Groen TS /9 Stand, TS 9S Stand User manual
- Category
- Food warmers
- Type
- User manual
Groen TS /9 Stand, TS 9S Stand is intended for professional food service use only, as described in this manual.
Groen TS /9 Stand, TS 9S Stand is intended for professional food service use only, as described in this manual.
Model TS /9S [with Drain
C art] and TDB /7 K ettle
Model TS /9S [with Drain C art] s hown with
TD/F P C B rais ing P an
OP E R A TOR MA NUA L OM-T S /9
P art Number 121040 R ev. B DOME S T IC
MODE L : TS /9 S tand [Only]
TS /9S S tand [with Drain C art]
S tainles s S teel
S elf-Draining
F or Us e with Table-Top E quipment
F OR Y OUR S A F E T Y
DO NOT S T OR E OR US E G A S OL INE OR OTHE R F L AMMAB L E VA P OR S
AND L IQUIDS IN THE VIC INITY OF THIS OR A NY OTHE R A P P L IANC E .
WAR NING
THIS DE V IC E IS INTE NDE D F OR P R OF E S S IONAL FOOD S E R VIC E US E
ONL Y, AS DE S C R IB E D IN T HIS MANUA L . DO NOT S T AND OR C L IMB
ON IT AT ANY T IME . DO NOT US E IT F OR S TOR AG E OR ANY OT HE R
P UR P OS E F OR WHIC H IT WAS NOT DE S IG NE D.
S ee the appropriate equipment
Operator Manual for applicable
Ins ta lla tion, O peration and
C leaning Ins tructions .
IMPORTANT INFORMATION I KEEP FOR OPERATOR I IMPORTANT INFORMATION
OPERATOR MANUAL
Part Number 121040 Rev. B
Information contained in this document is
known to be current and accurate at the time
of printing/creation. Unified Brands recom-
mends referencing our product line websites,
unifiedbrands.net, for the most updated
product information and specifications.
OM-TS/9
2
IMPORTANT — READ FIRST — IMPORTANT
CAUTION: BE SURE ALL OPERATORS READ, UNDERSTAND AND FOLLOW THE OPERATING
INSTRUCTIONS,
CAUTIONS, AND SAFETY INSTRUCTIONS IN THIS MANUAL.
WARNING: THE EQUIPMENT AND SUPPORT STAND ARE INTENDED FOR USE IN
COMMERCIAL HEATING, COOKING AND HOLDING OF WATER AND FOOD
PRODUCTS, PER THE INSTRUCTIONS CONTAINED IN THIS AND THE
APPROPRIATE EQUIPMENT OPERATOR MANUAL. ANY OTHER USE COULD
RESULT IN SERIOUS PERSONAL INJURY OR DAMAGE TO THE EQUIPMENT AND
WILL VOID WARRANTY.
WARNING: DO NOT STAND OR CLIMB ON THE STAND AT ANY TIME. DO NOT USE IT FOR
STORAGE OR ANY OTHER PURPOSE FOR WHICH IT WAS NOT DESIGNED.
WARNING: EQUIPMENT MUST BE INSTALLED BY PERSONNEL QUALIFIED TO WORK WITH
ELECTRICITY AND AS NECESSARY, WITH GAS. IMPROPER INSTALLATION CAN
RESULT IN INJURY TO PERSONNEL AND/OR DAMAGE TO EQUIPMENT.
DANGER: ELECTRICALLY GROUND THE UNIT AT THE TERMINAL PROVIDED. FAILURE TO
GROUND UNIT COULD RESULT IN ELECTROCUTION AND DEATH.
WARNING: AVOID ALL DIRECT CONTACT WITH HOT EQUIPMENT SURFACES. DIRECT SKIN
CONTACT COULD RESULT IN SEVERE BURNS.
WARNING: AVOID ALL DIRECT CONTACT WITH HOT FOOD OR WATER IN KETTLES AND
BRAISING PANS. DIRECT CONTACT COULD RESULT IN SEVERE BURNS.
CAUTION: DO NOT OVER FILL UNITS WHEN COOKING, HOLDING OR CLEANING. KEEP
LIQUIDS A MINIMUM OF 2-3” (5-8 cm) BELOW THE BODY RIM TO ALLOW
CLEARANCE FOR STIRRING, BOILING AND SAFE PRODUCT TRANSFER.
WARNING: TAKE SPECIAL CARE TO AVOID CONTACT WITH HOT UNIT BODY OR HOT
PRODUCT WHEN ADDING INGREDIENTS, STIRRING OR TRANSFERRING
PRODUCT TO ANOTHER CONTAINER.
WARNING: WHEN TILTING EQUIPMENT FOR PRODUCT TRANSFER:
1) WEAR PROTECTIVE OVEN MITT AND PROTECTIVE APRON.
2) USE CONTAINER DEEP ENOUGH TO CONTAIN AND MINIMIZE PRODUCT
SPLASHING.
3) PLACE CONTAINER FULLY IN DRAIN BASIN OR ON TOP OF COMPLETELY
CLOSED SPLASH SHIELD COVER, AS CLOSE TO THE UNIT AS POSSIBLE.
4) POUR SLOWLY, MAINTAIN CONTROL OF UNIT BODY AT ALL TIMES, AND
RETURN IT TO THE UPRIGHT POSITION AFTER CONTAINER IS FILLED OR
TRANSFER IS COMPLETE.
5) DO NOT OVER-FILL CONTAINER(S). AVOID DIRECT SKIN CONTACT WITH HOT
CONTAINER AND CONTENTS.
CAUTION: KEEP
FLOORS IN FRONT OF WORK AREA CLEAN AND DRY. IF SPILLS OCCUR,
CLEAN
IMMEDIATELY, TO AVOID SLIPS OR FALLS.
WARNING: BEFORE REPLACING ANY PARTS, DISCONNECT THE UNIT FROM THE ELECTRIC
POWER SUPPLY.
WARNING: KEEP WATER AND SOLUTIONS OUT OF CONTROLS AND ELECTRICAL
EQUIPMENT. NEVER SPRAY OR HOSE SUPPORT HOUSING OR ELECTRICAL
CONNECTIONS.
2
OM-TS/9
OM-TS/9
3
IMPORTANT — READ FIRST — IMPORTANT
CAUTION: MOST CLEANERS ARE HARMFUL TO THE SKIN, EYES, MUCOUS MEMBRANES
AND CLOTHING. PRECAUTIONS SHOULD BE TAKEN. WEAR RUBBER GLOVES,
GOGGLES OR FACE SHIELD AND PROTECTIVE CLOTHING. CAREFULLY READ
THE WARNINGS AND FOLLOW THE DIRECTIONS ON THE LABEL OF THE
CLEANER TO BE USED.
CAUTION
: USE OF ANY REPLACEMENT PARTS OTHER THAN THOSE SUPPLIED BY GROEN
OR
AUTHORIZED GROEN DISTRIBUTORS CAN CAUSE OPERATOR INJURY AND
DAMAGE TO THE EQUIPMENT, AND WILL VOID ALL WARRANTIES.
IMPORTANT
: SERVICE PERFORMED BY OTHER THAN FACTORY AUTHORIZED PERSONNEL
WILL VOID WARRANTIES.
3
OM-TS/9
4
OM-TS/9
OM-TS/9
5
f. Lift and position the drain cart over the front
frame cross member and straddle the drain
trough, with casters just inside the
reinforcing cross bar. Align cart and drain
trough with the center of the kettle or
braising pan pour lip.
g. Fit the splash guard onto the drain cart hinge
pins.
h. Extend the drain line to the nearest floor sink
or drain. Refer to local plumbing codes for
drain line connections. A recommended 90∫
elbow installation is shown below.
Proceed with installation of the kettle or braising
pan as described in its Operator Manual.
5
OM-TS/9
OM-TS/9
6
Side-by-Side Stand Assembly
Several stands may be installed side by side,
using the Stand Clamp Kit (P/N 127240) as
follows (see photos):
a. Level stands so that the outsides of adjacent
legs are even (flush) with one another.
b. Remove adjacent mounting bolts (front and
rear) from under the stand, discarding their
flat washers.
c. Install the brackets (front and rear) as
shown.
d. Reinstall mounting bolts and tighten
securely.
TS/9 and TS/9S stands are extremely
versatile:
The cart
accepts
steamer pans,
and includes a
splash guard to
minimize spills
.
The Drain Cart
is conveniently
stored beneath
the kettle (or
braising pan).
...and pulls out
easily to be
used with the
drain
.
With the splash
guard down,
almost any
container size
may be used.
6
OM-TS/9
OM-TS/9
7
Limited Warranty
To Commercial Purchasers *
(Domestic U.S., Hawaii &
Canadian Sales Only)
Groen Foodservice Equipment ("Groen Equipment") has been skillfully manufactured, carefully inspected and
packaged to meet rigid standards of excellence. Groen warrants its Equipment to be free from defects in
material and workmanship for (12) twelve months with the following conditions and subject to the following
limitations.
I. This parts and labor warranty is limited to Groen Equipment sold to the original commercial
purchaser/users (but not original equipment manufacturers), at its original place of installation in the
continental United States, Hawaii and Canada.
II. Damage during shipment is to be reported to the carrier, is not covered under this warranty, and is
the sole responsibility of purchaser/user.
III. Groen, or an authorized service representative, will repair or replace, at Groen's sole election, any
Groen Equipment, including but not limited to, drawoff valves, safety valves, gas and electric
components, found to be defective during the warranty period. As to warranty service in the territory
described above, Groen will absorb labor and portal to portal transportation costs (time & mileage)
for the first twelve (12) months from date of installation or fifteen (15) months from date of shipment
from Groen.
IV. This warranty does not cover boiler maintenance, calibration, periodic adjustments as specified in
operating instructions or manuals, and consumable parts such as scraper blades, gaskets, packing,
etc., or labor costs incurred for removal of adjacent equipment or objects to gain access to Groen
Equipment. This warranty does not cover defects caused by improper installation, abuse, careless
operation, or improper maintenance of equipment. This warranty does not cover damage caused by
poor water quality or improper boiler maintenance.
V. THIS WARRANTY IS EXCLUSIVE AND IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESSED
OR IMPLIED, INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE, EACH OF WHICH IS HEREBY EXPRESSLY DISCLAIMED. THE
REMEDIES DESCRIBED ABOVE ARE EXCLUSIVE AND IN NO EVENT SHALL GROEN BE
LIABLE FOR SPECIAL, CONSEQUENTIAL OR INCIDENTAL DAMAGES FOR THE BREACH OR
DELAY IN PERFORMANCE OF THIS WARRANTY.
VI. Groen Equipment is for commercial use only. If sold as a component of another (O.E.M.)
manufacturer's equipment, or if used as a consumer product, such Equipment is sold AS IS and
without any warranty.
* (Covers All Foodservice Equipment Ordered After October 1, 1995)
7
OM-TS/9
1055 Mendell Davis Drive
J ackson, MS 39272
Telephone 601 372-3903
F AX 601 373- 9587
www.groen.com
OM-T S /9
P art Number 121040 R ev. B
revised 09/02
OM-TS/9
Part Number 121040 Rev. B
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
Groen TS /9 Stand, TS 9S Stand User manual
- Category
- Food warmers
- Type
- User manual
Groen TS /9 Stand, TS 9S Stand is intended for professional food service use only, as described in this manual.
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Groen TS/9S Operating instructions
-
-
-
-
-
-
-
-
-
