Sierra 595 User manual

AirLink MP595/595W Modem

User Guide

2130795

Rev 1.4 Draft

Preface

Rev 1.4 Draft Mar.08 3

Important Notice Duetothenatureofwirelesscommunications,transmission

andreceptionofdatacanneverbeguaranteed.Datamaybe

delayed,corrupted(i.e.,haveerrors)orbetotallylost.

Althoughsignificantdelaysorlossesofdataarerarewhen

wirelessdevicessuchastheSierraWirelessmodemareusedin

anormal

mannerwithawell‐constructednetwork,theSierra

Wirelessmodemshouldnotbeusedinsituationswherefailure

totransmitorreceivedatacouldresultindamageofanykind

totheuseroranyotherparty,includingbutnotlimitedto

personalinjury,death,orlossofproperty.Sierra

Wireless

acceptsnoresponsibilityfordamagesofanykindresulting

fromdelaysorerrorsindatatransmittedorreceivedusingthe

SierraWirelessmodem,orforfailureoftheSierraWireless

modemtotransmitorreceivesuchdata.

Safety and Hazards DonotoperatetheSierraWirelessmodeminareaswhere

blastingisinprogress,whereexplosiveatmospheresmaybe

present,nearmedicalequipment,nearlifesupportequipment,

oranyequipmentwhichmaybesusceptibletoanyformof

radiointerference.Insuchareas,theSierraWirelessmodem

MUSTBEPOWEREDOFF

.TheSierraWirelessmodemcan

transmitsignalsthatcouldinterferewiththisequipment.

DonotoperatetheSierraWirelessmodeminanyaircraft,

whethertheaircraftisonthegroundorinflight.Inaircraft,the

SierraWirelessmodemMUSTBEPOWE REDOFF.When

operating,theSierraWirelessmodemcantransmitsignalsthat

couldinterferewithvariousonboardsystems.

Note: Some airlines may permit the use of cellular phones while the

aircraft is on the ground and the door is open. Sierra Wireless

modems may be used at this time.

Thedriveroroperatorofanyvehicleshouldnotoperatethe

SierraWirelessmodemwhileincontrolofavehicle.Doingso

willdetractfromthedriveroroperatorʹscontrolandoperation

ofthatvehicle.In somestatesandprovinces, operatingsuch

communicationsdeviceswhileincontrolofavehicle

isan

offence.

Limitation of

Liability

Theinformationinthismanualissubjecttochangewithout

noticeanddoesnotrepresentacommitmentonthepartof

SierraWireless.SIERRAWIRELESSANDITSAFFILIATES

SPECIFICALLYDISCLAIMLIABILIT YFORANYANDALL

DIRECT,INDIRECT,SPECIAL,GENERAL,INCIDENTAL,

CONSEQUENTIAL,PUNITIVEOREXEMPLARYDAMAGES

INCLUDING,BUTNOTLIMITEDTO,LOSS

OFPROFITSOR

AirLink MP595 / MP595W Modem User Guide

4 2130795

REVENUEORANTICIPATEDPROFITSORREVENUE

ARISINGOUTOFTHEUSEORINABILITYTOUSEANY

SIERRAWIRELESSPRODUCT,EVENIFSIERRAWIRELESS

AND/ORITSAFFILIATESHASBEENADVISEDOFTHE

POSSIBILITYOFSUCHDAMAGESORTHEYARE

FORESEEABLEORFORCLAIMSBYANYTHIRDPARTY.

Notwithstandingtheforegoing,innoeventshallSierra

Wirelessand/oritsaffiliatesaggregateliabilityarisingunderor

inconnectionwiththeSierraWirelessproduct,regardlessof

thenumberofevents,occurrences,orclaimsgivingriseto

liability,beinexcessofthepricepaidbythe purchaserforthe

SierraWireless

product.

Patents Portionsofthisproductmaybe coveredbysomeorallofthe

followingUSpatents:

5,515,013 5,629,960 5,845,216 5,847,553 5,878,234

5,890,057 5,929,815 6,169,884 6,191,741 6,199,168

6,339,405 6,359,591 6,400,336 6,516,204 6,561,851

6,643,501 6,653,979 6,697,030 6,785,830 6,845,249

6,847,830 6,876,697 6,879,585 6,886,049 6,968,171

6,985,757 7,023,878 7,053,843 7,106,569 7,145,267

7,200,512 7,295,171 7,287,162 D442,170 D459,303

D599,256 D560,911

andotherpatentspending.

Thisproductincludes

technologylicensedfrom:

LicensedbyQUALCOMMIncorporatedunderoneormoreof

thefollowingUnitedStatespatentsand/ortheircounterparts

inothernations:

4,901,307 5,056,109 5,101,501 5,109,390 5,228,054

5,267,261 5,267,262 5,337,338 5,414,796 5,416,797

5,490,165 5,504,773 5,506,865 5,511,073 5,535,239

5,544,196 5,568,483 5,600,754 5,657,420 5,659,569

5,710,784 5,778,338

ManufacturedorsoldbySierraWirelessoritslicense esunder

oneormorepatentslicensedfromInterDigitalGroup.

LicensedunderthefollowingNortelNetworksLimited

patents:

UnitedStatespatentnumbers: 5 128925,5398247

Francepatentnumbers:2665993,2653959, 2659812,2745091

QUALCOMM

®

3G

Preface

Rev 1.4 Draft Mar.08 5

Trademarks AirCard

®

and“HeartoftheWirelessMachine

®

”areregistered

trademarksofSierraWireless.Watcher

®

isatrademarkof

SierraWireless,registeredintheEuropeanCommunity.



SierraWireless,theSierraWirelesslogo,theredwavedesign,

andthered‐tippedantennaaretrademarksofSierraWireless.

Windows

®

isaregisteredtrademarkofMicrosoftCorporation.

QUALCOMM

®

isaregisteredtrademarkofQUALCOMM

Incorporated.Usedunderlicense.

Othertrademarksarethepropertyoftherespectiveowners.

Contact

Information

Consultourwebsiteforup‐to‐dateproductdescriptions,

documentation,applicationnotes,firmwareupgrades,trouble

‐

shootingtips,andpressreleases:

www.sierrawireless.com

Revision History

Sales Desk: Phone: 1-604-232-1488

Hours: 8:00 AM to 5:00 PM Pacific Time

E-mail: [email protected]

Post: Sierra Wireless

13811 Wireless Way

Richmond, BC

Canada V6V 3A4

Fax: 1-604-231-1109

Web: www.sierrawireless.com

Revision

number

Release

date

Changes

1.1 August 2007

• RemoveddetailaboutATcommandparameters,instead

directinguserstotheMP3GModemsATCommandReference

manual.(document#2130810.)

• UpdatedregulatoryinformationforCanadaandtheUSA.(See

“RegulatoryInformation”onpage79.).

1.2 January 2008

• AddedNATandWAPinformation.

1.3 February 2008

• Addedbatterycableinformationunderpowerconnection.

1.4 March 2008

• AddedmoreRegulatoryinformation.(See“RegulatoryInfor‐

mation”onpage79.)

AirLink MP595 / MP595W Modem User Guide

6 2130795

Rev 1.4 Draft Mar.08 7

Contents

Introducing the MP Modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

About CDMA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

CDMA account and coverage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Supported CDMA radio frequencies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Receive diversity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Connection methods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Virtual serial port. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

VPN support for RNAP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Software . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

MP Modem Manager . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Documentation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Getting Started . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

Plan your MP modem installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Where do you want to install your MP modem?. . . . . . . . . . . . . . . . . . 20

What type of connection(s) do you plan to use?. . . . . . . . . . . . . . . . . . 20

Required equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Package contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Additional required equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

System requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

MP modem accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Hardware and Software

Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25

Installation overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

MP modem housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Connector panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

GPS and I/O options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Overview of installation steps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

AirLink MP595 / MP595W Modem User Guide

8 2130795

Install the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Step 1 — Mount the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Select a location for the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Mounting the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Ground the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28

Step 2 — Mount the antennas and install the cables . . . . . . . . . . . . . . . . 29

Main RF antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29

GPS antenna . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

AP antenna (MP 595W only) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Antenna locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Install the antennas and cables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31

Step 3 — Install the power harness . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Power connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Power connector (Molex) pinouts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Vehicle installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32

Ignition sense on/off wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Ignition sense options . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Ground the power harness. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Power connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Correct wire splicing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Crimp terminals. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

Office installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

Step 4 — Connect the MP modem to computer cable . . . . . . . . . . . . . . . 35

Serial connector (DB9) pinouts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

Install the USB, Ethernet or serial cable . . . . . . . . . . . . . . . . . . . . . . . . 36

I/O port connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Step 5 — Install the software . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

Step 6 — Activate your account . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37

The Activation Wizard. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Manual activation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Automated activation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

Step 7 — Test the system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38

MP Modem Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

Turning the MP modem on and off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39

Status indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40

Reset the MP modem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Contents

Rev 1.4 Draft Mar.08 9

3G Watcher software. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

3G Watcher Help . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Launching 3G Watcher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

3G Watcher window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Establishing connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Configuring the Router Functions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43

Non-NAT mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

NAT mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44

MP modem networking basics in NAT mode . . . . . . . . . . . . . . . . . . . . . . 45

Enable the router . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

File and resource sharing over LAN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Static IP and TCP/UDP port forwarding in NAT mode . . . . . . . . . . . . . . . . . . 46

Set up static IP addresses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46

Set up TCP/UDP port forwarding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47

Configuring the Wireless Access Point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49

Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49

Unlock MP modem configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50

Change the password (optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50

Enable the wireless access point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

Set the SSID. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51

Configure the security settings. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52

Configure security on the client computers . . . . . . . . . . . . . . . . . . . . . . . . 53

Reset the MP modem to factory defaults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53

Configuring the MP Modem to Report GPS and I/O Data . . . . . . . . . . . . . . .55

GPS configuration and reporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

GPS protocols and commands . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

GPS display in 3G Watcher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56

GPS TAIP quick reference . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

AirLink MP595 / MP595W Modem User Guide

10 2130795

I/O device installation and configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57

Connector pinouts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

Port specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

Digital input devices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58

Example: panic button connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59

Digital output devices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

Analog input devices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60

Example: analog sensor connections. . . . . . . . . . . . . . . . . . . . . . . . . . . 61

I/O configuration using AT or 3G Watcher commands . . . . . . . . . . . . . . 61

Analog input setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62

Digital I/O setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63

Sending Data to Your Network Application . . . . . . . . . . . . . . . . . . . . . . . . . . . .65

Configure the MP modem to route data to a server. . . . . . . . . . . . . . . . . . . . . 65

Report frequency timers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65

Monitoring and Tracking configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . 68

IP Addressing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68

The problem created by Network Address Translation . . . . . . . . . . . . . . 69

Solutions to the NAT problem. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70

Retrieve the Unique Mobile Device ID. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70

Support and Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71

Technical support . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71

Technical Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .73

Regulatory, radio frequency and electrical specifications . . . . . . . . . . . . . . . 73

Environmental specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

Weight and dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74

Host interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

Other interfaces . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

GPS specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

Contents

Rev 1.4 Draft Mar.08 11

I/O port characteristics. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

3G Watcher software. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

Wireless access point specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76

Regulatory Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .79

Canada . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

U.S.A. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

Important Note . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80

FCC Caution . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80

Approved antennas. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 80

AirLink MP595 / MP595W Modem User Guide

12 2130795

Rev 1.4 Draft Mar.08 13

1: Introducing the MP Modem

• CDMA account and

coverage

• Receive diversity

• Virtual serial port

• VPN support for RNAP

• Software

• Documentation

Note: Do not connect the MP

modem to a USB port on a

computer before installing the

software. (

See “Step 5 — Install

the software” on page 37.)

TheSierraWirelessMPmodemprovidesawirelessnetwork

connectionforportablecomputersinvehiclesoroffices.

IftheMPmodemisinstalledinavehicle,ittypicallyis

mountedinthetrunkandconnectedtoanotebookcomputer

inthepassengercompartment.Aradiofrequency(RF)antenna

mountedontheroofofthevehicleenablestheMPmodemto

communicatethroughawirelessnetworktoahost

computer.

Abuilt‐inGlobalPo sitioningSystem(GPS)modu leprovides

locationandheadingdatathatcanalsoberemotelymonitored.

TheMPmodemhasaruggeddesignthatallowsitto

withstandthevibration,shock,humidity,andextremesof

temperatureexperiencedinthenormaloperationofpolice,

emergency,utility,andfieldservicevehicles.

YoucanusethenetworkconnectionprovidedbytheMP

modemtoaccessshareddata,browsetheInternet,andsend

andreceivee‐mailandtextmessages.TheMPmodemalso

allowsforsensors,gauges,andalarms(suchaspanicbuttons)

tobeinstalledinvehiclesandremotelymonitoredfroma



centrallocation.

AirLink MP595 / MP595W Modem User Guide

14 2130795

About CDMA

TheMPmodemoperatesoveratypeofwirelessnetwork

calledCodeDivisionMultipleAccess(CDMA).CDMAThird

Generation(3G)technologyprovidesavarietyofconnectivity

features,dependingonyourserviceproviderandaccount:

• 1xEvolution‐DataOptimizedRevisionA

(1xEV‐DORev.A)supportsInternetconnectionswithdata

ratesupto3.1

Megabitspersecond(Mbps)downlinkfrom

thenetworkand1.8

Mbpsuplinktothenetwork.Average

dataratesare450

‐800kilobitspersecond(kbps)downlink

and300‐400

kbpsuplink.Actualspeeddependson

networkconditions.

• 1xEV‐DORevision0(Rev.0)supportsInternetconnections

withdataratesupto2.4

Mbpsdownlinkand153kbps

uplink.Averagedataratesare400

–700kbpsdownlinkand

40‐80

kbpsuplink.Actualspeeddependsonnetwork

conditions.

• 1xsupportsInternetconnectionswithdataratesupto

153

kbps.Actualspeeddependsonthenetworkcondi‐

tions.

• Circuitswitched(dial‐up)data,usingtheearlierCDMA

IS‐95specification,supportsdataconnectionstoanydial‐

upserviceatratesupto14.4kbps.

TheMP595modemisprimarilydesignedtoprovide1xor

betterdataconnectionsbutitalsoallowsforCircuit

SwitchedData(CSD)connectionsinareasthathave

CDMAIS‐95coveragebutno3G(1xEVDOor1x)high‐

speedpacketservice.

QuickNetConnect(QNC)providesasimplifiedwayto

dialintoanInternetconnectionusingCSD,assumingCSD

issupportedbyyourserviceprovider.

Onceaconnectionisestablished,youcanopenyourbrowser

andconnecttowebsitesandaccessotherInternetservices

suchase‐mail.

CDMA account and coverage

YoumustsetupanaccountwithaCDMAserviceproviderfor

eachMP

modemyouinstall.AfterinstallingtheMPmodem

software,youmustconfigureittouseanaccount.

Introducing the MP Modem

Rev 1.4 Draft Mar.08 15

TheabilityoftheMPmodemtoobtainserviceandthetypeof

serviceobtainedinanyareaisdeterminedbyseveralfactors:

Network proximity and 1xEV-DO CDMA availability To

obtainservice,youmustbewithinthecoverageareaofa

networkoperatinginoneoftheradiofrequencybands

supportedbytheMPmodem.Thetypeofconnectiondepends

ontheserviceavailableinthatarea.Forexample,thereare

areaswith1xserviceinwhich1xEV‐DOhas

notyetbeen

implemented.

Roaming Ifyouare withinthecoverageofanetwork

operatedbyadifferentserv iceprovider,yourabilitytoobtain

servicedependsonwhetheraroamingagreementexists

betweenyourserviceproviderandtheoneoperatingyour

currentlocalnetwork.Theremaybeadditionalfeesfor

roamingservice.Contactyourreselleror

serviceproviderfor

information.

Account provisions Youraccountmayrestrictusageof

certainnetworksormaylimityourconnectiontimeordata

transmission.

Supported CDMA radio frequencies

CDMAnetworksoperateontwosetsofradiofrequency

bands.TheMP

595modemisadual‐bandproductthat

operatesonbothbands:

• 1900MHz(alsocalledthePCS,orPersonalCommunica‐

tionsServices,band)

• 800MHz(Cellularband)

Receive diversity

TheMP595modemsupportsreceivediversityforimproved

signalreception.Receivediversityusestwoantennasto

enhancethequalityofthesignal,butdoesnotextendtheMP

modem’scoveragearea.

Connection methods

YoucanconnecttheMPmodemtoaUSB,Et hernet(RJ45),or

serial(DB9)portonacomputer.WhenconnectedtoaUSBor

Ethernetport,theMPmodembehaveslikeanetworkcard.

Whenconnectedtoaserialport,theMPmodembehaveslikea

dial‐upmodem.

AirLink MP595 / MP595W Modem User Guide

16 2130795

TheMPmodemalsosupportsconnectionsviaIEEE802.11b/g

(MP595only).See

Chapter6formoredetails.

Virtual serial port

TheMPmodemsupportsfourvirtualserialports(VSPs).

ThreearereservedforinternalusebytheMPmodem.The

remainingVSP,whichiscalledSierraWirelessApplication

Interface2,isassignedtoaspecificCOMportthatvaries

betweenusers.ThisVSPcanbeused,forexample,tosendAT



commands,ortorunapplicationssuchasHyperTerminal



.

SpecialMPmodemmodessuchasGPSthataresupportedon

aserialportarealsoavailableonthevirtualport.Forexample,

withthevirtualportenabled,amappingapplicationonyour

computerthatnormallylistensforGPSmessagesonaserial

portlistensforthosesamemessagesonthe

virtualport.

TheMPmodemVSPsareavailableonbothUS BandEthernet

interfaces.Forinformationonenablingavirtualserialport,see

theMP3GModemsATCommandReferencemanual(docum ent

#2130810).

VPN support for RNAP

ThisfeatureallowsfortheexchangeofRemoteNetwork

AccessProtocol(RNAP

1

)databetweentheMPmodemanda

remoteserveraccessibleonlythroughaVirtualPrivate

Network(VPN)connection.Whenusingthisfeature,youmust

have3GWatcherrunningonthecomputer.

TheMPmodemsendsRNAPdataoverEthernetorUSBto3G

Watcheronthecomputer.3GWatcherplacestheRNAPdatain

aUserDatagramProtocol/InternetProtocol(UDP/IP)packet

andsendsitovertheVPNconnectiontotheserver.When3G

WatcherreceivesaUDP/IPpacketcontainingRNAPdataover



theVPNconnection,itdisassemblesthepacketandsend sthe

RNAPdatatotheMPmodem.

Youcanenablethisoptionusing3GWatchersoftwareorAT

commands.Seethe3GWatcheronlinehelpandtheMP3G

ModemsATCommandReferencemanual (document#2130810)

fordetails.

1. RNAP is a Sierra Wireless proprietary protocol that encapsu-

lates the MTP data that is sent to and from the MP modem. It

ensures that both the MP modem and remote host recognize

the data packets. See The Monitoring and Tracking Protocol

Guide on

page 18.

Introducing the MP Modem

Rev 1.4 Draft Mar.08 17

Software

TheMPmodemcomeswiththefollowingsoftware:

• 3GWatcher,thesoftwarefortheMPmodemwhichallows

youtomanageandmonitoryourconnections.

• ThedriverthatformstheinterfacebetweentheMP

modemandyourWindowsoperatingsystem.

• Thefirmwarethatisstoredinnon‐volatilememory.

TheMPmodemhasanembeddedradiomodule(a

Mini

Card5725),alsomadebySierraWireless,Inc.There

aretwofirmwareprogramsontheMPmodem—one

storedonthecontrollerboardoftheMPmodemand one

ontheradiomodule.

Thefirmwarewasloadedintotheradiomoduleandcon‐

trollerboardwhentheMPmodemwasassembled.Asnew

versionsofthesoftwareandfirmwarearereleased,they

arepostedat

www.sierrawireless.com.

MP Modem Manager

MPModemManagerisaweb‐baseddiagnosticand

managementtoolthatallowsyoutoremotelymonitorand

configureafleetofMPmodems.WithMPModemManager

youcan:

• Diagnoseandtroubleshootfieldissues.

• IdentifyMPmodemfirmwareversionsandremotely

upgradefirmware.

• OrganizeMPmodemsintogroupsfortableviewingof

modemandnetworkstatus.

• ConfigureGPSsettings.

MPModemManagersoftw areisavailablefreeofcharge. To

requestthissoftware,completeandsubmittheformat:

https://www.sierrawireless.com/product/

mp_modem_mgr_request.aspx.

Documentation

ThisUserGuidedescribeshowto:

• InstalltheMPmodemhardware.

• ConnecttheradioandGPSantennas.

• Connectanotebookcomputerandotherinput/output

(I/O)devices.

• Installthesoftware.

• ConfigurethesoftwaretouseaCDMAaccount.

AirLink MP595 / MP595W Modem User Guide

18 2130795

• InterprettheLEDsontheMPmodemandtheindicatorsin

the3GWatchersoftware.

• ConfiguretheMPmodemtoreportGPSand/orI/Odata

(fromsensors,gauges,orpanicbuttons).

• UsetheMPmodemtoconnecttoanetwork.

• CollectanduseGPSandI/Odatafromafleetofvehiclesin

whichMPmodemsareinstalled.

• Configurerouterfunctions.

• ConfigureWAP.

ThisUserGuideisprovidedasaPDF(PortableDocument

Format)fileontheinstallationCD.

Onlinehelpisprovidedwith3GWatcher.Itdescribesallthe

iconsandindicatorsin3GWatcherandprovidesdetailed

instructionsonusing3GWatchertomakedataconnections.

Whenusing3GWatcher,youcanaccesshelpthroughthe

menusystemorbypressingthe

<F1>key.

TheMP3GModemsATCommandReferencemanual(d ocument

#2130810)describestheavailableATcommandset.

TheMPModemManagerUserGuide(document#2130554)

providesinformationonhowtoinstall,configure,andusethe

MPModemManagersoftw aretomanageafleetofmodems.

TheMonitoringandTrackingProtocolGuidedescribesthe

protocolsusedindatatransmissionsbetweentheMPmodem

andthenetworkserver.Itprovidestheinformationnecessary

todevelophostapplicationsthatprocessGPSanddigitalinput

fromafleetofMPmodems.Formoreinformationcontact

[email protected].

Rev 1.4 Draft Mar.08 19

2: Getting Started

• Plan your MP modem

installation

• Required equipment

• System requirements Thischapterprovides:

• Anoverviewoftheinstallationprocess

• Informationabouttheequipmentyou’llneed

• Systemrequirementsfortheclientsyouwanttousewith

theMPmodem

• Planningconsiderations

Overviewofinstallationsteps:

• Plantheinstallation.

· Location

· Connectiontype

· Routing

• Ensurerequiredequipmentisavailable.

• Ensuretheclientshavethenecessarysystemrequirements.

• Installthehardware(MPmodem,clients,antennas,

cables).

• InstallthepowerharnessorAC/DCadapter.

• ConnecttheMPmodemtothecomputer(ifusingcables).

• Installthesoftware(WatcherandMPmodemdrivers).

• Configureyouraccount.

• Configurenetworkingoptions(ifyouareusingtherouter

functionality).

• Configurethewirelessaccesspointsettings(ifdesired).

AirLink MP595 / MP595W Modem User Guide

20 2130795

Plan your MP modem

installation

Thissectionguidesyouthroughthedecisionsyouneedto

makebeforeyoubegintheinstallati on.

Where do you want to install your MP modem?

TheMPmodemcanbeinstalledinavehicleorinanoffice.The

sameinstallationstepsapplywiththefollowingexceptions:

• IfyouareinstallingtheMPmodeminavehicle:

· UsethepowerharnesstoconnecttheMPmodemtothe

vehiclebattery.

· Decidehowtosettheignitionsenseoptionforpowe ring

theMPmodemonandoff(thatis,dependingonthe

ignitionswitchwiring,theMPmodemcanbeturnedon

whentheengineisstarted,whentheignitionisin

accessorymode,orindependentlyoftheignition).

• IfyouareinstallingtheMPmodeminanoffice,anAC/DC

adapterisavailable.

What type of connection(s) do you plan to use?

TheMPmodemiscapableofthefollowingkindsofnetwork

connections:

• Serial

• USB

• Ethernet

• WirelessAccessPointviaIEEE802.11b/g(MP595W only)

Datatransferratesvary,dependingonthenetwork,butnote

thatthehighestdatarateusingaserialconnectionis

115.2

kbps.

Beforedecidingwhichnetworkinterfacetouse,youneedto

understandtheadvantagesanddisadvantagesofeach,and

anyotherimplicationsofusingoneinterfaceoveranother.

Page is loading ...

Sierra 595 User manual

This manual is also suitable for

Sierra 595 User manual

Related papers

Other documents