Grape Solar GS-CF-1.1-Fab1 User guide

Brand: Grape Solar

Model: GS-CF-1.1-Fab1

Category: Fridge-freezers

Type: User guide

Grape Solar GS-CF-1.1-Fab1 is a compact and versatile refrigerator/freezer suitable for both AC and DC power sources. With a capacity of 1.1 cubic feet, it offers ample storage space for food and beverages. The adjustable thermostat allows you to set the desired temperature for precise cooling or freezing. Its energy-efficient design and quiet operation make it ideal for use in RVs, boats, and off-grid cabins.

Valid from May 2013

GS-CF-1.1-Fab1

Reference Manual Rev. 130515

www.grapesolar.com

Tel. 1-877-264-1014 (toll free), 1-541-349-9000, Fax: 1-541-343-9000

Grape Solar

DC COMPRESSOR FRIDGE/FREEZER MODEL: Grape Glacier 1.1

INSTRUCTION MANUAL

ENGLISH

Congratulaons on the purchase of the Grape Solar Glacier 1.1 Refrigerator/Freezer. We trust that you will

enjoy many years of trouble free use. Please read the instrucons carefully before using your Refrigerator/

Freezer. This book will provide you with informaon on how to operate and care for your Refrigerator/

Freezer in order to gain the maximum benet from it.

The appliance must be connected to a suitable 120volt or 12 volt socket. The manufacturer and the seller do

not accept responsibility for any damage due to incorrect electrical installaon.

www.grapesolar.com

Tel. 1-877-264-1014 (toll free), 1-541-349-9000, Fax: 1-541-343-9000

Valid from May 2013

GS-CF-1.1-Fab1

Reference Manual Rev. 130515

INPUT REQUIREMENTS

DC Input

Voltage Range:10.9Vdc~28Vdc

Cut Out: 10.4Vdc

Cut In: 11.8Vdc

AC Input

Voltage Range: 120Vdc

TEST-RUN

Do not pull the appliance by the power cord.

Connect power, set the digital thermostat to 0°F and check the indicators, 30 minutes later, open the door

and check the inside surface. If the inside surface is cold, your appliance is working.

OPERATION WITH 120V AC/60 Hz

Connect the appliance to an 120Vac power source using the removable AC cable supplied with the appliance.

In the Temperature window, the current temperature seng will ash for 5 seconds and then automacally

change to display the temperature inside the cabinet.

Press the “Up” or “Down” keys to set the desired temperature.

The set temperature will ash for 5 seconds and then automacally change to display the current tempera-

ture inside the cabinet.

To turn o the appliance, remove the plug from the socket.

OPERATION WITH 12VDC/24V DC

Connect the DC cable supplied with the appliance to a suitable DC socket outlet. A 120 Wa DC socket outlet

is recommended.

DO NOT USE THE CIGARETTE LIGHTER SOCKET OUTLET TO RUN THIS FREEZER BECAUSE IT MAY NOT BE ABLE

TO HANDLE THE HIGH CURRENT.

The appliance will automacally idenfy and apply 12V DC or 24V DC.

In the Temperature window, the current temperature seng will ash for 5 seconds and then automacally

change to display the temperature inside the cabinet.

Press the “Up” or “Down” keys to set the desired temperature.

www.grapesolar.com

Tel. 1-877-264-1014 (toll free), 1-541-349-9000, Fax: 1-541-343-9000

Valid from May 2013

GS-CF-1.1-Fab1

Reference Manual Rev. 130515

The set temperature will ash for 5 seconds and then automacally change to display the current tempera-

ture inside the cabinet.

To turn o the appliance, remove the DC plug from the DC socket.

DEFROSTING AND DEODORIZING

When the ice layer on the inner cabinet sides is over 2/10” the unit should be defrosted before operaon

to improve eciency.

Disconnect power, remove all items and clean unit. Open lid and let unit sit unl all ice has melted. Aer

defrosng, remove excess water and clean unit with a so rag and switch the appliance on.

Note: Never remove ice with sharp objects.

Place an open box of baking soda in the appliance to remove any bad odors.

MAINTENANCE AND REGULAR CLEANING

Always disconnect the power supply before cleaning.

Clean the inside of the cabinet whenever necessary, using a warm soluon of water and baking soda (1 table-

spoon to every 2 liters of water)

Dry with a so cloth.

Dirt from the condenser should be cleaned by a qualied technician when necessary.

NOT A MALFUNCTION

It is normal to hear gurgling sounds caused by the ow of refrigerant when each cooling cycle ends.

The surface temperature of the compressor can reach 160°F -195°F when running.

The noise emied by the cooling fan on the condenser is normal.

SAFETY

A separate grounded 15A socket outlet should be used on 120Vac and at least a 120Wdc socket

on 12Vdc.

In the event of any malfuncon of your freezer, please contact Grape Solar Technical Support.

www.grapesolar.com

Tel. 1-877-264-1014 (toll free), 1-541-349-9000, Fax: 1-541-343-9000

Valid from May 2013

GS-CF-1.1-Fab1

Reference Manual Rev. 130515

MOVEMENT AND INSTALL ATION

When moving the freezer, the angle between the cabinet and the ground should not be more than

45 degrees C in order to protect the compressor and refrigerang system.

Posion the freezer in a dry and well-venlated place. Keep the freezer away from direct sunlight,

heaters and corrosive gases.

The normal operaon of the freezer depends on the heat radiaon of the condenser. For the inial

use, the packing foam must be taken o and at least 6” of open space must be le around the freezer.

MAIN TECHNICAL PARAMETERS

MODEL：GS-CF-1.1-Fab1 SERIAL：NO.

DC COMPRESSOR FRIDGE-FREEZER

NET

VOLUME：1.1CuFt

REFRIGERANT：R134A

GRAMS

INSULA

ION

： CYCLO-

PENTANE

POWER IN

：

AC ,

37W

CURRENT：0.25AMPS

AC,

INPUT

VOL

：

220

240

AC,

CLASS：

MADE IN CHINA

READ MANUFACTURER’S INSTRUCTIONS BEFORE

USE

THIS APPLIANCE MUST BE INSTALLED ACCORDING TO

THE

C-

TURER’S

INST

RUC

ION

TO BE USED ONLY IN WELL

VENTILATED

AREA

www.grapesolar.com

Tel. 1-877-264-1014 (toll free), 1-541-349-9000, Fax: 1-541-343-9000

Valid from May 2013

GS-CF-1.1-Fab1

Reference Manual Rev. 130515

CIRCUIT DIAGRAM

TROUBLESHOOTING

problem Cause Remedy

The compressor runs

for 1～5 minutes and

stops

The voltage is not in the

normal range

Switch off power and

restart when power is

normal

The compressor runs

but inner liner does not

get cold

The refrigerant has

leaked

Contact Grape Solar

The system is blocked

The inner liner is very

cold and the compres-

sor runs continuously.

The controller is faulty Contact Grape Solar

The door is being

opened and closed too

frequently

The door should be

opened as little as pos-

sible

The condenser is not

well-ventilated.

Select a well-ventilated

place

The compressor does

not run

“+” and “-” are switched. Rectify

The controller is faulty

(the power indicator is

not on)

Contact your local deal-

The thermostat is set

too high; the ambient

temperature is too low.

Use as a freezer

The freezer is noisy

The freezer is tilted at a

bad angle.

Make the freezer level

Some parts have come

loose.

Contact Grape Solar

The pipes are touching. Contact Grape Solar

Grape Solar GS-CF-1.1-Fab1 User guide

Brand: Grape Solar

Model: GS-CF-1.1-Fab1

Category: Fridge-freezers

Type: User guide

Download PDF

report

Grape Solar GS-CF-1.1-Fab1 User guide

Grape Solar GS-CF-1.1-Fab1 User guide

Related papers

Other documents