Saber Compact ATD-80335 User manual

ATD-80335

35W COB LED Work Light w/Telescopic Stand

Instruction Manual

Features:

ͻ Power Cord: 18/3 SJTW

ͻ Lumens: 2800-3000

ͻ Lux: 900-1200

ͻ Super bright 35 WaƩ COB LED

ͻ Heavy-duty industrial design with diecast aluminum housing

ͻ 16 Ō. water-resistant power cord remains Ňexible in cold weather

ͻ Quick fastening light head for easier adjustment

ͻ 160 degree horizontal rotaƟon on base

ͻ RotaƟng telescopic stand easily folds for storage and extends from 25” to 72”

ͻ IP67 rated for dust and water resistance

ͻ CSA outdoor cerƟĮcate

ͻ Long beam distance

^ƉĞĐŝĮĐĂƟŽŶƐ͗



CaliforniaProp65WARNING:

Thisproductcontainschemicalsincludinglead,knowntotheStateofCaliforniatocausecancer,birthdefects,orother

reproductiveharm.Washhandsafterhandling.



GeneralSafetyWarnings:



WARNING:Theinstructionsandwarningscontainedinthismanualshouldbereadandunderstoodbeforeusing

oroperatingthislight.Donotallowanyonetouseoroperatethislightuntiltheyhavereadthismanualandhave

developedathoroughunderstandingofhowthislightworks.Failuretoobserveanyof

thefollowinginstructionscould

resultinseverepersonalinjurytolightuserandbystanders,orcausedamagetothelightandproperty.Keepthismanual

forfuturereference.



Note:Thewarningsandcautionsdiscussedinthisinstructionmanualcannotcoverallpossibleconditionsand

situationsthatmayoccur.Itmustbeunderstoodbytheoperatorthatcommonsenseandcautionarefactorswhich

cannotbebuiltintothisproduct,butmustbesuppliedbytheoperator.



WARNING:Usesafetyequipment.Usersandbystandersshouldusesafetygogglesorsafetyglasseswithside

shieldswhichcomplywithcurrentnationalstandards,orwhenneeded,afaceshield.UseanANSIapproveddustmaskor

respiratorwhenworkingaroundmetal,wood,andchemicaldustsandmists.Thisappliestoallpersons

intheworkarea.

AlsousenonͲskidsafetyshoes,hardhat,gloves,dustcollectionsystems,andhearingprotectionwhenappropriate.



WARNING:Keepbystandersandchildrenoutoftheworkareawhileoperatingthislight.



WARNING:Alwayskeepyourworkareaclean,uncluttered,andwelllit.Clutteredordarkareasinviteaccidents

andinjuries.DONOTworkonfloorsurfacesthatareslippery.



WARNING:Donotoperatethislightifyouaretiredorundertheinfluenceofalcohol,drugs,ormedicationsthat

couldaffectyourabilitytousethelightproperly.



WARNING:Dressproperly.Donotwearlooseclothingorjeweleryastheycanbecaughtinmovingparts.Wear

restrictivehaircoveringtocontainlonghair.



WARNING:Donotreachoveroracrossrunningmachines.Keepproperfootingandbalanceatalltimes.NonͲ

skidfootwearisrecommendedwhenworking.



ElectricalSafetyWarnings:



WARNING:Readallsafetywarningsandinstructions.Failuretofollowallwarningsandinstructionsmayresult

inelectricshock,fireand/orseriousinjuryordeath.



WARNING:Beforeconnectingalighttoapowersupply,alwayschecktoensurethepowersupplycorrespondsto

thevoltageonthenameplateofthelight.Apowersupplywithavoltagegreaterthanthatspecifiedforthelightcan

resultinseriousinjurytotheuser,aswellasdamageto

thelight.Usingapowersupplywithavoltagelessthanthe

nameplateratingisharmfultothemotor.Ifindoubt,donotpluginthelight.



WARNING:Groundedlightsmustbepluggedintoanoutletproperlyinstalledandgroundedinaccordancewith

allcodesandordinances.Thislightisequippedwitha3Ͳprongpluganda3Ͳwiregroundingsystem.Neverremovethe

groundingprongormodifythepluginanyway.Donotuseanyadapter

plugs.Checkwithaqualifiedelectricianifyou

areindoubtastowhethertheoutletisproperlygrounded.



NOTE:Doubleinsulatedlightsareequippedwithapolarizedplug(onebladeiswiderthantheother).Thisplug

willfitinapolarizedoutletonlyoneway.Iftheplugdoesnotfitfullyintheoutlet,reversetheplug.Ifitstilldoesn’tfit,

contactaqualifiedelectricianto

installapolarizedoutlet.Donotchangethepluginanyway.



WARNING:Toreducetheriskofelectricshock,DONOTuseindampconditions,onwetsurfaces,orexposeto

rain.Donotpluginthislightoroperateitwithwethandsorwhilestandinginwater.



WARNING:Neverusethecordforcarrying,pullingorunpluggingthelight.Graspplugandpulltodisconnect

fromoutlet.Keepcordawayfromheat,oil,sharpedgesormovingparts.Replacedamagedcordsimmediately.



WARNING:Alwaysremovethepowercordfromtheelectricoutletwhenmakingadjustments,changingparts,

cleaningorworkingonthelight.



WARNING:Careshouldbetakentoarrangethecordsoitwillnotbesteppedon,trippedover,orotherwise

subjectedtodamageorstress.



WARNING:Neverattempttopluginoroperateequipmentwithdefectiveordamagedwires,powercordor

powercordplug.Haveanydefectiveordamagedpartsreplacedimmediatelybyqualifiedpersonnel.



WARNING:Avoidbodycontactwithelectricallygroundedsurfaces.Thereisanincreasedriskofelectricshockif

yourbodyisgrounded.



WARNING:IftheworkareaisnotequippedwithapermanentlyinstalledGroundFaultCircuitInterrupteroutlet

(GFCI),useaplugͲinGFCIbetweenthelightorextensioncordandthepowerreceptacle.



WARNING:Ifanextensioncordisnecessary,useonly‘Listed’extensioncords.Ifusedoutdoors,theymustbe

marked“ForOutdoorUse”.Thosecordshavinga3Ͳpronggroundingtypeplugsandmatingreceptaclesaretobeused

withgroundedlights.



WARNING:Useofimpropersizeorgaugeofextensioncordmaycauseunsafeorinefficientoperationofyour

lightortool,orcausedamagetoyourlightortool.Besureyourextensioncordisratedtoallowsufficientcurrentflowto

themotorofyourtool.Ifindoubt,alwaysusealargergaugecord.Besuretocheckthevoltagerequirementsofthelight

toyourincomingpowersource.



NOTE:Thetablebelowshowsthecorrectsizetouseaccordingtocordlengthandtheamperagedrawofthelight

(specifiedonthenameplate).Whenindoubt,usethenextheaviergauge.Thesmallerthegaugenumber,theheavier

thecord.(AWG=AmericanWireGauge).



MinimumGaugefor

ExtensionCords(AWG)

(whenusing120voltsonly)

AmpereRating TotalLengthofCordinFeet(meters)

MoreThan NotMoreThan 25'(7.6m) 50'(15m) 100'(30.4m) 150'(45.7m)

0 6 18 16 16 14

6 10 18 16 14 12

10 12 16 16 14 12

12 16 14 12 NotRecommended



ATDͲ80335SpecificSafetyInstructions:



WARNING:Theworklightmustbeconnectedto120Vpowersourceasspecified.Allwiringshouldbeperformed

byaqualifiedelectrician.

WARNING:Disconnectpowerbeforeinstallingorservicing.



WARNING:Toreducetheriskofelectricshock,lightsshouldbepluggeddirectlytoaproperlyinstalledand

grounded3Ͳprongreceptacle.Useonlya3Ͳwireextensioncordthathasa3Ͳpronggroundingtypeplugwith3Ͳpole

receptaclesthataccepttheequipmentplug.

WARNING:Thesefixturesarenotintendedtobeusedinpotentiallydangerouslocations,suchasflammableor

explosiveatmospheres.

WARNING:Donotdisassemblethelighthead.Thewaterresistantfunctionwillbeaffectedafter

disassembling/openingthelight.

WARNING:Keepplugsandreceptaclesdry.



WARNING:Donotraisethelightabovethemarkedwarninglineontripodextensiontopreventtippingofthe

light.



ATDͲ80335AssemblyInstructions:



IllustrationA:







1) Insertbolt(02)throughthelightheadbracket(06)slidespringwasher(04)andflatwasher(03)tothebolt(02)

andthenthreadbolt(02)tothetripodstandasshownillustrationabove.

2) Fastenthebolt(02)

tothe

tripodstand(05)andtighten.

3) Velcrocanbeusedtotiecordoff.



OPERATION:



1) Lampisturnedonandoffwithaswitchlocatedonthebackofthelamphead



    

 Ref# Description Qty 

 01 Lighthead 1 

 02 Bolt1/4" 1 

 03 Flatwasher 1 

 04 Springwasher 1 

 05 Bracket 1 

 06 Lightheadbracket 1 

    

ATD-80335

NOITPIRCSEDTRAP#TRAPGNIREDRO#METINOITPIRCSEDTRAP#TRAPGNIREDRO#METI

ESABHCTIWS51-53308TRP51WERCS10-53308TRP1

WOTJS3/81,DROC61-53308TRP61REPPU,GNISUOH20-53308TRP2

ROTCENNOCRETPADATNATSISERRETAW71-53308TRP71GNIRGNILAES30-53308TRP3

CREWS81-53308TRP81SSALGDEREPMET40-53308TRP4

2REHSAWEDISTUO91-53308TRP91ROTCELFER50-53308TRP5

WERCS02-53308TRP02WERCS60-53308TRP6

1REHSAWEDISTUO12-53308TRP12REHSAWDEGGAJRENNI70-53308T

RP7

ROTARIPSER22-53308TRP22ELDDIM,GNISUOH80-53308TRP8

REVIRD32-53308TRP32KOOH90-53308TRP9

1GNIRO42-53308TRP42WERCSYLFRETTUB01-53308TRP01

TLOBDNAH52-53308TRP52WERCSYLFRETTUB11-53308TRP11

TEKCARB62-53308TRP62HCTIWSNOTTUB21-53308TRP21

DELBOC72-53308TRP72REVOCGNILAESHCTIWS31-53308TRP31

14 PRT80335-14 O RING

Visit us at www.atdtools.com

Saber Compact ATD-80335 User manual

Related papers

Other documents