Life Fitness 93T-0XXXX-02 User manual
- Category
- Treadmills
- Type
- User manual
1
Treadmill 93T 93T-0XXXX-02
General Assembly S/N TTD100000
Touch-Up Paint Color Container
0017-00008-0196 Silver Bullet Bottle
0017-00008-0197 Silver Bullet Spray Can
0017-00008-0198 Stealth Gray Bottle
0017-00008-0199 Stealth Gray Spray Can
Manual/Video Part Number
Operation Manual, Eng M051-00K58-B081
Service Manual M051-00K58-A097
Installation Video M051-00K58-A098
Service Video M051-00K58-A099
Access Panel Cover (2)
0K58-01279-0000
Screw (4)
0017-00101-1771
Leveler
Assembly
Rear End Cap
0K58-01268-0000
Rear End Cap
0K58-01268-0000
Screws (4)
0017-00101-1772
Striding Belt, Deck,
and Rear Roller
Handrail Components
Console
Cup Holder, LT
AK58-00247-0002
Cup Holder, RT
AK58-00247-0001
Motor Cover, Endcaps,
and Hardware
Frame Components
Access Panel Decal, RT
0K58-01336-0001
Access Panel Decal, LT
0K58-01336-0002
Power
Components
Cable
rev 27 Feb
2008
2
Treadmill 93T 93T-0XXXX-02
Frame Assembly S/N TTD100000
Idler Arm
Assembly
Lift Motor
and Frame
Motor
Controller
Wax Lift
Boar
d
Anti-Scuff Pad
0K58-01376-0000 (2)
Wax Components
Static Brush
Motor
Assembly
Anti-Static Tinsel
Tinsel Spring
0017-00009-0901
0K58-01102-0001
Front Roller
Assembly
Frame Tag PCB
B084-92187-D000
3
Treadmill 93T 93T-0XXXX-02
Console Assembly S/N TTD100000
Console Assembly Overlay Switch Bezel Assy Language
AK58-00198-0001 AK58-00204-0001 Eng/Met
AK58-00198-0002 AK58-00204-0001 Eng/Eur
AK58-00198-0003 AK58-00204-0003 German
AK58-00198-0004 AK58-00204-0004 Spanish
AK58-00198-0006 AK58-00204-0006 Japanese
AK58-00198-0007 AK58-00204-0007 French
AK58-00198-0008 AK58-00204-0008 Italian
AK58-00198-0009 AK58-00204-0009 Dutch
AK58-00198-00010 AK58-00204-00010 Portuguese
AK58-00198-00011 AK58-00204-00011 Chinese
PCB Assembly
A084-92184-A004
Rear Console Case
0K58-01272-0000
Rear Console Decal
0K58-01357-000
Console Screw (8)
0017-00101-1288
Console Accessory
Cover
0K58-01280-0000
PCB Mounting Screw (8)
0017-00101-1275
Polar Receiver
118E-00001-0152
Polar PCB Cable Assy
AK39-00064-0000
Switch Membrane
118E-00001-0128
Front Console Case
0K58-01273-0001
Stop Switch
0K58-01321-0000
Micro-Switch
0017-00032-0185
CD Tray, Rubber Pad
0K58-01359-000
0
Tether Stop Assy
AK58-00322-0000
Magnet Disc
0K40-01070-0000
See Table
4
Treadmill 93T 93T-0XXXX-02
Handrail Assembly S/N TTD100000
Handrail Hex Nut (4)
0017-00103-0327
Handrail (2)
AK58-00259-0000
Top RT Handrail Boot
0K58-01303-0001
Console/Cup Holder
Mounting Screw (8)
0017-00101-1780
Bottom RT
Handrail Boot
0K58-01304-0001
Handrail Mounting
Screw (4)
0017-00101-1774
Handrail Boot
Screws (6)
0017-00101-1770
Bottom LT
Handrail Boot
0K58-01304-0002
Console Mounting
Screw (4)
0017-00101-1773
Top LT Handrail Boot
0K58-01303-0002
Handrail Screw (2)
0017-00101-1773
Handrail Tube Cap (2)
0K58-01323-0000
Upright, RT
AK58-00311-0001
Upright, LT
AK58-00255-0002
Upright Tube Cap (2)
0K58-01302-0000
Upright Tube
Cap Screw (2)
0017-00101-1772
Grommet (2)
0017-00042-0326
Hardware Bag Assembly
AK58-00227-0001
Upright Plug (2)
0K58-01305-0000
Upright Mounting
Screw - 0017-00101-1778 (6)
Washer - 0017-00104-0325 (6)
Handrail Collar (2)
0K58-01348-0000
ERGO Bar Assembly
AK58-00190-0000
ERGO Bar Gasket (2)
0K58-01347-0000
5
Treadmill 93T 93T-0XXXX-02
Covers, End Caps, Hardware S/N TTD100000
Front End Cap (2)
0K58-01267-0000
End Cap Screws (4)
0017-00101-1772
Front Cover
0K58-01266-0000
Screws (4)
0017-00101-1771
Motor Cover Screws (4)
0017-00101-1772
Motor Cover
AK58-00228-0000
Bug Medallion Assembly
AK58-00245-0000
Felt Strip - 28”
0017-00081-0294
6
Treadmill 93T 93T-0XXXX-02
Belt, Deck, Rear Roller S/N TTD100000
Deck
0K58-01091-0001
Deck Mounting Screws (4)
0017-00101-1775
Grommet (2)
0017-00042-1147
TECSPAK Spring (8)
0K40-01026-0002
TECSPAK Tinnerman Clip (8)
0017-00103-0198
TECSPAK Mounting Screw (8)
0017-00101-1652
Belt Limit Label, RT
M051-00K58-A100
Caution Label
M051-00K58-A014
Striding Belt
0K58-01180-0000
Rear Roller
0K58-01002-0000
Roller Guard, LT
0K58-01390-0002
Roller Guard, RT
0K58-01390-0001
Rear Roller
A
djusting Screws
0017-00101-1779
Screw (4)
0017-00101-1776
7
Treadmill 93T 93T-0XXXX-02
Lift Motor and Frame S/N TTD100000
Clevis Clip
0017-00007-0208
Clevis Pin
0017-00007-0214
Lift Motor
0K58-01062-0000
Lock Nut (2)
0017-00103-0285
Hex Screw (2)
0017-00101-1777
Flat Washer (2)
0017-00104-0259
Bronze Sleeve (2)
0K58-01089-0000
Line Cord Clip
0017-00042-0840
Lift Frame
0K58-01066-0000
Lock Nut
0017-00103-0025
Lift Motor Hex Bolt
0017-00101-1021
Vinyl Cap
0017-00042-1075
Wheel
0K58-01071-0000
Phillips Screw
0017-00101-1612
Washer
0017-00104-0189
Lift Frame End Cap
0017-00042-1076
IEC Receptacle
0017-00003-0949
Retainer Bracket w/Screw
0017-00042-1145
Frame Screws
0017-00101-1723
8
Treadmill 93T 93T-0XXXX-02
Wax/Lift Assembly S/N TTD100000
Wax Lift Mounting Screw (3)
0017-00101-1641
Pin Collar Spacer (3)
0017-00042-1070
Wax/Lift PCB
A084-92261-A001
Spacer (3)
0017-00042-1149
Mounting Bracket
0K58-01316-0000
Plastic Grommet (4)
0017-00042-0821
Locking Nut (3)
0017-00103-0052
Motor Capacitor
PCB Assembly
B084-92241-A000
Motor Capacitor
PCB Mounting
Screw (4)
0017-00101-1253
9
Treadmill 93T 93T-0XXXX-02
Motor Controller Assembly S/N TTD100000
AK60-00171-0000 MTR-CNTRL W/O FERRITE ASY: 100-120
Model SKU Description
93T-0100-02 93T.ENG/ENG.120/60.DOM
93T-0105-02 93T.ENG+MET.100/50.DOM
93T-0300-02 93T.FRN/MET.120/60.DOM
93T-0400-02 93T.SPN/MET.120/60.CON
93T-0705-02 93T.JAP/MET.100/50.DOM
93T-0800-02 93T.POR/MET.120/60.DOM
AK58-00372-0001 MTR-CNTRL W/O FERRITE ASY: 200-240
Model SKU Description
93T-0103-02 93T.ENG+MET.220/60.DOM
93T-0104-02 93T.ENG+MET.240V+. AUS
AK58-00372-0003 MTR-CNTRL W/FERRITE ASY: 200-240
Model SKU Description
93T-0101-02 93T.ENG+MET.230/50.CON
93T-0102-02 93T.ENG+MET.240/50.U.K
93T-0106-02 93T.ENG+MET.200/50.DOM
93T-0109-02 93T.ENG+MET.230/50.U.K
93T-0201-02 93T.GER/MET.230/50.CON
93T-0301-02 93T.FRN/MET.230/50.CON
93T-0401-02 93T.SPN/MET.230/50.CON
93T-0501-02 93T.ITL/MET.230/50.CON
93T-0601-02 93T.DUT/MET.230/50.CON
93T-0706-02 93T.JAP/MET.200/50.DOM
93T-0801-02 93T.POR/MET.230/50.CON
A
K58-00077-0001
10
Treadmill 93T 93T-0XXXX-02
Drive Motor Assembly S/N TTD100000
Poly-V Pulley
0K58-01057-0001
Motor w/Caution Label
AK58-00171-0000
Slotted Hex Screw (2)
0017-00101-0975
Speed Sensor Assembly
AK58-00073-0001
Sensor Wheel
Mounting Screw (3)
0017-00101-1631
Sensor Wheel
0K58-01094-0000
Locking Nut (4)
0017-00103-0027
Washer (4)
0017-00104-0409
Insulating Shoulder
Washer (4)
0K58-01255-0000
Insulating Pad (2)
0K58-01256-0001
Flywheel Assembly
AK58-00090-0002
11
Treadmill 93T 93T-0XXXX-02
Wax Components S/N TTD100000
Brass Spray Tip
0017-00009-0842
Extrusion
0K58-01111-0001
Phillip Screws
0017-00101-0658
Tie Straps
0017-00042-0622
PVC Tube - 22”
0017-00041-0830
Spray Nozzle Assembly
AK58-00046-0000
Protective Sleeve
0K58-01080-0000
Wax Refill Bag
GK58-00002-0002
Wing Nuts
0017-00103-0284
Tube Reducer Connector
0017-00021-2188
Hose Clamp
0017-00042-0842
Wax Pump
AK58-00187-0000
Replacement Hose
AK58-00148-0000
12
Treadmill 93T 93T-0XXXX-02
Idler Arm Assembly S/N TTD100000
Idler Arm Assembly
AK58-00053-0002
Idler Pin
0017-00007-0248
Idler Spring Damper
0K26-02055-0000
Idler Spring
0K58-01085-0000
Wire Clamp
0017-00042-1072
Screw
0017-00101-1193
Limit Switch
0017-00032-0195
Grommet
0017-00042-0326
Drive Belt
0K58-01114-0000
Idler Pulley
0K26-01731-0000
Threaded Idler
0K58-01084-0002
Lock Nut: Idler
0017-00103-0324
Shaft
Tinsel Bracket
0K58-01263-0001
Tinsel Bracket Screw(2)
0017-00101-1193
Plug
0017-00042-1053
(For units not
equipped with
circuit breaker.)
13
Treadmill 93T 93T-0XXXX-02
Leveler Assembly AK58-00370-0000 S/N TTD100000
Bracket Leveler
0K58-01083-0000
Pivot Pin
0K58-01098-0000
Leveling Foot
0K58-01110-0000
Stop Nut
0K58-01099-0000
Hex Nut (4)
0017-00101-1253
Lock Washer (4)
0017-00104-0333
Flat Washer (4)
0017-00104-0190
14
Treadmill 93T 93T-0XXXX-02
Front Roller Assembly AK58-00066-0000 S/N TTD100000
Polley V Pulley 8”
0K58-1105-0000
Hex Bolt
0017-00101-1632
Flat Washer
0017-00104-033
0
Lock Washer
0017-00104-0005
Flat Washer
0017-00104-0043
Mounting Bolt
0017-00101-0974
15
Treadmill 93T 93T-0XXXX-02
Power Components Schematic S/N TTD100000
Voltage Power Cable Part No. Breaker AMP/Part No.
100v AK58-00258-0001 4 AMP/0017-00003-0950
200v AK58-00258-0002 2 AMP/0017-00003-0626
220/230v AK58-00258-0003 2 AMP/0017-00003-0626
240+ AK58-00258-0004 2 AMP/0017-00003-0626
10 Amp Line Filter
units with 220v or higher
0017-00003-0898
20 Amp Line Filter
units with 230v or lower
0017-00003-0943
On/Off switch
0017-00032-0198
4” Black Wire
AK58-00081-0000
6” White Wire
AK58-00082-0000
5” Green/Yellow Wire
AK58-00083-0000
Xformer Bracket Assembly
(foreign units only)
AK58-00210-0000
MOV/Filter Cable Assy.
AK58-00224-0001
Line Cord (Plug End Changes)
0017-00003-0947 12’ 120v
0017-00003-0923 Domestic
0017-00003-0948 12’ 220v
0017-00003-0915 RT Angle Plug
0017-00003-0781 220v/60Hz
0017-00003-0696 Continental
0017-00003-0890 Uk
16
Treadmill 93T 93T-0XXXX-02
Wax/Lift Power Supply S/N TTD100000
AK58-43-0
AK58-77-1
(4
WIRE)
AK58-181-0
(3
WIRE)
AK58-81-0
AK58-82-0
AK58-83-0
AK58-222-0
AK58-81-0
AK58-82-0
AK58-83-0
AK58-34-0
AK60-9-1
AK58-35-1
AK58-27-0
AK58-29-0
AK58-237-0
AK58-36-1
AK58-41-1
AK58-31-0
AK58-32-0
AK58-30-0
AK58-224-1
AK58-263-0
AK58-263-0
AK58-224-1
AK58-42-2
B
B
B
B
123
GND
RPM_IN
VCC
P5
MOTOR
CONTROLLER
AK58-242
*BLACK
*RED
*WHITE
3POS.MINIFITSR.CONN.
&BLACK
&WHITE
&GR E EN
&BLACK
&WHITE
&GREEN
&BLACK
&WHITE
&GREEN
AK58-00223-0004
AK58-00223-0003
AK58-00223-0002
AK58-00223-0001
120V
DOMESTIC
ONLY
MOTOR
CONTROL
POWER
WAX/LIFT
POWER
27 5V A C
MOV
(x3)
ON/O F F
switch
100V,
200-240V
FOREIGN
275VAC
MOV
(x3)
ON/OFF
switch
220/230
VOLTS
CABLE
SHOWN
WAX/LIFT
POWER
MOTOR
CONTR OL
POWER
2POS.
MICROFIT
CONN.
4POS.
MICROFIT
CONN.
FASTON.TE RM
(2
PLCS)
E
STOP
POLAR/END
SE SSI O N
KEY PAD S
WAX
LIFT
POWER
SUPPLY
LEVEL
SW ITCH
CLOSED
@
0
%
10P OS. MI NIF IT JR. CONN .
LIFE
LINK
GRE EN/ YELLOW
UP,RL
4
*RED MISO
8POS.MINIFITJR.CONN.
*WHIT E
*BLACK
21
VCC
GND
BOTTOM
0
POSITION
4
3
2
1
*BLACK
*RED
*WHITE
P2
GND.
5
P8
TXD
RXD
*YE LLOW
*ORA NGE
*BLU E
*BROW N
*GREE N
CE
854376
MOS I
SC K
NC.
CS
P4
P7
321
DN, R L2
HOT
PUR PLE
ORA NGE
BUS
REQ
2
3
2
1
GND.
+8VDC
1
GND.
P1
YELLOW
+8VDC
+8VDC
34
GND.
567
RXD
NC.
+12 VD C
BUS_REQ
RE ED SE NSE
89
TXD
10
GREE N
RED
BROW N
BLU E
BLA CK
WHI TE
GRA Y
4POS.MNL.CON.
4
N/C
WHITE
BLACK
P6
21
LINE
NEUTRAL
GND
2
3
1
WHI T E
GREEN
BLACK
10POS.MINIFITJR.CONN.
N. O.
6POS.MICROFIT.CONN.
POLAR
RECEI VE R
PCB
N. O.
NS
G ND.
+8VDC
+8VDC
G ND.
REED
SENSE
TXD
RXD
BUS
_
REQ
+12VDC
RELAY ENABLE
2
ORANG E
YELLOW
P1
1
GREE N
RED
BROWN
PUR PLE
BLUE
BLACK
GRAY
WHITE
43 567 9810
POLAR
VCC
GND
VCC
STOP
NC.
*WHI TE
*WHI TE
P11
12
*RED
*WHI TE
*RED
*BLAC K
*BLAC K
2
P6
31645
NS
CARDI O
OTHER
MA N UA L
RAN DOM HILL
BURN
FAT
SPA R E
SPA R E
TEST
FIT
3
SPARE
12
10 PO S. R AL I F. C ON N.
GND
RI GHT
LE FT
GND
*CLEAR
*CLEAR
*BLACK
*BLACK
1
P7
324
P3
4P OS.M I CROF IT. CON N.
P2
12POS.RALIF.CONN.
P4
16POS.KK100
DOWNSTART
GND
NEUTRAL
LINE
1
2
3
P1
GREEN
WHITE
BLACK
#BLK
#GR N / Y L W
N
LO A D
LINE
FILT E R
LINE
#WHT
N
NE U
#WHT
HOT
GND
L
#BL K
L
#GRN/YLW
AUTO
X-FRMR
1
2
3
4
5
6
10 0V IN
1
2
3
4
5
6
CLEAR
CLEAR
DOWNDOWN
QUICK
PAUSE
TIM E
UP
TIM E
INCLINE
INCLINE
UP
DOWN
COOL
SPEED
SPEED
UP
START
QUICK
PAUSE
DOWN
UP
TIM E
TIM E
DOWN
INCLINE
INCLINE
UP
COOL
DOWN
SPEED
SPEED
DOWN
UP
4
7
1
ENTER
SELECT
DOWN
UP
SELECT
ENTER
HARD SOFT
0
DECK DECK
65
89
23
16POS.KK100
GRE EN
BLACK
WHI T E
6POS.MINIFITJR.CONN.
COM
22 0/ 23 0 V
IN
12 0V OUT
#GR N / YL W
CIRC UIT
BREAKER
(SEE
CHART )
LO A D
L
N
LIN E
FILT ER
LINE
#WHT
N
#BL K
L
24 0V IN
20 0V IN
240V
22 0/ 230 V
200V
NEU
#WHT
#BLK
GND
HOT
#GRN / Y LW
2
AMP
POWER
CABLE
PAR T #
100V
VOLTAGE CIRCUIT
BREAKER
4
AMP
MAIN
PWR/ SCI
CSA FE
CAR DIO
THEATER
2
CSAFE
CARDIO
THEATER
1
LIFE
PULSE
MESSAGE
CENTER
CONSOLE
*BLACK/BROWN
*GREEN
*RED
*WHITE
*BLACK
*BLACK/GREEN
*BLACK/RED
*BLACK/WHITE
*PINK
*GRAY
*PURPLE
*YELLOW
*ORANGE
*BLUE
*BROWN
*GREEN
*RED
*WHITE
*BLACK
4POS.INLINEMICRO-FIT
8POS.MOD.PHONEJACK
8POS.MOD.PHONEJACK
D11
5
CTS
8
7
GND
6
5
4
3
8V
TD
RD
ST11
ST10
ST9
ST8
ST7
ST6
ST5
D10
D8
D9
13
16
15
14
9
12
11
10
8
7
6
6
CTS
2
1
8
7
GND
2
5
4
3
8V
TD
RD
1
U_DETECT
UD_ E N
8VDC
GND.
D12
D13
D14
D15
4
1
4
3
2
3
2
1
P8
11
4
3
2
1
7
12
6
5
10
9
8
7-7
SEGMENT
SIDE
CONSOLE
DISPLAY
USED
ON
97Ti
16
15
14
13
USER
SENSE
4
4POS.MICRO-FIT
3
2
1
USED
ON
95Ti
&
97Ti
BLACK
EXTERNAL
MEMORY
FRAME
TAG
LIFT
MOTOR
WAX
PUMP
MOTOR
SPEED
PICK-UP
MISO
8POS.MINIFITJR.CONN.
VCC
GND
1 2
MOS1
SCK
CE
NC.
CS
834567
RED
WHITE
2POS.MAT-N-LOK.CONN.
21
$WHI TE
3
$B LACK
$RED
21
10POS.
MINIFITJR.
CO NN.
3P OS.C- G RI D.C ONN.
3POS. C-GRID.CON.
3POS.C-GRID.CON.
CAPACITOR
BD.
P1
IN100 -1 20V
200-240V OUT
P1-3
NEU
VN EG
VP OS
VP OS
4POS. SABRE.CON.
4321
P4
VOU T
GN D
VIN
GND
1
4
2
3
5POS.
MINIFITJR.
CONN.
2POS.
MAT-N-LOK.
CONN.
3POS.
MAT-N-LOK.
CONN.
AK58-243
4POS.
SAB RE.
CON.
0%
SWITCH
FA STON.TER M
(4
PLCS)
ATTACHED
TO
LIFT
MOTOR
-3%
SWITCH
4P OS .
MICR OF IT
CONN.
*RED
*BLACK
*RED
BOTTOM
0
POSIT ION
3
4
1
GN D.
ON
UNITS
WITH
NEGATIVE
DECLINE
P2
*BLA CK
2
GN D.
1 2
21
6POS.
MICROFI T.
CONN.
BUSREQ
TXD
RXD
GND .
8VDC
6
5
4
2
1
P9
BUSR EQ
GND .
8V D C
*BROWN
*GREE N
*WHIT E
*BLACK
*RED
6POS.
MINIFITJR.
CONN.
6
5
4
TXD
RXD
2
1
P3
PINR LY
3
*BLUE
3
PINR LY*BLUE
MOTOR
6POS.MNL2.CON.
6POS.MNL2.CON.
P2
56 4 3 21
PURPLE
BLACK
RED
WHITE
BLUE
BLUE
654321
GREEN/YELLOW
GND
BLACK
V19
RED
W18
WHITE
U20
BLUE
AC2
BLUE
AC PWR
21
2P O S .
MIN IF I T JR .
CONN.
2POS.
MI NIF ITJR .
CONN.
2P OS.
MI NI F IT J R.
CONN.
HI-POT
JUMPER
(REMO VE
FOR
HI-POT
TE ST
ONLY)
HI- POT
JUMPER
(REMO VE
FO R
HI- POT
TEST
ON LY)
-
1
-
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
Life Fitness 93T-0XXXX-02 User manual
- Category
- Treadmills
- Type
- User manual
Ask a question and I''ll find the answer in the document
Finding information in a document is now easier with AI
Related papers
-
Life Fitness 93tw User manual
-
-
Life Fitness 97TW User manual
-
-
-
-
-
-
-
Other documents
-
Philips 8500 User manual
-
USE 1771.24 Installation guide
-
Armen Living LCBRSH24 Operating instructions
-
Univex TR9100 Series User manual
-
ALLEGION RC-04 ISONAS Reader Controll User guide
-
Treadmill Doctor TR95-00000-0032 User manual
-
Citronic ST5 User manual
-
Fraser Hill Farm FFFT050-1RGG Installation guide
-
ST ST5-Si User manual
-
Omega ST5/10-Q-Si-IP Owner's manual
