Optimus HY-TM7B-WP User manual

Brand: Optimus

Model: HY-TM7B-WP

Category: AV equipment stands

Type: User manual

This manual is also suitable for

HY-TM7W-WP

1. SAFETY PRECAUTIONS

• Beforeinstallationoruse,besuretocarefullyread

all the instructions in this section for correct and

safeoperation.

• Besuretofollowalltheprecautionaryinstructions

in this section, which contain important warnings

and/orcautionsregardingsafety.

• After reading, keep this manual handy for future

reference.

Indicatesapotentiallyhazardoussituationwhich,

if mishandled, could result in death or serious

personalinjury.

WARNING

• Referallinstallationworktothedealerfromwhom

the speaker was purchased. Installation onto the

ceilingrequiresextensivetechnicalknowledgeand

experience.The speaker may falloff ifincorrectly

installed,resultinginpossiblepersonalinjury.

• Installtheunitonlyinalocationthatcanstructurally

supporttheweightofthespeakerandthemounting

bracket.Doingotherwisemayresultinthespeaker

falling down and causing personal injury and/or

propertydamage.

• Owing to the speaker's size and weight, be sure

thatatleasttwopersonsareavailabletoinstallthe

speaker. Failure todo so could result in personal

injury.

• Donotuseothermethodsthanspeciedtomount

thebracket.Extremeforceisappliedtothebracket

andthespeakercouldfalloff,possiblyresultingin

personalinjuries.

• Usesafetywireswheninstallingspeakers.Ifnot

used, personalinjurycouldresult if a speaker

shouldaccidentallyfall.

• Attachthesafetywiretothespeaker.Ifnotattached,

thespeakercouldfalloff,resultinginpersonalinjury.

• Use nuts and bolts that are appropriate for the

ceiling’sstructureandcomposition.Failuretodoso

maycausethespeakertofall,resultinginmaterial

damageandpossiblepersonalinjury.

• Tighten each nut and bolt securely. Ensure that

the bracket has no loose joints after installation

to prevent accidents that could result in personal

injury.

• UsetheHX-7B-WPorHX-7W-WPSpeakerSystem

in combination. Doing otherwise may cause the

speakertofalloff,resultinginpersonalinjury.

• Do not mount the speaker in locations exposed

to constant vibration. The rigging bracket can be

damagedbyexcessivevibration,potentiallycausing

the speakertofall, whichcouldresult in personal

injury.

• Avoidinstallingthespeakerinlocationsclosetothe

seashore or in indoor swimming facilities thatare

not well ventilated. In such locations, the bracket

maybevulnerabletocorrosion,eventuallyallowing

thespeakertofallresultinginpersonalinjury.

Indicatesapotentiallyhazardoussituationwhich,

ifmishandled,couldresultinmoderateorminor

personalinjury,and/orpropertydamage.

CAUTION

• Avoid touching the bracket's sharp metal edge to

preventinjury.

• Do not stand or sit on, nor hang down from the

bracketasthismaycausethespeakertofalldown

ordrop,resultinginpersonalinjuryand/orproperty

damage.

• Havethebracketcheckedperiodicallybytheshop

fromwhereitwaspurchased.Failuretodosomay

resultincorrosionordamagetothespeakerorits

riggingbracketthatcouldcausethespeakertofall,

possiblycausingpersonalinjury.

INSTALLATION MANUAL

SPEAkER RIGGING bRACkET HY-TM7b-WP

HY-TM7W-WP

ThankyouforpurchasingTOA’sSpeakerRiggingBracket.

Pleasecarefullyfollowtheinstructionsinthismanualtoensurelong,trouble-freeuseofyourequipment.

2. GENERAL DESCRIPTION

TheHY-TM7SeriesSpeakerRiggingBracketsareusedtohangtheHX-7B-WPorHX-7W-WPSpeakerSystem

directlyfromceilings,beamsorotherbuildingstructures,includingunderoutdooreaves.

3. NOTES ON INSTALLATION

• Observethefollowinginstructionswheninstallingthespeaker

system.

 Failuretodosocouldadverselyaffecttheirintendedweather-

resistantcapability,leadingtomalfunction.

· Installthespeakersysteminlocationsnotexposeddirectlyto

rain,suchasundereaves.

· Allspeakermodulesmustpointdownwardfromthehorizontal.

• TwojoinedHX-7 SeriesSpeaker Systems cannotbe installed

withthisbracket.

4. INSTALLATION

Step 1. Mountthisbrackettoaceiling,beam,etc.usingthebolts.

Boltsandnutsformountingthebracketontheceilingorbeamarenot

supplied.

Use bolts and nuts that are appropriate for the ceiling’s or beam’s

structureandcomposition.Failuretodosomaycausethespeakerto

fall,resultinginmaterialdamageandpossiblepersonalinjury.

WARNING

[Mounting dimensions]

(1.42")

146.5 (5.77")

[Front] [Right side]

ø8.5 (0.33") (with M8 weld nut)

ø8.5 (0.33")

(with M8 weld nut)

ø8.5 (0.33")

(with M8 weld nut)

ø8.5(0.33")

(6 positions)*

353 (13.9")

60 (2.36")

100 (3.94")100 (3.94")

(1.02")

(2.99")

126

(4.96")

291

(11.46")

220

(8.66")

170

(6.69")

φ8.5 (0.33")*

Note: Left-side surface same.

Unit: mm

*TheseholesnotttedwithM8weldnuts.

[Vertical installation]

Horizontal

Step 2. Mountthespeakersystemtothisbracket.

Mountthespeakersystemvertically,asshowninthegure.

Fixthespeakertothemountingbracketatall3indicatedplaces.

 2-1. Fixthisbrackettobothendsofthesideangleplateofthespeakerfront.

Usethesuppliedbolts(withspringandplainwashers)andspacers.

 2-2. Fixthisbrackettothespeaker’srearbracket.

Fixtotherearbracket’sendmosthole.

Usethesuppliedbolt(withspringandplainwashers),J-spacer,andangenut.

Fordetails,refertotheprocedures(1)to(3)asshownbelow.

• Use safety wires when installing speakers. If not used, personal

injurycouldresultifaspeakershouldaccidentallyfall.

• Owingto the speaker's size and weight, besure that at leasttwo

personsareavailabletoinstalltheunit.

 Failuretodosocouldresultinpersonalinjury.

• Tighten the bolts securely, as instructed below. Failure to follow

instructionspreciselycouldresultinafallingspeakerandpotential

personalinjury.

· Ensurethatallboltsaresecurelyinsertedasfarastheirthreadsgo,

thensecurelyfasteneachboltwithanut.

· Tighten all the bolts with the designated tightening torque. For

tightening,useaPhillipsscrewdriver,oropen-orbox-endwrench.

WARNING

This bracket

HX-7B-WP or HX-7W-WP

J-spacer

(accessory)

Rear bracket

(1) Lightly secure.

(3) Tighten firmly.

(2) Insert.

Flange nut

for M6 (accessory)

Hex head

bolt M6x30

(accessory)

Tightening

torque: 5 N·m

Spacer ø9.2 (0.36")

(accessory)

Hex head bolt

M6x12(accessory)

Side angle plate

Protection cover

Note

Remove the

protection covers

from the side

angle plates

before joining.

Tightening torque:

5 N·m

2-1

Note

Similarly, fix this bracket to the end of the

side angle plate on the opposite side.

2-2

This bracket

HX-7B-WP or HX-7W-WP

[Completed installation]

Step 3. Attachsafetywiresforprotectionagainstfalls.

Regardingtheattachingmethodofsafetywires,

refertotheoperatinginstructionssuppliedwith

HX-7Seriesspeakersystem.

Note

Aftertighteningthebolt,ensurethat

theJ-spacerisrmlyxed.

5. SPECIFICATIONS

ModelNo. HY-TM7B-WP HY-TM7W-WP

Finish Stainless steel, black, semi-gloss,

paint

Stainless steel, white, semi-gloss,

paint

Dimensions 433(w)x57(h)x295(d)mm(17.05"x2.24"x11.61")

Weight 2.5kg(5.51lb)

Note: Thedesignandspecicationsaresubjecttochangewithoutnoticeforimprovement.

• Accessories

HexheadboltM6x12withspringandplainwashers... 2

HexheadboltM6x30withspringandplainwashers... 1

FlangenutforM6........................................................... 1

Spacerø9.2(0.36")........................................................ 2

J-spacer.......................................................................... 1

URL:http://www.toa.jp/

133-01-00045-00

Optimus HY-TM7B-WP User manual

Brand: Optimus

Model: HY-TM7B-WP

Category: AV equipment stands

Type: User manual

This manual is also suitable for

HY-TM7W-WP

Download PDF

report

Optimus HY-TM7B-WP User manual

This manual is also suitable for

Optimus HY-TM7B-WP User manual

Related papers

Other documents