2. EZ Screen Room
  3. EZSRSRDEH

EZ Screen Room EZSRSRDEH Installation guide

  • Hello! I am an AI chatbot trained to assist you with the EZ Screen Room EZSRSRDEH Installation guide. I’ve already reviewed the document and can help you find the information you need or explain it in simple terms. Just ask your questions, and providing more details will help me assist you more effectively!
WORKINGWITHSCREENANDSPLINE:
1.
FIRSTPRACTICEHOWTHEFLATSPLINEFITS
INTOTHESCREEN
CHANNEL.CUTA6”PIECEOFSPLINE. USINGYOURFINGERS,
PUSHTHEFLATSIDEOFTHESPLINEINTOTHE
DEEPEREDGEOF
SPLINECHANNEL(WITHOUTANYSCREEN).NOWPRACTICE
ROLLINGTHESPLINEROLLERTOOLTO“LOCK”
THESPLINEINTOTHE SPLINECHANNEL. (Seeillustrations).
NOTE:“Flatedge”ofsplineseatsinflatedgeofchannel.
PROPERWHEELSELECTIONFORSPLINEROLLINGTOOL
U‐shapedwheelRoundwheel
Eitherwheelisacceptable
WORKINGWITHSCREENANDSPLINE:
WHENSCREENINGYOUROPENING,FOLLOWTHEDIAGRAMBELOWASTOTHEORDERIN
WHICHTOSCREENTHECHANNELS,STARTATBOTTOMPANEL#1ANDFINISHAT#4.THEN
MOVETO1‐4OFTHELARGERTOPPANEL. BESURETOREADANDUNDERSTANDTHISENTIRE
SECTIONBEFOREYOUBEGINTHESCREENINGPROCESS.
TopPanel
1
TopPanel
1.
Screenchannel(F)
2.
Screenchannel(E)
3 2
3.
Screenchannel(D)
4. Screentopchannel(C)
4
BottomPanel
1
BottomPanel
1.
Screenbottomchannel(C)
3 2
2. Screenchannel(B)
3. Screenchannel(A)
4
4.
Screentopchannel(G)
INSTALLINGSCREEN‐LOWERPANEL:
12.
TAPEORTACKTHESMALLERBOTTOMPANELSCREEN(S1)LOOSELYOVERLOWEROPENING
(BELOWMIDRAIL).OVERLAPALLEDGESATLEAST3”.Note:Extrascreenissupplied.
Maskingtape
(notincluded)
Maskingtape
(notincluded)
13.
USEAPIECEOF10’SPLINE(S3)TOBEGININSTALLINGTHELOWERSCREENPANEL. REFER
TOPAGE 12.
INSTALLINGSCREENcontinued‐LOWERPANEL:
14.
ALIGNMIDDLEOFSPLINEWITHTHE MIDDLEOFTHEMIDRAIL(C).ROLLTHESPLINEANDSCREEN
INTOTHECHANNELTOWARDSEITHERCORNER.
Allowextrascreen
15.
MEASURESIDE(A)ANDCUTOFFPIECEOFSPLINE6”LONGER.
16.
STARTINGABOUT1”BELOWTHEUPPERRIGHTCORNER,ROLLTHE
SPLINEANDSCREENINTOTHECHANNEL. ENSURESPLINECOVERS
ENTIRESCREENCHANNEL.
17.
REPEATSTEP15FORSIDEB. APPLYASLIGHTSIDEWAYSPRESSUREWITHYOUR
FINGERSASYOUROLLSIDEB.
NOTE:ASTHESPLINELOCKSINTOPLACEYOURSCREENSHOULDBECOMETIGHT. IF
NECESSARYPULLOUTSPLINEANDRESTARTPROCESSUNTILYOUACHIEVEDESIREDLOOK
ANDSCREENTAUTNESS.REFERTOPG.7FORSIDES(A),(B),AND(C).
INSTALLINGSCREENcontinued‐LOWERANDUPPERPANELS
18.
STARTINGINTHEMIDDLEOF(F),ROLLTHESPLINEANDSCREENINTOTHECHANNELTO‐
WARDSEITHERCORNER. NOWTHATTHETOP(F)ISDONE,COMPLETEBOTHSIDESAS
YOUDID WITHTHELOWERPANEL.
NOTE:ASTHESPLINELOCKSINTOPLACEYOURSCREENSHOULDBECOMETIGHT. IF
NECESSARYREMOVESPLINEANDRESTARTPROCESSUNTILYOUACHIEVEDESIREDLOOK
ANDSCREENTAUTNESS.
19.
REPEATSTEPS12‐18FORUPPERPANEL(ABOVEMIDRAIL).
TRIMMINGTHESCREEN:
20.
CAREFULLYTRIMOFFEXCESSSCREENTHATISOUT‐
SIDETHESPLINEUSINGASHARPUTILITYKNIFE.
21.
TUCKSPLINEINTOCORNERSUSINGTHETIPOFA
SCREWDRIVER.
/