SAKRETE 65550060 Installation guide

Brand: SAKRETE

Model: 65550060

Type: Installation guide

B-1 Trowel Grade Leveler

and Underlayment

www.sakrete.com • 866-SAKRETE 866-725-7383

B-1 Trowel Grade Leveler and Underlayment is a trowel grade, polymer

modiﬁed cement-based ﬂoor underlayment for interior applications.

FEATURES AND BENEFITS:

•EasytoMix

•EasytoTrowel

•FastSetting

•Self-BondingoverConcrete

•ExcellentSurfaceHardness

•HighTensileandCompressiveStrength

•Featheredges

USES:

InteriorUseFor:

•LevelingandSmoothingFloors

•FillCracksandVoids

•RepairSurfaceDefects

ForUseOver:

•Concrete

•Wood

•CementPlasterCompositionBoard

•CementitiousBackerBoard

•UnderlaymentGradePlywood

•EmbossedVinylTile

ForUseUnder:

•AsphaltTile •CeramicTile

•QuarryTile •MosaicTile

•Linoleum •VinylTile

•WoodFlooring •Carpet

SAFETY:

READandUNDERSTANDtheMaterialSafetyDataSheet(MSDS)beforeusing

thisproduct.WARNING:Wearprotectiveclothingandequipment.SeeHMIS

block.Foremergencyinformation,callCHEMTRECat800-424-9300

or703-527-3887(outsideUSA).KEEPOUTOFREACHOFCHILDREN.

PREPARATION:

Evaluationofthesubstratebyaqualiedengineer,architectorcontractoris

recommended.Cleanareaandremoveallunsoundmaterial,concrete,

grease,oil,paintandanyotherforeignmaterialsthatwillinhibitperformance.

Slickorsealedsurfacesmustbethoroughlyroughened.

Referto:

•ASTMD4259AbradingConcrete

•ICRIGuidelineNo.03732SelectingandSpecifyingConcreteSurface 

PreparationforSealers,CoatingsandPolymerOverlays

•ACI201.1RGuideforMakingaConditionSurveyofConcreteinService

Over Concrete

Newconcreteslabsmustbeproperlycuredbeforeinstallationmaybe

attempted.Dependingonatmosphericconditionsandwatercontent,slabsmay

requireuptosixweekscuringtime.Onlywhenacceptablemoisturelevelsand

effectiverestrictionsonmoisturetransmissionareinplacemayoorcoverings

beinstalled.Concreteoorsonorbelowgrademusthaveaneffectivevapor

barrierundertheslab.Testingmayberequiredtodetermineifadequate

moisturebarriersarepresent.

Suspended Wood Floors

Theoormustbestructurallysound.Removematerialsthatpreventbond.

Wherethesub-oorboardsaremorethan4inches(10.16cm)wide,cover

withsheetunderlaymentperprojectrequirementsorinaccordwithTileCouncil

ofAmericarecommendationsforInstallationofInteriorWoodSubooringand

applicablesectionsofANSIAN-3FloorsofPlywood.Allowabledeectionis

l/360maximum.

Vinyl Flooring

Removewaxesandotheroortreatmentmaterials.Floorsshouldbelightly

roughened.PrimewithSAKRETEBonder/Fortier.

MIXING:

Use31/2to4quarts(3.3Lto3.78L)ofwaterper25lb.(11.35kg)bag.For

smallrepairs,mixthedrycompoundwithwatertoasoftputty-likeconsistency.

Dampentheareatoberepairedandll.Forskimcoating,use2quarts(1.9L)

ofSAKRETEBonder/Fortierand2–21/2quarts(1.9–2.4L)per25lb.

(11.35kg)bag.Additionaldryingtimewillbeneededwhenanadditiveisused.

COLOR:

Gray

COVERAGE:

25sq.ft.(2.3m2)at1/8(3.17mm)thicknessper25lb.(11.3kg)bag

PACKAGING:

25lb.(11.3kg)Multi-Plybag-UPC:7-64661-10525-1

SHELF LIFE:

Oneyearfromdateofmanufacture.

DISPOSAL:

Complywithallapplicablelocal,stateandfederalregulationsfordisposal

ofunusableorcontaminatedmaterials.Disposeofpackaging/containers

accordingtolocal,stateandfederalregulations.

RREV 3/12

LIMITED PRODUCT WARRANTY

The manufacturer warrants that this product shall be

of merchantable quality when used or applied in accor-

dance with the manufacturer’s instructions. This prod-

uct is not warranted as suitable for any purpose other

than the general purpose for which it is intended. This

warranty runs for one (1) year from the date the product

is purchased. ANY IMPLIED WARRANTY OF

MERCHANTABILITY OR FITNESS FOR A PARTICULAR

PURPOSE ON THIS PRODUCT IS LIMITED TO THE DURA-

TION OF THIS WARRANTY. Liability under this warranty

is limited to replacement of defective product or, at the

manufacturer’s option, refund of the purchase price.

CONSEQUENTIAL AND INCIDENTAL DAMAGES ARE NOT

RECOVERABLE UNDER THIS WARRANTY.

The SAKRETE Companies

866-SAKRETE

866-725-7383

www.sakrete.com

ENVIRONMENTAL ADVISORY:

Uncuredorcrushedcuredcementisanenvi-

ronmentalhazard,whichmayadverselyaffect

shandwildlife.Disposeofconstructiondebris

containingcement,includingemptybags,ata

permittedmunicipaldisposalrm.Donotuse

crushedconcreteasallnearanaquatichabitat.

WARNING! CAUSES IRRITATION –

Avoid contact with eyes, skin and clothing.

Wash thoroughly after handling. Exposure may

result in irritation of the skin, eyes or nasal

passages from alkali in Portland cement.

When wet, contact with the skin or eyes may

result in irritation or burns. FIRST AID: In case

of eye contact, flush immediately with plenty

of water for at least 15 minutes and get prompt

medical attention; for skin, wash thoroughly

with plenty of soap and water. If irritation

persists, get medical attention. WARNING!

HARMFUL IF INHALED – Avoid breathing dust.

Keep container closed. Use with adequate

ventilation. Excessive exposure by inhalation

over an extended period of time may result

in the development of pulmonary diseases

including pneumoconiosis and silicosis.

Crystalline Silica has been classified

by IARC and NTP as a carcinogen.

B-1 Trowel Grade Leveler

and Underlayment

REV3/12

SAKRETE 65550060 Installation guide

SAKRETE 65550060 Installation guide

SAKRETE 65550060 Installation guide

Related papers

Other documents