Sea Ray 2006 290 SELECT EXECUTIVE Supplement Owner's manual

290 Select EX

Owner’s Manual Part Number: MRP 1803657

This owner’s manual is arranged into two parts. Following is a description of each.

General Information

This section contains general information you need to know to safely operate

and maintain your boat.

Specific Information

This section contains information that is specific to your boat such as dimensions, general

arrangement, specific safety information, special features and the electrical system.

If any of these sections are missing from this book contact your dealer.

Your dealer can find out when it will be available and order it for you.

Sea Ray

Owner’s

Manual

Sea Ray

®

• Owner’s Manual Supplement • 290 Select EX • MRP #1803657

Printed in the U.S.A. December 2000.

Revised June 2001, June 2002, June 2004, July 2005

Sea Ray Boats, Inc. 2600 Sea Ray Blvd., Knoxville, TN 37914.

For information call 1-800-SRBOATS. or fax 1-314-213-7878 Domestic/International

Internet address: http://www.searay.com

Note: Not all accessories shown in pictures or described herein are standard equipment or even available as options.

Options and features are subject to change without notice.

Owner’s Manual

Supplement

290 Select EX

1-800-SRBOATS

www.searay.com

3

290 Select EX

Engine Cooling System ........................................26

Engine Oil Change System ..................................26

Anchoring..............................................................27

Anchoring Arrangement .......................................27

Location Of Through-Hull Fittings ........................28

Canvas ..................................................................29

Electrical Installation............................................. 30

Battery Switch (Opt) .............................................30

Lighting Locations.................................................31

Ground Faunt Interrupter (GFI) Outlet

Loctions & Associated Loads ............................ 32

Electric Switch Pads & Electronic

Interface Modules (EIM) .................................... 33

Bilge Accessory Board .......................................... 35

Main DC Distribution Panel ................................... 36

Main Distribution Panel .......................................... 37

Mercury

®

Diesel Engine Monitor (Option) .............. 38

Battery Cable Routing .......................................... 38

Wiring Harness Installation ..................................40

Wiring Schematics ................................................ 43

Safety Label Locations .........................................61

International Homologations ................................ 65

If this is your first craft, or you are changing to a type of

craft you are not familiar with, for your own comfort

and safety, please ensure that you obtain handling and

operating experience before “assuming command” of

the craft. Your dealer or yacht club will be pleased to

advise you of local sea schools, or competent instructors.

PLEASE KEEP THIS OWNER'S MANUAL PACKET IN A

SECURE PLACE, AND HAND IT OVER TO THE NEW

OWNER WHEN YOU SELL THE CRAFT.

This owner's manual supplement has been written to

provide additional specific information about your boat

and should be read carefully.

The owner's manual packet has been compiled to help

you to operate your craft with safety and pleasure. It

contains details of the craft, the equipment supplied or

fitted, its systems and information on its operation and

maintenance. Please read the information in it carefully,

and familiarize yourself with the craft before using it.

Life Saving Equipment (PFD) ................................. 4

Troubleshooting ....................................................... 4

Repair and Parts Facilities ...................................... 4

Docking / Lifting / Trailering ..................................... 5

Bow & Stern Eye / Cleat / Sling Tag Locations ....... 5

General Arrrangements & Dimensions ....................

6

Accommodation Plan .............................................. 7

Deck Occupancy Plan ............................................ 8

Accessory Locations ............................................... 9

Dash Layout .......................................................... 10

Engine Compartment Layout ............................... 12

Exhaust System Layout (Optional Corsa) ............ 14

Water System .......................................................15

Grey Water System (Option) ................................ 18

Head System ........................................................19

Macerator (Option) ...............................................20

Fuel System .......................................................... 20

Ventilation System / Bilge Blowers ....................... 22

Bilge Pumping System ......................................... 23

Steering System ...................................................24

Fire Extinguishing System .................................... 25

Extinguisher Indicator Panel................................. 25

Information in this publication is based upon the latest product specifications available at printing. Sea Ray

®

Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifica-

tions, materials and prices of all models, or to discontinue models. Should changes in production models be

made, Sea Ray

®

is not obligated to make similar changes or modifications to models sold prior to the date of

such changes.

The following are registered trademarks of the Brunswick Corporation: Sea Ray

®

, The SR Wave Logo.

(This book contains 65 pages.)

INTRODUCTION & TABLE OF CONTENTS

4

290 Select EX

TROUBLESHOOTING

LIST OF REFERENCE MANUALS AND DRAWINGS

PERFORMANCE: Refer to “Power Capacity” in the own-

er's manual.

ENGINE: Refer to the owner's manual and/or the en-

gine manual.

ELECTRICAL: Refer to electrical section of the owner's

manual and electrical schematics in this owner's manual

supplement. Only a qualified marine electrical techni-

cian may service the boat's electrical system.

REPAIR AND PARTS FACILITIES

To find a Sea Ray

®

dealer in your area, call: Sea Ray

®

Customer Service: 1-800-SRBOATS

FAX: 1-314-213-7878

To find repair and parts facilities for equipment installed

on your boat, refer to the original equipment manuals

(OEM's) found in the owner's manual packet.

SUPPLEMENTAL GENERAL INFORMATION

LIFE SAVING EQUIPMENT

(PERSONAL FLOTATION DEVICE (PFD) )

STORAGE: The 290 SLX offers sutable storage for per-

sonal flotation devices (PFD’s) under the forward port

and starboard seat cushions, under the cockpit floor

storage, under cockpit entertainment center and tran-

som storage.

OPERATION: Wear PFD according to manufacturer rec-

ommendations. See pamphlet Federal Requirements

And Safety Tips For Recreational Boats in the owner’s

packet or get one from your dealer.

MAINTENANCE: Rinse with fresh water and let dry

thoroughly. Do not store in a damp compartment. Avoid

the possibility of mildew.

STORAGE AREAS

(FIG. 4.1)

BELOW BOW

RIDER SEAT

CUSHIONS

COCKPIT

FLOOR

STORAGE

UNDER COCKPIT

ENTERTAINMENT

CENTER

COCKPIT SIDE

PANEL STORAGE

STORAGE BELOW

PORT SEATING

TRANSOM

STORAGE

COMPARTMENTS

BOW SIDE

STORAGE

PLATFORM

STORAGE

COMPARTMENT

5

290 Select EX

CLEAT LOCATIONS

(FIG. 5.1)

CLEAT

BOW/STERN

EYE

DOCKING/LIFTING/TRAILERING

CLEATS: Cleats must not be used for lift-

ing the boat, they are intended for moor-

ing use only.

BOW AND STERN EYES: The bow eye

should be used to haul the boat onto a

trailer. The stern eyes should be used as

tie down points for trailering the boat. The

bow and stern eyes may be used for short term lifting

of the boat such as for service. Long term lifting with

the bow and stern eyes may cause stress on the fiber-

glass and gel coat.

For long term storage use flat, wide

belt-type slings and spreaders long

enough to keep pressure from gun-

wales. Do not place slings where they may lift on un-

derwater fittings. When slings are used for lifting the

boat, they shoud be positioned at the “SLING” tag lo-

cations on the sides of the hull.

BOW EYE

STERN EYE

(STARBOARD SHOWN)

(PORT SIDE IDENTICAL)

SLING TAG

BOW & STERN EYES /

SLING TAG LOCATIONS

(FIG. 5.2)

SLING

6

290 Select EX

(C) 5’ 6” (1.67 m)

GENERAL ARRANGEMENTS & DIMENSIONS

KEEL

WATERLINE

INTERIOR SEATING PLAN

(A) 29’ 6” (8.99 m) Overall Length

PROFILE

(FIG. 6.1)

(D) 7’ 3” (2.20 m)

HEIGHT DIMENSIONS290 SLX SPECIFICATIONS

(A) Overall Length ......................................29’ 6” (8.99 m)

(B) Beam ..................................................... 9’ 8” (2.95 m)

Draft (Stern Drive Down) ........................... 38” (96.5 cm)

Draft (Stern Drive Up) ................................ 23” (58.4 cm)

Draft (Twin Stern Drive Down) .................. 35” (88.9 cm)

Draft (Twin Stern Drive Up) ....................... 24” (61.0 cm)

Dry Weight (lbs.) ...................................... 7,200 (3.266 kg)

Fuel Capacity (gal.) ............................... 130 (492.1 liters)

Usable Fuel (gal.) .................................. 123.5 (467 liters)

Water Capacity (gal.) .................................. 24 (90.8 liters)

Holding Tank (gal.) .................................... 20 (75.7 liters)

Dead Rise ...................................................................... 21°

(FIG. 6.2)

290 SLX SEATING PLAN

Starboard Double Helm Seat w/Flip-Up Thigh-Rise Bolster, Port Back-to-Back Lounger - Adjustable w/

Flip-Up Thigh-Rise Bolster, Bow Rider Loungers, Aft Circular Seat w/Sun Pad Filler Cushions

(FIG. 6.3)

(B)

9’ 8”

(2.95 m)

(C) Waterline To Top Of Windshield ......... 5’ 6” (1.67 m)

(D) Waterline To Top Of Arch .................... 7’ 3” (2.20 m)

(E) Keel To Top Of Windshield .................7’ 6” (2.28 m)

(F) Keel To Top Of Arch ............................9’ 3” (2.81 m)

(E) 7’ 6” (2.28 m)

(F) 9’ 3” (2.81 m)

(G) 1’ 2” (35 cm)

7

290 Select EX

MAIN DECK (FLOOR PLAN)

(FIG. 7.1)

PORT

STBD

FWD

COCKPIT

ENCLOSED HEAD

ACCOMMODATION PLAN

FLOOR

STORAGE

FUEL FILL

WASTE / GREY WATER

PUMP-OUT PLATE

WATER TANK FILL

PLATE

OPTIONAL SHORE

POWERINLET

STARBOARD DOUBLE HELM

SEAT W/FLIP-UP THIGH RISE

BOLSTER

PORT BACK-TO-BACK

LOUNGER-ADJUSTABEL W/

FLIP-UP THIGH RISE BOLSTER

BOW RIDER

LOUNGERS

AFT CIRCULAR SEATING

W/SUN PAD FILLER CUSHIONS

AND

ENGINE COMPARTMENT HATCH

(ELECTRICALLY OPERATED)

ENTERTAINMENT CENTER

WITH WET BAR

SWIM PLATFORM

WALK THROUGH

WITH TRANSOM

DOOR

CONCEALED LADDER

PLATFORM STORAGE

TRANSOM STORAGE

COMPARTMENTS

COOLER

8

290 Select EX

(FIG. 8.1)

DECK OCCUPANCY PLAN

TO AVOID RISK OF SERIOUS INJURY

OR DEATH SHUT OFF ENGINE WHEN

NEAR SWIMMERS OR PRIOR TO US-

ING SWIM PLATFORM AND BOARD-

ING LADDER.

! DANGER

PERSONAL INJURY HAZARD

When underway, keep occupants

clear of areas not designed for

riding. Especially hazardous areas

include seat backs, bow, gunwale,

transom platform and fore and aft

decks.

! WARNING

SLIPPING HAZARD - Wet decks

are slippery. Wear proper

footwear and use extreme

caution on wet surfaces.

! WARNING

PORT

STBD

FWD

WORKING DECK

(DECK AREA INTENDED FOR OCCUPATION

DURING ANCHORING, MOORING AND

EMERGENCY OPERATION ONLY)

ACCOMODATION DECK

(DECK AREA INTENDED FOR OCCUPATION

DURING NORMAL OPERATION)

DO NOT WALK ON THIS AREA

9

290 Select EX

ACCESSORY LOCATIONS

(FIG. 9.1)

TRANSOM

SHOWER

LIFTING/TIE

DOWN EYE

PORT

STBD

FWD

LIFTING/TIE

DOWN EYE

SPEAKER (INSIDE STORAGE)

MAIN DISTRIBUTION PANEL

STEREO SYSTEM

(INSIDE ENCLOSED HEAD)

BILGE VENTS

BATTERY SWITCH(ES)

MAIN DC DISTRIBUTION

BREAKER PANEL

BILGE VENTS

ENCLOSED HEAD

(WITH HEAD SYSTEM, SINK, PULLOUT

SPRAYER, STORAGE, MEDICINE

CABINET, MIRRORED DOOR & LIGHT)

FUEL TANK SENDING UNIT

ACCESS PLATE

BOW TABLE LEG INSERT

OPTIONAL WINDLASS

OPTIONAL

SPOTLIGHT

ANCHOR CHUTE

(WITH OPTIONAL WINDLASS)

COCKPIT TABLE LEG INSERT

ENTERTAINMENT CENTER

(WITH SINK, PULL OUT FAUCET,

COOLER,BOTTLE STORAGE,

OPTIONAL 120V/12V

REFRIGERATOR)

PORT BOW

NAVIGATION LIGHT

STARBOARD BOW

NAVIGATION LIGHT

NAVIGATION LIGHT ON

OPTIONAL SPORT SPOILER

CONTROL

STATION

ENGINE SHIFT AND

THROTTLE CONTROL

STANDARD: ANCHOR AND ROPE STORAGE

OPTION: ROPE STORAGE WITH WINDLASS

HORN

10

290 Select EX

SINGLE ENGINE GAUGE PANEL

(FIG. 10.2)

DASH LAYOUT

GAUGE PANEL

(FIG. 10.1)

PORT SWITCH

PANEL

STARBOARD

SWITCH PANEL

VHF MARINE RADIO

(OPTION)

INDICATOR LIGHT

AND INFORMATION TAG

FOR AUTOMATIC

FIRE EXTINGUISHING

SYSTEM

STEERING

WHEEL

KICK PANEL STORAGE AND

BEHIND DASH ACCESS

TWIN ENGINE

THROTTLES

STERN DRIVE TRIM &

SEARCH LIGHT PANEL

TWIN ENGINE

GEAR SHIFTS

IGNITION SHUT

DOWN SWITCH

(SEE ENGINE

MANUAL)

STORAGE

COMPARTMENT

STEREO REMOTE

DEPTH FINDER

12 VOLT

RECEPTACLE

TACHOMETER

FUEL GAUGE

SPEEDOMETER

OUTDRIVE

TRIM GAUGE

HOURMETER

WATER

TEMPERATURE

VOLTMETER OIL PRESSURE

11

290 Select EX

STEREO REMOTE DEPTH FINDER

CENTER PANEL

(FIG. 11.4)

WATER TEMPERATURE

VOLTMETER

OIL PRESSURE

STARBOARD ENGINE

TACHOMETER

FUEL GAUGE

SPEEDOMETER

OUTDRIVE

TRIM GAUGE

HOURMETER

PORT ENGINE

TACHOMETER

HOURMETER

WATER

TEMPERATURE

VOLTMETER

OIL PRESSURE

OUTDRIVE

TRIM GAUGE

ENGINE RPM

SYNCHRONIZER

GAUGE

PORT ENGINE

MULTI-GAUGE

STBD ENGINE

MULTI-GAUGE

TWIN ENGINE GAUGE PANEL

(FIG. 11.1)

TRIM TAB

SWITCHES

ENGINE

IGNITION

SWITCH

(START)

HATCH

LIFT

FWD

ACC

AFT

ACC

TRIM TABS

ACCESSORY 1

ACCESSORY 2

BILGE PUMP

(ON/OFF)

ENGINE HATCH

LIFT (UP)

ENGINE HATCH

LIFT (DOWN)

ENGINE

IGNITION

SWITCH

(STOP)

BILGE BLOWER

(ON/OFF)

NAV

ANCHOR

COMP

COCKPIT

BILGE

ARCH

VENT

OPEN

VENT

CLOSE

P

S

ACC

1

ACC

2

DIM

WINDSHIELD

WIPER

(PORT &

STARBOARD)

ACCESSORY

1 & 2

WINDSHIELD

VENT

(OPEN & CLOSE)

WINDLASS

(UP & DOWN)

WINDLASS

(ON/OFF)

DASH LIGHTS

DIMMER

CONTROL

ANCHOR LIGHT

(ON/OFF)

NAVIGATION LIGHT

(ON/OFF)

DEPTH

SOUNDER

STEREO

MUTE

LIGHTS:

COMP

BILGE

COCKPIT

ARCH

HORN

PORT SWITCH PANEL

(FIG. 11.2)

STARBOARD SWITCH PANEL

(FIG. 11.3)

STERN DRIVE TRIM &

SEARCH LIGHT PANEL (FIG. 11.5)

ENGINE TRIM

TRAILER

PORT STBD

DOWN

UP

SEARCHLIGHT

S

F

STERN

DRIVE

TRAILER

TRIM

PORT STERN

DRIVE TRIM

STBD STERN

DRIVE TRIM

SEARCH LIGHT

CONTROL PANEL

TWIN ENGINE

EMERGENCY START SWITCH

(SEE OWNER’S MANUAL

FOR DETAILED INFORMATION)

12

290 Select EX

H: BILGE PUMP

I: HIGH WATER BILGE PUMP

J: TRIM TAB PUMP

K: HEAD SYSTEM OVERBOARD DISCHARGE

SEACOCK

L: FUEL TANK

M: BATTERIES

A: BILGE COMPONENT BOARD

B: STERN DRIVE POWER TRIM PUMP

C: BILGE BLOWER

D: TRANSDUCER

E: HIGH WATER BILGE PUMP FLOAT

SWITCH

F: BILGE PUMP FLOAT SWITCH

G: AUTOMATIC FIRE EXTINGUISHER

GASOLINE SINGLE ENGINE (FIG. 12.1)

ENGINE COMPARTMENT L AYOUT

A

B

C

D E F G H I

J

K

L

M

C

13

290 Select EX

GASOLINE TWIN ENGINE (FIG. 13.1)

H: BILGE PUMP

I: HIGH WATER BILGE PUMP

J: STARBOARD STERN DRIVE POWER

TRIM PUMP

K: TRIM TAB PUMP

L: HEAD SYSTEM OVERBOARD DISCHARGE

SEACOCK

M: FUEL TANK

N: BATTERIES

A: BILGE COMPONENT BOARD

B: PORT STERN DRIVE POWER

TRIM PUMP

C: BILGE BLOWER

D: TRANSDUCER

E: HIGH WATER BILGE PUMP FLOAT

SWITCH

F: BILGE PUMP FLOAT SWITCH

G: AUTOMATIC FIRE EXTINGUISHER

A

B

C

D E F G H I

K

L

M

N

C

J

14

290 Select EX

OPTIONAL CORSA EXHAUST SYSTEM LAYOUT

SINGLE ENGINE CORSA EXHAUST SYSTEM LAYOUT (FIG. 14.1)

TWIN ENGINE CORSA EXHAUST SYSTEM LAYOUT (FIG. 14.2)

TRANSOM

STARBOARD

HULL

PORT

STBD

FWD

PORT

STBD

FWD

EXHAUST TIP

EXHAUST HOSE

4” DIAMETER

EXHAUST

ELBOW

EXHAUST

ELBOW

EXHAUST

DIVERTER

TRANSOM

STARBOARD

HULL

EXHAUST TIP

EXHAUST HOSE

4” DIAMETER

EXHAUST

ELBOW

EXHAUST

ELBOW

EXHAUST

DIVERTER

EXHAUST

TEE FITTING

15

290 Select EX

WATER SYSTEM

The water system on your Sea Ray® Sport Cruiser is

equipped with a sink and faucet in the head, cockpit

entertainment center wet bar, transom shower and fresh-

water washdown spigot. The grey water sump collects

GREY WATER SUMP

(LOCATED BELOW AFT END OF COCKPIT HATCH)

(FIG. 15.4)

SUMP PUMP

FLOAT SWITCH

TRANSOM SHOWER

(FIG. 15.5)

FAUCET

COOLER

ENTERTAINMENT CENTER WET BAR

(FIG. 15.3)

SINK

HEAD FAUCET AND TOILET

(FIG. 15.2)

TOILET

FAUCET AND

SINK

WATER SYSTEM ACCESSORY LOCATIONS

(FIG. 15.1)

water from the head sink and pumps it overboard. Re-

fer to owner’s manual Shower System section for grey

water sump information.

16

290 Select EX

WATER PUMP

WATER TANK

WATER FILL HOSE

ROUTE TO DECK FILL

WATER TANK

VENT

WATER SYSTEM TANK LOCATION & HOSE ROUTING

(LOCATED BELOW COCKPIT HATCH & FORWARD)

(FIG. 16.2)

TO HEAD TOILET

(WITH VACUFLUSH

®

OPTION)

TO HEAD SINK

WATER SYSTEM

(FIG. 16.1)

WATER FILTER

TRANSOM

SHOWER

WATER FILL HOSE

ROUTE TO DECK FILL

WATER VENT HOSE

ROUTE TO DECK

FILL VENT

ROUTE TO

ENTERTAINMENT

CENTER

PORT

STBD

FWD

CONNECTION

FOR TRANSOM

SHOWER

FLEXIBLE HOSE

DETAIL B

DETAIL A

SEE PUMP

DETAIL B

SEE DETAIL A

FOR WATER

TANK FITTINGS

VENT

CONNECTION

FILL HOSE

CONNECTION

PUMP

CONNECTION

HEAD FAUCET /

PULLOUT SHOWER

COCKPIT WET

BAR FAUCET

TO TRANSOM

SHOWER

PORT

STBD

FWD

WATER PUMP &

FILTER

17

290 Select EX

FORWARD SUMP HOSE ROUTING

(SHOWER SUMP)

(

FIG. 17.1)

FROM

HEAD SINK

FROM AFT

SUMP PUMP

TO OVERBOARD

THROUGH HULL

FITTING

AFT

SUMP PUMP

FORWARD SUMP

(SHOWER SUMP)

FROM FORWARD

SUMP PUMP TO OVERBOARD

THROUGH HULL FITTING

FROM HEAD FLOOR PAN

TO FORWARD SUMP

PORT

STBD

FWD

18

290 Select EX

GREY WATER SYSTEM LINE ROUTING (OPTION)

(LOCATED BELOW COCKPIT HATCH)

(FIG. 18.1)

GREY WATER SYSTEM (OPTION)

The grey water system option is available for boats

operating in areas with overboard discharge restrictions.

The grey water system drains all water into the en-

closed sump where it is pumped into a holding tank. If

you are operating your boat in areas with discharge

restrictions the holding tank must be emptyed at a

pump-out station. Refer to the Grey Water section in

the owner’s manual.

FROM AFT SUMP PUMP

TO OVERBOARD

FROM

HEAD SINK

FORWARD SUMP

PUMP

FROM FORWARD

SUMP PUMP

FROM

HEAD SINK

GREY WATER

HOLDING TANK

FROM COCKPIT

ENTERTAINMENT

CENTER

TO FORWARD SUMP

AFT SUMP

PUMP

TO GREY WATER HOLDING

TANK DECK PLATE

TO GREY WATER HOLDING

TANK HULL VENT

FROM HEAD

FLOOR PAN

PORT

STBD

FWD

Page is loading ...

Sea Ray 2006 290 SELECT EXECUTIVE Supplement Owner's manual

This manual is also suitable for

Sea Ray 2006 290 SELECT EXECUTIVE Supplement Owner's manual

Related papers

Other documents