Lexus RC350 2015 Pre-Delivery Service Manual

Lexus
Brand
Lexus
Model
RC350 2015
Category
Cars
Type
Pre-Delivery Service Manual

This manual is also suitable for

RC350/RCF Pre-Delivery Service Manual
Lexus Technician:
Before you perform Pre-Delivery Service (PDS) on this vehicle, be sure you:
 •ReadandunderstandthisPDSManual
 •ReadandunderstandallapplicablePDSTechnicalServiceInformationBulletins(TSIBs)forthisvehicle
 •ReadandunderstandthePDSPrecautionsintheTSIBs.
 •Attendthe“TechnicalIntroductiontoLexusCourseL005”attheLexusAreaOfce
When performing PDS on this vehicle:
 •UsethePDSManualwhenperformingthisservice
 •ChecktheTechnicalInformationSystem(TIS)foranyupdatedPDSTSIBsthatapplytothemodelyouare
 servicing
 •VerifythattheVehicleIdenticationNumber(VIN)onrepairorderandvehiclematch
 •Liftvehicleandperformundervehiclesafety/damageinspection
 •Roadtestvehiclelongenoughtotesthotengineanddriveoverroughroad(Bottdots)totestforrattles/
 squeaks
 •WhenPDSiscompleted,signVehicleDeliveryCerticate,locatedintheglovebox
The following TSIBs are available on TIS:
 D/C CutFuseInstallationduringPDS
 InitialCalibrationofCompassduringPDS
 FrontLicensePlate& MountingBracketInstallation
 FrontWheelOpeningExtensionPadInstallationduringPDS
 TirePressureWarningSystemInitialization
TPWS Operation Verication
1.ConnectTechstreamtoDLC3.
2.Adjustalltires(exceptthesparetire)tothestandardtireinationpressure,asindicatedonthetireand
 loadinginformationlabelonvehicle.
NOTE:
 •Toadjusttirepressurecorrectlywhenoutsidetemperatureissignicantlycolderorwarmerthanshop
 temperature,performaHealthCheckusingTechstreamandselectthe“CompensationTirePressure”
 checkbox.CompensationpressureswillbedisplayedontheHealthCheckresultsscreen.
 •Adjustthetirepressurewhenthetiresarecold.
To obtain PDS material:
Manual
 •DownloadfromTISwebsiteorLexusCustomerServiceswebsiteonDealerdaily
 •OrderfromMDC,00242-PDSRC-MAN15
CheckSheet
 •DownloadandprintfromTISwebsiteorLexusCustomerServiceswebsiteonDealerDaily,or
 •OrderfromMDC,00242-PDSRC-CK15,eachpacketcontains25CheckSheets
 •Sheetistwo-sided,backsidehasproceduretips
VehicleDeliveryCerticate
 •OrderfromMDC,00242-TIQ15
OtherPDSTSIBs
 •DownloadfromTISwebsite
Contact your District Service & Parts Manager if you have any questions.
MDC#00242-PDSRC-MAN15 JBS20141113
©2014Lexus,aDivisionofToyotaMotorSalesUSA,Inc.
2015MY
RC350/RCF
Pre-Delivery
Service Manual
RC350/RCF
INSPECTION DETAILS
A.ENGINECOMPARTMENT........................................................ 1
B.LOCKSANDLIGHTS................................................................ 5
C.LEFTFRONT............................................................................. 11
D.LEFTREAR............................................................................... 34
E.TRUNK...................................................................................... 36
F. RIGHTREAR............................................................................. 38
G.RIGHTFRONT.......................................................................... 39
H.FRONTBUMPER...................................................................... 42
I. UNDERVEHICLE(SAFETY/DAMAGE).................................... 45
J. ROADTEST.............................................................................. 46
COMPLETION .......................................................................................54
INDEX ...................................................................................................57
I
TABLE OF CONTENTS
RC350/RCF
1Relay block............................................................................................................-
2Battery.................................................................................................................. 3
3Engineoilleveldipstick........................................................................................ 2
4Enginecoolantreservoir....................................................................................... 3
5Engineoilllercap............................................................................................... 2
6Brakeuidreservoir.............................................................................................. 2
7Washeruidtank.................................................................................................. 4
8Electriccoolingfans............................................................................................ 48
9Condenser............................................................................................................. -
10Radiator.................................................................................................................-
Page
NOTE:
Install protective fender covers prior to beginning the under-hood inspection.
RC350
II
TABLE OF CONTENTS
RC350/RCF
RCF
1Relay block............................................................................................................-
2Battery.................................................................................................................. 3
3Engineoilleveldipstick........................................................................................ 2
4Enginecoolantreservoir....................................................................................... 3
5Engineoilllercap............................................................................................... 2
6Brakeuidreservoir.............................................................................................. 2
7Washeruidtank.................................................................................................. 4
8Electriccoolingfans............................................................................................ 48
9Condenser............................................................................................................. -
10Radiator.................................................................................................................-
III
TABLE OF CONTENTS
RC350/RCF
Engineswitch....................................................................................................... 8
Transmissionshiftlever...................................................................................... 47
Meters...................................................................................................................-
Multi-informationdisplay..................................................................................... 24
Parkingbrake..................................................................................................... 48
Turnsignallever................................................................................................... 9
Headlightswitch................................................................................................... 9
Windshieldwiperandwasherswitch.................................................................. 18
Emergencyasherswitch.................................................................................. 10
Trunkopener...................................................................................................... 17
Hoodlockreleaselever........................................................................................ 2
Tiltandtelescopicsteeringcontrolswitch*......................................................... 24
Tiltandtelescopicsteeringreleaselever*.......................................................... 24
Airconditioningsystem....................................................................................... 25
Audiosystem...................................................................................................... 26
Trunkopenermainswitch.................................................................................. 17
Page
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1 5 
6
*Ifequipped
IV
TABLE OF CONTENTS
RC350/RCF
Audioremotecontrolswitches............................................................................27
Paddleshiftswitches.............................................................................................-
Metercontrolswitches........................................................................................24
Vehicle-to-vehicledistancebutton*.....................................................................50
Cruisecontrolswitch*.........................................................................................50
LDAswitch*........................................................................................................49
Talkswitch..........................................................................................................27
Telephoneswitches............................................................................................27
Page
*Ifequipped
1
2
3
4
5
6
7
8
V
TABLE OF CONTENTS
RC350/RCF
*Ifequipped
Insiderearviewmirror.........................................................................................32
Sunvisors...........................................................................................................31
Vanitymirrors......................................................................................................31
Interiorlight.........................................................................................................16
Personallights....................................................................................................16
Moonroofswitches*...........................................................................................32
SOSbutton*........................................................................................................33
Garagedooropenerswitches............................................................................33
Page
1
2
3
4
5
6
7
4
VI
TABLE OF CONTENTS
RC350/RCF
*Ifequipped
Drivingpositionmemoryswitches*......................................................................14
Outsiderearviewmirrorswitches........................................................................16
Doorlockswitches...............................................................................................15
Powerwindowswitches.......................................................................................15
Windowlockswitch.............................................................................................15
Tirepressurewarningresetswitch........................................................................ -
PCSOFFswitch*.................................................................................................11
Page
1
2
3
4
5
6
7
VII
TABLE OF CONTENTS
RC350/RCF
*Ifequipped
Seatheaterswitches*......................................................................................... 31
Seatventilatorswitches*.................................................................................... 31
Heatedsteeringwheelswitch*........................................................................... 31
Drivingmodeselectswitch................................................................................. 51
TVDswitch*........................................................................................................ 51
Snowmodeswitch.............................................................................................. 51
VSCOFFswitch................................................................................................. 52
Remotetouch*.................................................................................................... 28
Lexusdisplayaudiocontroller*.......................................................................... 28
Page
1
2
3
4
5
6
7
8
9
VIII
TABLE OF CONTENTS
RC350/RCF
Automatichighbeamswitch*............................................................................. 10
Windshieldwiperde-icerswitch*........................................................................ 16
Activerearwingswitch*...................................................................................... 30
Odometer/tripmeterandtripmeterresetbutton................................................ 17
Instrumentpanellightcontrolswitches............................................................... 17
Intuitiveparkingassistswitch*............................................................................ 29
BSM(BlindSpotMonitor)mainswitch*.............................................................. 17
ASCswitch*........................................................................................................ 53
Page
1
2
3
4
5
6
7
8
*Ifequipped
RC350
RCF
IX
TABLE OF CONTENTS
RC350/RCF
INSPECTION DETAILS
WASHING VEHICLE
Afterwashingvehicle,makesurealladhesivewrappinglm
isremoved.
NOTE:
Handwashingisrecommended.
WATER LEAK TEST
Visuallyandbyhandcheckforwaterleaksinthevehicle
interiorfromeachofthefollowingareas(makesurethatthe
trimandoorcarpetarenotdamp):
a)Doorglassweatherstrips
b)Frontcowlsides
c)Aroundthewindshield
d)Aroundthemoonroofarea
e)Aroundthequarterwindow
f)Aroundtherearwindow
PAINT FINISH (PAINT DEFECTS, DAMAGE)
Visuallyandbyhandinspectallbodypanels(doors,trunk,
fenders,enginehood,roofpanel)forsurfacedamagefrom
shipmentoranyforabnormalities(surfacerust,paintaking,
chips,dentsorscratches).
NOTE:
Carefullyinspectallpaintedsurfacesinawell-illuminated
area(800-luxilluminationisrecommended).
EXTERIOR PARTS FOR FIT
Visuallyandbyhandcheckthefollowingpartsforproper
installation,rust,t,misalignmentandlooseitems:
a)Frontandrearbumpers
b)Windowmoldings(front,sideandrear)
c)Lexusemblems(frontandrear)
d)Outsiderearviewmirrors
e)Headlights,turnsignallights,sidemarkerlights,fog 
 lightsandtaillightlenses
f)Doors,enginehoodandfuelllerdoor
g)Moonroof
h)Front/Reardoorpanelprotector
i)Outsidedoorhandle
j) Radiatorgrille
1RC350/RCF
INSPECTION DETAILS - A. ENGINE COMPARTMENT
ENGINE HOOD RELEASE LEVER
Usetheenginehoodreleaselevertocheckthatthelatch
operatesproperly.Ensurethattheenginehoodopensand
closessmoothly.
BRAKE FLUID LEVEL
Visuallychecktheuidlevelthroughthereservoir.Ifthe
uidlevelislow,replenishthebrakeuidreservoirwith
FMVSSNo.116DOT3,FMVSSNo.116DOT4or
SAEJ1703brakeuidandcheckforuidleaks.Brakeuid
levelshouldbeatthe“MAX”line(within0.2inches[5.0
mm]below).
NOTE:
RefertotheRepair Manualforuidspecications.
RC350shown(RCFsimilar)
RC350shown(RCFsimilar)
ENGINE OIL LEVEL (ENGINE NOT
RUNNING)
a)Removetheengineoilleveldipstickandwipeitclean. 
Reinsertthedipstickandpullitouttochecktheoillevel. 
 Thelevelshouldbebetweenthetwomarks.
1Low
2Normal
  Excessive
b)Checktheoilfordirtorimpurities.
NOTE:
Iftheoillevelislow,addspeciedengineoilandcheck 
foroilleaks.
3
2RC350/RCF
INSPECTION DETAILS - A. ENGINE COMPARTMENT
ENGINE COOLANT LEVEL
Visuallycheckthecoolantlevelthroughthecoolant
reservoirtankwhentheengineiscool.Thecoolantlevelis
satisfactoryifthelevelisbetweenthe“FULL”and“LOW”.
1Reservoircap
2“FULL”
3“LOW”
Onlyuse“ToyotaSuperLongLifeCoolant.”
CAUTION:
Topreventburningyourself,donotremovetheradiatorcap
whentheengineishot.
BATTERY TERMINAL TIGHTNESS AND
CHARGE
a)Checktheelectrolytelevel.Iftheelectrolytelevelislow, 
 checkthebatterycaseforleakage.
b)Checkthebatterycharge.Measuretheopen-circuit 
 batteryvoltagebetweentheterminals.Ifthevoltage
 readingislessthan12.6volts,rechargethebattery.
NOTE:
Beforemeasuringthevoltage,turnofftheengineandall
electricalsystems.Wait60secondstoremovethesurface
charge.Iftheenginewasrunningbeforemeasuringthe
voltage,wait20minutesaftertheenginestopstoremove
thesurfacecharge.
c)Checkthatthebatteryterminalsareproperlyconnected 
 andthattheclampisrmlyinstalled.
  Terminals
  Hold-downclamp
1
2
RC350
RCF
3RC350/RCF
INSPECTION DETAILS - A. ENGINE COMPARTMENT
WASHER FLUID LEVEL
Openthewashertankcapandvisuallycheckthewasher
uidlevelinthewashertank.Theuidlevelshouldbelled
within2inchesofthecap.
WIRING AND HOSES
a)Checkthehoses,hoseconnectorsandvariousclamps 
 fortightness.
b)Visuallyinspecttheconditionofallharnessconnectors 
 andterminalsforproperinstallationandtightness.
RC350shown(RCFsimilar)
4RC350/RCF
INSPECTION DETAILS - A. ENGINE COMPARTMENT
WIRELESS REMOTE CONTROL
Inspectthevefunctionsofthesystem.
1Locksthedoors
2Unlocksthedoors
3Opensthetrunk(Pressandhold)
4Soundsalarm(Pressandhold)
a)Lockingthedoors
 1. Closeallthedoors.
 2. Press ontheelectronickeytolockallthedoors 
  fromoutsidethevehicle.
NOTE:
  When ispressedtolockdoors,abeepwill 
 soundandallturnsignallightswillashonce.
  However,ifanydoorisnotclosedsecurely,
  pressing willcausethebuzzertosound 
  continuouslyuntilalldoorsareproperlyclosed.
b)Unlockingthedoors
 1. Press ontheelectronickeyoncetounlockthe 
  driver’sdoor.
 2. Press onceagainwithin3secondstounlockthe
  otherdoors
NOTE:
  Theinteriorlightandouterfootlightswill
  turnonandalltheturnsignallightsashtwice,
  soundingtwobeeps.
 3. Checkthatalldoorsautomaticallyre-lockafter60
  secondsifanydoorisnotopened.
c)Openingthetrunk
Pressandhold toopenthetrunk.
NOTE:
 Abuzzersoundstoindicatethatthetrunkisopening.
d)Soundingthealarm
 1. Pressandhold tosoundthealarm.
2. Tostopthealarm,pressanybutton.
1
2
3
4
5RC350/RCF
INSPECTION DETAILS - B. LOCKS AND LIGHTS
SMART ACCESS SYSTEM
a)Withelectronickeyinsideofthevehicle,touchthelock 
 sensor(ontheupperpartofthedoorhandle)andtrunk
 lockbutton.Checkthatthebuzzersoundsandthat
 thedoorsdonotlock.
b)Taketheelectronickeyandgetoutofthevehicle.Touch 
 thelocksensor(ontheupperpartofthedoorhandle).
 Checkthatthedoorlocks.
NOTE:
 Recognitionsignalsforthelockoperationwilloperate
 uptotwoconsecutivetimes.
c)Fromadistanceofatleast2.3ft.(0.7m),approachthe 
 vehicleandpullthedriverandpassengersidedoor
 handles,andthetrunkopener.Checkthatthedoor
 unlocks.
NOTE:
 Thedoorscannotbeunlockedfor3secondsafterthe
 doorsarelocked.
THEFT DETERRENT SYSTEM
Withthedoorslocked,checkthatthesystemoperates
properly.
System Test:
a)Openthewindows.
b)Lockthedoorsbysmartaccesssystem,wireless 
 remotecontrolormechanicalkey.Besuretowaituntil
 thesecuritylightonthecenterpanelstartsashing.
c)Unlockoneofthedoorsusingtheinsidedoorlock.The 
systemshouldactivatethealarm(soundingofthehorn, 
 blinkingoftheheadlights,taillightsandemergency
 asher,lightingupinteriorlight).
d)Cancelthesystembyunlockingdoorswiththesmart 
 accesssystem,wirelessremotecontrolormechanical
 key.
IMMOBILIZER SYSTEM
a)Checkthatthesecurityindicatorlightasheswhenthe 
 “ENGINE”switchisOFF.
b)Checkthattheenginecanbestartedusingall 
 thekeys.
c)Checkthatthesecurityindicatorlightturnsoffwhen 
 startingtheengine.
6RC350/RCF
INSPECTION DETAILS - B. LOCKS AND LIGHTS
DOOR LOCK SYSTEM AND ILLUMINATED
ENTRY SYSTEM
a)Checkthatalldoorsopenandclosesmoothlyusingthe 
 insideandoutsidedoorhandles.
b)Checkthatthedoorscannotbeopenedbyusingthe 
 insideandoutsidedoorhandleswhenthelockbuttonis
 inthelockedposition(exceptfrontinsidedoorhandles).
c)Forfrontinsidedoorhandles:Checkthatthefrontdoors 
 canbeopenedbyusingtheinsidedoorhandleswhen
 thelockbuttonisinthelockposition.
d)Checkexteriorkeylockcontrolsystemoperationby 
 mechanicalkey(withdriver’sdoor).
1Locksbothsidedoors
2Unlocksthedoor(two-stepunlockfunction):
1.Turnthekeyoncetounlockthedriver’sdoor.
2.Turnthekeytwicetounlockallthedoors.
e)Checkthattheouterfootlightilluminateswhenthe
 doorisopened.
REMOTE ENGINE STARTER*
a)StartingtheEngine
  1. Closeandlockalldoors.
  2. Quicklypress twiceandthenpressandhold
   for3seconds.
NOTE:
   Whentheenginestarts,thehazardlightswillashfor
   20seconds.
b)StoppingtheEngine
  1. Press orpressandhold for2seconds.
*Ifequipped
OUTERFOOTLIGHT
7RC350/RCF
INSPECTION DETAILS - B. LOCKS AND LIGHTS
RC350shown(RCFsimilar) POWER SUPPLY CHANGEOVER AND
ENGINE START/STOP
Checkforproperactivationofthe“ENGINE”switch.
Powersupplychangeover
a)Carrytheelectronickeyinthevehicleandapplythe 
 parkingbrake.
b)Withoutdepressingthebrakepedal,pressthe 
 “ENGINE”switchandchangethepowersupply.
  OFF
  Pressonce:ACCESSORYmode
  Presstwice:”IG-ON”mode
c)Ineachmode,checkthatthepowersupplyhaschanged
 properly.
Engine start/stop
a)Carrytheelectronickeyinthevehicleandapplythe 
 parkingbrake.
b)Checkthattheshiftleverisinthe“P”position.
c)Whiledepressingthebrakepedal,pressthe“ENGINE”
 switch.
EXTERIOR LIGHTS
Walkaroundthevehicleandcheckthatthefollowinglights
illuminate:
a)Headlights
b)Parkinglightsanddaytimerunninglights
c)Frontsidemarkerlights
d)Sideturnsignallights
e)Stop/taillights
f)Taillights
g)Rearsidemarkerlights
h)Highmountedstoplight
i) Licenseplatelights
j) Outerfootlights
1
2
3
8RC350/RCF
INSPECTION DETAILS - B. LOCKS AND LIGHTS
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
Page is loading ...
  • Page 1 1
  • Page 2 2
  • Page 3 3
  • Page 4 4
  • Page 5 5
  • Page 6 6
  • Page 7 7
  • Page 8 8
  • Page 9 9
  • Page 10 10
  • Page 11 11
  • Page 12 12
  • Page 13 13
  • Page 14 14
  • Page 15 15
  • Page 16 16
  • Page 17 17
  • Page 18 18
  • Page 19 19
  • Page 20 20
  • Page 21 21
  • Page 22 22
  • Page 23 23
  • Page 24 24
  • Page 25 25
  • Page 26 26
  • Page 27 27
  • Page 28 28
  • Page 29 29
  • Page 30 30
  • Page 31 31
  • Page 32 32
  • Page 33 33
  • Page 34 34
  • Page 35 35
  • Page 36 36
  • Page 37 37
  • Page 38 38
  • Page 39 39
  • Page 40 40
  • Page 41 41
  • Page 42 42
  • Page 43 43
  • Page 44 44
  • Page 45 45
  • Page 46 46
  • Page 47 47
  • Page 48 48
  • Page 49 49
  • Page 50 50
  • Page 51 51
  • Page 52 52
  • Page 53 53
  • Page 54 54
  • Page 55 55
  • Page 56 56
  • Page 57 57
  • Page 58 58
  • Page 59 59
  • Page 60 60
  • Page 61 61
  • Page 62 62
  • Page 63 63
  • Page 64 64
  • Page 65 65
  • Page 66 66
  • Page 67 67
  • Page 68 68
  • Page 69 69

Lexus RC350 2015 Pre-Delivery Service Manual

Lexus
Brand
Lexus
Model
RC350 2015
Category
Cars
Type
Pre-Delivery Service Manual
This manual is also suitable for
Download PDF
report

Ask a question and I''ll find the answer in the document

Finding information in a document is now easier with AI

Related papers

Other documents