Curtis CB CBP CB CBP User guide

Important Safeguards/Conventions

This appliance is designed for commercial use. Any servicing other than cleaning and maintenance should be performed by an

authorized service technician.

 •DoNOTimmersetheunitinwateroranyotherliquid

 •Toreducetheriskofreorelectricshock,doNOTopentoporfrontpanel.Nouserserviceablepartsinside.

 •Keephandsandotheritemsawayfromhotpartsofunitduringoperation.

 •Nevercleanwithscouringpowders,bleachorharshchemicals.

Symbols

WARNINGS–Tohelpavoidpersonalinjury

ImportantNotes/Cautions–fromthefactory

SanitationRequirements

YourCurtisComboBrewerisFactoryPre-SetandReadytoGo…RightoutoftheBox.

FollowingaretheFactorySettingsforyourCoffee/TeaBrewingSystem:

 •BrewTemperature=204°F

 •BrewVolume=Settodispensingvesselrequirements(2.2liters)

GenerallytherewillneverbeareasontochangetheG3/GoldCupSeriesdefaultsettings.However,shouldyouneedtomakeslight

adjustmentstomeetyourbrewingneeds,programminginstructionsareprovidedlaterinthismanual.

 SystemRequirements:

  •WaterSource20–90PSI.Minimumowrateof½gpm(1gpmpreferredowrate).

  •Electrical:Seeattachedschematicforstandardmodelorvisitwww.wilburcurtis.comforyourmodel.

Equipmenttobeinstalledtocomplywithapplicablefederal,state,orlocalplumbing/electricalcodeshavingjurisdiction.

SETUP STEPS

Theunitshouldbelevel(lefttorightandfronttoback)andlocatedonasolidcountertop.Connectawaterlinefromthewaterltertothe

brewer.

NOTE:Awaterltrationsystemmustbeusedtohelpmaintaintrouble-freeoperation.Air must be purged from the

cartridge prior to connection to equipment.Inareaswithextremelyhardwater,wehighlyrecommendtheuseofaCurtis

approvedwaterlter.Forourfulllineoflters,pleaselogontowww.wilburcurtis.com.

1.A1/4”Flarehasbeensuppliedforwaterlineconnection.Usetubingsizedsufcientlytoprovideaminimumof½gpm(1gpmis 

 preferred).

2.Connecttheunittoanappropriateelectricalpowercircuit.

3.Turnonthetoggle(STANDBY/ON)switchbehindtheunit.Theheatingtankwillstarttoll.Whenthewaterlevelinthetankrises 

 tothecorrectvolume,theheatingelementwillenergizeautomatically.WiththeG3/GoldCupSeriesthereisnodangerofelement 

 burnoutduetoanunlledheatingtank.

4.Theheatingtankwillrequire20to30minutestoreachoperatingtemperature(204°F)asindicatedbytheREADY-TO-BREW 

 LCDreadout.

5.Important:RunonefullTEAbrewcyclerst,beforerunningacoffeebrewcycletopurgewaterlinesandvalvesofair.Five 

 secondsofpulsingdilutionwateratthebeginningofeachTEAbrewcycleisnormalpre-programmedoperatingbehavior.

NSFInternationalrequiresthefollowingwaterconnection:

1.Aquickdisconnectoradditionalcoiledtubing(atleast2xthedepthoftheunit)sothatthemachinecanbemovedforcleaning

underneath the unit.

2.Thisequipmentistobeinstalledwithadequatebackowprotectiontocomplywithapplicablefederal,stateandlocalcodes..

3.Waterpipeconnectionsandxturesdirectlyconnectedtoapotablewatersupplyshallbesized,installedandmaintainedin

accordancewithfederal,state,andlocalcodes.

CAUTION:Pleaseuse

this setup procedure

before attempting to use

thisbrewer.Failuretofollowthe

instructionscanresultininjuryorthe

voidingofthewarranty.

CAUTION:DONOT

connectthisbrewertohot

water.Theinletvalveis

notratedforhotwater.

IMPORTANT:After

setup,runafullTEA

cyclerstbeforerunning

aCOFFEEcycle.Placeanempty

teacontainertocatchbothhotwater

fromthebrewconeanddilution

waterfromspoutonthefrontcover.

Models:

 •CB

 •CBP

WARNINGHOTLIQUID,

Scaldingmayoccur.

Avoid splashing.

4. Pourground

coffee into

brewcone

marked

COFFEE

6.Pressthe

COFFEE

Brewbutton.

5. Position

lledbrew

cone into

brewrails.

BREWING INSTRUCTIONS – COFFEE

1.Ready-to-BrewshouldbedisplayedontheUCMscreen.

2.Makesurethatthefoldingairpotdeckisintheproperpositiontoaccommodateyourairpot.Placeaclean,emptyairpotonthedeck.

3. Placeanewpaperlterintothebrewcone.

FOR THE LATEST SPECIFICATIONS AND INFORMATION GO TO WWW.WILBURCURTIS.COM

ISO 9001:2008 REGISTERED

WILBUR CURTIS CO., INC.

6913 West Acco Street

Montebello, CA 90640-5403

For the latest information go to

www.wilburcurtis.com

Tel: 800-421-6150

Fax: 323-837-2410

ServiceManual–CB&CBP

Wilbur Curtis Co., inC.

Program Menus

Tea Recipes

ProgramMenus

ContinuedonPage3

Your Curtis G3/Gold Cup Series is Factory Pre-Set for Optimum Performance.

Afterconnectiontowaterandpower;thereartoggleswitchmustbeon.Youwillhearabeepsound,indicatingpowerisavailabletothe

controller.

Thecontroldisplays  .PressON/OFFbuttonandthescreenwilldisplay  .Afterthreeseconds, 

is displayed.

Thetheheatingtankwillllinapproximatelytwotothreeminutes,dependingonwaterowrate.

Whentheproperlevelisreached  willappearonthescreen.Ittakesapproximately20minutestoreachsetpointtem-

peratureof204°F.

Controlwilldisplay   whentemperaturereachesthesetpoint(204°F).Unitisnowreadytobrew.

Brewing Instructions – Tea

1. BrewershouldbeON(Conrmatreartoggleswitch,thenpressON/OFFbutton)andReady-to-Brewdisplayed.

2. Makesuredeckisfoldeddownandteacontainerisinplace.

3. Placelterin

brewbasket.

Pourteainto

basketmarked

ICEDTEA.

4. Slidebrew

cone into rails.

Placetea

container under

brewcone.

Programming

Turnoff(darkdisplay)bypressingON/OFFbutton(yellow).PressandholdBREWbutton4(green)andthenpressandreleaseON/OFFbutton(yellow).

ContinueholdingBREWbutton.Displaywillread  ,waituntil  isdisplayedEnterthe4-digitaccesscode,thedigits1-4corre-

spondtothebuttons(seeillustrationbelow).

Thedefaultcodesetatthefactoryis1-2-3-4.Then  willbedisplayed.

Allprogrammingselectionsareperformedwiththethreecenterbuttons.

Thesymbolsbelowthebuttonsare:

 ScrollLEFT

 SELECTIONorENTERtosavenewparameter

  ScrollRIGHT

431 2

SelectingBrewbyVolumeorBrewbyTimedependsonwhetheryouknowyourbrewtimebeforestarting.

FromProgram Menuspress>displaywillnowshowthenextfeature.

Tea Recipes (Factorysetting,Standard–PurpleFull,Standard–PurpleHalf)

PresstoSelect.Press<or>totogglebetweenStandard-Gray,Standard-Purple,Tropical-Gray,Tropical-

Purple,76/308-Grayand76/308-Purple.Setandexitprogrammingbypressing.

5. Pressthe

teabrew

button to begin

brewingtea.

TeaDilut.Volume

TeaDilut.Time

TeaDilut.Delay

TeaByVolume

TeaByTime

Tea by Volume

ScrolluntilBrewbyVolumeisdisplayed.PresstoSelect.ThedisplaywillreadSelectBrewButton!Oncethedesired

brewbuttonisselected(COFFEEorTEA),thedisplaywillreadPressBREWtoStart0:00Time.PresstheFULLBREW

buttonandhotwaterstartsdispensing.Whenthedesiredvolumeisreached,pressFULLBREWagaintostoptheow.

Thebrewvolumehasnowbeenset(HALFBREWwillalwaysbehalfoftheFULLBREWvolume).WhenEXITisdis-

played,Presstoselectandexittheprogrammingmode.Pressing>buttonwilldisplaythesubsequentmenufeatures.

Tea by Time:(Factorysetto5:52FullBrew,2:56HalfBrew)PresstoSelect.Press<or>toincreaseordecrease

time.TeabyTimehasarangeof0:00to9:59(Incrementsareminutesandseconds).TheHALFBREWbuttonwillbeset

athalfthebrewtime.

Dilution Delay: (Factorysetto30secFullBrew,30secHalfBrew)PresstoSelect.Press<or>totogglebetween

Standard-Gray(30sec),Standard-Purple(30sec),Tropical-Gray(9min),Tropical-Purple(9min),76/308-Gray(4min)

and76/308-Purple(4min).Rangeisfrom0seconds,1minuteto10minutes.

Dilution Volume:PresstoSelect,DisplaywillnowshowPushSTARTToBegin...PresstheBREWbuttonthenwater

startsrunning,whendesiredvolumeisreachedpressBREWbuttonagaintostoptheow.Nowthevolumehasbeenset.

Pressing>buttonwilldisplaythesubsequentmenufeatures.

Dilution Time: (Factorysetto4:05Full,2:02Half)PresstoSelect.Press<or>totogglebetweenStandard-Gray

(4min-5sec),Standard-Purple(4min-5sec),Tropical-Gray(4min-26sec),Tropical-Purple(4min-26sec),76/308-Gray

(4min-55sec)and76/308-Purple(4min-55sec).DilutionTimeisfrom30secto9min,59sec.

Tea Dilution Stir: (FactorysettoStandard–PurpleOn).

PresstoSelect,press<or>forachoiceofStandard-Gray:On,Standard-Purple:On,Tropical-Gray-Off,Tropical-

Purple-Off,76/308-Gray-Offand76/308-Purple-Off.DilutionStirappliesonlytotheDilutioncycle,bypulsingthedilution

time45secondson,5secondsoff.

Tea Pulse Brew (FactorysettoOFF).

PresstoSelect,press<or>tochooseON/OFForD(manualprogramming).Dwillgiveyouapulsingsprayof1-20

pulsesonandoffat5secondincrements,dependingonthetotaltimesetforbrew(seeTeabyTime).

Tea Fast Brew(FactorysettoOFF).

PresstoSelect,press<or>tochooseONorOFF.SelectingONwillstarthotwatersprayinginthebrewconerst

andthen1minutelaterthedilutionwaterwillstarttoow.

Tea Half Batch(FactorysettoON)

WhenthisfeatureisON,ahalfbatchbuttononthecontrolpanelactivates.PresstodisplayONorOFF.Pressing<or

>willchangethisfeatureofforon.

Tea Drip-out (FactorysettoOFF)

PresstoSelect.Press<or>tomovetodesiredtime.SettingsareOFF,5secondsto15minutes(in5secondincre-

ments).PresstoSelecttime.

Coffee by Volume: (Factorysetto60ozFullBrew,30ozHalfBrew)PresstoSelect,DisplaywillnowshowPush

STARTToBegin...PresstheFULLBREWbuttonthenhotwaterstartsrunning,whendesiredvolumeisreachedpress

FULLBREWbuttonagaintostoptheow.Nowthevolumehasbeenset(HALFBREWwillalwaysbehalfoftheFULL

BREWvolume).

Coffee by Time(Factorysetto2:25FullBrew,1:12HalfBrew).

PresstoSelecttochangethebrewtime.Displaywillnowshowthecurrenttime.Bypressing<or>youcantoggle

backandforthfromminutestosecondstoexit(ex).Changethetimeorsetandexitbypressing.

TeaDilutionStir

TeaPulseBrew

TeaFastBrew

Continued on Page 4

TeaHalf-Batch

TeaDrip-out

CoffeeByTime

CoffeeByVolume

Program Menus

Pre-Infusion(FactorysettoOFF)

PresstoSelect.Currentsettinginsecondsisdisplayed<todecreaseorselect>toincrease(rangefromOFFto10

through60seconds), to set.

IfPre-infusionisselected(ON),ColdBrewLockissettoDelta1within5ºFofsetpointandColdBrewLockdisappears

fromthelistofprogramselections.WhenPre-infusionisON,PulseBrewdisappearsfromthelistofprogramselections.

Pulse Brew (FactorysettingOFF)

Presstoselect,<or>toselectOFForoneofvepulsepatterns(AtoE).

GuidelinesforPulseBrew:

Thisfeatureallowstuningofthecoffeeavor.ThisoptionshouldonlybeusedwiththestandardGrayorPurpleAFS

sprayheads.ThepotlevelshouldalwaysbesetrstwiththisoptionOFF.Dependingonyourgrindproleandwater

conditions,thethreePulseBrewoptionshelp“tune”orchangethecoffeeavor.FilterPacktypecoffeestypicallyextract

betterwiththeAandBpulsesetting.DecafcoffeestypicallyextractbetterwiththeBpulsesetting.High-Yieldcoffeestypi-

callyextractbetterwiththeCpulsesetting.Ofcourse,anyoftheA,BorCsettingsmaybeusedtosuityourtasteprole.

SettingsDandEaremanualpulsecounts.IfPulseBrewisselected(ON),ColdBrewLockissettoDelta1within5ºFof

setpointandColdBrewLockdisappearsfromthelistofprogramselections.

WhenPulseBrewisON,Pre-infusiondisappearsfromthelistofprogramselections.

Coffee Drip-out (Factorysetto2minutes)

PresstoSelect.Press<or>tomovetodesiredtime.SettingsareOFF,1,2,3,4and5minutes.PresstoSelect

time.

Safety Sw On/Off (FactorysettoOFF)

Presstodisplay.Pressing<or>willturnthisfeatureofforon.

Temperature(Factorysetto204°F)

PresstoSelect.Press<or>tomovetodesiredtemperatureandthen to set. Temperature is programmable from

170ºFto208ºFin2-degreeincrements.

Energy Save Mode(FactorysettoOFF)

PresstoSelect,<or>ON,OFForON140ºF,toset.WheninON,unitwillautomaticallyshutoff4hoursfrom

lastbrew.WhenfeatureisOFF,unitdoesnothavetheenergysavingmode.

IntheON140ºFposition,temperaturegoesdownto140ºF,ifunithasnotbrewedin4hours.Thisfeaturewillsave

energybymaintainingalowertemperatureinthetankinperiodsofnon-operation.

Brew Count Odom

Presstodisplaytotalbrewcycles.PressexorReset

Brew Count Total

PresstoSelect,Showstotalgallonsandtotalbrewcyclesontheunit.Cannotbereset.

Cold Brew Lock ...(Factorysetto5º)

Presstoselect,<or>toselectdesiredsetting(CBL5,15orOFF), to set.

TheColdBrewLockfeatureallowsthebrewertobrewatthreedifferenttemperaturelevelsfromtheactualsetpoint.The

rstsettingiswithin5degreesofsetpoint,nextiswithin15degreesofsetpoint,OFFiswithin30degreesofsetpointfor

theReadytoBrewmessage,however,itwillbrewatanytemperature.

Master Reset

PresstodisplayAreYouSure?

Then<forYes,>forNo.Whenreset,thebrewerresumesbacktothefactorydefaults.

Service Call(PhonenumberFactorysetto1-800-000-0000)

Presstodisplaynumberandchangenumberor<tomoveplaceandEXtoexitwhencomplete.Thisnumberwillbe

displayedduringaHeatingsystemSENSORERRORorduringaWATERERROR.

EnergySaveMode

Coffee

Drip-out

Temperature

ServiceCall

MasterReset

ColdBrewLock

BrewCountOdom

BrewCountTotal

Continued on Page 5

SafetySWOn/Off

CoffeePre-infusion

CoffeePulseBrew

Program Menus

BeeperOn/Off

P-Maintenance

BannerName

AccessCode

Access Code (Factorysetto1-2-3-4)

Presstodisplaynumberandchangenumber,(thenumbercanbechanged1to4)or<tomoveplaceandextoexit

whencomplete.

Banner Name(FactorysettoCurtis)

Presstodisplaylettersandchangelettersor<tomoveplaceandEXtoexitwhencomplete

Thisfeatureallowsupto14letterstobeprogrammedforcompanynameorregionalname.Programmingallblanks

disablesBannerName.Ifprogrammed,BannerNameisdisplayedevery5sec.onandoff.

P-Maintenance(FactorysettoOFF)

PresstoSelect,SetgallonsbrewedtoindicateP-Maintenance.Press<or>toadjustfromOffto3000gallons.Press

toexit.

Beeper On/Off (FactorysettoON)

PresstodisplayONorOFF.Pressingeither<or>togglesbetweenonandoff.toset.WhenON,thisfeatureallows

you to hear a short beep each time a button is pressed.

Quality Timer(FactorysettoOFF)

PresstoSelect,OFForON,or0to10hoursin5secondincrements.Anaudiblealarmsoundswhentimehasexpired;

atthesametime,thescreenwillashoffandonwiththewords“BrewFreshTea”.Thisfeatureisformodelsbuiltafter

1/2015).

Displ. Brew Time (FactorysettoON)

PresstodisplayONorOFF.Pressingeither<or>togglesbetweenonandoff.

Displ. Messages (FactorysettoON)

PresstodisplayONorOFF.Pressingeither<or>togglesbetweenonandoff.Whenon,thisfeaturedisplays“Rinse

ServerBeforeBrewing”alternately,with“ReadytoBrew”.

Model Select(FactorysettoCOMBO)

PresstoSelect.Pressing<or>willlistmodelsavailable:TEA/IC-1BATCH,TEA/IC-2BATCH,TEA/IC-3BATCH,TEA/

IC-4BATCH,TEA-SWEET,DUAL-DILUTION,DUAL-SWEET,COMBO,COMBO/IC,COMBO-SWEET.Press to select

andexit.

Exit

Presstoselect,exitsprogrammodeandreturnsunittooperation.Pressing>returnsyoutoBrewByVolume.

Exit

Displ.BrewTime

Displ.Messages

QualityTimer

ModelSelect

Program Menus

Error Message

WiththeG3/GoldCupSeriesbrewers,therearethreeerrormessagesthatcanappearonthescreentoadvisetheuserofamalfunction.Ifoneof

theseerrormessagesappear,thebrewerwilllockupandstopfunctioninguntiltheerroriscorrected.Anerrormessagewilloccurunderthefollowing

conditions:

1.Waterlevelllerrororoverow.Thiserrormessageoccurswhentheinletvalvesolenoidhasbeenonformore

than10minutes.Thiserrormessagealsooccurswhenthevalveisrellingthetankduringabrewcycleformore

than1½minutes.

2.Watertemperaturecontrolsystemerror.Anopenprobeorabreakinthetemperaturecontrolcircuitisdetected.

This error message indicates there is an overheating problem. The sensor is reading that temperature in the heat-

ingtankhasrisenabove210ºF.

3.Usuallythescreenwilldisplayaservicecallphonenumber.Onceamalfunctioniscorrected,theerrormessage

mustbecleared.Toresetthecontrolpanelandreturntonormaloperation,pressthe button for 5 seconds.

14A

29A

14B

12A

Illustrated Parts

2

2A

3

4

4A

4B

7

8

9

12A

14A

15A

21A

WC-58117

WC-889*

WC-860

WC-2977-101K*

WC-37184*

WC-390162

WC-37418

WC-3417

WC-3398*

WC-61709*

WC-4538

WC-1809

WC-43134

WC-29025*

WC-66079

WC-8556*

WC-6193-0

WC-37255

WC-61716-101

WC-61717-101

WC-102*

WC-103

WC-3518*

WC-5853-102

WC-43062*

WC-6277

WC-6290-101

COVER,TOPBREWER

VALVE,DUMPLEFT120V12W

VALVE,DUMPLEFT220V12W(EXPORTONLY)

KIT,FITTINGSPRAYHEADPLASTIC

KIT,LABEL&UCMCBSCURTIS

LABEL,UCMOVERLAYCBP/CBSCURTISLOGO

KIT,UCM&LABELCBS/CBP220V(EXPORT)

BREWCONE,ASSYW/SPLASHPOCKETBROWNCOFFEE

BREWCONE,ASSYSTDTEANON-METALW/BLUGUARD

SHELF,SSCBS

SCREW,SHOULDER8-32X.25x3/16LGTHRDS.S.

FAUCET,HOTWATER

O’RING,.426X9/16O.DX.070WALLEDPMTCTS

SPRAYHEAD,PURPLEADVANCEFLOW

SPOUTASSY,DILUTIONPLASTIC

HEATSINKASSYDV

TRIAC,40A600V

KIT,DUALVALVEWATERINLET

COVER,FRONTTOPCBS

COVER,FRONTBOTTOMNOSWITCHHOLE

SWITCH,TOGGLENON-LITSPST15A125VacRESISTIVE

SWITCH,TOGGLEDPST25A125/250VACRSTV(EXPORT)

LEG,GLIDE3/8”-16STUDSCREW

COVER,TOPHEATINGTANKGENUSE

GASKET,TANKLID

TANKASSY,COMPLETETEABREWER

TANK,COMPLETEW/WC-934-01ELMNT(EXPORTONLY)

DESCRIPTIONPART№ITEM№

23A

26A

29A

36A

36B

36C

WC-5527K*

WC-904-04*

WC-934-04

WC-4394

WC-1438-101*

WC-523*

WC-522

WC-5231*

WC-5310*

WC-895-105

WC-878-102

WC-8531

WC-3503*

WC-85008

WC-39550

WC-3528

WC-3763*

TCO308A000

TCO417A000

TCO419A000

TCO421A000

WC-5683

WC-38471

WC-1803

WC-3707*

WC-1805*

WC-37260*

KIT,PROBEWATERLEVELO-RING&NUT

ELEMENT,HEATING1.6KW120VW/JAMNUTS

KIT,HEATINGELEMENT2.5KW220V(EXPORTONLY)

SHOCKGUARD,HEATINGELEMENT

SENSOR,TEMPERATURETANK

THERMOSTAT,MANUALRESET120/220V25A220ºFMAX

THERMOSTAT,HILIMITDPST277V40A(EXPORTONLY)

COMPOUNDSILICONE5OZ

TUBING,5/16”IDX1/8”WSILICONE

VALVE,INLETDUAL120V10W2GPMX.5GPM

VALVE,INLETDUAL220V1.0GPM5GPMDLTN(EXPORT)

RAIL,BASETCTD

LEG,3/8”-16STUDSCREWBUMPER

SUPPORT,DECKEXTENDEDSS(CBPONLY)

LABEL,BOTTOMCPB

LEG,4”ADJUST3/8-16THRDITAL-STYLE(CBPONLY)

KIT,VALVEREPAIRUSEONWC-889(NOTSHOWN)

TEACONTAINEROVAL3GAL8½”(INCLDW/PTTBRWR)

TEACONTAINEROVAL4GAL17”(SOLDSEPARATELY)

TEACONTAINEROVAL4GAL19”(SOLDSEPARATELY)

TEACONTAINEROVAL4GAL21”(SOLDSEPARATELY)

LIDASSY,TCO

LABEL,FRONTTCOICEDTEAGENERIC

FAUCET,SPB

KIT,REPAIRSPBFAUCET

SEATCUP,FAUCETS’

KIT,FAUCETW/ADAPTERCOMPLETE

*Recommendedpartstostock

DESCRIPTIONPART№ITEM№

Parts List

Illustrated Parts List

TCOTeaServer

2

3

4

7

8

9

WC-56052

WC-38471

WC-1803

WC-37260

WC-3707

WC-1805

WC-38163

WC-5686

WC-3531

WC-3289

LID,BREWTHROUGHASSY

LABEL,FRONTTCNGENERIC

FAUCET,SPB

KIT,FAUCETW/ADAPTERCMPLT

KIT,REPAIRSPBFAUCET

SEATCUP,FAUCETS’

LABEL,CURTISSWPCLR/WHT

DRIPTRAY,OCTAGONSTYLE

LEG,PLASTICGLIDETCN

HANDLE,GASKET

DESCRIPTIONPART№ITEM№

Illustrated Parts List

TCNTeaServer

Tea Tips

1. Storeteabagsinadark,coolanddryplaceawayfromstrongodorsandmoisture.Donotrefrigerate.

2. Neverholdnishedbrewedteaformorethaneighthoursatroomtemperature.Discardanyunusedteaaftereighthours

3. Brewonlyenoughteathatyoureasonablyexpecttosellwithinafewhours.

4. Toprotectteaavorandtoavoidbacterialcontaminationandgrowth,cleanandsanitizeteabrewing,storageanddispensingequipmentatleast

once a day.

WARNINGDONOTrefrigerateunusedteaovernightforlaterconsumption.

Electrical Schematic

Cleaning the Brewer

Regularcleaningandpreventivemaintenanceisessentialtokeepyourcoffeebrewerlookingandworkinglikenew.

CAUTION –Donotusecleansers,bleachliquids,powdersoranyothersubstancecontainingchlorine.Theseproductspromotecorro-

sionandwillpitthestainlesssteel.USEOFTHESEPRODUCTSWILLVOIDTHEWARRANTY.

1. Wipeexteriorsurfaceswithamoistcloth,removingspillsanddebris.

2. Slidethebrewconeoutandcleanit.Cleanthesprayheadareawithamoistcleancloth.

3. Rinseanddrythebrewcone.

4. Rubastainlesssteelpolishontheoutsidesurfacestoprotectthebrewer.

Cleaning the Tea Containers

1.Washtheteacontainerandtopcover.Useadetergentsolutionandasoftbristledbrushtocleaninsidethecontainer.Wipetheexterior

surfaceswithaspongeanddetergentsolution.Rinsethoroughly.

2.Cleanthefaucetassembly.Unscrewthehandleassemblyfromthefaucetandremove.Cleanthefaucetshankwithagageglassbrush

(circularbristle)bypushingthebrushthroughtheshank.Usingthesamebrushcleanthefaucetbodyinletandoutlet.Cleanthefaucet

cap and silicone seat cup.

3.Afterthecleaning,placetheparts(sprayhead,brewconeandbasketandfaucetparts)rinsethepartsinhotwatertoremovetracesof

detergent.

Rough-In Drawing

To Sanitize the Disassembled Parts:

Wear rubber gloves for protection.

1.Placethecleanedpartsintoasink.

2. ImmersethemincommercialBarTabs/Sani-TabssanitizingsolutionThesolutionmustbewarm(75°F.)Allowthepartssoakinthesanitizerforat

least one minute.

3. Removethepartsfromthesanitizerandairdry.

4.Aftercleaning,sanitizinganddrying,assemblethepartstakenfromtheteacontainer.

Cleaning Airpots:

1. Inacontainer,mixamilddetergentsolutionforcleaningyourairpots.

2. Discardanyoldcoffeefromtheairpot.

2. Wipetheexteriorsurfaceswithaspongemoistenedwiththedetergentsolution,removingwater

spots and coffee.

3. Removeandcleanthesyphontube/funnelwithadetergentsolution.

3. Cleaninsidetheairpotswithaspongebrushsoakedindetergentsolution.

4. Aneasywaytocleanremovemineraldepositsfromthebrewconeandairpot,istousecoffee

equipmentcleaningtablets.

 a.Placeatabletintothebrewcone.

 b.Placetheairpotontothebrewdeckandopenthelid.

 c.StartacoffeebrewcyclebypressingtheBrewbuttononthecontrolpanel.

 d.Oncethebrewcyclehasnished,allowthecleaningsolutiontositintheairpotfora 

minute.Discardtheusedcleanerfromtheairpot.

 e.Rinsetheairpotandbrewconewithrunningwater.Boththebrewconeandairpotshouldbe

clean and ready to use.

Airpot Precautions:

 Donotimmerseairpotsinwater.

 Donotplaceindishwasher.

 Donotuseharshpowdersorcleanserscontainingchlorine.

 Donotuseawirebrushorpotscourtocleaninsideliner.

Liquid Level Probe

Cleaningintervalsfortheprobearetobedeterminedbytheuserortheservicetech,basedonwaterconditions.Theuseofwaterlters,orthetype

ofwaterlterthatisbeingusedcanimpacttheserviceinterval.Intervalscanbefromonemonthtoseveralyears,however,replacingratherthan

cleaning the probe is preferable.

WARNING:Electricshockhazard.Disconnectelectricalpowerbeforeremovingaccesspanels.

CAUTION: ScaldingandBurnhazard.Hotwaterandhotsurfaces.Allowunittocoolbeforeworking.

1. Unplugthepowercordandshutoffthewaterline.

2. Removethetopcoveroftheteabrewer.Locatetheheatingtankandremovethetopcover.

3. Drainthetanktoalevelabout3”belowthetipoftheprobe.

4. Allowsometimefortheheatingtankandliquidlevelprobetocooldownbeforeproceeding.

5. CleanthetipoftheprobeusingaScotch-Brite

™

scuff pad.

6. Ifawhiteresidueisstillvisibleontheprobe,removetheprobeandsoakitinvinegarorascaleremoving

chemical. Repeat this step until the probe is clean.

EDR9267.1/9/15@8º.revNC

FOR THE LATEST SPECIFICATION INFORMATION GO TO WWW.WILBURCURTIS.COM

Printed in U.S.A. 1/2015 F-4011 Rev NC

WILBUR CURTIS CO., INC.

6913 Acco St., Montebello, CA 90640-5403 USA

Phone: 800/421-6150 Fax: 323-837-2410

Technical Support Phone: 800/995-0417 (M-F 5:30A - 4:00P PST) E-Mail: [email protected]

Web Site: www.wilburcurtis.com

ProductWarrantyInformation

TheWilburCurtisCo.,Inc.certiesthatitsproductsarefreefromdefectsinmaterialandworkmanshipundernormaluse.Thefollowinglimitedwar-

rantiesandconditionsapply:

3 Years,PartsandLabor,fromOriginalDateofPurchaseondigitalcontrolboards.

2 Years,Parts,fromOriginalDateofPurchaseonallotherelectricalcomponents,ttingsandtubing.

1 Year,Labor,fromOriginalDateofPurchaseonallelectricalcomponents,ttingsandtubing.

Additionally,theWilburCurtisCo.,Inc.warrantsitsGrindingBurrsforForty(40)monthsfromdateofpurchaseor40,000poundsofcoffee,whichever

comesrst.StainlessSteelcomponentsarewarrantedfortwo(2)yearsfromdateofpurchaseagainstleakingorpittingandreplacementpartsarewar-

rantedforninety(90)daysfromdateofpurchaseorfortheremainderofthelimitedwarrantyperiodoftheequipmentinwhichthecomponentisinstalled.

Allin-warrantyservicecallsmusthavepriorauthorization.ForAuthorization,calltheTechnicalSupportDepartmentat1-800-995-0417.Effectivedate

ofthispolicyisApril1,2003.

Additionalconditionsmayapply.Gotowww.wilburcurtis.comtoviewthefullproductwarrantyinformation.

CONDITIONS & EXCEPTIONS

Thewarrantycoversoriginalequipmentattimeofpurchaseonly.TheWilburCurtisCo.,Inc.,assumesnoresponsibilityforsubstitutereplacementparts

installedonCurtisequipmentthathavenotbeenpurchasedfromWilburCurtisCo.,Inc.TheWilburCurtisCo.,Inc.willnotacceptanyresponsibilityif

thefollowingconditionsarenotmet.Thewarrantydoesnotcoverandisvoidunderthefollowingcircumstances:

1) Improper operation of equipment: The equipment must be used for its designed and intended purpose and function.

2) Improper installation of equipment: This equipment must be installed by a professional technician and must comply with all local electrical,

mechanical and plumbing codes.

3) Improper voltage: Equipment must be installed at the voltage stated on the serial plate supplied with this equipment.

4) Improper water supply: This includes, but is not limited to, excessive or low water pressure, and inadequate or uctuating water ow rate.

5) Adjustments and cleaning: The resetting of safety thermostats and circuit breakers, programming and temperature adjustments are the respon-

sibility of the equipment owner. The owner is responsible for proper cleaning and regular maintenance of this equipment.

6) Damaged in transit: Equipment damaged in transit is the responsibility of the freight company and a claim should be made with the carrier.

7) Abuse or neglect (including failure to periodically clean or remove lime accumulations): Manufacturer is not responsible for variation in

equipment operation due to excessive lime or local water conditions. The equipment must be maintained according to the manufacturer’s recom-

mendations.

8) Replacement of items subject to normal use and wear: This shall include, but is not limited to, light bulbs, shear disks, “0” rings, gaskets,

silicone tube, canister assemblies, whipper chambers and plates, mixing bowls, agitation assemblies and whipper propellers.

9) Repairs and/or Replacements are subject to our decision that the workmanship or parts were faulty and the defects showed up under normal

use. All labor shall be performed during regular working hours. Overtime charges are the responsibility of the owner. Charges incurred by delays,

waiting time, or operating restrictions that hinder the service technician’s ability to perform service is the responsibility of the owner of the equipment.

This includes institutional and correctional facilities. The Wilbur Curtis Co., Inc. will allow up to 100 miles, round trip, per in-warranty service call.

RETURN MERCHANDISE AUTHORIZATION:AllclaimsunderthiswarrantymustbesubmittedtotheWilburCurtisCo.,Inc.TechnicalSupport

Departmentpriortoperforminganyrepairworkorreturnofthisequipmenttothefactory.Allreturnedequipmentmustberepackagedproperlyinthe

originalcarton.Nounitswillbeacceptediftheyaredamagedintransitduetoimproperpackaging.NO UNITS OR PARTS WILL BE ACCEPTED

WITHOUT A RETURN MERCHANDISE AUTHORIZATION (RMA). RMA NUMBER MUST BE MARKED ON THE CARTON OR SHIPPING LA-

BEL. Allin-warrantyservicecallsmustbeperformedbyanauthorizedserviceagent.CalltheWilburCurtisTechnicalSupportDepartmenttondan

agent near you.