Kohler OPIAZ Installation & User Manual

Kohler
Brand
Kohler
Model
OPIAZ
Type
Installation & User Manual

This manual is also suitable for

1102602-A2-D
Installation&UserGuide
Dual-FlushToilet
OPIAZ
ESCALEPERSUADE
PANACHE
OVE
PARLIAMENT
1102602-A2-D 2 KohlerCo.
Thank You For Choosing Kohler Company
Before You Begin
Tools and Materials
CAUTION: Risk of personal injury or product damage. Handle
with care. Vitreous china can break or chip if the product is handled
carelessly.
Observe all local plumbing and building codes.
Carefully inspect the new toilet for damage.
If the existing toilet does not have a supply shut-o valve below the
cistern, install one before installing the new toilet.
Install sucient backing behind the nished wall to provide a secure
material for the anchoring devices.
We appreciate your commitment to Kohler quality. Please take a few
minutes to review this manual before you start installation. If you
encounter any installation or performance problems, please don’t hesitate to
contact us. Our phone numbers are listed on the back cover. Thanks again
for choosing Kohler Company.
KohlerCo. 3 1102602-A2-D
Installation
2  Dene the position of connector: Place the connector onto the pan, position
between outlet and waste pipe.
1 Remove the existing toilet: Turn o the water supply and ush the toilet, then
sponge out all remaining water from the cistern. Disconnect the supply shut-o
valve (if present), and remove the old pan and cistern.
CAUTION: Risk of hazardous gases. If the new toilet is not installed immediately,
temporarity stu a rag in the closet ange.
3 Position the template on the oor. Mark the positions of the oor xing kit holes.
Waste Pipe
Waste Pipe
A
B
Connector to Wall Connector to Wall
Wall
Wall
Case 1 Case 2
Finished
Wall
Finished
Wall
Pan
Connector
Waste Pipe
Connector
Waste Pipe
Connector
X
Pan
X
Case 3
Finished
Wall
Connector
Waste Pipe
Connector
Pan
X
Offset Pan Collar
X = Set out as per spec sheet
1102602-A2-D 4 KohlerCo.
4 Bracket
  Drill 3/8” (10 mm) xing holes at the marked locations on the oor and insert
the anchor. Install the washer and insert the hexagon screw into the bracket
then tighten the screw. Position the toilet in the installed position. Install the
sleeves, tighten the screw and aach the caps.
Floor xing option
5 Screw
  Drill 5/16” (8 mm) mounting holes at the marked locations. Insert anchors into
the holes. Place the toilet and align with anchoring holes position. Tighten screws
and aach the bolt caps.
Anchor
Screw
Sleeve
Hole
Cap
Hexagon
Lag Screw
Bracket
Washer
Anchor
Fixing Holes
Screw Cap
Screw
Anchor
Sleeve
Drill
KohlerCo. 5 1102602-A2-D
Installation
6 In cistern.
Optional Bottom Water Inlet Kit
148794A-NA for use on
OPIAZ
PARLIAMENT
PERSUADE
ESCALE
Stop Valve
Tank Hose
OVE
PANACHE
OPIAZ
PARLIAMENT
PERSUADE
ESCALE
1102602-A2-D 6 KohlerCo.
Tank xing option
8 Connect the supply shut-o valve to the supply hose and connect supply hose
to toilet supply shank.
7 Position the cistern on the pan by centering the gasket on the pan inlet.
Assemble the retaining washing and sealing washer to the screw. Securely tighten
the screw so the cistern is level.
Gasket
Screw
Retaining Washer
Plan Washer
Fiber Washer
Sealing Washer
Screw
Washer
Screw
Nut
Plastic*
Brass*
* Optional for different product
Water
Supply
Hose
Water Supply Hose
(Not supplied)
Rear Inlet TypeBottom Inlet Type
KohlerCo. 7 1102602-A2-D
Install the Push Buttons
1 Disassemble the push rods.
2 Using the push rod, measure the
distance between the ush valve and
the top of the tank lid. Mark this
lengh and cut the push rod to length.
Cut the push rod to length.
3 Reassemble the push rods. 4 Fit the lid and test the buons. Adjust
the rods as required.
1102602-A2-D 8 KohlerCo.
Install Flush Valve
2  Assembly ush valve by pushing
straight down into the canister and
turning le.
Flush Valve B
1 Release ush valve by squeezing
the tabs on both side of the canister
and pulling straight up out of the
ush valve.
2 Assembly ush valve by pressing it
into the ush valve so it snaps into
place.
Flush Valve A
1 Release ush valve by turning righ
and pull straight up on the canister.
1
2
1
2
KohlerCo. 9 1102602-A2-D
1102602-A2-D 10 KohlerCo.
KohlerCo. 11 1102602-A2-D
1102602-A2-D
CALL US FOR HELP
NEWZEALAND AUSTRALIA
KOHLERNZLTD KOHLERCO.
FreePh:0800564537(0800KOHLER) FreePh:1300658277
FreeFax:0800664488 FreeFax:0296181189
www.kohler.co.nz www.au.kohler.com
CONTACT AND WARRANTY INFORMATION
Forwarrantyinformation,pleasevisitourwebsite
Australia
www.au.kohler.com.
New Zealand
www.kohler.co.nz
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12

Kohler OPIAZ Installation & User Manual

Kohler
Brand
Kohler
Model
OPIAZ
Type
Installation & User Manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents