Cleveland Range SteamCub 1SCEMCS User manual
- Category
- Cookers
- Type
- User manual
This manual is also suitable for
Cleveland
™
P
roject ________________________________
I
tem __________________________________
Quantity _______________________________
FCSI Section ____________________________
A
pproval _______________________________
D
ate __________________________________
1333 East 179 St.,
Cleveland, Ohio, U.S.A. 44110
Tel: 1-216-481-4900
Fax: 1-216-481-3782
Web Site: www.ClevelandRange.com
Email: Steam@ClevelandRange.com
STEAMCUB™ BOILERLESS
CONNECTIONLESS STEAMER
SECT. I PAGE 1
0707
SteamCub
TM
PRESSURELESS STEAM COOKER,
RETHERMALIZER & HOLDING CABINET
Cleveland Standard Features
n Boilerless Pressureless Steam Cooker and Rethermalizer.
n Capacity: Full Size Steam Table Pans:
• Five: 2 1/2" x 12" x 20" (1/1 GN, 65mm)
• Ten: 1" x 12" x 20" (1/1GN, 40mm)
n Easy installation, no drain line, water connections or hood is
needed.
*
n 60 Mechanical Timer with ON/OFF Main Power Switch with
a Heat On, Low Water Indicator Lights and High
Temperature Safety Light and Shut-off (Reset Light).
n 6" (152mm) Skid Resistant Stainless Steel Adjustable Legs
with Flanged Feet.
n 8 gauge stainless steel inner cooking compartment, 14
gauge stainless steel outer compartment with two piece
compartment door for an airtight, leak-proof seal.
n Reversible Door Gasket.
n 9 kW total output, with easy to remove 1 kW heating
elements (9 each) cast into aluminum bocks.
n Electronic Low-Water Shut-Off Safety Indicator with audible
alarm, High Temperature Safety Shut-Off and LED "Heat
On" Indicator Light.
n Separate Power ON/OFF Control includes an Automatic
Pre-Heat when power is turned "ON".
n Easy-Access Manual Drain V
alve located in front, Pan Slide
Guides located under unit to fit 12" x 20" (1/1GN) Pans.
Includes one 4" x 12" x 20" stainless steel pan
(1/1GN-102mm).
n Approvals: cUL, NSF #4.
Options & Accessories
p Equipment Stand Model UniStand34.
p POSK Pull-Out Shelf Kit for UniStands (P/N 111724)
p URK Pan Rack Kit UniStands (P/N 111726)
p Optional Voltages, 480 Volt (VOS2).
p 6 kW total Output Six - 1 kW heating elements.
p Single Phase Operation.
* Consult local authorities for venting requirements
Shall be a Cleveland SteamCub
™, Model 1SCEMCS
, one compartment
steamer. 60-minute mechanical timer with a low water indicator and alarm. a
heat-on indicator light. 9 kW power rating. Capacity for five 2 1/2" deep full
size steam table pans. 8 gauge stainless steel inner cooking compartment,
14 gauge stainless steel outer compar
tment with two piece compartment
door
.
Short Form Specifications
MODEL: c 1SCEMCS
(NOT
T
O SCALE)
SECT
.
I P
AGE
2
0707
Litho in U.S.A.
17.434"
443mm
2
1.625"
5
49mm
2
3.100"
5
87mm
25.361"
644mm
2.100"
53mm
24.858"
6
31mm
1.574"
40mm
30.890"
785mm
1.500"
38mm
RIGHT
SIDE VIEW
FRONT
VIEW
REAR
VIEW
Note: Consult local authorities for venting and installation requirements.
∗
For supply connection use only copper wire suitable for at least 75
°
C (167
°F).
•
Compartment has capacity for:
Five, 12˝ x 20˝ x 2
1
⁄2˝ deep Cafeteria Pans.
WATER QUALITY REQUIREMENT
The recommended minimum water quality standards whether
untreated or pre-treated, based upon 10 hours of use per day,
and a Daily Blowdown, are as follows:
T
OTAL DISSOLVED SOLIDS less than 60 parts per million
T
OTAL ALKALINITY less than 20 parts per million
SILICA less than 13 parts per million
pH FACTOR greater than 7.5
CHLORINE less than 30 parts per million
C
onsult a local water treatment specialist for an on site water
analysis for recommendations concerning steam generator
feed water treatment (if required), in order to remove or
r
educe harmful concentrations of minerals. The use of high-
ly mineralized water will mean that more frequent servicing of
the steam generator will be necessary. The fact that a water
s
upply is potable is not proof that it will be suitable for the
generator.
NO
TES
:
Cleveland Range reserves right of design improvement or modification, as warranted.
Many regional, state and local codes exist and it is the responsibility of the owner and installer to comply with the codes.
Cleveland Range equipment is built to comply with applicable standards for manufacturers. Included among those approval agencies are
U.L/NSF#4 and CSA (AGA, CGA).
H
D
C
C1 C2
ELECTRICAL
W
A
TTS
VOL
TS PHASE WIRES
CYCLE
AMPS
SUPPL
Y CONNECTION
HER
TZ
WIRE SIZE (COPPER)
*
Standard Wattage
Thr
ee Phase - 9 kW Standar
d
9400 208 3 3 60 26.1 10
9400
240
3
3
60 22.6 10
9400 480 3 3 60 11.4 14
Optional Low Wattage
Thr
ee Phase - 6 kW option
6400 208 3 3 60 17.8 12
6400 240 3 3 60 15.4 12
6400
480
3 3 60 7.7 14
* For supply connection use only copper wire suitable for at least 75˚C. (167˚F).
W
A
TTS
VOL
TS PHASE WIRES
CYCLE
AMPS
SUPPL
Y CONNECTION
HER
TZ
WIRE SIZE (COPPER)
*
Standard Wattage
Single Phase - 9 kW Standar
d
9400 208 1 2 60 45.2 6
9400
240
1
2
60 39.2 8
Optional Low Wattage
Single Phase - 6 kW option
6400 208 1 2 60 30.8 8
6400 240 1 2 60 26.7 10
-
1
-
2
Cleveland Range SteamCub 1SCEMCS User manual
- Category
- Cookers
- Type
- User manual
- This manual is also suitable for
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Cleveland CA1-E User manual
-
Cleveland Electric Steamer 1SCE-OPM User manual
-
Cleveland Range Electric Steamer 1SCE-OPM User manual
-
Cleveland 1SCEMCS User manual
-
Cleveland SteamCub 1SCE User manual
-
-
-
Cleveland 22CET3.1 User manual
-
Cleveland SteamChef 3 User manual
-
