Invacare IH6300 Owner's Operator And Maintenance Manual

Brand: Invacare

Model: IH6300

Type: Owner's Operator And Maintenance Manual

This manual is also suitable for

IH6300ADH

Owner’s Operation and Maintenance Manual

DEALER: This manual MUST be given to

the user of the tub.

USER:

BEFORE using this tub, read this

manual and save for future reference.

For more information regarding

Invacare products, parts, and services,

please visit www.invacare-ccg.com

Supine Bath Tub

IH6300 Fixed Height

IH6300ADH Adjustable Height

AFTER INSTALLATION, PLEASE CALL CUSTOMER SERVICE AT

1-800-668-2337 TO ARRANGE FOR AN IN-SERVICE ON THE TUB

Supine Bath Tub 2 Part No 1096926

 WARNING

DO NOT USE THIS PRODUCT OR ANY AVAILABLE OPTIONAL EQUIPMENT

WITHOUT FIRST COMPLETELY READING AND UNDERSTANDING THESE

INSTRUCTIONS AND ANY ADDITIONAL INSTRUCTIONAL MATERIAL SUCH

AS OWNER’S MANUALS, SERVICE MANUALS OR INSTRUCTION SHEETS

SUPPLIED WITH THIS PRODUCT OR OPTIONAL EQUIPMENT. IF YOU ARE

UNABLE TO UNDERSTAND THE WARNINGS, CAUTIONS OR

INSTRUCTIONS, CONTACT A HEALTHCARE PROFESSIONAL, DEALER OR

TECHNICAL PERSONNEL BEFORE ATTEMPTING TO USE THIS EQUIPMENT -

OTHERWISE, INJURY OR DAMAGE MAY OCCUR.

THE INITIAL SET UP OF THIS TUB MUST BE PERFORMED BY A QUALIFIED

TECHNICIAN.

PROCEDURES OTHER THAN THOSE DESCRIBED IN THIS MANUAL MUST BE

PERFORMED BY A QUALIFIED TECHNICIAN.

 ACCESSORIES WARNING

Invacare products are specifically designed and manufactured for use in conjunction

with Invacare accessories. Accessories designed by other manufacturers have not

been tested by Invacare and are not recommended for use with Invacare products.

Forfurtherinformationonthisproduct,pleasecallthefollowing:

CustomerService‐1‐800‐668‐2337

TechnicalSupport‐1‐800‐668‐2337

TABLE OF CONTENTS

Part No 1096926 3 Supine Bath Tub

TABLE OF CONTENTS

SPECIAL NOTES ................................................................................ 5

LABEL LOCATION ............................................................................ 6

TYPICAL PRODUCT PARAMETERS .................................................... 7

FEATURES ........................................................................................ 8

SECTION 1—GENERAL GUIDELINES ................................................... 9

Installation ....................................................................................................................................................9

Electrical .......................................................................................................................................................9

Grounding Instructions.........................................................................................................................9

Plumbing........................................................................................................................................................9

Maintenance and Inspection...................................................................................................................10

Electrical Shock Hazard......................................................................................................................10

Disinfecting.................................................................................................................................................10

Operation...................................................................................................................................................10

SECTION 2—DISINFECTING THE TUB .............................................. 12

Disinfecting the Tub Using the Closed Loop System.......................................................................12

SECTION 3—OPERATION ................................................................ 13

Overview....................................................................................................................................................13

Preparing the Tub for Use......................................................................................................................13

Operating the Tub....................................................................................................................................14

Using Water Temperature Setting ..................................................................................................14

Operating Shower/Massage Wand ..................................................................................................15

Filling the Tub .......................................................................................................................................15

Using Hydromassage ...........................................................................................................................15

Adjusting Tub Height - Model IH6300ADH ONLY.........................................................................16

Raising the Supine Tub........................................................................................................................16

Lowering the Supine Tub ...................................................................................................................16

SECTION 4—INSTALLATION ........................................................... 17

Preparing the Work Area.......................................................................................................................17

Securing the Tub.......................................................................................................................................18

Electrical Hook-up....................................................................................................................................19

Electrical Installation ................................................................................................................................21

Plumbing Hook-Up...................................................................................................................................22

Plumbing Installation ................................................................................................................................23

TABLE OF CONTENTS

Supine Bath Tub 4 Part No 1096926

TABLE OF CONTENTS

SECTION 5—MAINTENANCE ........................................................... 25

Parts Information......................................................................................................................................25

Safety Inspection Checklists...................................................................................................................25

Initially.....................................................................................................................................................25

Before Each Use...................................................................................................................................25

Every 80-150 Baths..............................................................................................................................25

Every Six Months..................................................................................................................................26

Maintenance for IH6300ADH Adjustable Height ONLY Glide Pads...........................................26

Removing Soap Film and Hard Water Deposits ...............................................................................26

Removing Calcium Deposits, Scale and Lime Build-up....................................................................26

Heavy Duty Cleaning Procedure ..........................................................................................................27

Calibrating the Disinfectant Flowmeter ..............................................................................................28

Maintenance Record ................................................................................................................................30

SECTION 6—TROUBLESHOOTING .................................................... 31

LIMITED WARRANTY ..................................................................... 32

SPECIAL NOTES

Part No 1096926 5 Supine Bath Tub

SPECIAL NOTES

Signalwordsareusedinthismanualandapplytohazardsorunsafepracticeswhich

couldresultinpersonalinjuryorpropertydamage.Refertothetablebelowfor

definitionsofthesignalwords.

NOTICE

THE INFORMATION CONTAINED IN THIS DOCUMENT IS SUBJECT TO

CHANGE WITHOUT NOTICE.

RADIO FREQUENCY INTERFERENCE

Most electronic equipment is influenced by Radio Frequency Interference (RFI).

CAUTION should be exercised with regard to the use of portable communication

equipment in the area around such equipment. If RFI causes erratic behavior, PUSH

the Red Power Switch OFF IMMEDIATELY. DO NOT turn the Power Switch ON

while transmission is in progress.

MAINTENANCE

Maintenance MUST be performed ONLY by qualified personnel.

Information on maintenance and adjustment of the thermoscopic mixing valve

(RADA) is in the RADA Owner’s Manual which is included with this product.

SIGNAL WORD MEANING

DANGER

Danger indicates an imminently hazardous situation which, if not avoided, will result in

death or serious injury.

WARNING

Warning indicates a potentially hazardous situation which, if not avoided, could result in

death or serious injury.

CAUTION

Caution indicates a potentially hazardous situation which, if not avoided, may result in

property damage or minor injury or both.

LABEL LOCATION

Supine Bath Tub 6 Part No 1096926

LABEL LOCATION

WARNING

ELECTRICAL SHOCK HAZARD. All

disassembly and maintenance of the Supine

Tub MUST be done by a qualified technician,

certified electrician or plumber. Disconnect

electrical supply or turn OFF circuit breaker

before performing any maintenance to the

Supine Tub.

1097132 Rev.A(1) - 02/00

DANGER

ELECTRICAL SHOCK HAZARD. For use with hospital

grade GFCI receptacle ONLY. Failure to do so may

result in an electrical shock and/or serious or fatal

injury. DO NOT remove this label.

1097131 Rev.A(1) - 02/00

! DANGER

The National Electrical Code requires

the use of a ground fault circuit

interrupter on all therapeutic pools

and tubs (hydro-therapeutic tanks).

Failure to follow this requirement

could result in serious or fatal injury.

1095610 Rev.A(1) - 02/00

CAUTION

Some state and local plumbing codes require the

installation of a “reduced pressure zone” (RPZ) assembly

on both the incoming hot and cold supply lines to prevent

back flow contamination into the potable water system.

Invacare recommends you check local plumbing code

requirements to determine if RPZs are required on your

tub installation. RPZs are NOT supplied by Invacare and

are to be provided by the customer if required.

P/N 1150759 Rev A

! WARNING

BEFORE using the

Supine Tub READ and

UNDERSTAND the

Owner's Manual for

proper operation and

safety procedures

Read and understand ALL

information on Invacare

disinfectant BEFORE use.

Refer to Owner's Manual

for proper disinfecting

procedures.

1095523 Rev.A(1) - 02/00

! WARNING

For disinfecting use ONLY. DO NOT use

for showering. Refer to Owner's Manual

for proper disinfecting procedures.

1095526 Rev.A(1) - 02/00

! WARNING

DO NOT stand in tub. Tub surfaces are

slippery when wet. Serious injury may occur.

1097288 Rev.A(1) - 02/00

! WARNING

DO NOT STAND ON TUB FRAME.

Frame is slippery when wet. Foot injury possible

when adjusting tub height.

1095525 Rev.A(1) - 02/00

! WARNING

BEFORE immersing patient or operating the

shower/massage wand, check that the

water temperature is between 95˚ and 105˚

fahrenheit (35˚ and 41˚ C) to avoid scalding

the patient.

1095524 Rev.A(1) - 02/00

! WARNING

This dispensing system has been

factory tested and calibrated for use

with INVACARE Disinfectant. The use of

any disinfectant with a dilution ratio or

viscosity level different than that of

INVACARE Disinfectant will result in an

improper mixture of disinfectant and

water. This may cause your system to be

improperly disinfected - or in some

instances, not disinfected at all. If you

choose to use a product other than

INVACARE Disinfectant, Invacare will not

be responsible for the proper calibration

or function of your disinfectant system.

1095611 Rev.A(1) - 02/00

P/N 1150694 Rev A

DO NOT install a heater in the tub. Installing a heater

will violate safety codes and may result in scalding

injuries to the user.

! WARNING

P/N 1150694 Rev A

1095523

1095526

1097288

1095611

1095524

1095525

1097132

1095610

NOTE:ModelIH6300ADHONLY

1097131

1150759

1150694

Disinfectant

Cabinet

PAR9992









!

"#$%#&$"''()

#!#*&+##,

#%-

'./.0'12).3'1"4.(

(56('72

%,

8'1

(.(6(723

%8

#



&)1'7.00.3+./29:;9

%#



!

#%



%#<==9

#<

%+

#%

0()







>?0

'?

51

!/8.(

+(.@8&'

#

.



72;

TYPICAL PRODUCT PARAMETERS

Part No 1096926 7 Supine Bath Tub

TYPICAL PRODUCT PARAMETERS

IH6300

FIXED HEIGHT

IH6300ADH

ADJUSTABLE HEIGHT

Height

Tub Rim 32 inches (813 mm)

Raised N/A 41 inches (1041 mm)

Lowered N/A 27 inches (686 mm)

Overall Tub Height 56 inches (1422 mm)

Raised N/A 65 inches (1651 mm)

Lowered N/A 51 inches (1295 mm)

Width

Tub Exterior 38 inches (965 mm) 38 inches (965 mm)

Tub Interior at Shoulder 30 inches (762 mm) 30 inches (762 mm)

Tub Interior at Hip 25 inches (635 mm) 25 inches (635 mm)

Tub Interior at Foot 22 inches (559 mm) 22 inches (559 mm)

Length

Overall Tub Length 94 inches (2388 mm) 94 inches (2388 mm)

Tub Interior 69 inches (1753 mm) 69 inches (1753 mm)

Frame Base 49 inches (1245 mm) 49 inches (1245 mm)

Weight

Tub (shipping weight) 725 lbs (329 kg) 725 lbs (329 kg)

Tub (empty) 700 lbs (318 kg) 700 lbs (318 kg)

Tub w/ 103 gal of water

(max water capacity)

1575 lbs (714 kg) 1575 lbs (714 kg)

Floor Load Capacity

66 PSI (45 n/cm

) 66 PSI (45 n/cm

)

Water Capacity

Maximum 103 gal (390 l) 103 gal (390 l)

w/ Tub Occupied (average usage) 70-77 gal maximum

(265-292 l)

70-77 gal maximum

(265-292 l)

Water Fill Rate 24 gal per min (91 l/min) 24 gal per min (91 l/min)

Water Pressure 65 PSI maximum (448 kPa) 65 PSI maximum (448 kPa)

Water Drain Rate 25 gal per min (95 l/min) 25 gal per min (95 l/min)

Hydromassage System

Pump Motor 3/4 HP 3/4 HP

Flow Rate 70 gal per min (265 l/min) 70 gal per min (265 l/min)

Electrical

Classification Class I, Type B Class I, Type B

Ingress Protection IPX5 IPX5

Power 115 VAC; 50/60 Hz 115 VAC; 50/60 Hz

Current Rating 11 amp continuous, maximum 13 amp continuous, maximum

FEATURES

Supine Bath Tub 8 Part No 1096926

FEATURES

CONTROL PANEL

TUB INTERIOR

Model IH6300ADH

Adjustable Height Tub

Tub Fill

ON/OFF

Disinfectant

Flow Meter

Disinfectant Wand

Disinfectant

Cabinet

Water Temperature

Thermometer

Shower ON/OFF

Tub Fill Spout

Disinfectant

On/Off

Whirlpool

ON/OFF

Model IH6300

Fixed Height Tub

Tub Controls UP/Down

Whirlpool

Aerator

Whirlpool

Jets

Whirlpool

Inlet

Shower Massage Wand

Water Temperature

Control Valve

Overflow

Drain

NOTE:ModelIH6300ADHAdjustableHeightTubShown.

SECTION 1—GENERAL GUIDELINES

Part No 1096926 9 Supine Bath Tub

SECTION 1—GENERAL GUIDELINES

 WARNING

SECTION 1 - GENERAL GUIDELINES contains important information for the safe

operation and use of this product.

Checkallpartsforshippingdamagebeforeusing.Incaseofdamage,DONOTusethe

equipment.ContacttheICCGdealerforfurtherinstructions.

Installation

ICCGassumesnoresponsibilityforcodeinfractionsordamagetocomponentsdueto

improperinstallation.

Useextremecareduringinstallation.

TheinstallationareaMUSTbeabletosupportthe66poundspersquareinchload

capacityoftheSupineTub.

Afterinstallationandbeforeuseensureallpartsareproperlyandsecurelyinstalled.

Ensurebathroomfloorisdryandfreeofobstructionsbeforetransportingorassembling

unit.

BecertainALLelectricalworkisperformedbyaqualifiedelectricianandisincompliance

withlocalelectricalcodes.

Electrical

Grounding Instructions

ModelIH6300SupineTubMUSTbedirectwiredtowallusinghot,neutralandground

wiresinaccordancewiththeNationalElectricalCode.ExternalwiringMUSTbe

groundedthrougha15ampbreakerandGFCIreceptacle.

ModelIH6300ADHSupineTubMUSTbepluggedintoahospitalgradeGFCIreceptacle

witha

15AMPbreaker.

Plumbing

BecertainALLplumbingworkisperformedbyaqualifiedplumber.

Somestateandlocalplumbingcodesrequiretheinstallationofa“reducedpressurezone”

(RPZ)assemblyonboththeincominghotandcoldsupplylinestopreventbackflow

contaminationintothepotablewatersystem.Invacarerecommendsyouchecklocal

plumbingcoderequirementstodetermineifRPZsarerequiredonyourtubinstallation.

RPZsareNOTsuppliedbyInvacareandaretobeprovidedbythecustomerifrequired.

ThehotwatersupplytothetubMUSTNOTexceed110°F(43°C)toprotecttheuserfrom

scalding.

SECTION 1—GENERAL GUIDELINES

Supine Bath Tub 10 Part No 1096926

Whenoperatingwaterpressureexceeds55p.s.i.,pressureregulators(similartothe

¾‐inchWattsU5)MUSTbeinstalled.

Maintenance and Inspection

IfanypartofthesystemisNOTfunctioningproperly,DONOTusethesystem.Havethe

systemservicedtocorrecttheproblem.

ThesystemMUSTbemaintainedonaregularbasistoensureitisfunctioningproperly.

Electrical Shock Hazard

AlldisassemblyandmaintenanceofthetubMUSTbedonebyaqualifiedtechnician,

certifiedelectricianorplumber.DisconnectelectricalsupplyorturnOffcircuitbreaker

beforeperforminganymaintenancetothetub.

Disinfecting

DisinfectthetubafterinitialsetupandALWAYSdisinfectthetubAFTEReachuseto

avoidresidentinfectionandcontaminationofthetub.

DONOTdisinfectthetubwhenitisoccupiedotherwiseinjurymayoccur.

ALWAYSweargloves,protectiveapron,andfaceshieldprotectionwhendisinfectingor

cleaningyourtub.

ALWAYShandledisinfectants,cleaningcompounds,andpowderedsanitizerswith

extremecare.Physicalormechanicaldamagecausedbyimproperhandlingorusageof

suchproductswillnotbetheresponsibilityofICCG.

DONOTattempttoturnonwhirlpoolpumpduringthedisinfectantcycle.Doingso

couldresultinskinoreyecontactwiththedisinfectant,whichiscorrosive.Ifcontactis

made,rinseIMMEDIATELYwithwater .Ifirritationoccurs,consultaphysician.

ALWAYSreadandfollowdisinfectantlabeldirections carefully.

NEVERuseabrasivecleanerslikescouringpowderorliquidcleanerscontainingpumice

stone.Theuseofthesetypesofcleaners willmake

thegel‐coatfinishofyourtubscratched

anddull.NEVERusecleanerscontainingiodine,bromine,Betadine

ormethyleneblue.

Theuseofthesetypesofcleanerswillcausethetubtostain.Neverusecleanerscontaining

bleach.Useofthesetypesofcleanerswilldryouttherubbersealsandgasketsandthetub

willnotfunctionproperly.

Operation

 DANGER

Keep hair and body away from suction guard when pump is running.

SECTION 1—GENERAL GUIDELINES

Part No 1096926 11 Supine Bath Tub

TheSupineTubisspecificallydesignedtobeusedwithabathlift.ICCGrecommendsuse

oftheTraverseLiftModel1200ONLY.Bathliftsdesignedbyothermanufacturersare

NOTtobeutilizedwiththeSupineTub.Useoftheseproductsisprohibitedandwillvoid

ICCG’sSupineTubwarranty.UseONLYTraverseLiftModel1200tomaintainresident

safetyandproductutility.Refertotheliftowner’smanualforcompletelifeoperatingand

safetyinstructions.

NEVERoperatewhirlpoolwithoutwaterlevelabovethewhirlpooljets.Severepump

damagewillresult.

DONOToperatethisunitwithouttheguardoverthe(waterintake)suctionfitting.The

guardisasafetydevicethatreducesthepotentialhazardofhairorbodyentrapment.

Toreducetheriskofinjury,DONOTpermitchildrenorinfirmpersonstousethisunit

unlesstheyaresupervisedatalltimes.

Recommendedlengthofabathis5to10minutes.However,ifyoubecomenauseousor

dizzyordevelopaheadache,getoutatonceandcooldown.Getmedicalattentionif

symptomspersist.Also,checkwithaphysicianbeforeusingthisunitagain.

Anyoneunderadoctorʹssupervision,pregnant,orwithpoorhealth,shouldcheckwitha

physicianbeforeusingthisunit.

DONOTusedirectlyaftereatingorwhileundertheinfluenceofalcoholordrugs.

SECTION 2—DISINFECTING THE TUB

Supine Bath Tub 12 Part No 1096926

SECTION 2—DISINFECTING THE TUB

 WARNING

Disinfect the tub after EACH use to avoid resident infection and contamination of the tub.

DO NOT disinfect the tub when it is occupied otherwise injury may occur.

Read and understand all information on Invacare brand disinfectant before use.

ALWAYS wear rubber gloves, an apron and a face shield when using disinfectant. In case of eye or skin

contact, follow procedures on disinfectant container.

The disinfectant dispensing system has been factory tested and calibrated for use with Invacare disinfectant.

The use of any disinfectant with a dilution ratio (½ oz. per gallon) or viscosity level different than that of

Invacare disinfectant will result in an improper mixture of disinfectant and water. This may cause your system

to be improperly disinfected - or in some instances, not disinfected at all. If using any disinfectant with a dilution

ratio or viscosity level different than that of Invacare disinfectant or if switching from one type of disinfectant to

another type, the disinfectant flowmeter MUST be calibrated before performing this procedure. Refer to

Calibrating the Disinfectant Flowmeter

on page 28.

DO NOT use the disinfectant wand for showering. The disinfectant wand is to be used for disinfecting ONLY.

CAUTION

NEVER use abrasive cleaners like scouring powder or liquid cleaners containing pumice stone. The use of

these types of cleaners will make the gel-coat finish of your tub scratched and dull. NEVER use cleaners

containing iodine, bromine, Betadine or methylene blue. The use of these types of cleaners will cause the

tub to stain. Never use cleaners containing bleach. Use of these types of cleaners will dry out the rubber

seals and gaskets and the tub will not function properly.

Disinfecting the Tub Using the Closed Loop System

NOTE:Forthisprocedure,refertoFIGURE 2.1.

NOTE:Ensurethatthewhirlpooljetsandwhirlpool inletfittingareclosedbeforestartingthisproc edure.

1. Cleantheentiretubsurfacetoremov evisibletissueresidueandfluid.

2. Dependingonthetypeofwhirlpooljetsthatareinyourtub,clo seallje tsbyperforming

oneofthe following:

•Turnthecenterofthejetclockwisetoafullstop.

•Pushthecenterofthejetin.

3. Closethewhirlpoolinletbyge ntly pullingthepluginthecenteroftheinletcoveroutw arduntilitstops.

4. Openaerato rbyrotatingaeratorknobtw oturnscounte r ‐clockwise.

5. Open

disinfectantcabinetonthetopofthetub.

6. Ensurethat disinfectantsiphontubeisplacedin

disinfectantcontainer.

7. Holdthedisinfectantwandovertheinteriorofthetub.

8. Adjustwatertemperatureto105°F(40°C).

9. Turndisi nfecta ntOn/OffvalvetotheOnposition.

NOTE:Liquid willbeginflowingfromthedisinfectantwandinto

the

tub.

10. Turntheadjustmentknobontheflowmeteruntilthe

floatingballrisestoalevelof35cc/min.

NOTE:At35cc/min.,disinfectantisbeingmixedwithwaterat

thepr operratio.

11. Continuetoholdthedisinfectantwandoverthe

interiorofthetub.

NOTE:Whendisinfectanthastotallyfilledtheinteriorplumbing,

liquidwillbegintoflowfro mthedisinfectantwand.

NOTE:Invacarerecommendsthatyouthor oughlyscruball

interiorsurfacesofthetubwithdisinfectant.Theuseofalo ng‐

handledbrushwillmakethisoperationeasier.

12. Spraytheinteriorsurfacesofthetub,includingthe

whirlpooljets,ov erflowfitting

andwhirlpoolinlet

fittingwithdisinfectant.Scruballinteri orsurfaces.

13. TurnthedisinfectantOn/OffvalvetotheOffposit ion.

14. Returndisinfectantwandtoits holder.

15. Afterscrubbingtheinterior surfaces,leavethe

disinfectantintheloopandonthetubsurfacesforten

minutes.

16. Usetheshower/massagewandonthepulsesetting

and

directthesprayintobothwhirlpooljetstobackflush

untilthewaterdisc hargingfromthewhirlpoolinletis

clear.

17. Rinseallinteriortubsurfaces.

18. ReverseSTEPS2and3toope nthewhirlpooljetsand

whirlpoolinlet.

FIGURE 2.1 Disinfecting the Tub Using the Closed Loop

System

Whirlpool Jets

Disinfectant

Wand

Overflow

Disinfectant

Siphon Tube

Whirlpool Inlet

Disinfectant Cabinet

Disinfectant

On/Off Valve

DETAIL “B” -

TUB DETAILS

Push In To

Whirlpool Inlet

Plug

Ball

Turn Clockwise

to Close

Whirlpool Jet

DETAIL “A” -

WHIRLPOOL JET

AND INLET DETAILS

Flow meter

Adjustment Knob

SECTION 3—OPERATION

Part No 1096926 13 Supine Bath Tub

SECTION 3—OPERATION

Overview

Thetu bisdesignedtoimprovetheefficiencyandenvironmentalsafetyof yourfacilityʹs

operation.Howev er,if thetubisnotoperated ormaintainedproperly,thebenefitsdesigned

intothesystemwillnotberealized.Thepurpose ofthismanualis toprovideyouwith

recommendedprocedurestohelpyouobtainthemaximumefficiencyandsafetywhileusing

yourtub.

Whenusingthetub,performtheseproceduresinthefollowingorder:

1. Preparingthetubforuse

2. Transferringtheresidentintothetub

3. Bathing

4. Transferringtheresidentfromthetub

Preparing the Tub for Use

NOTE:Forthispr ocedur e,refertoFIGURE 3.1.

NOTE:Makesurethatyour tubhasbeen

disinfectedbefor epreparingthetubforuse.

NOTE:Thisprocedur emustbeperformedafter

disinfectingthetubtofinalizethedisinfecting

process.

1. Openthewhirlpoolinletbypushingthe

inletplu ginthecenteroftheinletcover

inuntilitstops.

2. Openallwhirlpooljetsbyperforming

oneofthefollowing:

•Turnthecenterjetcounter‐clockwise

toafullstop.

•Pullthecenterof thejetout.

3. Usingshower/massagewandon

Pulsesetting,directwatersprayintothe

whirlpooljetstoback‐flushthesystem

untilwatercoming

fromthewhirlpool

inletis clear.RefertoOperatingShow er/

MassageWandonpage 15.

4. Rinseallinteriortubsurfaceswith

shower/massagewandonSpraysetting.

5. V isuallyinspecttubfordamageandto

ensurethatalltubsurfacesarecleanand

thatno visibledisin fect antresidue

remains.

FIGURE 3.1 Preparing the Tub for Use

Whirlpool

Inlet

Shower/

Massage

Wand

Inlet

Plug

Whirlpool

Jet

Turn Counter-

Clockwise To Open

Pull Out

To Open

SECTION 3—OPERATION

Supine Bath Tub 14 Part No 1096926

Operating the Tub

 WARNING

DO NOT stand in tub. Tub surfaces are slippery when wet. Serious injury may

occur.

DO NOT stand on tub frame. Frame is slippery when wet.

BEFORE immersing the resident or operating the shower/massage wand, check

that the water temperature is between 95° F and 105° F (35° C and 41° C) to avoid

scalding the resident.

Disinfect the tub after EACH use to avoid resident contamination.

NOTE:Forthisprocedure,refertoFIGURE 3.2.

Using Water Temperature Setting

FlowWaterThermometer‐Measuresthetemperatureofwatercomingfromthetubfill

spoutorshower/massagewand.

WaterTemperatureControlValve‐Setsandmaintainsconstanttemperatureforall

incomingwater .

 WARNING

ALWAYS hand test the incoming water temperature and the water temperature in

the tub BEFORE immersing the resident. Failure to do so may result in a scalding

injury.

FIGURE 3.2 Using Water Temperature Setting

Whirlpool

Aerator

Flow Water

Thermometer

Shower

ON/OFF

Tub Fill

ON/OFF

Flow Water

Thermometer

Shower

ON/OFF

Tub Fill

ON/OFF

Water Temperature

Control Valve

Whirlpool

On/Off

Tub

Control

Down

Tub

Control

Model IH6300

Model IH6300ADH

Whirlpool

On/Off

SECTION 3—OPERATION

Part No 1096926 15 Supine Bath Tub

Operating Shower/Massage Wand

NOTE:STEPS1‐3aretobeperformedwhileholdingtheshower/massagewandoverthetub.Referto

Featuresonpage 8foradditionalillustrations.

1. Turnshower/massagewandontodesiredflowbyrotatingknob.

2. Adjustwatertemperaturewhilewatchingthermometer.

3. Adjustshowerspraybyrotatingshowerwandhead.

NOTE:Refer tothefollowingchartforshowerheadadjustmentsettings.

4. TurnshowerOn/OffknobtoOffpositionwhenfinished.

Filling the Tub

1. Closethedrain.

2. TurntubfillOn/OffvalvetoOnpositionbyrotatingknob.

3. Adjustwatertemperaturewhilewatchingthermometer.

4. TurntubfillOn/OffvalvetoOffpositionwhenwaterreachesdesiredlev el.

NOTE:If hydr omassageuseisanticipated,waterlevelMUST becompletelyabovewhirlpooljets.

NOTE:Befor estartinghydr omassage,openthewhirlpoolinletandwhirlpoolje ts.

Using Hydromassage

CAUTION

Before starting hydromassage, water level MUST be completely above whirlpool jets

otherwise damage to the motor/pump will result.

1. Openthewhirlpoolin letbypushinginonthepluginthewhirlpoolinletfitting.

2. Openallwhirlpooljetsbyperformingoneofthefollowing:

•Turnthecenterofthejetcounter‐clockwisetoafullstop.

•Pullthecenterof thejetout.

3. AddInv acareDefoamertobathwater.Re ferto

De foamerbottlefordirections.

4. PushwhirlpoolOn/Offbuttontostartwhirlpooljets.

5. Adjustthewhirlpoolaeratorforde siredwateragitationbyrotatingtheknob.

6. Afteruse,pushwhirlpoolOn/Offbuttontostopwhirlpooljets.

7. Drainthetub.

Stream

Shower Spray

Mixture of Spray and Pulse Massage

Pulse Massage

SECTION 3—OPERATION

Supine Bath Tub 16 Part No 1096926

Adjusting Tub Height - Model IH6300ADH ONLY

 WARNING

DO NOT stand on tub frame. Frame is slippery when wet. Foot injury is possible

when adjusting tub height.

CAUTION

DO NOT adjust height more than three cycles (up and down) within a ten minute

period. Damage to the actuator may result.

NOTE:ThesupinetubstopsautomaticallywhenmaximumheightadjustmentUporDownis

reached.

Raising the Supine Tub

1. PressandholdtubcontrolUpbutton.

2. ReleasetubcontrolUpbuttonwhendesiredheightisreached.

Lowering the Supine Tub

1. PressandholdtubcontrolDownbutton.

2. ReleasetubcontrolDownbuttonwhendesiredheightisreached.

SECTION 4—INSTALLATION

Part No 1096926 17 Supine Bath Tub

SECTION 4—INSTALLATION

Preparing the Work Area

NOTE:Forthisprocedure,refertoFIGURE 4.1.

1. Determinelocationforthesupinebathtubinstallation.

NOTE:Followrecommendedfloorplanwheninstallingtub.

2. Carefullyremovethetubfromcarton.

3. Removetubfromshippingpalletbyremovingscrewsfromlegmountingpads.

4. ModelIH6300ONLY‐Removethescrewsthatsecuretherearaccesspaneltoaccess

thepumpelectricalconnections(Detail“A ” ofFIGURE 4.1).

FIGURE 4.1 Preparing the Work Area

3 ft

(914 mm)

Wall

94 inches (2388 mm)

38 in.

(965 mm)

142 inches (3606 mm)

Screw

(1 of 4)

Access

Panel

Leg Mounting Pads

DETAIL "A"

3 ft

(914 mm)

3 ft

(914 mm)

1 ft

(304 mm)

SECTION 4—INSTALLATION

Supine Bath Tub 18 Part No 1096926

Securing the Tub

NOTE:Forthisprocedure,refertoFIGURE 4.1onpage 17andFIGURE 4.2.

1. Setthetubinplace.

2. Marklocationofanchorholes,usingpre‐drilledholesinlegmountingpadsasa

template(Detail“A ” ofFIGURE 4.1).

3. Movetubawayfrommountingarea.

 WARNING

Protective eye wear MUST be worn when drilling to avoid possible eye injury.

4. Drillanchorholesinfloor.Useajack‐drillwithacarbidebitforconcretefloorsora

woodbitforwoodfloors.

5. Repositionthetubinmountingarea,aligningtheholesinthelegmountingpadswith

theholesdrilledinSTEP4.

 WARNING

DO NOT adjust height of legs more than 1 inch (25.4 mm); leg will disassemble

from leg mounting pad and serious injury may occur.

6. Levelthetubbyadjustingthetelescopiclegseitherupordown,usingawrench,to

achievethedesiredheight.

7. Checktomakesuretubislevelbyplacingalevelonthefrontandsidesofthetub

(Detail“A ” ofFIGURE 4.2).

8. RepeatSTEPS6and7untiltubislevel.

9. Securelegstofloorusingfastenersappropriateforthefloormaterialandinkeeping

withlocalcodes(Detail“B”ofFIGURE 4.2).

FIGURE 4.2 Securing the Tub

DETAIL “A” - LEVELING

Level

Leg

Leg Mounting

Pad

Anchor

1-inch (25.4 mm)

Maximum Adjustment

DETAIL “B” - SECURING TUB

Lag Bolt

Leveling

End to End

Leveling

Side to Side

Lag Bolt

Anchor

SECTION 4—INSTALLATION

Part No 1096926 19 Supine Bath Tub

Electrical Hook-up

 WARNING

Be certain ALL electrical work is performed by a qualified electrician and is in

compliance with local electrical codes.

Before installing and connecting the tub, make certain that the electric power

source is SHUT OFF to avoid electrical shock.

NOTE:Forthisprocedure,refertoFIGURE 4.3onpage 20.

NOTE:Forinstallationdetailsrefertoonpage 20.

1. Installtheelectricalhook‐upsperFIGURE 4.3.

SECTION 4—INSTALLATION

Supine Bath Tub 20 Part No 1096926

FIGURE 4.3 Electrical Hook-up

Electrical

Hookup

115 V

Electrical

IH6300 Fixed Height

Use 15 Amp GFCI Breaker Only

IH6300ADH Adjustable Height

Use 15 Amp Hospital Grade GFCI Receptacle Only

DETAIL “B” - ELECTRICAL HOOK UP DETAILS

DETAIL “A” - ELECTRICAL HOOK UP LOCATION

Wall

Tub Wall

Pump

Motor

BLACK

WHITE

GREEN

DETAIL “C” - ELECTRICAL SCHEMATIC

Air Switch Line

Motor

Cover

Ground (GREEN)

Line (BLACK)

Neutral (WHITE)

Ground

Line

Neutral

DETAIL “E” - MOTOR END PLATE

DETAIL “D” - MOTOR COVER

Page is loading ...

Invacare IH6300 Owner's Operator And Maintenance Manual

Brand: Invacare

Model: IH6300

Type: Owner's Operator And Maintenance Manual

This manual is also suitable for

IH6300ADH

Download PDF

report

Invacare IH6300 Owner's Operator And Maintenance Manual

This manual is also suitable for

Invacare IH6300 Owner's Operator And Maintenance Manual

Related papers

Other documents