Dometic DMC2641, DMC2841 Installation guide

DMC2641, DMC2841

Refrigerator

Installation and Operating Manual. . . . . . . 14

EN

REFRIGERATION

AMERICANA

DMC2641_DMC2841--IO--US.book Seite 1 Mittwoch, 16. August 2017 12:23 12

DMC2641_DMC2841--IO--US.book Seite 2 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

3

DMC 2641

1

2

3

4

6

5

1

DMC2641_DMC2841--IO--US.book Seite 3 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

4

1

2

3

4

6

5

DMC 2841

2

MODE

1 2 3 4

5

6

3

DMC2641_DMC2841--IO--US.book Seite 4 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

5

1

3

2

4

DMC2641_DMC2841--IO--US.book Seite 5 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

6

min. 611 mm

(min. 24")

610 – 620 mm

(24" – 24.4")

DMC 2641: 1362 – 1372 mm (53.6" – 54")

DMC 2841: 1520 – 1530 mm (59.8" – 60")

5

>∅25.4 mm

(>∅1")

21

6

DMC2641_DMC2841--IO--US.book Seite 6 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

7

∅/mm²

l/m

12 V

24 V

0 2 4 6 8 10 12 14 16 18 20 22 24 26 28

0

2

6

10

14

8

DMC2641_DMC2841--IO--US.book Seite 7 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

8

1

3

2

9

0

DMC2641_DMC2841--IO--US.book Seite 8 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

9

1.

2.

3.

a

b

DMC2641_DMC2841--IO--US.book Seite 9 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

10

1

c

21

d

DMC2641_DMC2841--IO--US.book Seite 10 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

11

1. 2.

4.3. 5.

e

DMC2641_DMC2841--IO--US.book Seite 11 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

12

600 (23.6")

1389 (54.7")

580 (22.8")

611 (24.0")

633 (24.9")

230

(9")

40

(1.6")

1360 (53.5")

DMC 2641

f

DMC2641_DMC2841--IO--US.book Seite 12 Mittwoch, 16. August 2017 12:23 12

DMC2641, DMC2841

13

580 (22.8")

DMC 2841

1545 (60.8")

1516 (60.0")

600 (23.6")

611 (24.0")

230

(9")

40

(1.6")

633 (24.9")

g

DMC2641_DMC2841--IO--US.book Seite 13 Mittwoch, 16. August 2017 12:23 12

EN

DMC2641, DMC2841

14

Please read this instruction manual carefully before installation and first

use, and store it in a safe place. If you pass on the product to another

person, hand over this instruction manual along with it.

Table of contents

1 Explanation of symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

2 Safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15

3 Scope of delivery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

4 Intended use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18

5 Technical description . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19

6 Installing and connecting the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . 20

7 Using the refrigerator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

8 Cleaning and maintenance. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

9 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31

10 Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

11 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34

12 Technical data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35

DMC2641_DMC2841--IO--US.book Seite 14 Mittwoch, 16. August 2017 12:23 12

EN

DMC2641, DMC2841 Explanation of symbols

15

1 Explanation of symbols

D

!

A

I

2 Safety instructions

The manufacturer accepts no liability for damage in the following cases:

• Faulty assembly or connection

• Damage to the product resulting from mechanical influences and excess voltage

• Alterations to the product without express permission from the manufacturer

• Use for purposes other than those described in the operating manual

2.1 General safety

D

DANGER!

• On boats: If the device is powered by the mains, ensure that the

power supply has a residual current circuit breaker. The break distance

must not be less than 3 mm.

DANGER!

Safety instruction: Failure to observe this instruction will cause fatal or

serious injury.

WARNING!

Safety instruction: Failure to observe this instruction can cause fatal or

serious injury.

CAUTION!

Safety instruction: Failure to observe this instruction can lead to injury.

NOTICE!

Failure to observe this instruction can cause material damage and impair

the function of the product.

NOTE

Supplementary information for operating the product.

DMC2641_DMC2841--IO--US.book Seite 15 Mittwoch, 16. August 2017 12:23 12

EN

Safety instructions DMC2641, DMC2841

16

!

WARNING!

• Have a qualified technician perform the installation in wet rooms.

• Do not operate the device if it is visibly damaged.

• If this device's power cable is damaged, it must be replaced by the

manufacturer, customer service or a similarly qualified person in order

to prevent safety hazards.

• This device may only be repaired by qualified personnel. Inadequate

repairs may cause serious hazards.

• This device can be used by children aged 8 years or over, as well as by

persons with diminished physical, sensory or mental capacities or a

lack of experience and knowledge, providing they are supervised, or

have been taught how to use the device safely and are aware of the

resulting risks.

• Cleaning and user maintenance must not be carried out by children

without supervision.

• Children must be supervised to ensure that they do not play with the

device.

• Always keep and use the device out of the reach of children under 8

years of age.

• Do not store any explosive substances, such as spray cans with propel-

lants, in the device.

!

CAUTION!

• Danger of crushing! Do not put your fingers into the hinge.

• Foodstuff may only be stored in its original packaging or in suitable

containers.

A

NOTICE!

• Check that the voltage specification on the type plate is the same as

that of the power supply.

• Never pull the plug out of the socket by the connection cable.

• If the refrigerator is connected to the DC socket: disconnect the refrig-

erator and other electric consumers from the battery before connect-

ing the quick charging device.

• If the refrigerator is connected to the DC socket: disconnect the refrig-

erator or switch it off when you turn off the engine. Otherwise you may

discharge the battery.

• The refrigerator is not suitable for transporting substances which are

caustic or contain solvents.

DMC2641_DMC2841--IO--US.book Seite 16 Mittwoch, 16. August 2017 12:23 12

EN

DMC2641, DMC2841 Safety instructions

17

• Keep the drainage outlet clean at all times.

• Do not open the refrigerant circuit under any circumstances.

• Never transport the device in a horizontal position, so that no oil can

leak out of the compressor.

• Make sure that the refrigerator circuit is not damaged during transpor-

tation. The refrigerant in the refrigerator circuit is highly flammable.

In the event of any damage to the refrigerator circuit:

– Avoid naked flames and sparks.

– Air the room well.

• Set up the device in a dry location where it is protected against splash-

ing water.

2.2 Operating the device safely

D

DANGER!

• Do not touch exposed cables with your bare hands. This applies espe-

cially when operating the device from the AC mains.

!

CAUTION!

• Before starting the device, ensure that the power supply line and the

plug are dry.

• If you connect the device to a battery, make sure that no food comes

into contact with the battery acid.

• Do not use extension cords.

A

NOTICE!

• Do not use electrical devices inside the cooling device unless they are

recommended by the manufacturer for that purpose.

• Do not place it near naked flames or other heat sources (heaters, direct

sunlight, gas ovens etc.)

• Danger of overheating!

Always ensure sufficient ventilation so that the heat generated during

operation can dissipate. Make sure that the device is sufficiently far

away from walls and other objects so that the air can circulate.

• Ensure that the ventilation vents are not covered.

• Do not fill the inner container with ice or fluid.

• Never immerse the appliance in water.

• Protect the appliance and the cable against heat and moisture.

• Make sure that foodstuffs do not touch the walls of the cooling area.

DMC2641_DMC2841--IO--US.book Seite 17 Mittwoch, 16. August 2017 12:23 12

EN

Scope of delivery DMC2641, DMC2841

18

3Scope of delivery

4 Intended use

The RPD series refrigerators are suitable for refrigerating foodstuffs and

storing frozen foodstuffs.

The device is also suitable for use on boats.

The device is designed to be operated from a 12 V or 24 V on-board

supply socket of a vehicle, boat or RV as well as from a 100 – 240 V mains.

!

The refrigerator is only suitable for installation in a fitted cavity. Once it is installed,

only the front of the appliance may be accessible.

Quantity Description

1 Refrigerator

1 Lower ventilation grille

1Drain hose

2 Icecube tray

1 LH hinge conversion kit (with instruction)

2 Airing position card

1 Operating manual

CAUTION! Health hazard!

Please check if the cooling capacity of the device is suitable for storing

the food or medicine you wish to cool.

DMC2641_DMC2841--IO--US.book Seite 18 Mittwoch, 16. August 2017 12:23 12

EN

DMC2641, DMC2841 Technical description

19

5 Technical description

5.1 Function description

The device can refrigerate goods to +7 °C to +2 °C (45 °F to 36 °F) and keep them

cool. Products can be frozen to –10 °C to –18 °C (14 °F to 97 °F) in the freezer

compartment. You can use the variable thermostat to set the desired temperature.

The refrigerator is suitable for use with 12 V

g or 24 Vg and can therefore also be

used e.g. for mobile homes, caravans or on boats. It can also be connected to a

100 – 240 V mains supply.

The refrigerator can withstand a short-term inclination of 30°, for example on boats.

All materials used in the refrigerator are compatible for use with foodstuffs. The

refrigerant circuit is hermetically sealed and CFC-free.

5.2 Control elements inside the refrigerator

The various types of refrigerators are shown in the following illustrations:

• DMC2641: fig. 1, page 3

• DMC2841: fig. 2, page 4

No. Description

1 Freezer compartment

2 Control panel

3 Wire shelf (folding, so that bottles can be put in the refrigerator)

4Shelf

5 Crisper bin

6 Door shelf

DMC2641_DMC2841--IO--US.book Seite 19 Mittwoch, 16. August 2017 12:23 12

EN

Installing and connecting the refrigerator DMC2641, DMC2841

20

5.3 Control elements

6 Installing and connecting the

refrigerator

Please note the following instructions for installation on boats:

D

A

6.1 Reversing the doors

With the LH hinge conversion kit you can change the hinge of the door, so that it

opens to the left instead to the right. A separate instruction sheet is included with this

kit.

No. in

fig. 3, page 4

Description

1 ON/OFF button

2 Power LED

3 Status LED

4 Mode button

5 Temperature level LEDs

6 Temperature setting button

DANGER!

If the device is powered by the mains, ensure that the power supply has

a residual current circuit breaker.

NOTICE!

• The device can be tilted sideways up to 30°. When setting up the

refrigerator, note that it must be fastened to take account of this. If

you have any questions regarding installation, consult your specialist

dealer.

• Install the refrigerator so that the warm air generated can easily flow

away (fig. 4, page 5)

• The appliance is designed for ambient temperatures between

+16°C and +43°C (61°F to 109°F).

DMC2641_DMC2841--IO--US.book Seite 20 Mittwoch, 16. August 2017 12:23 12

Page is loading ...

Dometic DMC2641, DMC2841 Installation guide

Dometic DMC2641, DMC2841 Installation guide

Related papers

Other documents