperformed.If

anymortarordustdoescomeintocontactwiththestainless,makesuretowipeitoffassoonaspossibleand

useastainlesssteelpolishimmediatelyafterwards.

3) Positionyoursideburnerawayfromareasthatcanreceivewatersplashfromapoolorhottub.

4) Donotstorepoolchemicalsinyourislandorislandcabinets.



HowtoRemoveScratchesfromyourStainlessSteel:

Ifyoursituationisalittlemoreseriousandyouhaveobtainedscratchesinyourequipment,thenyouwillneedto

purchasea“stainlesssteelscratchkit.”Thesekitsarepopularinretailstoresbutcanbeeasiertoobtainonline.

A very popular one is called “Scratch‐B‐Gone.” With these kits, you will not polish the unit until you are done

re‐scratchingtheentireproductyouareworkingon.Withascratchkit,thegoalistoliterallyre‐scratchtheentire

surface,sothattheoriginalgrainsarereplacedbyyournewscratched‐ingrains.Withthispractice,youmustbe

willingtodotheentiresurfaceasyouwillnoticeastartandstoppoint.Also,becarefultopayattentiontoyour

rolled or finished edges as these scratch kits will ruin this finish. After you have used the kit, you will want to

followitupwithagoodstainlesspolish(asmentionedprior)andthenadrytowelforafinalwipedown.



ANNUALCLEANINGOFBURNERHOUSING

Burn‐offthebarbequeaftereverycookoutwillkeepitreadyforinstantuse,however,onceayearyoushouldgive

theentiresideburnerathoroughcleaningtokeepitintopoperatingcondition.

1.Shutoffgassupplyatsourceanddisconnectsfuelline.Protectfuellinefitting.

2.Removeandcleanthecookinggridsandburners.

3.Coverthegasvalveorificeswithapieceofaluminumfoil.

4.Brushtheinside and bottom ofthesideburner with astiff wire brush, andwashdownwithamildsoap

andwarmwatersolution.Washthoroughlyandletdry.

5.Removealuminumfoilfromorificesandcheckorificesforobstruction.

6.Checkelectrode.

7.Reinstallcookinggrids.

8.Reconnecttogassourceandobserveburnerflameforcorrectoperation.

IMPORTANT: You should NOT line the bottom of the burner housing with aluminum foil, sand or any other

greaseabsorbentsubstance,agreasefiremayoccur.



MAINTENANCEGUIDELINES

1. Keepoutdoor cookinggasapplianceareaclearand free fromcombustiblematerials,gasoline and other

flammablevaporsandliquids.

2. Donotobstructtheflowofcombustionandventilation air.

3. Keeptheventilationopening(s)ofthecylinderenclosurefreeandclearfromdebris.

4. Visuallycheckburnerflames.Burnerflamesshouldbeblueandstablewithnoyellow tips,excessivenois e ,or

lifting.Ifanyoftheseconditionsexistcallourcustomerserviceline.

5. Clean outdoor cooking gas appliance, including special surfaces, with recommended cleaning agents, if

necessary.

6. Checkandcleanburnerforinsectsandinsectnests.Acloggedtubecanleadtoafirebeneaththesideburner.



RecommendedCleanersforSpecificSituations 



JOB CLEANINGAGENTS COMMENTS

RoutineCleaning

Soap,ammonia,detergentMedallion

Applywithclothorsponge

Fingerprints&smears Arcal20,Lac‐O‐NuEcoshine Providesbarrierfilm

Stubbornstains&

discoloration

Cameo,Talc,Zud

FirstImpression

Rubindirectionof polishlines

Grease&Oil

Anygoodcommercialdetergent

Applywithspongeorcloth

Restoration/Passivation Benefit,SuperSheen



Page is loading ...

Coyote C1DBNG Owner's manual

Brand: Coyote

Model: C1DBNG

Category: Barbecues & grills

Type: Owner's manual

This manual is also suitable for

Download PDF

report

Coyote C1DBNG Owner's manual

This manual is also suitable for

Coyote C1DBNG Owner's manual

Related papers

Other documents