Xtreme Power Conversion XPRT?2000 User and Installation Manual





XtremePowerConversion®Corporation



XtremePerformanceRackTowerSeries

(XPRT)



User’s&InstallationManual

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[2]



TABLEOFCONTENTS

INTRODUCTION...................................................................................................................................................... 7

PRODUCTDESCRIPTION ..................................................................................................................................... 7

DETERMININGTHEPOWERREQUIREMENTSOFYOUREQUIPMENT.............................................. 13

HARDWAREINSTALLATIONGUIDE ............................................................................................................. 13

USER’SOPERATIONS.......................................................................................................................................... 21

BATTERIES ............................................................................................................................................................ 26

REPLACINGTHEBATTERY .............................................................................................................................. 26

TROUBLESHOOTING .......................................................................................................................................... 27

SPECIFICATIONS.................................................................................................................................................. 28

OBTAININGSERVICE.......................................................................................................................................... 31

XTREMEPOWERCONVERSION™(XPC)CORPORATIONLIMITEDWARRANTY ............................ 32

APPENDIXA:BATTERYPACKUSERGUIDE ............................................................................................... 33

APPENDIXB:SNMPCONFIGURATIONGUIDE ........................................................................................... 42



INTRODUCTION

Thankyouforselectingthisuninterruptiblepowersupply(UPS).Itprovidesyouwithprotectionfor

connectedequipment.PleasereadthismanualbeforeinstallingtheXPRT‐SeriesUPSmodelsXPRT‐

1000,XPRT‐1500,XPRT‐2000andXPRT‐3000asitprovidesimportantinformationthatshouldbe

followedduringinstallationandmaintenanceoftheUPSandbatteries,allowingyoutocorrectlysetup

yoursystemforthemaximumsafetyandperformance.Includedisinformationoncustomersupport

andservice,ifitisrequired.IfyouexperienceaproblemwiththeUPS,pleaserefertothe

Troubleshootingsectioninthismanualtocorrecttheproblem.Iftheproblemisnotcorrected,please

collectinformationsothattheTechnicalSupportpersonnelcanmoreeffectivelyassistyou.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[3]



EMCStatements‐FCCPart15

Notice:Pursuanttosection15oftheFCCrules,thisproducthasbeentestedandtherebycomplies

totheconditionsofaClassB(XPRT‐1000,XPRT‐1500)andClassA(XPRT‐2000,XPRT‐3000)digitaldevice,

whichhavebeenestablishedforofferingsufficientprotectionagainstdangerousinterferencefor

installationinaresidentialarea.Installationanduseoftheequipmentshouldcomplywiththe

instructionsprovidedinordertoavoidsuchinterferenceduetotheamountofradiofrequencyenergy

thatisradiatedandgeneratedbytheequipment.Inspiteofthis,wecannotassurethatacertain

amountofinterferencemaynotoccurinsomeinstallations.If,byturningonandoff,itcanbededuced

thatyourradioortelevisionreceptionisfoundtobeinfluencedbyharmfulinterferencefromthe

equipment,itisrecommendedtouseoneofthefollowingpreventivemeasures.

• Placethereceivingantennainaseparatelocationororientation.

• Ensureagreaterdistanceisachievedbetweenthereceiverandtheequipment.

• Ensurethatyourequipmentisconnectedtoanoutletonaseparatecircuitthanthe

receiver.

• ContactatechnicianexperiencedwithradioandTVoradealerforfurtherassistance.

ICES‐003

ThisClassBInterferenceCausingEquipmentmeetsallrequirementsoftheCanadianInterference

CausingEquipmentRegulationsICES‐003.CetappareilnumeriquedelaclasseBrespectetoutesles

exigenciesduReglementsurlematerielbrouilleurduCanada.

DeclarationofConformityRequest

UnitslabeledwithaCEmarkcomplywiththefollowingstandardsanddirectives:

• HarmonicStandards:EN50091‐1‐1andEN50091‐2

• EUDirectives73/23/EEC,CouncilDirectiveonequipmentdesignedforusewithincertain

voltagelimits.

o 96/68/EEC,AmendingDirective73/23/EEC

o 89/336/EEC,CouncilDirectiverelatingtoelectromagneticcompatibility

o 92/31/EEC,AmendingDirective89/336/EECrelatingtoEMC

• TheECDeclarationofConformityisavailableuponrequestforproductswithaCEmark.

CAUTION:Ashielded‐typepowercordisrequiredinordertomeetFCCemissionlimitsandto

preventinterferencetothenearbyradioorTVreception.Itisessentialthatonlythesuppliedpower

cordbeused.UseonlyshieldedcablestoconnectI/Odevicestothisequipment.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[4]

WARNING:Anychangesormodificationsnotexpresslyapprovedbythemanufacturerofthis

devicecouldvoidtheuser’sauthoritytooperatetheequipment.

IMPORTANTSAFETYINSTRUCTIONS:

(SAVETHESEINSTRUCTIONS)

CAUTION!(UPShavingInternalBatteries):Riskofelectricalshock–Hazardouslive

partsinsidethisunitareenergizedfromthebatterysupplyevenwhentheinputACpoweris

disconnected.

CAUTION!(NoUserserviceableParts):Riskofelectricalshock,donotremovecover.

Nouserserviceablepartsinside.Referservicingtoqualifiedservicepersonnel.

CAUTION!(Non‐isolatedBatterysupply):Riskofelectricshock,batterycircuitisnot

isolatedfromACinput,hazardousvoltagemayexistbetweenbatteryterminalsandground.Testbefore

touching.

WARNING!(Fuses):Toreducetheriskoffire,replaceonlywiththesametypeandsizeoffuse.

WARNING!Unitintendedforinstallationinacontrolledenvironment.

CAUTION!Donotdisposeofbatteriesinafire,thebatterymayexplode.

CAUTION!Donotopenormutilatethebattery,releasedelectrolyteisharmfultotheskinandeyes.

CAUTION!Abatterycanpresentariskofelectricshockandhighshortcircuitcurrent.Thefollowing

precautionshouldbeobservedwhenworkingonbatteries:

• Removewatches,ringsorothermetalobjects.

• Usetoolswithinsulatedhandles.

Toreducetheriskofelectricshock,disconnecttheUPSfromthemainsupplybeforeinstallinga

computerinterfacesignalcable.Reconnectthepowercordonlyaftersignalinginterconnectionshave

beenmade.

Servicingofbatteriesshouldbeperformedorsupervisedbypersonnelwithknowledgeofbatteriesand

therequiredprecautions.Keepunauthorizedpersonnelawayfrombatteries.

TheseUPSunitsareextremelyheavy.DonotinstalltheUPSinarackorenclosurebyitsfronttwoears

only.Adjustablerackrailsarerequiredforthistypeofinstallation(Part#XPRT‐RR1)

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[5]

Theinstructionscontainedwithinthissafetymanualaredeemedimportantandshouldbeclosely

followedatalltimesduringinstallationandfollow‐upmaintenanceoftheUPSandbatteries.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[6]



 CAUTION

Theunithasadangerousamountofvoltage.IftheUPSindicatorison,theunit’soutletsmayhavea

dangerousamountofvoltageevenwhennotpluggedintothewalloutletbecausethebatterymay

continuetosupplypower.

Careshouldbetakentoundertakeinstallationindoors,freefromelectrically‐conductiveparticles

whichareundertemperatureandhumiditycontrol,inordertoreducetheriskofelectricshock.

Itisbesttodisconnectthedeviceusingthepowersupplycord.Ensurethattheequipmentisplacedin

apositionneartheoutletwhereeasilyaccessible.

Exceptforreplacingthebatteries,allservicingonthisequipmentmustbecarriedoutbyqualified

servicepersonnel.

Beforeconductinganymaintenance,repair,orshipment,firstensurethateverythingisturnedoff

completelyanddisconnected.

Foradditionalsafetyinstructions,pleaseusetheSafetyManualasareference.

SpecialSymbols

ThefollowingsymbolsusedontheUPSwarnyouofprecautions:

RISKOFELECTRICSHOCK‐Pleaseobservethewarningthatariskofelectricshockispresent



CAUTION:REFERTOOPERATOR’SMANUAL‐Refertotheoperator’smanualforadditional

information,suchasimportantoperatingandmaintenanceinstructions.



SAFEGROUNDINGTERMINAL‐Indicatesprimarysafeground



LOADON/OFF–Pressingthebuttonturnson/offtheoutputreceptaclesandtheindicator

light.

RJ45RECEPTACLE–Thereceptacleprovidesnetworkinterfaceconnectionsandtelephoneor

telecommunicationsequipmentshouldnotbepluggedintoit.

PleasedonotdiscardoftheUPSortheUPSbatteriesastheUPSmayhavevalve‐regulated

lead‐acidbatteries.Pleaserecyclebatteriesappropriately.



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[7]



INTRODUCTION

Theinformationprovidedinthismanualcoverssinglephase1000‐3000VAuninterruptiblepower

systems,theirbasicfunctions,operatingprocedures,optionsavailableandemergencysituations.Italso

includesinformationonhowtoship,store,handle,andinstalltheequipment.Onlydetailed

requirementsoftheUPSunitsaredescribedherein,andinstallationmustbecarriedoutinaccordance

withthismanual.Electricalinstallationmustalsocarefullyfollowlocallegislationandregulations.Only

qualifiedpersonnelshouldconducttheseinstallationsasfailuretoacknowledgeelectricalhazardscould

provetobefatal.

PRODUCTDESCRIPTION

ManydifferentkindsofsensitiveelectricalequipmentcanbeprotectedbyanUninterruptiblePower

Supply(UPS)includingcomputers,workstations,processcontrolsystems,telecommunicationssystems,

salesterminals,othercriticalinstrumentation,etc.ThepurposeoftheUPSistoprotectthesesystems

frompoorqualityutilitypower,completelossofpower,orotherassociatedproblems.

Electricalinterferenceexistsinmanyforms,causingproblemsinACpower,fromlightning,power

companyaccidentsandradiotransmissionmotors,airconditioners,andvendingmachines.Protection

ofsensitiveelectricalequipmentisvitaltoprotectagainstpoweroutages,loworhighvoltage

conditions,slowvoltagefluctuations,frequencyvariations,differentialandcommon‐modenoise,

transients,etc.

Topreventpowerlineproblemsfromreachingcriticalsystemscausingdamagetosoftware,hardware,

andequipmentmalfunctions,theUPSmaintainsconstantvoltage,isolatingcriticalloadoutputand

cleaningtheutilityACpower.

DoubleConversionOn‐LineTechnology

Adoubleconversionon‐linetechnologyUPSprovidescompletelyisolated,clean,uninterruptedsingle‐

phasepowertoyourcriticalsystems,whilemaintainingthebatteriesfortheirmaximumpotential.In

theeventthatthepowerfailurelastslongerthantheUPSbackuptime,theUPSwillshutdownavoiding

batterydamage.WhentheinputACvoltagereturns,theUPSwillautomaticallyreturnonlineto

rechargethebatteries.

Asshowninfig.1blockdiagram:

• Aninputfilterreducestransientsontheincomingutility.

• Tomaintainfullbatterycharge,theACinputpowerisrectifiedandregulatedintherectifier

feedingpowertothebatteryconverterandinverter.

• DCpowerisconvertedtoACintheinverter,passingitontotheload.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[8]

• Powerismaintainedfromthebatteryduringapowerfailure.

• Theconverterincreasesvoltageappropriatelyfortheinverter.



EfficiencyOptimizerFunction

TheEfficiencyOptimizerFunctionisanewfeaturefortheUPS,addingcosteffectiveness,minimizing

powerlossandreducingpowerconsumption.Alternatingbetweenbypassandon‐linemodesis

achievedautomaticallyandinaccordancewiththeconditionsoftheutilitypower.On‐linemodemaybe

usedduringtimesofintermittentpower,andbypassmodeusedwhenpowerflowssmoothly,inorder

toobtaingreatestefficiency.Irregularitiescanbedetectedinlessthanasecond,andon‐linemode

reactivatesimmediately.Switchingbacktoon‐linemodeoccurswheninputvoltageisoutside±10%of

nominal(±15%selectable),wheninputfrequencyisoutsideof±3Hzorwhennoinputlineisavailable.

Althoughhighefficiencyisstandard,thedefaultoperationisinon‐linemode.Bypasscanbeactivatedin

theLCDpanel,thoughon‐linecanberunpermanentlyifpreferred.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[9]



FreeRunMode

TheUPSoperatesinFreeRunModewheninputfrequencyisoutsideoftheselectedinputfrequency

range.FreeRunModeiswhenoutputfrequencydoesnotmatchinputfrequency.Whenstartingthe

UPS,thefrequencyregulationdetectedis50or60Hz±0.25Hz.

DiagnosticTests

WhentheUPSisstarted,adiagnostictestisautomaticallyexecuted,checkingtheelectronicsand

batteries,reportinganyproblemsontheLCDdisplay.

AnXtremeBatteryManagementsystemalwaysmonitorstheconditionsofthebatteries,sendingany

forewarningsifreplacementofbatteriesisrequired.Every30daysofnormalmodeoperation,abattery

dischargetestisautomaticallyperformed,reportinganyproblemsontheLCDdisplay.

Exceptduringthefirst24hoursafterstartupwhiletheUPSisinchargingmode,diagnostictestscanbe

performedmanuallyfromthefrontpanelatanytime.

SystemConfiguration

TheUPSdeviceandtheinternalbatteriesmakeupthesystem.Dependingonthesiteandload

requirementsoftheinstallation,certainadditionaloptionsareavailableforthesolution.

PlanningaUPSsystem,thefollowingshouldbetakenintoconsideration:

• Thetotaldemandoftheprotectedsystemshalldictatetheoutputpowerrating(VA).Allowa

marginforfutureexpansionorcalculationinaccuraciesfrommeasuredpowerrequirements.

• Backuptimerequiredwillindicatethebatterysizeneeded.IftheloadislessthantheUPS

nominalpowerrating,thenactualbackuptimeislonger.

• Thefollowingoptionsareavailable:

o ExtendedBatteryPacks(maximumof2batterypacksofsamemodel)

 XPRT‐BP1for1000/1500

 XPRT‐BP2for1000/1500

 XPRT‐BP3for2000/3000

o ConnectivityOptions–SNMP/WEBcard

SeetheSpecificationsectionofthismanualforadditionmodelinformation.



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[10]



Note:XPRT‐2000has(1)L5‐20R+(2)5‐20R;XPRT‐3000has(1)L5‐30R+(2)5‐20R



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[11]



“UPSON”Indicator

ThisLEDisgreenwhentheUPShasbeenturnedonandnormalutilitypowerisavailable.

“ONLINE”Indicator

ThisLEDisgreenwhentheUPSisinnormalorstaticbypassmodes,andthereisvoltageattheoutput

receptacles.

“ONBATTERY”Indicator

ThisLEDisredwhentheUPSisoperatinginbatterymode.

“ONBYPASS”Indicator

ThisLEDisyellowwhentheUPSisinbypassmode.

“FAULT”Indicator

ThisLEDisredifanyinternalerroroccursintheUPS.Anaudiblealarmwillalsobepresent.Pressanyof

thebuttonsonthefrontpaneltosilencethealarm.

FUNCTIONBUTTON

PressthisbuttontochoosewhichfunctionyouwantontheLCDdisplay.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[12]

ENTERBUTTON

PressthisbuttontocheckthecontentoftheUPSLDCdisplay.

ON/OFFBUTTON

Pressthisbuttonandholdfor3secondstoturntheUPSon.

RS‐232StandardInterface

TheRS‐232interfaceusesa9‐pinfemaleD‐subconnector.Informationprovidedincludesdataabout

utility,loadandtheUPS.Theinterfaceportpinsandtheirfunctionsareidentifiedinthefollowingtable:



PIN#SIGNALNAMEDIRECTION(RE:UPS)FUNCTIONS

2TxDOUTPUTTxDOUTPUT

3RxDINPUTRxD/INVERTEROFFINPUT

5COMMON COMMON

6 OUTPUTACFAILOUTPUT

8 OUTPUTLOWBATTERYOUTPUT

9 OUTPUT12VDCPOWER

CAUTION:MAXRATEDVALUES12VDC

USBPort

ConnectingtheUPStoyourcomputerisaccomplishedthroughtheUSBportonthebackofyour

computer.USBcomplianthardwareandoperatingsystemwillbenecessary,includinginstallationofa

UPSdriver.TheserialportcannotbeusedwhenusingtheUSBport.TheUSBcableisastandardcable

included.

EmergencyPowerOff(EPO)Port

AcustomersuppliedswitchlocatedremotelycanbeusedtoopentheEPOconnectionandallowsthe

UPSoutputreceptaclestobeswitchedoff.SincetheEPOshutsdowntheequipmentimmediately,

orderlyshutdownproceduresarenotfollowedbyanypowermanagementsoftware.TheUPSwillhave

tobemanuallyrestartedinordertoregainpowertotheoutletsontheUPS.

NetworkTransientProtector

ThenetworktransientprotectorlocatedonthebackpaneloftheUPS,hasbothanINandOUTjacks,

housingasingleRJ‐45(10BaseT)networkconnector.ConnecttheinputconnectortothejacklabeledIN

andtheoutputconnectortothejacklabeledOUT.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[13]

LoadSegments

Thepowermanagementsoftwarecontrolsthesetsofreceptaclesknownasloadsegments,whichcan

provideorganizedshutdownandstartupoftheequipmentconnectedtotheUPS.Lesscritical

equipmentcanbeturnedoffduringpoweroutagessavingbatterypowerforcriticalloads.Thepower

managementsoftwareinstructionsprovidemoredetailregardingoperationofthisfeature.Theload

groupstatuscanbeviewedfromtheLCDdisplayandcanbechangedifrequired.

DETERMININGTHEPOWERREQUIREMENTSOFYOUR

EQUIPMENT

1. MakesurethetotalVolt‐Amp(VA)requirementsofyourconnectedequipmentdoesnotexceed

themaximumVAratingfortheUPS.ThemaximumVAratingsareshownintheSpecifications

sectionofthisdocument.

2. Ensurethattheequipmentpluggedintothebattery‐poweredoutletsdoesnotexceedtheUPS

ratedcapacity.IfUPSratedcapacitiesareexceeded,anoverloadconditionmayoccurandcause

theUPStoshutdownandtripthecircuitbreaker.

3. IfthepowerrequirementsofyourequipmentarelistedinvaluesotherthanVolt‐Amps(VA),

convertWatts(W)orAmps(A)intoVAbydoingthecalculationsbelow.Note:Theequation

belowonlycalculatesthemaximumamountofVAthattheequipmentcanuse,notwhatis

typicallyusedbytheequipmentatanygiventime.Usersshouldexpectusagerequirementsto

beapproximately60%ofthevaluetoestimatepowerrequirements:

verifyWatts(W)x1.43=_____VAor_____Amps(A)x120=_____VA

Addthetotalsforalloftheequipmentandmultiplythistotalby0.65tocalculateactualpower

requirements.

Note:Manyfactorscanaffecttheamountofpowerthatyourcomputersystemwillrequire.The

totalloadthatyouwillbeplacingonthebattery‐poweredoutletsshouldnotexceed85%ofthe

UPScapacity.

HARDWAREINSTALLATIONGUIDE

InspecttheUPSuponreceipt.Thepackagingisrecyclable;keepitforreuseordisposeofproperly.

SafetyInformation

Informationpresentedhereisvitaltoallpersonnel.PleasereadallSafetyinformation.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[14]



StorageandTransportation

PleasehandletheUPSandassociatedequipmentwithextremecautionsinceahighamountofenergyis

containedinthebatteries.Alwayskeeptheunitinanuprightpositionasmarkedonthepackaging,and

neverdroptheunit.

PleaseadheretothefollowinginstructionsiftheUPSisnotinstalledimmediately:

• Storetheequipmentasisinitsoriginalpackingandshippingcarton.

• Donotstoreintemperaturesoutsidetherangeof‐15°Cto+25°C

• Ensurethattheequipmentisfullyprotectedfromwetordampareasandfrommoistair.

Inordertomaintainthebatteries,theUPSshouldberechargedevery6monthsforatleast8hours.

Ifflammablesubstancessuchasgasesorfumesarepresent,oriftheroomisairtight,ahazardous

situationmayexistinwhichnoelectricalequipmentshouldbeoperated.

TheinstructionsinthismanualexplainhowtoinstalltheUPSsafely.Notacknowledgingsuchelectrical

hazardsmaybefatal–keepthismanualforfuturereference.

WARNING!

ItisstronglyrecommendedthattheUPScabinetnotbeopenedascomponentshavevery

highvoltageandtouchingthosecomponentsmaybefatal.Onlyaqualifiedtechnicianor

authorizedagentmayservicetheunit.

TheUPSunit’soutputreceptaclescarrylivevoltageevenwhennotconnectedtoaninput

voltagesource.TheUPShasitsowninternalenergysource.

Environment

Ensurethatallenvironmentalconcernsandrequirementsaremetaccordingtospecificationslistedin

thisdocument,otherwisethesafetyofinstallationpersonnelcannotbeguaranteed,andtheunitmay

malfunction.

EnsurethatyourememberthefollowingwhenlocatingtheUPSsystemandbatteryoptions:

• Avoidextremesoftemperatureandhumidity.Maximumbatterylifecanbeattainedwitha

recommendedtemperaturerangeof+15°Cto+25°C.

• Provideprotectionfortheequipmentfrommoisture.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[15]

• Spaceandventilationrequirementsmustbemet.Ensurethereis100mmbehindand50mmon

thesidesoftheUPSforproperventilation.

• EnsurethatthefrontoftheUPSremainsclearforuseroperation.

INSTALLATION

VerticalInstallationSteps

 



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[16]

Wall‐mountedInstallationSteps





XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[17]

StackedInstallationSteps



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[18]

Rack‐mountInstallationSteps



XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[19]



Note:AnyexternalBatteryPacksmustbeinstallednexttoorundertheUPS.PleaserefertotheBattery

PackUserGuideincludedintheBatteryPackboxformoreinformationwheninstallingthese.

XPRT‐1000,XPRT‐1500,XPRT‐2000,XPRT‐3000USER’SMANUALUNINTERRUPTIBLEPOWERSUPPLY(UPS)

[20]

InitialConnectionandStartup:

EnsurethattheUPSandoptionalbatterypacksaremountedcorrectly,andtheUPSisdisconnected

frominputpowerbeforeproceeding.

1. Connectexternalbatterypacks(option).

• UsethecablefromtheExternalBatteryPacktoconnecttotheUPSintheappropriate

location.IfasecondExternalBatteryPackisbeingused,connectthecablefromthe

secondExternalBatteryPacktotheappropriateconnectorintherearofthe1stExternal

BatteryPack.Donotclosethebatterybreaker(s)onthebatterypack(s).

• RefertotheBatteryPackUserManualincludedintheBatterypackboxformoredetails

2. ConnectSNMPcard(option)

• RemovethetwoscrewssecuringtheSNMPcoverplateontherearoftheUPS,andslide

theSNMPcardintotheslot.Securethecardintotheslotwiththetwoscrews

previouslyremoved.

3. ConnecttheUPStoACpower

• EnsuretheUPSlinecordisconnectedtotheappropriategroundedreceptacle.The

batterieswillautomaticallychargewhenconnectedtoACinput.Pleasenotethateven

thoughyoumaystartusingtheUPSimmediately,maximumbatterybackuptimemay

notbeavailableuntilthebatterieshavechargedforaminimumof8hours.

4. StartandconfiguretheUPS

• StarttheUPSbypushingtheON/OFFBUTTONonthecontrolpanel.

• TheUPSwillcommenceastartupself‐testofinternalfunctionsincludingmain

synchronization,andinverterstartup.Duringthestartupself‐test,theLCDwilldisplay:

“Readyon”,“BatteryMode”,and“LineMode”inthatorder.TheUPSwillremainin

“LineMode”andwillbeprovidingpowertotheoutputreceptacles.

• ProgramtheUPSforsystemandsitespecificparameters.Thesearethefactoryfunction

settingslistedonpage23andshouldonlybechangedifneeded.Forexample,if

optionalbatterypacksareutilized,thisiswhereyouchangethenumberofbattery

packsforruntimeaccuracy.Thisisonlychangedfrom“0”ifexternalbatterypacksare

beingused.See“ButtonOperation”onpage21toenterconfigurationmodeviathe

functionbuttonandmakechangestodefaultparameters.

• Configurethelocalmonitoringsoftwareifdesired.

1. InserttheUPSMONCD(includedwithUPSpackaging)intotheCDROMofthelocal

computer.

2. SelecttheappropriateinstallationfromtheAutorunmenu.

3. Followthesetupinstructions.Clickfinishwhenprompted.Ensurethecheckboxto

startUPSMONischeckedbeforeclickingfinish.

4. TheUPSMONiconwillappearinthesystemtrayofthedesktopnearthesystem

clock.Doubleclickthisicontoenlargetheprogramwindow.

Page is loading ...

Xtreme Power Conversion XPRT?2000, XPRT?1000, XPRT?1500 User and Installation Manual

Related papers

Other documents